Aiwa CA-DW248 Service manual

http://www.xiaoyu163.com
QQ
CA-DW238 LH(S)
376315150CA-DW248
892498U(S)299
CA-DW258 LH(S)
TEL
TEL
xiaoy u163. com
S/M Code No. 09-012-354-1N1
http://www.xiaoyu163.com
DA
TA
.
376315150 892498299
376315150 892498299
www
BASIC TAPE MECHANISM : ZZM-2 APR3NC
BASIC CD MECHANISM : DA11T3C
QQ
QQ
COMPACT DISC CARRY
COMPONENT SYSTEM
376315150 892498299
13942296513
13942296513
SERVICEQQMANUAL
TEL 13942296513
http://www.xiaoyu163.com
SPECIFICATIONS
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
www
.
xiaoy u163. com
-2-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
Design and specifications are subject to change without
notice .
QQ
QQ
•
TEL 13942296513
http://www.xiaoyu163.com
ACCESSORIES/PACKAGE LIST-1/1
QQ 376315150 892498299
REF. NO
PART NO.
!
1
1
1
2
3
KANRI
DESCRIPTION
NO.
8B-CTA-902-010
IB,LH(ESP)FM<238LHSC>
8B-CTA-902-010
IB,LH(ESP)FM<258LHSC>
8B-CTA-903-010
IB,U(ESF)FM<248USC>
8A-CLB-963-010
RC UNIT,RC-AAT25<258LHSC,248USC>
87-A80-036-010
AC CORD SET ASSY,E W/FLTR VOL<258LHSC>
!
!
!
!
3
3
4
4
87-A80-081-010
87-A80-109-010
87-A91-017-010
87-A91-017-010
AC CORD SET ASSY,EZ BLK<238LHSC>
AC CORD,HK7281 BLK U<248USC>
PLUG,CONVERSION JT-0476<258LHSC>
PLUG,CONVERSION JT-0476<238LHSC>
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-3-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
QQ 376315150 892498299
This set employs laser. Therefore, be sure to follow carefully the
instructions below when servicing.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
WARNING!
WHEN SERVICING, DO NOT APPROACH THE LASER EXIT
WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO
CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE
FROM A DISTANCE OF MORE THAN 30cm FROM THE
SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL
PICK-UP BLOCK.
ATTENTION
L'utilisation de commandes, réglages ou procédures autres que
ceux spécifiés peut entraîner une dangereuse exposition aux
radiations.
ADVARSEL!
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer ude
af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1 LASER
product.
The CLASS 1 LASER PRODUCT label is located on the rear
exterior.
VAROITUS!
CLASS 1
KLASSE 1
LUOKAN 1
KLASS 1
VARNING!
LASER PRODUCT
LASER PRODUKT
LASER LAITE
LASER APPARAT
Om apparaten används på annat sätt än vad som specificeras i
denna bruksanvising, kan användaren utsättas för osynling
laserstrålning, som överskrider gränsen för laserklass 1.
.
xiaoy u163. com
-4-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
13942296513
13942296513
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa mainitulla tavalla saattaa altistaa käyt-täjän turvallisuusluokan 1 ylittävälle näkymättömälle lasersäteilylle.
TEL
TEL
Caution: Invisible laser radiation when
open and interlocks defeated avoid exposure to beam.
Advarsel:Usynling laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
http://www.xiaoyu163.com
Precaution to replace Optical block
(SF-P101NR)
QQ 376315150 892498299
PICK-UP Assy PWB
Body or clothes electrostatic potential could ruin
laser diode in the optical block. Be sure ground
body and workbench, and use care the clothes
do not touch the diode.
1) After the connection, remove solder shown in
the right figure.
TEL
TEL
Solder
13942296513
13942296513
.
xiaoy u163. com
-5-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
ELECTRICAL MAIN PARTS LIST-1/4
QQ 376315150 892498299
REF. NO
PART NO.
KANRI
NO.
DESCRIPTION
REF. NO
IC
87-A20-955-010
87-A21-090-010
87-A21-520-040
87-A21-443-040
87-020-828-010
IC,LA1828
IC,LA4600
C-IC,M61509FP<258LHSC,248USC>
C-IC,M62495AFP<238LHSC>
IC,BA3416BL
87-001-440-010
87-A20-446-010
87-A21-319-010
87-A21-093-010
8B-CTA-611-010
IC,BA15218N
C-IC,LA9241ML
C-IC,LC78622NE
IC,LA6541D
C-IC,LC865516A-5T71
87-A20-650-010
IC,RPM6938-V11
89-327-143-080
87-026-462-080
87-026-463-080
87-026-213-080
89-318-154-080
TR,2SC2714 (0.1W)
TR,2SC1740 S(RS 0.3W)
TR,2SA933S (0.3W)
CHIP-TR,DTC114YK
TR,2SC1815 (0.4W)
89-320-011-080
87-026-291-080
89-109-332-380
87-A30-515-080
87-A30-287-040
TR,2SC2001 (15W)
TR,DTC124XS
TR,2SA933RS
TR,2SA1979O/Y
C-TR,DTC114TKA
87-A30-435-040
89-112-965-080
87-A30-226-010
87-026-464-010
87-026-291-010
C-TR,DTC144EK T146
TR,2SA1296 (0.75W)
TR,2SB1655E
TR,DTC114TS
TR,DTC124XS
87-026-463-010
87-026-610-080
89-322-405-080
TR,2SA933S,RS
TR,KTC3198GR
TR,2SC2240GR
PART NO.
C27
C28
C29
C30
C31
KANRI
DESCRIPTION
NO.
87-A11-729-080
C-CAP,S 0.47-25 Z F
87-010-992-080
C-CAP,S 0.047-25 B
87-010-992-080
C-CAP,S 0.047-25 B
87-010-248-080
CAP, ELECT 220-10V
87-010-379-080
CAP, ELECT 22-16V
C32
C33
C34
C35
C36
87-010-197-080
87-010-197-080
87-010-197-080
87-010-197-080
87-010-263-080
CAP,
CAP,
CAP,
CAP,
CAP,
C38
C39
C56
C91
C92
87-010-322-080
87-010-197-080
87-010-151-080
87-010-197-080
87-010-197-080
C-CAP,S 100P-50 CH
CAP, CHIP 0.01 DM
C-CAP,S 7P-50 D CH GRM
CAP, CHIP 0.01 DM
CAP, CHIP 0.01 DM
C211
C212
C215
C216
C231
87-010-805-080
87-010-805-080
87-010-425-080
87-010-425-080
87-015-632-080
CAP, S 1-16
CAP, S 1-16
C-CAP,S 0.22-25 Z F
C-CAP,S 0.22-25 Z F
C-CAP,0.015-50 B
C232
C233
C234
C235
C236
87-015-632-080
87-A10-201-080
87-A10-201-080
87-015-785-080
87-015-785-080
C-CAP,0.015-50 B
C-CAP,S 0.33-16 K B
C-CAP,S 0.33-16 K B
CHIP CAPACITOR, 0.1FZ-25Z
CHIP CAPACITOR, 0.1FZ-25Z
C237
C238
C239
C239
C240
87-010-374-080
87-010-221-080
87-010-805-080
87-010-197-080
87-010-805-080
CAP,
CAP,
CAP,
CAP,
CAP,
ELECT 47-10V
ELECT 470-10V
S 1-16<238LHSC>
CHIP 0.01 DM<258LHSC,248USC>
S 1-16<238LHSC>
