advertisement
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
SERVICE MANUAL
CD RECEIVER
KD-G515
Area suffix
UT ------------------------ Taiwan
UH --------------------- Thailand
UN ------------------------ Asean
U ------------------- Other Areas
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
TABLE OF CONTENTS
1
2
3
4
5
www. xiaoyu163. com
COPYRIGHT © 2005 Victor Company of Japan, Limited http://www.xiaoyu163.com
No.MA139
2005/1
http://www.xiaoyu163.com
Maximum Power Output Front
SPECIFICATION
QQ 376315150
Rear
50 W per channel
50 W per channel
8 9 2 4 9 8 2 9 9
Continuous Power Output
(RMS)
Load Impedance
Tone Control Range
Front
Rear
Bass
19 W per channel into 4 Ω , 40 Hz to 20 000 Hz at no more than
0.8% total harmonic distortion.
19 W per channel into 4 Ω , 40 Hz to 20 000 Hz at no more than
0.8% total harmonic distortion.
4 Ω (4 Ω to 8 Ω allowance)
±10 dB at 100 Hz
Frequency Response
Signal-to-Noise Ratio
Line-Out Level/Impedance
Output Impedance
Frequency Range
[FM Tuner]
Treble ±10 dB at 10 kHz
40 Hz to 20 000 Hz
70 dB
2.5 V/20 k Ω load (full scale)
1 k Ω
TUNER SECTION
FM 87.5 MHz to 108.0 MHz
AM
Usable Sensitivity
50 dB Quieting Sensitivity
531 kHz to 1 602 kHz
11.3 dBf (1.0 µ V/75 Ω )
16.3 dBf (1.8 µ V/75 Ω )
Alternate Channel Selectivity (400 kHz) 65 dB
Type
Signal Detection System
Number of Channels
Frequency Response
Dynamic Range
Signal-to-Noise Ratio
Wow and Flutter
MP3 Decoding Format
Frequency Response
Stereo Separation
TEL 13942296513
[AM Tuner] Sensitivity
Selectivity
WMA (Windows Media Audio) Decoding Format
Power Requirement Operating Voltage
Grounding System
Allowable Operating Temperature
Dimensions (W × H × D) Installation Size (approx.)
Panel Size (approx.)
Mass (approx.)
40 Hz to 15 000 Hz
Q
35 dB
Q
20 µ V
35 dB
3
CD PLAYER SECTION
7 6 3 1 5 1 5 0 8 9 2
Compact disc player
Non-contact optical pickup (semiconductor laser)
2 channels (stereo)
5 Hz to 20 000 Hz
96 dB
98 dB
Less than measurable limit
MPEG1/2 Audio Layer 3
Max. Bit Rate : 320 kbps
Max. Bit Rate : 192 kbps
GENERAL
DC 14.4 V (11 V to 16 V allowance)
Negative ground
0 ° C to +40 ° C
182 mm × 52 mm × 150 mm
188 mm × 58 mm × 11 mm
1.5 kg (excluding accessories)
4 9 8 2 9 9
• Microsoft and Windows Media are either registered trademarks or trademarks of Microsoft Corporation in the United States and/ or other countries.
1-2 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
1.1
Safety Precautions
!
SECTION 1
PRECAUTIONS
8 9 2 4 9 8 2 9 9
Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.
!
Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-3
http://www.xiaoyu163.com
1.2
Preventing static electricity
Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser QQ 376315150 8 9 2 4
Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as CD players.
9 8 2 9
Be careful to use proper grounding in the area where repairs are being performed.
9
(1) Ground the workbench
Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the traverse unit (optical pickup) on it.
(2) Ground yourself
Use an anti-static wrist strap to release any static electricity built up in your body.
(caption)
Anti-static wrist strap
1M
Conductive material
(conductive sheet) or iron plate
(3) Handling the optical pickup
• In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical pickup are shorted. After replacement, return the shorted parts to their original condition.
(Refer to the text.)
• Do not use a tester to check the condition of the laser diode in the optical pickup. The tester's internal power source can easily destroy the laser diode.
1.3
Handling the traverse unit (optical pickup)
(1) Do not subject the traverse unit (optical pickup) to strong shocks, as it is a sensitive, complex unit.
(2) Cut off the shorted part of the flexible cable using nippers, etc. after replacing the optical pickup. For specific details, refer to the time when attaching it to the connector.
Q Q 3 7 6 3
(3) Handle the flexible cable carefully as it may break when subjected to strong force.
1 5 1 5 0 8 9 2 4 9 8 2 9 9
(4) It is not possible to adjust the semi-fixed resistor that adjusts the laser power. Do not turn it.
1.4
Attention when traverse unit is decomposed
*Please refer to "Disassembly method" in the text for the CD pickup unit.
• Apply solder to the short land before the flexible wire is disconnected from the connector on the CD pickup unit.
(If the flexible wire is disconnected without applying solder, the CD pickup may be destroyed by static electricity.)
• In the assembly, be sure to remove solder from the short land after connecting the flexible wire.
Short-circuit point
(Soldering)
Flexible wire
Pickup www. xiaoyu163. com
1-4 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
1.5
Important for laser products
2.DANGER : Invisible laser radiation when open and inter lock failed or defeated. Avoid direct exposure to beam.
3.CAUTION : There are no serviceable parts inside the
Laser Unit. Do not disassemble the Laser Unit. Replace the complete Laser Unit if it malfunctions.
4.CAUTION : The CD,MD and DVD player uses invisible laser radiation and is equipped with safety switches which prevent emission of radiation when the drawer is open and the safety interlocks have failed or are defeated. It is dangerous to defeat the safety switches.
5.CAUTION : to function.
8 9 2 4 9 8 2 9
6.CAUTION : Use of controls, adjustments or performance of
9 procedures other than those specified here in may result in hazardous radiation exposure.
!
Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
REPRODUCTION AND POSITION OF LABELS
TEL 13942296513 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
CLASS 1
LASER PRODUCT
CAUTION : Visible and Invisible laser radiation when open and interlock failed or defeated.
AVOID DIRECT EXPOSURE TO
BEAM. (e)
ADVARSEL : Synlig og usynlig laserstråling når maskinen er
åben eller interlocken fejeler.
Undgå direkte eksponering til stråling. (d)
VARNING : Synlig och osynling laserstrålning när den öppnas och spärren är urkopplad. Betrakta ej strålen. (s)
VARO : Avattaessa ja suojalukitus ohitettuna tai viallisena olet alttiina näkyvälle ja näkymättömälle lasersäteilylle. Vältä säteen kohdistumista suoraan itseesi. (f) www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-5
http://www.xiaoyu163.com
SECTION 2
8 9 2 4 9 8 2
This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS.
9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
1-6 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.1
Main body
SECTION 3
DISASSEMBLY
8 9
3.1.1 Removing the front panel assembly
(See Fig.1)
(1) Push the detach button in the lower right part of the front panel assembly and remove the front panel assembly.
(2) Take out the front panel assembly.
2 4 9
Front panel assembly
8 2 9 9
Detach button
Fig.1
3.1.2 Removing the bottom cover
(See Fig.2)
(1) Turn the main body up side down.
(2) Insert a screwdriver under the joints to release the two joints a on the left side, two joints b on the right side and joint c on the back side of the main body, then remove the bottom cover from the main body.
CAUTION:
When releasing the joints using a screwdriver, do not damage the main board.
TEL 13942296513 Q Q
Joint a
Bottom cover
Joint b
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Joint b
Joint a
Joint c
Fig.2
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-7
http://www.xiaoyu163.com
3.1.3 Removing the front chassis assembly
(See Figs.3 and 4) QQ 376315150 body. (See Fig.3)
(2) Remove the two screws B on the front side of the main body. (See Fig.4)
(3) Release the two joints d and two joints e on the both sides of the main body, then remove the front chassis assembly forward. (See Fig.3)
Joint d
8 9
A
2 4 9
Joint
8 2
A
9 9
Joint d Joint e
Front chassis assembly
Fig.3
Front chassis assembly
(See Fig.55)
Reference:
Remove the front panel assembly as required. (Refer to "3.1.1
Removing front panel assembly")
(1) Remove the two screws C and screw D attaching the side panel on the left side of the main body.
(2) Take out the side panel from the main body.
Q Q
B
Fig.4
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
C D C
3.1.5 Removing the rear bracket
(See Fig.6)
• Prior to performing the following procedure, remove the bottom cover.
(1) Remove the three screws E , four screws F and tow screws
G attaching the rear bracket on the back side of the main body.
(2) Take out the rear bracket.
Side panel
Fig.5
F
Rear bracket
G F G
E
1-8 (No.MA139) http://www.xiaoyu163.com
Fig.6
http://www.xiaoyu163.com
3.1.6 Removing the main board
(See Fig.7) QQ 376315150
(1) Remove the two screws H attaching the main board.
(2) Disconnect the connector CN501 and take out the main board.
H
8
CN501
2 4 9
Main board
9 9
H
Fig.7
3.1.7 Removing the CD mechanism assembly
(See Fig.8)
• Prior to performing the following procedure, remove the front panel assembly, front chassis assembly, side panel, bottom cover, rear bracket and main board.
(1) Remove the three screws J attaching the top chassis.
(2) Take out the CD mechanism assembly.
TEL 13942296513 Q Q
J
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
CD mechanism assembly
Fig.8
J
Top chassis www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-9
http://www.xiaoyu163.com
3.1.8 Removing the switch board
(See Figs.9 to 11) QQ 376315150 bly. (See Fig.9)
(2) Release the nine joints h , and take out the rear cover. (See
Fig.10)
(3) Take out the switch board. (See Fig.11)
Note:
When removing the rear cover assembly and switch board, be careful not to lose the spring. (See Fig.11)
8 9 2 4 9 8 9 9
Rear cover
Fig.9
Joint h Joint h
TEL 13942296513
Joint h Rear cover
Fig.10
Joint h
Q Q
Spring
3 7 6 3 1 5 1 5 0
Switch board
8 9 2 4 9 8 2 9 9
Spring
Front panel assembly
Fig.11
www. xiaoyu163. com
1-10 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2
CD Mechanism Assembly
(1) Remove the two screws A on the both side of the body.
(2) Lift the front side of the top cover and move the top cover backward to release the two joints a .
8 9
A
2 4 9 8 2 9 9
A
Top cover Joints a
Joints a
Fig.1
A
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0
Top cover
9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-11
http://www.xiaoyu163.com
3.2.2 Removing the connector board
(See Figs.3 to 5) QQ 376315150 the short-circuit point on the pickup. No observance of this instruction may cause damage of the pickup.
(1) Remove the screw B fixing the connector board.
(2) Solder the short-circuit point on the connector board.
(3) Disconnect the flexible wire from the pickup.
(4) Move the connector board in the direction of the arrow to release the two joints b .
(5) Unsolder the wire on the connector board if necessary.
B
8
Connector board
Wires 9 2 4 9 8 2 9 9
CAUTION:
Unsolder the short-circuit point after reassembling.
Joints b Short-circuit point
Fig.3
Pickup
Short-circuit point
(Soldering)
Flexible wire
TEL 13942296513 Q Q
Pickup
3 7 6 3
Fig.4
1 5 1 5 0 8 9
Connector board
2 4 9 8 2 9 9
Flexible wire
Frame
Fig.5
www. xiaoyu163. com
1-12 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.3 Removing the DET switch
(See Figs.6 and 7) QQ 376315150 8 9 2 4 9 8 2 9 9
DET switch
Connector board
DET switch
Fig.6
Pickup
Tab c
TEL 13942296513
DET switch wire
Q Q 3 7 6 3 1 5 1 5
Tab c
0
Feed sw. holder
9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-13
http://www.xiaoyu163.com
3.2.4 Removing the chassis unit
(See Figs.8 and 9) QQ 376315150 the chassis unit to the frame.
CAUTION:
• The shape of the suspension spring (L) and (R) are different. Handle them with care.
• When reassembling, make sure that the three shafts on the underside of the chassis unit are inserted to the dampers certainly.
8 9 2 4 9 8 2 9 9
Frame
Suspension spring (R)
Fig.8
Chassis unit
Suspension spring (L)
Shaft
TEL 13942296513 Q
Shafts
Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Damper
Damper
Damper
Fig.9
Frame www. xiaoyu163. com
1-14 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.5 Removing the clamper assembly
(See Figs.10 and 11) QQ 376315150
(2) Move the clamper assembly in the direction of the arrow to release the two joints d .
