- Home
- Domestic appliances
- Large home appliances
- Water heaters & boilers
- CSA American
- ATI-705-P
- Datasheet
advertisement
Dräger Gas Detection
Dräger: Technology for Life
®
Inside front cover BLANK
DRÄGER GAS DETECTION | 02
Dräger Gas Detection
TABLE OF CONTENTS
Dräger X-zone 5000
Dräger X-am 2000
Dräger X-am 5000
Dräger X-am 5600
Dräger X-am 3000
Dräger X-am 7000
Dräger Pac 7000
Dräger Pac 3500/5500
Dräger-Sensors
®
, XXS and PID Sensors
Dräger E-Cal Systems
Calibration Gases
Dräger Software
Dräger Support Material
Dräger Training Software
Dräger CMS Analyzer
Dräger CMS Chips
Dräger accuro
®
Pump and Dräger X-act
®
5000
Short Term Dräger-Tubes
®
Dräger Emergency Response Kits
TWA Measurements
Air Current Measurements
DrägerService
Dräger Swede Survival
Fire Training Systems
Respiratory Protection Products
Notes
41
42
43
45
35
38
39
40
27
29
31
33
23
24
25
26
03
05
07
09
11
13
15
17
19
21
03 | DRÄGER GAS DETECTION
Area monitoring
without limits.
Dräger X-zone® 5000
Front view
Dräger X-zone® 5000
Back view
Dräger X-zone ® 5000
Area monitoring wit hout limits – t he Dräger X-zone 5000. In combination wit h t he Dräger X-am 5000 or X-am 5600, the X-zone 5000 reliably monitors for up to six hazardous gases and warns at preset levels. This easily transportable, robust and water-proof unit extends mobile gas detection technology to a unique system wit h many applications.
INNOVATIVE AREA MONITORING
The Dräger X-zone 5000 transforms the Dräger
X-am 5000 or X-am 5600 personal gas detection instrument into an innovative area monitoring device for a wide range of applications. A patented combination for increased safety – used with personal gas air monitoring carried on the body or positioned where gas hazards are expected, the X-zone 5000 area monitor knows no limits!
WIRELES S FENCE LINE
Up to 25 Dräger X-zones can be automatically interconnected to form a wireless fence line. This interconnection of the monitoring devices allows for rapid securing of larger areas, e.g. leaking pipelines or industrial tanks – or the monitoring required during industrial shutdowns.
CLE AR AL ARM - 360°
Even from a distance, the illuminated green LED ring indicates that the air is free of toxic and combustible gases. When gas hazards are detected, the LED changes colors from green to red, providing a clear visual warning that hazardous gas is present. In addition, it emits a loud and audible evacuation alarm. With a patented 360° alarm amplifier, the acoustic warning is heard easily over a wide area, independent of wind direction. The Dräger X-zone
5000 gas entry is arranged so that gas can diffuse into the Dräger X-am 5000 or X-am 5600 from all sides.
In the event of a gas alarm, the Dräger X-zone 5000 transmits alarm signals to all units that are part of the fence line which then display a daughter alarm. The original alarming unit shows a red LED along with its audible alarm, while the daughter alarm displays green/red with its illuminated LED ring. This provides fast, easy recognition of the general alarm, while identifying the unit which alarmed originally. This assures a positive alert and a clear and clean evacuation. Alternatively, the fence line can be wired.
ARE A MONITORING – USING A SAMPLING PUMP
An optional integrated pump allows monitoring of remote areas by pulling a sample to the device. This provides continuous monitoring of confined spaces and locations which are difficult to access – from a distance of up to 150 ft. (45 m).
DRÄGER GAS DETECTION | 04
Area monitoring
Dräger X-zone 5000 complements the
Dräger personal gas measuring devices X-am 5000 and X-am 5600.
Wireless fence line
Up to 25 Dräger X-zone 5000 automatically interconnect to form a wireless fence line.
TECHNICAL DATA
Dimensions (W x H x D)
Weight
Approvals
16.2 x 11.4 x 11.4 inch (490 x 300 x 300 mm)
15 lbs. (7 kg) (12 Ah battery), 22 lbs. (10 kg) (24 Ah battery)
ATEX I M1 Ex ia I Ma
II 1G Ex ia IIC T3 Ga
IEC
II 2G Ex ia d IIC T4 Gb
Ex ia IIC T3/T4
Ex ia IIC T3
Ex d ia IIC T4
Class I, Zone 0, AEx ia IIC T3
Class I, Zone 1, AEx d ia IIC T4
ORDER INFORMATION
Dräger X-zone ® 5000 wit h diffusion cap
Dräger X-zone 5000 – 915 MHz, 12 Ah battery
Dräger X-zone 5000 – 915 MHz, 24 Ah battery
Dräger X-zone ® 5000 wit h integrated pump, diffusion and pump cap
Dräger X-zone 5000 – 915 MHz, 12 Ah battery
Dräger X-zone 5000 – 915 MHz, 24 Ah battery
Accessories
Bump Test adapter
Alarm damper
Leg extender, 1 ft. or 25 cm in height
Charging accessories
Inductive charger
Plug-in charger
Pump accessories
Float probe with 16.4 ft. or 5 m viton hose
Hose set (consisting of water trap, dust and water filter)
Viton hose, solvent-resistant
Tygon hose
Communication accessories
Dräger CC-Vision ®
USB DIRA with USB cable
Order No.
83 20 744
83 20 745
83 20 746
83 20 747
83 20 108
83 20 110
83 20 645
83 22 076
83 20 749
83 18 371
83 21 527
12 03 150
45 94 707
64 08 515
83 17 409
05 | DRÄGER GAS DETECTION
The Dräger X-am 2000 represents a new generation of personal gas detectors.
DRÄGER X- AM 2000
The Dräger X-am 2000 represents a new generation of personal gas detectors which have been specially designed for personal monitoring. These gas detectors reliably measure combustible gases and vapors, as well as O
2
, CO and H
2
S. Their ergonomic design, mobile phone dimensions and light weight make t hem t he perfect companion in your daily work. Reliable measurement technology, long sensor life and easy operation guarantee maximum safety at an extremely low cost of ownership.
The instrument’s light weight and mobile phone size — unique in today’s market — guarantees users a high level of comfort and convenience. By design, the instruments are easy to use, thanks to the practical two button control panel and easy to understand display icons.
The Dräger E-Cal automatic test, calibration, and documentation system is also an ideal complement to the instrument, saving time and minimizing the workload.
The Dräger X-am 2000 is available in
1 to 4 gas configurations with a 1000 hour data logger. This monitor is not life limited and has user replaceable sensors, unmatched for a monitor of this type. The optional T4 NiMH battery pack will be covered by a two-year warranty.
For improved safety when facing unknown gas hazards the catalytic EX sensor, calibrated to methane, responds quickly to explosive gases. It also offers a high level of sensitivity to combustible organic vapors, thus providing dependable warnings in the event of explosive hazards.
Dräger-Sensors ® stand for innovative technology at the highest level. The
Dräger X-am monitors feature the latest series of powerful electrochemical
Dräger-Sensors ® from the miniaturize
XXS generation.
The new bump-test station will allow for complete function tests in about
20 seconds. Automatic recognition of the monitor starts the process as soon as the monitor is placed in the cradle. The monitor can also be configured to automatically perform a complete calibration when placed in the test station. Records of the tests are stored in the instrument’s data or event logger.
The Dräger X-am 2000 monitor is tough: water and dust resistant to IP 67, the instruments remain fully functional and ready for use even after being dropped in water. The integrated rubber protection and shockproof sensors ensure additional resistance to impact and vibration. The
Dräger X-am 2000 also has certified protection against electromagnetic and
RFI interference.
Dräger X-am 2000: The ideal 4-gas detector for industrial shutdowns.
DRÄGER GAS DETECTION | 06
TECHNICAL DATA
Gases Detected
Dimensions
Weight
Approvals
Combustible Gases, O
2
, CO and H
2
S.
1.85 x 5.08 x 1.22 inch (7 x 129 x 31 mm)
7.8 oz (220 g)
ATEX
UL
CSA
IECEx
CE-mark
MSHA
II 2G EEx ia d IIC T4/T3 - I M2 EEx ia d I
Cl. I Div. 1 Group A,B,C,D - Cl. II E,F,G T.-Code T4/T3
Cl. I Div. 1 Group A,B,C,D T.-Code T4/T3
Ex ia d I/IIC T4/T3
Electromagnetic compatibility (directive 89/336/EEC)
X-am 2000 permissible gas detector
ORDER INFORMATION
Dräger X-am 2000 Monitor - unlimited life with data logger - 3 Year Warranty*
Dräger X-am 2000 EX, O
2
, CO, H
2
S w/ alkaline battery pack
Dräger X-am 2000 EX, O
2
, H
2
S w/ alkaline battery pack
Dräger X-am 2000 EX, O
2
, CO w/ alkaline battery pack
Dräger X-am 2000, O
2
, H
2
S w/ alkaline battery pack
Dräger X-am 2000, O
2
, CO w/ alkaline battery pack
Dräger X-am 2000, CO, H
2
S w/ alkaline battery pack
Dräger X-am 2000 EX, CO w/ alkaline battery pack
Dräger X-am 2000 EX, H
2
S w/ alkaline battery pack
Dräger X-am 2000 EX, O
2 w/ alkaline battery pack
Dräger X-am 2000 EX w/ alkaline battery pack
Dräger X-am 2000 O
2
, CO, H
2
S w/ alkaline battery pack
X-am 2000 Ex/O
2
/CO/H
2
S NiMH, w/ Charger Kit
X-am 2000 Ex/O
2
/H
2
S, NiMH, w/ Charger Kit
X-am 2000 Ex/O
2
/CO NiMH, w/ Charger Kit
X-am 2000 Ex/CO NiMH, w/ Charger Kit
X-am 2000 Ex/H
2
S NiMH, w/ Charger Kit
X-am 2000 Ex/O
2
NiMH, w/ Charger Kit
X-am 2000 Ex NiMH, w/ Charger Kit
Accessories
NiMH battery pack T4
NiMH battery pack T4 with charger module and power pack
Alkaline battery pack T3/T4 (without alkaline batteries)
Alkaline battery for alkaline power supply 8318703
Dräger Bump Test Station for X-am 2000
Mixed gas cylinder, 2.5 vol.-% CH
4
, 100 ppm CO; 25 ppm H
2
S, 17 vol.-% O
2
Deluxe instrument case
*5 Year Warranty on EC Sensors
83 18 910
83 18 890
83 18 880
83 18 698
83 18 697
83 18 696
83 18 790
83 18 780
83 18 770
83 18 750
83 18 699
45 43 095
45 43 907
45 43 908
45 43 910
45 43 911
45 43 912
45 43 913
Dräger X-am 2000:
Robust 1- to 4-gas detector for personal monitoring.
83 18 704
83 18 785
83 18 703
45 88 195
83 19 131
45 94 655
45 43 755
07 | DRÄGER GAS DETECTION
Dräger X-am 5000
DRÄGER X- AM 5000
The smallest gas detection instrument for up to 5 gases. The Dräger X-am 5000 belongs to a new generation of gas detectors, developed especially for personal monitoring applications. This 1 to 5-gas detector reliably measures combustible gases and vapors as well as oxygen and harmful concentrations of CO, H
2
S, CO
2
,
Cl
2
, HCN, O
3
, COCl
2
, NH
3
, NO
2
, PH
3
, SO
2
, amines, odorants and organic vapors.
A variety of special calibrations for the catalytic Ex sensor allow the Dräger X-am
5000 even more sensitivity when detecting specific combustible gases and vapors.
Equipped with durable DrägerSensors
®
XXS sensor technology, the Dräger X-am
5000 offers maximum security and extremely low operational costs. The longevity of the catalytic sensor and five year expected lifetime of the oxygen sensor are unique in the market.
Moreover, the Dräger X-am 5000 is insensitive to electromagnetic interference.
The two button control panel and easy to follow menu system allow for intuitive use.
It is easy to exchange, upgrade or calibrate the sensors to other gases. The ability to customize the Dräger X-am 5000's sensors makes more applications possible, including rental equipment.
Dräger X-am 5000's ergonomic mobile phone design and light weight make it comfortable for users to carry. It is water and dust-resistant according to IP 67.
The integrated rubber protection and shock-proof sensors ensure additional resistance to impact and vibration.
The innovative catalytic Ex sensor, with full range functionality, measures 0-100 %
LEL and 0-100 Vol.- % methane concentration. The calibration concept simplifies a calibration to vapors. When set for maximum sensitivity, the detector is even more reliable to warn about unknown hazards.
TECHNICAL DATA
Dimensions (W x H x D
Weight
Ambient conditions
Alarms
Battery options
Operating times
Charging times
Data logger
Pump operation
Approvals
1.85 x 5.08 x 1.22 inch (47 x 129 x 31 mm)
Approximately 7.8 oz. (220 g)
Temperature -4 to +122 °F, -20 to +50 °C,
Pressure
Humidity
Visual
Audible
700 to 1300 mbar, 20.7 to 38.4 inch Hg
10 to 95% RH
180°
Multi-tone >90 dB at 30 cm, 1 ft.
Vibration
Alkaline, rechargeable NiMH cells for alkaline pack, T4 battery pack
> 12 hours, with pulsed mode > 40 hours
< 4 hours
Can be read out via infrared approx. 1000 hours with 5 gases and a recording interval of 1 reading per minute
Maximum hose length 98 ft., 30 m.; 30 hours with 3 ”AA” alkaline
ATEX II 2G Ex d ia IIC T4/T3
I M2 Ex d ia II
Measurement performance certificate according to:
- EN 50104 (2002) + A1 (2004) O
2
- EN 45544 CO & H
2
S
- EN 60079-29-1:2007 Methane to Nonane
- EN 50271 1:2001 Software and
UL
CSA
IECEx
CE mark
MED
MSHA
Documentation
Class I Div. 1 Group A, B, C, D, E, F, G T-Code T4/T3
Class I, Div. I Group A, B, C, D, T-Code T4/T3
Ex d ia IIC T4/T3
Electromagnetic compatibility
Marine Equipment Directive 96/98/EC
ORDER INFORMATION
CONTAC T CUS TOMER SERVICE FOR KIT CONFIGUR ATIONS (1-800-858-1737)
Description
Dräger X-am 5000, basic instrument without power supply unit, with data logger, with manufacturer's and calibration certificates. Order battery and sensors separately.
