915 Universal Treadmill

OWNER'S MANUAL

IMPORTANT:

PLEASE READ ALL INSTRUCTIONS CAREFULLY BEFORE USING THIS PRODUCT. REVIEW AND FOLLOW ALL

REFERENCED SAFETY GUIDELINES. RETAIN ALL PRODUCT LITERATURE FOR FUTURE REFERENCE.

SAFETY CAUTION: PROPERLY WARM UP & STRETCH BEFORE EXERCISING. IF YOU FEEL PAIN OR DIZZINESS AT

ANY TIME WHILE EXERCISING, STOP IMMEDIATELY AND CONSULT YOUR PHYSICIAN.

Part No. 06031

Revision: A Date: 1/05

ASSEMBLY INSTRUCTIONS

STEP 1

Take the whole treadmill out of the box, and lay all parts flat on floor as shown in Figure 1.

Locate the hardware bag and parts that are listed in the chart below.

Figure 1

Part # Description QTY

A Main frame & computer 1

B Upright side cap 2

C Allen Bolt 6

D Washer 6

E Phillips Head Screw 6

F Allen Key 1

G Screwdriver 1

H Safety Key 1

1

ASSEMBLY INSTRUCTIONS

STEP 2

Lift the upright and carefully thread the Allen Bolts (C) and washers (D) inside holes at the bottom of the upright. Use the Allen Key (F) to tighten them down.

Figure 2

2

ASSEMBLY INSTRUCTIONS

STEP 3

Put the console to the correct position by holding and pushing both handlebars down.

Use the handgrips to pivot the console into position. (Caution: be careful not to pinch the computer wire)

Use the Allen Key (F) to securely tighten the Allen Bolts (C) with Washers (D).

Figure 3

3

ASSEMBLY INSTRUCTIONS

STEP 4

Place the upright side caps (B) to the correct position.

Use the screwdriver to tighten the Phillips Head Screws as shown in Figure 4.

Figure 4

4

FOLDING AND LOWERING THE TREADMILL

TO FOLD THE TREADMILL

After assembly is complete, you may fold the machine into the upright position for storage. To fold the machine, raise the deck and make sure the latch is in place by turning the knob as shown. (Figure 5)

WARNING: Make sure the treadmill's

elevation is at 0 before

folding the deck. If the

elevation is not at 0, it

will cause damage to the

machine.

Figure 5

TO LOWER THE TREADMILL

To lower the deck, pull and turn the knob on the latch until it releases the deck. (Figure 6)

** This machine has a built-in soft-

lowering system to help the deck

lower slowly.

WARNING: Please make sure there

are no children or other

things under the deck

when you lower it.

Figure 6

5

MOVING THE TREADMILL

TO MOVE THE TREADMILL

Fold the treadmill to the upright position and make sure to engage the safety latch as shown in Figure 5. Use the handgrips to maneuver your treadmill on its transport wheels.

Caution: treadmills are heavy pieces of equipment and require extreme care during transportation.

6

CAUTION

The machine will shut off when the electricity load is above the machine's capacity.

To restart the machine, please follow the procedure below:

A. Unplug the power cord from the machine's socket.

B. Push in the safety switch.

C. Replug the power cord into the machine's socket.

** DO NOT PUSH IN THE SAFETY SWITCH BEFORE UNPLUGGING THE MACHINE'S POWER CORD.

Safety switch

Power cord

CAUTION

!

If you leave the treadmill plugged in after turning off the console, there will still be current running to the console. This treadmill is equipped with a safety control program that will automatically shut down the machine after six hours of no use. In the event of an automatic shut down, please follow the procedure below to restart the treadmill:

A. Unplug the power cord form the machine's socket.

B. Replug the power cord into the machine's socket to restart the machine.

7

IMPORTANT PRECAUTIONS

Caution

Do Not attempt to plug in or operate your treadmill before reading the Important Precautions.

Important Precautions

Power Source

Plug the treadmill power cord into a dedicated (not shared) 110 volt, alternating current (AC),

15 amp grounded outlet circuit. Do not use an extension cord or an ungrounded outlet.

Do not modify the plug to fit an existing outlet. If it will not fit your outlet, have the correct outlet installed by a qualified electrician.

Never operate your treadmill if the power cord has been damaged. Keep the power cord away from any heated surfaces.

Do not run the power cord under the treadmill. Make sure that the power cord has enough slack to allow the walking deck to fully elevate.

Treadmill Placement

Select a location that is:

• Indoors, away from a water source (pool, hot tub, sauna etc.)

