Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

Description of Rev. 02:

EMC UPDATE TEST REPORT

Applicant

Trade Name

Model Number

For

Panel PC

: Advantech Co., Ltd.

: ADVANTECH

: PPC-L126X (X = 0 ~ 9, A ~ Z or blank)

PPC-L126X-XX

Serial Number

Date

Date of test

Revision

(X-XX = 0 ~ 9, A ~ Z or blank)

: N/A

: January 8, 2003

: December 10, 2002 ~ January 6, 2003

: 02

Reference Standard : ANSI C63.4: 1992 (FCC Class B (DoC))

1. Applicant adds one LCD Panel and one Inverter board to re-test.

(Please refer to have ** mark items on this report)

2. Other information please refers to the Rev.00, Rev.01 and this (Rev.02) test report.

Approved by Authorized Signatory:

Lucky Chen / EMC Director

Page 1 of 18

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

VERIFICATION OF COMPLIANCE

Equipment Under Test: Panel PC

Trade Name: ADVANTECH

Model Number:

Serial Number:

PPC-L126X (X= 0 ~ 9, A ~ Z or blank)

PPC-L126X-XX (X-XX = 0 ~ 9, A ~ Z or blank)

N/A

Applicant:

Manufacturer:

Type of Test:

Advantech Co., Ltd.

No. 1, Alley 20, Lane 26, Rueiguang Road,

Neihu District, Taipei 114, R.O.C.

Advantech Co., Ltd.

No. 1, Alley 20, Lane 26, Rueiguang Road,

Neihu District, Taipei 114, R.O.C.

FCC Class B (DoC)

Measurement Procedure: ANSI C63.4: 1992

File Number: 020439-D

Date of test:

Deviation:

December 10, 2002 ~ January 6, 2003

None

Condition of Test Sample: Normal

Final Result: Pass

Worst data: See below

Test Item

Radiated Emission

Freq. (MHz) Measured data

133.26 28.0 (dB/m)

Margin (MìC)

-2.0 dB (± 1.6672 dB)

Remark

Conducted Emission 0.150 53.70 (dB) -12.3 dB (± 2.8216 dB) l The negative sign in Margin cell means under the specific limit. l This test result traceable to national or international standards

The above equipment was tested by C&C Laboratory, Co., Ltd. for compliance with the requirements set forth in the FCC Rules and Regulations Part 15, Subpart B and the measurement procedure according to ANSI C63.4. This said equipment in the configuration described in this report shows the maximum emission levels emanating from equipment are within the compliance requirements.

The test results of this report relate only to the tested sample identified in this report.

Page 2

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

PRODUCT INFORMATION

Housing Type:

EUT Power Rating:

AC power during Test:

AC Power Cord Type:

DC Power Cable Type:

Power Adapter Manufacturer:

Power Adapter Power Rating:

Plastic

DCV from Power Adaptor

120VAC/60Hz

CPU Manufacture:

OSC/Clock Frequencies:

Memory Capacity:

12.1” TFT LCD Panel Manufacturer: IMES

HDD Manufacturer:

CD-ROM Manufacturer:

Mother Board Manufacturer:

Battery Pack Manufacturer:

LAN Card Manufacturer:

VGA Card Manufacturer:

**Inverter Board Manufacturer:

** SANYO

FUJITSU

ASUS

Advantech

Advantech

On Board

On board

LECERF

Unshielded, 1.8m (Undetachable)

Unshielded, 0.3m (Undetachable) with one core

LE Model: LE-9702B-01

LE Model: LE-9702B-06

I/P: 100-240VAC, 60/50Hz, 1.5AVDC

O/P: 19VDC, 3.16A

I/P: 100-240VAC, 50/60Hz, 1.8A

O/P: 19VDC, 3.79A

VIA Type: C3 667MHz

133 MHz

Installed: 128MB

Model:

Model:

Model:

Model:

Model:

Model:

Model:

M121-53DR

MXS121022010

MHK2060AT

SCD-2400

PCM-9671

PPC-L126-BP

LV-104S

Page 3

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

I/O Port of EUT:

I/O Port Type

1. Parallel Port

2. Serial Port

3. Video Port

4. PS/2 Keyboard/ Mouse Port

Q’TY

1

4

1

1

Tested with

1

4

1

1

5. Microphone Port

6. Line-In Port

7. Line-Out Port

8. LAN Port

1

1

1

1

1

1

1

1

9. USB Port 2 2

Note:

1. The means of “X” (X = 0 ~ 9, A ~ Z or blank) on the model number is different Panel as per customer declaration.

2. Client consigns only one model sample (Model Number ： PPC-L126T with TFT LCD

Panel type, the LCD Panel is 12.1” TFT LCD Panel, Please refer the report ) to test.

