advertisement
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
SERVICE MANUAL
CD RECEIVER
KD-G400, KD-AR400
KD-AR400
KD-AR400
S
TEL 13942296513
KD-G400
KD-G400
S
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Area Suffix
J --------- Northern America
TABLE OF CONTENTS
1
2
3
4
5
www. xiaoyu163. com
COPYRIGHT © 2003 VICTOR COMPANY OF JAPAN, LIMITED http://www.xiaoyu163.com
No.MA074
2004/1
http://www.xiaoyu163.com
QQ 376315150
Rear
SPECIFICATION
50 W per channel
50 W per channel
8 9 2 4 9 8 2 9 9
Continuous Power Output
(RMS)
Front
Load Impedance
Rear
19 W per channel into 4 Ω , 40 Hz to 20 000 Hz at no more than
0.8% total harmonic distortion.
19 W per channel into 4
Ω
, 40 Hz to 20 000 Hz at no more than
0.8% total harmonic distortion.
4 Ω (4 Ω to 8 Ω allowance)
Tone Control Range Bass ±10 dB at 100 Hz
Treble ±10 dB at 10 kHz
Frequency Response
Signal-to-Noise Ratio
Line-Out Level/Impedance
Output Impedance
Frequency Range
[FM Tuner]
40 Hz to 20 000 Hz
70 dB
2.5 V/20 k
Ω
load (full scale)
1 k
Ω
TUNER SECTION
FM 87.5 MHz to 107.9 MHz
AM
Usable Sensitivity
50 dB Quieting Sensitivity
530 kHz to 1 710 kHz
11.3 dBf (1.0
µ
V/75
Ω
)
16.3 dBf (1.8
µ
V/75
Ω
)
Alternate Channel Selectivity (400 kHz) 65 dB
Frequency Response 40 Hz to 15 000 Hz
Stereo Separation
TEL 13942296513
[AM Tuner] Sensitivity
Selectivity
35 dB
Q Q
20
µ
V
35 dB
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8
Type
Signal Detection System
Number of channels
Frequency Response
Dynamic Range
Signal-to-Noise Ratio
Wow and Flutter
MP3 decoding format
Power Requirement Operating Voltage
Grounding System
Allowable Operating Temperature
Dimensions (W
×
H
×
D) Installation Size (approx.)
Panel Size (approx.)
Mass (approx.)
CD PLAYER SECTION
Compact disc player
Non-contact optical pickup (semiconductor laser)
2 channels (stereo)
5 Hz to 20 000 Hz
96 dB
98 dB
Less than measurable limit
MPEG1/2 Audio Layer 3
Max. Bit Rate:320 Kbps
GENERAL
DC 14.4 V (11 V to 16 V allowance)
Negative ground
0ºC to +40ºC (32ºF to 104ºF)
182 mm
×
52 mm
×
150 mm (7-3/16"
×
2-1/16"
×
5-15/16")
188 mm
×
58 mm
×
12 mm (7-7/16"
×
2-5/16"
×
1/2")
1.4 kg (3.1 lbs) (excluding accessories)
2 9 9
Design and specifications are subject to change without notice.
www. xiaoyu163. com
1-2 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
1.1
Safety Precautions
!
SECTION 1
PRECAUTION
8 9 2 4 9 8 2 9 9
Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.
!
Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-3
http://www.xiaoyu163.com
1.2
Preventing static electricity
Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser QQ 376315150 8 9 2 4
Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as CD players.
9 8 2 9 9
Be careful to use proper grounding in the area where repairs are being performed.
(1) Ground the workbench
Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the traverse unit (optical pickup) on it.
(2) Ground yourself
Use an anti-static wrist strap to release any static electricity built up in your body.
(caption)
Anti-static wrist strap
1M
Conductive material
(conductive sheet) or iron plate
(3) Handling the optical pickup
• In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical pickup are shorted. After replacement, return the shorted parts to their original condition.
(Refer to the text.)
• Do not use a tester to check the condition of the laser diode in the optical pickup. The tester's internal power source can easily destroy the laser diode.
1.3
Handling the traverse unit (optical pickup)
(1) Do not subject the traverse unit (optical pickup) to strong shocks, as it is a sensitive, complex unit.
(2) Cut off the shorted part of the flexible cable using nippers, etc. after replacing the optical pickup. For specific details, refer to the time when attaching it to the connector.
Q Q 3 7 6 3
(3) Handle the flexible cable carefully as it may break when subjected to strong force.
1 5 1 5 0 8 9 2 4 9 8 2 9 9
(4) It is not possible to adjust the semi-fixed resistor that adjusts the laser power. Do not turn it.
1.4
Attention when traverse unit is decomposed
*Please refer to "Disassembly method" in the text for the CD pickup unit.
• Apply solder to the short land before the flexible wire is disconnected from the connector on the CD pickup unit.
(If the flexible wire is disconnected without applying solder, the CDpickup may be destroyed by static electricity.)
• In the assembly, be sure to remove solder from the short land after connecting the flexible wire.
Short-circuit point
(Soldering)
Flexible wire
Pickup www. xiaoyu163. com
1-4 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
SECTION 2
8 9 2 4 9 8 2 9
This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS.
9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-5
http://www.xiaoyu163.com
SECTION 3
8 9 2 4 9 8 2 9 9
3.1
Main body
3.1.1
Removing the front panel assembly
(See Fig.1)
(1) Press the detach button and remove the front panel assembly.
Front panel assembly
Detach button
3.1.2
Removing the bottom cover
(See Fig.2)
(1) From the bottom side of the main body, release the two joints a , two joints b and joint c .
CAUTION:
Do not damage the main board when releasing the joints using a screwdriver.
Joint a
Fig.1
Bottom cover
Joint b
TEL 13942296513
3.1.3
Removing the front chassis assembly
(See Figs.3 and 4)
• Prior to performing the following procedures, remove the front panel assembly and bottom cover.
(1) From the both sides of the main body, remove the two screws A attaching the front chassis assembly. (See
Fig.3.)
(2) From the front side of the main body, remove the two screws B attaching the front chassis assembly. (See
Fig.4.)
(3) Release the two joints d and two joints e from the both sides of the main body, then remove the front chassis assembly toward the front. (See Fig.3.)
Q Q 3 7 6 3 1 5 1 5 0
Joint a Joint c
Fig.2
8 9 2 4 9 8 2
Joint b
9 9
Joint d
Joint d
A A
Joint e
Joint e
Front chassis assembly
Fig.3
Front chassis assembly
1-6 (No.MA074)
B http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.1.4 Removing the side panel
(See Fig.5) QQ 376315150
C and screw D attaching the side panel.
C
8
D
9 2 4 9 2 9 9
Side panel
Fig.5
3.1.5 Removing the rear bracket
(See Fig.6)
• Prior to performing the following procedure, remove the bottom cover.
(1) From back side of the main body, remove the three screws
E , three screws F and three screws G attaching the rear bracket.
(2) Remove the rear bracket.
F G F G
3.1.6 Removing the main board
(See Figs.6 and 7)
• Prior to performing the following procedures, remove the front panel assembly, bottom cover, front chassis assembly and side panel.
• Remove the front chassis assembly as required.
(1) Remove the three screws E attaching the rear bracket on
TEL 13942296513 Q Q screws H attaching the main board. (See fig.7.)
(3) Disconnect the connector CN501 from the CD mechanism assembly and remove the main board. (See fig.7.)
Reference:
Remove the rear bracket from the main body as required.(SeeÅh2.1.5 Removing the rear bracketÅh.)
E Rear bracket G E
3 7 6 3
CN501
1 5 1 5 0
Fig.6
8 9
Main board
2 4 9 8 2 9 9
H
H
Fig.7
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-7
http://www.xiaoyu163.com
3.1.7
Removing the CD mechanism assembly
(See Fig.8) QQ 376315150
(1) Remove the three screws J attaching the CD mechanism.
(2) Take out the CD mechanism assembly.
8 9 2 4 9 8
J
2 9 9
3.1.8
Removing the front board
(See Figs.9 to 11)
• Prior to performing the following procedures, remove the front panel assembly.
(1) From the back side of the front panel assembly, remove the four screws K attaching the rear cover to the front panel assembly. (See Fig.9.)
(2) Release the ten joints f attaching the rear cover to the front panel assembly. (See Fig.10.)
TEL 13942296513
Caution:
Take care not to lose the springs.
Q Q
CD mechanism assembly
Fig.8
J
3 7 6 3 1 5 1 5 0
Rear cover
Fig.9
Top chassis
K
8 9 2 4 9 8 2 9 9
Joints f Joints f
1-8 (No.MA074)
Spring
Joints f Rear cover
Fig.10
Joints
Front board
f
Front panel assembly http://www.xiaoyu163.com
Spring
http://www.xiaoyu163.com
3.2
CD Mechanism Assembly
(1) Remove the two screws A on the both side of the body.
(2) Lift the front side of the top cover and move the top cover backward to release the two joints a .
8 9
A
2 4 9 8 2 9 9
A
Top cover Joints a
Joints a
Fig.1
A
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0
Top cover
9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-9
http://www.xiaoyu163.com
3.2.2
Removing the connector board
(See Figs.3 to 5) QQ 376315150 the short-circuit point on the pickup. No observance of this instruction may cause damage of the pickup.
(1) Remove the screw B fixing the connector board.
(2) Solder the short-circuit point on the connector board.
(3) Disconnect the flexible wire from the pickup.
(4) Move the connector board in the direction of the arrow to release the two joints b .
(5) Unsolder the wire on the connector board if necessary.
B
8
Connector board
Wires
9 2 4 9 8 2 9 9
CAUTION:
Unsolder the short-circuit point after reassembling.
Joints b Short-circuit point
Fig.3
Pickup
Short-circuit point
(Soldering)
Flexible wire
TEL 13942296513 Q Q
Pickup
3 7 6 3
Fig.4
1 5 1 5 0 8 9
Connector board
2 4 9 8 2 9 9
Flexible wire
Frame
Fig.5
www. xiaoyu163. com
1-10 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.3 Removing the DET switch
(See Figs.6 and 7) QQ 376315150 8 9 2 4 9 8 2 9 9
DET switch
Connector board
DET switch
Fig.6
Pickup
Tab c
TEL 13942296513
DET switch wire
Q Q 3 7 6 3 1 5 1 5
Tab c
0
Feed sw. holder
9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-11
http://www.xiaoyu163.com
3.2.4
Removing the chassis unit
(See Figs.8 and 9) QQ 376315150 the chassis unit to the frame.
CAUTION:
• The shape of the suspension spring (L) and (R) are different. Handle them with care.
• When reassembling, make sure that the three shafts on the underside of the chassis unit are inserted to the dampers certainly.
8 9 2 4 9 8 2 9 9
Frame
Suspension spring (R)
Fig.8
Chassis unit
Suspension spring (L)
Shaft
TEL 13942296513 Q
Shafts
Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Damper
Damper
Damper
Fig.9
Frame www. xiaoyu163. com
1-12 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.5 Removing the clamper assembly
(See Figs.10 and 11) QQ 376315150
(2) Move the clamper assembly in the direction of the arrow to release the two joints d .
8
Clamper arm
spring
9 2 4 9 8 2 9 9
Joint d
Clamper assembly
Fig.10
Clamper arm spring
Chassis rivet assembly
Joint d
TEL 13942296513
Joint d
Clamper assembly
Joint d
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Chassis rivet assembly
Fig.11
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-13
http://www.xiaoyu163.com
3.2.6
Removing the loading / feed motor assembly
(See Figs.12 and 13) QQ 376315150 assembly in the direction of the arrow to remove it from the chassis rivet assembly.
(2) Disconnect the wire from the loading / feed motor assembly if necessary.
CAUTION:
When reassembling, connect the wire from the loading / feed motor assembly to the flame as shown in Fig.12.
8 9 2 4 9 8 2 9 9
Loading / feed motor assembly
Fig.12
Loading / feed motor assembly
TEL 13942296513
C
Q Q
Fig.13
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
1-14 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.7 Removing the pickup unit
(See Figs.14 to 18) QQ 376315150 the pu. shaft.
(2) Remove the screw E attaching the feed sw. holder.
(3) Move the part e of the pickup unit upward with the pu. shaft and the feed sw. holder, then release the joint f of the feed sw. holder in the direction of the arrow. The joint g of the pickup unit and the feed rack is released, and the feed sw.
holder comes off.
(4) Remove the pu. shaft from the pickup unit.