C240
C243
C244
C245
C246
87-010-197-080
87-010-401-080
87-010-401-080
87-010-401-080
87-010-401-080
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP 0.01 DM<258LHSC,248USC>
ELECT 1-50V
ELECT 1-50V
ELECT 1-50V
ELECT 1-50V
C247
C248
C251
C261
C262
87-010-401-080
87-010-401-080
87-010-404-080
87-010-402-080
87-010-402-080
CAP,
CAP,
CAP,
CAP,
CAP,
ELECT
ELECT
ELECT
ELECT
ELECT
C263
C264
C266
C267
C271
87-010-178-080
87-010-178-080
87-010-545-080
87-010-545-080
87-010-235-080
CHIP CAP 1000P
CHIP CAP 1000P
CAP, ELECT 0.22-50V
CAP, ELECT 0.22-50V
C-CAP,E 470-16 M SME<248USC>
C271
C272
C272
C277
C278
87-010-237-080
87-010-235-080
87-010-237-080
87-010-404-080
87-010-263-080
CAP, ELECT 1000-16V<EXCEPT 248USC>
C-CAP,E 470-16 M SME<248USC>
CAP, ELECT 1000-16V<EXCEPT 248USC>
CAP, ELECT 4.7-50V
CAP, ELECT 100-10V
C279
C280
C281
C285
C287
87-016-628-080
87-010-178-080
87-010-178-080
87-010-178-080
87-010-178-080
CAP,E 10-25 M SEL
CHIP CAP 1000P
CHIP CAP 1000P
CHIP CAP 1000P
CHIP CAP 1000P
C288
C292
C293
C299
C301
87-010-178-080
87-010-404-080
87-010-404-080
87-010-196-080
87-010-175-080
CHIP CAP 1000P
CAP, ELECT 4.7-50V
CAP, ELECT 4.7-50V
CHIP CAPACITOR,0.1-25
CAP 560P
C302
C303
C304
C305
C306
87-010-175-080
87-010-177-080
87-010-177-080
87-010-374-080
87-010-374-080
CAP 560P
C-CAP,S 820P-50 SL
C-CAP,S 820P-50 SL
CAP, ELECT 47-10V
CAP, ELECT 47-10V
C307
C308
C309
C310
C311
87-010-382-080
87-010-405-080
87-010-404-080
87-010-404-080
87-010-248-080
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP 0.01 DM
CHIP 0.01 DM
CHIP 0.01 DM
CHIP 0.01 DM
ELECT 100-10V
TRANSISTOR
DIODE,IN4148
C-VARI-CAP,HVC202A
ZENNER,HZ7A3L
ZENER,MTZJ2.7A
ZENER,MTZJ8.2A
87-027-702-08J
87-A40-465-090
ZENNER,HZ6C2L
DIODE,FR202
MAIN C.B
C1
C2
C3
C4
C5
87-010-314-080
87-010-316-080
87-010-314-080
87-010-146-080
87-010-378-080
C-CAP,S 22P-50V
C-CAP,S 33P-50 CH
C-CAP,S 22P-50V
C-CAP, 2P-50 C CH GRM
CAP, ELECT 10-16V
C7
C8
C9
C10
C11
87-012-156-080
87-010-197-080
87-010-154-080
87-010-197-080
87-010-151-080
C-CAP,S 220P-50 CH
CAP, CHIP 0.01 DM
C-CAP,S 10P-50 D CH GRM
CAP, CHIP 0.01 DM
C-CAP,S 7P-50 D CH GRM
C12
C13
C14
C16
C17
87-010-314-080
87-010-148-080
87-010-196-080
87-010-178-080
87-016-669-080
C-CAP,S 22P-50V
CAP,S 4P/50
CHIP CAPACITOR,0.1-25
CHIP CAP 1000P
C-CAP,S 0.1-25 K B
C18
C19
C20
C21
C22
87-010-197-080
87-016-669-080
87-010-400-080
87-010-403-080
87-010-197-080
CAP, CHIP 0.01 DM
C-CAP,S 0.1-25 K B
CAP, ELECT 0.47-50V
CAP, ELECT 3.3-50V
CAP, CHIP 0.01 DM
C24
C25
C26
www
87-010-784-080
87-010-784-080
87-A11-729-080
.
xiaoy u163. com
C-CAP,U 0.012-25 B
C-CAP,U 0.012-25 B
C-CAP,S 0.47-25 Z F
-6-
http://www.xiaoyu163.com
ELECT
ELECT
ELECT
ELECT
ELECT
22-25V
10-50V
4.7-50V
4.7-50V
220-10V
376315150 892498299
376315150 892498299
87-070-345-080
87-A40-916-040
87-027-399-080
87-A40-466-080
87-A40-648-080
1-50V
1-50V
4.7-50V
2.2-50V
2.2-50V
QQ
QQ
DIODE
13942296513
13942296513
QQ 376315150 892498299
TEL
TEL
TEL 13942296513
http://www.xiaoyu163.com
ELECTRICAL MAIN PARTS LIST-2/4
C317
C320
C321
C322
C323
87-010-382-080
87-010-405-080
87-012-157-080
87-012-157-080
87-010-197-080
CAP, ELECT 22-25V
CAP, ELECT 10-50V
C-CAP,S 330P-50 CH
C-CAP,S 330P-50 CH
CAP, CHIP 0.01 DM
C324
C325
C326
C327
C328
87-010-197-080
87-010-180-080
87-010-180-080
87-010-404-080
87-010-178-080
CAP, CHIP 0.01 DM
C-CER 1500P
C-CER 1500P
CAP, ELECT 4.7-50V
C-CAP,S 1000P-50 K B C2012
C329
C330
C331
C334
C341
87-010-182-080
87-010-213-080
87-010-374-080
87-012-155-080
87-012-157-080
C-CAP,S 2200P-50 B
C-CAP,S 0.015-25 K B GRM
CAP, ELECT 47-10V
C-CAP 180P-50CH
C-CAP,S 330P-50 CH
C342
C343
C344
C350
C501
87-012-157-080
87-012-157-080
87-010-303-080
87-010-992-080
87-010-390-010
C-CAP,S 330P-50 CH
C-CAP,S 330P-50 CH
C-CAP, 330P-50 J CH
C-CAP,S 0.047-25 B
CAP,E 3300-25 SME
C506
C507
C508
C509
C511
87-010-404-080
87-010-401-080
87-010-235-080
87-A11-149-080
87-010-383-080
CAP, ELECT 4.7-50V
CAP, ELECT 1-50V
C-CAP,E 470-16 M SME
CAP,TC U 0.22-50 Z F
CAP,E 33-25 M 11L SME
QQ
C512
C520
C521
C522
C544
87-010-385-080
87-A11-566-080
87-A11-566-080
87-010-112-810
87-010-405-080
CAP, ELECT 220-25V
C-CAP,S 0.01-25 K B
C-CAP,S 0.01-25 K B
CAP,E 100-16 M SME
CAP, ELECT 10-50V
C762
C765
C766
C767
CF1
87-010-198-080
87-010-196-080
87-010-260-080
87-010-384-080
87-A90-128-010
CAP, CHIP 0.022
CHIP CAPACITOR,0.1-25
CAP, ELECT 47-25V
CAP,E 100-25 M 11L SME
FLTR,AM IF CFAL-455
CF2
CF3
CN301
CN302
CN501
87-008-261-08C
87-008-261-08C
8B-CT5-616-010
8B-CT5-617-010
87-049-919-010
FRTR,CF SFE10.7MAS5
FRTR,CF SFE10.7MAS5
CONN ASSY,4P 2791 30AWG PH<238LHSC>
CONN ASSY,5P 2791 30AWG PH<238LHSC>
CONN,3P EH V WHT
CN601
CN751
CON201
L2
L3
87-A60-109-010
8B-CT5-618-010
87-A60-202-010
87-A50-560-010
8A-CD9-660-010
CONN,2P V S2M-2W
CONN ASSY,8P 1007 26AWG PH<238LHSC>
TERMINAL,ANT 4P MSP-54V-02
COIL,FM BPF(ACD)
BAR-ANT,MW 2B-ACD(COI)
L4
L5
L6
L7
L8
87-A50-562-010
87-A50-564-010
87-A50-588-010
87-A50-579-010
87-A50-590-010
COIL,FM
COIL,FM
COIL,AM
COIL,AM
COIL,FM
L9
L10
L16
L330
L615
87-A50-577-010
87-005-849-080
87-A50-588-010
88-CT6-620-010
87-005-849-080
COIL,FM DET(ACD)
COIL,10UH(CECS)
COIL,AM-OSC-ACD(C01)
REC OSC
COIL,10UH(CECS)
PN301
PN302
PN751
PVC1
R761
87-A60-110-010
87-A60-111-010
87-099-832-010
87-A91-316-010
87-029-019-010
CONN,4P V S2M-4W
CONN,5P V S2M 5W
CONN,8P S2M-8W
TUN-CAP,20P-160P U(TWD)
RES, FUSEIBLE 1/2W-2.2
SFR761
SW1
SW301
87-024-272-010
87-A91-548-010
88-CT6-619-010
SFR,10K V RH0632C
SW,SL-2-3 SK23E01G06
BACK SLIDE SW 6P2T SHORTIN
PART NO.