Therefore, testing Lab. just guarantees the units, which have been tested.

3. The new adds model number means of “X-XX” (X-XX = 0 ~ 9, A ~ Z or blank) on the model number as below: l The first “X” means different Panel. l The other “X” means Battery Pack.

4. Client consigns only one model sample (Model Number is PPC-L126) to test. Therefore, testing Lab. just guarantees the units, which have been tested.

Page 4

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

SUPPORT EQUIPMENT

No.

1.

2.

Equipment

Monitor

Modem

Model #

CPD-G200

Serial #

2716043

FCC ID

FCC DoC

Trade

Name

SONY

Data

Cable

Shielded, 1.8m with a core

Power

Cord

Unshielded, 1.8m

231AA A25531083541 BFJ9D93108US Hayes Shielded, 1.8m Unshielded, 1.8m

3.

4.

Modem

Printer

2400

2225C

94-364-176277 DK467GSM24

3006S67978 DSI6XU2225

Computer

Peripherals

Shielded, 1.8m Unshielded, 1.8m

HP Shielded, 1.8m Unshielded, 1.8m

5.

PS/2

Keyboard

SK-2800C B1C790BCPJCN76

6. PS/2 Mouse M-CAA43 LZA11751072

GYUR79SK

FCC DoC

Compaq Shielded, 1.8m

Logitech Shielded, 1.8m

N/A

N/A

7.

8.

Mouse

Mouse

M-MM43

M-MM43

LZE93352988

LZE94052771

FCC DoC

FCC DoC

Logitech Shielded, 1.8m

Logitech Shielded, 1.8m

N/A

N/A

9. USB Mouse M-BB48 LZE01450904

10. USB Mouse M-BB48 LZE01361333

11. Earphone GT-2004V

12. Walkman RQ-L10

N/A

HB004471

FCC DoC

FCC DoC

N/A

FCC DoC

Logitech Shielded, 1.8m

Logitech Shielded, 1.8m

GITON Unshielded, 1.2m

Panasonic Unshielded, 1.8m

N/A

N/A

N/A

N/A

13. Microphone DM-510

14.

Notebook PC

(Remote)

M285

I3-0

NU2503589

N/A

FCC DoC

KOKA Unshielded, 2.2m

LEO

LAN Cable:

Unshielded, 10m

N/A

AC I/P:

Unshielded, 1.8m

DC O/P:

Unshielded, 1.8m with a core

Note: All the above equipment/cables were placed in worse case positions to maximize emission signals during emission test.

Grounding: Grounding was in accordance with the manufacturer’s requirements and conditions for the intended use.

Page 5

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

BLOCK DIAGRAM OF TEST SETUP

System Diagram of Connections between EUT and Simulators

EUT: Panel PC

Trade Name: ADVANTECH

Model Number: PPC-L126

AC Power Cord: Unshielded, 1.8m to Power Adapter

2. Modem

One to Two Adapter

5. PS/2

Keyboard

1. Monitor

6. PS/2

Mouse

7.Mouse

8.Mouse

Panel PC

(EUT)

9. USB

Mouse

11. Earphone

3. Modem 4. Printer

LAN Cable

13. Microphone

10. USB

Mouse

12. Walkman

14. Notebook PC

(Remote)

Page 6

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

TEST EQUIPMENT LIST (EMISSION)

Instrumentation: The following list contains equipment used at C & C Laboratory, Co., Ltd. for testing. The equipment conforms to the CISPR 16-1 / ANSI C63.2-1988 Specifications for

Electromagnetic Interference and Field Strength Instrumentation from 9kHz to 1.0GHz or above.

Equipment used during the tests:

Open Area Test Site: # 4

EQUIPMENT

TYPE

Spectrum Analyzer

EMI Test Receiver

MFR

Open Area Test Site # 4

ADVANTEST

MODEL

NUMBER

R3132

SERIAL

NUMBER

LAST

CAL.

CAL DUE.

91700456 02/22/2002 02/21/2003

R&S ESVS10 846285/016 04/18/2002 04/17/2003

Bilog Antenna

Turn Table

Antenna Tower

Controller

RF Switch

Site NSA

CHASE

Chance most

Chance most

Chance most

ANRITSU

C&C Lab.

CBL 6112B

N/A

N/A

N/A

MP59B

N/A

2462

N/A

N/A

N/A

M51067

N/A

01/12/2002 01/11/2003

N.C.R

N.C.R

N.C.R

N.C.R

N.C.R

N.C.R

N.C.R N.C.R

08/17/2002 08/16/2003

3 meter Chamber

EQUIPMENT

TYPE

Spectrum Analyzer

Pre-Amplifier

Horn Antenna

Coaxial Cable

Turn Table

Antenna Tower

Controller

MFR

ADVANTEST

3 meter Chamber

MODEL

NUMBER

R3271A

SERIAL

NUMBER

LAST

CAL.

