ENGLISH

Operator’s Manual

COUNTERTOP SANDWICH PRESS

Item Model Description Voltage Watts Amps Plug

40794 TSI7001 Sandwich Press, Ribbed Plate, Cast Iron 120V

40795 TSI8002 Sandwich Press, Ribbed Plate, Cast Iron 220V

1800

3080

15 Amps 5-15P

14 Amps 6-15P

40794-C TSI7001 Sandwich Press, Ribbed Plate, Cast Iron 120V

40795-C TSI8002 Sandwich Press, Ribbed Plate, Cast Iron 220V

1800

3080

15 Amps 5-20P

14 Amps 6-20P

Thank you for purchasing this Vollrath Counter Top Cooking Equipment. Before operating the unit, read and familiarize yourself with the following operating and safety instructions. SAVE THE ORIGINAL BOX AND PACKAGING. Use this packaging to ship the unit if repairs are needed. SAVE THESE

INSTRUCTIONS FOR FUTURE REFERENCE.

Item No. 2350014-1 en Rev 06/14

S aFety

p recaUtionS

To ensure safe operation, read the following statements and understand their meaning. This manual contains safety precautions which are explained below. Please read carefully.

This sandwich press is a medium duty appliance capable of a wide variety of applications. The temperature is thermostatically controlled. The temperature range for non-coated surface models is between 120°F (49°C) and

550°F (288°C). The thermostat is also the ON/OFF switch. An indicator lamp adjacent to the thermostat dial indicates when the elements are heating.

WARNING

Warning is used to indicate the presence of a hazard that can cause

severe personal injury, death, or substantial property damage if the warning is ignored.

CAUTION

Caution is used to indicate the presence of a hazard that will or can cause minor personal injury or property damage if the caution is ignored.

NOTE

Note is used to notify people of installation, operation, or maintenance information that is important but not hazard-related.

For Your Safety!

These precautions should be followed at all times. Failure to follow these precautions could result in injury to yourself and others.

To reduce risk of injury or damage to the unit:

„ Use only grounded electrical outlets matching the nameplate rated voltage.

„ Have equipment installed by a qualified personal in accordance with local codes and ordinances.

„ This unit must only be used in a flat, level position.

„ Do not use an extension cord with this unit.

„ Unplug the unit, turn off and let it cool before cleaning or moving.

„ Do not spray controls or outside of the unit with liquids or cleaning agents.

„ Do not clean the unit with steel wool.

„ Keep the unit and power cord away from open flames, electric burners or excessive heat.

„ Do not operate the unit unattended.

„ Do not operate the unit in public areas and/or around children.

„ The unit may be hot, even though the pilot light is not on.

„ Do not operate if the unit has been damaged or is malfunctioning in any way.

F

Unction and

p

UrpoSe

This unit is intended to be used for contact grilling foods in commercial foodservice operations only. It is not intended for household, industrial or laboratory use.

Before using this equipment it must be cleaned and dried thoroughly. Clean all surfaces before use. Failure to clean surfaces before using the unit could cause food contamination.

U npacking the

e qUipment

F eatUreS and

c ontrolS and

i nitial

S etUp

Dispose of all packaging, materials in an environmentally responsible manner.

1. Remove all packing material and tape, as well as any protective plastic from the unit.

2. Clean any glue residue left over from the plastic or tape.

3. Place the unit in the desired position and height.

4. Plug the unit into a properly grounded electrical supply matching the nameplate rating. Damage to the unit can occur if incorrect power is supplied.

E

F

A

C

B

D

Figure 1. Features and Controls

A HANDLE. Used to control the up and down movement of the top grill plate.

B TOP GRILL PLATE. Contains a heating element and heats food.

C BOTTOM GRILL PLATE. Contains a heating element and heats food.

D THERMOSTAT CONTROL dial. Used to set or adjust the temperature of the cooking plate. The numbers on the dial correspond with the grill plate temperature. The “0” position is off.

2 O peratOr

’ s

M anual

E PILOT LIGHT. This light indicates the element is heating. Once the set temperature has been reached the light will go out. This light indicates that the element is heating. Once the temperature has been reached the light will go out. Unit will continue to maintain heat and temperature with the light cycling. This is not a power indicator light.

F DRIP TRAY. A container that collects grease, oil and liquid from the bottom grill plate. This is removable for draining and cleaning.

c leaning

To maintain the appearance and increase the service life, clean your unit daily.

WARNING

Burn Hazard.

Do not touch hot food, liquid or heating surfaces while unit is heating or operating.

Hot surfaces and food can burn skin. Allow the hot surfaces to cool before handling. Do not drop or spill water into the cooking surface as it can spray or splatter.

o peration

WARNING

Burn Hazard.

Do not touch hot food, liquid or heating surfaces while unit is heating or operating.

Hot surfaces and food can burn skin. Allow the hot surfaces to cool before handling. Do not drop or spill water into the cooking surface as it can spray or splatter.

Before initial use, turn the thermostat control to the maximum setting, close the lid and allow unit to burn in for 30 minutes. You may notice smoke appearing due to the cooking surface burning in. This is normal. After 30 minute burn in period the unit is ready for use.