Contact Dräger for additional sensors for the X-am 5000.
Alkaline power supply with AA batteries (2 required)
Rechargeable NiMH power supply unit T4
Additional power supply units
Battery charging set, consisting of: NiMH power supply unit T4 with charger module and connection cable (for worldwide use) for one charger module
Alkaline batteries (4 pc.) for alkaline power supply
Order No.
83 20 088
83 18 703
83 18 704
83 18 785
45 88 195
DRÄGER GAS DETECTION | 08
09 | DRÄGER GAS DETECTION
Dräger X-am 5600
Innovation in the palm of your hand. Dräger X-am 5600 — Unprecedented protection from the market’s smallest, infrared-capable, six-gas personal monitor.
SMALLES T DEVICE INCRE A SES YOUR
PRODUC TIVIT Y BIG TIME
As the smallest device of its type in the industry it is much less obtrusive on the user allowing him to focus on the task at hand. In addition the X-am 5600 can measure up to 6 gases at one time reducing the need for additional instruments.
Size comparison of t he X-am 5600 to t hree of its main competitors
GO E A SY ON YOUR BOT TOM LINE WITH
REDUCED TOTAL COS T OF OWNERSHIP
Dustproof and watertight monitors are only as reliable as their sensors. That’s why Dräger starts by engineering its infrared sensors to last up to eight years, keeping total cost of ownership low and instrument uptime high. In fact, Dräger’s 5 year warranty on the
IR sensors exceeds the industry average by 60% and there is no need to invest in new or additional equipment because the X-am 5600 works seamlessly with your existing Dräger X-am bump test stations, pumps, and calibration stations
KEEP YOUR TEAMS EVEN SAFER
The new Dräger infrared sensors can be used for the measurement of combustible hydrocarbons or
CO
2
. For those applications where the reliable measurement of these substances is specifically needed Dräger’s dual IR CO2/EX Sensor performs at its best. The innovative 2-in-1 design provides added protection and versatility by making room for an additional sensor.
PERSONAL MONITORING JUS T BECAME
CONVENIENT
Single-handed operation feels natural with its handheld ergonomic design. It’s a cinch to operate with a simple, two-button control panel. It maintains uninterrupted accuracy when worn in a pocket with its upper and front side mounted gas inlets. With Dräger, a world leader in gas detection technology and innovation, both bump tests and equipment calibrations are simple, quick, and professionally completed in no time.
Dräger X-am® 5600
Designed for durability and reliability—and single-handed detection of up to 6 gases
Innovation in the palm of your hand.
DRÄGER GAS DETECTION | 10
ORDER INFORMATION
Electrochemical Sensors
DrägerSensor XXS O
2
DrägerSensor XXS CO
DrägerSensor XXS CO HC
DrägerSensor XXS CO/H
2 compensated
DrägerSensor XXS H
2
S
DrägerSensor XXS H
2
S LC
DrägerSensor XXS H
2
S HC
DrägerSensor XXS CO/H
2
S
DrägerSensor XXS NO
DrägerSensor XXS NO
2
DrägerSensor XXS SO
2
DraegerSensor XXS NO
2
-LC
DrägerSensor XXS PH
3
DrägerSensor XXS PH
3
HC
DrägerSensor XXS HCN
DrägerSensor XXS NH
3
DrägerSensor XXS CO
2
DrägerSensor XXS CI
2
DrägerSensor XXS H
2
DrägerSensor XXS H
2
HC
DrägerSensor XXS OV
DrägerSensor XXS OV-A
DrägerSensor XXS Amine
DrägerSensor XXS Odorant
DrägerSensor XXS COCl
2
DrägerSensor XXS O
3
DrägerSensor XXS E CO
DrägerSensor XXS E H
2
S
DrägerSensor XXS E O
2
Measuring Range
0 – 25 Vol.-%
0 – 2,000 ppm
0 – 10,000 ppm
0 – 2,000 ppm CO
0 – 200 ppm
0 – 100 ppm
0 – 1,000 ppm
0 – 2,000 ppm CO / 0 – 200 ppm H
2
S
0 – 200 ppm
0 – 50 ppm
0 – 100 ppm
0 – 50 ppm
0 – 20 ppm
0 – 2,000 ppm
0 – 50 ppm
0 – 300 ppm
0 – 5 Vol.-%
0 – 20 ppm
0 – 2,000 ppm
0 – 4 Vol.-%
0 – 200 ppm
0 – 200 ppm
0 – 100 ppm
0 – 40 ppm
0 – 10 ppm
0 – 10 ppm
0 – 2,000 ppm
0 – 200 ppm
0 – 25 Vol.-%
Resolution
0.1 Vol.-%
2 ppm
5 ppm
2 ppm
1 ppm
0.1 ppm
2 ppm
1 ppm H
2
S / 2 ppm CO
0.1 ppm
0.1 ppm
0.1 ppm
0.02 ppm
0.01 ppm
1 ppm
0.1 ppm
1 ppm
0.1 Vol.-%
0.05 ppm
5 ppm
0.01 Vol.-%
0.5 ppm
1 ppm
1 ppm
0.5 ppm
0.01 ppm
0.01 ppm
2 ppm
1 ppm
0.1 Vol.-%
Communication accessories
Dräger GasVision ®
Dräger CC-Vision ®
USB DIRA with USB cable, communication adapter infrared to USB
PC communication set 1 with USB port, Dräger CC-Vision ® includes registration software
PC communication set 2 with USB port, Dräger CC-Vision ® includes registration software and barcode reader
Response time (t
90
)
10 sec.
15 sec.
25 sec.
25 sec.
15 sec.
15 sec.
15 sec.
20 sec.
10 sec.
15 sec.
15 sec.
15 sec
10 sec.
10 sec.
10 sec. (t
50
)
20 sec. (t
50
)
30 sec. (t
50
)
30 sec.
10 sec.
20 sec.
20 sec. (t
50
)
40 sec. (t
50
)
30 sec.
90 sec.
30 sec.
10 sec. (t
50
)
68 10 888
68 10 889
68 10 890
68 12 370
68 12 025
68 11 530
68 11 535
68 12 545
68 12 535
68 12 005
68 11 540
Order Code
68 10 881
68 10 882
68 12 010
68 11 950
68 10 883
68 11 525
68 12 015
68 11 410
68 11 545
68 10 884
68 10 885
68 12 600
68 10 886
68 12 020
68 10 887
15 sec.
15 sec.
10 sec.
68 12 212
68 12 213
68 12 211
Order code
83 14 034
64 08 515
83 17 409
83 18 761
83 18 762
11 | DRÄGER GAS DETECTION
Innovative Measuring for combustible gases
Dräger X-am 3000
The Dräger X-am 3000 Monitor is a small and innovative measuring device for Combustible Gases, O
2
, CO and H
2
S in industrial gas detection applications. Go about your job confidently knowing that the Dräger X-am 3000 will measure and alert you to dangerous gases and vapors.
alarm demand attention, even in high noise areas. Different alarm cadences distinguish between pre and main alarms. The large easy-to-read display quickly indicates the gases measured, their concentrations, and other relevant data to the user. An optional internal datalogger records all of the gas measurements and events for documentation purposes.
The most convenient feature of the Dräger X-am 3000 is the optional built-in remote sample pump. Everything is in one package for your confined space applications. Simply attach the pump adapter and hose and you’re ready to measure gases in a confined space. Additionally, the small profile of the Dräger
X-am 3000 makes it easy to take into a confined space or wear on one’s body all day.
The Dräger X-am 3000 may be small in size, but it is designed for use in the most demanding industrial environments. The rugged polymer housing is resistant to many corrosive chemicals as well as the bumps and drops that one may encounter in confined space entry or an industrial environment. All joints and openings are sealed or have gaskets to prevent the ingress of dirt or water. If required, an optional rubber boot provides additional protection to the Dräger X-am 3000. The Dräger X-am 3000 is very easy to use. The large display continuously displays the level of gas measured. The three large buttons on the front of the unit turn it ON and OFF, acknowledge alarms, and access frequently required features such as fresh-air calibration. Additional functions and features are accessed through plain text password-protected menus.
With the convenient internal sampling pump, the Dräger X-am
3000 is very well suited for confined space entry applications such as those found in the water/waste water industry, petrochemical plants and other applications.
Distinctive alarms means that you will always know when a hazardous level of gas is present. The two high intensity visual red alarm lights, a loud audible alarm and a standard vibrating
Dräger X-am® 3000
Designed for durability and reliability—and single-handed detection of up to 6 gases
T E C H N I C A L D ATA
Gases Detected
Dimension
Weight
Approvals
Combustible Gases, O
2
, CO and H
2
S.
3.5 x 5.5 x 2.1 inch (89 x 140 x 55 mm)
19.4 oz. (550 g)
UL: Class I, Division 1, Groups A-D, T4
CSA: Class I, Division 1, Groups A-D, T4
MSHA: permissible gas detector
ATEX: EEx iad IIC T4 (-25 to + 55°C)
D R Ä G E R X - A M 3 0 0 0 O R D E R I N F O R M AT I O N
The following part numbers include: Instrument w/pump, noted sensors, NiMH battery, battery charger, service tool, calibration and pump adapters, 10 ft. tubing, water-stop filter, calibration gas cylinder, regulator, rubber boot, and carry case.
Dräger X-am 3000 LEL, O
2
, CO, H
2
S Confined Space Kit
Dräger X-am 3000 LEL, O
2
, H
2
S Confined Space Kit
Dräger X-am 3000 LEL, O
2
, CO Confined Space Kit
Dräger X-am 3000 LEL, O
2
Confined Space Kit
45 43 721
45 43 720
45 43 719
45 43 740
The following part numbers include: Instrument, noted sensors, NiMH battery, battery charger, service tool, calibration adapter and instruction manuals. Pump units include pump adapter,
10 ft. tubing and water-stop filter.
Dräger X-am 3000 LEL, O
2
, CO & H
2
S with internal pump
Dräger X-am 3000 LEL, O
2 and H
2
S with internal pump
Dräger X-am 3000 LEL, O
2 and CO with internal pump
Dräger X-am 3000 LEL, O
2 with internal pump
Dräger X-am 3000 LEL, O
2
, CO, and H
2
S
Dräger X-am 3000 LEL, O
2 and H
2
S
Dräger X-am 3000 LEL, O
2 and CO
Dräger X-am 3000 LEL, O
2
Accessories
Alkaline Battery Pack
Internal Datalogger
MSHA Approved Update
Protective Rubber Boot
Leather Carrying Case
Nylon Carrying Case
X-am 3000 is available for rental.
45 43 718
45 43 717
45 43 716
45 43 739
45 43 715
45 43 714
45 43 713
45 43 738
83 17 716
45 43 625
45 43 745
83 17 727
45 43 618
83 17 720
DRÄGER GAS DETECTION | 12
13 | DRÄGER GAS DETECTION
Dräger X-am 7000:
Multiple gas measurement capabilities in one compact package.
DRÄGER X- AM 7000
The Dräger X-am 7000 Monitor combines electrochemical (EC), catalytic oxidation (CAT), photo ionization (PID) and infrared (IR) sensing technology for a total of up to 5 sensors. You can choose from over 25 different electrochemical
Dräger-Sensors ® , 3 different catalytic sensors, a PID Sensor and 3 different IR sensors.
The Dräger X-am 7000 is the smallest gas monitor in the world that can utilize all of these technologies in one compact package. The multiple gas measurement and internal pump capabilities make this unit an ideal choice for confined space entry applications like those found in refineries, chemical plants, utility passage ways, and paper mills.
sensor will measure hydrocarbons in inert backgrounds (without oxygen). The
IR-Ex is very good at measuring heavier hydrocarbons (like turpentine, kerosene and jet fuels) from ppm to %LEL levels.
Gases that poison catalytic sensors such as H
2
S, halogenated hydrocarbons, and silicones have no effect on the IR-Ex
Sensor making it ideal for industries that make or use these types of compounds.
Gases like methane and propane can be measured in ppm, %LEL, and %Vol.
measurement ranges (with the same instrument), which make the X-am 7000 well suited for the natural gas industry.
The Dräger X-am 7000 Monitor has many
“strengths”. The strong internal pump can draw gases from well over 150 ft. (45 m).
This is useful for deep ship holds, large storage silos or reaction towers in refineries. The integrated rubber boot and strong advanced polymer enclosure of the Dräger X-am 7000 withstands the toughest industrial environments, providing good resistance against dust, RFI interference, rain, and extreme temperatures. Loud audible and bright visual alarms warn the user that hazardous levels of gas are present. The standard NiMH battery pack will last well in excess of an
8-hour shift and the optional high capacity battery will allow operation times of greater than 20 hours.
Another strength of the Dräger X-am 7000 is the optional IR Sensor. The infrared combustible gas (IR-Ex) sensor measures a wide range of hydrocarbons.
However, unlike catalytic sensors, the IR
The IR-CO
The IR-CO
2
2 sensor makes the X-am 7000 the ideal choice for breweries, carbonated beverage bottlers, and bulk gas handlers who need to measure Carbon Dioxide.
sensor detects from low ppm levels to %Vol. concentrations of CO
2
.
The smart PID sensor measuring a wide range of VOC’s up to 5,000 ppm, depending on the gas selected. The
Dräger X-am 7000 has 20 compounds pre-programmed in its library and 3 user programmable entries available. This sensor is well suited for confined space entry, area monitoring and HazMat applications.