8
Clamper arm
spring
9 2 4 9 8 2 9 9
Joint d
Clamper assembly
Fig.10
Clamper arm spring
Chassis rivet assembly
Joint d
TEL 13942296513
Joint d
Clamper assembly
Joint d
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Chassis rivet assembly
Fig.11
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-15
http://www.xiaoyu163.com
3.2.6 Removing the loading / feed motor assembly
(See Figs.12 and 13) QQ 376315150 assembly in the direction of the arrow to remove it from the chassis rivet assembly.
(2) Disconnect the wire from the loading / feed motor assembly if necessary.
CAUTION:
When reassembling, connect the wire from the loading / feed motor assembly to the flame as shown in Fig.12.
8 9 2 4 9 8 2 9 9
Loading / feed motor assembly
Fig.12
Loading / feed motor assembly
TEL 13942296513
C
Q Q
Fig.13
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
1-16 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.7 Removing the pickup unit
(See Figs.14 to 18) QQ 376315150 the pu. shaft.
(2) Remove the screw E attaching the feed sw. holder.
(3) Move the part e of the pickup unit upward with the pu. shaft and the feed sw. holder, then release the joint f of the feed sw. holder in the direction of the arrow. The joint g of the pickup unit and the feed rack is released, and the feed sw.
holder comes off.
(4) Remove the pu. shaft from the pickup unit.
(5) Remove the screw F attaching the feed rack to the pickup unit.
3.2.8 Reattaching the pickup unit
(See Figs.14 to 17)
(1) Reattach the feed rack to the pickup unit using the screw F .
(2) Reattach the feed sw. holder to the feed rack while setting the joint g to the slot of the feed rack and setting the part f of the feed rack to the switch of the feed sw. holder correctly.
(3) As the feed sw. holder is temporarily attached to the pickup unit, set to the gear of the joint g and to the bending part of the chassis (joint h ) at a time.
CAUTION:
Make sure that the part i on the underside of the feed rack is certainly inserted to the slot j of the change lock lever.
(4) Reattach the feed sw. holder using the screw E .
(5) Reattach the pu. shaft to the pickup unit. Reattach the pu.
TEL 13942296513
D .
Q Q
Feed sw. holder
Joint g
8
Part e
E
9 2 4 9
Feed rack
Fig.15
Feed sw. holder
Pu. shaft
Part i
Pickup unit
Slot j
Joint f
Joint h
8 Pickup unit 2 9
D
Pu. shaft holder
Feed sw. holder
3 7 6 3 1 5 1 5 0
Fig.16
8 9 2 4 9 8 2 9 9
9
Pickup unit
Joint f
Pu. shaft
D
Pu. shaft holder
Pickup unit
Fig.14
Part e
E
Joint g
Joint g
Fig.17
Pickup unit
Joint f
Feed rack
Feed sw. holder
Fig.18
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-17
http://www.xiaoyu163.com
3.2.9 Removing the trigger arm
(See Figs.19 and 20) QQ 376315150 the joint k and pull out upward.
CAUTION:
When reassembling, insert the part m and n of the trigger arm into the part p and q at the slot of the chassis rivet assembly respectively and join the joint k at a time.
8 9 2 Joint k 4 9 8 2
Trigger arm
9 9
Chassis rivet assembly
Fig.19
Part p
Trigger arm
Part q
Part m
Part n
Chassis rivet assembly
TEL 13942296513
3.2.10 Removing the top plate assembly
(See Fig.21)
• Prior to performing the following procedure, remove the top cover, connector board, chassis unit, and clamper assembly.
(1) Remove the screw H .
(2) Move the top plate assembly in the direction of the arrow to release the two joints r.
(3) Unsolder the wire marked s if necessary.
Q Q 3 7 6 3 1 5 1 5 0
Fig.20
8 9 2 4 9 8 2 9 9
Top plate assembly
H
Joints r s
Fig.21
www. xiaoyu163. com
1-18 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.11 Removing the mode sw. / select lock arm
(See Figs.22 and 23) QQ 376315150 t ) and turn in the direction of the arrow to release the joint u .
(2) Unsolder the wire of the mode sw. marked s if necessary.
(3) Turn the select lock arm in the direction of the arrow to release the two joints v .
(4) The select lock arm spring comes off the select lock arm at the same time.
8 9
Link plate 2 4 Joint t
9
Top plate
9 9
Joint u s
Fig.22
Select lock arm
Top plate
Hook w
Select lock arm
Select lock arm spring
TEL 13942296513
Joints v
Q Q
Link plate
3 7 6 3 1 5 1 5 0
Fig.23
8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-19
http://www.xiaoyu163.com
3.2.12 Reassembling the mode sw. / select lock arm
(See Figs.24 to 26) QQ 376315150
(1) Reattach the select lock arm spring to the top plate and set the shorter end of the select lock arm spring to the hook w
Select lock arm spring
8
Hook w on the top plate.
(2) Set the other longer end of the select lock arm spring to the boss x on the underside of the select lock arm, and join the select lock arm to the slots (joint v ). Turn the select lock arm as shown in the figure.
(3) Reattach the mode sw. while setting the part t to the first peak of the link plate gear, and join the joint u .
2 4
Joint v
Select lock arm
9
Boss x
CAUTION:
When reattaching the mode sw., check if the points y and z are correctly fitted and if each part operates properly.
Fig.24
Joint t
Point y
8 2
Joint v
9 9
Link plate
Point z
TEL 13942296513
Fig.25
Mode sw.
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8
Select lock arm
2 9 9
Link plate
Joint t
Joint u
Fig.26
www. xiaoyu163. com
1-20 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.13 Removing the select arm R / link plate
(See Figs.27 and 28) QQ 376315150
(joint a') and turn as shown in the figure to release the two joints b' and joint c' .
(2) Move the link plate in the direction of the arrow to release the joint d'. Remove the link plate spring at the same time.
REFERENCE:
Before removing the link plate, remove the mode sw..
Joint b'
Joint c' 2 4 Link plate 9
Joint a'
Fig.27
Link plate spring
Top plate Joint d'
8 Joint r 2 9 9
Link plate
Fig.28
3.2.14 Reattaching the Select arm R / link plate
(See Figs.29 and 30)
REFERENCE:
(1) Reattach the link plate spring.
Q
(2) Reattach the link plate to the link plate spring while joining
Q them at joint d' .
(3) Reattach the joint a' of the select arm R to the first peak of the link plate while joining the two joints b' with the slots.
Then turn the select arm R as shown in the figure. The top plate is joined to the joint c' .
CAUTION:
When reattaching the select arm R , check if the points e' and f' are correctly fitted and if each part operates properly.
3 7 6 3 1 5 1 5
Link plate spring
8 9
Joint b'
Joint b' Joint a'
Fig.29
2
Joint d'
4 9 8 2 9 9
Joint a'
Point e'
Point f'
Fig.30
www. xiaoyu163. com
Link plate
(No.MA139)1-21 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.15 Removing the loading roller assembly
(See Figs.31 to 33) QQ 376315150 and detach it upward from the slot of the joint g' of the lock
Roller guide
spring arm rivet assembly.
(2) Detach the loading roller assembly from the slot of the joint h' of the lock arm rivet assembly.
Part k'
The roller guide comes off the gear section of the loading roller assembly.
8 9 Loading roller assembly 2 4 9 8 2 9 9
Loading roller assembly
Roller guide
spring
Remove the roller guide and the HL washer from the shaft of the loading roller assembly.
(3) Remove the screw J attaching the lock arm rivet assembly.
(4) Push the shaft at the joint i' of the lock arm rivet assembly inward to release the lock arm rivet assembly from the slot of the L side plate.
(5) Extend the lock arm rivet assembly outward and release the joint j' from the boss of the chassis rivet assembly. The roller guide springs on both sides come off at the same time.
CAUTION:
When reassembling, reattach the left and right roller guide springs to the lock arm rivet assembly before reattaching the lock arm rivet assembly to the chassis rivet assembly. Make sure to fit the part k' of the roller guide spring inside of the roller guide. (Refer to Fig.34.)
Roller guide
Chassis rivet assembly
Fig.32
Boss
Loading roller assembly
Q Q
J
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8
L side plate
2 9 9
Roller guide spring
Roller guide
Joint h'
Roller guide spring
Roller guide spring
Joint g'
Lock arm rivet assembly
Fig.33
Part j'
Joint i'
Roller guide
HL washer
Roller shaft assembly
Loading roller assembly
Lock arm rivet assembly
Fig.31
Roller guide spring
Loading roller
Lock arm rivet assembly Roller guide spring
Fig.34
www. xiaoyu163. com
1-22 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.16 Removing the loading gear 5, 6 and 7
(See Figs.35 and 36) QQ 376315150
The loading gear 6 and 7 come off the loading gear bracket.
(2) Pull out the loading gear 5.
8 9 2 K
Loading gear bracket 4 9 8 2 9 9
Loading gear 5
Loading gear 3
TEL 13942296513
K
Loading gear 5
Fig.35
Loading gear bracket
Loading gear 6
Loading gear 7
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Fig.36
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-23
http://www.xiaoyu163.com
3.2.17 Removing the gears
(See Figs.37 to 40) QQ 376315150
(1) Pull out the feed gear.
Shafts rivet assembly
(2) Move the loading plate assembly in the direction of the arrow to release the L side plate from the two slots m' of the chassis rivet assembly. (See Fig.37.)
(3) Detach the loading plate assembly upward from the chassis rivet assembly while releasing the joint n' . Remove the slide hook and loading plate spring from the loading plate assembly.
(4) Pull out the loading gear 2 and remove the change lock lever.
(5) Remove the E ring and washer attaching the changer gear
2.
(6) The changer gear 2, change gear spring and adjusting washer come off.
(7) Remove the loading gear 1.
(8) Move the change plate rivet assembly in the direction of the arrow to release from the three shafts of the chassis rivet assembly upward. (See Fig.38.)
(9) Detach the loading gear plate rivet assembly from the shaft of the chassis rivet assembly upward while releasing the joint p'. (See Figs.38 and 40.)
(10) Pull out the loading gear 4.
E ring
Loading plate spring
9 Joint p' 2 4
Fig.38
Loading plate assembly
Loading gear plate rivet assembly
Chassis rivet assembly
Change gear 2
Joint n'
9 8 2
Loading gear 4
9 9
Shaft
Loading gear 2
Loading gear 1
Slide hook
Feed gear
L side plate
Loading plate assembly
Joint n'
Slot m'
Fig.37
Chassis rivet assembly
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 L side plate 8 2 9 9
Slot m'
Chassis rivet assembly
Fig.39
E ring
Washer
Change gear 2
Change gear spring
Adjusting washer
Loading gear 1
Loading gear 2
Change lock lever
Loading gear 4
Change plate rivet assembly
Chassis rivet assembly
Loading gear plate rivet assembly
Fig.40
www. xiaoyu163. com
1-24 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.18 Removing the turn table / spindle motor
(See Figs.41 and 42) QQ 376315150 sembly through the slot of the turn table on top of the body.
(2) Unsolder the wire on the connector board if necessary.
8 9 2 4 9 8 Turn table 2 9 9
L
Fig.41
L
Turn table
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Spindle motor
Fig.42
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-25
http://www.xiaoyu163.com
SECTION 4
8 9 2
Standard measuring conditions
4 9 8 2 9 9
4.1
Adjustment method
Test instruments required for adjustment
(1) Digital oscilloscope (100MHz)
(2) Electric voltmeter
(3) Digital tester
(4) Tracking offset meter
(5) Test Disc JVC :CTS-1000
(6) Extension cable for check
EXTSH002-22P × 1
Standard volume position
Balance and Bass &Treble volume : lndication"0"
Loudness : OFF
Power supply voltage
Load impedance
Output Level
Dummy load
DC14.4V(11 to 16V)
20K Ω (2 Speakers connection)
Line out 2.5V (Vol. MAX)
Exclusive dummy load should be used for AM,and FM. For FM dummy load,there is a loss of 6dB between SSG output and antenna input.The loss of 6dB need not be considered since direct reading of figures are applied in this working standard.