• Away from the use of aerosol sprays or the administration of oxygen.

• Level, free of obstructions, and offers clear access on all sides.

You may place the treadmill on a carpeted floor, but deep pile shag carpeting could interfere with proper ventilation. Use a treadmill mat (usually available from your retailer) if you have deep pile carpeting.

Treadmill Operation

Consult your physician before beginning any exercise program.

Do not overexert yourself during a workout. If you feel any pain or discomfort, consult your physician immediately.

Close supervision is required whenever your treadmill is in use. This is especially important when in use around children, invalids, disabled persons and pets.

Wear clothing appropriate for exercising on your treadmill. Always wear running or training shoes with rubber soles. Do not wear loose fitting clothing that may become caught in the treadmill.

Keep fingers, jewelry, towels and long hair away from any moving parts.

Always attach the Safety Key lanyard clip to your clothing so that the unit will shut down if you stumble or fall.

8

IMPORTANT SAFEGUARDS

Never power up the computer or start the treadmill while standing on the walking belt.

You should straddle the walking deck by standing on the side rails until the belt starts moving. Don’t wait for the treadmill to ramp up to full speed before stepping onto the walking belt.

Make sure that all users are familiar with the instructions and precautions in this manual.

Allow only one person at a time on your treadmill. Always keep your body facing forward when the walking belt is moving. Use the handles when mounting, operating and exiting your treadmill.

It’s a good idea to remove the magnetic Safety Key when you finish your workout to prevent unauthorized use. If your treadmill is going to be left unattended, remove the

Safety Key and unplug the power cord.

Treadmill Maintenance

Allow only trained personnel to service your treadmill.

Do not modify your treadmill, use any parts or attachments not recommended by the manufacturer, or attempt any service other than the assembly and maintenance recommended in this manual.

Always unplug the power cord before attempting to move or perform any maintenance on your treadmill.

When folded, make sure that the Safety Lock is fully engaged. Refer to the Folding And

Lowering The Treadmill section of this manual for the proper folding and lowering procedure.

Regularly inspect and tighten any of the hardware used in the treadmill assembly process.

9

915 COMPUTER OPERATION

Computer Display Panel

Incline Quick

Adj Keys

Speed Quick

Adj Keys

Before Starting

Computer Control Bar

Note: Never stand on the walking belt while starting or stopping the treadmill.

Straddle the walking belt by standing on the side rails. If you are a new user, start at a slow speed and hold the handles until you become comfortable.

Computer Control Bar

Magnetic Safety Key

Note: The 915 computer and walking belt will not function without the Magnetic Safety Key in place.

To operate the 915 treadmill, attach the safety key lanyard clip to your clothing and position the Magnetic Safety Key on the “Safety Key” circle.

When not in use, move the Magnetic Safety Key to the “Off” circle.

Power Key

With the Magnetic Safety Key in place, press this key to turn on and off the 915 computer.

Incline Up Key

Note: In addition to increasing the walking deck incline, this key allows you to toggle through programs or increase the setting values.

Press this key (on either the Computer Control Bar or above the left hand grip) to increase the walking deck incline. Press and hold this key to quickly reach your desired incline setting.

Incline Down Key

Note: In addition to decreasing the walking deck incline, this key allows you to toggle through programs or decrease the setting values.

Press this key (on either the Computer Control Bar or above the left hand grip) to decrease the walking deck incline. Press and hold this key to quickly reach your desired incline setting.

Start/Stop Key

Press this key to start or stop the selected program. Both the speed and incline will automatically return to 0.

Scan/Select Key

To Select: Press this key to toggle through and display either Distance, Calories, Pulse or Incline on the Computer Display Panel.

To Scan: (automatically cycle through the 4 display options at 5 second intervals) Press and hold this key until the L.E.D. begins to flash.

This will confirm that you are in Scan mode.

Enter/Reset Key

Press this key to confirm the selected program or setting value. Press and hold this key for 2 seconds to return to the default setting values.

Speed Up Key

Note: In addition to increasing the walking belt speed, this key allows you to toggle through programs or increase the setting values.

Press this key (on either the Computer Control Bar or above the right hand grip) to increase the walking belt speed from 0.5 to 10 MPH (0.8 to 16 KPH) in 0.1

MPH (0.2 KPH) increments. Press and hold this to quicking reach your desired speed setting.

Speed Down Key

Note: In addition to decreasing the walking belt speed, this key allows you to toggle through programs or decrease the setting values.

Press this key (on either the Computer Control Bar or above the right hand grip) to decrease the walking belt speed from 0.1 MPH (0.2 KPH) increments. Press and hold this to quickly reach your desired speed setting.