(5) Remove the screw F attaching the feed rack to the pickup unit.
3.2.8 Reattaching the pickup unit
(See Figs.14 to 17)
(1) Reattach the feed rack to the pickup unit using the screw F .
(2) Reattach the feed sw. holder to the feed rack while setting the joint g to the slot of the feed rack and setting the part f of the feed rack to the switch of the feed sw. holder correctly.
(3) As the feed sw. holder is temporarily attached to the pickup unit, set to the gear of the joint g and to the bending part of the chassis (joint h ) at a time.
CAUTION:
Make sure that the part i on the underside of the feed rack is certainly inserted to the slot j of the change lock lever.
(4) Reattach the feed sw. holder using the screw E .
(5) Reattach the pu. shaft to the pickup unit. Reattach the pu.
TEL 13942296513
D .
Q Q
Feed sw. holder
Joint g
8
Part e
E
9 2 4 9
Feed rack
Fig.15
Feed sw. holder
Pu. shaft
Part i
Pickup unit
Slot j
Joint f
Joint h
8 Pickup unit 2 9
D
Pu. shaft holder
Feed sw. holder
3 7 6 3 1 5 1 5 0
Fig.16
8 9 2 4 9 8 2 9 9
9
Pickup unit
Joint f
Pu. shaft
D
Pu. shaft holder
Pickup unit
Fig.14
Part e
E
Joint g
Joint g
Fig.17
Pickup unit
Joint f
Feed rack
Feed sw. holder
Fig.18
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-15
http://www.xiaoyu163.com
3.2.9
Removing the trigger arm
(See Figs.19 and 20) QQ 376315150 the joint k and pull out upward.
CAUTION:
When reassembling, insert the part m and n of the trigger arm into the part p and q at the slot of the chassis rivet assembly respectively and join the joint k at a time.
8 9 2 Joint k 4 9 8 2
Trigger arm
9 9
Chassis rivet assembly
Fig.19
Part p
Trigger arm
Part q
Part m
Part n
Chassis rivet assembly
TEL 13942296513
3.2.10 Removing the top plate assembly
(See Fig.21)
• Prior to performing the following procedure, remove the top cover, connector board, chassis unit, and clamper assembly.
(1) Remove the screw H .
(2) Move the top plate assembly in the direction of the arrow to release the two joints r.
(3) Unsolder the wire marked s if necessary.
Q Q 3 7 6 3 1 5 1 5 0
Fig.20
8 9 2 4 9 8 2 9 9
Top plate assembly
H
Joints r s
Fig.21
www. xiaoyu163. com
1-16 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.11 Removing the mode sw. / select lock arm
(See Figs.22 and 23) QQ 376315150 t ) and turn in the direction of the arrow to release the joint u .
(2) Unsolder the wire of the mode sw. marked s if necessary.
(3) Turn the select lock arm in the direction of the arrow to release the two joints v .
(4) The select lock arm spring comes off the select lock arm at the same time.
8 9
Link plate 2 4 Joint t
9
Top plate
9 9
Joint u s
Fig.22
Select lock arm
Top plate
Hook w
Select lock arm
Select lock arm spring
TEL 13942296513
Joints v
Q Q
Link plate
3 7 6 3 1 5 1 5 0
Fig.23
8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-17
http://www.xiaoyu163.com
3.2.12 Reassembling the mode sw. / select lock arm
(See Figs.24 to 26) QQ 376315150
(1) Reattach the select lock arm spring to the top plate and set
Select lock arm spring
8
Hook w the shorter end of the select lock arm spring to the hook w on the top plate.
2 4
Joint v
9 8 2
Joint v
9 9
(2) Set the other longer end of the select lock arm spring to the boss x on the underside of the select lock arm, and join the select lock arm to the slots (joint v ). Turn the select lock arm as shown in the figure.
(3) Reattach the mode sw. while setting the part t to the first peak of the link plate gear, and join the joint u .
Select lock arm
Boss x
CAUTION:
When reattaching the mode sw., check if the points y and z are correctly fitted and if each part operates properly.
Fig.24
Joint t
Point y
Link plate
Point z
TEL 13942296513
Fig.25
Mode sw.
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8
Select lock arm
2 9 9
Link plate
Joint t
Joint u
Fig.26
www. xiaoyu163. com
1-18 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.13 Removing the select arm R / link plate
(See Figs.27 and 28) QQ 376315150
(joint a') and turn as shown in the figure to release the two joints b' and joint c' .
(2) Move the link plate in the direction of the arrow to release the joint d'. Remove the link plate spring at the same time.
REFERENCE:
Before removing the link plate, remove the mode sw..
Joint b'
Joint c' 2 4 Link plate 9
Joint a'
Fig.27
Link plate spring
Top plate Joint d'
8 Joint r 2 9 9
Link plate
Fig.28
3.2.14 Reattaching the Select arm R / link plate
(See Figs.29 and 30)
REFERENCE:
(1) Reattach the link plate spring.
Q
(2) Reattach the link plate to the link plate spring while joining
Q them at joint d' .
(3) Reattach the joint a' of the select arm R to the first peak of the link plate while joining the two joints b' with the slots.
Then turn the select arm R as shown in the figure. The top plate is joined to the joint c' .
CAUTION:
When reattaching the select arm R, check if the points e' and f' are correctly fitted and if each part operates properly.
3 7 6 3 1 5 1 5
Link plate spring
8 9
Joint b'
Joint b' Joint a'
Fig.29
2
Joint d'
4 9 8 2 9 9
Joint a'
Point e'
Point f'
Fig.30
www. xiaoyu163. com
Link plate
(No.MA074)1-19 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.15 Removing the loading roller assembly
(See Figs.31 to 33) QQ 376315150 and detach it upward from the slot of the joint g' of the lock
Roller guide
spring arm rivet assembly.
(2) Detach the loading roller assembly from the slot of the joint h' of the lock arm rivet assembly.
Part k'
8 9 Loading roller assembly 2 4 9 8 2 9 9
Loading roller assembly
The roller guide comes off the gear section of the loading roller assembly.
Roller guide
spring
Remove the roller guide and the HL washer from the shaft of the loading roller assembly.
(3) Remove the screw J attaching the lock arm rivet assembly.
(4) Push the shaft at the joint i' of the lock arm rivet assembly inward to release the lock arm rivet assembly from the slot of the L side plate.
(5) Extend the lock arm rivet assembly outward and release the joint j' from the boss of the chassis rivet assembly. The roller guide springs on both sides come off at the same time.
CAUTION:
When reassembling, reattach the left and right roller guide springs to the lock arm rivet assembly before reattaching the lock arm rivet assembly to the chassis rivet assembly. Make sure to fit the part k' of the roller guide spring inside of the roller guide. (Refer to Fig.34.)
Roller guide
Chassis rivet assembly
Fig.32
Boss
Loading roller assembly
Roller guide
Q Q
J
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8
L side plate
2 9 9
Roller guide spring
Joint h'
Roller guide spring
Roller guide spring
Joint g'
Lock arm rivet assembly
Fig.33
Part j'
Joint i'
Roller guide
HL washer
Roller shaft assembly
Loading roller assembly
Lock arm rivet assembly
Roller guide spring
Fig.31
Loading roller
Lock arm rivet assembly Roller guide spring
Fig.34
www. xiaoyu163. com
1-20 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.16 Removing the loading gear 5, 6 and 7
(See Figs.35 and 36) QQ 376315150
The loading gear 6 and 7 come off the loading gear bracket.
(2) Pull out the loading gear 5.
8 9 2 K
Loading gear bracket 4 9 8 2 9 9
Loading gear 5
Loading gear 3
TEL 13942296513
K
Loading gear 5
Fig.35
Loading gear bracket
Loading gear 6
Loading gear 7
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Fig.36
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-21
http://www.xiaoyu163.com
3.2.17 Removing the gears
(See Figs.37 to 40) QQ 376315150
(1) Pull out the feed gear.
Shafts rivet assembly
(2) Move the loading plate assembly in the direction of the arrow to release the L side plate from the two slots m' of the chassis rivet assembly. (See Fig.37.)
(3) Detach the loading plate assembly upward from the chassis rivet assembly while releasing the joint n' . Remove the slide hook and loading plate spring from the loading plate assembly.
(4) Pull out the loading gear 2 and remove the change lock lever.
(5) Remove the E ring and washer attaching the changer gear
2.
(6) The changer gear 2, change gear spring and adjusting washer come off.
(7) Remove the loading gear 1.
(8) Move the change plate rivet assembly in the direction of the arrow to release from the three shafts of the chassis rivet assembly upward. (See Fig.38.)
(9) Detach the loading gear plate rivet assembly from the shaft of the chassis rivet assembly upward while releasing the joint p'. (See Figs.38 and 40.)
(10) Pull out the loading gear 4.
E ring
Loading plate spring
9 Joint p' 2 4
Fig.38
Loading plate assembly
Loading gear plate rivet assembly
Chassis rivet assembly
Change gear 2
Joint n'
9 8 2
Loading gear 4
9 9
Shaft
Loading gear 2
Loading gear 1
Slide hook
Feed gear
L side plate
Loading plate assembly
Joint n'
Slot m'
Fig.37
Chassis rivet assembly
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 L side plate 8 2 9 9
Slot m'
Chassis rivet assembly
Fig.39
E ring
Washer
Change gear 2
Change gear spring
Adjusting washer
Loading gear 1
Loading gear 2
Change lock lever
Loading gear 4
Change plate rivet assembly
Chassis rivet assembly
Loading gear plate rivet assembly
Fig.40
www. xiaoyu163. com
1-22 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
3.2.18 Removing the turn table / spindle motor
(See Figs.41 and 42) QQ 376315150 sembly through the slot of the turn table on top of the body.
(2) Unsolder the wire on the connector board if necessary.
8 9 2 4 9 8 Turn table 2 9 9
L
Fig.41
L
Turn table
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Spindle motor
Fig.42
www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-23
http://www.xiaoyu163.com
4.1
Adjustment method
Test instruments required for adjustment
(1) Digital oscilloscope (100MHz)
(2) AM Standard signal generator
(3) FM Standard signal generator
(4) Stereo modulator
(5) Electric voltmeter
(6) Digital tester
(7) Tracking offset meter
(8) Test Disc JVC :CTS-1000
(9) Extension cable for check
EXTSH002-22P
×
1
Standard volume position
Balance and Bass &Treble volume : lndication"0"
Loudness : OFF
How to connect the extension cable for adjusting
SECTION 4
8 9 2
Standard measuring conditions
4 9 8 2 9 9
Power supply voltage DC14.4V(10.5 to 16V)
Load impedance 20K
Ω
(2 Speakers connection)
Output Level Line out 2.0V (Vol. MAX)
Dummy load
Exclusive dummy load should be used for AM,and FM. For FM dummy load,there is a loss of 6dB between SSG output and antenna input.The loss of 6dB need not be considered since direct reading of figures are applied in this working standard.
Caution:
Be sure to attach the heat sink and rear bracket onto the power amplifier IC and regulator IC respectively, before supply the power.
If voltage is applied without attaching these parts, the power amplifier IC and regulator IC will be destroyed by heat.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
Heat sink
Extension cable
EXTSH002-22P
Rear bracket www. xiaoyu163. com
1-24 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
5.1
Feed section
Is the voltage output at
IC541 pin 40 5v or 0V
YES
NO
SECTION 5
8 9 2 4 9 8 2 9 9
YES NO
Is the wiring for IC541 pin 40 correct?
NO
Is 5V present at IC501 pins 3,12 and 21?
YES
Check the vicinity of
IC541.
Check CD 8V.
YES
Is 6V or 2V present at
IC501 pins 4 and 5?
NO
Check the feed motor connection wiring.
Check IC501.
Is 4V present at both sides of the feed motor?
YES
NO
Check the feed motor.
5.2
Focus section
When the lens is moving:
NO Check the circuits in the vicinity of IC501 pins 8 and 9.
4V
Does the S-search waveform appear at
IC501 pins 8 and 9?
YES
YES Q Q
Is the disk rotated?
YES
Does the RF signal appear at IC521 pin 19?
NO
Is 4V present between
IC501 pins 6 and 7?
NO
YES
Check the spindle motor and its wiring.
YES
Is the RF waveform at IC521 pin 19 distorted?
YES
Proceed to the Tracking section
5.4
Tracking section
NO
NO
Check the circuits in the vicinity of IC521 pin 19 or the pickup.