T E C H N I C A L D ATA
Smart PID Sensors
Smart EC Sensors
Smart IR Sensors
Smart CAT Sensors
Size
Weight
Approvals
VOC’s
O
2
, H
2
S, CO, CL
2
, NH
3
, NO
2
, SO
2
, HCN, CO
2
, NO, H
2
, H
2
S-HC, CO-HC,
PH
3
-HC, H
2
-HC, ClO
2
, Organic Vapors, Hydrides, Amines, Mercaptans,
Combustible Gases (Ex) or Carbon Dioxide (CO
2
)
Standard 100 %LEL Combustible Gas or 100% Vol. CH
4
5.9 x 5.5 x 2.9 inch (150 x 140 x 75 mm)
2.4 lbs. (1.09 kg) with standard battery
UL: Class I, Division 1, Groups A-D, T4
CSA: Class I, Division 1, Groups A-D, T4
ATEX: II2G EEx ia d IIC T4
M2 ia d I
D R Ä G E R X - A M 7 0 0 0 O R D E R I N F O R M AT I O N
The following Kits include the Dräger X-am 7000 Monitor with Internal Pump, integrated rubber boot, carrying strap, standard NiMH battery pack, noted sensors (with 5 year warranty), single-unit battery charger system, calibration adapter, pump adapter with water stop filter, and instruction manuals.
Dräger X-am 7000 Ex / O
2
/ H
2
S
Dräger X-am 7000 Ex / O
2
/ CO / H
2
S
Dräger X-am 7000 IR-CO
2
Dräger X-am 7000 IR-CO
2
/ O
2
Dräger X-am 7000 IR-Ex / O
2
Dräger X-am 7000 IR-Ex / O
2
/ CO / H
2
S
Dräger X-am 7000 with datalogger, PID only
Dräger X-am 7000 with datalogger, PID EX
Dräger X-am 7000 with datalogger, PID, EX, O
2
Dräger X-am 7000 with datalogger, PID, EX, O
2
, CO
Dräger X-am 7000 with datalogger, PID, EX, O
2
, CO, H
2
S
For other sensor selections, see pages 19-20.
Accessories
Leather Carrying Case
Nylon Transport Case
Dräger X-am 7000 is available for rental.
83 17 683
83 17 684
45 52 198
45 52 199
45 52 204
45 52 205
45 52 200
45 52 203
45 52 300
45 52 301
45 52 302
45 52 303
45 52 304
DRÄGER GAS DETECTION | 14
15 | DRÄGER GAS DETECTION
ACTUAL SIZE SHOWN
Pac 7000:
The innovative single gas instrument with reliable monitoring of ambient air.
DRÄGER PAC 7000 MONITOR
The innovative Dräger Pac ® 7000 is small and robust, ergonomic and intuitive, economic and powerful – t he Dräger
Pac 7000 is an impressive single gas monitor equipped wit h a wide range of functions.
SMALL AND RUGGED
With its handy, pocket-sized design, the Dräger Pac 7000 is tailor-made for personal monitoring in daily work activities.
Dräger Pac 7000 is dust proof and water resistant, meeting the requirements of IP 66/67.
SENSOR TECHNOLOGY
Dräger Pac 7000 boasts the latest XXS DrägerSensor ® technology, combining smaller size with high performance. Response time is very fast due to the short diffusion paths and the extremely quick electrochemical reaction times of these new sensors. The sensor is mounted in the unit so gas can enter from both the top and the front of the monitor. This positioning minimizes the possibility of the gas inlet being accidentally covered.
A strong, tough, stainless steel crocodile clip allows the instrument to be fastened securely anywhere. The clip can be rotated to the best position for user comfort. The dual alarm LED’s are positioned on opposite corners of the instrument for assured visibility. Battery and sensor replacement are easy and ensure a long instrument life.
AL ARM/ WARNING FUNC TIONS
Along with the strong internal vibrating alarm, attention getting visual and audible alarms are triggered if the user adjustable alarm thresholds are exceeded. A two-tone audible alarm is used to maximize notification. The Dräger Pac 7000 features adjustable TWA and STEL alarms as well. A warning is also given near the end of the battery life or in the event of an error.
DISPL AY
The concentration is displayed continuously in large, easy to read numbers. During an alarm, or on the push of a button, the display is backlit for better readability. Distinct icons are used to give status information and provide details on instrument functions. In addition, the peak concentration, time weighted average concentration (8-hour TWA value) and short-term exposure limit
(15-minute STEL) for the measurement period are readily accessed. The Dräger Pac 7000 will show TWA, STEL and MAX values at the touch of a button and measure CO to 2000 ppm.
The Dräger Pac 7000 offers on-board calibration and real time datalogging. The Dräger Pac 7000 sensors has a 2-year warranty, and are expected to operate more than 3 years. The sensor is field replaceable by the user. The unit will operate 5 - 10 months
24/7 using a replaceable Lithium alkaline battery.
T E C H N I C A L D ATA
Gases Measured
Dimensions
Weight
Approvals
H
2
S, CO, O
2 and other toxics
2.5 x 3.3 x 1.0 inch (64 x 84 x 25 mm)
3.8 oz. (106 g)
UL / ULc: Class I, Division 1, Groups A-G T4
MSHA: Permissible gas detector
ATEX: I/II 1/2G EEx ia I/IIC, T4
O R D E R I N F O R M AT I O N
Description
Dräger Pac 7000 CO
Dräger Pac 7000 H
2
S
Dräger Pac 7000 H
2
S-LC
Dräger Pac 7000 O
2
Dräger Pac 7000 HCN
Dräger Pac 7000 PH
3
Dräger Pac 7000 CO
2
Dräger Pac 7000 SO
2
Dräger Pac 7000 NO
2
Dräger Pac 7000 Cl
2
Dräger Pac 7000 NH
3
Dräger Pac 7000 OV
Dräger Pac 7000 OV-A
Dräger Pac 7000 NO
Measuring
Range
0 to 1999 ppm
0 to 100 ppm
0 to 100 ppm
0 to 25 Vol.-%
0 to 50 ppm
0 to 20 ppm
0 to 5 Vol.-%
0 to 100 ppm
0 to 50 ppm
0 to 20 ppm
0 to 300 ppm
0 to 200 ppm
0 to 200 ppm
0 to 200 ppm
Alarm
Threshold A1
35 ppm
10 ppm
10 ppm
19.5 Vol.-%
2.5 ppm
0.1 ppm
0.5 Vol.-%
2 ppm
2.5 ppm
0.5 ppm
25 ppm
5 ppm
5 ppm
2.5 ppm
Alarm
Threshold A2
50 ppm
15 ppm
20 ppm
23.5 Vol.-%
4.5 ppm
0.2 ppm
1.0 Vol.-%
4 ppm
5 ppm
1 ppm
50 ppm
10 ppm
10 ppm
5 ppm
Order
Number
83 18 970
83 18 971
83 21 004
83 18 972
83 18 973
83 18 974
83 18 975
83 18 976
83 18 977
83 18 978
83 18 979
83 10 006
83 10 007
83 21 263
5 Y E A R W A R R A N T Y M O N I T O R S F O R O
2
, C O , H
2
S O R D E R I N F O R M AT I O N
Description
Dräger Pac 7000 5Y CO
Dräger Pac 7000 5Y H
2
S
Dräger Pac 7000 5Y O
2
Measuring
Range
0 to 1999 ppm
0 to 100 ppm
0 to 25 Vol.-%
Alarm
Threshold A1
35 ppm
10 ppm
19.5 Vol.-%
Alarm
Threshold A2
50 ppm
20 ppm
23.5 Vol.-%
Order
Number
83 21 031
83 21 032
83 21 033
A C C E S S O R I E S
Connecting Cradle, complete with USB cable and Dräger PacVision ® software
Lithium battery
Dust and water filter (4 per pkg)
Leather carrying case
Smart Bump Test Station, (order gas cylinder 58 L separately)
E-Cal instrument module for connection of 4 Dräger Pac 3500, 5500 or 7000 to a
Dräger E-Cal Master Station or to Module Adapter
83 18 587
45 88 183
45 43 836
45 43 822
83 19 559
83 18 589
DRÄGER GAS DETECTION | 16
17 | DRÄGER GAS DETECTION
Pac 3500/5000 Monitors:
Accurate, quick, reliable detection.
DRÄGER PAC 3500/5500 MONITORS
Accurate and easy to use, t he Dräger Pac ® 3500 and t he Dräger Pac ® 5500 are ideal for industrial personal monitoring applications. Providing quick detection of carbon monoxide, hydrogen sulfide or oxygen, t hese robust single gas detectors are made specifically to fit industrial safety requirements. The small, ergonomic
Dräger Pac ® 3500 has a lifetime of 2 years, while t he Dräger Pac ® 5500 has no lifetime limitation.
SMALL AND ROBUST HOUSING
Small in size and light in weight, the
Dräger Pac ® 3500 and the Dräger Pac ®
5500 were developed with the needs of industrial users and applications in mind.
The instruments provide easy, singlehanded operation, even when wearing gloves, and is designed to withstand the toughest environments. The impactresistant rubber housing is impervious to corrosive chemicals and meets the requirements of IP 66/67 to ensure operation even when sprayed with water.
HIGHLY VISIBLE DISPLAY
The large display, easily seen at a glance, shows both the gas concentration and the measurement unit. Alternatively, the instrument can be configured to show only the gas detected. The concentration is displayed only when the set alarm level has been exceeded. Language-free to avoid any misunderstanding, the continuous numeric display can also be back-lit to improve readability in darker environments.
SAFETY FIRST
To ensure continuous operation even when the unit is in a shirt pocket, the instrument’s sensor has been carefully positioned to allow gas intake from both the top and the front of the device.
WARNINGS AND ALARMS
In addition to a vibrating alarm, these instruments emit an audible, multi-tone signal and a clear, 360° visual alarm via bright, flashing LEDs at the top and base of the instrument. The alarm threshold levels can be individually adjusted to comply with company policy or other standards using Dräger software.
MINIATURE SENSOR TECHNOLOGY
The latest miniature Dräger XXS sensor technology has been incorporated into both the Dräger Pac ® 3500 and the
Dräger Pac ® 5500. Dräger XXS sensors have been specifically developed for use in personal monitoring and handheld applications. These innovative sensors, which offer a long, expected life span from 5 to 8 years, combine high performance with a fast reaction time of just ten seconds.
EVENT LOGGER
These monitors are complete with an infrared interface and are able to store up to 60 events with dates and times. They can be easily linked to a PC via a connecting cradle. This means that significant events such as switching on or off, gas and battery alarms, error codes, configuration changes, fresh air calibrations and bump tests can be downloaded, printed and stored centrally for future reference or reporting purposes.
DRÄGER GAS DETECTION | 18
DRÄGER X- AM PAC ® 3500/5500 MONITOR O R D E R I N F O R M AT I O N
Description
Dräger Pac ® 3500 CO
Dräger Pac ® 3500 H
2
S
Dräger Pac ® 3500 H
2
S w/ yellow keypad overlay
Dräger Pac ® 3500 O
2
Dräger Pac ® 3500 O
2 w/ blue keypad overlay
Dräger Pac ® 5500 CO
Dräger Pac ® 5500 H
2
S
Dräger Pac ® 5500 H
2
S w/ yellow keypad overlay
Dräger Pac ® 5500 O
2
Dräger Pac ® 5500 O
2 w/ blue keypad overlay
Measuring
Range
0 – 500 ppm
0 – 100 ppm
0 – 100 ppm
0 – 25 Vol.-%
0 – 25 Vol.-%
0 – 500 ppm
0 – 100 ppm
0 – 100 ppm
0 – 25 Vol.-%
0 – 25 Vol.-%
Default Alarm
Threshold A1/A2
35/50
10/15
10/15
19.5/23.5
19.5/23.5
35/50
10/15
10/15
19.5/23.5
19.5/23.5
Resolution
1 ppm
0.1 ppm
0.1 ppm
0.1 Vol.-%
0.1 Vol.-%
1 ppm
0.1 ppm
0.1 ppm
0.1 Vol.-%
0.1 Vol.-%
Accessories
Leather carrying case
High visibility yellow overlay for H
2
S instruments
High visibility blue overlay for O
2 instruments
Communication Accessories
Dräger CC-Vision ®
Communication Module, complete with USB cable and Dräger PacVision ® software
Calibration Accessories
Calibration adapter
Dräger Pac Module for Dräger E-Cal calibration system
Dräger Bump Test Station for Dräger Pac ® 3500/5500, (order gas cylinder separately)
Dräger Smart Bump Test Station for Dräger Pac ® 3500/5500 (order gas cylinder separately)
The station for use with Dräger Mobile Printer.
Printer Set for Dräger Bump Test Station
Consisting of: Dräger Mobile Printer, single charger, rechargeable NiMH batteries, USB connection cable, positioning aid, Dräger CC-Vision ®
Replacement Parts
Lithium battery
Water and dust filter
Response
Time
15 sec.
15 sec.
15 sec.
10 sec.
10 sec.
15 sec.
15 sec.
15 sec.
10 sec.
10 sec.
Order No.
45 43 957
45 43 958
45 43 963
45 43 959
45 43 964
45 43 960
45 43 961
45 43 965
45 43 962
45 43 966
45 43 822
83 20 978
83 20 977
64 08 515
83 18 587
83 18 588
83 18 589
83 17 410
83 19 559
83 21 010
45 88 183
45 43 836
19 | DRÄGER GAS DETECTION
ELEC TROCHEMICAL (EC) SENSORS
The sensor is t he heart of any gas detection instrument. Dräger is one of t he few manufacturers of gas detection instruments who also make t heir own sensors and we have more experience wit h t his technology t han anyone else. Over many years,
Dräger-Sensors ® have proven t hemselves, even under t he most difficult conditions.
Our latest generation of sensors, t he Extra Stability (XS), provide outstanding performance in a wide range of industrial applications.
DRÄGER-SENSOR ® XS-R
The XS-R sensors offer the longest warranties and require the least maintenance of any sensor in the industry. The
Dräger-Sensors ® XS-R for CO, H
2
S and O
2 are covered by an unequalled 5-Year
Warranty! Yes, even our O
2 sensor which continuously detects oxygen for a period of
5 years! This is far better than what other manufacturers can offer. Calibration is only required on a yearly basis which greatly reduces down time and maintenance costs. The XS-R series offers the best cost of ownership through their unsurpassed stability and longevity.