10

Computer Display Panel

Program L.E.D. Display

As you toggle through the Manual, 6 preset and 2 user defined program, the corresponding L.E.D. will light to confirm your selection.

Time Display Window

This window will display exercise time in your choice of count-up or count-down mode. For count-down mode, select program, press the Enter/Reset Key and use the Speed Up key to choose your exercise time. For count-up mode, press the Start/Stop Key without using the Enter/Reset Key. The 915 computer will count up from 0:00 to 99:59, or count down from 10:00 through 99:00. When the count-down time reaches 0:00, the computer will beep 12 times and stop.

Speed Display Window

This window will display the speed of the walking belt in MPH (0.5 to 10) or KPH (0.8 to 16).

Multi-Function Display Window

Distance

This default display will show distance traveled in count-up mode from 0 to 999. You can choose a total distance target by pressing the Enter/Reset Key until the window flashes 0.00. Use the Speed Up Key to select your distance target. The 915 computer will count down distance to 0.00, beep 12 times and stop

Calories

This display will show estimated calories burned in count-up mode from 0 to 999. You can choose a total calories target by pressing the

Scan/Select Key to select calories and then following the steps described in choosing a distance target.

Pulse

This display will show your heart rate in beats per minute.

Incline

This display will show your selected incline level from 1 through 12.

Progress L.E.D. Display

This display will show your progress around a quarter mile (400 meter) oval. Each “lap” is divided into twelve segments represented by one L.E.D.

Your progress will be shown by first lighting then unlighting the oval.

Caution

Read Important Precautions and 915 Computer Operation before attempting to workout on your treadmill.

Manual Programs

Note: Never stand on the walking belt while starting or stopping the treadmill.

With the treadmill properly attached to the required power source and the magnetic Safety Key in place, press the Power Key to start the computer.

Confirm that the L.E.D. next to Manual on the Computer Display Panel is lit.

Count-up Mode: Press the Start/Stop Key to begin the Manual Program in count-up mode. The walking belt will automatically begin moving at 0.5 MPH.

Using the Speed Up Key, select a comfortable warm up speed and begin walking. Using the Speed and Incline Keys you can tailor the workload to suit your needs. To stop on the side rails and press the Start/Stop Key. Press the Power Key to shut down the computer and slide the magnetic Safety Key to the Off Circle.

Count-down Mode: After pressing the Power Key, press the Enter Key and confirm that the Time Display Window is flashing 0.00. Use any Speed or Incline Key to select a count-down workout time from 10:00 to 99:00 and press the Start/Stop Key to begin.

Distance Target: After pressing the Power Key, press the Enter Key twice and confirm that the Multi-Function Display Window is flashing 0.00. The Distance

L.E.D. will also be lit. Use any Speed or Incline Key to select a distance target from 1 to 999 miles and press the Start/Stop Key to begin.

Calorie Target: After pressing the Power Key, press the Enter Key 3 times and confirm that the Multi-Function Display Window is flashing 0.00. The Calorie

L.E.D. will also be lit. Use any Speed or Incline key to select a calorie target from 1 to 9999 and press the Start/Stop Key to begin.

Note: If you program multiple targets, the treadmill will stop when the first goal is reached. To continue, press the Start/Stop key.

11

PRESET PROGRAMS

Automatic Incline Programs

Rollings Hills, Weight Loss, Triathlon and 5K Fun Run programs are all Automatic Incline programs. The incline will automatically adjust to match the hill profiles shown on the Computer Display Panel.

After pressing the Power Key, use any Speed or Incline key to select one of the Automatic Incline Programs and press the Start/Stop Key to begin. Using the Speed Up Key, select a comfortable warm up speed and begin walking. Follow the steps outlined in the Manual Count-Down

Mode to enter Time, Distance or Calorie Targets.

Automatic Speed Programs

Both the Interval Walker and Interval Jogger programs are Automatic Speed programs. The walking belt speed will automatically adjust to match the speed profiles shown on the Computer Display Panel.

After pressing the Power Key, use any Speed or Incline key to select one of the Automatic Speed Programs and press the Start/Stop Key to begin walking/jogging. Press the Incline Up Key to adjust the incline and increase your workload.

Follow the steps outlined in the Manual Count-Down Mode to enter Time, Distance or Calorie Targets.