Check the pickup and
3 7 1 5 0 8 9 2 4 9 8 2 9 9
Is 4V present at IC541 pin 41?
NO
YES
Check the vicinity of
IC501
Check IC541.
When the disc is rotated at first:
NO
Check the circuits in the vicinity of IC501 pins 2 to 11.
NO Check the pickup and its connections.
Approx. 1.2V
Is the tracking error signal output at
IC521 pin 11?
www. xiaoyu163. com
Check IC541.
(No.MA074)1-25 http://www.xiaoyu163.com
http://www.xiaoyu163.com
5.5
Signal processing section
Is the sound output from both channels (L, R)?
NO
Normal
YES
channel.
YES
Is 9V present at IC161 pin
31?
YES
Is the audio signal
(including sampling output components) output to
IC581 pins 1 and 7 during playback?
NO
NO
NO
8
R-ch to locate the defctive point.
Check the viciniyt of the
IC901 audio power supply.
8 2 9 9
Check IC581 and its peripheral circuits.
YES
Is the audio signal output at IC161 pins16 and 17 during playback?
YES
NO
Check the muting circuit.
Check IC161 and its peripheral circuits.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
1-26 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
5.6
Maintenance of laser pickup with a alcohol soaked cotton swab.
(2) Life of the laser diode
When the life of the laser diode has expired, the following symptoms will appear.
• The level of RF output (EFM output: amplitude of eye pattern) will be low.
5.7
Replacement of laser pickup
8 9 2 4 9 8 2 9
Replace the pickup with a normal one.(Refer to "Pickup Removal" on the previous page)
NO
Is RF output
1.0 0.35Vp-p?
Replace it.
YES
Plug the power cord in,and turn the power on.
At this time,check that the laser emits for about 3seconds and the objective lens moves up and down.
Note: Do not observe the laser beam directly.
O.K
(3) Semi-fixed resistor on the APC PC board
The semi-fixed resistor on the APC printed circuit board which is attached to the pickup is used to adjust the laser power.Since this adjustment should be performed to match the characteristics of the whole optical block, do not touch the semi-fixed resistor.
If the laser power is lower than the specified value, the laser diode is almost worn out, and the laser pickup should be replaced. If the semi-fixed resistor is adjusted while the pickup is functioning normally, the laser pickup may be damaged due to excessive current.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5
Play a disc.
Check the eye-pattern at TP1.
9 2 4 9 8 2 9 9
9 www. xiaoyu163. com http://www.xiaoyu163.com
(No.MA074)1-27
5.8
16 pin cord diagram
BK
7
6
RD
5
BL
BL/WH
YL 16
OR/WH 15
NC
NC
14
13
3
4
1
2
WH
GN
VI
GY
WH/BK 11
GN/BK 12
VI/BK 9
GY/BK 10 http://www.xiaoyu163.com
BK Black
RD
BL
Red
Blue
WH White
8 9 2 4 9 8 2 9 9
GN Green
VI Violet
GY Gray
YL Yellow
OR Orange
-
+
-
+
-
+
2 GY
FR
10
FR
1 VI
RR
9 VI/BK
RR
4 GN
RL
12 GN/BK
RL
RR
FR
FL
RL
Rear Right
Front Right
Front Left
Rear Left
REMOTE Remote
15 OR/WH
ILL
7 RD
ACC
Q Q
16 YL
MEMORY
5
3 8 7
BL/WH
6 3 1 5 1 5 0
REMOTE
6 BL
ANT
FL
3 WH
11
FL
WH/BK
+
-
8 9 2 4 9 8 2 9 9
ANT Auto Antenna
ACC
ILL
ACC Line
Illuminations Control
GND
Ground
MEMORY Memory Backup Battery+ www. xiaoyu163. com
1-28 (No.MA074) http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
VICTOR COMPANY OF JAPAN, LIMITED
AV & MULTIMEDIA COMPANY MOBILE ENTERTAINMENT CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MA074) http://www.xiaoyu163.com
Printed in Japan
WPC
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
SCHEMATIC DIAGRAMS
CD RECEIVER
KD-AR400,KD-G400
CD-ROM No.SML200401
Area suffix
J -------------- Northern America
TEL 13942296513
S
Q Q
KD-AR400
3 7 6 3 1 5 1 5 8 9 2 4 9 8 2 9 9
KD-G400
KD-G400
S
LINE OUT FRONT
ARSENAL rogo
KD-AR400J KD-G400J
Contents
Block diagram
Standard schematic diagrams
Printed circuit boards
2-1
2-
3
2-
9
to
11 www. xiaoyu163. com
COPYRIGHT 2004 VICTOR COMPANY OF JAPAN, LTD.
http://www.xiaoyu163.com
No.MA074SCH
2004/1
http://www.xiaoyu163.com
Safety precaution
QQ 376315150
!
8 9 2 4 9
Burrs formed during molding may be left over on some parts of the chassis. Therefore,
8
pay attention to such burrs in the case of preforming repair of this system.
2 9 9
!
Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
< M E M O >
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
Block diagram
QQ 376315150 8 9 2 4 9 8 2 9 9
J1
ANT
SW1,SW2,PSW
POSITION SET
SWITCH
PSW
LOAD&FEED
MOTOR
FEED+
FEED-
SPINDLE+
SPINDLE-
FEED+
FEED-
TRACKING+
TRACKING-
FOCUS+
FOCUS-
SPINDLE
MOTOR
SPINDLE+
SPINDLE-
SW1, SW2
SW1, SW2
VF1,VF2
VT1,VT2
LD,MD TEL 13942296513
TRACKING-
FOCUS+
FOCUS-
PICK UP
VF1,VF2,
VT1,VT2,
MD,LD
LM0
LM1
IC501
CD
DRIVER
DMO,FMO
TRO,FOO
IC541
DSP
BCK
LRCK
BUS0 to BUS3
BUCK,CCE
RST
Q Q
RFGC,RF
RFRP,RFDC
TEB,SEL
TE,FE
BUCK
LRCK
AOUT
CDRW
IC521
RF AMP
3 7 6 3 1 5 1 5 0
DAC-CDTI
DAC-CCLK 8 9
DAC-PDN
9 8 2 9 9
IC481
DAC
IC602
REMOCON
REMOCON
S601 to S617
KEY MATRIX
KEY0
KEY1
KEY2
KEY0
KEY1
KEY2
LCDCL
LCDDA
LCDCE
REMOCON
ENC1
ENC2
BCK
LRCK
AOUT
IC401
MP3/WMA LSI
& INT.SRAM
M
M
M
M
M
M
LCD1
ENC1
ENC2
EN601
ENCODER COM1
COM2
COM3
S1 to S52
IC601
LCD
DRIVER
LCDCL
LCDDA
LCDCE
2-1 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150
J1
ANT
TU1
FM/AM
L-CH
R-CH
TUNER
IC161
E.VOLUME
IC31
PLL
PLLCE
PLLDA
PLLCL
PLLDI
FM/AM OSC
FM VT
AM VT
SD/ST
MONO
SM,FM/AM
SEEK/STOP
CD.L
CD.R
VOLDA
VOLCL
SDA
SCL IC771
EPROM IC701
CPU
OUTLF
OUTLR
OUTRF
OUTRR
8 9 2 4 9 8 2 9 9
Only used for
KD-AR400J
FRONT L
FRONT R
REAR L
REAR R
IC901
IC301
POWER
AMP.
REGULATOR
FRONT LEFT (+)
FRONT LEFT (-)
FRONT RIGHT (+)
FRONT RIGHT (-)
REAR LEFT (+)
REAR LEFT (-)
REAR RIGHT (+)
REAR RIGHT (-)
J321
LINE OUT
EACH BLOCK
RESET IC702
RESET
CN901
TEL 13942296513
AOUTL +
AOUTL -
AOUTR +
AOUTR IC581
CD L.P.F.
Q Q
MP3STBY
MP3CLK
MP3DOUT
MP3RESET
MP3REQ
MP3DIN
SI,SO,I/O
INT,SCK
CH.SCK
SO
IC801
JVC BUS
3 7
CH.L
CH.R
6 3
SPK
BATTERY
1 5 1 5 0
CD CHANGER
CONTROL
8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
2-2
2-3 http://www.xiaoyu163.com
Standard schematic diagrams
QQ 376315150
QAU0311-001
TU1
8 9 2 4 9 8 2 9 9
J1
R793
0
L1
4.7u
AM.ANT
FM.ANT
TUN.R
TUN.L
MUTE.DR
C81
C91
1/50
1/50
R81
R91
TU.L
C8
D1 D2
Q1
2SD601A/R/-X
CH.L
C39
1000P
C173
1/50
C172 1/50
C171 1/50
FM/AM.VT
AM.VCC
CD.L
R5
47k
FM.VCC
IC31
TB2118F-X
C38
0.001
PLLCE
PLLDA
PLLCL
PLLDT
RA30
2.2K
C46
C47
R43
470
C32
47P
0.01
0.01
10
R44
220
C50
100P
C49
0.001
FM/AM
Q6
2SB624/4/-X
R7
4.7k
R6
47k
Q7
UN2211-X
SD/ST
R13
47K
R4
3.3k
R10
10K
CD.R
TU.R
CH.R
C161 1/50
C162 1/50
C163
1/50
C191
47/16
C19
100/16
R32
6.2k
C34
0.047
C33
47/6.3
Q31 UN2211-X 9V
SW5V
CD.R
CD.L
A-GND
PSW
SW1
SW2
LM0
LM1
BUS0
(SHEET 2)
BUS3
BUCK
CCE
RST
8V
MP3REQ
MP3RESET
MP3STBY
MP3DIN
MP3DOUT
MP3CLK
DAC-CDTI
DAC-CCLK
DAC-CSN
DAC-PDN
CDON
CDRW
VDD5V
Q Q
C720 0.22
R758
47k
S701
QSW0451-001
C247 0.01
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
CDON
IC701
UPD784217AGC238
VSS
REMOCON
DIM.OUT
R720
R719
1.2k
0
C706
0.1
VDD
To CN601
(SHEET 3)
ENC1
ENC2
LCDCE
LCDDA
LCDCL
KEY2
KEY1
KEY0
LEDB
LEDR
DIMOUT
CN701
QNZ0605-001
CH.R
CH.L
R805
100k
R803
100
R806 10k
D715
D716
D717
R709
10K
MA8062/M/-X
VOLDA
VOLCL
R762
R761
R774
R773
BUCK
CCE
BUS0
BUS1
BUS2
BUS3
R760
R759
R716
R715
R717
R714
R713
R712
R711
R710
CDRW R708
47k
820
820
100
10k
820
820
820
820
3.3k
VPP R778
R777
R704
R705
47k
47k
SCK
SI
R808
330
SO
SI
SO
I/O
R807
100k
INT
SCK
C802
X1
R810
100
120P
R801
J801
CH.SCK
QNZ0095-001
IC801
HD74HC126FP-X
C801
0.047
47k
C726
0.0039
X701 X702 www. xiaoyu163. com
QAX0617-001Z QAX0401-001
REMOCON
R729
47k
RESET
RESET
R764
100
D714
OPEN
EPROMCK
EPROMDA
R706
R707
R734
R735
R736
R737
R738
R739
R740
R741
R779
10k
47K
R743
R744
10k
10k
R745
R746
10k
10k
R775 47K
R776 47K
C724
QSW
S703
4
C
0.