How to connect the extension cable for adjusting
Caution:
Be sure to attach the heat sink and rear bracket onto the power amplifier IC and regulator IC respectively, before supply the power.
If voltage is applied without attaching these parts, the power amplifier IC and regulator IC will be destroyed by heat.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Heat sink
Extension cable
EXTSH002-22P
Rear bracket www. xiaoyu163. com
1-26 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
5.1
Feed section
Is the voltage out put at
IC541 pin 40, 5V or 0V?
NO
YES
SECTION 5
8 9 2 4 9 8 2 9 9
YES NO
Is the wiring for IC541 pin 40 correct?
NO
Is 5V present at IC501 pins 3,12 and 21?
YES
Check the vicinity of
IC541.
Check CD8V.
Is 6V or 2V present at
IC501 pins 4 and 5?
NO
YES
Check the feed motor connection wiring.
Check IC501.
Is 4V present at both sides of the feed motor?
NO
YES
Check the feed motor.
5.2
Focus section
When the lens is moving:
NO Check the circuits in the vicinity of IC501 pins 15 and 16.
4V
Does the S-search waveform appear at
IC501 pins 8 and 9?
YES
Is the disk rotated?
NO
YES Q Q
NO
Is 4V present between
IC501 pins 6 and 7?
Check the pickup and
3 its connections.
7 6 3 1 5 1 5 0
Is 4V present at IC541 pin 41?
NO
8 9 2 4 9 8 2 9 9
Check IC541.
YES
Does the RF signal appear at RF test point?
YES
Check the spindle motor and its wiring.
YES
Is the RF waveform at RF test point distorted?
NO
NO
Check the circuits in the vicinity of IC521 pin
19 or the pickup.
YES
Proceed to the Tracking section.
5.4
Tracking section
YES
Check the vicinity of
IC501.
When the disc is rotated at first:
NO
Approx. 1.2V
Check the circuits in the vicinity of IC521 pins 2 to 12.
NO Check the pickup and its connections.
Is the tracking error signal output at TE test point?
Check IC541.
(No.MA139)1-27 http://www.xiaoyu163.com
http://www.xiaoyu163.com
5.5
Signal processing section
Is the sound output from both channels (L, R)?
NO
YES
Normal channel.
NO
8 9 2 defective point.
4 9 8 2 9 9
YES
Is 9V present at IC161 pin 31?
NO
Check the vicinity of the
IC901 audio power supply.
YES
Is the audio signal
(including sampling output components) output to IC581 pins 1 and 7 during playback?
NO
YES
Check IC581 and its peripheral circuits.
Is the audio signal output at IC161 pins 3 and 30 during playback?
NO
YES
Check IC161 and its peripheral circuits.
Check the power amp.
IC301.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
1-28 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
5.6
Maintenance of laser pickup 5.7
Replacement of laser pickup with a alcohol soaked cotton swab.
(2) Life of the laser diode
When the life of the laser diode has expired, the following symptoms will appear.
• The level of RF output (EFM output: amplitude of eye pattern) will be low.
power cord from the ac outlet.
Replace the pickup with a normal one. (Refer to "Removing the pickup unit" on the previous page.)
Is RF output
1.0 0.35Vp-p?
NO
Replace it.
YES
Plug the power cord in, and turn the power on.
At this time, check that the laser emits for about seconds and the objective lens moves up and down.
Note: Do not observe the laser beam directly.
OK
(3) Semi-fixed resistor on the APC PC board
The semi-fixed resistor on the APC printed circuit board which is attached to the pickup is used to adjust the laser power.Since this adjustment should be performed to match the characteristics of the whole optical block, do not touch the semi-fixed resistor.
If the laser power is lower than the specified value, the laser diode is almost worn out, and the laser pickup should be replaced. If the semi-fixed resistor is adjusted while the pickup is functioning normally, the laser pickup may be
TEL 13942296513 Q Q
Play a disc.
Check the eye-pattern at
RF test point.
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-29
5.8
16 PIN CORD DIAGRAM
BK
7
6
5
RD
BL
BL/WH
YL
16
OR/WH
15
NC
14
NC
13
4
3
2
1
WH
GN
VI
GY
WH/BK
12
GN/BK
11
VI/BK
10
GY/BK
9 http://www.xiaoyu163.com
BK
RD
Black
8 9 2 4 9
GN Green
8 2 9 9
Red VI Violet
GY Gray BL Blue
WH White YL Yellow
OR Orange
16 YL
8 BK
7 RD
15 OR/WH
3 GN
2 VI
10 VI/BK
4 WH
12 WH/BK
1 GY
9 GY/BK
5 BL/WH
6 BL
MEMORY
GND
ACC
ILL
RL+
RL-
RR+
RR-
FL+
FL-
FR+
FR-
REMOTE
ANT
GND
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Rear Right
ANT
Auto Antenna
RR
FR
Front Right ACC Line
ACC
Front Left
ILL
Illuminations Control
FL
RL
Rear Left
GND
Ground
REMOTE
Remote out
MEMORY
Memory Backup Battery+ www. xiaoyu163. com
1-30 (No.MA139) http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA139)1-31
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
Victor Company of Japan, Limited
AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MA139) http://www.xiaoyu163.com
Printed in Japan
VPT
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
SCHEMATIC DIAGRAMS
CD RECEIVER
TEL 13942296513
KD-G515
CD-ROM No.SML200501
Q Q
Area suffix
UT ------------------------ Taiwan
UH --------------------- Thailand
UN ------------------------ Asean
U ------------------- Other Areas
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Contents
Block diagram
Standard schematic diagrams
Printed circuit boards
2-1
2-2
2-5 to7
www. xiaoyu163. com
COPYRIGHT 2005 Victor Company of Japan, Limited.
http://www.xiaoyu163.com
No.MA139SCH
2005/1
http://www.xiaoyu163.com
Safety precaution
QQ 376315150
!
8 9 2 4 9
Burrs formed during molding may be left over on some parts of the chassis. Therefore,
8
pay attention to such burrs in the case of preforming repair of this system.
2 9 9
!
Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
Block diagram
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9
J1
ANT
PICK UP
FOCUS &
TRACKING
COIL
VF1, VF2, VT1
VT2, LD, MD
TRACKING+,
TRACKING-
FOCUS+,
FOCUS-
LOAD&FEED
MOTOR
FEED+
FEED-
CN001
Main amplifier & CD servo control section
LM0, LM1
IC501
CD
DRIVER
DMO
FOO
FMO
TRO
SPINDLE+
SPINDLE-
FEED+
FEED-
TRACKING+
TRACKING-
FOCUS+
FOCUS-
IC541
DSP
BCK
LRCK
AOUT
BUS0 to 3
BUCK
CCE
RST
POSITION SET
SWITCH
PSW SW1, SW2, PSW
VF1, VF2
SPINDLE
T E L
SPINDLE+
SPINDLE-
VT1, VT2
MD, LD
1 3 9 4 2 2 9 6 5 1 3
RFGC, RF
RFRP, RFDC
SEL, TEB
SW1, SW2
SW1, SW2
IC521
CDRW
RF AMP
LCD & Key control section
IC601
LCD
DRIVER
IC602
REMOCON
LCDCL
LCDDA
LCDCE
REMOCON
ENC1
ENC2
S601 to S617
KEY MATRIX
KEY0
KEY1
KEY2
DIM_CON
KEY0
KEY1
KEY2
LCDCL
LCDDA
LCDCE
REMOCON
ENC1
ENC2
DIMOUT
IC481
DAC
IC401
MP3 & WMA
LSI
MP3REQ
MP3CLK
MP3DOUT
MP3DIN
MP3STBY
MP3RESET
AOUTL+
AOUTL-
AOUTR+
AOUTR-
IC581
CD L.P.F.
DAC_CDTI
DAC_CCLK
DAC_CSN
DAC_PDN
Q
Q641
DIMMER
BCK
LRCK
SDTI Q
COM1
COM2
COM3
S1 to S52
LCD1
LCD DISPLAY
EN601
ENCODER
D601 to D619
D645,D646
LIGHTING
DISPLAY
TU1
FM/AM
TUNER
FMVT
AMVT
FM/AM
IC31
PLL
PLLCE
PLLDA
PLLCL
PLLDI
IC701
3 7
TU.L
TU.R
Q781, Q782
MUTE
CIRCUIT
Q341, Q351
LINE OUT
MUTING
REARL, REARR
SD/ST
MONO
SM
IFC-CONT
SEEK/STOP
MUTE MUTE
6
IC301
POWER
AMP.
OUTLF, OUTLR
OUTRF, OUTRR
VOLDA
VOLCL
3 1
IC161
E.VOLUME
5 1 5
EACH BLOCK
0
IC901
REGULATOR
8
FRONT LEFT (+)
FRONT LEFT (-)
FRONT RIGHT (+)
FRONT RIGHT (-)
REAR LEFT (+) 9 2 4
REAR RIGHT (-)
9
J321
LINE OUT
8 2
IC702
RESET
9
CN901
SPK
BATTERY
9
CD.L
CD.R
SI
SO
I/O
INT
SCK IC801
JVC BUS
CH.SCK
SI/SO
CH.L
CH.R
SI
CD CHANGER
CONTROL w w w . x i a o y u 1 6 3 . c o m
9
2-1 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Standard schematic diagrams
Q Q 3 7 6 3 1 5 1 5 0
R248
220
R244
12k
8 9 2 4 9 8 2
R242
22k
C241
1/50
R241
47k
IC301
TB2906HQ
TU1
QAU0394-001
Q241
2SD601A/R/-X
LEVEL
R161
220k
D240
MA111-X
C312
0.47
51K
R312
1.2K
R900
J1
R793
0
L1
MUTE.DR
AM.ANT
QNB0100-002
4.7u
FM.ANT
TUN.R
TUN.L
C81
C91
1/50
1/50
R81
R91
3.3K
3.3K
C311
0.47
R311
51K
TU.L
C181
0.1
R171
220k
MA111-X
D241
2.2k
R173
C8
R172
22k
D1 D2
Q1
KTD1304-X
CH.L
C173
1/50
C172 1/50
C174
0.0082
C178
0.0056
C179 4.7/25 OUTLF
C39
1000P C171 2.2/50
C175
0.22
C176
0.22
C177
0.033
C180
R181
4.7/25
270
OUTLR
C301
0.47
R301
51K
R930
1.2K
FM/AM.VT
AM.VCC
CD.L
VOLDA
FM.VCC
R5
47k
C302
0.47
R302
51K
R920
1.2K
C36
7P
C316
IC31
RA30
2.2K
TB2118F-X R7
4.7k
IC161
TEA6320T-X
4.7/25
0.0047
0.0047
C322
C323
FM/AM
R6
47k
Q7
UN2211-X
R4
3.3k
R10
10K
CD.R
C161 2.2/50
C160 C191
0.22
47/16
C166 4.7/25
VOLCL
OUTRR
R352
R342 820
820
D351
MA111-X R351
2.2k
R341
D341
MA111-X
2.2k
Q301
UN2211-X
0.0047
0.0047
C324
C325
PLLCE
PLLDA
PLLCL
PLLDI
C46
C47
R43
470
0.01
0.01
10
R44
220
C50
100P
SD/ST
R13
47K
TU.R
CH.R
C162 1/50
C163
1/50
C159
0.10
C164
0.0082
C192
R162
22k
100/16
0.22
C165
0.22
R163
2.2k
C167
0.033
C168
0.0056
C194
0.01
C193
100/16
C170
C169 4.7/25 OUTRF
AMPSW
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
D991
D992
D993
D994
D995
D996
D997
D998
R32
9V
SW5V
6.2k
C34
0.047
C33
47/6.3
Q31 UN2211-X
D321
MA111-X
R321
2.2k
R331
D331
MA111-X
2.2k
R332
R322
820
820
470P
470P
470P
470P
470P
470P
470P
470P
C961
C962
C963
C964
C965
C966
C967
C968
CD.R
CD.L
D901
1N5401-F64
PSW
SW1
SW2
LM0
LM1
BUS0
BUS1
BUS2
BUS3
BUCK
CCE
RST
S701
QSW0451-001
T E L
C720 0.22
R758
47k 1 3 9 4 2 2 9 6 5 1 3 Q Q 3 7
R782
47K
R785
2.2K
6
R783
10K
3
Q977
2SB709A/QR/-X 1 5 R977 12k 1
Q784
UN2111-X
5 0
1k
R901
C902
2.2/50
8
HA13164A IC901
IC771
BR24L16F-W-X
L701
4.7u
C782
0.1
MP3REQ
MP3RESET
MP3STBY
MP3DIN
MP3DOUT
MP3CLK
DAC-CDTI
DAC-CCLK
IC701
UPD784217AGC306
VSS
R729
47k
VDD
C719
D902
MA111-X
DAC-CSN
DAC-PDN
CDON
CDRW
8V
CDON
R720 1.2k
C723
R731
0.047
D781
MA111-X
C914
100/16
47k
VDD5V R719 0
DIMOUT
DIM.OUT
R730
REMOCON
VDD
OPEN
EPROMCK 10k
C706
0.1
EPROMDA
R732
10K
S702
QSW0451-001
ACC5V
10V
ENC1
R734
R735
2.2k
2.2k
LCDCE RD
R892
47k R891
1k
ENC2
LCDCE
VOLDA
VOLCL
R762
R736
LCDDA
LCDCL
D716
SML-310VT/JK/-X
2.2k
47
LCDCL
LCDDA
TD TELMUTE
D717
SML-310VT/JK/-X
R761
R774
R773
R737
R738
R739
4.7k
4.7k
I/O
SCK
KEY2
KEY1
KEY0 R740 4.7k
SO
SI
Q891
UN2211-X R760
R759
C891
0.1
R709
10K BUCK
CCE
R706
R707
150k
150k
R716
R715
R717
820
820
100
LEDB
LEDR
GND D718
MA8062/M/-X
BUS0
R714
R713
10k
820
R741
R779
10k
47K
SM
CN701
QNZ0605-001
LEVEL
R881
47k
BUS1
BUS2
R712
R711
820
820 R743 10k
BUS3 R710 820
KEY2
KEY1
Q881
UN2211-X
RB160M-30-X
ANT
R744
R745
10k
10k
10k
SI
CDRW
AMPSW
R778
R708 3.3k
VPP
R746
R775
10k
47K
R811 R882
4.7k
D851
R805
100k
R806 SI SO
SO
R777
KEY0
4.7k
ENC2
R747
4.7k
R748
4.7k
R749 R776 47K
D852
RB160M-30-X
CN702
QGA2006F1-02
I/O
R704 100K
CH.R
CH.L
R705 47k
R807
100k SCK
C724 0.047
R803
100
R808
330 INT
C730 0.01
J801 SCK
R764
100
0.01
C731
QNZ0095-001 R809
22k C732 0.01
C802
D714 UDZS5.6B-X
X1
C741 0.01
R810
100
120P
2.2k
R780
C801
0.047
RESET
R756
47k
C710
47/6.3
R757
2.2k
C729 0.01
CH.SCK
IC801
HD74HC126FP-X
R801
47k
C726
0.0039
X701 X702
RESET
IC702
IC-PST3433U-X
C728
C721 0.01
w w w . x i a o y u 1 6 3 . c o m
MEM.IN
QAX0617-001Z QAX0401-001
QNN0519-001
9 2
C901
3300/16
RB160M-30-X
4
D971
RB160M-30-X
CN901
QNZ0611-001
J321
9 8
Parts are safety assurance parts.