DRÄGER-SENSOR ® XS
There are 34 different XS sensors currently available that will measure over 50 different toxic gases and vapors. This is possible through our patented three-electrode sensor technology and internal filter media that maximizes response to the gas of concern while greatly reducing responses to other gases that may be present. The superior stability and accuracy of Dräger-Sensors ® is especially evident on the reactive gas and exotic gas sensors where longer lives and less frequent calibration is required. The large selection of Dräger-Sensors ® allows you to meet a wider range of gas detection applications with your Pac 7000, X-am 2000,
X-am 5000, X-am 5500 or X-am 7000 monitors.
The CO, H
2
S and O
2 version of the Dräger-
Sensors ® XS are provided with a long
3-year warranty.
DRÄGER-SENSOR ® XS-2
Our XS-2 Sensors offer the same advanced technology of the other Dräger-Sensors ® in a value priced package. Available for CO,
H
2
S and O
2
, these sensors come with a standard 2-year warranty. Even this series of Dräger-Sensors ® offers superior performance and stability over other sensor brands.
DRÄGER-SENSOR ® XXS FEATURES
- The longest warranties offered by any manufacturer
- Fast and accurate response to changing gas concentrations
- Extra stability sensors that drift less and require less frequent calibration
- Superior operating temperature range
(-40 to +105 °F / -40 to +40 °C) and stability due to an internal thermal compensating device
- A wide operating pressure range
(20.7 to 38.4 in Hg /700 to 1300 mbar) due to a unique mechanical design of the sensor
- The ability to withstand and recover from high concentration exposures
- Calibration intervals of 6-12 months
- Dräger-Sensor ® XXS combines “New
Sensor Technology” from the Dräger
Pac 7000 with “Dräger Sensor
Technology” from the Dräger X-am 5000
Dräger-Sensor ® XXS
Dräger-Sensor ® XS-R
Dräger-Sensor ® XS-2
DRÄGER GAS DETECTION | 20
Gas
1-Chloro-2,3-epoxypropane
Acetaldehyde
Acrylonitrile
Ammonia
Arsine
Bromine
Butadiene
Butyl Mercaptan
Carbon Dioxide
Carbon Monoxide (2 Year Warranty)
Carbon Monoxide (3 Year Warranty)
Carbon Monoxide (5 Year Warranty)
Carbon Monoxide (High Concentration)
Chlorine
Chlorine Dioxide
Diborane
Diethylamine
Diethyl Ether
Dimethylamine
Dimethyl Sulfide
Dimethyl Disulfide
Ethanol
Ethine
Ethyl Mercaptan
Ethylene
Ethylene Oxide
Formaldehyde
Fluorine
Germane
Hydrazine (Pac III only)
Hydrazine "D" (Pac III only)
Hydrogen
Hydrogen (High Concentration)
Hydrogen Chloride (Pac III only)
Hydrogen Cyanide
Hydrogen Fluoride (Pac III only)
Hydrogen Peroxide (Pac III only)
Hydrogen Selenide
Hydrogen Sulfide (2 Year Warranty)
Hydrogen Sulfide (3 Year Warranty)
Hydrogen Sulfide (5 Year Warranty)
Hydrogen Sulfide (High Concentrations)
Hydrogen Sulfide (Sensitivity Revised)
Isobutane
Iso-Propyl Alcohol
Methanol
Methylamine
Methyl Mercaptan
Nitric Oxide
Nitrogen Dioxide
Oxygen 100% Vol.
Oxygen (2 Year Warranty)
Oxygen (3 Year Warranty)
Oxygen (5 Year Warranty)
Ozone
Phosgene
Phosphine
Phosphine (High Concentration)
Propylene
Propylene Oxide
Silane
Styrene
Sulfur Dioxide
Tetrahydrofuran
Tetrahydrothiophene
Triethylamine
Vinyl Acetate
Vinyl Chloride
D R Ä G E R X S T O X I C G A S A N D V A P O R S E N S O R S E L E C T I O N
Sensor (XXS)
OV(XXS)
OV(XS)
OV-A(XXS)
NH
3
(XXS)
PH
3
(XXS)
Cl
2
(XXS)
OV (XXS)
Odorant (XXS)
CO
2
(XXS)
CO (XXS)
-
CO E (XXS)
CO-HC (XXS)
Cl
2
(XXS)
Cl
2
(XXS)
PH
3
(XXS)
Amine (XXS)
OV-A(XXS)
Amine (XXS)
Odorant (XXS)
Odorant (XXS)
OV-A (XXS)
OV-A (XXS)
Odorant (XXS)
OV (XXS)
OV (XXS)
OV (XXS)
Cl
2
(XXS)
-
-
-
H
2
(XXS)
H
2
-HC (XXS)
-
HCN (XXS)
-
-
-
H
2
S (XXS)
-
H
2
S E (XXS )
H
2
S -HC (XXS)
H
2
S -LC (XXS)
OV-A (XXS)
OV (XXS)
OV (XXS)
Amine (XXS)
Odorant (XXS)
NO (XXS)
NO
2
(XXS)
-
O
2
(XXS)
-
O
2
E (XXS)
O
3
(XXS);
COCl
2
(XXS)
PH
3
(XXS)
PH
3
HC (XXS)
OV (XXS)
OV (XXS)
PH
3
(XXS)
OV-A (XXS)
SO
2
(XXS)
OV (XXS)
Odorant (XXS)
Amine (XXS)
OV-A (XXS)
OV (XXS)
Sensor (XS)
-
-
OV-A(XS)
NH
3
(XS)
Hydride (XS)
Cl
2
(XS)
OV(XS)
Odorant (XS)
CO
2
(XS)
CO (XS-2)
CO (XS)
CO (XS-R)
-
Cl
2
(XS)
CIO
2
(XS)
Hydride (XS)
Amine (XS)
OV (XS)
Amine (XS)
Odorant (XS)
Odorant (XS)
OV(XS)
-
Odorant (XS)
OV (XS)
OV (XS)
OV (XS)
Cl
2
(XS)
Hydride (XS)
Hydrazine (XS)
N
2
H
4
D (XS)
H
2
(XS)
H
2
-HC (XS)
HF/HCI (XS)
HCN (XS)
HF/HCI (XS)
H
2
O
2
(XS)
Hydride (XS)
H
2
S (XS-2)
H
2
S (XS)
H
2
S (XS-R)
H
2
S -HC (XS)
H
2
S -SR (XS-2)
-
OV (XS)
OV (XS)
Amine (XS)
Odorant (XS)
NO (XS)
NO
2
(XS)
O
2
-100% (XS)
O
2
(XS-2)
O
2
(XS)
O
2
(XS-R)
-
COCl
2
(XS)
Hydride (XS)
PH
3
HC (XS)
OV (XS)
OV (XS)
Hydride (XS)
OV-A(XS)
SO
2
(XS)
-
Odorant (XS)
Amine (XS)
OV (XS)
OV (XS)
Range Resolution
Part No.
(XXS)
Part No.
(XS)
0-100 ppm
0-200 ppm
0-100 ppm
0-300 ppm
0-20 ppm
0-20 ppm
0-100 ppm
0-40 ppm
0-5 %Vol.
0-2000 ppm
0-2000 ppm
0-2000 ppm
0-10,000 ppm
0-20 ppm
0-20 ppm
0-20/0-1 ppm
0-100 ppm
0-200 ppm
0-100 ppm
0-100 ppm
0-40 ppm
0-300 ppm
0-100 ppm
0-40 ppm
0-100 ppm
0-200 ppm
0-100 ppm
0-20 ppm
0-20 ppm
0-3 ppm
0-3 ppm
0-2,000 ppm
1 ppm
0.5 ppm
1 ppm
0.5 ppm
0.5 ppm
0.5 ppm
0.5 ppm
0.5 ppm
0.5 ppm
0.5 ppm
0.5 ppm
0.05 ppm
0.01 ppm
0.01 ppm
0.01 ppm
5 ppm
0.5 ppm
0.5 ppm
0.5 ppm
1 ppm
0.01 ppm
0.05 ppm
0.05 ppm
0.5 ppm
86 11 530 -
68 09 115 -
68 11 535 68 09 522
68 10 888 68 09 145
68 10 886 68 09 135
68 10 890 68 09 168
68 11 530 68 09 115
68 12 535 68 09 200
0.1 %Vol.
2/1 ppm
1 ppm
1 ppm
68 10 889 68 09 175
68 10 882 68 10 365
-
68 12 212
68 09 105
68 10 258
5 ppm
0.05 ppm
68 12 010 68 09 120
68 10 890 68 09 165
0.05/0.01 ppm 68 10 890 68 11 360
0.01 ppm 68 10 886 68 09 135
68 12 545
68 11 353
68 12 545
68 12 535
68 12 535
68 11 535
68 11 530
68 11 530
68 11 530
68 10 890
-
-
-
68 12 370
68 09 545
68 09 522
68 09 545
68 09 200
68 09 200
68 09 115
68 11 530 -
68 12 535 68 09 200
68 09 115
69 09 115
70 09 115
68 09 165
68 09135
68 09 190
68 10 295
68 09 185
0-4 %Vol.
0-30 ppm
0-50 ppm
0-30 ppm
0.1 %Vol.
0.1 ppm
0.1 ppm
0.1 ppm
0-20 ppm
0-1 ppm
0.1 ppm
0.01 ppm
0-200/100 ppm 1 ppm
0-100 ppm 1 ppm
68 12 025 68 11 365
68 09 140
68 10 887 68 09 150
68 09 140
-
68 09 170
68 09 135
68 10 883 68 10 370
68 09 110
0-100 ppm
0-1,000 ppm
0-100
0-300 ppm
2 ppm 68 12 213 68 10 260
2 ppm/1 ppm 68 12 015 68 09 180
0.1 ppm
1 ppm
68 11 525 68 10 575
68 11 535 -
0-300 ppm 0.5 ppm
0-200/100 ppm 0.5 ppm
0-100 ppm
0-40 ppm
1 ppm
0.5 ppm
68 12 530
68 11 530
68 12 545
68 12 535
68 09 115
69 09 115
68 09 545
68 09 200
0-200 ppm
0-50 ppm
0-100 %Vol
0-25 %Vol
0-25 %Vol
0-25 %Vol
0-10 ppm
0-10 ppm
0-20 ppm
0-2,000/1,000
0-100 ppm
0-200 ppm
0-50 ppm
0-100 ppm
0-100 ppm
0-200 ppm
0-40 ppm
0-100 ppm
0-100 ppm
0-100 ppm
0.1/0.5 ppm
0.1 ppm
0.5 %Vol.
0.1 %Vol.
0.1 %Vol.
0.1 %Vol.
0.01 ppm
0.01 ppm
0.01 ppm
1 ppm
1 ppm
0.5 ppm
0.01 ppm
0.5 ppm
0.1/0.5 ppm
0.5 ppm
0.5 ppm
1 ppm
0.5 ppm
0.5 ppm
68 11 545 68 09 125
68 10 884 68 09 155
68 09 550
69 10 881 68 10 375
-
68 12 211
68 11 540
68 12 005
68 09 130
68 10 262
-
68 08 582
68 10 886 69 09 135
68 12 020 68 09 535
68 11 530 68 09 115
68 11 530 69 09 115
68 10 886 68 09 135
68 11 535 68 08 522
68 10 885 68 09 160
68 11 530 -
68 12 535 68 09 200
68 12 545 68 09 545
68 11 535 68 09 115
68 11 530 68 09 115
21 | DRÄGER GAS DETECTION
Easy Calibration
while saving time and money.
DRÄGER E- CAL SYS TEMS
The Dräger E-Cal system makes calibrating your Dräger gas detection instruments easy while saving time and money. The Dräger E-Cal system automatically calibrates up to 10 gas monitors and documents t he entire process making it ideal for ISO-9001 compliance.
The Dräger E-Cal Station also bump tests, downloads stored information, charges the instrument, and changes instrument configurations with the included
CC-Vision ® software. This computer control ensures that the calibration is done properly every time according to Dräger’s exacting specifications. The Dräger E-Cal system supports different calibration gases, even mixed gases and many non-standard gases. You can start with as little as a single drop-in instrument module and expand as your needs grow.
Instrument modules can work alone as remote bump test or calibration modules using the adapter. The Dräger E-Cal system makes use of “parallel” processing to simultaneously process instruments yielding significant savings in gas, time, and money.
THE DRÄGER E-CAL SYSTEM FEATURES
- Simultaneous automatic calibration of up to 10 instruments at once saving time and money.
- Automatic bump testing, calibration, documentation, datalogging, and charging at each station.
- CC-Vision ® Software provides state-of-the-art asset management and complete ISO-9001 compliance for your instrument program.
- The Dräger E-Cal System is closed and self-purging allowing operation without an expensive fume-hood. With optional purge module you can exhaust gas more than 75 feet away.
- Modules can function independently with or without a PC as “bump” stations or as mixed gas autocal stations for smaller users.
- Compatible with Dräger instruments.
T E C H N I C A L D ATA
Dimensions
Master Station (l x w x h)
Dräger Pac X000 Module (l x w x h)
Dräger X-am 1/2/5000 Module (l x w x h)
Dräger X-am 3000 Module (l x w x h)
Dräger X-am 7000 Module (l x w x h)
Computer Requirements
Computer System
Operating System
Connections
DRÄGER E- CAL SYS TEMS O R D E R I N F O R M AT I O N
Master Station 2 USB (with inputs for 2 gas bottles)
Master Station 12 USB (with inputs for up to 12 gas bottles)
Master Station 6 USB (with inputs for up to 6 gas bottles)
Module Adapter USB (for single instrument module)
Dräger Pac X000 Module
Dräger X-am 1/2/5000 E-Cal Module
Dräger X-am 3000 E-Cal Module
Dräger X-am 7000 E-Cal Module
12.3 x 12.1 x 2.5 in (295 x 290 x 60 mm)
12.3 x 10.0 x 2.5 in (295 x 240 x 60 mm)
12.3 x 5.6 x 2.5 in (295 x 135 x 60 mm)
12.3 x 10.0 x 2.5 in (295 x 240 x 60 mm)
12.3 x 10.0 x 2.5 in (295 x 240 x 60 mm)
IBM Compatible PC
Windows XP, Windows 7
1 available USB port with appropriate adapters, or combination
83 19 452
83 19 412
83 194 56
83 19 409
83 18 589
83 18 754
83 17 719
83 17 705
DRÄGER GAS DETECTION | 22
23 | DRÄGER GAS DETECTION
Dräger’s Full Range of Calibration Gases
All gas detection sensors require periodic calibration or bump testing. Dräger offers a full range of calibration gas mixtures in various concentrations and related supplies.