http://www.xiaoyu163.com
http://www.xiaoyu163.com
C181
0.1
R172
22k
C174
0.0082
RB160M-30-X
D243
C243
0.047
R244
12k
Q241
2SD601A/R/-X
C241
1/50
R241
47k
R161
220k
D240
MA111-X
2.2k
R173
R171
220k
MA111-X
D241
C178
0.0056
C175
0.22
C176
0.22
C177
0.033
C179
4.7/25
C180
R181
4.7/25
270
LEVEL
OUTLF
OUTLR
8
C312
0.47
C311
0.47
9
IC301
LA47515
27k
R312
R311
27k
2 4 9 8 2 9 9
VOLDA
C191
7/16
C192
100/16
C164
0.0082
R162
22k
C166
0.22
C165
0.22
C167
0.033
R163
2.2k
C168
0.0056
C194
0.01
C193
100/16
IC161
TEA6320T-X
C170
C169
R182
270
4.7/25
4.7/25
VOLCL
OUTRR
OUTRF
C302
0.47
D351
MA111-X R351
2.2k
R341
R342
R352
820
820
D341
MA111-X
2.2k
R302
27k
D321
MA111-X
R321
2.2k
R331
D331
MA111-X
2.2k
R322 820
R332 820
C316
4.7/25
0.1
0.1
0.1
C322
C323
C324
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
RB160M-30-X
0.1
C325
D991
D992
D993
D994
D995
D996
D997
D998
100P
100P
100P
100P
100P
100P
100P
100P
D901
1N5401-TU-15
C961
C962
C963
C964
C965
C966
C967
C968
D782
MA111-X
TEL 13942296513
L701
4.7u
VDD IC771
BR24L16F-W-X C782
0.1
C711
220/10
R782
47K
R783
10k
D902
MA111-X C719
100/6.3
C781
C728
C729 0.01
D781
MA111-X
C771
0.047
C723 0.047
OPEN
EPROMCK
EPROMDA
R734
R735
R736
R737
R738
R739
R740
R706
R707
R741
R779
10k
47K
R731
47k
R730
10k
S702
QSW0451-001
R732
10K
2.2k
2.2k
2.2k
LCDCE
LCDCL
LCDDA
47
4.7k
4.7k
4.7k
I/O
SCK
SO
SI
TD
RD
C707
0.047
150k
150k
LEDB
LEDR
SM
LEVEL
R775
R776
R743
R744
10k
10k
R745
R746
10k
10k
47K
47K
KEY2
KEY1
KEY0
4.7k
ENC2
R747
4.7k
R748
4.7k
R749
R811
TELMUTE
Q891
UN2211-X
C891
0.1
R891
1k
R881
47k
Q881
UN2211-X
R882
4.7k
Q977
2SB709A/QR/-X
R977 12k
Q
R976
Q
HA13164A IC901
3 7 6 3
R901
1 1k
C902
2.2/50
5 1 5 0
RB160M-30-X
D851
ANT
D852
RB160M-30-X
C914
100/16
Q784
UN2111-X
J321
C901
3300/16
8 9 2
RB160M-30-X
4 9 8 2 9 9
D971
RB160M-30-X
CN901
QNZ0611-001
R764
100
C724 0.047
QSW1049-001Z
S703
D714 UDZS5.6B-X
C730
C731
C732
C741
0.01
0.01
0.01
0.01
IC702
IC-PST3433U-X www. xiaoyu163. com
47/6.3
Parts are safety assurance parts.
When replacing those parts make sure to use the specified one.
SHEET 1
2-4 http://www.xiaoyu163.com
CD servo section
http://www.xiaoyu163.com
FEED-
VF2
FEED+
VCC
GND
VT2
SW1
VT1
SW2
VF1
PSW
VR
SPINDLE-
LD
SPINDLE+
FOCUS-
VREF
FOCUS+
MD
TRACKING+
TRACKING-
FEED-
VF2
FEED+
VCC
SPINDLE-
LD
SPINDLE+
FOCUS-
VREF
FOCUS+
MD
TRACKING+
TRACKING-
VT2
SW1
VT1
SW2
VF1
PSW
VR
R539
150
VREF
C533
0.01
LM1
C515
0.01
8
R511 1.5k
1.5k
R512
2
C513
0.01
R518
8.2K
5.1K
9 8
C508
0.1
2
47/10
C501
9 9
Q501
2SB1322/RS/-T
C
AOUTR-
AOUTR+
C
C
AOUTL+
C
AOUTL-
Q50
2SB1132/Q
R516
330
R534
15k
C532
68P
R533
1k
R532 R531 R535
2k 10k 100
C531
C534
5p
0.1
RF
C530 0.1
C502
0.01
C529
100/10
C528
C503
100/10
0.01
R504
15k
DMO
R502
8.2k
FOO
R501
FMO
33k TRO
VREF
R538
33K
R537
0
CDRW
L54
2-5
TEL 13942296513
C527
R523 VF1
R524 VF2
C521
0.01
VCC
Q R525
R526
82k
3 82k
330k
330k
7 6 3 1 5 1 5 0
C525
0.0068
100/10
R529 R536
82k 8 9 820 2 4 9 8 2 9 9
RA5
10K
Q541
UN2111-X L543
C522
0.01
C523
100/10
R527
R528
22
22
47u
C524
0.01
Q542
Q521
2SB1241/QR/-T
IC461
NJU7772F15-X
R461 100
R462 100
VDD5V
R415
47K
2.2K
Q401
2SB624/4/-X
R416
Q402
UN2211-X
C461
0.1
C462
100/6.3
C463
100/6.3
L402
47u
L404
47u
C411
C412
100/10
0.01
C420
C418 0.01
R405
2.2K
12P
C419
12P
C413
0.1
X401
QAX0760-001Z
R424
220
C414
0.0022
IC401
TC94A34FG-002
C404
0.01
R423
10K
R433
100
C405
1/50
R406 47 http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150
R581 8.2k
R584 180
R586
R585
6.8k
180
C581
3300P
C580 4.7/25
OUTR-
OUTR+
C589 4.7/25
R582 8.2k
R583 8.2k
R593
R594
8.2k
180 C599 4.7/25
OUTL+
C590
OUTL-
Q502
2SB1132/QR/-W
4.7/25
R592 8.2k
R591 8.2k
C591
3300P
C583 C593
270P 270P
R595
R596
180
6.8k
C592
270P
C582
270P
IC581
NJM4565M-WE
8 9
CD.R
2 4 9 8 2 9 9
CD.L
R516
330
C597
0.01
C512
47/16
C596
100/10
C598
0.01
L541 47u
Q541
UN2111-X
RA550
10K
L543
47u
Q542
C568
0.1
C570
47/6.3
0.01
C571
BUS0
BUS1
BUCK
CCE
RST
R558
10k
C541
CDON 100/10 C542
0.01
C543
1/50 C545
0.01
C544
100/10
R548
R547
R546
C559
C558
C557
C556
0.047
0.047
470P
470P
47
47
47
SEL
TEB
RFGC
IC541
TC94A14FA
C552 0.033
R541
5.6k
TE
RFDC
FE
RFRP C551
R545
10k
C550 0.01
C549 0.0027
0.033
C548
R559
C547 Q Q R544
10K
R543
470k
1.5M
0.01
C572
100/10
RF
3 7 6 3 1 5 1 5 0
C546
47P
9V
SW5V
CD.R
CD.L
PSW
SW1
SW2
LM0
LM1
BUS0
BUS1
BUS2
BUS3
BUCK
CCE
RST
8V
(SHEET 1)
MP3REQ
8 9 2 4 9 MP3RESET
MP3STBY
MP3DIN
MP3DOUT
MP3CLK
DAC-CDTI
2 9 9
DAC-CCLK
DAC-CSN
DAC-PDN
CDON
CDRW
C482
0.1
C481
47/16
Q543
UN2111-X
IC481
AK4385VT-X
R451
47k
22k
R453
4.7k
2.2k
R455
4.7k
2.2k
R457
2.2k
4.7k
C440
0.01
R440
4.7K
C430
0.01
R430
4.7K
C431
100P
R431
10K
R432
6.8K
C483
0.1
www. xiaoyu163. com
R407
R409
R408
2.2K
2.2K
2.2K
http://www.xiaoyu163.com
SHEET 2
2-6
http://www.xiaoyu163.com
LCD & Key control section
QQ 376315150 8 9 2 4 9 8 2 9 9
LCD1
TEL 13942296513
R606
3.9K
R605
2.7K
R604
1.8K
R603
1.2K
R602
820
R601
820
S607 S606 S605 S604 S603 S602 S601
KEY2
R612
3.9K
R611
2.7K
R610
1.8K
R609
1.2K
R608
820
R607
820
S614 S613 S612 S611 S610 S609 S608
KEY1
R614
820
R613
820
S617 S616 S615
KEY0
Q Q 3 7 6 3 1 5 1 5 0
D601 D602 D603
D604
D605
D606
D607
D608
D609
D610
D611
D612
D613
D614
D615
D616
D617
D618
D620
D621
D619
8 9 2 4 9 8 2 9 9
R6
470
R6
470
2-7 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
IC602
RPM7338-V4
EN601
QSW0793-001
TEL 13942296513
R672
470
R671
470
R653
10k
S49
S50
S51
S52
COM1
COM2
COM3
VDD
INH
R658
180k
D642
MA111-X
LCDCE
LCDCL
LCDDA
R654
R655
R656
10k
10k
10k
C602
680p
R657
51k
OSC
CE
CLK
DATA
C601
0.022
C603
10/6.3
R682 47K
R683 47K
IC601
LC75823W
Q Q
CN601
NNZ0087-001
S25
S24
S23
S22
S21
S20
S19
S18
S17
S32
S31
S30
S29
S28
S27
S26
REMOCON
ACC5V
10V
ENC1
ENC2
LCDCE
LCDDA
LCDCL
KEY2
KEY1
3 7 6 3 1 5 1 5
0
KEY0 0
GND
To CN701
(SHEET 1)
8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
SHEET 3
2-8
http://www.xiaoyu163.com
Printed circuit boards
QQ 376315150 8 9 2 4 9 8 2 9 9
Forward side
C910
IC901
C308
C901
C318
CN901
D996
D995
C966
C965
C187
C961
C962
C963
C964
R311
R312
R302
R301
D991
D992
D993
D994
D998
D997
C968
C967
C891
Q891
R901
Q881
R892
R891
R881
D781
C781
L901
D901
C902
Q976
C909
C908
C312
C302
C311
C301
R905
Q901
C905
C192
C191
J321
J801
C163
Q331
R1
C161
C189
C31
Q321
R40
R41
C44
R39
C38
R38
Q31
C50
C9
Q351
Q341
C735
L1
TU1
J1
S701
C307
R536
R529
R528
R527
C555
C554
C553
L541
C315
D782 C784
C512
Q502
C172 C40
C317 C503
C41 C48
IC161
C506
R516
Q Q 3 7 6
C241
3 1 5 1 5
IC31
0
R545
R532
R535
C530 C531
R530
C552
IC541
C527
C549
R558
R541
RA550
R534
C532
C572
C542
C541
Q543
L402
C481
C482
IC481
Q430
Q541
Q542
CN701
R408
R409
R407
C422
R519
C593
R406
R440
R430
R581
R594
IC401
R452
Q440
R586
C582
IC501
C515
C585
C592
R596
C413
C414
C405
R704
R705
R716
R715
R717
L702
R710
R243
R245
R242
R241
R712
Q241
R711
R248
D244
R708
R702
C598
C596
X701
X702
C416 R757
R756
C709
IC701
C411
C463
IC461
IC702
R743
R744
R745
C462
C407
L401
R768
L404
R751
R750
R746
R734
R736
R735
R706
R707
R709
R806
R803
IC801
C711
R729
R747
R748
R749
R720
R719
RA30
R772
S703
R42
R726
R728
IC771
C725
C34
8 9 2 4 9 8 2 9 9
S702
2-9 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
Main board
QQ 376315150 8 9 2 4 9 8 2 9 9
Reverse side
J1 CN901
C901
J321
C910
B902
R793
C8
C11
C10
R11
C720
C6
C341
D361
R343
R342
TU1
C39
C2
C51
R730
IC901 C911
Q902 J801
C905
R353
R352
C802
C906
C908 C902
D901
R901
D971
C327
C318
C308 C319
C163
R323
R322
R977
C781
R333
R332
C737
S702
C736
C185
C161
R5
C47
C42
C46
Q6
C45
C40
C31
C186
C36
C172
D243
C241
C191
C192
C712 C183
Q7
R182
R714
R181
R81
R82
C82
Q1
R91
C727
C92
R92
Q10 B905
X701
R53
R51
R52
R752
R753
C707
R773
R759
R454
R456
R458
R811
R754
Q
R462
C462
R461
C463
Q
C596
R161
R162 R163
R172 R173
C416
C405
C418
C503
C585
3 7
C509
6 3
C415
C423
C461
C184
C909
C411
C464
C782
C852
D852
R851
D784
Q784
C311
C301
C312
C302
C512
C784
C785
R593
R591
R405
R410
C421
C407
5 R724 1
C404
R402
R401
C422
5
C505
C556
C557
C572
C541
Q782
C315
C528
C733
CN501
C504
C317
C307
C320
IC301
8 9 2 4 9 8
R549
R550
C558
C559
R551
R552
C571
C562
C731
C730
2 9 9
Q401
R415
CN701 S701
D714
S703 www. xiaoyu163. com http://www.xiaoyu163.com
2-10
http://www.xiaoyu163.com
Front board
QQ 376315150
Forward side
D607
D603
D604
D605
R601
R602
S608
D606
S617
S616
TEL 13942296513
8 9 2
R611
R610
R661
R660
Reverse side
R635
R634
4 9 8 2 9
R636
R637
D642
R658
R648
R649
R645
R644
R632
R633
R643
R642
R671
R672
Q640
R673
R674
Q641
Q Q 3 7 6 3
R638
R639
5 1 5 0
C602
R657
8 9 2 4 9 8 2 9 9
D641
9
D643
C611
R631
S613
S614
D617
2-11 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
< M E M O >
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150 8 9 2 4 9 8 2 9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 www. xiaoyu163. com
VICTOR COMPANY OF JAPAN, LIMITED
AV & MULTIMEDIA COMPANY MOBILE ENTERTAINMENT CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MA074SCH) http://www.xiaoyu163.com
Printed in Japan
WPC
http://www.xiaoyu163.com
8 9 2 4 9 8 2 9 9
[ KD-G400 ]
[ KD-AR400 ]
* All printed circuit boards and its assemblies are not available as service parts.