When replacing those parts make sure to use the specified one.
2 9
9
9
9
SHEET 1
2-2 http://www.xiaoyu163.com
http://www.xiaoyu163.com
CD servo control section
5.1K
8 9
R586
R585 180
6.8k
2
C582
270P
4
CD.R
9 8 2 9
GND
FEED-
VF2
FEED+
VCC
GND
VT2
SW1
VT1
SW2
VF1
PSW
VR
SPINDLE-
LD
SPINDLE+
FOCUS-
VREF
FOCUS+
MD
TRACKING+
TRACKING-
FEED-
VF2
FEED+
VCC
VT2
SW1
VT1
SW2
VF1
PSW
VR
SPINDLE-
LD
SPINDLE+
FOCUS-
VREF
FOCUS+
MD
TRACKING+
TRACKING-
R539
150
VREF
C533
0.01
R534
15k
C532
68P
R533
1k
R532 R531 R535
2k 10k 100
C531
0.1
RF
C530 0.1
IC521
TA2157FN-X
C515
0.01
LM1
R511 1.5k
1.5k
R512
VF1 R523 82k
VF2
VT2
VT1
VCC
82k T E L R524 1 3 9 4 2 2 9 6 5 1 3
C521
0.01
C522
0.01
C523
100/10
C524
0.01
R529
82k
Q521
2SB1241/QR/-T
C525 100/10
R527
R528
22
22
IC461
NJU7772F15-X
R461 100
R462 100
R518
8.2K
C502
0.01
C529
100/10
C528
C503
100/10
0.01
R504
15k
DMO
R502
8.2k
FOO
R503
4.7k
R501
FMO
33k TRO
VREF
47/10
C508
0.1
Q501
2SB1322/RS/-T
C501
AOUTR-
AOUTR+
R581 8.2k
C580 4.7/25
C589 4.7/25
R582 8.2k
C581
3300P
R584 180
R583 8.2k
R593
R594
8.2k
180 C599
AOUTL+
C590
AOUTL-
Q502
2SB1132/QR/-W
4.7/25
4.7/25
R592 8.2k
R591 8.2k
C591
3300P
C512
47/16
R538
33K
R537
0
CDRW
R536
820
C527
0.0068
C583 C593
270P 270P
R595
R596
180
6.8k
C592
270P
C596
100/10
IC581
NJM4580M-X
C597
0.01
CD.L
C598
0.01
R548
R547
R546
C559
C558
C557
C556
0.047
0.047
470P
470P
47
47
47
SEL
TEB
RFGC
L541 47u
C568
0.1
C570
47/6.3
0.01
C571
Q541
UN2111-X L543
47u
Q Q
BUS0
BUS1
BUS2
BUS3
BUCK
CCE
RST
Q542
C541
CDON 100/10
C542
0.01
3 7
R558
10k
C543
1/50
6 3 1 5
IC541
TC94A14FA
C552 0.033
C551
R545
C550
C549
10k
0.01
0.0027
0.033
1
R559
C547
0.015
C548
10K
R543
470k
0.01
1.5M
0
TE
C572
100/10
RFDC
FE
RFRP
RF
8
R541
5.6k
C546
47P
9 2
C545
0.01
C544
100/10
4 9
9V
SW5V
CD.R
CD.L
PSW
SW1
SW2
LM0
LM1
BUS0
BUS1
BUS2
BUS3
BUCK
CCE
RST
8V
8
MP3REQ
MP3RESET
MP3STBY
MP3DOUT
MP3CLK
2
DAC-CDTI
DAC-CCLK
DAC-CSN
DAC-PDN
CDON
CDRW
9 9
VDD5V
C482
0.1
C481
47/16
Q543
UN2111-X
9
R415
47K
Q401
2SB624/4/-X
Q402
UN2211-X
C462
100/6.3
C463
100/6.3
L402
47u
L404
47u
C411
C412
100/10
0.01
12P
C418
C420
0.01
R405
2.2K
C419
X401
12P
QAX0760-001Z
C413
R424
0.1
220
C414
0.0022
IC401
TC94A34FG-002
R423
10K
R451
47k
22k
R453
4.7k
2.2k
R455
4.7k
2.2k
R457
2.2k
4.7k
C440
0.01
R440
4.7K
C430
0.01
IC431
SN74AHCT1G04K-X
C483
0.1
IC481
AK4385ET-X
1/50
R404
10k
R433
100
C403
0.01
47
R407
2.2K
R409
2.2K
R408
2.2K
SHEET 2
2-3 http://www.xiaoyu163.com
http://www.xiaoyu163.com
LCD & Key control section
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
IC602
RPM7338-V4
C681
0.022
0.022
C682
LCD1
QLD0354-001
T E L 1 3 9 4 2 2 9 6 5 1 3
R606
3.9K
R605
2.7K
R604
1.8K
R603
1.2K
R602
820
R601
820
KEY2
R612
3.9K
R611
2.7K
R610
1.8K
R609
1.2K
R608
820
R607
820
KEY1
R614
820
R613
820
KEY0
D601
D602
D603
D604
D605
D606
D607
MA152WK-X
D640
D610
D611
D612
D613
D614
D615
D616
D617
D618 D619
D608 D609
Q Q
R672
470
R671
470
3 7 6 3
IC601
PT6523LQ-L
1 5 1 5 0
R653
10k
R658
180k
R654 10k
10k
10k
LCDDA
C602
680p
R657
51k
OSC
CE
CLK
DATA
S49
S50
S51
S52
COM1
COM2
COM3
VDD
INH
EN601
QSW1115-001
8
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
9 2
DIM_CON
4
470
R624
9
0
R670
DIMOUT
REMOCON
ACC5V
10V
ENC1
ENC2
LCDCE
LCDDA
LCDCL
8 KEY2
KEY1
KEY0
AUX.R
2
AUX.L
0.047
C620
R622 R623
J601
QNS0245-001
9 9 w w w . x i a o y u 1 6 3 . c o m
2-4 http://www.xiaoyu163.com
SHEET 3
http://www.xiaoyu163.com
Printed circuit boards
QQ 376315150
Forward side
8 9 2 4 9 8 2 9 9
C910
IC901
C901
C318
CN901
D996
D995
C966
C965
R311
R312
C961
C962
C963
C964
C187
D991
D992
D993
D994
C312
C302
C311
C301
D998
D997
C968
C967
Q881
C891
Q891
D781
R901
R976
C781
R892
R891
R881
L901
D901
C902
Q781 Q976
C909
C908
R905
Q901
C905
C192
C159
C191
C160
J321
J801
C163
Q331
R1
R40
Q321
R41
C44
R39
C38
R38
Q31
C50
C9
Q351
L1
Q341
C735
TU1
J1
CN702
C161
C31
R930
C317
C307
R302
R301
C315
D782 C784
C512
C506
C503
Q502
IC161
C172 C40
C41 C48
R516
CN501
R532
R535
C530 C531
R530
TEL 13942296513
C481
C482
R519
R581
S701
R536
R529
R528
R527
C555
C554
C553
L541
R545
C552
C527
C549
IC541
R558
RA550
C430
R541
C241
C532
C572
C542
L402
Q543
IC481
Q541
CN701
R408
R409
R407
C593
R433
R406
R594
IC431
Q542
C541
C422
R440
R452
Q440
X401
IC401
C407
R586
C582
C515
C585
C592
R596
C413
C414
C405
IC501
L401
C598
C596
R704
Q
R705
Q
L702
R716
R715
R717
R710
R248 C711
3 R243
R245
R242
R241
7
Q241
6 D244
R712
R711
R708
3 1 5 1
R702
X701
C416
IC702
X702
R780
R757
R756
C709
IC701
C411
C463
IC461
R743
R744
R745
R729
R747
R748
R749
L404
R768
R751
R750
R746
R734
R736
R735
R706
R707
R709
C462
R806
R803
IC801
R772
IC31
RA30
0 R42
C34
8 9 2 4 9 8 2 9 9
R726
R728
IC771
S703
C725
S702 www. xiaoyu163. com http://www.xiaoyu163.com
2-5
http://www.xiaoyu163.com
8 9 2 4 9 8 2 9 9
Reverse side
J1 CN901
C901
J321
C910
R793
C8
B902
C11
C10
R11
C720
C6
C341
D361
R343
R342
TU1
C39
C2
C51
R730
IC901 C911
Q902 J801
C905
D901
R901
D971
C327
C318
R353
R352
R323
R322
C802
R333
R332
C163
C906
C908 C902
R977
C781
C319
C737
CN702
D712
R770
B910
C191
C192
C736
C161
R5
C47
C42
C46
Q6
C45
C40
C31
C186
C36
C172
C712
D243
C241
C183
Q7
R81
R82
S702
C82
Q1
R53
R51
R52
R91
C727
C711
C92
R92
Q10
R773
R759
R454
R456
R458
R811
D714
S703
R753
R752
C707
C184
C909
R161
R162
R172
R163
R173
Q301
R305
C782
C852
D852
R851
D784
Q784
C311
C301
C312
C302
Q782
C315
C512
C785
C784
R785
C503
C733
CN501
C317
C505 C504
C320
IC301
R181
B905
R182
R714
X701
C461
R754
R462
C462
R461
C463
C596
C585
Q Q
C509
R505 3
R718
7 6 R724 3 1 5 1 5 0
C528
8 9
C745
2 4 9 8 2 9 9
C731
C572
R549
R550
C730
R593
R591
C556
C557
C415
C423
C562
C416
C405
C418
C411
C464
C404
R402
R401
C422
C541
C558
C559
R551
R552
C571
C744
R405
C420
C407
R410
C421
Q401
R415
CN701 S701
2-6 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
Switch board
QQ 376315150 8 9 2 4 9 8 2 9 9
Forward side
D619
IC602
LCD1
S611
S613
D605 R610
S612
D604
S614
D607 R612 D606
EN601
S608 D611 D610
S617
S602
D612
R602
S603
R603
D613
S604
D614
R604
S605
R605
D615
S606
D616
S609
D617
R606
S607
D618
J601
TEL 13942296513
J601
R621
C620
R624
R620
R692
R691
IC601
R657
C602
Reverse side
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
R674
Q640
R673
Q641
EN601
C681
C682
R650
R641
D640
R640
R670
R613
R614
R609
R608
R607
R611
CN601
C603
R651
R652
R636
R637
R638
R639 www. xiaoyu163. com http://www.xiaoyu163.com
2-7
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
Victor Company of Japan, Limited
AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MA139SCH) http://www.xiaoyu163.com
Printed in Japan
VPT
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
PARTS LIST
[ KD-G515 ]
* All printed circuit boards and its assemblies are not available as service parts.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
- Contents -
Exploded view of general assembly and parts list (Block No.M1)
CD mechanism assembly and parts list (Block No.MB)
Electrical parts list (Block No.01~02)
Packing materials and accessories parts list (Block No.M3)
www. xiaoyu163. com
MA139 http://www.xiaoyu163.com
3-2
3-5
3-7
3-12
3-1
3-2 http://www.xiaoyu163.com
Exploded view of general assembly and parts list
QQ 376315150
M 1 M M
8 9 2 4 9 8 2 9 9
1
5
A
8
B
66
only UT version
2
4
TEL 13942296513
33
4
35
36
40
C
5
B
3
23
28
25
4
15
6
17
14 21
10
22
Q Q
9
3 7 6 3 1 5 1 5 0
37
12
8 9 2 4 9 8
24
2
16
9
1
9
43 10
11
32
65
Switch board
34
41
42
38
46
55
39
29
48
44
4
30
31
47
54 http://www.xiaoyu163.com
http://www.xiaoyu163.com
1
1 M M
A
5
8
B
5
C
63
8 9 2 4 9 8 2 9 9
7
61
57
56
64
A
7
58
60
62
59
7
10
28
3
4
15
23
25
Main board
37
12
43
17
14
22
6
21
27
20
6
26
24
Q
16
Q
18
13
3
19
7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
50
11
10
Switch board
34
46
38
41
42
55
47
54
48
44
49
53
52
3-3 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-4
General Assembly
QQ 376315150
Symbol No.