T O X I C G A S E S
The following gases are most commonly requested and recommended calibration gases for TWA measurements. Other gases and concentrations are available, contact Dräger for the full selection of calibration gases.
Chemical
Ammonia (NH
3
)
Carbon Dioxide (CO
2
)
Carbon Monoxide (CO)
Chlorine (CL
2
)
Ethylene (for OV Sensor)
Hydrogen Chloride (HCL)
Hydrogen Cyanide (HCN)
Hydrogen Sulfide (H
2
S)
Nitric Oxide (NO)
Nitrogen Dioxide (NO
2
)
Phosphine (PH
3
)
Sulfur Dioxide (SO
2
)
CH
4
/CO/SO
2
/CO
2
/O
2
CH
4
/CO/H
2
S/O
2
CH
4
/CO/H
2
S
2
/O
2
H
2
S
C O M B U S T I B L E G A S E S
Concentration
50 ppm in N
2
2.5 %Vol. in Air
50 ppm in N
2
5 ppm in N
2
100 ppm in Air
10 ppm in N
2
10 ppm in N
2
25 ppm in N
2
25 ppm in N
2
10 ppm in N
2
0.5 ppm in N
2
10 ppm in N
2
50% LEL / 100 ppm / 10 ppm / 2.5% / 17.0%
50% LEL / 100 ppm / 25 ppm / 17.0%
50% LEL / 100 ppm / 25 ppm / 17.0%
25 ppm
Chemical
Hydrogen
Methane (CH
4
)
Methane (CH
4
)
Pentane
Propane
Concentration
50% LEL (2.0 %Vol.) in Air
50% LEL (2.5 %Vol.) in N
2
40 %Vol. in N
2
50% LEL (0.75 %Vol.) in N
2
35% LEL (0.75 %Vol.) in Air
M U LT I - C O M P O N E N T C A L I B R AT I O N G A S E S
Chemical/Concentration
Methane 50% LEL / CO, 100 ppm / H
2
S 25 ppm / O
2
, 17% / bal N
2
Methane 50% LEL / CO, 100 ppm / H
2
S 25 ppm / in N
2
Methane 5 % LEL / CO, 100 ppm / in N
2
Pentane 30% LEL / CO, 100 ppm / H
2
S 25 ppm / N
2
Pentane 30% LEL / CO, 100 ppm / O
2
, 17% / bal N
2
C Y L I N D E R R E G U L AT O R S
Chemical/Concentration
Standard Regulator, suitable for most calibration gases
Trigger Control Regulator, allows both calibration and bump testing
Demand Valve Regulator, for use with sampling pumps
Reactive Gas Regulator, for use with NH
3
Gas
BUMP TES T GA SES (CYLINDER REGUL ATOR NOT REQUIRED)
Cylinder
58L/500 psi
103L/1000 psi
103L/1000 psi
58L/500 psi
103L/1000 psi
58L/500 psi
58L/500 psi
58L/500 psi
58L/500 psi
58L/500 psi
58L/500 psi
58L/500 psi
116L/1000 psi
116L/1000 psi
116L/1000 psi
116L/1000 psi
Cylinder
103L/1000 psi
103L/1000 psi
34L/500 psi
80L/750 psi
103L/1000 psi
Cylinder
58L/500 psi
58L/500 psi
103L/1000 psi
58L/500 psi
103L/1000 psi
Max. Pressure
1000 psi
1000 psi
1000 psi
500 psi
Part No.
45 94 957
45 95 193
45 02 153
45 94 964
45 94 645
45 94 658
45 94 962
45 02 155
45 52 020
45 94 977
45 97 057
45 97 050
45 97 160
45 97 161
45 97 162
45 97 163
Part No.
45 94 627
45 57 019
45 94 625
45 10 057
45 94 624
Part No.
45 94 655
45 94 943
45 94 945
45 94 944
45 94 947
Part No.
45 57 020
45 94 640
45 95 641
45 94 952
Chemical/Concentration
Hydrogen Sulfide (H
2
S)/ 25 ppm in N
2
Carbon Monoxide (CO)/ 100 ppm in Air
Methane (CH
4
)/ 50 %LEL in Air
Methane, 50% LEL / CO, 100 ppm / 17% O
2
/ bal N
2
Methane, 50% LEL / CO, 100 ppm / H
2
S, 25 ppm / 17% O
2
/ bal N
2
Cylinder
11L/155 psi
11L/155 psi
11L/155 psi
11L/155 psi
11L/155 psi
Part No.
45 94 634
45 94 682
45 94 633
45 94 635
45 94 636
DRÄGER GAS DETECTION | 24
Calibrate, configure and document
DRÄGER SOF T WARE
GAS-VISION ®
Document gas and vapor exposures measured with Dräger instruments equipped with internal data loggers.
Quickly and easily determine TWA and
STEL exposures. Create graphs and spreadsheets from this data for documentation and reporting purposes with included graphical and tabular report generators. Dräger Gas-Vision ® is also a complete management tool that will manage the stored exposure data for you. Search previous reports by date, gas measured, or person monitored and get only the information you need including serial numbers and sensor calibration dates for the monitors used.
CC-VISION ®
Calibrate, configure, and document all maintenance of your Dräger instruments with Dräger CC-Vision ® Software. A complete maintenance record can be automatically created and stored when calibrating your Dräger monitor with
CC-Vision ® .
CC-Vision ® speeds up your maintenance while drastically reducing the amount of paperwork. This tool is ideal for ISO 9001 or similar quality documentation. All serial numbers, installed sensors, and configurations are automatically stored with
CC-Vision’s ® on-board report generation and management system. CC-Vision ® also allows the point-and-click setup of your instruments via a “Browser”–type interface, including alarm levels, menus, and sensor status. Training technicians and users is made much easier and requires less use of complicated written manuals. Save certain configurations to a disk and later download them to your instrument for rapid configuration.
CC-Vision ® also makes possible the new tamper-proof “end-user” no features mode for more reliable field operations.
DRÄGER SOF T WARE ORDER INFORMATION
Gas-Vision ® (exposure documentation)
CC-Vision ® (calibrate and configure, single unit version)
83 14 034
64 08 515
25 | DRÄGER GAS DETECTION
Dräger Support Materials
GAS DETECTION SELECTION GUIDE
This booklet lists the most common industrial chemicals and whether there is a Dräger-Tube ® , Dräger CMS-Chip, and/or
Dräger-Sensor ® available for detecting this substance. The
Selection Guide also includes a list of the Dräger Detection products available with measuring ranges and order information.
Contact our Customer Service Department for a free copy of this valuable field guide for health and safety professionals.
DRÄGER-TUBE ® /DRÄGER CMS HANDBOOK
Everything you wanted to know about Dräger-Tubes ® and
Dräger-CMS Chips in one book. Measurement Data, Operating
Conditions, Reaction Principles, Cross Sensitivity, Range
Extension information, and full color graphics of the tubes are is given in one handy to use format. The new 15th edition Tube
Handbook also contains general detector tube and chemical information and is a good reference source for any health and safety professional.
VOICE ® ON DRÄGER.COM
Determine the best Dräger detection tool for your application with VOICE ® software. Search from over 1600 different substances by chemical name, chemical formulas, trade names,
CAS Numbers, UN/DOT Numbers, and other synonyms. Once the chemical is located, VOICE will tell you what Dräger devices are available for measurement. Electronic Instruction Sheets for all Dräger-Tubes ® are included.
DRÄGER SOF T WARE ORDER INFORMATION
Dräger-Tube ® /CMS Handbook (16th edition)
Dräger-Sensor® Handbook (1st edition)
Dräger-Sensor ® Handbook CD (1st edition)
90 92 086
90 46 571
45 95 444
Dräger-Training and Training Software
Even t hough Dräger equipment is simple to operate, t he new equipment must be understood by all who use t hem. To make your job easier, Dräger Safety has created training tools in MS Power Point to aid in t he implementation of your new equipment. These programs contain operating training modules, a competency test, helpful maintenance tips, and a guide to accessories and options.
COMPUTER BASED TRAINING
(CBT) PROGRAMS
Computer Based Training programs identify the monitor components, alarm signals and display icons. When it comes to operating the monitor, the CBT contains a
“virtual instrument” that mimics the exact operation of the gas detector. This is supplemented with video clips that will guide you through performing all of the operator functions of the monitor. At the end of the training course there is a competency test.
If a satisfactory grade is not achieved, the program will take the user back through the CBT course. When a passing grade is achieved, a certificate is printed. Training records can be reviewed and are able to be exported to a database for documentation of the training.
DRÄGER-TRAINING
Let our experienced and knowledgeable trainers teach your staff. We provide basic operation training, service and maintenance levels for your technicians and application safety courses like confined space entry or emergency response.
Call Dräger-Service for more information.
DRÄGER TR AINING SOF T WARE ORDER INFORMATION
Dräger-Tube ® /accuro ® Pump Training CD
Dräger CMS Operator Training CD
Dräger Haz-Mat Simultest Operator Training CD
Dräger X-am 3000 Operator Training CD
Dräger X-am 7000 Operator Training CD
Drager X-act 5000 Video Tutorial
Drager Civil Defense Simultest Operator Training CD
40 56 835
40 56 637
40 56 561
45 43 701
45 52 286
45 23 620
40 56 666
DRÄGER GAS DETECTION | 26
27 | DRÄGER GAS DETECTION
Accurate
gas measurements
made easier.
DRÄGER CMS ANALY Z ER
Accurate gas measurements are made easier wit h t he Dräger-CMS ® . This spotcheck detection device is literally as easy as 1-2-3 to operate. Simply insert one of t he over 50 chemical specific CMS Chips and follow t he instructions on t he display as to when to move t he slide switch. TWA levels are typically analyzed in
1-2 minutes. Upon completion of t his process, t he concentration is indicated on t he LCD display. Every Chip uses t he exact same procedure so training is minimal.
The system is based on Dräger’s 70+ years of dry chemical reaction technology used in Dräger-Tubes ® , however, the
Dräger CMS includes a mass flow controller to take a precise air sample and the color change is measured with a photo-optical system eliminating any human subjectivity. Accuracies of +/- 4 to
10% of measured values are achieved for most gases and vapors.
An optional remote sampling system makes the Dräger CMS an ideal choice for confined space entry applications.
The on-board data-recorder stores up to
50 measurements with the gas/concentration and date/time. The recorder can be set up to record manually or automatically, and previous measurements can be called up on demand.
Dräger CMS does not require gas calibration. All measurement and calibration information is stored on a bar code on the CMS Chip. An electronic leak check is performed before each measurement so you are assured of accurate indications every time. Operating on 4 “AA” cells, the Dräger CMS will deliver about
100 measurements per battery change.
The Dräger CMS is currently used extensively in the petrochemical, transportation, and utilities industries as well as the fire service and government regulatory agencies. Popular applications include
TWA screening, confined space entry and emergency response.
Dräger CMS Chip
Miniaturized Dräger-Tubes
DRÄGER GAS DETECTION | 28
S P E C I F I C AT I O N S
Dimensions
Weight
Operational Temperature
Ingress Protection
Data Capacity
Power Supply
Battery Duration
Approvals
O R D E R I N F O R M AT I O N
Description
CMS Analyzer with Data Recorder
Remote System
CMS Analyzer with Remote System
Telescopic Probe (requires remote system)
10 meter Sampling Hose (use with 8317700)
Nylon Transport Case
Molded Plastic Transport Case
Leather Carrying Case with Shoulder Strap for Analyzer
Leather Carrying Case for Chips
4.1 x 8.5 x 2.5 inch (105 x 215 x 65 mm)
25.6 oz. (730 g)
32 - 104 °F (0 - 40 °C)
IP-54, protected against dust and water
Stores up to 50 measurements
4 x 1.5 Volt (AA) alkaline batteries
450 minutes of analysis time
(typically greater than 100 measurements)
UL: Class I, Division 1, Groups A-D, T4
CSA: Class I, Division 1, Groups A-D, T4
MSHA: Permissible Gas Detector
ATEX: EEx ib IIC T4
Order No.
64 05 300
64 05 060
83 17 700
33 16 530
83 17 613
45 94 631
40 56 442
64 05 080
64 05 090
Dräger CMS Analyzer
29 | DRÄGER GAS DETECTION
Sampling Septum
Cancellation Pins
Information Barcode
Measurement Capillar y
Direc tion of Inser tion into
CMS Analyzer
Shown Actual Size
Dräger CMS - accurate, versatile, easy to use for chemical specific measurements.
DRÄGER CMS
®
CHIP
The Dräger CMS Chip consists of 10 measurement capillaries filled wit h substance-specific reagent systems. The gas type, part number and batch number are printed on t he chip. A printed barcode on t he chip, read by t he analyzer optics, contains information about gas type, measuring range and measuring time required for completing t he measurement. Each chip is calibrated during manufacturing and is valid for two years.
The chemical specific Chip and the advanced electronics of the Analyzer make the Dräger CMS one of the most accurate gas and vapor measurement tools available. The pre-calibrated Chip means no gas calibration type maintenance is required. The Analyzer eliminates all interpretation or usage errors that may be associated with other methods.
The mass flow pump system ensures that the exact amount of sample is taken and the opto-electronics make precise measurements of the chemical reaction.