USER DEFINED PROGRAMS

The User Setting 1 and User Setting 2 program allow you to create two customized workouts without which will be saved until the computer is reset. After pressing the Power Key, use any Speed or Incline key to select one of the User Defined Programs and press the Enter Key. Follow the steps outlined in the Manual Count-Down Mode to enter Time, Distance or Calorie Targets.

After you’ve entered the targets (or skipped them by hitting enter 4 times), both the Speed and Multi-Function Display Windows should be flashing.

Using the Speed and Incline keys you can input both the speed and incline for the first of 20 equal workout segments. Press the Enter Key and input the speed and incline for the second workout segment. Continue entering the values for the remaining 18 segments and then press the Start/Stop Key to begin

Note: While exercising in either of the User Defined Programs, you can manually adjust the speed or incline of a segment using any of the Speed or Incline keys.

12

MANUAL

PROGRAM PROFILES

ROLLING HILLS WEIGHT LOSS

INCLINE 0 1 0 2 1 3 0 3 2 1 0 1 0 2 1 3 0 3 2 1

TRIATHLON

INCLINE 0 0 8 8 0 0 8 8 0 4 0 0 8 8 0 0 8 8 0 4

5K FUN RUN

INCLINE 0 1 3 5 5 5 5 5 3 1 0 1 3 5 5 5 5 5 3 1

INTERVAL WALKER

INCLINE 0 1 0 2 0 3 0 1 3 1 0 1 0 2 0 3 0 1 3 1

INTERVAL JOGGER

SPEED 2.5 3.0 2.6 3.1 2.7 3.2 2.8 3.3 3.0 3.5 2.5 3.0 2.6 3.1 2.7 3.2 2.8 3.3 3.0 3.5

USER SETTING 1

SPEED 4.0 4.5 4.1 4.6 4.2 4.7 4.3 4.8 4.5 5.0 4.0 4.5 4.1 4.6 4.2 4.7 4.3 4.8 4.5 5.0

USER SETTING 2

13

USING YOUR TREADMILL

HOW TO START: First of all, start out slow and easy. Just walk for 10 minutes. Do this every day for a week. If this was easy for you, add five minutes to your exercise for week 2. Keep adding 5 minutes until you are running as long as desired.

WATCH YOUR POSTURE: Think of elongating your body. Hold your head up and eyes forward.

Your shoulders should be down, back and relaxed. Tighten your abdominals and buttocks.

Be sure to drink plenty of water before, during, and after exercise. Incorporate a warm up, cool down and stretches into your routine. Start your walk at a slow warm up pace, stop and do a few warm up stretches. Then exercise for the desired length of time. End your exercise with the slower cool down pace and stretch well. Stretching will make you feel great and assist in injury prevention.

The toughest thing about starting a fitness program is developing a habit. Walking daily will help (a minimum of 5 days a week is a good goal). You should walk fast enough to reach your target heart rate, but you should not be gasping for air.

After you have formed the habit you will want to evaluate your program and your goals.

To improve cardiovascular fitness walk 3 to 4 days a week, 20 to 30 minutes at a very fast pace

- breathing hard but not gasping for air.

If you are exercising for weight loss you should walk a minimum of five days a week, 45 to 60 minutes at a "purposeful" pace.

If you're new to exercise, start off with slow, short sessions and build your way up gradually.

If you have any health concerns or medical conditions, be sure to check with your doctor for advice before you begin a routine.

14

STRETCHING

Stretching is one of the most important elements of a good fitness regimen. Many users don't stretch enough, or stretch incorrectly. Stretching can be time consuming, but it is important for good exercise form and injury prevention.

Important rules for stretching:

1. Always warm up prior to stretching.

2. Do not bounce. A stretch should be a gentle movement. Slowly go to the point where you

feel tension in the muscle.

3. A good stretch should not hurt. If you are stretching to the point of pain you are stretching

too hard.

4. To lengthen the muscles hold the stretch for 30 to 40 seconds.

Stretching Routine

Toe points -- Lift one foot off the floor and gently point the toe. Hold for a few seconds. Now, flex your foot pointing your toe up. Do about five of these on each foot.

Ankle Circles -- Stand with your weight on one foot. Lift one foot off the floor and gently point the toe. Rotate your ankle and do about ten circles in each direction. Then change feet. Do this two or three times with each foot.

Arm Circles -- Hold your arms straight out to the side. Make small circles going backward, gradually getting larger and larger. Rest for a second and do the same thing in the forward direction. Do this a couple of times until your arms, shoulders and upper back are warmed up.

Hamstring and Lower Back -- Slowly bend forward from your waist with your knees slightly bent. Reach for the floor and hold. Only bend as far as comfortable.