Part No.
Part Name Description
8 9 2
Local
13
14
15
16
17
18
19
20
21
22
23
24
1
2
3
4
5
6
7
8
9
10
11
12
GE10043-210A
GE40135-001A
GE30938-003A
QYSDST2604ZA
GE40235-001A
GE40235-004A
QYSDST2604ZA
QYSDST2610ZA
QYSDSF2006ZA
QYSDST2004ZA
GE30823-005A
FSYH4036-098
GE30827-002A
GE30824-002A
GE31245-002A
GE30829-001A
GE31607-001A
GE31608-001A
GE40154-001A
QZW0108-002
GE40153-001A
GE40157-001A
VKW5264-005
FSKW4012-002
TOP CHASSIS
EARTH PLATE
SIDE PANEL
TAP SCREW
SCREW
SCREW
TAP SCREW
TAP SCREW
TAP SCREW
TAP SCREW
F.CHASSIS ASSY
SHEET
OPEN LEVER
LOCK LEVER(O.L)
RELEASE LEVER
LOCK LEVER(TOP)
LOCK LEVER(L)
LOCK LEVER(R)
GEAR
OIL DAMPER
T.SPRING
T.SPRING
T.SPRING
T.SPRING
49
50
52
53
43
44
45
46
47
48
54
55
56
37
38
39
40
41
42
63
64
65
66
57
58
59
60
61
62
25
26
27
28
29
30
VKW5263-002
GE40155-001A
QYSDSF2006ZA
GE40156-001A
GE31590-015A
GE31592-003A
T.SPRING
T.SPRING
TAP SCREW
BLIND
FRONT PANEL ASSY
FINDER ASSY
31 GE40254-004A VOLUME KNOB ASS
32
33
34
GE31599-001A
GE31593-003A
GE20175-003A
RIM LENS
PRESET BUTTON
35
36
GE31594-004A
GE31595-004A
UP/DOWN BTN
SEARCH BTN
VKZ4777-010
GE31601-004A
GE31598-001A
FSKW3002-012
GE40202-012A
GE10107-001A
VKZ4777-010
GE31603-001A
GE31604-001A
GE31605-001A
GE40251-002A
GE40218-032A
GE30393-002A
FSMA3005-001
GE31452-001A
LV41843-002A
QLD0354-001
QNZ0772-001
QMFZ047-150-T
GE30912-019A
QYSDST2606ZA
QYSDST2606ZA
QYSDST2606ZA
QYSDSF2606ZA
QYSDSF2606ZA
GE40172-004A
GE40124-002A
GE30854-001A
GE31574-011A
MINI SCREW
EJECT BUTTON
RIM COVER
COMP.SPRING
COMPRESSION SPRING
REAR COVER
MINI SCREW
LCD CASE
LCD LENS
LENS CASE
LIGHTING SHEET
SHEET
BOTTOM COVER
INSULATOR
NAME PLATE
LASER CAUTION
LCD MODULE
RUBBER CONN
FUSE
REAR BRACKET
TAP SCREW
TAP SCREW
TAP SCREW
TAP SCREW
TAP SCREW
IC BRACKET
REG BRACKET
LED HOLDER
UT LABEL
M2.6 x 4mm(x3)
(x2)
(x2)
M2.6 x 4mm(x3)
M2.6 x 10mm
M2 x 6mm(x2)
M2 x 4mm(x2)
M2 x 6mm
(x4)
Q
15A
Q
M2.6 x 6mm
M2.6 x 6mm
M2.6 x 6mm
M2.6 x 6mm(x2)
M2.6 x 6mm
3 7 6 3 1 5 1 5 0
G515UT
8 9 2 4 9 8 2 9 9
9 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
CD mechanism assembly and parts list
QQ 376315150
TNG-87 TN-2001-1011
GP-501MK
CFD-005Z
GP-305T
111
8 9 2 4 9 8
B
2
M M
9 9
34
74
2
72
35
26
33
31
111
111
73
C
36
85
15
37
22
101
112
24
76
94
61
29
116
93
122
100
95
38
62
75
100
14
96
B
21
112
19
11
25
114
Q Q
A
23
38
13
27
30
A
3 7 6 3 1 5 1 5 32 0
99
8 9 2 4 9 8 2 9 9
28
115
32
D
90
C
B
12
86
83
98
123
97 a
113
89
92
18
20
87
82
125
88
121
16
17
124
83
4
94
91
111
81
84
1
73
74
75
93
77
111
3
111
71
3
The parts without symbol number are not service.
3-5 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-6
CD mechanism
QQ 376315150
Symbol No.
Part No.
Part Name Description
19
20
21
22
23
24
25
26
27
28
29
30
1
2
3
4
11
12
13
14
15
16
17
18
30320101T
30320102T
30320115T
30320116T
303205505T
303205503T
303205301T
303205302T
30320502T
30320503T
30320505T
30320506T
30320507T
30320509T
30320510T
30320511T
30320513T
30320514T
30320518T
30320519T
30320520T
30320521T
30320522T
30320525T
FRAME
TOP COVER
DANPER F
DANPER R
CHASSIS RIVET
CHANGE P. RVT A
CLAMPER ASS'Y
SPINDLE MOTOR A
CLAMPER ARM
CHANGE GEAR SPG
CHANGE GEAR 2
FEED GEAR
FEED RACK
CHANGE LOCK RAR
FEED SW HOLDER
PU SHAFT HOLDER
CLAMPER SUB SPG
FD SUB HOLDER
TOP PLATE
SELECT LOCK ARM
TRIGGER ARM
SLIDE HOOK
PU SHAFT
CLAMPER ARM SPG
88
89
90
91
82
83
84
85
86
87
73
74
75
76
77
81
31
32
33
34
35
36
30320526T
30320538T
30320529T
30320530T
30320531T
30320523T
SELECT L ARM SP
SUSPENSION SP R
SELECT ARM R
LINK PLATE
LINK PLATE SPG
CUSHION F
37 30320524T CUSHION R
38
61
62
30320539T
69011614T
64180406T
SUSPENSION SP L
DET SW ESE22
71
72
303210301T
30321002T
CONN PWB ASS'Y
MODE SW
30321003T
30321005T
30321009T
30321011T
19501403T
303211301T
303211501T
303211302T
303211502T
303211303T
30321101T
30321102T
30321103T
30321104T
30321105T
30321106T
LOAD MOTOR WIRE
MODE SW WIRE
SL WIRE
WIRE HOLDER
WIRE CLUMPER
ROLLER SHAFT AS
L GEAR PLATE RV
LOADING PLATE A
LOCK ARM RV ASS
L/F MOTOR ASS'Y
LOADING GEAR 1
LOADING GEAR 2
LOADING GEAR 3
LOADING GEAR 4
LOADING GEAR 5
LOADING GEAR 6
92
93
94
95
96
97
98
99
100
101
111
112
113
114
30321107T
30321149T
30321114T
30321116T
30321117T
30321118T
30321125T
30321131T
30321133T
18211223T
9P0420031T
9P0420041T
9B0320041T
9C0117183T
LOADING GEAR 7
ROLLER GUIDE
ROLLER GUIDE SP
DISC STOPPER AR
DISC ST ARM SPG
LD GEAR BRACKET
L SIDE PLATE
LOAD PLATE SPG
LDG ROLLER
COLLAR SCREW
SCREW
TAP.SCREW
SCREW
SCREW
115
116
9C0120203T
9C0317503T
SCREW
SCREW
121
122
123
9W0130170T
9W0513060T
9W0710070T
PW 3.5X8X0.3
L WASHER
124
125
9E0100152T
9W0113020T
E RING
PW 2.1X4X0.13
8 9 2
Local
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Electrical parts list
QQ 376315150
Block No. [0][1]
Symbol
No.
IC31
IC161
IC301
IC401
IC431
IC461
IC481
IC501
IC521
IC541
IC581
IC701
IC701
Part No.