CHEMICAL SPECIFIC MEASUREMENTS
When you need to know exactly what is there, Dräger CMS is the tool to provide those answers. The chemistry is chosen to provide the best results possible. The capillaries of several chips have multiple layers (yes, even in something that small!) to help reduce cross sensitivity to derive a specific measurement of the targeted chemical.
DRÄGER CMS CHIPS 1)
MTBE
Nitrogen Dioxide
Nitrous Gases
Nitrous Gases
Oxygen
Ozone
Perchloroethylene
Petroleum Hydrocarbons
Petroleum Hydrocarbons
Phosgene
Phosphine
Phosphine
Phosphine
Phosphine
Propane
Styrene
Sulphur Dioxide
Sulphur Dioxide
Toluene
Training Chip
Trichlorethylene
Vinyl Chloride
Vinyl Chloride
Water Vapor
Xylene
Description
Acetic Acid
Acetone
Ammonia
Ammonia
Ammonia
Ammonia
Benzene
Benzene
Benzene
Benzene
Butadiene
Carbon Dioxide
Carbon Dioxide
Carbon Dioxide
Carbon Monoxide
Chlorine
Ethanol
Ethylene Oxide
Formaldehyde
Hydrochloric Acid
Hydrochloric Acid
Hydrocyanic Acid
Hydrogen Peroxide
Hydrogen Sulphide
Hydrogen Sulphide
Hydrogen Sulphide
Hydrogen Sulphide
Iso-Propanol
Mercaptan
Methanol
Methylene Chloride
64 06 530
64 06 120
64 06 060
64 06 240
64 06 490
64 06 430
64 06 040
64 06 200
64 06 270
64 06 340
64 06 400
64 06 410
64 06 420
64 06 500
64 06 310
64 06 560
64 06 110
64 06 180
64 06 250
64 06 290
64 06 320
64 06 170
64 06 230
64 06 450
64 06 260
64 06 010
64 06 370
64 06 580
64 06 540
64 06 090
64 06 140
64 06 100
64 06 440
64 06 520
64 06 050
64 06 150
64 06 220
64 06 390
64 06 360
64 06 380
64 06 510
Order no.
64 06 330
64 06 470
64 06 550
64 06 130
64 06 020
64 06 570
64 06 600
64 06 030
64 06 160
64 06 280
64 06 460
64 06 190
64 06 070
64 06 210
64 06 080
10.0-200 ppm
0.50-25.0 ppm
0.50-15.0 ppm
10.0-200 ppm
1.0-30.0 Vol.-%
25.0-1000 ppb
5.0-150 ppm
20.0-500 ppm
100-3000 ppm
0.05-2.0 ppm
0.10-2.50 ppm
1.0-25.0 ppm
20.0-500 ppm
200-5000 ppm
100-2000 ppm
2.0-40.0 ppm
0.40-10.0 ppm
5.0-150 ppm
10.0-300 ppm
Simulation
5.0-100 ppm
0.30-10.0 ppm
10.0- 250 ppm
0.4.0-10.0 mg/L
10.0 - 300 ppm
Measurement range
2.0-50.0 ppm
40.0-600 ppm
0.20 -5.0 ppm
2.0-50.0 ppm
10.0-150 ppm
100-2000 ppm
50-2500 ppb
0.20-10.0 ppm
0.50-10.0 ppm
10.0-250 ppm
1.0-25.0 ppm
200-3000 ppm
1000-25000 ppm
1.0-20.0 Vol.-%
5.0-150 ppm
0.20-10 ppm
100-2500 ppm
0.40-5.0 ppm
0.20-5.0 ppm
1.0-25.0 ppm
20.0-500 ppm
2.0-50.0 ppm
0.20-2.0 ppm
0.20-5.0 ppm
2.0-50.0 ppm
20.0-500 ppm
100 -2500 ppm
40.0- 1000 ppm
0.25-6.0 ppm
20.0-500 ppm
20.0-200 ppm
DRÄGER GAS DETECTION | 30
31 | DRÄGER GAS DETECTION
Dräger’s leading edge technology puts us on the forefront of colorimetric detector tubes.
DRÄGER ACCURO
®
PUMP AND DRÄGER X- AC T
®
5000
The world has relied on Dräger-Tubes ® more than any other gas and vapor measurement device to tell them when the air is safe to breathe, to identify an unknown hazard, or to check on process gases. For more than 70 years, Dräger has been the leader in detector tube technology with more accurate measurements, a wider range of gases and vapors measured, more designs of tubes and more accessories to meet specific gas and vapor measurement applications.
Though many Dräger-Tubes
Reagents used in the Dräger-Tubes ® are chosen to provide not only the most accurate, but also the most specific results. The use of chemical pre-layers on many tubes (like benzene) removes potentially interfering gases (e.g. aromatic hydrocarbons) so you only measure the targeted chemical, getting only the results you want.
® require more than one pump stroke, the sampling time is usually faster than competitive onestroke tubes. Not only do you get the benefit of quicker analysis, the larger sample volume provides statistically better accuracy.
Once the sample is taken, the larger diameter Dräger-Tubes ® and well-spaced graduation marks enable distinct and decisive measurement readings.
go. A built-in stroke counter tells you exactly how many strokes have been taken. The visual end-of-stroke indicator signifies the completion of each pump stroke.
DRÄGER-X-ACT ® 5000 AUTOMATIC TUBE PUMP
The handling of gases, vapors, and aerosols has never been easier. The automatic tube pump, Dräger X-act 5000, directs the air to be measured through the appropriate Dräger-Tube effortlessly. It is conveniently carried with one hand or using the shoulder strap and is easily operated wearing heavy work gloves. A simple and intuitive menu structure provides the user efficient operation with just a few button presses.
SWIPING BARCODE LOADS MEASUREMENT DATA
Accuracy and reliability of measurement results is critical. A bar code printed on the back label of a box of Dräger short-term tubes contains all relevant measurement parameters. Simply sliding the bar code over the bar code reader of the pump automatically transfers the name of the substance to be measured, the number of strokes, and the measuring range to the display.
The cornerstone of the Dräger-Tube ® system is the accuro ®
Pump. It draws a calibrated 100 ml sample of air through the
Dräger-Tube ® with each stroke. The one-handed operation is simple and allows you to reach places that a piston pump cannot
REDUCED MEASUREMENT TIME
Less time spent measuring means reduced cost for your operations. The X-act 5000 presents a new concept that reduces the average measurement time for certain Dräger-Tubes by 15 - 20%.
The key principle is the ability to provide the required flow characteristics of the Dräger short-term tubes on the spot – no manual calibration is necessary.
D R Ä G E R A C C U R O ® P U M P O R D E R I N F O R M AT I O N
Dräger accuro ® Pump
Soft-Sided accuro ® Pump Kit
Hard-Sided accuro ® Pump Kit
Extension Hose, 3 meter
Extension Hose, 10 meter
Extension Hose, 15 meter
Hot Air Probe
Tube Opener 7000 accuro ® Pump and X-act ® 5000 Pump are available for rental.
D R Ä G E R X - A C T ® 5 0 0 0 ORDER INFORMATION
Dräger X-act 5000, consists of Dräger X-act 5000, shoulder strap without power supply
Dräger X-act 5000 Kit, consists of Dräger X-act 5000, shoulder strap,
NiMH battery and power supply
Power Packs
Rechargeable Battery NiMH, T4
Alkaline Battery Pack, T4 w/o batteries (6 batteries required)
Alkaline Battery, AA pack of 4
Charging accessories
Wall-Wart Charger 100 – 240 VAC (worldwide)
Car Charger 12 / 24 V
Accessories
Extension Hose, 3 meter
Extension Hose, 10 meter
Extension Hose, 15 meter
Extension Hose, 30 meter
45 23 500
45 23 617
45 23 520
45 23 525
45 88 195
45 23 545
45 23 511
64 00 077
64 00 078
64 00 079
64 01 175
DRÄGER GAS DETECTION | 32
64 00 000
40 53 473
40 56 443
64 00 077
64 00 078
64 00 079
CH 00 213
64 01 200
Dräger-Tubes® accuro ® Pump Soft & Hard Sided accuro ® Pump Kits
X-act 5000 X-act 5000
With connected extension hose
Dräger-Tube® Boxes
Barcode printed on the label
33 | DRÄGER GAS DETECTION
WHAT IS THE DRÄGER-TUBE ® SYSTEM?
Dräger-Tubes ® are glass vials filled with a chemical reagent that reacts to a specific chemical or family of chemicals. With each stoke a calibrated 100 ml sample of air is drawn through the tube with the Dräger accuro ® bellows pump. If the targeted chemical(s) is present the reagent in the tube changes color and the length of the color change typically indicates the measured concentration.
The Dräger-Tubes ® System is the world’s most popular form of gas detection.
DRÄGER SHORT-TERM DETECTION TUBES
Dräger-Tube
®
Acetaldehyde 100/a
Acetic Acid 5/a
Acetone 40/a
Acetone 100/b
Acid Test
Measuring Range
100-1,000 ppm
5-80 ppm
40-800 ppm
100-12,000 ppm
Qualitative
Acrylonitrile 0.5/a (5) 0.5-20 ppm
Air Current Tube Kit
Air Current Tubes
Alcohol 25/a
Alcohol 100/a
Amine Test
Ammonia 0.25/a
Ammonia 2/a
Ammonia 5/b
Ammonia 5/a
Ammonia 0.5%/a
67
67
81
CH
81
67
40
Part No.
26 665
22 101
03 381
22 901
01 121
28 591
54 388
50-4,000 ppm Isopropanol
25-5,000 ppm Methanol
100-3,000 ppm
CH 25 301
81 01 631
Qualitative
0.25-3 ppm
2-30 ppm
2.5-100 ppm
CH 29 701
81
81
01 061
01 711
67 33 231
81 01 941
5-600 ppm CH 20 501
0.05-10 Vol.% CH 31 901
Aniline 0.5/a
Aniline 5/a
Arsine 0.05/a
Benzene 0.5/a
Benzene 0.5/c (5) specific
Benzene 2/a (5)
Benzene 5/b
Benzene 15/a
0.5-10 ppm
1-20 ppm
0.05-60 ppm
0.5-10 ppm
0.5-10 ppm
2-60 ppm
5-50 ppm
15-420 ppm
67
CH
CH
67
81
81
67
81
33 171
20 401
25 001
28 561
01 841
01 231
28 071
01 741
Carbon Dioxide 100/a
Carbon Dioxide 0.1%/a
Carbon Dioxide 0.5%/a
Carbon Dioxide 1%/a
Carbon Dioxide 5%/A
Carbon Disulfide 3/a
Carbon Disulfide 30/a
Carbon Monoxide 2/a
Carbon Monoxide 5/c
Carbon Monoxide 8/a
(only for CO in H
2
)
Carbon Monoxide 10/b
Carbon Monoxide 10/d
Carbon Monoxide 0.3%/b
Carbon Pretubes
Carbon Tetrachloride 0.1/a
Carbon Tetrachloride 1/a (5)
Carbon Tetrachloride 5/c
Chlorine 0.2/a
Chlorine 0.3/b
Chlorine 50/a
Chlorine Dioxide 0.025/a
100-3,000 ppm 81 01 811
0.1-6 Vol.% CH 23 501
0.5-10 Vol.% CH 31 401
1-20 Vol.% CH 25 101
5-60 Vol.% CH 20 301
3-95 ppm 81 01 891
32-3,200 ppm
2-300 ppm
CH
67
23 201
33 051
5-700 ppm CH 25 601
8-150 ppm CH 19 701
10-3,000 ppm
10-3,000 ppm 81 03 321
0.3-7 Vol.% CH 29 901
0.1-5 ppm
1-15 ppm
5-50 ppm
CH 20 601
CH 24 101
81 03 501
81 01 021
CH 27 401
0.2-30 ppm CH 24 301
0.3-10 ppm 67 28 411
50-500 ppm
0.025-3 ppm
CH
81
20 701
03 491
Dräger-Tube ®
Chlorobenzene 5/a (5)
Chloroform 2/a (5)
Chloroformates 0.2/b
Chloropicrin 0.1/a
Chloroprene 5/a
Chromic Acid 0.1/a (9)
Cyanide 2/a
Cyanogen Chloride 0.25/a
Cyclohexane 100/a
Cyclohexylamine 2/a
Dichloropropene 0.1/a
Diesel Fuel
Diethyl Ether 100/a
Dimethyl Formamide 10/b
Dimethyl Sulfate 0.005/c (9)
Dimethyl Sulfide 1/a (5)
Epichlorohydrin 5/c
Ethyl Acetate 200/a
Ethyl Benzene 30/a
Ethylene 0.1/a (5)
Ethylene 50/a
Ethylene Glycol 10 (5)
Ethylene Oxide 1/a (5)
Ethylene Oxide 25/a
Ethyl Formate 20/a
Ethyl Glycol Acetate 50/a
Fluorine 0.1/a
Formaldehyde 0.2/a
Formaldehyde Activation tube (for use only in conjunction with 0.2/a tube)
Formaldehyde 2/a
Formic Acid 1/a
Halogenated Hydrocarbons
100/a
Hexane 100/a
Hydrazine 0.01/a
Hydrazine 0.25/a
Hydrocarbons 0.1%/c
Hydrocarbons 2/a
Hydrochloric Acid 0.2/a
Hydrochloric Acid 1/a
Hydrochloric Acid 50/a
Hydrochloric Acid/Nitric
Acid 1/a 1-15 ppm (HNO
3
)
Hydrocyanic Acid 0.5/a
Hydrogen 0.2%/a
Measuring Range
5-200 ppm
2-10 ppm
0.2-10 ppm
0.1-2 ppm
5-60 ppm
0.1-0.5 mg/m 3
2-15 mg/m 3
0.25-5 ppm
100-1,500 ppm
2-30 ppm
0.1-10 ppm
25-200 mg/m 3
100-4,000 ppm
10-40 ppm
0.005-0.05 ppm
1-15 ppm
5-80 ppm
200-3,000 ppm
30-600 ppm
0.2-5 ppm
50-2,500 ppm
10-180 mg/m 3
1-15 ppm
25-500 ppm
20-500 ppm
50-700 ppm
0.1-2 ppm
0.2-5 ppm extend to 0.04 ppm
67 28 451
67 28 111
CH 20 201
67 28 381
81 01 331
67 28 051
81 01 351
67 28 961
67 28 241
81 03 541
67 26 801
81 01 491
67 33 081
81 01 141
Part No.