REF. NO
DESCRIPTION
87-010-403-080
87-010-197-080
87-010-263-080
87-010-248-080
87-010-197-080
CAP,
CAP,
CAP,
CAP,
CAP,
ELECT 3.3-50V
CHIP 0.01 DM
ELECT 100-10V
ELECT 220-10V
CHIP 0.01 DM
C406
C407
C408
C409
C410
87-010-374-080
87-010-178-080
87-010-198-080
87-010-248-080
87-010-263-080
CAP,
CHIP
CAP,
CAP,
CAP,
ELECT 47-10V
CAP 1000P
CHIP 0.022
ELECT 220-10V
ELECT 100-10V
C411
C412
C413
C414
C416
87-A11-693-080
87-010-401-080
87-016-369-080
87-010-401-080
87-010-545-080
C-CAP,S 0.15-50 M F
CAP, ELECT 1-50V
C-CAP,S 0.033-25 B K
CAP, ELECT 1-50V
CAP, ELECT 0.22-50V
C417
C418
C419
C420
C421
87-012-157-080
87-010-213-080
87-A11-608-080
87-016-369-080
87-A11-693-080
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C422
C423
C424
C425
C426
87-010-184-080
87-010-992-080
87-016-460-080
87-010-176-080
87-A11-608-080
CHIP CAPACITOR 3300P(K)
C-CAP,S 0.047-25 B
C-CAP,S 0.22-16 K B
C-CAP,S 680P-50 SL
C-CAP,S 0.33-25 K B
C428
C429
C430
C431
C432
87-010-197-080
87-010-186-080
87-012-156-080
87-010-545-080
87-010-374-080
CAP, CHIP 0.01 DM
CAP,CHIP 4700P
C-CAP,S 220P-50 CH
CAP, ELECT 0.22-50V
CAP, ELECT 47-10V
330P-50 CH
0.015-25 K B GRM
0.33-25 K B
0.033-25 B K
0.15-50 M F
RF EX(ACD)
OSC EX(ACD)
OSC-ACD(COI)
IFT(ACD)
IFT-ACD(COI)
87-010-401-080
87-010-184-080
87-010-197-080
87-010-374-080
87-010-404-080
CAP,
CHIP
CAP,
CAP,
CAP,
ELECT 1-50V
CAPACITOR 3300P(K)
CHIP 0.01 DM
ELECT 47-10V
ELECT 4.7-50V
C438
C439
C440
C441
C442
87-016-669-080
87-010-178-080
87-010-145-080
87-010-197-080
87-010-314-080
C-CAP,S 0.1-25 K B
CHIP CAP 1000P
C-CAP,S 1P-50 CH
CAP, CHIP 0.01 DM
C-CAP,S 22P-50V
C445
C446
C447
C448
C450
87-010-196-080
87-010-196-080
87-010-196-080
87-010-315-080
87-010-305-080
CHIP CAPACITOR,0.1-25
CHIP CAPACITOR,0.1-25
CHIP CAPACITOR,0.1-25
C-CAP,S 27P-50 CH
C-CAP 470P-50CH
C451
C455
C457
C458
C459
87-012-156-080
87-010-247-080
87-010-312-080
87-010-312-080
87-010-263-080
C-CAP,S 220P-50 CH
CAP, ELECT 100-50V
C-CAP,S 15P-50 CH
C-CAP,S 15P-50 CH
CAP, ELECT 100-10V
C460
C461
C462
C463
C465
87-015-819-080
87-010-197-080
87-010-248-080
87-010-197-080
87-010-404-080
CAPACITOR,0.01
CAP, CHIP 0.01 DM
CAP, ELECT 220-10V
CAP, CHIP 0.01 DM
CAP, ELECT 4.7-50V
C466
C467
C469
C470
C471
87-010-196-080
87-010-263-080
87-012-154-080
87-010-544-080
87-A11-601-080
CHIP CAPACITOR,0.1-25
CAP, ELECT 100-10V
C-CAP,S 150P-50 CH
CAP, ELECT 0.1-50V
C-CAP,S 0.1-25 K B
C472
C473
C474
C475
C476
87-A11-601-080
87-A11-601-080
87-A11-601-080
87-010-197-080
87-010-236-080
C-CAP,S 0.1-25 K B
C-CAP,S 0.1-25 K B
C-CAP,S 0.1-25 K B
CAP, CHIP 0.01 DM
CAP,E 1000-10 SME
C477
C478
C479
87-010-197-080
87-010-263-080
87-010-197-080
CAP, CHIP 0.01 DM
CAP, ELECT 100-10V
CAP, CHIP 0.01 DM
xiaoy u163. com
-7-
http://www.xiaoyu163.com
376315150 892498299
QQ 376315150 892498299
C433
C434
C435
C436
C437
QQ
C401
C402
C403
C404
C405
13942296513
376315150 892498299
.
KANRI
NO.
CD C.B
TEL 13942296513
www
PART NO.
TEL
TEL
C312
C313
C314
C315
C316
KANRI
DESCRIPTION
NO.
87-010-374-080
CAP, ELECT 47-10V
87-015-828-080
C-CAP,0.033 F
87-015-828-080
C-CAP,0.033 F
87-010-401-080
CAP, ELECT 1-50V
87-010-401-080
CAP, ELECT 1-50V
13942296513
QQ 376315150 892498299
REF. NO
http://www.xiaoyu163.com
ELECTRICAL MAIN PARTS LIST-3/4
QQ 376315150 892498299
REF. NO
PART NO.
C480
C481
C482
C489
C490
KANRI
NO.