Area suffix
J -------------- Northern America
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
- Contents -
Exploded view of general assembly and parts list (Block No.M1)
CD mechanism assembly and parts list (Block No.MB)
Electrical parts list (Block No.01,02)
Packing materials and accessories parts list (Block No.M3)
3- 2
3- 4
3- 6
3-11 www. xiaoyu163. com
No. MA074 http://www.xiaoyu163.com
3-1
http://www.xiaoyu163.com
Exploded view of general assembly and parts list
QQ 376315150 8 9 2 4 9
M 1
8
M
9 9
TEL 13942296513 Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
3-2 www. xiaoyu163. com http://www.xiaoyu163.com
http://www.xiaoyu163.com
General assembly
QQ 376315150
Symbol No.
Part No.
21
22
23
24
17
18
19
20
25
26
27
28
29
30
13
14
15
16
9
10
11
12
5
6
7
8
1
2
3
4
GE10043-210A
GE40135-001A
GE30938-003A
GE30393-002A
FSMA3005-001
QYSDST2604Z
FSKZ4005-001
QYSDST2606Z
QYSDST2604Z
QYSDST2610Z
QYSDSF2006M
GE30823-001A
QYSDST2004M
FSYH4036-098
GE30827-002A
GE30824-002A
GE31245-001A
GE30829-001A
GE30825-002A
GE30828-002A
GE40154-001A
QZW0108-002
GE40153-001A
GE40157-001A
VKW5264-005
FSKW4012-002
VKW5263-002
GE40155-001A
QYSDSF2006M
GE40156-001A
Part Name
TOP CHASSIS
EARTH PLATE
SIDE PANEL
BOTTOM COVER
INSULATOR
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
F. CHASSIS ASSY
MINI SCREW
SHEET
OPEN LEVER
LOCK LEVER(O.L)
RELEASE LEVER
LOCK LEVER(TOP)
LOCK LEVER(L)
LOCK LEVER(R)
GEAR
OIL DAMPER
T.SPRING
T.SPRING
T.SPRING
T.SPRING
T.SPRING
T.SPRING
SCREW
BLIND
Description Local
2.6mm x 4mm(x3)
(x2)
2.6mm x 6mm(x2)
2.6mm x 4mm(x3)
2.6mm x 10mm
2mm x 6mm(x2)
2mm x 4mm(x2)
2mm x 6mm
58
64
65
66
67
58
59
60
61
62
63
68
69
70
71
Symbol No.
8 9
GE31118-002A
GE31115-002A
QLD0297-001
QNZ0442-001
QMFZ047-150-T
GE30912-006A
QYSDST2606Z
FSKZ4005-001
QYSDST2606Z
QYSDSF2606Z
QYSDSF2606Z
GE40172-004A
GE40124-002A
GE30854-001A
FSYH4036-053
2 4 9
NAME PLATE
NAME PLATE
LCD MODULE
LCD CONNECTOR
FUSE
REAR BRACKET
SCREW
SCREW
SCREW
SCREW
SCREW
IC BRACKET
REG BRACKET
LED HOLDER
SHEET
8 2 9 9
AR40
0J
G400J
15A
2.6mm x 6mm
2.6mm x 6mm
2.6mm x 6mm(x2)
2.6mm x 6mm
31
32
GE10080-003A
GE10080-002A
GE31048-004A
FRONT PANEL
FRONT PANEL
FINDER ASSY
AR40
0J
G400J
AR40
0J
Q
G400J
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
32
33
34
35
GE31048-002A
GE31044-001A
GE31038-001A
GE40218-002A
FINDER ASSY
POWER BUTTON
VOLUME KNOB
SHEET
36 GE31039-004A SEL BUTTON
AR40
0J
G400J 36
37
38
GE31039-003A
GE31040-001A
FSYH4036-069
SEL BUTTON
RIM LENS
SHEET
39
39
40
40
41
GE31181-002A
GE31029-001A
GE20161-002A
GE20161-001A
GE31043-003A
D.FUNC BTN
D.FUNC BTN
PRESET BUTTON
PRESET BUTTON
UP/DOWN BTN
AR40
0J
G400J
AR40
0J
G400J
AR40
0J
G400J 41
42
GE31043-001A
GE31028-003A
UP/DOWN BTN
SSM BTN
43
43
44
GE31025-002A
GE31025-001A
GE31041-003A
SEARCH BTN
SEARCH BTN
EJECT BUTTON
AR40
0J
G400J
AR40
0J
G400J 44
45
46
GE31041-002A
GE31250-001A
GE40220-001A
EJECT BUTTON
EJECT COVER
LIGHT SHIELD
47 GE31042-003A DETACH BUTTON
GE31042-002A
GE31045-001A
GE40204-001A
VKW3001-330
GE40202-004A
DETACH BUTTON
RIM COVER
JVC BADGE
COMP.SPRING
COMP.SPRING
AR40
0J
G400J 47
48
49
50
51
52
53
54
55
57
GE10081-001A
VKZ4777-001
GE31035-001A
GE31036-001A
GE40200-003A
REAR COVER
MINI SCREW
LCD CASE
LCD LENS
(x4) www. xiaoyu163. com
56 GE31037-001A LENS CASE
LIGHTING SHEET
3-3 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-4
CD mechanism assembly and parts list
QQ 376315150
TNG-87 TN-2001-1011
GP-501MK
CFD-005Z
GP-501A
111
34
74
72
35
26
33
8 9 2
2
4
M
9
B M
2 9
31
111
C
36
22
29
116
19
112
B
61
21
24
62
TEL 13942296513
D 75
112
11
114
25
76
93
122
100
101
94
38
95
14
100
96
123
97
32 a
113
D
73
85
15
37
111
89
A
23 38
13
Q
A
Q
30
3 7 6 3 1 5 1 5 0
27
8 9 2 4 9 8 2 9 9
99
28
115
90
C
B
92
18
20
87
82
125
88
12
86
83
121
16
17
124
83
98
4
94
91
111
81
84
93 1
73
74
75
77
3
111
71
3
111
9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
CD mechanism
QQ 376315150
Symbol No.
Part No.
Part Name Description Local
21
22
23
24
17
18
19
20
13
14
15
16
1
2
3
4
11
12
30320101T
30320102T
30320115T
30320116T
303205505T
303205503T
303205301T
303205302T
30320502T
30320503T
30320505T
30320506T
30320507T
30320509T
30320510T
30320511T
30320513T
30320514T
FRAME
TOP COVER
DANPER F
DANPER R
CHASSIS RIVET
CHANGE P. RVT A
CLAMPER ASS'Y
SPINDLE MOTOR A
CLAMPER ARM
CHANGE GEAR SPG
CHANGE GEAR 2
FEED GEAR
FEED RACK
CHANGE LOCK RAR
FEED SW HOLDER
PU SHAFT HOLDER
CLAMPER SUB SPG
FD SUB HOLDER
29
30
31
32
25
26
27
28
30320518T
30320519T
30320520T
30320521T
30320522T
30320525T
30320526T
30320538T
TOP PLATE
SELECT LOCK ARM
TRIGGER ARM
SLIDE HOOK
PU SHAFT
CLAMPER ARM SPG
SELECT L ARM SP
SUSPENSION SP R
71
72
73
74
33
34
30320529T
30320530T
SELECT ARM R
LINK PLATE
35
36
37
30320531T
30320523T
30320524T
LINK PLATE SPG
CUSHION F
CUSHION R
38
61
62
30320539T
69011614T
64180406T
SUSPENSION SP L
PICKUP OPT-725
DET SW ESE22
303210301T
30321002T
30321003T
30321005T
CONN PWB ASS'Y
MODE SW
LOAD MOTOR WIRE
MODE SW WIRE
90
91
92
93
94
95
96
97
98
99
100
101
75
76
77
81
82
83
84
85
86
87
88
89
30321009T
30321011T
19501403T
303211301T
303211501T
303211302T
303211502T
303211303T
30321101T
30321102T
30321103T
30321104T
30321105T
30321106T
30321107T
30321111T
30321114T
30321116T
30321117T
30321118T
30321125T
30321131T
30321133T
18211223T
111
112
113
114
115
9P0420031T
9P0420041T
9B0320041T
9C0117183T
9C0120203T
SCREW
TAP.SCREW
SCREW
SCREW
SCREW
116 9C0317503T SCREW
121
122
123
9W0130170T
9W0513060T
9W0710070T
PW 3.5X8X0.3
HL WASHER
L WASHER
124
125
9E0100152T
9W0113020T
E RING
PW 2.1X4X0.13
SL WIRE
WIRE HOLDER
WIRE CLUMPER
ROLLER SHAFT AS
L GEAR PLATE RV
LOADING PLATE A
LOCK ARM RV ASS
L/F MOTOR ASS'Y
LOADING GEAR 1
LOADING GEAR 2
LOADING GEAR 3
LOADING GEAR 4
LOADING GEAR 5
LOADING GEAR 6
LOADING GEAR 7
ROLLER GUIDE
ROLLER GUIDE SP
DISC STOPPER AR
DISC ST ARM SPG
LD GEAR BRACKET
L SIDE PLATE
LOAD PLATE SPG
LDG ROLLER
COLLAR SCREW
8 9 2 4 9 8 2 9
Q Q 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
9
3-5 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-6
D1
D2
D4
D5
D240
D241
D242
D243
D244
D321
Electrical parts list
QQ 376315150
Block No. [0][1][0][0] Symbol No.
Part No.
8 9 2
Part Name
4 9 8 2 9
Description Local
9
Symbol No.
Part No.