CAL DUE.

85060321 10/16/2002 10/15/2003

HP

EMCO

ANOREW

HD

HD

HD

8449B

3115

LDF-2-50

HD320

MA 240

HD 100

3008A00965 10/15/2002 10/14/2003

9602-4659 04/16/2002 04/15/2003

79027 10/14/2002 10/13/2003

N/A

N/A

N/A

N.C.R

N.C.R

N.C.R

N.C.R

N.C.R

N.C.R

Conducted Emission Test Site: # 4

Conducted Emission Test Site # 4

EQUIPMENT

TYPE

EMI Test Receiver

LISN

MFR

R&S

R&S

MODEL

NUMBER

ESCS30

ENV 4200

SERIAL

NUMBER

LAST

CAL.

CAL DUE.

847793/012 12/21/2002 12/20/2003

830326/016 02/08/2002 02/07/2003

LISN EMCO 3825/2 9003/1382 02/18/2002 02/17/2003

The calibrations of the measuring instruments, including any accessories that may effect such calibration, are checked frequently to assure their accuracy. Adjustments are made and correction factors applied in accordance with instructions contained in the manual for the measuring instrument.

Page 7

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

EUT Configuration during measurement:

1) Pre-scan test mode(s) are list as below:

Mode(s):

1. 800 × 600 Resolution + 100Mbps

2. 800 × 600 Resolution + 10Mbps

3. 640 × 480 Resolution + 100Mbps

2) After pre-scan, found mode 1 producing the highest emission level, used this mode for all final test.

Page 8

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

SUMMARY DATA

(LINE CONDUCTED TEST)

Model Number: PPC-L126

Tested by: George Liao

Location: Site # 4

Test Mode: Mode 1

Test Results: Passed

Temperature: 20

°

C Humidity: 66%RH

(The chart below shows the highest readings taken from the final data)

F R E Q

MHz

NOTE

0.150

2.051

4.743

9.241

10.524

12.393

Q.P.

RAW dBuV

53.40

37.00

37.10

40.10

40.30

39.90

AVG

RAW dBuV

---

---

---

---

---

---

Q.P.

Limit dBuV

66.00

56.00

56.00

60.00

60.00

60.00

AVG

Limit dBuV

56.00

46.00

46.00

50.00

50.00

50.00

Q.P.

AVG

Margin Margin dB

-12.60

-19.00

-18.90

-19.90

-19.70

-20.10

dB

---

---

---

---

---

---

L1

L1

L1

L1

L1

L1

0.150

2.233

2.471

4.814

10.671

11.963

53.70

37.40

35.30

36.20

37.10

38.00

---

---

---

---

---

---

66.00

56.00

56.00

56.00

60.00

60.00

L1 = Line One (Hot side) / L2 = Line Two (Neutral side)

56.00

46.00

46.00

46.00

50.00

50.00

-12.30

-18.60

-20.70

-19.80

-22.90

-22.00

---

---

---

---

---

---

**NOTE: “---” denotes the emission level was or more than 2dB below the Average limit, so no re-check anymore.

L2

L2

L2

L2

L2

L2

Page 9

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

SUMMARY DATA

(RADIATED EMISSION TEST)

Model Number: PPC-L126

Tested by: George Liao

Location: Site # 4

Polar: Vertical--10m

Test Mode: Mode 1

Detector Function: Quasi-Peak

Test Results: Passed

Temperature: 22

°

C Humidity: 63%RH

(The chart below shows the highest readings taken from the final data)

====================================================================

Freq. Raw Corr. Emiss. Limits Margin

Data Factor Level

(MHz) ( dBuV/m ) (dB) ( dBuV/m ) (dB)

====================================================================

133.26 13.8 14.2 28.0 30.0 -2.0

------------------------------------------------------------------------------------------------------------------

252.20 7.5 16.7 24.2 37.0 -12.8

------------------------------------------------------------------------------------------------------------------

294.50 14.4 17.9 32.3 37.0 -4.7

------------------------------------------------------------------------------------------------------------------

397.62 3.0 20.7 23.7 37.0 -13.3

------------------------------------------------------------------------------------------------------------------

453.62 4.6 21.5 26.1 37.0 -10.9

------------------------------------------------------------------------------------------------------------------

533.10 5.2 24.5 29.7 37.0 -7.3

------------------------------------------------------------------------------------------------------------------