87-010-221-080
CAP,
87-010-405-080
CAP,
87-010-405-080
CAP,
87-010-196-080
CHIP
87-010-196-080
CHIP
C491
C492
C493
C494
C4001
DESCRIPTION
C840
C841
C842
C844
J251
87-010-221-080
87-010-401-080
87-012-140-080
87-010-401-080
88-CT6-625-010
CAP, ELECT 470-10V
CAP, ELECT 1-50V
CAP 470P
CAP, ELECT 1-50V
JACK,MIC
C4002
C4003
C4004
C4005
C4006
87-010-322-080
87-010-322-080
87-010-322-080
87-010-322-080
87-010-322-080
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
J801
L601
L612
L616
L617
88-CT6-625-010
87-003-102-080
87-005-849-080
87-005-849-080
87-005-849-080
JACK,MIC
COIL, 10UH
COIL,10UH(CECS)
COIL,10UH(CECS)
COIL,10UH(CECS)
C4007
C4010
C4011
C4012
C4013
87-010-178-080
87-018-209-08C
87-010-178-080
87-010-178-080
87-010-178-080
CHIP CAP
CAP,TC U
CHIP CAP
CHIP CAP
CHIP CAP
L618
L801
LED602
LED603
LED606
87-005-849-080
87-003-098-080
87-A41-050-040
87-A41-050-040
87-A41-050-040
COIL,10UH(CECS)
COIL,2.2UH
LED,BT-H203D-31 RED
LED,BT-H203D-31 RED
LED,BT-H203D-31 RED
CN401
CNA402
FFC401
L401
L402
87-A60-424-010
8Z-CT6-631-010
8B-CTA-616-010
87-005-849-080
87-005-849-080
CONN,16P V TOC-B
CONN ASSY,6P CD MO
FF-CABLE,16P 1.0 165MM<238LHSC>
COIL,10UH(CECS)
COIL,10UH(CECS)
LED607
LED608
LED610
LED611
SW601
87-A41-050-040
87-A41-050-040
87-A41-050-040
87-A41-066-010
8Z-CT6-636-010
LED,BT-H203D-31 RED
LED,BT-H203D-31 RED
LED,BT-H203D-31 RED<258LHSC,248USC>
LED,FR-12037G RED
SW,TACT EVQJAC04M
L404
L405
L406
SFR430
X401
87-003-152-080
87-005-849-080
87-008-372-080
87-024-437-080
8Z-CD5-633-010
COIL, 100UH
COIL,10UH(CECS)
FLTR,EMI BL 01RN1
SFR100K,RH063EC
VIB, CER16.93MHZ FCR16.93M2
SW602
SW603
SW604
SW605
SW606
8Z-CT6-636-010
8Z-CT6-636-010
8Z-CT6-636-010
8Z-CT6-636-010
8Z-CT6-636-010
SW,TACT
SW,TACT
SW,TACT
SW,TACT
SW,TACT
EVQJAC04M
EVQJAC04M
EVQJAC04M
EVQJAC04M
EVQJAC04M
SW607
SW608
SW611
SW614
SW615
8Z-CT6-636-010
8Z-CT6-636-010
8Z-CT6-636-010
8Z-CT6-636-010
8Z-CT6-636-010
SW,TACT
SW,TACT
SW,TACT
SW,TACT
SW,TACT
EVQJAC04M
EVQJAC04M
EVQJAC04M
EVQJAC04M
EVQJAC04M
SW616
SW617
VR801
X601
X602
8Z-CT6-636-010
8Z-CT6-636-010
87-A90-768-010
87-030-273-010
87-A70-070-080
SW,TACT EVQJAC04M
SW,TACT EVQJAC04M
VR,RTRY 10KAX1 1 H
VIB,XTAL 32.768K5PPM
VIB,CER 5.76MHZ CRHF
C901
C902
C903
C904
CNA901
87-A10-577-080
87-A10-577-080
87-A10-577-080
87-A10-577-080
8Z-CT9-640-010
CAP,CER 0.022-50 Z YF
CAP,CER 0.022-50 Z YF
CAP,CER 0.022-50 Z YF
CAP,CER 0.022-50 Z YF
CONN ASSY,3P EH(POWER)
!PR901
87-A90-764-080
PROTECTER,1.25A 60V 491<EXCEPT 248USC>
S0-M10-A09-700
S2-369-750-000
S4-S13-A01-600
MOTOR SLED ASSY
PLUG,6P
SW,LEAF
FRONT C.B
C601
C602
C603
C604
C605
TEL 13942296513
87-010-313-080
87-010-315-080
87-010-319-080
87-010-317-080
87-010-263-080
CAP, CHIP 18P
C-CAP,S 27P-50 CH
C-CAP,S 56P-50 CH
C-CAP,S 39P-50 CH
CAP, ELECT 100-10V
C606
C607
C608
C609
C611
87-010-196-080
87-010-197-080
87-010-405-080
87-010-400-080
87-010-248-080
CHIP
CAP,
CAP,
CAP,
CAP,
C613
C614
C615
C616
C617
87-010-196-080
87-010-312-080
87-010-805-080
87-010-805-080
87-010-179-080
CHIP CAPACITOR,0.1-25
C-CAP,S 15P-50 CH
CAP, S 1-16
CAP, S 1-16
CAP,CHIP S B1200P
C618
C619
C630
C631
C632
87-010-263-080
87-010-401-080
87-A11-566-080
87-A11-566-080
87-A11-566-080
CAP, ELECT 100-10V
CAP, ELECT 1-50V
C-CAP,S 0.01-25 K B
C-CAP,S 0.01-25 K B
C-CAP,S 0.01-25 K B
C633
C638
C639
C640
C641
87-A11-566-080
87-A11-566-080
87-A11-566-080
87-A11-566-080
87-A11-601-080
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C-CAP,S
C642
C830
C831
C832
C833
87-010-197-080
87-A11-566-080
87-A11-566-080
87-015-628-080
87-010-178-080
CAP, CHIP 0.01 DM
C-CAP,S 0.01-25 K B
C-CAP,S 0.01-25 K B
C-CAP,1800P-50 B
CHIP CAP 1000P
www
.
QQ 376315150 892498299
CAPACITOR,0.1-25
CHIP 0.01 DM
ELECT 10-50V
ELECT 0.47-50V
ELECT 220-10V
POWER C.B
MOTOR C.B
M2
PIN3
SW1
0.01-25 K B
0.01-25 K B
0.01-25 K B
0.01-25 K B
0.1-25 K B
xiaoy u163. com
-8-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
CAPACITOR,0.01
CAP, ELECT 470-10V
CAP, CHIP 0.01 DM
CAP, CHIP 0.01 DM
CHIP CAPACITOR,0.1-25
ELECT 4.7-50V
ELECT 0.1-50V
CAP 1000P
CAP 1000P
ELECT 1-50V
QQ
QQ
87-015-819-080
87-010-221-080
87-010-197-080
87-010-197-080
87-010-196-080
1000P
0.1-50 Z F UP 050
1000P
1000P
1000P
DESCRIPTION
13942296513
13942296513
C834
C835
C836
C837
C838
CH
CH
CH
CH
CH
PART NO.
TEL
TEL
ELECT 470-10V
ELECT 10-50V
ELECT 10-50V
CAPACITOR,0.1-25
CAPACITOR,0.1-25
KANRI
NO.
87-010-404-080
CAP,
87-010-544-080
CAP,
87-010-178-080
CHIP
87-010-178-080
CHIP
87-010-401-080
CAP,
100P-50
100P-50
100P-50
100P-50
100P-50
REF. NO
http://www.xiaoyu163.com
ELECTRICAL MAIN PARTS LIST-4/4
QQ 376315150 892498299
• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
8 8
A
Figure
Resistor Code
Value of resistor
Type
1005
Tolerance
5%
Symbol
CJ
1/16W
1/10W
1608
2125
5%
5%
CJ
CJ
1/8W
3216
5%
CJ
W
t
:A
Resistor Code : A
1.0
0.5
0.35
104
.
t
W
1.6
0.8
0.45
108
2
1.25
0.45
118
3.2
1.6
0.55
128
QQ 376315150 892498299
xiaoy u163. com
-9-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
L
QQ
QQ
TEL 13942296513
Form
13942296513
13942296513
L
Dimensions (mm)
Wattage
1/16W
TEL
TEL
Chip resistor
http://www.xiaoyu163.com
TRANSISTOR ILLUSTRATION-1/1
QQ 376315150 892498299
ECB
2SA1296
ECB
2SA1318
ECB
2SB1655
TEL
TEL
B
ECB
2SC2714
DTC114YK
DTC114TK
DTC144EK
www
.
DTC124XS
2SC1740
QQ 376315150 892498299
xiaoy u163. com
-10-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
DTC114TS
ECB
QQ
QQ
2SC2001
2SA933
2SC1815
2SC2240
KTC3198
ECB
E
13942296513
13942296513
C
http://www.xiaoyu163.com
WIRING-1/2 (MAIN, CD, FRONT)
QQ 3 7 6 3 1 5 1 5 0
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
8 9 2 4 9 8 2 9 9
A
B
C
+
D
L
R
E
SPEAKERS
OPE LED
R
F
G
I
J
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
K
L
M
N
O
P
Q
R
S
www
.
x
i
a o y u 1 6 3
-11http://www.xiaoyu163.com
.
c o
m
T
U
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
13942296513
13942296513
H
TEL
TEL
+
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-1/5 (MAIN 1/2)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
QQ
8 9 2 4 9 8 2 9 9
A
A
3 7 6 3 1 5 1 5 0
R763
10k
www
.
x
A
i
a o y u 1 6 3
-12http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-2/5 (MAIN 2/2)
QQ 3 7 6 3 1 5 1 5 0
TEL
TEL
9
68k
8 9 2 4 9 8 2 9 9
13942296513
13942296513
C092
0.01
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
C039 0.01
QQ
C091 0.01
www
.