Part Name
TB2118F-X
TEA6320T-X
PLL IC
IC
TB2906HQ
TC94A34FG-002
IC
IC
SN74AHCT1G04K-X IC
NJU7772F15-X
AK4385ET-X
LA6242H-X
TA2157FN-X
TC94A14FA
NJM4580M-X
IC
IC
IC
RF AMP IC
CD LSI IC
IC
UPD784217AGC306 IC
UPD784217AGC320 IC
Description
IC702
IC771
IC801
IC901
IC-PST3433U-X
BR24L16F-W-X
HD74HC126FP-X
HA13164A
IC
IC
IC
IC
Q1
Q5
Q6
Q7
Q10
KTD1304-X
2SB709A/R/-X
2SB624/4/-X
UN2211-X
UN2211-X
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q31 UN2211-X TRANSISTOR
Q241
Q341
2SD601A/R/-X
KTD1304-X
TRANSISTOR
TRANSISTOR
Q351 KTD1304-X TRANSISTOR
Q401 2SB624/4/-X TRANSISTOR
Q402
Q440
Q501
Q502
Q521
Q541
Q542
Q543
Q781
Q782
Q784
Q881
Q976
Q977
UN2211-X
UN2211-X
2SB1322/RS/-T
2SB1132/QR/-W
2SB1241/QR/-T
UN2111-X
UN2211-X
UN2111-X
UN2111-X
KTD1304-X
UN2111-X
UN2211-X
UN2211-X
2SB709A/QR/-X
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
D1
D2
D4
D5
D51
D240
D241
D242
D243
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
RB160M-30-X
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SB DIODE
D244
D341
D351
D361
D701
D702
UDZS5.1B-X
MA111-X
MA111-X
UDZS11B-X
MA8062/M/-X
MA8062/M/-X
Z DIODE
SI DIODE
SI DIODE
Z DIODE
Z DIODE
Z DIODE
D703
D704
MA8062/M/-X
MA8062/M/-X
Z DIODE
Z DIODE
D705
D706
D707
D708
MA8062/M/-X
MA8062/M/-X
MA8062/M/-X
MA8062/M/-X
Z DIODE
Z DIODE
Z DIODE
Z DIODE
D709
D713
D714
MA8062/M/-X
MA111-X
UDZS5.6B-X
Z DIODE
SI DIODE
Z DIODE 1.5k
Ω
1/10W J
Local
G515
UN
G515
U,G51
5UH,
G515
UT
Q Q
Symbol
No.
8 9 2 4 9 8 2 9
D715
D716
D717
D718
D781
D782
D784
D851
D852
D901
D902
D971
D972
D993
D995
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
MA8062/M/-X
MA111-X
MA111-X
UDZS11B-X
RB160M-30-X
RB160M-30-X
1N5401-F64
MA111-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
LED
LED
LED
Z DIODE
SI DIODE
SI DIODE
Z DIODE
SB DIODE
SB DIODE
DIODE
SI DIODE
SB DIODE
SB DIODE
SB DIODE
SB DIODE
C94
C159
C160
C161
C162
C163
C164
C165
C166
C167
C168
C169
C170
C171
C172
C173
C174
C175
C176
C177
C178
C179
C180
C191
C47
C48
C49
C50
C51
C81
C82
C84
C91
C92
C42
C43
C44
C45
C46
C1
C2
C3
C4
C5
C6
C9
C10
C11
C31
C32
C33
C34
C35
C36
C37
QEKJ1CM-226Z
NCB31EK-473X
QEKJ1CM-226Z
QEKJ1AM-227Z
QEKJ1HM-104Z
NCB31HK-103X
QEKJ1AM-227Z
NCB31HK-103X
NCB31HK-103X
QEKJ1AM-107Z
NDC31HJ-470X
QEKJ0JM-476Z
NCB31EK-473X
NDC31HJ-100X
NDC31HJ-7R0X
NDC31HJ-100X
E CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
22uF 16V M
0.047uF 25V K
22uF 16V M
220uF 10V M
0.1uF 50V M
0.01uF 50V K
220uF 10V M
0.01uF 50V K
0.01uF 50V K
100uF 10V M
47pF 50V J
47uF 6.3V M
0.047uF 25V K
10pF 50V J
7pF 50V J
10pF 50V J
3
C38
C39
C40
C41
7 6 3
NCB31HK-102X
1 5 1
NCB31EK-473X
5
1000pF 50V K
0
C CAPACITOR
8 9
C CAPACITOR
2 4 9 8 2 9
0.047uF 25V K
9
NCB31HK-103X
QFV61HJ-473Z
NCB31HK-103X
NCB31HK-272X
NCB31HK-103X
NCB31HK-103X
NCB31EK-473X
NCB31HK-102X
NDC31HJ-101X
NDC31HJ-331X
QEKJ1HM-105Z
NCB31HK-332X
NCB31HK-153X
QEKJ1HM-105Z
NCB31HK-332X
NCB31HK-153X
NCB31CK-104X
NCB31CK-224X
QTE1H55-225Z
QEKJ1HM-105Z
QEKJ1HM-105Z
NCB31HK-822X
NCB31CK-224X
NCB21CK-224X
NCB31EK-333X
NCB31HK-562X
QEKJ1EM-475Z
QEKJ1EM-475Z
QTE1H55-225Z
QEKJ1HM-105Z
QEKJ1HM-105Z
NCB31HK-822X
NCB31CK-224X
NCB21CK-224X
NCB31EK-333X
NCB31HK-562X
QEKJ1EM-475Z
QEKJ1EM-475Z
QEKJ1CM-476Z
C CAPACITOR
MF CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
0.01uF 50V K
0.047uF 50V J
0.01uF 50V K
2700pF 50V K
0.01uF 50V K
0.01uF 50V K
0.047uF 25V K
1000pF 50V K
100pF 50V J
330pF 50V J
1uF 50V M
3300pF 50V K
0.015uF 50V K
1uF 50V M
3300pF 50V K
0.015uF 50V K
0.1uF 16V K
0.22uF 16V K
2.2uF 50V
1uF 50V M
1uF 50V M
8200pF 50V K
0.22uF 16V K
0.22uF 16V K
0.033uF 25V K
5600pF 50V K
4.7uF 25V M
4.7uF 25V M
2.2uF 50V
1uF 50V M
1uF 50V M
8200pF 50V K
0.22uF 16V K
0.22uF 16V K
0.033uF 25V K
5600pF 50V K
4.7uF 25V M
4.7uF 25V M
47uF 16V M
3-7 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-8
Symbol
No.
Part No.
Part Name Description QQ 376315150
C192
C193
QEKJ1CM-107Z
QEKJ1CM-107Z
E CAPACITOR
E CAPACITOR
100uF 16V M
100uF 16V M
Local
Symbol
No.
C534
C541
C312
C313
C314
C315
C316
C317
C318
C319
C320
C322
C323
C324
C194
C241
C242
C243
C244
C247
C301
C302
C303
C304
C311
NCB31EK-103X
QEKJ1HM-105Z
QEKJ1CM-226Z
NCB31EK-473X
QEKJ1HM-224Z
NCB31HK-103X
QFV91HJ-474Z
QFV91HJ-474Z
NDC31HJ-101X
NDC31HJ-101X
QFV91HJ-474Z
QFV91HJ-474Z
NDC31HJ-101X
NDC31HJ-101X
QERF1HM-225Z
QEKJ1EM-475Z
QEKJ1CM-226Z
QERF1HM-225Z
NCB31EK-223X
NCB31EK-223X
NCB31HK-472X
NCB31HK-472X
NCB31HK-472X
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
MF CAPACITOR
MF CAPACITOR
C CAPACITOR
C CAPACITOR
MF CAPACITOR
MF CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C464
C481
C482
C483
C501
C502
C503
C504
C419
C420
C421
C422
C423
C430
C440
C461
C462
C463
C325
C341
C403
C404
C405
C407
NCB31HK-472X
NCB31EK-104X
NCB31HK-103X
NCB31HK-103X
QEKJ1HM-105Z
QEKJ1AM-107Z
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
4700pF 50V K
0.1uF 25V K
0.01uF 50V K
0.01uF 50V K
1uF 50V M
100uF 10V M
C408
C411
NCB31HK-103X
QEKJ1AM-107Z
C CAPACITOR
E CAPACITOR
0.01uF 50V K
100uF 10V M
C412 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C413
C414
C415
NCB31EK-104X
NCB31HK-222X
NCB31HK-103X
C CAPACITOR
C CAPACITOR
C CAPACITOR
0.1uF 25V K
2200pF 50V K
0.01uF 50V K
C416
C418
QEKJ1AM-107Z
NCB31HK-103X
E CAPACITOR
C CAPACITOR
100uF 10V M
0.01uF 50V K
NDC31HJ-120X
NDC31HJ-120X
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31EK-104X
QEKJ0JM-107Z
QEKJ0JM-107Z
NCB31EK-104X
QEKJ1CM-476Z
NCB31EK-104X
NCB31EK-104X
QEDJ1AM-476Z
NCB31HK-103X
QEKJ1AM-107Z
NCB31EK-473X
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
12pF 50V J
12pF 50V J
0.01uF 50V K
100uF 10V M
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.1uF 25V K
100uF 6.3V M
100uF 6.3V M
0.1uF 25V K
47uF 16V M
0.1uF 25V K
0.1uF 25V K
47uF 10V M
0.01uF 50V K
100uF 10V M
0.047uF 25V K
C505
C506
C507
C508
C510
C512
C513
C514
C521
C522
C523
C524
NCB31EK-473X
NCB31EK-473X
NCB31EK-473X
NCB31EK-104X
NCB31EK-103X
QERF1CM-476Z
NCB31HK-103X
NCB31EK-103X
NCB31HK-103X
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
0.047uF 25V K
0.047uF 25V K
0.047uF 25V K
0.1uF 25V K
0.01uF 25V K
47uF 16V M
0.01uF 50V K
0.01uF 25V K
0.01uF 50V K
0.01uF 50V K
100uF 10V M
0.01uF 50V K
C525
C527
QEKJ1AM-107Z
NCB31HK-682X
E CAPACITOR
C CAPACITOR
100uF 10V M
6800pF 50V K
C528
C529
C530
C531
NCB31HK-103X
QERF1AM-107Z
NCB31EK-104X
NCB31EK-104X
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
0.01uF 50V K
100uF 10V M
0.1uF 25V K
0.1uF 25V K
C532
C533
NDC31HJ-680X
NCB31HK-103X
C CAPACITOR
C CAPACITOR
68pF 50V J
0.01uF 50V K
0.01uF 25V K
1uF 50V M
22uF 16V M
0.047uF 25V K
0.22uF 50V M
0.01uF 50V K
0.47uF 50V J
0.47uF 50V J
100pF 50V J
100pF 50V J
0.47uF 50V J
0.47uF 50V J
100pF 50V J
100pF 50V J
2.2uF 50V M
4.7uF 25V M
22uF 16V M
2.2uF 50V M
0.022uF 25V K
0.022uF 25V K
4700pF 50V K
4700pF 50V K
4700pF 50V K
C553
C554
C555
C556
C557
C558
C559
C560
C561
C562
C565
C566
C542
C543
C544
C545
C546
C547
C548
C549
C550
C551
C552
C568
C570
C571
C572
C580
C581
C582
C583
C584
Q
C585
Q
C591
C709
C710
C711
C712
C716
C717
C720
C721
C729
C730
C731
C732
C741
C771
C781
C782
C784
C785
C801
C802
C851
C852
C881
C901
C592
C593
C594
C595
C596
C597
C598
C599
C701
C702
C703
C704
C705
C706
C708
Part No.