Page 10

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

SUMMARY DATA

(RADIATED EMISSION TEST)

Model Number: PPC-L126

Tested by: George Liao

Test Mode: Mode 1

Location: Site # 4

Polar: Horizontal--10m

Test Results: Passed

Detector Function: Quasi-Peak

Temperature: 22

°

C Humidity: 63%RH

(The chart below shows the highest readings taken from the final data)

====================================================================

Freq. Raw Corr. Emiss. Limits Margin

(MHz)

Data

( dBuV/m )

Factor

(dB)

Level

( dBuV/m ) (dB)

====================================================================

133.23 9.0 14.2 23.2 30.0 -6.8

------------------------------------------------------------------------------------------------------------------

190.75 13.7 12.5 26.2 30.0 -3.8

------------------------------------------------------------------------------------------------------------------

320.35 12.8 18.0 30.8 37.0 -6.2

------------------------------------------------------------------------------------------------------------------

360.40 12.4 18.6 31.0 37.0 -6.0

------------------------------------------------------------------------------------------------------------------

400.45 6.8 20.8 27.6 37.0 -9.4

------------------------------------------------------------------------------------------------------------------

531.91 10.0 24.5 34.5 37.0 -2.5

------------------------------------------------------------------------------------------------------------------

560.65 9.9 25.0 34.9 37.0 -2.1

------------------------------------------------------------------------------------------------------------------

Page 11

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

SUMMARY DATA

(RADIATED EMISSION TEST)

Model Number: PPC-L126

Tested by: Sam Chang

Test Mode: Mode 1.

Location: 3 meter chamber

Polar: Vertical ---3 m

Detector Function: Pk / A.V. Test Results: Passed

Temperature: 24 o

C Humidity: 60%RH

(The chart below shows the highest readings taken from the final data)

====================================================================

Freq. Raw Corr. Emiss. Limits Margin

(MHz)

Data

( dBuV/m )

Factor

(dB)

Level(PK) (PK)

( dBuV/m ) (dB)

====================================================================

1126.00 14.6 26.8 41.4 73.9 -32.5

------------------------------------------------------------------------------------------------------------------

1171.00 15.4 26.9 42.3 73.9 -31.6

------------------------------------------------------------------------------------------------------------------

1257.00 19.1 27.2 46.3 73.9 -27.6

------------------------------------------------------------------------------------------------------------------

1331.00 23.1 27.4 50.5 73.9 -23.4

------------------------------------------------------------------------------------------------------------------

1446.00 20.6 27.8 48.4 73.9 -25.5

------------------------------------------------------------------------------------------------------------------

1514.00 18.1 28.0 46.1 73.9 -27.8

------------------------------------------------------------------------------------------------------------------

Note: In case of peak reading complied with the limit at least 22dB margin, no measurement with A.V. detector required.

Page 12

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

SUMMARY DATA

(RADIATED EMISSION TEST)

Model Number: PPC-L126

Tested by: Sam Chang

Test Mode: Mode 1.

Location: 3 meter chamber

Polar: Horizontal ---3 m

Detector Function: Pk / A.V. Test Results: Passed

Temperature: 24 o

C Humidity: 60%RH

(The chart below shows the highest readings taken from the final data)

====================================================================

Freq. Raw Corr. Emiss. Limits Margin

(MHz)

Data

( dBuV/m )

Factor

(dB)

Level(PK) (PK)

( dBuV/m ) (dB)

====================================================================

1200.00 17.3 27.0 44.3 73.9 -29.6

------------------------------------------------------------------------------------------------------------------

1257.00 20.8 27.2 48.0 73.9 -25.9

------------------------------------------------------------------------------------------------------------------

1331.00 22.2 27.4 49.6 73.9 -24.3

------------------------------------------------------------------------------------------------------------------

1394.00 21.5 27.6 49.1 73.9 -24.8

------------------------------------------------------------------------------------------------------------------

1446.00 23.1 27.8 50.9 73.9 -23.0

------------------------------------------------------------------------------------------------------------------

Note: In case of peak reading complied with the limit at least 22dB margin, no measurement with A.V. detector required.

Page 13

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

APPENDIX 1

PHOTOGRAPHS OF TEST SETUP

Page 14

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

LINE CONDUCTED EMISSION TEST

Front View

Back View

Page 15

Rev. 02

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

RADIATED EMISSION TEST

Front View

Back View

Page 16

Rev. 02

APPENDIX 2

PHOTOGRAPHS OF EUT

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

Page 17

Rev. 02

Front View of EUT

Report Number: 020439-D

Refer Number: 021330-D

January 9, 2003

Back View of EUT

Page 18

Rev. 02