x
i
a o y u 1 6 3
-13http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-3/5 (CD)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
NC
T4
1 3 9 4 2 2 9 6 5 1 3
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
-14http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
FFC401
QQ
QQ
T E L
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-4/5 (FRONT)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
x
i
QQ
3 7 6 3 1 5 1 5 0
a o y u 1 6 3
-15http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
WIRING-2/2 (POWER, MOTOR)
1515
MOTOR
C.B0
892498299
QQ 3763
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
A
B
M2
_
C
M2
(SLED MOTOR)
D
SW1
(INSIDE LIMIT SW)
E
M3
(SPINDLE MOTOR)
SW1
G
_
1
H
+
I
QQ 376315150 892498299
K
L
M
N
O
P
Q
R
S
www
.
xiaoy u163. com
-16-
http://www.xiaoyu163.com
T
U
376315150 892498299
376315150 892498299
TEL 13942296513
J
QQ
QQ
M3
13942296513
13942296513
PIN3
6
F
TEL
TEL
TO CD C.B
CNA402
+
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-5/5 (POWER)
QQ 376315150 892498299
238, 258
248
TEL
TEL
13942296513
13942296513
O E
2
238,
CN501
1
PR
2
238,258
248
6
JW
3
www
.
xiaoy u163. com
-17-
http://www.xiaoyu163.com
8
8
376315150 892498299
376315150 892498299
CNA901
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
http://www.xiaoyu163.com
ELECTRICAL ADJUSTMENT-1/1
QQ 3 7 6 3 1 5 1 5 0
FRONT C.B
8 9 2 4 9 8 2 9 9
< TUNER SECTION >
1. AM Freq. Range Adjustment
L006 ............................................................................. 517kHz
TC003 ......................................................................... 1750kHz
MAIN C.B
2. AM Tracking Adjustment
L003 ............................................................................. 600kHz
TC004 ......................................................................... 1400kHz
89
J251
PHONES
SFR761
3. AM IF Adjustment
Settings: • Test point: IC001 (L1828) 19PIN
• Adjustment location: L007
Method: Adjust L007 so that the output level at 1000kHz
becomes maximum.
L330
8
0
CD C.B
6. FM IF Adjustment
Settings: • Test point: IC001 (L1828) 19PIN
• Adjustment location: L008
Method: Adjust L008 so that the output level at 98.0MHz
becomes balanced.
1 3 9 4 2 2 9 6 5 1 3
TC3
TC1
L005
L009
TC4
TC2
4
L004
3 7 6 3 1 5 1 5 0
< TAPE SECTION >
8. Tape speed Adjustment
Settings: • Test tape: TTA-100
• Test point: J251 (PHONES jack)
• Adjustment location: SFR761
Method: Play back the test tape and adjust SFR761 so that the
frequency counter reads 3000Hz ±5Hz.
IC001
3
L007
L008
8 9 2 4 9 8 2 9 9
L003
5
19
7
2
QQ
6
9. Head Azimuth Adjustment
Settings: • Test tape: TTA-320
• Test point: J251 (PHONES jack)
• Adjustment location: Azimuth adjustment screw.
Method: Play back the 8kHz signal of the test tape and adjust
screw so that the output becomes maximum.
RPH (DECK1)/PH (DECK2)
10. Bias frequency Adjustment
L330 .................................................................... 56kHz ±2kHz
9
www
.
x
i
a o y u 1 6 3
-18http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
T E L
2
L006
QQ
QQ
1
7. FM Balance Adjustment
Settings: • Test point: IC001 (L1828) 19PIN
• Adjustment location: L009
Method: Adjust L009 so that the output level at 98.0MHz
becomes balanced.
13942296513
13942296513
5. FM Tracking Adjustment
L004 ........................................................................... 90.0MHz
TC002 ....................................................................... 108.0MHz
TEL
TEL
4. FM Freq. Range Adjustment
L005 ........................................................................... 87.0MHz
TC001 ....................................................................... 109.0MHz
http://www.xiaoyu163.com
IC BLOCK DIAGRAM-1/2
IC, M61509
QQ 376315150 892498299
mono. SW
TEL
TEL
www
.
QQ 376315150 892498299
xiaoy u163. com
AUTO RESET
-19-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
IC, M62495AFP
13942296513
13942296513
Control logic
http://www.xiaoyu163.com
IC BLOCK DIAGRAM-2/2
IC, LA6541D
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
IC, BA3416BL
QQ 376315150 892498299
DECK R
DECK L
DECK R
DECK L
R OUT
L OUT
www
.
xiaoy u163. com
-20-
http://www.xiaoyu163.com
TAPE SELECT
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
IC, LA1828
http://www.xiaoyu163.com
VOLTAGE CHART-1/4
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-21-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
VOLTAGE CHART-2/4
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-22-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
VOLTAGE CHART-3/4
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-23-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
VOLTAGE CHART-4/4
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-24-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
IC DESCRIPTION-1/3 (LA9241ML)-1/2
QQ 376315150 892498299
Pin No.
Pin Name
I/O
1
FIN2
I
Description
Pin to which external pickup photo diode is connected. RF signal is created by adding with the
FIN1 pin signal. FE signal is created by subtracting from the FIN1 pin signal.
2
FIN1
I
3
E
I
Pin to which external pickup photo diode is connected.
Pin to which external pickup photo diode is connected. TE signal is created by subtracting from
the F pin signal.
F
I
Pin to which external pickup photo diode is connected.
5
TB
I
DC component of the TE signal is input.
6
TE-
I
Pin to which external resistor setting the TE signal gain is connected between the TE pin.
7
TE
O
TE signal output pin.
8
TESI
I
TES “Track Error Sense” comparator input pin. TE signal is passed through a band-pass filter
then input.
Shock detection signal input pin.
TH
I
Tracking gain time constant setting pin.
11
TA
O
TA amplifier output pin.
12
TD-
I
13
TD
I
Tracking phase compensation setting pin.
14
JP
I
Tracking jump signal (kick pulse) amplitude setting pin.
15
TO
O
Tracking control signal output pin.
Pin to which external tracking phase compensation constants are connected between the TD and
VR pins.
16
FD
O
17
FD-
I
Focusing control signal output pin.
Pin to which external focusing phase compensation constants are connected between the FD and
FA pins.
18
FA
I
Pin to which external focusing phase compensation constants are connected between the FD–
and FA– pins.
19
FA-
I
Pin to which external focusing phase compensation constants are connected between the FA and
FE pins.
20
FE
O
FE signal output pin.
21
FE-
I
Pin to which external FE signal gain setting resistor is connected between the FE pin.
22
AGND
—
Analog signal GND.
23
SP
O
Signal ended output of the CV+and CV- pin input signal.
24
SPI
I
Spndle amp input.
25
SPG
I
Pin to which external spindle gain setting resistor in 12 cm mode is connected. (Not connected)
26
SP-
I
Pin to which external spindle phase compensation constants are connected together with SPD
pin.
27
SPD
O
Spindle control signal output pin.
28
SLEQ
I
Pin to which external sled phase compensation constants are connected.
29
SLD
O
Sled control signal output pin.
30, 31
SL-, SL+
32, 33
JP-, JP+
34
TGL
35
TOFF
www
.
xiaoy u163. com
I
Sled advance signal input pin from microprocessor.
I
Tracking jump signal input pin from DSP.
I
Tracking gain control signal input from DSP. Low gain when TGL = H.
I
Tracking off control signal input pin from DSP. Off when TOFF = H.
-25-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
10
13942296513
I
QQ
SCI
13942296513
9
TEL
TEL
4
http://www.xiaoyu163.com
IC DESCRIPTION-1/3 (LA9241ML)-2/2
QQ 376315150 892498299
Pin No.
Pin Name
I/O
36
TES
O
37
HFL
O
Description
Pin from which TES signal is output to DSP.
“High Frequency Level” is used to judge whether the main beam position is on top of bit or on
top of mirror.
Sled servo off control input pin.
39, 40
CV-, CV+
I
CLV error signal input pin from DSP.
41
RFSM
O
RF output pin.
42
RFS-
I
RF gain setting and EFM signal 3T compensation constant setting pin together with RFSM pin.
43
SLC
O
“Slice Level Control” is the output pin which controls the RF signal data slice level by DSP.
44
SLI
I
Input pin which control the data slice level by the DSP.
45
DGND
—
Digital system GND.