Lower back -- While lying on your back, bring both knees up towards the chest with the hands.

Round the lower back and relax into the stretch. Don't do this stretch on a hard surface...use a stretching mat, which will provide the required support.

Shoulder Stretch -- Standing upright, cross left arm over chest. Place your right hand on your upper arm and pull arm in tight to chest. Be sure to keep shoulders down and do not pull at the elbow. Hold, and then repeat stretch with other arm.

Neck Relax -- Turn and look over your right shoulder and hold. Repeat on the left side. Don't hyper-extend the neck, or tilt it backwards.

15

YOUR TARGET HEART RATE

You should know your Maximum Heart Rate and your correct training zone to know if you are training at the right pace. Here are a few ways to figure your target heart rate.

You can easily find your Target Heart Rate with this simple method. Subtract your age from

220 (226 for women) to calculate your Maximum Heart Rate. Find your training zone below and multiply that number times your maximum rate.

TRAINING ZONES

Healthy Heart Zone (Warm up) --- 50 - 60% of maximum heart rate: The easiest zone and probably the best zone for people just starting a fitness program. It can also be used as a warm up for more serious walkers. This zone has been shown to help decrease body fat, blood pressure and cholesterol. It also decreases the risk of degenerative diseases and has a low risk of injury. 85% of calories burned in this zone are fats!

Fitness Zone (Fat Burning) --- 60 - 70% of maximum heart rate: This zone provides the same benefits as the healthy heart zone, but is more intense and burns more total calories. The percent of fat calories is still 85%.

Aerobic Zone (Endurance Training) --- 70 - 80% of maximum heart rate: The aerobic zone will improve your cardiovascular and respiratory system AND increase the strength of your heart.

This is the preferred zone if you are training for an endurance event. More calories are burned with 50% from fat.

Anaerobic Zone (Performance Training) --- 80 - 90% of maximum heart rate: Benefits of this zone include an improved VO2 maximum (the highest amount of oxygen one can consume during exercise) and thus an improved cardiorespiratory system, and a higher lactate tolerance ability which means your endurance will improve and you'll be able to fight fatigue better.

This is a high intensity zone burning more calories, 15 % from fat.

Red Line (Maximum Effort) --- 90 - 100% of maximum heart rate: Although this zone burns the highest number of calories, it is very intense. Most people can only stay in this zone for short periods. You should only train in this zone if you are in very good shape and have been cleared by a physician to do so.

16

17

BELT ADJUSTMENT

NOTICE: The treadmill should be placed on a level surface. If the treadmill is not

level, the belt will continuously track to the low side of the treadmill.

WALKING BELT TENSION

As walking belts tend to stretch slightly with use, the belt may occasionally need to be tightened.

If belt is too loose, you may find the belt stops while running or walking, while the motor continues to run. DO NOT OVERTIGHTEN THE BELT. This will cause reduced motor performance and roller damage.

When properly tensioned, you should be able to lift the side of the belt about 2-3 inches

(5-7.5 centimeters). A quick test for belt tension: you should be able to fit three fingers under the edge of the belt.

To tighten belt:

Use allen key provided with the treadmill, place it in the hole in rear end cap and into the socket of the adjustment screw. Turn key one full turn clockwise. Then place allen key in hole in right end cap and turn key one full turn clockwise.

Check the tension of the belt. Continue back and forth until belt is at the correct tension.

Make sure to adjust both sides equally to ensure correct belt alignment.

18

WALKING BELT CENTERING

The walking belt may occasionally need to be centered. First be certain that belt is tensioned properly. Start the treadmill and run it at about 4km/h, place the allen key through the hole in the rear end cap and into the socket of the adjustment screw.

1. If belt has moved to the right:

Turn the right adjustment screw 1/4 turn clockwise, continue adjusting at 1/4 of a turn until

belt returns to the center.

2. If belt has moved to the left:

Turn the left adjustment screw 1/4 turn clockwise, continue adjusting at 1/4 of a turn until belt

returns to the center.

Continue to run the treadmill around 3-5 minutes to ensure the belt has been centered and you have not made over-adjustment.

19

MAINTENANCE

WARNING : ALWAYS UNPLUG THE TREADMILL FROM THE ELECTRICAL OUTLET BEFORE

CLEANING, LUBRICATING OR SERVICING THE UNIT.

CLEANING

General cleaning of the treadmill will prolong the life of the treadmill and improve performance.

Keep the unit clean by dusting regularly. Be sure to dust the exposed part of the deck on either side of the walking belt and also the side rails.