Part Name Description Local
1.5k
Ω
1/10W J
IC31
IC161
IC301
IC401
IC461
IC481
IC501
IC521
IC541
IC581
IC701
IC702
IC771
IC801
IC901
TB2118F-X
TEA6320T-X
LA47515
TC94A34FG-002
NJU7772F15-X
AK4385VT-X
LA6242H-X
TA2157FN-X
TC94A14FA
NJM4565M-WE
UPD784217AGC238 IC
IC-PST3433U-X IC
BR24L16F-W-X
HD74HC126FP-X
HA13164A
IC
IC
IC
PLL IC
IC
IC
IC
IC
IC
BTL DRIVER IC
RF AMP IC
CD LSI IC
IC
D714
D715
D716
D717
D718
D781
D782
D784
D901
D902
D971
D972
UDZS5.6B-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
MA8062/M/-X
MA111-X
MA111-X
UDZS11B-X
1N5401-TU-15
MA111-X
RB160M-30-X
RB160M-30-X
Z DIODE
LED
LED
LED
Z DIODE
SI DIODE
SI DIODE
Z DIODE
DIODE
SI DIODE
SB DIODE
SB DIODE
Q1
Q5
Q6
Q7
Q10
Q31
Q241
Q321
2SD601A/R/-X
2SB709A/R/-X
2SB624/4/-X
UN2211-X
UN2211-X
UN2211-X
2SD601A/R/-X
2SD1781K/QR/-X
Q331 2SD1781K/QR/-X TRANSISTOR
Q341 2SD1781K/QR/-X TRANSISTOR
Q351 2SD1781K/QR/-X TRANSISTOR
Q401
Q402
Q430
2SB624/4/-X
UN2211-X
2SD601A/QR/-X
TRANSISTOR
TRANSISTOR
Q440
Q501
UN2211-X
2SB1322/RS/-T
TRANSISTOR
TRANSISTOR
Q502
Q521
Q541
Q542
Q543
Q781
Q782
Q784
Q881
Q976
Q977
2SB1132/QR/-W
2SB1241/QR/-T
UN2111-X
UN2211-X
UN2111-X
UN2111-X
UN2211-X
UN2111-X
UN2211-X
UN2211-X
2SB709A/QR/-X
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
MA111-X
RB160M-30-X
UDZS5.1B-X
MA111-X
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SI DIODE
SB DIODE
Z DIODE
SI DIODE
D331 MA111-X SI DIODE
D341
D351
D361
D701
D702
MA111-X
MA111-X
UDZS11B-X
MA8062/M/-X
MA8062/M/-X
SI DIODE
SI DIODE
Z DIODE
Z DIODE
Z DIODE
D703
D704
MA8062/M/-X
MA8062/M/-X
Z DIODE
Z DIODE
D705
D706
D707
D708
MA8062/M/-X
MA8062/M/-X
MA8062/M/-X
MA8062/M/-X
Z DIODE
Z DIODE
Z DIODE
D709 MA8062/M/-X Z DIODE
D713 MA111-X SI DIODE
AR40
0J
AR40
0J
AR40
0J
AR40
0J
Q
C40
Q
C43
C44
C10
C11
C31
C32
C33
C34
C35
C36
C1
C2
C3
C4
C5
C6
C9
C37
C38
C39
C164
C165
C166
C167
C168
C169
C170
C171
C172
C173
C174
C175
C45
C46
C47
C48
C49
C50
C51
C81
C82
C84
C91
C92
C94
C161
C162
C163
C176
C177
C178
C179
C180
C191
C192
C193
C194
C241
QEKJ1CM-226Z
NCB31EK-473X
QEKJ1CM-226Z
QEKJ1AM-227Z
QEKJ1HM-104Z
NCB31HK-103X
QEKJ1AM-227Z
NCB31HK-103X
NCB31HK-103X
QEKJ1AM-107Z
NDC31HJ-470X
QEKJ0JM-476Z
NCB31EK-473X
NDC31HJ-100X
NDC31HJ-7R0X
NDC31HJ-100X
NCB31HK-102X
NCB31HK-102X
E CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
22uF 16V M
0.047uF 25V K
22uF 16V M
220uF 10V M
0.1uF 50V M
0.01uF 50V K
220uF 10V M
0.01uF 50V K
0.01uF 50V K
100uF 10V M
47pF 50V J
47uF 6.3V M
0.047uF 25V K
10pF 50V J
7pF 50V J
10pF 50V J
1000pF 50V K
1000pF 50V K
3 QEKJ1CM-106Z 7 1
QFV61HJ-473Z
E CAPACITOR 5 1 5 0
MF CAPACITOR
8 9 10uF 16V M 2 4
0.047uF 50V J
8
NCB31HK-103X C CAPACITOR 0.01uF 50V K
2 9 9
NCB31HK-272X
NCB31HK-103X
NCB31HK-103X
NCB31EK-473X
NCB31HK-102X
NDC31HJ-101X
NCB31HK-103X
QEKJ1HM-105Z
NCB31HK-472X
NCB31EK-273X
QEKJ1HM-105Z
NCB31HK-472X
NCB31EK-273X
QEKJ1HM-105Z
QEKJ1HM-105Z
QEKJ1HM-105Z
NCB31HK-822X
NCB31CK-224X
NCB21CK-224X
NCB31EK-333X
NCB31HK-562X
QEKJ1EM-475Z
QEKJ1EM-475Z
QEKJ1HM-105Z
QEKJ1HM-105Z
QEKJ1HM-105Z
NCB31HK-822X
NCB31CK-224X
NCB21CK-224X
NCB31EK-333X
NCB31HK-562X
QEKJ1EM-475Z
QEKJ1EM-475Z
QEKJ1CM-476Z
QEKJ1CM-107Z
QEKJ1CM-107Z
NCB31EK-103X
QEKJ1HM-105Z
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
2700pF 50V K
0.01uF 50V K
0.01uF 50V K
0.047uF 25V K
1000pF 50V K
100pF 50V J
0.01uF 50V K
1uF 50V M
4700pF 50V K
0.027uF 25V K
1uF 50V M
4700pF 50V K
0.027uF 25V K
1uF 50V M
1uF 50V M
1uF 50V M
8200pF 50V K
0.22uF 16V K
0.22uF 16V K
0.033uF 25V K
5600pF 50V K
4.7uF 25V M
4.7uF 25V M
1uF 50V M
1uF 50V M
1uF 50V M
8200pF 50V K
0.22uF 16V K
0.22uF 16V K
0.033uF 25V K
5600pF 50V K
4.7uF 25V M
4.7uF 25V M
47uF 16V M
100uF 16V M
100uF 16V M
0.01uF 25V K
1uF 50V M http://www.xiaoyu163.com
http://www.xiaoyu163.com
Symbol No.
Part No.
Part Name
C308
C311
C312
C313
C314
C315
C316
C317
C243
C244
C301
C302
C303
C304
C307
C420
C421
C422
C423
C430
C431
C440
C461
C462
C463
C464
C481
C482
C483
C501
QEKJ1CM-226Z
NCB31EK-473X
QEKJ1HM-224Z
QFVD1HJ-474Z
QFVD1HJ-474Z
NCS31HJ-391X
NCS31HJ-391X
QEKJ1HM-105Z
QEKJ1HM-105Z
QFVD1HJ-474Z
QFVD1HJ-474Z
NCS31HJ-391X
NCS31HJ-391X
QEKJ1EM-475Z
QEKJ1EM-475Z
QEKJ1CM-476Z
E CAPACITOR
C CAPACITOR
E CAPACITOR
MF CAPACITOR
MF CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
MF CAPACITOR
MF CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
22uF 16V M
0.047uF 25V K
0.22uF 50V M
0.47uF 50V J
0.47uF 50V J
390pF 50V J
390pF 50V J
1uF 50V M
1uF 50V M
0.47uF 50V J
0.47uF 50V J
390pF 50V J
390pF 50V J
4.7uF 25V M
4.7uF 25V M
47uF 16V M
C318
C319
C320
C322
C323
C324
C325
C341
QEDJ1CM-226Z
NCB31EK-223X
NCB31EK-223X
NCB31EK-104X
NCB31EK-104X
NCB31EK-104X
NCB31EK-104X
NCB31EK-104X
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
22uF 16V M
0.022uF 25V K
0.022uF 25V K
0.1uF 25V K
0.1uF 25V K
0.1uF 25V K
0.1uF 25V K
0.1uF 25V K
C403
C404
C405
C407
NCB31HK-103X
NCB31HK-103X
QEKJ1HM-105Z
QEKJ1AM-107Z
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
0.01uF 50V K
0.01uF 50V K
1uF 50V M
100uF 10V M
C408
C411
C412
C413
C414
C415
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
NCB31EK-104X
NCB31HK-222X
NCB31HK-103X
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
0.01uF 50V K
100uF 10V M
0.01uF 50V K
0.1uF 25V K
2200pF 50V K
0.01uF 50V K
C416 QEKJ1AM-107Z E CAPACITOR 100uF 10V M
C418
C419
NCB31HK-103X
NDC31HJ-120X
C CAPACITOR
C CAPACITOR
0.01uF 50V K
12pF 50V J
NDC31HJ-120X
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
NCB31HK-103X
NDC31HJ-101X
NCB31HK-103X
NCB31EK-104X
QEKJ0JM-107Z
QEKJ0JM-107Z
NCB31EK-104X
QEKJ1CM-476Z
NCB31EK-104X
NCB31EK-104X
QEDJ1AM-476Z
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
12pF 50V J
0.01uF 50V K
100uF 10V M
0.01uF 50V K
0.01uF 50V K
100P 50V J
0.01uF 50V K
0.1uF 25V K
100uF 6.3V M
100uF 6.3V M
0.1uF 25V K
47uF 16V M
0.1uF 25V K
0.1uF 25V K
47uF 10V M
C502
C503
C504
C505
C506
C507
C508
C510
C512
C513
C514
C521
NCB31HK-103X
QEKJ1AM-107Z
NCB31EK-473X
NCB31EK-473X
NCB31EK-473X
NCB31EK-473X
NCB31EK-104X
NCB31EK-103X
QERF1CM-476Z
NCB31HK-103X
NCB31EK-103X
NCB31HK-103X
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
0.01uF 50V K
100uF 10V M
0.047uF 25V K
0.047uF 25V K
0.047uF 25V K
0.047uF 25V K
0.1uF 25V K
0.01uF 25V K
47uF 16V M
0.01uF 50V K
0.01uF 25V K
0.01uF 50V K
C522
C523
C524
C525
C527
C528
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-682X
NCB31HK-103X
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
0.01uF 50V K
100uF 10V M
0.01uF 50V K
100uF 10V M
6800pF 50V K
0.01uF 50V K
C529
C530
QERF1AM-107Z
NCB31EK-104X
E CAPACITOR
C CAPACITOR
100uF 10V M
0.1uF 25V K
C531
C532
C533
NCB31EK-104X
NDC31HJ-680X
NCB31HK-103X
C CAPACITOR
C CAPACITOR
C CAPACITOR
0.1uF 25V K
68pF 50V J
0.01uF 50V K
C534 NDC31HJ-5R0X C CAPACITOR 5pF 50V J
C541
C542
QEKJ1AM-107Z
NCB31HK-103X
E CAPACITOR
C CAPACITOR
100uF 10V M
0.01uF 50V K
Description Local
Q Q
C711
C712
C716
C717
C720
C728
C729
C730
C731
C732
C741
C771
C597
C598
C599
C701
C702
C703
C704
C705
C706
C708
C709
C710
C781
C782
C784
C785
C801
C802
C881
C901
C902
C903
C904
C905
C906
C907
NCB31HK-103X
NCB31HK-103X
QEKJ1EM-475Z
NDC31HJ-220X
NDC31HJ-270X
NDC31HJ-270X
NDC31HJ-8R0X
NCB31EK-104X
NCB31EK-104X
NCB31EK-104X
NCB31HK-103X
QEKJ0JM-476Z
QEKJ1AM-227Z
NCB31HK-103X
NCB31EK-104X
NCB31HK-103X
NCB31CK-224X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31HK-103X
NCB31EK-473X
QEKJ0JM-107Z
NCB31EK-104X
QEKJ1CM-107Z
NDC31HJ-101X
NCB31EK-473X
NDC31HJ-121X
QEKJ1CM-226Z
QEZ0622-338
QEKJ1HM-225Z
QEKJ1CM-476Z
QEDJ1CM-106Z
QEKJ1CM-476Z
NCB31HK-103X
QEKJ1AM-227Z
Symbol No.
Part No.
C543
9
C544
C545
8
QEKJ1AM-107Z
NCB31HK-103X
2
C546 NDC31HJ-470X
Part Name
C565
C566
C568
C570
C571
C572
C580
C581
C582
C583
C584
C585
C589
C590
C555
C556
C557
C558
C559
C560
C561
C562
C547
C548
C549
C550
C551
C552
C553
C554
NCB31HK-153X
NCB31HK-103X
NCB31HK-272X
NCB31HK-103X
NCB31EK-333X
NCB31EK-333X
NCB31EK-473X
NCB31EK-473X
NCB31EK-473X
NCB31HK-471X
NCB31HK-471X
NCB31EK-473X
NCB31EK-473X
NCB31HK-103X
QEKJ1AM-107Z
NCB31HK-103X
NCB31HK-103X
QEKJ1AM-107Z
NCB31EK-104X
QEKJ0JM-476Z
NCB31HK-103X
QEKJ1AM-107Z
QEKJ1EM-475Z
NCB31HK-332X
NDC31HJ-271X
NDC31HJ-271X
NCB31EK-104X
QEKJ0JM-476Z
QEKJ1EM-475Z
QEKJ1EM-475Z
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
8 2 Description Local
100uF 10V M
0.01uF 50V K
47pF 50V J
9
0.015uF 50V K
0.01uF 50V K
2700pF 50V K
0.01uF 50V K
0.033uF 25V K
0.033uF 25V K
0.047uF 25V K
0.047uF 25V K
0.047uF 25V K
470pF 50V K
470pF 50V K
0.047uF 25V K
0.047uF 25V K
0.01uF 50V K
100uF 10V M
0.01uF 50V K
0.01uF 50V K
100uF 10V M
0.1uF 25V K
47uF 6.3V M
0.01uF 50V K
100uF 10V M
4.7uF 25V M
3300pF 50V K
270pF 50V J
270pF 50V J
0.1uF 25V K
47uF 6.3V M
4.7uF 25V M
4.7uF 25V M
C591 NCB31HK-332X
3
C592
7
C595
6 3
NDC31HJ-271X
1 5 1
QEKJ0JM-476Z
5
C596 QEKJ1AM-107Z
C CAPACITOR 3300pF 50V K
270pF 50V J
0
C CAPACITOR
8 9
E CAPACITOR
2 4 9 8 2
47uF 6.3V M
9 9
E CAPACITOR 100uF 10V M
9
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
E CAPACITOR
0.01uF 50V K
0.01uF 50V K
4.7uF 25V M
22pF 50V J
27pF 50V J
27pF 50V J
8pF 50V J
0.1uF 25V K
0.1uF 25V K
0.1uF 25V K
0.01uF 50V K
47uF 6.3V M
220uF 10V M
0.01uF 50V K
0.1uF 25V K
0.01uF 50V K
0.22uF 16V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.01uF 50V K
0.047uF 25V K
100uF 6.3V M
0.1uF 25V K
100uF 16V M
100pF 50V J
0.047uF 25V K
120pF 50V J
22uF 16V M
3300uF
2.2uF 50V M
47uF 16V M
10uF 16V M
47uF 16V M
0.01uF 50V K
220uF 10V M
3-7 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-8
Symbol No.