TEL
46
FSC
O
Output pin to which external focus search smoothing capacitor is connected.
47
TBC
I
“Tracking Balance Control” EF balance variable range setting pin.
13942296513
48
NC
—
No connection.
49
DEF
O
Disc defect detector output pin.
50
CLK
I
Reference clock input pin. 4.23 MHz of the DSP is input.
51
CL
I
Microprocessor command clock input pin.
52
DAT
I
Microprocessor command data input pin.
53
CE
I
Microprocessor command chip enable input pin.
QQ
54
DRF
O
“Detect RF” RF level detector output.
55
FSS
I
56
VCC2
—
Servo system and digital system Vcc pin.
57
REFI
—
Pin to which external bypass capacitor for reference voltage is connected. (Pull down)
58
VR
O
Reference voltage output pin.
59
LF2
I
Disc defect detector time constant setting pin. (Pull down)
60
PH1
I
Pin to which external capacitor for RF signal peak holding is connected. (Pull up)
61
BH1
I
Pin to which external capacitor for RF signal bottom holding is connected. (Pull down)
62
LDD
O
APC circuit output pin.
63
LDS
I
APC circuit input pin.
64
VCC1
—
www
.
“Focus Search Select” focus search mode (± search/+ search) select pin. (Not connected)
RF system Vcc pin.
xiaoy u163. com
-26-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
I
13942296513
SLOF
TEL
38
http://www.xiaoyu163.com
IC DESCRIPTION-2/3 (LC78622NE)-1/2
QQ 376315150 892498299
I/O
1
DEFI
I
2
TAI
I
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
3
PDO
O
Phase comparator output pin to control external VCO.
4
VVSS
—
5
ISET
I
6
VVDD
—
7
FR
I
8
VSS
—
9
EFMO
O
10
EFMIN
I
11
TEST2
I
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
12, 13
CLV+, CLV-
O
Disc motor control output. Three level output is possible using command.
14
V/P
___
O
Description
Defect sense signal (DEF) input pin. (Connect to 0V when not used).
For PLL.
GND pin for built-in VCO. Be sure to connect to 0V.
Pin to which external resistor adjusting the PD0 output current. (Pull down)
Power supply pin for built-in VCO.
Pin for VCO frequency range adjustment. (Pull down)
Digital system GND. Be sure to connect to 0V.
For slice level control.
EFM signal output pin.
EFM signal input pin.
Rough servo or phase control automatic selection monitoring output pin. Rough servo at H.
Phase servo at L.
HFL
I
Track detect signal input pin. Schmidt input.
16
TES
I
Tracking error signal input pin. Schmidt input.
17
TOFF
O
Tracking OFF output pin.
18
TGL
O
Tracking gain selection output pin. Gain boost at L.
19, 20
JP+, JP-
O
Track jump control signal output pin. Three level output is possible using command.
21
PCK
O
22
FSEQ
O
QQ 376315150 892498299
EFM data playback clock monitoring pin 4.3218 MHz when phase is locked in. (Not connected)
Sync signal detection output pin. H when the sync signal which is detected from EFM signal and
thesync signal which is internally generated agree. (Not connected)
23
VDD
—
Digital system power supply pin.
24
SL+
I/O
The pin is controlled by the serial data
25
SL-
I/O
26
PUSW
I/O
27
PUIN
I/O
command from microprocessor. When
the pin is not used, set the pin to the input
terminal and connect to 0V, or alternately
set the pin to output terminal and leave
28
RW
I/O
the pin open.
29
EMPH
O
De-emphasis monitor output pin. De-emphasis disc is being played back at H. (Not connected)
30
C2F
O
C2 flag output pin. (Not connected)
31
DOUT
O
DIGITAL OUT output pin. (EIAJ format) (Not connected)
32, 33
TEST3, TEST4
I
General purpose input/output pin 1 to 5.
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
(Connected to GND)
34
N.C.
—
35
MUTEL
O
36
LVDD
—
37
LCHO
O
www
38
LVSS
39
RVSS
40
RCHO
41
RVDD
.
Not used. Set the pin to open.
L-channel mute output pin. (Not connected)
L-channel 1-bit DAC.
L-channel power supply pin.
L-channel output pin.
xiaoy u163. com
—
L-channel GND. Be sure to connect to 0V. (Connected to GND)
—
R-channel GND. Be sure to connect to 0V. (Connected to GND)
O
R-channel 1-bit DAC.
R-channel output pin.
R-channel power supply pin.
—
-27-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
15
13942296513
13942296513
Pin Name
TEL
TEL
Pin No.
http://www.xiaoyu163.com
IC DESCRIPTION-2/3 (LC78622NE)-2/2
QQ 376315150 892498299
Pin No.
Pin Name
I/O
Description
42
MUTER
O
R-channel 1-bit DAC.
43
XVDD
—
Crystal oscillator power supply pin.
44
XOUT
O
45
XIN
I
46
XVSS
—
Crystal oscillator GND pin. Be sure to connect to 0V.
47
SBSY
O
Subcode block sync signal output pin. (Not connected)
48
EFLG
O
C1, C2, single and dual correction monitoring pin. (Not connected)
49
PW
O
Subcode P, Q, R, S, T, U and W output pin. (Not connected)
50
SFSY
O
R-channel mute output pin. (Not connected)
Pin to which external 16.9344 MHz crystal oscillator is connected.
Subcode frame sync signal output pin. Falls down when subcode enters standby.
(Not connected)
SBCK
I
Subcode read clock input pin. Schmidt input. (Be sure to connected to 0V when not in use)
(Connected to GND)
FSX
O
Pin outputting the 7.35 kHz sync signal which is generated by dividing frequency of crystal
oscillator. (Not connected)
53
WRQ
O
Subcode Q output standby output pin.
54
RWC
I
Read/write control input pin. Schmidt input.
55
SQOUT
O
Subcode Q output pin.
COIN
I
Command input pin from microprocessor.
I
Command input read clock or subcode read input clock from SQOUT pin
56
13942296513
13942296513
52
TEL
TEL
51
___________
CQCK
QQ 376315150 892498299
58
RES
I
LC78622 reset input pin. Set this pin to L once when the main power is turned on.
59
TST11
O
Test signal output pin. Use this pin as open (normally L output). (Not connected)
60
16M
O
16.9344 MHz output pin.
61
4.2M
O
4.2336 MHz output pin.
62
TEST5
I
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
(Connected to GND)
______
63
CS
I
Chip select signal input pin with built-in pull-down resistor. Be sure to connect to 0V while it is
not controlling. (Connected to GND)
64
TEST1
I
Test signal input pin without built-in pull-down resistor. Be sure to connect to 0V.
(Connected to GND)
Note: The same potential must be applied to the respective power supply terminals. (VDD, VVDD, LVDD, RVDD, XVDD)
www
.
xiaoy u163. com
-28-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
57
http://www.xiaoyu163.com
IC DESCRIPTION-3/3 (LC865516A-5T71)-1/2
Description
O
SEG E control.
2
SEG F
O
SEG F control.
3
SEG G
O
SEG G control.
4
I-W. DECK
—
W. DECK control. (Pull up)
5
I-RES
I
Micro processor reset input. (Pull down)
6
XT1 (IN)
I
Connected to an external 32.768 kHz crystal oscillator.
7
NC
—
Not connected.
8
XT2 (OUT)
O
Connected to an external 32.768 kHz crystal oscillator.
9
VSS
—
GND.
10
CF1 (IN)
I
Connected to an external 5.76 MHz ceramic filter.
11
CF2 (OUT)
O
Connected to an external 5.76 MHz ceramic filter.
12
VDD
—
Microprocessor power supply (+5V).
I-KEY0
I
Key AD input. (AD)
14
I-KEY1
I
Key AD input. (AD)
15
I-MOTOR
I
Deck status input. (AD) (Pull up)
I-CD SW
I
CD door switch status input. (Pull up)
17
HI-DUBB
O
HI-SPEED DUBBING control.
18
NC
—
Not connected.
19
O-BASS LED
O
BASS LED ON/OFF control output. (Not connected)
16
_________________
20
O-Q. SOUND LED
O
Q sound LED ON/OFF control output. (Not connected)
21
HI-DUBB LED
—
HI-SPEED DUBBING LED control.