For best performance, we recommend your treadmill be placed on a treadmill mat. Along with reducing noise, a treadmill mat will help to keep dust debris away from your treadmill's critical components.Clean the top of the belt with a wet, soapy cloth. Be careful to keep liquid away from inside the motorized treadmill frame or underneath the belt.

WARNING : ALWAYS UNPLUG THE TREADMILL FROM THE ELECTRICAL OUTLET

BEFORE REMOVING THE MOTOR COVER. At least once a year remove the motor cover and vacuum under the motor cover.

WALKING BELT AND DECK LUBRICATION

It's important to take good care of your treadmill deck (the walking surface underneath the belt), because the belt/deck friction may affect the function and life of your treadmill and requires periodic lubrication.

Use the following timetable as a guide to lubricate the deck :

Type of user Exercising hours per week Number of times

Light user less than 3 hours Annually

Medium user 3-5 hours Every six months

Heavy user More than 5 hours Every three months

20

21

EXPLODED VIEW

22

Item Description

A01 C ONS OL E B AS E

A02 L E F T UP R IG HT HANDL E B AR

A03 R IG HT UP R IG HT HANDL E B AR

A04 P OWE R S WIT C H B R AC K E T

A05 F R ONT R OL L E R

A06 R E AR R OL L E R

A07 F R AME

A08 INC L INE B R AC K E T

A09 B AS E

A10 ADJ US T B AR - OUT S IDE

A11 ADJ US T B AR -INS IDE

B 01 S AF E T Y K E Y

B 02 C OMP UT E R

B 03 HAND P UL S E R E C IE V E R (T OP )

B 04 HAND P UL S E R E C IE V E R (B OT T OM)

B 05 HANDL E B AR C AP

B 06 UP P E R WIR E

B 07 L OWE R WIR E

B 08 WIR E G R OMME T

B 09 F R ONT MOT OR C OV E R

B 10 S AF E T Y S WIT C H F IXE R

B 11 S AF E T Y S WIT C H

B 12 ON/OF F S WIT C H

B 13 C ONT R OL L E R

B 14 L AT C HING AXL E

B 15 L AT C HING K NOB

B 16 S P E E D S E NS OR

B 17 S E NS OR P L AS T IC S T AND

B 18 MOT OR

B 19 MOT OR B E L T

B 20 INC L INE MOT OR

B 21 P OWE R C OR D

B 22 S MAL L HOOD B R AC K E T

B 23 S IDE R AIL

B 24 C US HION

B 25 R UNNING B E L T

B 26 R UNNING DE C K

B 27 L E F T R E AR E ND C AP (T OP )

B 28 L E F T R E AR E ND C AP (B OT T OM)

B 29 R IG HT R E AT E ND C AP (T OP )

B 30 R IG HT R E AR E ND C AP (B OT T OM)

B 31 WHE E L

B 32 C HOC K B IG

B 33 C HOC K S MAL L

B 34 S E NS OR P L AS T IC S T AND

B 35 WIR E

B 36 WIR E

B 37 S P R ING

B 38 F IXE R

Part # Qty Item Description

23022 1 B 39 P L AS T IC F IXE R

PARTS LIST

23024 1 B 41 WHE E L

27056 1 B 42 B AS E E ND C AP

11019 1 B 43 WHE E L

11020 1 B 44 E ND C AP

23027 1 B 45 E ND C AP

27057 1 B 46 S HOC K

23028 1 B 47 C ONS OL E L E F T

27058 1 B 48 C ONS OL E R IG HT

27059 1 B 49 L E F T HANDL E B AR C AP

B 50 R IG HT HANDL E B AR C AP

12029 1 B 51 R E ADING R AC K

10011 1 B 52 B AS E S IDE C AP L E F T

12030 2 B 53 B AS E S IDE C AP R IG HT

12031 2 B 54 WHE E L C OV E R (L E F T )

05119 2 B 55 WHE E L C OV E R (R IG HT )