Part No.
Part Name
C961
C962
C963
C964
C965
C966
C967
C968
C971
C909
C910
C911
C912
C913
C914
C915
QEKJ1AM-227Z
QEKJ1AM-227Z
QERF1CM-476Z
NCB31CK-104X
NCB31HK-103X
QEKJ1CM-106Z
QEKJ1CM-107Z
NCB31CK-104X
NDC31HJ-101X
NDC31HJ-101X
NDC31HJ-101X
NDC31HJ-101X
NDC31HJ-101X
NDC31HJ-101X
NDC31HJ-101X
NDC31HJ-101X
NCB31EK-104X
E CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
E CAPACITOR
E CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
C CAPACITOR
220uF 10V M
220uF 10V M
47uF 16V M
0.1uF 16V K
0.01uF 50V K
10uF 16V M
100uF 16V M
0.1uF 16V K
100pF 50V J
100pF 50V J
100pF 50V J
100pF 50V J
100pF 50V J
100pF 50V J
100pF 50V J
100pF 50V J
0.1uF 25V K
R1
R4
R5
R6
R7
R9
R10
R11
R13
R31
R32
R33
R38
R39
R40
R41
R42
R43
R44
R51
R52
R53
R81
R82
R91
R92
R161
R162
R163
R164
R165
R171
R172
R173
R174
R175
R181
R182
R241
R242
R243
R244
R245
R246
R247
R248
R301
R302
R311
R312
NRS181J-120X
NRSA63J-332X
NRSA63J-473X
NRSA63J-473X
NRSA63J-472X
NRSA63J-470X
NRSA63J-103X
NRSA63J-103X
NRSA63J-473X
NRS181J-100X
NRSA63J-622X
NRSA63J-103X
NRSA63J-101X
NRSA63J-0R0X
NRSA63J-393X
NRSA63J-103X
NRS181J-100X
NRSA63J-471X
NRSA63J-221X
NRSA63J-223X
NRSA63J-0R0X
NRSA63J-822X
NRSA63J-222X
NRSA63J-392X
NRSA63J-222X
NRSA63J-392X
NRSA63J-224X
NRSA63J-223X
NRSA63J-222X
NRSA63J-473X
NRSA63J-473X
NRSA63J-224X
NRSA63J-223X
NRSA63J-222X
NRSA63J-473X
NRSA63J-473X
NRSA63J-271X
NRSA63J-271X
NRSA63J-473X
NRSA63J-223X
NRSA63J-184X
NRSA63J-123X
NRSA63J-470X
NRSA63J-102X
NRSA63J-823X
NRSA63J-221X
NRSA63J-273X
NRSA63J-273X
NRSA63J-273X
NRSA63J-273X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
12
Ω
1/8W J
3.3k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
4.7k
Ω
1/16W J
47
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
10
Ω
1/8W J
6.2k
Ω
1/16W J
10k
Ω
1/16W J
100
Ω
1/16W J
0
Ω
1/16W J
39k
Ω
1/16W J
10k
Ω
1/16W J
10
Ω
1/8W J
470
Ω
1/16W J
220
Ω
1/16W J
22k
Ω
1/16W J
0
Ω
1/16W J
8.2k
Ω
1/16W J
2.2k
Ω
1/16W J
3.9k
Ω
1/16W J
2.2k
Ω
1/16W J
3.9k
Ω
1/16W J
220k
Ω
1/16W J
22k
Ω
1/16W J
2.2k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
220k
Ω
1/16W J
22k
Ω
1/16W J
2.2k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
270
Ω
1/16W J
270
Ω
1/16W J
47k
Ω
1/16W J
22k
Ω
1/16W J
180k
Ω
1/16W J
12k
Ω
1/16W J
47
Ω
1/16W J
1k
Ω
1/16W J
82k
Ω
1/16W J
220
Ω
1/16W J
27k
Ω
1/16W J
27k
Ω
1/16W J
27k
Ω
1/16W J
27k
Ω
1/16W J
R321
R322
NRSA63J-222X
NRSA63J-821X
MG RESISTOR
MG RESISTOR
2.2k
820
Ω
Ω
1/16W J
1/16W J
AR40
0J
AR40
0J
R323
R331
NRSA02J-101X
NRSA63J-222X
MG RESISTOR
MG RESISTOR
100
Ω
1/10W J
2.2k
Ω
1/16W J
AR40
0J
AR40
0J
R332 NRSA63J-821X MG RESISTOR 820
Ω
1/16W J
AR40
0J
Description Local Symbol No.
Part No.
R333
R341
R342
R343
R351
R352
R353
R402
R404
R405
R406
R407
R408
R409
R410
R412
R413
R414
R415
R416
R423
R424
R430
R431
R432
R433
R440
R451
R452
R453
R454
R455
R456
R457
Q
R458
Q
R501
R502
R503
R504
R507
R508
R509
R510
R511
R512
R513
R514
R515
R516
R518
R519
R523
R524
R525
R526
R527
R528
R529
R530
R531
R532
R533
R534
R535
R536
R537
R539
R541
R542
R543
R544
R545
R546
R547
R548
8 9 Part Name 2 4
MG RESISTOR
9
100
Ω
8 Description Local 2
NRSA63J-222X
NRSA63J-821X
NRSA02J-101X
NRSA63J-222X
NRSA63J-821X
NRSA02J-101X
NRSA63J-470X
NRSA63J-103X
NRSA63J-222X
NRSA63J-470X
NRSA63J-222X
NRSA63J-222X
NRSA63J-222X
NRSA63J-105X
NRSA63J-472X
NRSA63J-472X
NRSA63J-472X
NRSA63J-473X
NRSA63J-222X
NRSA63J-103X
NRSA63J-221X
NRSA63J-472X
NRSA63J-103X
NRSA63J-682X
NRSA63J-101X
NRSA63J-472X
NRSA63J-223X
NRSA63J-473X
NRSA63J-222X
NRSA63J-472X
NRSA63J-222X
NRSA63J-272X
NRSA63J-222X
3
NRSA63J-472X
7 1
NRSA63J-333X
NRSA63J-822X
NRSA63J-472X
NRSA63J-153X
NRSA63J-682X
NRSA63J-302X
NRSA63J-123X
NRSA63J-822X
NRSA63J-152X
NRSA63J-152X
NRSA63J-152X
NRSA02J-220X
NRSA02J-220X
NRSA02J-331X
NRSA02J-822X
NRSA02J-512X
NRSA63J-823X
NRSA63J-823X
NRSA63J-334X
NRSA63J-334X
NRSA02J-220X
NRSA02J-220X
NRSA63J-823X
NRSA63J-563X
NRSA63J-103X
NRSA63J-202X
NRSA63J-102X
NRSA63J-153X
NRSA63J-101X
NRSA63J-821X
NRSA63J-0R0X
NRSA02J-151X
NRSA63J-562X
NRSA63J-473X
NRSA63J-474X
NRSA63J-103X
NRSA63J-103X
NRSA63J-470X
NRSA63J-470X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
RESISTOR
RESISTOR
RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
5 1 5 0
MG RESISTOR
8 9
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
2.2k
Ω
1/16W J
820
Ω
1/16W J
100
Ω
1/10W J
2.2k
Ω
1/16W J
820
Ω
1/16W J
100
Ω
1/10W J
47
Ω
1/16W J
10k
Ω
1/16W J
2.2k
Ω
1/16W J
47
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
1M
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
47k
Ω
1/16W J
2.2k
Ω
1/16W J
10k
Ω
1/16W J
220
Ω
1/16W J
4.7k
Ω
1/16W J
10K
Ω
1/16W J
6.8K
Ω
1/16W J
100
Ω
1/16W J
4.7k
Ω
1/16W J
22k
Ω
1/16W J
47k
Ω
1/16W J
2.2k
Ω
1/16W J
4.7k
Ω
1/16W J
2.2k
Ω
1/16W J
2.7k
Ω
1/16W J
2.2k
Ω
1/16W J
4.7k
Ω
1/16W J
2 Ω
Ω
4 9
33k
Ω
1/16W J
8.2k
Ω
1/16W J
4.7k
Ω
1/16W J
15k
Ω
1/16W J
6.8k
Ω
1/16W J
3k
Ω
1/16W J
12k
Ω
1/16W J
8.2k
Ω
1/16W J
1.5k
Ω
1/16W J
1.5k
Ω
1/16W J
1.5k
Ω
1/16W J
22
Ω
1/10W J
22
Ω
1/10W J
330
Ω
1/10W J
8.2k
Ω
1/10W J
5.1k
Ω
1/10W J
82k
Ω
1/16W J
82k
Ω
1/16W J
330k
Ω
1/16W J
330k
Ω
1/16W J
22
Ω
1/10W J
22
Ω
1/10W J
82k
Ω
1/16W J
56k
Ω
1/16W J
10k
Ω
1/16W J
2k
Ω
1/16W J
1k
Ω
1/16W J
15k
Ω
1/16W J
100
Ω
1/16W J
820
Ω
1/16W J
0
Ω
1/16W J
150
Ω
1/10W J
5.6k
Ω
1/16W J
47k
Ω
1/16W J
470k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47
Ω
1/16W J
47
Ω
1/16W J
47
Ω
1/16W J
8
NRSA63J-470X MG RESISTOR
0J
2 9 9
9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Symbol No.
Part No.