22
I-DRF
I
CD RF level detection input.
23
I-WRQ
I
CD subcode Q standby input.
24
NC
—
Not connected.
25
I-REM
—
Remote control input. (Pull up)
26
O-CD ON
O
CD power control output.
27
O-TU ON
O
TU power control output.
28
O-P.CONT
O
The main power supply control output.
29
NC
—
Not connected.
30
O-BEAT
O
Beat control.
31
O-MUTE
O
Main mute output.
32
O-DIGIT
O
7-segment LED power supply control output.
33
O-SEG RPEAT
O
REPEAT LED ON/OFF control output.
34
O-COIN
O
CD command output.
35
I-SQOUT
I
CD subcode Q input.
36
O-CQCK
O
CD command/CLK for subcode.
37
O-RWC
O
CD read/write control output.
www
38
O-DATA
39
O-CD LED
40
O-TU LED
41
O-TA LED
.
xiaoy u163. com
O
Data output to M62349FP.
O
LED ON/OFF control output for the CD function.
O
LED ON/OFF control output for the TU function.
O
LED ON/OFF control output for the TA function. (Not connected)
-29-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
13
13942296513
SEG E
TEL
1
QQ
I/O
13942296513
Pin Name
TEL
QQ 376315150 892498299
Pin No.
http://www.xiaoyu163.com
IC DESCRIPTION-3/3 (LC865516A-5T71)-2/2
QQ 376315150 892498299
Pin No.
42
Pin Name
I/O
Description
NC
—
Not connected.
O
SEG DP control.
O
SEG A control.
O
SEG B control.
O
SEG C control.
______________
43
SEG DP
____________
44
SEG A
____________
45
SEG B
____________
46
SEG C
____________
47
SEG D
O
SEG D control.
48
NC
—
Not connected.
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-30-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
MECHANICAL EXPLODED VIEW-1/1
QQ 3 7 6 3 1 5 1 5 0
36
8 9 2 4 9 8 2 9 9
40
39
46
47
38
42
E
45
37
A
48
L
A
49
D
J
G
35
PWB
34
CHAS,TU
E
J
50
15
K
D
31
25 43
H
F
G
51
D
27
30
G
41
HLDR,LED
B
23
B
24
D
8
26
C
44
PWB
PLATE,PT
7
HT-SINK
QQ
21
9
3 7 6 3 1 5 1 5 0
8 9 2 4 9E 8 2E 9 9
CUSH,FOOT
29
PWB
D
12
F
PLATE,ANT
22
10
52
I
13
19 D
ZZM-2
A
6
20
18
E
C
ANT
14
A
C
5
55
A
1
2
5
3
A
CABI,FR SPKR
16
4
www
44
A
.
x
NET,SPKR
17
i
a o y u 1 6 3
-31http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
1 3 9 4 2 2119 6 5 1 3
54
PWB
QQ
QQ
T E L
D
53
13942296513
13942296513
28
TEL
TEL
33
32
http://www.xiaoyu163.com
MECHANICAL PARTS LIST-1/1
QQ 376315150 892498299
REF. NO
PART NO.
1
2
3
4
5
KANRI
DESCRIPTION
NO.
8B-CTA-007-010
WINDOW,CASS L
8B-CTA-004-010
BOX,CASS L
8B-CTA-008-010
WINDOW,CASS R
8B-CTA-005-010
BOX,CASS R
8B-CTA-206-010
SPR-T,CASS
6
6
6
7
7
8B-CTA-045-010
8B-CTB-006-010
8B-CTA-006-010
8B-CTB-001-010
8B-CTA-001-010
8
9
10
11
12
DA11T3C
KNOB,RTRY TU
OIL-DMPR 80
SPKR,12 3.2OHM<5LHSC>
SPKR,12 7.0OHM<4USC>
8B-CTA-013-010
8B-CTA-015-010
8B-CTA-017-010
8B-CTA-018-010
8B-CTA-019-010
BTN,FUNC
KNOB,SL BAND
BTN,EQ
LENS,FUNC
LENS,REPEAT
44
45
46
47
48
8B-CTA-615-010
8B-CTA-022-010
8B-CTA-023-010
8B-CTA-003-010
87-A92-048-010
SPKR,5' 3.2OHM 5W<3LHSC>
HANDL,ARM
HANDL,GRIP
LID,BATT
ANT,ROD 5SEC
13
14
15
16
17
8B-CTA-020-010
87-063-165-010
87-A90-086-010
8B-CTA-011-010
8B-CTA-012-010
LENS,EQ<5LHSC,4USC>
OIL-DMPR 150
COVER,AC-SOCKET
KEY,CASS L
KEY,CASS R
49
49
49
50
50
8B-CTB-004-010
8B-CTA-036-010
8B-CTA-002-010
87-A60-178-010
87-A60-177-010
CABI,REAR
CABI,REAR
CABI,REAR
JACK,AC E
JACK,AC U
18
19
19
20
21
8B-CT5-208-010
8A-CT9-215-010
8B-CTA-207-010
88-CD6-661-010
86-CT9-205-110
SPR-P,REC
SPR-P,REC A
SPR-P,REC B
HLDR,BAR ANT.
HLDR,REC
51
51
52
53
54
88-CT6-631-010
88-CT7-629-010
8Z-CT6-646-010
86-CT9-213-010
8B-CTA-029-010
POWER TRANS,EI-57/25<5LHSC,3LHSC>
PT,U<4USC>
CORD ASSY,SPEAKER
SPR-C,BATT(-)
HLDR,CORD SPKR
22
23
24
25
25
88-CT6-632-010
8B-CTA-203-010
88-CH6-220-010
8Z-CT9-064-010
8B-CTA-031-010
TERMINAL,ASSY MECHA 1P
GEAR,TU
CUSHION,CD A
PANEL CD<5LHSC,4USC>
PANEL,CD M<3LHSC>
55
55
A
B
C
8B-CTA-025-010
8B-CTA-026-010
87-751-097-410
81-CD5-204-010
87-751-095-410
CABI,REAR SPKR L
CABI,REAR SPKR R
SCREW 3X12
SCREW CD
VT2+3-8 W/O
26
27
28
29
30
86-CT9-212-010
8B-CTA-202-010
8B-CTA-201-010
8B-CTA-014-010
8Z-CT6-214-010
SPR-C,BATT LINK
HLDR,LED REPEAT
HLDR,LED FUNC
KNOB,RTRY MIC
RING,CHUCK
D
E
F
G
H
87-571-095-410
87-651-100-410
87-651-075-210
87-651-104-410
87-261-072-410
VIT+3-8
VT1+3-16
VT1+2.6-10
VT1+3-30
V+2.6-5<3LHSC>
31
32
33
34
35
8Z-CT6-213-010
87-036-368-010
86-CT9-222-010
86-CT9-217-010
8B-CTA-009-010
BASE,CHUCK
MAGNET
PLATE,MAGNET
HLDR,CHUCK A(S)
LID,CD
J
I
K
L
87-721-097-410
8A-CDA-222-010
87-265-097-410
87-751-096-410
QT2+3-12 GLD
S-SCREW,CASS+2.6-4
V+3-12 NI
VT2+3-10 GLD
www
.
!
!
LH<3LHSC>
LH<5LHSC>
U (7 OHM N)<4USC>
W/SW<5LHSC,3LHSC>
W/SW<4USC>
QQ 376315150 892498299
xiaoy u163. com
-32-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
M8-ZZK-E90-070
8B-CTA-016-010
87-063-164-010
8Z-CT6-647-010
8Z-CT9-631-010
QQ
QQ
41
42
43
44
44
13942296513
13942296513
WINDOW,DISP LH<5LHSC>
WINDOW,DISP LH L<3LHSC>
WINDOW,DISP U<4USC>
CABI,FR LH L<3LHSC>
CABI,FR U<5LHSC,4USC>
!
!
PART NO.
TEL
TEL
36
37
38
39
40
KANRI
DESCRIPTION
NO.