12032 1

12042 1 C 01 S C R E W

01228 2 C 02 S C R E W

07021 1 C 03 S C R E W

12037 1 C 04 NUT

12043 1 C 05 WAS HE R

12044 1 C 06 S C R E W

12045 1 C 07 S C R E W

05122 1 C 08 S C R E W

05123 1 C 09 WAS HE R

27044 1 C 10 NUT

27043 1 C 11 S C R E W

12046 1 C 12 WAS HE R

16005 1 C 13 P L AS T IC WAS HE R

12047 1 C 14 S C R E W

14007 1 C 15 S C R E W

27045 6 C 16 S C R E W F IXING T UB E

05130 2 C 17 S C R E W

27046 6 C 18 S C R E W

27060 1 C 19 S C R E W

27061 1 C 20 S C R E W F IXING T UB E

05131 1 C 21 S C R E W

05132 1 C 22 S T AR WAS HE R

05133 1 C 23 NUT

05134 1 C 24 WAS HE R

05111 2 C 25 S C R E W

27048 1 C 26 S C R E W

27049 1

27062 2

12048 1

12049 1

05124 1

27063 2

23

Part # Qty

27050 6

05135 4

05136 2

05137 2

05138 2

05120 2

05121 1

27064 1

10009 1

10010 1

05105 2

05106 2

27038 1

05139 1

05140 1

05141 1

05142 1

01274 10

01275 13

01276 2

01277 2

01278 4

01279 2

01280 4

01281 2

01282 2

01283 2

01284 2

01285 2

01286 5

01230 53

01232 6

01235 4

01236 8

01267 11

01233 6

01268 4

01261 1

01269 6

01270 7

01271 5

01272 16

01273 16

L IMITED W ARRANTY

General Terms & Conditions Exclusive Remedies

All LAMAR Health, Fitness & Sports, LLC exercise products are warranted to be free from defects in materials and workmanship

For any product that fails to conform under the terms of applied warranty, LAMAR Health, Fitness & Sports, LLC will provide, at under the terms of recommended use and warranty coverage. their option, one of the following; 1) repair or replacement of defective parts or; 2) replacement of equipment with a product of

Warranty coverage is valid to the original retail purchaser and is not purchase. Original proof of purchase and serial number identification equal value; 3) limited credit reimbursement toward another LAMAR

Health Fitness & Sports product. will be required with any associated warranty claim.

Service Procedure

Coverage periods & warranty terms may vary per product model.

Applied warranties will be based on type of product, components, and recommended application (use environment). Products sold or placed in non-recommended user applications will void all warranty coverage set forth by LAMAR Health, Fitness & Sports, LLC.

Coverage Periods

LAMAR Health, Fitness & Sports, LLC hereby extends the following limited warranties for the application, components, and time periods indicated;

User Environment:

Structural Frame:

Mechanical Parts:

Electronic Parts:

Residential

Lifetime (Limited)

2 years

N/A

Obtain warranty service by contacting LAMAR Health, Fitness &

Sports, LLC or the original place of product purchase. Warranty service will be performed by the original reseller or an authorized service provider. All warranty claims must be validated and meet the requirements set forth by LAMAR Health, Fitness & Sports, LLC.

Warranty claims will include confirmation of model number, serial number, and all pertinent information supporting the existence of an alleged defect. All non-warranty related service cost will be the sole responsibility of the purchaser.

Purchaser is responsible for all transportation of product to and from the reseller. Service calls & travel fees are not covered under standard warranty labor and are the responsibility of the purchaser.

Unauthorized repairs, service performed by someone other than an authorized service provider, and / or use of unapproved replacement parts will void warranty coverage.

Wear Items*:

6 months

Note to Authorized Warranty Service Providers:

Labor**:

6 months

* Wear items are those components that may need replacement based on normal wear & tear conditions (i.e. cables, upholstery, grips, etc.).

Warranty labor reimbursement or warranty parts rights may not be transferred or reassigned to a third party service provider without the authorization of LAMAR Health, Fitness & Sports, LLC.

Product Registration

** Labor coverage excludes unauthorized repairs, service calls, and non-warranty related charges.

Exclusions & Limitations

Fill out the enclosed warranty registration form and return to

LAMAR Health, Fitness & Sports, LLC within 30 days of product purchase. You can also register your product online. Along with

Applied warranties are exclusive to LAMAR Health, Fitness &

Sports, LLC. Warranty coverage will not extend to any product not product registration, keep copies of all product information for your personal records. purchased from LAMAR Health, Fitness & Sports, LLC or from an authorized reseller.

Product Information

Model:_______________________ Purchase Date:_____________

Warranty coverage is void and will not extend to; a) use of product in non-recommended environments ; b) invalid claims and / or; c) any improper maintenance, negligence, misuse, unauthorized repair, alteration, accident, normal wear & tear, or an ACT OF GOD.