Part Name
R582
R583
R584
R585
R586
R587
R588
R591
R550
R551
R552
R553
R558
R559
R581
NRSA63J-101X
NRSA63J-101X
NRSA63J-101X
NRSA63J-101X
NRSA63J-105X
NRSA63J-103X
NRSA63J-155X
NRSA63J-822X
NRSA63J-822X
NRSA63J-822X
NRSA63J-181X
NRSA63J-181X
NRSA63J-682X
NRSA63J-102X
NRSA63J-102X
NRSA63J-822X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R592
R593
R594
R595
R596
R597
R598
R701
NRSA63J-822X
NRSA63J-822X
NRSA63J-181X
NRSA63J-181X
NRSA63J-682X
NRSA63J-102X
NRSA63J-102X
NRSA63J-473X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R702
R703
R704
R705
R708
R709
R710
R711
R712
R713
NRSA63J-470X
NRSA63J-470X
NRSA63J-473X
NRSA63J-473X
NRSA63J-332X
NRSA63J-103X
NRSA63J-821X
NRSA63J-821X
NRSA63J-821X
NRSA63J-821X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R714 NRSA63J-103X MG RESISTOR
R715
R716
R717
NRSA63J-821X
NRSA63J-821X
NRSA63J-101X
MG RESISTOR
MG RESISTOR
MG RESISTOR
R718
R719
NRSA63J-471X
NRSA63J-0R0X
MG RESISTOR
MG RESISTOR
R734
R735
R736
R737
R738
R739
R740
R741
R743
R744
R745
R746
R720
R721
R722
R723
R724
R725
R726
R728
R729
R730
R731
R732
NRSA63J-122X
NRSA63J-102X
NRSA63J-103X
NRSA63J-103X
NRSA63J-471X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-473X
NRSA63J-103X
NRSA63J-473X
NRSA63J-103X
NRSA63J-222X
NRSA63J-222X
NRSA63J-222X
NRSA63J-470X
NRSA63J-472X
NRSA63J-472X
NRSA63J-472X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
R747
R748
R749
R750
R751
R752
NRSA63J-472X
NRSA63J-472X
NRSA63J-472X
NRSA63J-103X
NRSA63J-103X
NRSA63J-473X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R753
R754
NRSA63J-473X
NRSA63J-821X
MG RESISTOR
MG RESISTOR
R755
R756
R757
NRSA63J-106X
NRSA63J-473X
NRSA63J-222X
MG RESISTOR
MG RESISTOR
MG RESISTOR
R758 NRSA63J-473X MG RESISTOR
R759
R761
NRSA63J-473X
NRSA63J-473X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
820
Ω
1/16W J
820
Ω
1/16W J
10k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
100
Ω
1/16W J
470
Ω
1/16W J
0
Ω
1/16W J
1.2k
Ω
1/16W J
1k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
470
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
10k
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
47
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
100
Ω
1/16W J
100
Ω
1/16W J
100
Ω
1/16W J
100
Ω
1/16W J
1M
Ω
1/16W J
10k
Ω
1/16W J
1.5M
Ω
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
180
Ω
1/16W J
180
Ω
1/16W J
6.8k
Ω
1/16W J
1k
Ω
1/16W J
1k
Ω
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
8.2k
Ω
1/16W J
180
Ω
1/16W J
180
Ω
1/16W J
6.8k
Ω
1/16W J
1k
Ω
1/16W J
1k
Ω
1/16W J
47k
Ω
1/16W J
47
Ω
1/16W J
47
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
3.3k
Ω
1/16W J
10k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
4.7k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
820
Ω
1/16W J
10M
Ω
1/16W J
47k
Ω
1/16W J
2.2k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
Description Local
Q Q
CN501
CN701
CN901
J1
J321
J321
J801
S701
S702
S703
TU1
X31
X401
X701
X702
Symbol No.
Part No.
R763
9
R764
R768
8
NRSA63J-101X
NRSA02J-271X
2
R771 NRSA63J-271X
R881
R882
R901
R902
R903
R971
R972
R976
R977
RA30
RA550
R803
R804
R805
R806
R807
R808
R809
R810
R772
R773
R777
R779
R783
R793
R801
R802
NRSA63J-271X
NRSA63J-473X
NRSA63J-473X
NRSA63J-473X
NRSA63J-103X
NRS181J-0R0X
NRSA63J-473X
NRSA63J-473X
NRSA63J-101X
NRSA63J-223X
NRSA63J-104X
NRSA63J-103X
NRSA63J-104X
NRSA63J-331X
NRSA63J-223X
NRSA63J-101X
NRSA63J-473X
NRSA63J-472X
QRE142J-102X
NRSA02J-912X
NRSA02J-472X
NRS181J-222X
NRS181J-222X
NRSA02J-273X
NRSA02J-123X
NRZ0065-222X
NRZ0065-103X
Part Name
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
C RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
8
1k
Ω
2 Description Local
100
Ω
1/16W J
270
Ω
1/10W J
270
Ω
1/16W J
270
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
9
10k
Ω
1/16W J
0
Ω
1/8W J
47k
Ω
1/16W J
47k
Ω
1/16W J
100
Ω
1/16W J
22k
Ω
1/16W J
100k
Ω
1/16W J
10k
Ω
1/16W J
100k
Ω
1/16W J
330
Ω
1/16W J
22k
Ω
1/16W J
100
Ω
1/16W J
47k
Ω
1/16W J
4.7k
Ω
1/16W J
1k
Ω
1/4W J
9.1k
Ω
1/10W J
4.7k
Ω
1/10W J
2.2k
Ω
1/8W J
2.2k
Ω
1/8W J
27k
Ω
1/10W J
12k
Ω
1/10W J
2.2k
Ω
10k
Ω
9
L1
L401
QQL244J-4R7Z
NQL114K-470X
INDUCTIOR
INDUCITOR
4.7uH J
47uH K
L402 NQL114K-470X
3
L404
7
L544
6 3
NQL114K-470X
1 5 1
NQL114K-470X
5
L701 NQL114M-4R7X
INDUCITOR 47uH K
0
INDUCITOR
9
INDUCITOR
47uH K
2 4 9 8
47uH K
2 9 9
COIL 4.7uH M
4.7uH M L702
L901
NQL114M-4R7X
QQR1378-002
COIL
CHOKE COIL
QGB2027M4-22S
QNZ0605-001
QNZ0611-001
QNB0100-002
QNN0490-001
QNN0519-001
QNZ0095-001
QSW0451-001
QSW0451-001
QSW1049-001Z
QAU0311-001
QAX0616-001Z
QAX0760-001Z
QAX0617-001Z
QAX0401-001
CONNECTOR
CAR CONNECTOR
16P CONNECTOR
CAR ANT JACK
PIN JACK
SURROUND JACK
CONNECTOR
DETECT SW
DETECT SW
TACT SWITCH
TUNER PACK
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
B-B (1-22)
10.250MHz
12.500MHz
32.768KHz
AR40
0J
G400J
Front board
Symbol No.
Part No.
IC601
IC602
Q640
Q641
D601
D602
D603
LC75823W
RPM7338-V4
2SB624/4/-X
UN2211-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
Part Name
Block No. [0][2][0][0]
Description Local
IC
REMOCON RCV
TRANSISTOR
TRANSISTOR
LED
LED
LED
3-9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
3-10
Symbol No.
Part No.
Part Name Description Local
D612
D613
D614
D615
D616
D617
D618
D619
D605
D606
D607
D608
D609
D610
D611
D620
D621
D631
D641
D642
D643
D645
D646
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310VT/JK/-X
SML-310LT/MN/-X
UDZS5.1B-X
LED
LED
LED
Z DIODE
MA111-X
MA8062/M/-X
SI DIODE
Z DIODE
NSPW310BS/BRS/ LED
NSPW310BS/BRS/ LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
LED
C601
C602
C603
C611
C612
NCB31HK-223X
NCS31HJ-681X
NBE20JM-106X
NCB31HK-123X
NBE20JM-475X
R610
R611
R612
R613
R614
R631
R632
R634
R601
R602
R603
NRSA63J-821X
NRSA63J-821X
NRSA63J-122X
MG RESISTOR
MG RESISTOR
MG RESISTOR
R604 NRSA63J-182X MG RESISTOR
R605
R606
R607
NRSA63J-272X
NRSA63J-392X
NRSA63J-821X
MG RESISTOR
MG RESISTOR
R608
R609
NRSA63J-821X
NRSA63J-122X
MG RESISTOR
MG RESISTOR
NRSA63J-182X
NRSA63J-272X
NRSA63J-392X
NRSA63J-821X
NRSA63J-821X
NRS181J-821X
NRSA02J-271X
NRSA02J-271X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R636 NRSA02J-471X MG RESISTOR
R636
R638
R640
R642
R644
R646
R648
R651
R652
R653
R654
R655
NRSA02J-821X
NRSA02J-271X
NRSA02J-271X
NRSA02J-471X
NRSA02J-821X
NRSA02J-271X
NRSA02J-821X
NRSA63J-222X
NRSA63J-222X
NRSA63J-103X
NRSA63J-103X
NRSA63J-103X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R656
R657
R658
R660
R661
R670
NRSA63J-103X
NRSA63J-513X
NRSA63J-184X
NRS181J-391X
NRS181J-391X
NRSA63J-0R0X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R672
R673
R674
R681
NRS181J-471X
NRS181J-473X
NRS181J-102X
NRSA63J-101X
MG RESISTOR
MG RESISTOR
MG RESISTOR
MG RESISTOR
R682
R683
R691
R692
NRSA63J-473X
NRSA63J-473X
NRSA63J-103X
NRSA63J-471X
MG RESISTOR
MG RESISTOR
MG RESISTOR
C CAPACITOR 0.022uF 50V K
C CAPACITOR 680pF 50V J
TA E CAPACITOR 10uF 6.3V M
C CAPACITOR 0.012uF 50V K
TA E CAPACITOR 4.7uF 6.3V M
820
Ω
1/16W J
820
Ω
1/16W J
1.2k
Ω
1/16W J
1.8k
Ω
1/16W J
2.7k
Ω
1/16W J
3.9k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
1.2k
Ω
1/16W J
1.8k
Ω
1/16W J
2.7k
Ω
1/16W J
3.9k
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/16W J
820
Ω
1/8W J
270
Ω
1/10W J
270
Ω
1/10W J
470
Ω
1/10W J
820
Ω
1/10W J
270
Ω
1/10W J
270
Ω
1/10W J
470
Ω
1/10W J
820
Ω
1/10W J
270
Ω
1/10W J
820
Ω
1/10W J
2.2k
Ω
1/16W J
2.2k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
10k
Ω
1/16W J
51k
Ω
1/16W J
180k
Ω
1/16W J
390
Ω
1/8W J
390
Ω
1/8W J
0
Ω
1/16W J
470
Ω
1/8W J
47k
Ω
1/8W J
1k
Ω
1/8W J
100
Ω
1/16W J
47k
Ω
1/16W J
47k
Ω
1/16W J
10k
Ω
1/16W J
470
Ω
1/16W J
CN601 NNZ0087-001 CAR CONNECTOR
AR40
0J
G400J
Q Q
S612
S613
S614
S615
S616
S617
S604
S605
S606
S607
S608
S609
S610
S611
Symbol No.
Part No.
EN601
S601 NSW0206-001X
NSW0206-001X
9
S602
Part Name 2 4
TACT SWITCH
TACT SWITCH
9
S603 NSW0206-001X TACT SWITCH
8 Description Local 2 9 9
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
NSW0206-001X
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
TACT SWITCH
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
Packing materials and accessories parts list
QQ 376315150 8 9 2 4 9
M
8
3 M
2
M
9 9
P1
A1 A2 A3 A4 A5
A6 A7 A8 A9 A10
P7
A18
P6
P7 P5
TEL 13942296513
A17
A21
P4
P2
KIT : A11 A12
A13 A14 A15
Q Q
A20
3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
P3
A16
Packing and accessories
Symbol No.
Part No.
Part Name
Block No. [M][3][M][M]
Description Local
A 1
A 2
A 3
A 4
A 5
A 6
A 7
GET0189-001A
GET0189-002A
LVT0717-001B
GET0205-001A
GET0208-001A
LVT1120-001A
LVT1122-001A
INST SHEET ENG FRE SPA
INSTALL MANUAL ENG FRE SPA
TROUBLE SHEET(C
IMPORTANT SHEET
DEMO MODE SHT
MP3 GUIDE
SIRIUS SHEET
A 8 BT-51029-1 WARRANTY CARD
A 8 BT-51018-3 WARRANTY CARD
A 9
A 10
A 11
A 12
BT-52006-2
BT-51034-1
VKZ4027-202
VKH4871-001SS
WARRANTY CARD
J=REGIST CARD
PLUG NUT
MOUNT BOLT
A 13
A 14
VKZ4328-001
WNS5000Z
LOCK NUT
WASHER
AR40
0J
G400J
Symbol No.
Part No.
A 15
A 16
A 17
A 18
A 18
A 19
A 20
A 21
KIT
P 1
P 2
P 3
P 4
P 5
P 6
P 6
P 7
GE40130-002A
FSJB3002-00C
GE20137-003A
GE20149-010A
GE20149-009A
RM-RK60
-----------------
QAM0306-001
SRW-6060E
FSPG4002-001
QPA00801205
FSYH4036-068
QPA01003003
QPC03004315P
GE31119-002A
GE31116-002A
GE10070-002A
Part Name Description Local
HOOK
HARD CASE
MOUNTING SLEEVE
(x2)
TRIM PLATE
TRIM PLATE
REMOCON UNIT
BATTERY
16P CORD ASSY
SCREW PARTS KIT A11 to A15
POLY BAG
POLY BAG
SHEET
8cm x 12cm
POLY BAG
POLY BAG
10cm x 30cm
30cm x 43cm
CARTON
CARTON
EPS CUSHION
AR40
0J
G400J
AR40
0J
G400J
3-11 http://www.xiaoyu163.com
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project