8B-CTA-021-010
POINTER,TU
8B-CTA-208-010
HLDR,POINTER
8B-CTA-010-010
CHAS,CD
87-036-389-010
SW,PUSH LOCK
8B-CTA-205-010
SPR-T,CD
TEL 13942296513
REF. NO
http://www.xiaoyu163.com
QQ 376315150 892498299
COLOR NAME TABLE
Basic color symbol
Color
Basic color symbol
Color
Basic color symbol
Color
B
Black
C
Cream
D
Orange
G
Green
H
Gray
L
Blue
LT
Transparent Blue
N
Gold
P
Pink
R
Red
S
Silver
ST
Titan Silver
T
Brown
V
Violet
W
White
WT
Transparent White
Y
Yellow
YT
Transparent Yellow
LM
Metallic Blue
LL
Light Blue
GT
Transparent Green
LD
Dark Blue
DT
Transparent Orange
GM
Metallic Green
YM
Metallic Yellow
DM
Metallic Orange
PT
Transparent Pink
LA
Aqua Blue
GL
Light Green
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-33-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
TAPE MECHANISM EXPLODED VIEW-1/1 (ZZM-2 APR3NC)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TERMINAL,LB1 A
54
4
22
14
55
15
3
6
22
20
23
21
27
20
5
2
23
21
28
13
19
TERMINAL,LB1 A
18
14
17
1
25
29
15
6
5
13
24
26
a
55
31
TEL
TEL
59
54
b
19
16
28
59
17
30
16
B
53
46
47
27
38
45
33
QQ
1 3439 4 2 2 934 6 5 1 3
b
26
24
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
1
12
51
a
11
12
40
53
32
33
52
4
10
51
11
3
34
47
1
36
9
39
2
8
58
42
10
1
7
37
46
50
45
56
44
9
57
38
49
43
48
8
63
42
7
57
www
35
41
62
40
39
63
.
x
i
a o y u 1 6 3
-34http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
T E L
29
25
QQ
QQ
37
44
13942296513
13942296513
18
61
http://www.xiaoyu163.com
TAPE MECHANISM PARTS LIST-1/1 (ZZM-2 APR3NC)
QQ 376315150 892498299
REF. NO
1
2
3
4
5
PART NO.
KANRI
DESCRIPTION
NO.
8Z-ZM1-254-310
SPR-C,REEL R
8Z-ZM1-225-110
GEAR,REEL R
8Z-ZM1-253-210
SPR-C,AUTO SENSOR
8Z-ZM1-217-110
LEVER,AUTO SENSOR
8Z-ZM1-212-210
LEVER,T-UP
REF. NO
PART NO.
34
35
36
37
38
KANRI
DESCRIPTION
NO.
8Z-ZM1-226-010
GEAR,REEL L
8Z-ZM1-241-210
SPR-T,PLAY
8Z-ZM1-220-110
LEVER,REC SENSOR
8Z-ZM1-249-210
SPR-T,FR
8Z-ZM1-242-310
SPR-T,FF/REW
SPR-T,AUTO
CLR,SLIP FF/REW
SPR-C,FF/REW
GEAR,SLIP FR A ZZM-2
FELT,FF/REW 2
39
40
41
42
43
8Z-ZM3-244-110
8Z-ZM1-232-010
8Z-ZM3-228-110
8Z-ZM1-267-110
8Z-ZM1-228-010
GEAR,CAM TD20
GEAR,IDL FF/REW
FLY-WHL,M3
SHAFT,CAPSTAN 2
GEAR,SLIP T-UP B
11
12
13
14
15
8Z-ZM1-238-110
8Z-ZM1-237-110
8Z-ZM1-209-510
8Z-ZM1-218-210
8Z-ZM1-256-010
GEAR,SLIP FF/REW B 2
LEVER,FF/REW 2
LEVER,PAUSE
LEVER,E-LOCK H
SPR-P,PAUSE
44
45
46
47
48
8Z-ZM1-265-010
8Z-ZM1-227-010
8Z-ZM1-251-210
8Z-ZM1-243-310
87-A91-532-010
FELT,T-UP
GEAR,SLIP T-UP A
SPR-C,T-UP SLIP
SPR-T,STOP/PAUSE
MOT,MS15U2LW1A
16
17
18
19
20
8Z-ZM1-244-110
8Z-ZM1-247-310
8Z-ZM1-261-110
8Z-ZM1-221-210
8Z-ZM1-205-310
SPR-T,T-UP
SPR-T,PINCH
ROLLER ASSY,PINCH
LEVER,PINCH
LEVER,PLAY
49
50
51
52
53
8Z-ZM1-235-010
8Z-ZM2-216-010
8Z-ZM1-260-010
8Z-ZM2-201-510
8Z-ZM1-255-310
PULLEY,MOT
BELT,MAIN M
SPR-P,CASETTE
CHAS ASSY,ZZM-2
SPR-T,E-LOCK
13942296513
21
22
23
24
25
8Z-ZM1-248-210
87-A90-403-110
84-ZM2-227-310
8Z-ZM1-216-110
8Z-ZM1-246-110
SPR-T,BRG
HEAD,RPH MS15R
SPR-C,AZIMUTH
LEVER,AUTO
SPR-T,AUTO 2
54
55
56
57
58
8Z-ZM2-219-010
8Z-ZM1-214-310
8Z-ZM2-211-210
8Z-ZM1-257-110
8Z-ZM2-210-010
LEVER,E-OPEN ZZM-2
LEVER,LOCK
FLY-WHL,ZZM-2
SPR-C,F/R
LEVER,BRIDGE<YR2NF,YR3NF>
26
27
28
29
30
8Z-ZM2-214-110
8Z-ZM2-212-010
8Z-ZM1-207-010
8Z-ZM1-206-010
8Z-ZM1-210-010
GEAR,IDL REW ZZM-2
LEVER,STOP ZZM-2
LEVER,FF
LEVER,REW
LEVER,REC<YR1NF>
59
60
61
61
62
87-B10-301-010
87-A91-494-010
8Z-ZM1-241-010
8Z-ZM2-217-010
8Z-ZM2-601-010
W-L,1.63-3.2-0.5 SLIT
SW,LEAF MSW17820<YR1NF,YR2NF>
SPR-T,PLAY<YR1NF>
SPR-T,PLAY 2<YR2NF,YR3NF>
CONN ASSY,9P ZZM-2<YR1NF>
13942296513
QQ
30
31
31
32
33
8Z-ZM1-211-210
87-A90-404-010
87-A91-533-010
8Z-ZM2-218-010
87-A91-492-010
LEVER,REC 2<YR2NF,YR3NF>
HEAD,EH LE15B<YR1NF>
HEAD,EH PH-K380<YR2NF,YR3NF>
LEVER,REC LOCK ZZM-2
SW,LEAF MSW18560
63 8Z-ZM1-275-010
A 84-ZM2-242-010
B 8Z-ZM2-220-110
W-L,1.47-4-0.25<YR1NF>
S-SCREW,AZ1-2-6.4
V+2.6 ZZM-2
QQ
www
.
QQ 376315150 892498299
xiaoy u163. com
-35-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
TEL
8Z-ZM1-245-310
8Z-ZM1-236-010
8Z-ZM1-252-110
8Z-ZM2-213-010
8Z-ZM1-269-010
TEL
6
7
8
9
10
http://www.xiaoyu163.com
CD MECHANISM EXPLODED VIEW-1/1 (DA-11T3C)
QQ 376315150 892498299
1
A
2
SW1
www
.
M2
PIN 3
xiaoy u163. com
-36-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
MOTOR C.B
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
13942296513
13942296513
4
TEL
TEL
3
http://www.xiaoyu163.com
CD MECHANISM PARTS LIST-1/1 (DA-11T3C)
QQ 376315150 892498299
REF. NO
1
2
3
4
A
PART NO.
KANRI
DESCRIPTION
NO.
M8-ZZK-E90-070
DA11T3C
S2-121-A28-400
COVER GEAR
S2-511-A21-000
GEAR MIDDLE
S2-511-A21-100
GEAR,DRIVE
S1-PN2-03R-OSE
SCR PAN PCS 2-3
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
-37-
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
H251701
Printed in Singapore
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513