67 28 761
67 28 861
67 18 601
81 03 421
67 18 901
67 28 681
67 28 791
CH 19 801
67 25 201
67 28 931
81 03 551
81 03 475
67 30 501
67 18 501
67 18 701
2-40 ppm
1-15 ppm
100-2,800 ppm
81 01 751
67 22 701
81 01 601
50-3,000 ppm
0.01-6 ppm
0.1-10 ppm
0.1-1.3 Vol. %
2-24 mg/l
0.2-20 ppm
1-10 ppm
50-5,000 ppm
1-10 ppm (HCL)
67 28 391
81 03 351
CH 31 801
81 03 571
81 03 581
81 03 481
CH 29 501
67 28 181
81 01 681
0.5-50 ppm
0.2-2 Vol. %
81 03 601
81 01 511
Number in parenthesis indicates tests per box.
Bold font indicates SEI Certification
DRÄGER GAS DETECTION | 34
Dräger-Tube ®
Hydrogen Fluoride 0.5/a
Hydrogen Peroxide 0.1/a
Hydrogen Sulfide 0.2/a
Hydrogen Sulfide 0.2/b
Hydrogen Sulfide 0.5/a
Hydrogen Sulfide 1/d
Hydrogen Sulfide 2/a
Hydrogen Sulfide 2/b
Hydrogen Sulfide 5/b
Hydrogen Sulfide 100/a
Hydrogen Sulfide 0.2%/A
Hydrogen Sulfide 2%/a
Hydrogen Sulfide +
Sulfur Dioxide 0.2%/A
Iodine 0.1/a
Mercaptan 0.1/a
Mercaptan 0.5/a
Mercaptan 20/a
Mercury Vapor 0.1/b
Methyl Acrylate 5/a
Methyl Bromide 0.2/a
Methyl Bromide 0.5/a
Methyl Bromide 5/b
Methylisothiocyanate 0.1/a
Methylene Chloride 20/a
Natural Gas Test (Methane)(5)
Nickel Tetracarbonyl 0.1/a (9)
Nitric Acid 1/a
Nitrogen Dioxide 0.5/c
Nitrogen Dioxide 2/c
Nitrous Fumes 0.5/a
Nitrous Fumes 2/a
Nitrous Fumes 20/a
Nitrous Fumes 50/a
Nitrous Fumes 100/c
Oil Mist 1/a
Olefins 0.05%/a
Organic Arsenic Compounds and Arsine
Organic Basic Nitrogen
Compounds
Oxygen 5%/C
Ozone 0.05/b
Ozone 10/a
Pentane 100/a
Perchloroethylene 0.1/a
Measuring Range
0.5-90 ppm
0.1-3 ppm
0.2-5 ppm
0.2-6 ppm
0.5-15 ppm
1-200 ppm
2-200 ppm
Part No.
81 03 251
81 01 041
81 01 461
81 01 991
67 28 041
81 01 831
67 28 821
1-60 ppm 81 01 961
5-600 ppm CH 29 801
100-2,000 ppm
0.2-7 Vol. %
CH
CH
29 101
28 101
2-40 Vol. %
0.02-7 Vol. %
81 01 211
CH 28 201
0.1-6 ppm
0.1-2.5 ppm
0.5-5 ppm
81
81
67
03 521
03 281
28 981
20-100 ppm 81 01 871
0.05-2 mg/m 3 CH 23 101
5-200 ppm
0.2-8 ppm
0.5-30 ppm
5-50 ppm
67
81
81
CH
28 161
03 391
01 671
27 301
0.1-6 ppm
20-200 ppm
Qualitative
0.1-1 ppm
81 03 485
81 03 591
CH 20 001
CH 19 501
1-50 ppm 67 28 311
0.5-25 ppm CH 30 001
2-100 ppm 67 19 101
0.5-10 ppm CH 29 401
2-100 ppm CH 31 001
20-500 ppm 67 24 001
50-2,000 ppm
100-5,000 ppm
1-10 mg/m 3
0.06-3.2 Vol.% Propylene
81 01 921
CH 27 701
67
CH
33 031
31 201
0.04-2.4 Vol.% Butylene
3 mg org. arsenic/m 3 CH 26 303
1 mg/m 3 CH 25 903
5-23 Vol. % 81 03 261
0.05-1.4 ppm 67 33 181
10-300 ppm CH 21 001
100-1,500 ppm
0.1-4 ppm
67 24 701
81 01 551
Dräger-Tube ®
Perchloroethylene 2/a
Perchloroethylene 10/b
Petroleum Hydrocarbons 10/a
Petroleum Hydrocarbons 100/a
Phenol 1/b
Phosgene 0.02/a
Phosgene 0.25/c
Phosphine 0.01/a
Phosphine 0.1/a
Phosphine 0.1/b in acetylene
Phosphine 1/a
Phosphine 25/a
Phosphine 50/a
Phosphoric Acid Esters 0.05/a
Dimethyldichlorovinylphosphate)
Polytest
Pyridine 5/A
Styrene 10/a
Styrene 10/b
Styrene 50/a
Sulfur Dioxide 0.1/a
Sulfur Dioxide 0.5/a
Sulfur Dioxide 1/a
Sulfur Dioxide 20/a
Sulfur Dioxide 50/b
Sulfuric Acid 1/a (9)
Sulfuryl Fluoride 1/a (5)
Tetrahydrothiophene 1/b (5)
Thioether
Toluene 5/b
Toluene 50a
Toluene 100/a
Toluene Diisocyanate 0.02/A (9)
Trichloroethane 50/d (5)
Trichloroethylene 2/a
Trichloroethylene 50/a
Triethylamine 5/a
Vinyl Chloride 0.5/b
Vinyl Chloride 100/a
Water Vapor 0.1/a
Water Vapor 1/b
Water Vapor 3/a
Xylene 10/a
Measuring Range
2-300 ppm
10-500 ppm
10-300 ppm (n-Octane)
100-2,500 ppm (n-Octane)
1-20 ppm
0.02-1 ppm
0.25-15 ppm
0.01-1 ppm
0.1-4 ppm
0.1-15 ppm
1-100 ppm
25-10,000 ppm
15-1,000 ppm
0.05 ppm
Qualitative
5 ppm
10-200 ppm
10-250 ppm
50-400 ppm
0.1-3 ppm
0.5-25 ppm
1-25 ppm
20-2,000 ppm
50-8,000 ppm
1-5 mg/m 3
1-5 ppm
1-10 ppm
1 mg/m 3
5-300 ppm
50-400 ppm
100-1,800 ppm
0.02-0.2 ppm
50-600 ppm
2-250 ppm
50-2,000 ppm
5-60 ppm
0.5-30 ppm
100-3,000 ppm
0.05-1 mg/L
1-40 mg/L
3-60 lbs/mcf
10-400 ppm
Part No.
81 01 501
CH 30 701
81 01 691
67 30 201
81 01 641
81 01 521
CH 28 301
81 01 611
CH 31 101
81 03 341
81 01 801
81 01 621
CH 21 201
67 28 461
CH 28 401
67 28 651
67 23 301
67 33 141
CH 27 601
67 27 101
67 28 491
CH 31 701
CH 24 201
81 01 531
67 28 781
81 03 471
81 01 341
CH 25 803
81 01 661
81 01 701
81 01 731
67 24 501
CH 21 101
67 28 541
81 01 701
67 18 401
81 01 721
CH 19 601
81 01 321
81 01 781
81 03 031
67 33 161
Consult the VOICE ® Hazardous Substances Database for detection options on over 1700 chemicals. Access VOICE ® at www.dräger.com
35 | DRÄGER GAS DETECTION
Dräger Emergency Response Kits
DRÄGER CMS EMERGENCY RESPONSE KIT
Put the simplicity of the Dräger CMS to work for you in your emergency response procedures. The Dräger CMS Emergency
Response Kit contains the Dräger CMS
Analyzer, the appropriate accessories, and a selection of 10 different Chips for response to HazMat or other situations.
Use our standard selection of Chips, or create your own Emergency Response Kit selecting from the over 50 CMS Chips currently available.
GASES MEASURED
Ammonia, Carbon Dioxide, Carbon Monoxide, Chlorine, Hydrochloric Acid, Hydrogen
Sulfide, Nitrous Gases, Perchloroethylene, Petroleum Hydrocarbons, and Toluene.
DRÄGER CMS EMERGENCY RESPONSE KIT ORDER INFORMATION
Dräger CMS Emergency Response Kit
Dräger CMS Emergency Response Kit (without Chips)
40 55 711
40 55 976
Put the capability of several gas detection monitors in your hands without all of the worries. The Dräger CMS is as easy to use as 1-2-3, all Dräger Chips use the exact same procedure. The Chips never need calibration, and the Analyzer does not require battery charging. All of the needed accessories are placed in one rugged carrying case, ready to go at a moments notice.
CMS Emergency Response Kit
DRÄGER HA ZMAT SIMULTES T KIT
Designed primarily for the municipal fire service and other emergency responders, this kit quickly identifies and quantifies a wide range of chemical substances in less than 5 minutes using the Dräger Simultest
Sets. The Dräger HazMat Simultest Kit includes three Simultest Sets for measuring 15 different Organic and Inorganic chemicals and/or chemical families. Broad scale measurement and identification is as easy as using Set I, II and III.
GASES MEASURED
Acid Gases, Basic Gases, Carbon Monoxide, Hydrocyanic Acid, Nitrous Gases,
Phosphine, Chlorine, Hydrogen Sulfide, Phosgene, Sulfur Dioxide, Aliphatics,
Aromatics, Alcohols, Ketones and Chlorinated Hydrocarbons
DRÄGER SIMULTES T KIT ORDER INFORMATION
Dräger HazMat Simultest Kit
Dräger HazMat Simultest Kit (without Dräger accuro ® Pump)
Dräger Simultaneous Test Set I (Inorganic Gases)
Dräger Simultaneous Test Set II (Inorganic Gases)
Dräger Simultaneous Test Set III (Organic Vapors)
40 56 098
40 56 447
81 01 735
81 01 736
81 01 770
The Dräger HazMat Simultest Kit comes complete with a Dräger accuro ® Pump, 10
Simultest Sets, Test Set Adapter and Tube
Openers, full color laminated instruction sheets, and an Air Current Kit together in a rugged Pelican ® case.
HazMat Simultest Kit
DRÄGER GAS DETECTION | 36
DRÄGER CL AN L AB SIMULTES T KIT
The illegal manufacture of methamphetamine is a serious problem in North
America. Dräger has developed a
Simultest Set with detector tubes that quickly confirm the presence of chemicals commonly associated with three principal methods of methamphetamine production. This allows law enforcement and first responder personnel to make fast decisions on the need for respiratory protection.
GASES MEASURED
Ammonia, Hydrochloric Acid, Iodine, Phosgene and Phosphine
DRÄGER CL AN L AB SIMULTES T KIT ORDER INFORMATION
Dräger Clan Lab Simultest Kit
Dräger Clan Lab Simultaneous Test Set
The Dräger Clan Lab Simultest Kit includes the accuro ® Pump, Test Set
Adapter and Opener, quick reference laminated instruction sheet and 5 Clan
Lab Simultest Sets in a Pelican Case.
Clan Lab Simultest Kit
40 56 562
81 03 310
DRÄGER CIVIL DEFENSE SIMULTES T (CDS) KIT
Are you prepared to respond to a terrorist attack involving the use of chemical weapons? In today’s world, immediate and accurate detection of toxic chemicals is crucial. The Dräger CDS Kit uses specially developed Dräger-Tubes ® (the same tubes used by NATO forces) in a quick and easy to use kit. Two Civil
Defense Simultest Sets measure a wide range of chemical substances including nerve, blood, lung, and blister agents.
GASES MEASURED
Chlorine, Hydrocyanic Acid, Phosgene, Cyanogen Chloride, Organic Arsenic
Compounds and Arsine (e.g. Lewisite), Nerve Agents (G agents and VX) and Blister
Agents (Mustard and other Organic Basic Nitrogen Compounds).
DRÄGER CIVIL DEFENSE SIMULTES T KIT ORDER INFORMATION
Dräger Civil Defense Simultest Kit (w/ accuro ® Pump)
Dräger Civil Defense Simultest Kit (w/ X-act ® 5000)
Dräger Civil Defense/HazMat Simultest Kit (w/ accuro ® Pump)
Dräger Civil Defense/HazMat Simultest Kit (w/ X-act ® 5000)
Dräger Civil Defense Simultest, Set I
Dräger Civil Defense Simultest, Set V
Training Set for Civil Defense Simultest Set I
Training Set for Civil Defense Simultest Set V
6400 565S
40 56 570
40 56 665
40 56 528
81 03 140
81 03 200
81 03 230
81 03 240
Dräger-Tubes ® have been proven by
Aberdeen Proving Grounds to be more accurate, more specific and more reliable than PID and FID devices in detecting chemical warfare agents. The CDS Kit requires no calibration, no battery charges or changes, and is extremely simple to use.
Civil Defense Simultest (CDS) Kit wit h Quantimeter
37 | DRÄGER GAS DETECTION
DRÄGER AEROTES T KITS
Dräger-Tubes ® are widely used to measure the quality of compressed breathing air, the purity of medical gases, contaminants in process gases, and impurities in technical gases. The Aerotest Kits facilitate these types of measurements by conditioning the pressurized sample to a level at which the Dräger-Tubes ® can accurately operate.