8
NDC31HJ-5R0X
QEKJ1AM-107Z
9
Part Name
2 4
C CAPACITOR
E CAPACITOR
9
Description
8
5pF 50V J
100uF 10V M
2
Local
9
NDC31HJ-271X
NDC31HJ-271X
NCB31EK-104X
QEKJ0JM-476Z
QEKJ1AM-107Z
NCB31HK-103X
NCB31HK-103X
QEKJ1EM-475Z
NDC31HJ-220X
NDC31HJ-270X
NDC31HJ-270X
NDC31HJ-8R0X
NCB31EK-104X
NCB31EK-104X
NCB31EK-104X
NCB31HK-103X
QEKJ0JM-476Z
QEKJ1AM-227Z
NCB31HK-103X
NCB31EK-104X
NCB31HK-103X
NCB31CK-224X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31EK-473X
QEKJ0JM-107Z
NCB31EK-104X
QEKJ1CM-107Z
NDC31HJ-101X
NCB31EK-473X
NDC31HJ-121X
QEKJ1CM-106Z
NCB31EK-103X
QEKJ1CM-226Z
QEZ0723-338
NCB31HK-103X
QEKJ1HM-105Z
QEKJ1AM-107Z
NCB31HK-103X
NDC31HJ-470X
NCB31HK-153X
NCB31HK-103X
NCB31HK-272X
NCB31HK-103X
NCB31EK-333X
NCB31EK-333X
NCB31EK-473X
NCB31EK-473X
NCB31EK-473X
NCB31HK-471X
NCB31HK-471X
NCB31EK-473X
NCB31EK-473X
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
NCB31HK-103X
QEKJ1AM-107Z
NCB31EK-104X
QEKJ0JM-476Z
NCB31HK-103X
QEKJ1AM-107Z
QEKJ1EM-475Z
NCB31HK-332X
NDC31HJ-271X
NDC31HJ-271X
NCB31EK-104X
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
0.01uF 50V K
1uF 50V M
100uF 10V M
0.01uF 50V K
47pF 50V J
0.015uF 50V K
0.01uF 50V K
2700pF 50V K
0.01uF 50V K
0.033uF 25V K
0.033uF 25V K
0.047uF 25V K
0.047uF 25V K
0.047uF 25V K
470pF 50V K
470pF 50V K
0.047uF 25V K
0.047uF 25V K
0.01uF 50V K
100uF 10V M
0.01uF 50V K
0.01uF 50V K
100uF 10V M
0.1uF 25V K
47uF 6.3V M
0.01uF 50V K
100uF 10V M
4.7uF 25V M
3300pF 50V K
270pF 50V J
270pF 50V J
0.1uF 25V K
3
QEKJ0JM-476Z
7 1
NCB31HK-332X
E CAPACITOR
5 1 5 0
C CAPACITOR
8 9
47uF 6.3V M
9
3300pF 50V K
8 2 9 9
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
270pF 50V J
270pF 50V J
0.1uF 25V K
47uF 6.3V M
100uF 10V M
0.01uF 50V K
0.01uF 50V K
4.7uF 25V M
22pF 50V J
27pF 50V J
27pF 50V J
8pF 50V J
0.1uF 25V K
0.1uF 25V K
0.1uF 25V K
0.01uF 50V K
47uF 6.3V M
220uF 10V M
0.01uF 50V K
0.1uF 25V K
0.01uF 50V K
0.22uF 16V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.047uF 25V K
100uF 6.3V M
0.1uF 25V K
100uF 16V M
100pF 50V J
0.047uF 25V K
120pF 50V J
10uF 16V M
0.01uF 25V K
22uF 16V M
3300uF
9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Symbol
No.
Part No.
Part Name Description QQ 376315150
C902
C903
QEKJ1HM-225Z
QEKJ1CM-476Z
E CAPACITOR
E CAPACITOR
2.2uF 50V M
47uF 16V M
Local
C915
C961
C962
C963
C964
C965
C966
C967
C968
C971
C904
C905
C906
C907
C908
C909
C910
C911
C912
C913
C914
QEDJ1CM-106Z
QEKJ1CM-476Z
NCB31HK-103X
QEKJ1AM-227Z
QEKJ1AM-227Z
QEKJ1AM-227Z
QERF1CM-476Z
NCB31CK-104X
NCB31HK-103X
QEKJ1CM-106Z
QEKJ1CM-107Z
NCB31CK-104X
NDC31HJ-471X
NDC31HJ-471X
NDC31HJ-471X
NDC31HJ-471X
NDC31HJ-471X
NDC31HJ-471X
NDC31HJ-471X
NDC31HJ-471X
NCB31EK-104X
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
10uF 16V M
47uF 16V M
0.01uF 50V K
220uF 10V M
220uF 10V M
220uF 10V M
47uF 16V M
0.1uF 16V K
0.01uF 50V K
10uF 16V M
100uF 16V M
0.1uF 16V K
470pF 50V J
470pF 50V J
470pF 50V J
470pF 50V J
470pF 50V J
470pF 50V J
470pF 50V J
470pF 50V J
0.1uF 25V K
R41
R42
R43
R44
R51
R52
R53
R81
R82
R91
R92
R161
R162
R163
R164
R1
R4
R5
R6
R7
R9
NRS181J-120X
NRSA63J-332X
NRSA63J-473X
NRSA63J-473X
NRSA63J-472X
NRSA63J-470X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R10
R11
NRSA63J-103X
NRSA63J-103X
MG RESISTOR
MG RESISTOR
R13
R31
NRSA63J-473X
NRS181J-100X
MG RESISTOR
MG RESISTOR
R32
R33
R38
NRSA63J-622X
NRSA63J-103X
NRSA63J-101X
MG RESISTOR
MG RESISTOR
MG RESISTOR
R39
R40
NRSA63J-0R0X
NRSA63J-393X
MG RESISTOR
MG RESISTOR
NRSA63J-103X
NRS181J-100X
NRSA63J-471X
NRSA63J-221X
NRSA63J-223X
NRSA63J-104X
NRSA63J-822X
NRSA63J-332X
NRSA63J-133X
NRSA63J-332X
NRSA63J-133X
NRSA63J-224X
NRSA63J-223X
NRSA63J-222X
NRSA63J-473X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R241
R242
R243
R244
R245
R246
R247
R248
R165
R171
R172
R173
R174
R175
R181
R182
NRSA63J-473X
NRSA63J-224X
NRSA63J-223X
NRSA63J-222X
NRSA63J-473X
NRSA63J-473X
NRSA63J-271X
NRSA63J-271X
NRSA63J-473X
NRSA63J-223X
NRSA63J-184X
NRSA63J-123X
NRSA63J-470X
NRSA63J-102X
NRSA63J-473X
NRSA63J-221X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R301 NRSA63J-513X MG RESISTOR
R302
R311
R312
R341
NRSA63J-513X
NRSA63J-513X
NRSA63J-513X
NRSA63J-222X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R342
R343
NRSA63J-821X
NRSA02J-101X
MG RESISTOR
MG RESISTOR
12
Ω
1/8W J
3.3k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
4.7k
Ω
1/16W J
47
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
10
Ω
1/8W J
6.2k
Ω
1/16W J
10k
Ω
1/16W J
100
Ω
1/16W J
0
Ω
1/16W J
39k
Ω
1/16W J
10k
Ω
1/16W J
10
Ω
1/8W J
470
Ω
1/16W J
220
Ω
1/16W J
22k
Ω
1/16W J
100k
Ω
1/16W J
8.2k
Ω
1/16W J
3.3k
Ω
1/16W J
13k
Ω
1/16W J
3.3k
Ω
1/16W J
13k
Ω
1/16W J
220k
Ω
1/16W J
22k
Ω
1/16W J
2.2k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
220k
Ω
1/16W J
22k
Ω
1/16W J
2.2k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
270
Ω
1/16W J
270
Ω
1/16W J
47k
Ω
1/16W J
22k
Ω
1/16W J
180k
Ω
1/16W J
12k
Ω
1/16W J
47
Ω
1/16W J
1k
Ω
1/16W J
47k
Ω
1/16W J
220
Ω
1/16W J
51k
Ω
1/16W J
51k
Ω
1/16W J
51k
Ω
1/16W J
51k
Ω
1/16W J
2.2k
Ω
1/16W J
820
Ω
1/16W J
100
Ω
1/10W J
Q Q
Symbol
No.
R351
R352
R353
R402
R404
R405
R406
R407
R408
R409
R410
R412
R413
R414
R415
R416
R423
R424
R433
R440
R451
R452
R453
R454
R455
R456
R457
R458
R461
R462
R501
R502
R503
R504
R511
R512
R513
R514
R515
R516
R518
R519
R523
R524
R525
R526
R527
R528
R529
R530
R531
R532
R533
R534
R535
R536
R537
R539
R541
R542
R543
R544
R545
R546
R547
R548
R549
R550
R551
R552
R553
R558
R559
Part No.
8 9
NRSA63J-222X
NRSA63J-821X
2
NRSA02J-101X
NRSA63J-470X
NRSA63J-103X
NRSA63J-222X
NRSA63J-470X
NRSA63J-222X
NRSA63J-222X
NRSA63J-222X
NRSA63J-105X
NRSA63J-472X
NRSA63J-472X
NRSA63J-472X
NRSA63J-473X
NRSA63J-102X
NRSA63J-103X
NRSA63J-221X
NRSA63J-101X
NRSA63J-472X
NRSA63J-223X
NRSA63J-473X
NRSA63J-222X
NRSA63J-472X
NRSA63J-222X
NRSA63J-472X
NRSA63J-222X
NRSA63J-472X
NRSA02J-101X
NRSA02J-101X
NRSA63J-333X
NRSA63J-822X
NRSA63J-472X
NRSA63J-153X
3
R507
7
R510
6 3
NRSA63J-682X
1 5 1
NRSA63J-822X
5
NRSA63J-152X
NRSA63J-152X
NRSA63J-152X
NRSA02J-220X
NRSA02J-220X
NRSA02J-331X
NRSA02J-822X
NRSA02J-512X
NRSA63J-823X
NRSA63J-823X
NRSA63J-334X
NRSA63J-334X
NRSA02J-220X
NRSA02J-220X
NRSA63J-823X
NRSA63J-563X
NRSA63J-103X
NRSA63J-202X
NRSA63J-102X
NRSA63J-153X
NRSA63J-101X
NRSA63J-821X
NRSA63J-0R0X
NRSA02J-151X
NRSA63J-562X
NRSA63J-473X
NRSA63J-474X
NRSA63J-103X
NRSA63J-103X
NRSA63J-470X
NRSA63J-470X
NRSA63J-470X
NRSA63J-101X
NRSA63J-101X
NRSA63J-101X
NRSA63J-101X
NRSA63J-105X
NRSA63J-103X
NRSA63J-155X
Part Name
4 9 8
Description
2 9
0
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
8 9
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
2 4
2.2k
Ω
1/16W J
820
Ω
1/16W J
100
Ω
1/10W J
47
Ω
1/16W J
10k
Ω
1/16W J
2.2k
Ω
1/16W J
47
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
1M
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
47k
Ω
1/16W J
1k
Ω
1/16W J
10k
Ω
1/16W J
220
Ω
1/16W J
100
Ω
1/16W J
4.7k
Ω
1/16W J
22k
Ω
1/16W J
47k
Ω
1/16W J
2.2k
Ω
1/16W J
4.7k
Ω
1/16W J
2.2k
Ω
1/16W J
4.7k
Ω
1/16W J
2.2k
Ω
1/16W J
4.7k
Ω
1/16W J
100
Ω
1/10W J
100
Ω
1/10W J
33k
Ω
1/16W J
8.2k
Ω
1/16W J
4.7k
Ω
1/16W J
15k
Ω
1/16W J
6.8k
Ω
1/16W J
3k
Ω
12k
Ω
8 2 9
8.2k
Ω
1/16W J
1.5k
Ω
1/16W J
1.5k
Ω
1/16W J
1.5k
Ω
1/16W J
22
Ω
1/10W J
22
Ω
1/10W J
330
Ω
1/10W J
8.2k
Ω
1/10W J
5.1k
Ω
1/10W J
82k
Ω
1/16W J
82k
Ω
1/16W J
330k
Ω
1/16W J
330k
Ω
1/16W J
22
Ω
1/10W J
22
Ω
1/10W J
82k
Ω
1/16W J
56k
Ω
1/16W J
10k
Ω
1/16W J
2k
Ω
1/16W J
1k
Ω
1/16W J
15k
Ω
1/16W J
100
Ω
1/16W J
820
Ω
1/16W J
0
Ω
1/16W J
150
Ω
1/10W J
5.6k
Ω
1/16W J
47k
Ω
1/16W J
470k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47
Ω
1/16W J
47
Ω
1/16W J
47
Ω
1/16W J
100
Ω
1/16W J
100
Ω
1/16W J
100
Ω
1/16W J
100
Ω
1/16W J
1M
Ω
1/16W J
10k
Ω
1/16W J
1.5M
Ω
1/16W J
9
Local
9
3-9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Symbol
No.
Part No.