Except as expressly set forth in the stated warranty terms warranties, expressed or implied including, but not limited to,

Contact Information:

LAMAR Health, Fitness & Sports, LLC makes no other particular purpose. Any implied warranties that may be imposed by law are limited to the terms stated within LAMAR Health, do not allow limitations on how long an implied warranty lasts or

4699 Nautilus Court South #205

Fitness & Sports, LLC product warranties. Neither LAMAR

Health Fitness & Sports, LLC nor any of its affiliates will be

Boulder, responsible for incidental or consequential damages. Some states

Phone:

Email: apply. The stated warranty gives you specific legal rights and you may have other rights that vary state to state. LAMAR Health,

Fitness & Sports, LLC neither assumes or authorizes anyone to assume for it any other express warranty.

LAMAR H EALTH , F ITNESS , & S PORTS , LLC

4699 N

AUTILUS

C

OURT

S

OUTH

#205

B OULDER , C O . 80301

P RODUCT R EGISTRATION

Thank you for purchasing a LAMAR Health, Fitness & Sports, LLC product. Our products are designed and manufactured to the highest quality standards. We are committed to our customers satisfaction and we will do everything we can under the conditions of your product warranty to keep you secure in your product purchase. To help us serve you better, please fill out this Product Registration form & return it to us within 30-days of product purchase.

Send completed registration form to: LAMAR Health, Fitness & Sports, LLC

4699 Nautilus Court South #205

Boulder, Colorado 80301.

______________________________________________________________

Your Name

B) Please note all factors that influenced your product purchase:

1. □ Valued priced 5. □ Strength training

______________________________________________________________

Address Apt. #

2. □ Quality / durability

3. □ Brand name

6. □ Cardiovascular fitness

7. □ Weight loss

______________________________________________________________

City

4. □ Design / look / feel

______________________________________________________________

8. □ Home fitness convenience

C) Rate the overall in-home assembly of the product:

□ Fair □ Average □ Excellent

Phone Number: ________________________________________________ D) Rate the satisfaction with the retailer from which you purchased your product:

□ Fair □ Average □ Excellent

Email Address:_________________________________________________

E) What other types of exercise equipment do you own?

1. □ Treadmill 5. □ Upright bike

PRODUCT INFORMATION

2. □ Stepper 6. □ Recumbent bike

Model:________________________________________________________

3. □ Elliptical 7. □ Free weights

Product Type:__________________________________________________

(Home Gym, Upright Bike, Free Weight etc.)

4. □ Home Gym 8. Other:____________________________

Serial Number:_________________________________________________

F) What product features / functions are most important to you?

1. □ Heart rate monitoring 6. □ Design / appearance

Date of Purchase:_______________________________________________

(Month / Day / Year)

2. □ Multiple user programs 7. □ Ease of assembly

3. □ Ease of use 8. □ Warranty & service

Purchased From:_______________________________________________

(Retailer Name)

4. □ Quality / durability 9. □ Brand recognition

Address: ______________________________________________________

5.

□ Comfort / fit / feel 10. Other:___________________________

G) How many times a week do you exercise?

□ 1-2 times □ 3-4 times □ 4-5 times □ 6-7 times

SURVEY

H) What is the duration of your workout?

A) How did you learn about our products?

□ 20-30 minutes □ 1-2 hours □ 2 hours or more

1. □ Recommendation of personal trainer

2. □ Recommendation of retail salesperson

3. □ Recommendation of friend / relative □ 18-25 □ 26-35 □ 36-45 □ 46-55 □ 56-65 □ 66 & older

4. □ Article in magazine / newspaper

J) Gender: □ Male □ Female

5. □ Internet

K) Product used by:

□ Personal □ Spouse □ Family

6. □ TV / radio

7. □ other:______________________________________________________

L) Do you belong to a health club, gym, wellness center, etc.?

□ Yes □ No

Thank you ! We appreciate your response. The information provided on this questionnaire is used exclusively by LAMAR Health, Fitness & Sports,

LLC and will not be distributed to any other individuals or agencies regardless of purpose.

Safety Recommendations: Consult a physician or health professional before starting any type of exercise program. Warm up and stretch before staring a exercise routine. Inspect your product for proper assembly. Make sure all hardware is tightened appropriately. Check cables and all moving parts for smooth movement and full range of motion. If you are unsure of proper use of your purchased product, contact a local retailer or call us for instruction. Equipment is not designed for the use of children or minors. Failure to follow or apply these suggested safety tips may result in serious injury.

LAMAR H

EALTH

, F

ITNESS

, & S

PORTS

, LLC

4699 N

AUTILUS

C

OURT

S

OUTH

#205

B

OULDER

, C

O

. 80301

STAMP

FOLD LINE

F OLD & T APE C LOSED OR M AIL R EGISTRATION IN A S EPARATE E NVELOPE

www. lamarhfs. com