DRÄGER AEROTES T KITS ORDER INFORMATION
Aerotest Simultan Alpha (< 175 psi)
Aerotest Simultan HP (< 4500 psi)
Aerotest Multi-Test (< 75 psi)
Aerotest Level A (≤ 150 psi)
Aerotest Simultan HP + P Navy (≤ 4500 psi)
Aerotest Simultan Test CO
2
The Dräger Aerotest Kits are designed to measure the quality of breathing air. The kits come complete with Dräger-Tubes ® for measuring CO, CO
2
, oil and water vapor. The low-pressure (Alpha) version may be plugged directly into compressed airlines, while the high-pressure (HP) version can be connected directly to
SCBA cylinders or compressors.
The Dräger Multi-Test is designed for medical gases and can measure up to seven different substances simultaneously;
CO, CO
2
, H
2
O, Oil, SO
2
, H
2
S, and NOx.
DRÄGER BIO - CHECK F BADGES
The Bio-Check F detects formaldehyde in the range of 0.02 to 0.7 ppm without mechanical or electronic devices. An enzyme reaction changes the color of the indication layer and is evaluated by a color comparison chart that is included with the badge. The determination of indoor air exposure levels can be accomplished in only two hours. The Bio-Check is small enough to be worn on a person’s lapel, or set in a room of concern for measurement of formaldehyde at these very low levels.
ORDER INFORMATION
Bio-Check F Badge
Bio-Check F Badges
40 56 747
40 55 986
40 56 181
40 54 001
65 25 960
40 56 849
64 00 235
DRÄGER GAS DETECTION | 38
DR AGER BIO - CHECK ALLERGEN CONTROL
The house dust mite is the most common cause of allergies. The Dräger-Bio-Check
Allergen Control rapid-test allows the user to conduct an on-site analysis of house dust mite allergens. The table supplied with Dräger-Bio-Check Allergen Control groups the exposure levels into categories based on the scientific limit values for house dust allergens.
ORDER INFORMATION
Drager Bio-Check Allergen Control (package of 5) 64 00 945
Bio-Check Allergen Control
Dräger TWA Measurements
DRÄGER DIFFUSION (PA SSIVE SAMPLING) TUBES
Get on-site measurements of 8-hour exposures with the Dräger Diffusion Tubes. This gas and vapor measurement technique provides a quick, simple, and on-site means to determine employee exposures.
Unlike Short-Term detector tubes that require a pump for operation, Dräger Diffusion Tubes rely on natural movement of the gases and vapors to enter the tube and cause a color change. Simply read the indication on the graduated scale (ppm x hours) and divide by the amount of hours the Dräger Diffusion Tube has been in use for a TWA measurement. No waiting, no analysis fees, no laboratory services, no turn-around time; just on the spot measurement. The Dräger-Tube Holder allows you to place the
Dräger Diffusion Tube in the breathing zone of the people being monitored or in the suspected areas.
ORDER INFORMATION
Dräger-Tube
®
Acetic Acid 10/a-D
Ammonia 20/a-D
Butadiene 10/a-D
Carbon Dioxide 500/a-D
Carbon Dioxide 1%/a-D
Carbon Monoxide 50/a-D
Ethanol 1000/a-D
Hydrochloric Acid 10/a-D
Hydrocyanic Acid 20/a-D
Hydrogen Sulfide 10/a-D
Nitrogen Dioxide 10/a-D
Perchloroethylene 200/a-D
Sulfur Dioxide 5/a-D
Toluene 100/a-D
Trichloroethylene 200/a-D
Diffusion Tube Holder (pkg 3)
Range in Absolute Units
10 - 200 ppm x h
20 - 1,500 ppm x h
10 - 300 ppm x h
500 - 20,000 ppm x h
1 - 30 Vol.% x h
50 - 600 ppm x h
1,000 - 25,000 ppm x h
10 - 200 ppm x h
20 - 200 ppm x h
10 - 300 ppm x h
10 - 200 ppm x h
200 - 1,500 ppm x h
5 - 150 ppm x h
100 - 3,000 ppm x h
200 - 1,000 ppm x h
Part No.
81 01 071
81 01 301
81 01 161
81 01 381
81 01 051
67 33 191
81 01 151
67 33 111
67 33 221
67 33 091
81 01 111
81 01 401
81 01 091
81 01 421
81 01 441
67 33 014
Diffusion (Passive Sampling) Tubes
Air Current Measurement
DRÄGER FLOW CHECK
Air current directions and flow rates are very important to gas detection. The visible plume of non-toxic, non-reactive smoke generated by the Dräger Flow-
Check allows you to actually see the direction, dispersion, and relative speed of the air currents in an area. Knowing how the air is moving, you are better prepared to accurately measure gases. This smoke can also be used to detect air leaks around doorways or other fixtures.
Dräger Flow-Check is also popular for checking the effectiveness of ventilation ducts, pressurized rooms, fume hoods, vapor extractors and other air movement equipment. These functions assist those in the HVAC, hospital laboratory, and manufacturing industry sectors.
TECHNICAL DATA
Dimensions
Weight
Approx 11.8 x 7.9 x 2.8 in., (300 x 200 x 70 mm)
17.6 oz. (500 g)
DRÄGER FLOW - CHECK ORDER INFORMATION
Dräger Flow Check Device
Battery Charger, 110 VAC, Required for operation
Replacement Smoke Ampoules (3/pkg)
64 00 761
83 16 993
64 00 812
DRÄGER SMOKE TUBES SAMPLE KIT
Dräger Smoke Tubes have been very popular in the HVAC and mining industries for many years. The reagent inside the smoke tube produces a visible aerosol plume when in contact with atmospheric humidity. A simple squeeze bulb pushes air through the tube to propel the smoke into the ambient air. Even the most gentle air currents are made visible.
ORDER I N F O R M AT I O N
Air Current Tube Kit
Smoke Tubes
40 54 388
CH 25 301
DRÄGER GAS DETECTION | 40
Training and Support for your Dräger protection and detection equipment.
DrägerService
Let DrägerService provide expert care for your respiratory protection equipment. Dräger has strategically located Service
Centers across Nort h America in Pittsburgh PA, Carson CA, Pasadena TX, Richmond BC, Dartmout h NS, Mississauga ON,
Sudbury ON, Montreal PQ, Edmonton AB, and Queretaro, Mexico. Services are available at t hese locations or on-site.
DrägerService supports with a full range of technical services including gas calibration, maintenance, upgrades and repairs.
Services can be arranged on an as needed basis, or through maintenance agreements and service contracts. Dräger’s all-encompassing Total Care Packages provide all services, including loaner units when needed.
DRÄGER RENTAL
For many applications and situations, purchasing gas detection or respiratory protection equipment may not be the most efficient or cost-effective solution. The complete range of Dräger products are available for rental. We offer competitive pricing; convenient daily, weekly or monthly terms; expertly maintained equipment; and Rent-to-Own options.
DRÄGER TRAINING
The best safety equipment is only as good as the knowledge of those who use it. Let Dräger train your staff on the proper use and maintenance of all of our products. We offer both operator and technician level courses at our service facilities or at your site. Students are provided with the appropriate training materials such as posters, videos, CDs, books and/or schematics depending on the training given. All courses are available with certification.
DRÄGER SUPPORT
Our worldwide experience obtained from many different industries, applications, and environmental conditions are available to all Dräger customers. The Technical Services staff in Pittsburgh can assist you through the challenges and questions you may encounter in your application and recommend the proper equipment for the job at hand.
41 | DRÄGER GAS DETECTION
Dräger Swede Survival
LIVE FIRE TRAINING IN WOOD -FUELED CLASS "A"
CONTAINER SYSTEMS
Dräger Swede Survival training systems offer firefighters the opportunity to observe fire behavior and the signs that lead to phenomena like a flashover. The training is being conducted according to proven procedures in order to create a safe and controlled training setting. Repetition of the training increases and stabilizes the firefighter's knowledge and skills to recognize and handle the specific fire scenarios. adds to fire fighter's knowledge by demonstrating the conditions and warning signs of a backdraft. In Phase IV,
Phase IV replicates a garage fire scenario and Phase V is a
Multi-story system with multiple burn chambers. Each one of these live fire training systems provide a cost effective way to build the confidence and knowledge of fire fighters.
When all of these phases are combined, it creates a flexible and comprehensive fire training program for novice and veteran fire fighters alike.
The Swede Survival portfolio consists of 5 product categories, which represent a progression or different phases of training. Phase I is essentially a laboratory, where fire behavior and the flashover phenomenon can be safely observed three feet below the fire. The Phase II system is ideal for teaching fire attack scenarios by placing the trainees on the same level as the fire. The Phase III further
Realistic
reliable and
safe.
DRÄGER GAS DETECTION | 42
Dräger Fire Training Systems
LIVE FIRE TRAINING IN PROPANE FUELED CLASS 'B'
SYSTEMS
Dräger's training systems provide ideal conditions for breathing apparatus users to experience physical and mental stress common to emergency situations in a controlled environment. Dräger Safety Systems is taking firefighting to a whole new level with the acquisition of Fire Training Systems
(FTS). Dräger Safety Systems provides the fire service with one source for an entire range of training systems and equipment emphasizing on:
– Confidence in their skills and equipment under stressful situations
– Teamwork built with practice and repetition of skills and tactics
– Knowledge gained through experience with fire behavior
– Dräger improves the training experience for all fire fighters
43 | DRÄGER GAS DETECTION
Respiratory Protection
DRÄGER X-PLORE ® 1300
The Dräger X-plore ® Series of filtering facepiece respirators sets the standard for comfort and adjustability. The unique tension adjuster allows a wearer to fine-tune the non-irritating fabric head strap to a proper fit. In addition, the strap provides a drop-down feature to comfortably hang around the neck when not needed. The Dräger X-plore ® facepiece respirator is available in two sizes, with a strong plastic-coated nose clip and internal ribbing to prevent collapsing, making them the most ergonomically designed filtering facepiece respirators on the market.
DRÄGER X-PLORE ® MASKS AND FILTERS
The new Dräger X-plore ® Series masks set a new benchmark in fit and comfort in respiratory protection. The innovative X-guided strap system secures the mask evenly over the face providing an excellent fit while remaining very comfortable. Three sizes (S, M, L) of masks and a flexible nose seal ensure a proper fit for every type of face. The Dräger X-plore ® comes in economical use (3300) and premium (3500) half-mask styles. The full face (5500) mask provides a higher level protection when needed. To meet a wide range of industrial applications, Dräger offers a full line of NIOSH approved cartridges and filters with their exclusive two-point bayonet connector.
DRÄGER PARAT C
The Dräger Parat C fire/smoke escape hood offers a minimum of 15 minutes of protection against potential hazards found in fires, such a carbon monoxide, toxic gases and smoke particulates. The flame retardant hood is an easy to see orange color that has been flame flash tested at 1200 °F. It can be worn by people with facial hair, glasses, long hair, and has even been tested on children. The Parat C has a shelf life of 12 years, providing that the filter is replaced after 6 years. In addition, the Parat C offers documented protection against
H
2
S. This hood is approved to the European Standard EN403:2004.
DRÄGER INDUSTRIAL SUPPLIED AIR RESPIRATORS
Hard work in an industrial environment requires rugged and reliable equipment. The Dräger line of supplied air respirators confidently meets this challenge. Our modular airline respirator systems are based on the Dräger Panorama Nova mask that provides superior fit and comfort. The Type C Dräger SAR and constant flow Dräger PentAir ® respirators are for working extended periods in non-IDLH environments. The PAS Colt, Supplied Airline Respirator
(Combination Pressure Demand, Type "C") with a 5 or 10-minute self-contained air cylinder for emergency use, is NIOSH approved for entry and escape, and may be used in the supplied air mode up to 300 feet or 12 hose length sections from the air source, whichever is greater.
DRÄGER FIRE FIGHTING BREATHING APPARATUS
As the world’s largest SCBA manufacturer, we design SCBAs to withstand the most demand-ing circumstances while delivering the most safety and comfort. Ergonomic back plates and fully adjustable harness system, allow the Dräger PSS 3000 and Dräger PSS
5000 to provide exceptional safety, maneuverability, and comfort for fire fighters. The Dräger
PSS SCBA Series has been approved to the most challenging standards in the world, NFPA
1981-2007 edition. Available in both one piece, Evolution backplate as well as the PSS 7000 multi-position backplate, the series utilizes the advanced PSS pneumatic system and
Sentinel 7000 gauge and PASS device.
DRÄGER BG-4 CLOSED CIRCUIT BREATHING APPARATUS (CCBA)
The Dräger BG-4 is a NIOSH & MSHA Approved Closed Circuit Breathing Apparatus provides superior respiratory protection in IDLH environments for up to 4 hours!
Conventional SCBA’s are limited to just one hour or less and do not provide the extended time that is required in critical operations like: search and rescue, hazardous materials clean-up, domestic preparedness, or mine and tunnel rescue. The low profile of the Dräger BG-4 makes it easy to use under protective clothing. Every Dräger BG-4 is equipped with the
Dräger Sentinel, which is an electronic alarm; test and pressure display module that provides continuous information to the user.
DRÄGER GAS DETECTION | 44
45 | DRÄGER GAS DETECTION
NOTES
Inside back cover BLANK
HE ADQUARTERS:
Dräger Safety AG & Co. KGaA
Revalstrasse 1
23560 Lübeck, Germany www.draeger.com
REGIONAL OFFICES:
CANADA
Draeger Canada Ltd.
7555 Danbro Crescent
Mississauga, Ontario L5N 6P9
Tel +1 905 821-8988
Fax +1 905 821-2565
Customer Service
Tel 877 372 4371
Fax 800 329 8823
ME XICO
Draeger Safety S.A. de C.V.
Carretera San Luis Potosí Km 21
Bodegas No. 1 y 2
Condominio Industrial
“Polígono Empresarial
Santa Rosa Bloque SMED”
Queretaro, Qro
México, C.P. 72220
Tel +52 442 246-1113
Fax +52 442 246-1114
USA
Draeger Safety, Inc.
101 Technology Drive
Pittsburgh, PA 15275-1057
USA
Tel +1 412 787-8383
Fax +1 412 787-2207
Customer Service
Tel 800 858 1737
Fax 800 922 5519
Technical Service
Tel 888 794 3806
Fax 888 794 3807
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project