Part Name QQ 376315150
R581
R582
R583
R584
R585
R586
R587
R588
R591
R592
R593
R594
R595
R596
R597
R598
R701
R702
R703
R704
R705
R708
R709
R710
R711
R712
R713
R714
R715
R716
R717
R718
R719
R720
NRSA63J-822X
NRSA63J-822X
NRSA63J-822X
NRSA63J-181X
NRSA63J-181X
NRSA63J-682X
NRSA63J-102X
NRSA63J-102X
NRSA63J-822X
NRSA63J-822X
NRSA63J-822X
NRSA63J-181X
NRSA63J-181X
NRSA63J-682X
NRSA63J-102X
NRSA63J-102X
NRSA63J-473X
NRSA63J-470X
NRSA63J-470X
NRSA63J-104X
NRSA63J-473X
NRSA63J-332X
NRSA63J-103X
NRSA63J-821X
NRSA63J-821X
NRSA63J-821X
NRSA63J-821X
NRSA63J-103X
NRSA63J-821X
NRSA63J-821X
NRSA63J-101X
NRSA63J-471X
NRSA63J-0R0X
NRSA63J-122X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R721
R722
R723
NRSA63J-102X
NRSA63J-103X
NRSA63J-103X
MG RESISTOR
MG RESISTOR
R724
R725
R726
R728
R729
R730
R731
R732
R734
R735
R736
R737
R738
R739
R740
R741
R743
R744
R745
R746
R747
R748
R749
R750
R751
R752
R753
R754
R755
R756
R757
R758
R763
R764
NRSA63J-471X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-473X
NRSA63J-103X
NRSA63J-473X
NRSA63J-103X
NRSA63J-222X
NRSA63J-222X
NRSA63J-222X
NRSA63J-470X
NRSA63J-472X
NRSA63J-472X
NRSA63J-472X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-472X
NRSA63J-472X
NRSA63J-472X
NRSA63J-103X
NRSA63J-103X
NRSA63J-104X
NRSA63J-473X
NRSA63J-821X
NRSA63J-106X
NRSA63J-473X
NRSA63J-222X
NRSA63J-473X
NRSA63J-102X
NRSA63J-101X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R768
R771
R772
R775
NRSA02J-271X
NRSA63J-271X
NRSA63J-271X
NRSA63J-473X
MG RESISTOR
MG RESISTOR
MG RESISTOR
R776
R779
NRSA63J-473X
NRSA63J-473X
MG RESISTOR
MG RESISTOR
Description
8.2k
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
180
Ω
1/16W J
180
Ω
1/16W J
6.8k
Ω
1/16W J
1k
Ω
1/16W J
1k
Ω
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
180
Ω
1/16W J
180
Ω
1/16W J
6.8k
Ω
1/16W J
1k
Ω
1/16W J
1k
Ω
1/16W J
47k
Ω
1/16W J
47
Ω
1/16W J
47
Ω
1/16W J
100k
Ω
1/16W J
47k
Ω
1/16W J
3.3k
Ω
1/16W J
10k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
10k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
100
Ω
1/16W J
470
Ω
1/16W J
0
Ω
1/16W J
1.2k
Ω
1/16W J
1k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
470
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
10k
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
47
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
100k
Ω
1/16W J
47k
Ω
1/16W J
820
Ω
1/16W J
10M
Ω
1/16W J
47k
Ω
1/16W J
2.2k
Ω
1/16W J
47k
Ω
1/16W J
1k
Ω
1/16W J
100
Ω
1/16W J
270
Ω
1/10W J
270
Ω
1/16W J
270
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
Local
Symbol
No.
R782
R783
R785
R793
R801
R802
R803
R804
R805
R806
R807
R808
R809
R810
R851
R881
R882
R900
R901
R902
R903
R910
R920
R930
R971
R972
R976
R977
RA30
RA550
L1
L401
L402
Q
L404
Q
L544
L701
L702
L901
CN501
CN701
CN901
J1
J321
J801
S701
S702
S703
TU1
X31
X401
X701
X702
Part No.
8
NRSA63J-473X
NRSA63J-103X
NRSA63J-222X
NRS181J-0R0X
NRSA63J-473X
NRSA63J-473X
NRSA63J-101X
NRSA63J-223X
NRSA63J-104X
NRSA63J-103X
NRSA63J-104X
NRSA63J-331X
NRSA63J-223X
NRSA63J-101X
NRSA63J-103X
NRSA63J-473X
NRSA63J-472X
NRSA63J-122X
QRE142J-102X
NRSA02J-912X
NRSA02J-472X
NRSA63J-122X
NRSA63J-122X
NRSA63J-122X
NRS181J-222X
NRS181J-222X
NRSA02J-273X
NRSA02J-123X
NRZ0065-222X
NRZ0065-103X
QQL244J-4R7Z
NQL114K-470X
NQL114K-470X
NQL114M-4R7X
NQL114M-4R7X
QQR1378-002
QGB2027M4-22S
QNZ0605-001
QNZ0611-001
QNB0100-002
QNN0519-001
QNZ0095-001
QSW0451-001
QSW0451-001
QSW1049-001Z
QAU0394-001
QAX0616-001Z
QAX0760-001Z
QAX0617-001Z
QAX0401-001
9
Part Name
2
COIL
INDUCITOR
INDUCITOR
3
NQL114K-470X
7 1
NQL114K-470X
5 1
INDUCITOR
5 0
INDUCITOR
COIL
COIL
COIL
PIN JACK
DETECT SW
DETECT SW
TACT SW
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
4
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
C RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
NET RESISTOR
NET RESISTOR
CONNECTOR
CAR ANT JACK
CONNECTOR
TUNER PACK
9
Description
8
47k
Ω
1/16W J
10k
Ω
1/16W J
2.2k
Ω
1/16W J
0
Ω
1/8W J
47k
Ω
1/16W J
47k
Ω
1/16W J
100
Ω
1/16W J
22k
Ω
1/16W J
100k
Ω
1/16W J
10k
Ω
1/16W J
100k
Ω
1/16W J
330
Ω
1/16W J
22k
Ω
1/16W J
100
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
4.7k
Ω
1/16W J
1.2k
Ω
1/16W J
1k
Ω
1/4W J
9.1k
Ω
1/10W J
4.7k
Ω
1/10W J
1.2k
Ω
1/16W J
1.2k
Ω
1/16W J
1.2k
Ω
1/16W J
2.2k
Ω
1/8W J
2.2k
Ω
1/8W J
27k
Ω
1/10W J
12k
Ω
1/10W J
2.2k
Ω
10k
Ω
2
4.7uH J
47uH K
47uH K
8 9
47uH K
4
47uH K
9 8
CAR CONNECTOR
16P CONNECTOR
4.7uH M
4.7uH M
B-B (1-22)
10.250MHz
12.500MHz
32.768KHz
Local
9
2 9 9
9
3-10 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Switch board
QQ 376315150
Symbol
No.
Part No.
Part Name Description
IC601
IC602
Q640
Q641
PT6523LQ-L
RPM7338-V4
2SB624/4/-X
UN2211-X
LCD DRIVER
RM.RECEIVER
TRANSISTOR
TRANSISTOR
R601
R602
R603
R604
R605
R606
R607
R608
R609
R610
R611
R612
R641
R642
R643
R644
R646
R648
R651
R652
R613
R614
R631
R632
R634
R636
R638
R640
D601
D602
D603
D604
D605
D606
D607
D608
D609
D610
D611
D612
D613
D614
D615
D616
D617
D618
D619
D640
D641
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
MA152WK-X
UDZS5.1B-X
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
SI DIODE
Z DIODE
D642
D643
D645
MA111-X
MA8062/M/-X
SI DIODE
Z DIODE
NSPW310BS/BRS/ LED
D646
C601
NSPW310BS/BRS/ LED
C CAPACITOR
C602
C603
NCS31HJ-681X
NBE20JM-106X
C CAPACITOR
0.022uF 50V K
680pF 50V J
TA E CAPACITOR 10uF 6.3V M
C611
C612
NCB31HK-123X
NBE20JM-475X
C CAPACITOR
TA E CAPACITOR
0.012uF 50V K
4.7uF 6.3V M
NRSA63J-821X
NRSA63J-821X
NRSA63J-122X
NRSA63J-182X
NRSA63J-272X
NRSA63J-392X
NRSA63J-821X
NRSA63J-821X
NRSA63J-122X
NRSA63J-182X
NRSA63J-272X
NRSA63J-392X
NRSA63J-821X
NRSA63J-821X
NRSA63J-821X
NRSA63J-821X
NRSA63J-331X
NRSA63J-331X
NRSA63J-471X
NRSA02J-471X
NRSA02J-181X
NRSA02J-471X
NRSA02J-471X
NRSA63J-471X
NRSA63J-471X
NRSA63J-331X
NRSA63J-222X
NRSA63J-222X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R653 NRSA63J-103X MG RESISTOR
R654
R655
R656
R657
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-513X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R658
R660
NRSA63J-184X
NRSA02J-391X
MG RESISTOR
MG RESISTOR
820
Ω
1/16W J
820
Ω
1/16W J
1.2k
Ω
1/16W J
1.8k
Ω
1/16W J
2.7k
Ω
1/16W J
3.9k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
1.2k
Ω
1/16W J
1.8k
Ω
1/16W J
2.7k
Ω
1/16W J
3.9k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
330
Ω
1/16W J
330
Ω
1/16W J
470
Ω
1/16W J
470
Ω
1/10W J
180
Ω
1/10W J
470
Ω
1/10W J
470
Ω
1/10W J
470
Ω
1/16W J
470
Ω
1/16W J
330
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
51k
Ω
1/16W J
180k
Ω
1/16W J
390
Ω
1/10W J
Local
S601
S602
S603
S604
S605
S606
S607
S608
S609
S610
S611
S612
S613
S614
S616
S617
Symbol
No.
R661
R670
R672
R673
R674
R691
R692
Part No.
8 9
NRSA02J-391X
NRSA63J-0R0X
2
NRSA02J-471X
NRSA02J-473X
NRSA02J-102X
NRSA63J-103X
Part Name
4 9
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
Description
8 2
390
Ω
1/10W J
0
Ω
1/16W J
470
Ω
1/10W J
47k
Ω
1/10W J
1k
Ω
1/10W J
10k
Ω
1/16W J
470
Ω
1/16W J
9
Local
9
NRSA63J-471X
CN601
EN601
EN601
NNZ0085-001
QSW1115-001
QSW1115-002
CAR CONNECTOR
ROTARY ENCODER
ROTARY ENCODER
G515
UN
G515
U,G51
5UH,
G515
UT
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
3-11 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Packing materials and accessories parts list
QQ 376315150 8 9 2 4 9
3
8
M
9 9
P2
A3 A5 A6 A7 A8
P2
A4
P5
P4
TEL 13942296513
P5
A1
A2
P1
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
A17
P7
KIT:
A12 A13
P3
A16
A15
P6
3-12
A14
www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
Packing and Accessories
QQ 376315150
Symbol No.
Part No.
Part Name Description
A 9
A 10
A 11
A 12
A 13
A 14
A 15
A 16
A 17
KIT
P 1
P 2
P 2
P 3
P 4
P 5
P 6
P 7
A 1
A 2
A 3
A 3
A 4
A 5
A 5
A 6
A 6
A 7
A 8
A 8
GE20137-003A
GE20149-014A
GET0265-001A
GET0265-007A
GET0265-002A
GET0265-009A
GET0265-003A
GET0265-004A
GET0265-008A
GET0265-005A
GET0265-010A
GET0265-006A
VKZ4027-202
VKH4871-003
VKZ4328-003
QYWWS53A008ZA
GE40130-002A
FSJB3002-30C
RM-RK50
------------
QAM0456-002
SRW-385U
QPC03004315P
FSPG4002-001
FSPG4002-001
QPA00801205
GE31453-002A
GE10108-001A
FSYH4036-068
QPA01003003
MOUNTING SLEEVE
TRIM PLATE
INST BOOK
INST BOOK
INST BOOK
INST BOOK
INST BOOK
INSTALL MANUAL
INSTALL MANUAL
INSTALL MANUAL
INSTALL MANUAL
INSTALL MANUAL
PLUG NUT
MOUNT BOLT
LOCK NUT
WASHER
HOOK
HARD CASE
REMOCON UNIT
BATTERY
16P CORD ASSY
SCREW PARTS KIT
POLY BAG
POLY BAG
POLY BAG
POLY BAG
CARTON
PAPER CUSHION
SHEET
POLY BAG
A9 A10 A11 A12 A13
30cm x 43cm
(x2)
8cm x 12cm
(x2)
10cm x 30cm
8
ENG THA
KOR CHI(TAIWAN) ARA PER
RUS
0mm/5.3mm x
(x2)
9 2 4
Local
9
Block No. [M][3][M][M]
G515U,G515UH
G515UT
G515U
G515U
G515UN
G515U,G515UH
G515UT
G515U
G515U
G515UN
G515UH,G515UN,G515UT
G515U
G515UH,G515UN,G515UT
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
3-13
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project
Related manuals
advertisement