To begin heating or cooking:

1. Preheat unit to desired temperature.

2. Center the food product onto the bottom grill plate (C). See Figure 1.

3. Use handle (A) to lower top grill plate (B) to desires height.

4. Heat for desired length of time.

5. Raise handle and remove food product.

WARNING

Electrical Shock Hazard.

Keep water and other liquids from entering the inside of the unit. Liquid inside the unit could cause an electrical shock.

Do not spray the unit or controls with water or cleaning products.

Liquid could contact the electrical components and cause a short circuit or an electrical shock. Do not use unit if power cord is damaged or has been modified

6. At the end of each cooking cycle wipe down the cooking the plates.

Never allow excess fat, oil, or grease to build up as this will result in a build-up of carbon on the plates.

Do not clean the unit with steel wool.

1. Allow the unit to cool completely before cleaning.

WARNING

Electrical Shock Hazard.

Keep water and other liquids from entering the inside of the unit. Liquid inside the unit could cause an electrical shock.

Do not spray water or cleaning products. Liquid could contact the electrical components and cause a short circuit or an electrical shock. Do not use unit if power cord is damaged or has been modified

2. Unplug the unit.

3. Do not immerse the cord, plug or unit in water or any other liquid.

4. Wipe grease or oil into the drip tray (F). See Figure 1.

5. Using a damp cloth or sponge dipped in soapy water to clean the unit and plates (B and C); rinse thoroughly.

6. Dry thoroughly after cleaning.

7. Empty and clean the drip tray (F).

O peratOr

’ s

M anual

3

t roUbleShooting

T roubleshooTing

C harT

Problem

Pilot Light does not come on when the temperature control is turned up.

Grill Plates do not get hot.

It might be caused by

Unit is not plugged in.

Pilot Light malfunction.

Low or no voltage from power source (wall outlet).

Heating Element is faulty.

Course of Action

Plug unit in.

Replace Pilot Light.

Verify correct voltage is being provided to unit. If not, have qualified personnel correct power problem.

Replace Heating Element.

S ervice and

r epair

There are no user serviceable parts within this appliance. To avoid serious injury or damage, never attempt to repair the unit or replace a damaged power cord yourself. Do not send units directly to the Vollrath Company. Please contact the qualified professional repair service listed below.

VOLLRATH Technical Services • 1-800-628-0832 • Email: [email protected]

When contacting the Authorized Professional Service Center, please be ready with the item number, model number (if applicable), serial number, and proof of purchase showing the date the unit was purchased.

4 O peratOr

’ s

M anual

electrical draWing - c oUntertop

S andWich

p reSS

, m odelS

~ 40794, 40795, 407941-c and

40795-c

N

120V ~ 1800Watt

L 1 G

L2 L 1

208-240V ~ 2700-3600 Watt

G

T 1 T 1 T 1

2 3 4 2 5 4

2 3 4

Callout Description

1 Thermostat Control

2 Heating Element, Top, 120V ~ 810 Watt

3 Heating Element, Bottom, 120V ~ 990 Watt

4 Pilot Light, 120V, Amber

Callout Description

1 Thermostat Control

5

2

3

Heating Element, Top,

208-240V ~ 860W Max

Heating Element, Bottom,

Left, 208-240V ~ 940W Max

4 Pilot Light, 240V, Red

Heating Element, Bottom,

Right, 208-240V ~ 940W Max

O peratOr

’ s

M anual

5

Spare partS liSt - c oUntertop

S andWich

p reSS

, m odelS

~ 40794 and

40794-c

Callout Part Number Description

1 XAA0005 Power Cord, 120V, NEMA 5-15P Plug

1786001

XAA0012

XTSI2004

XTSI2030

XTSI2006

XTSI2007

XTSA0007

N/A

XTSI2005

XAA0009

N/A

XTSI2015

XAA0011

XTSI2035

XTSI2016

XTSI2017

XTSI2018

XTSI2019

XTSI2020

XTSI2021

XTSI2036

XTSI2023

N/A

XTSI2024

9

8

7

6

10

11

12

4

3

5

2

1

18

19

20

21

22

23

24

N/S

16

17

13

15

Power Cord, 120V, NEMA 5-20P Plug (Canada only)

Power Cord Restraint

Foot, Rubber

Top Heating Element, 120V ~ 810 Watt

Top Plate, Ribbed, Non-Coated

Bottom Plate, Ribbed, Non-Coated

Thermostat

Bottom Cover

Drip Tray

Control Panel Fascia

Frame

Control Knob (0-550)

Pilot Light, Red, 120 Volt

Bottom Heating Element 120V ~ 990 Watt

Handle, Steel

Handle Grip, Plastic

Handle Spring

Hinge Axle, Front

Hinge Axle Circlip

Hinge Axle, Rear

Wire Tube

Brass Saddle Clamp

Spring Cover

Hinge Axle Rear Cover

6 O peratOr

’ s

M anual

17

19

21

16

18 eXploded vieW - c oUntertop

S andWich

p reSS

, m odelS

~ 40794 and

40794-c

27

26

22

23

4

5

6

24

1

15

13

14

10

11

2

12

20

7 25

3

9

8

O peratOr

’ s

M anual

7

Spare partS liSt - c oUntertop

S andWich

p reSS

, m odelS

~ 40795 and

40795-c

16

17

18

19

20

14

15

12

13

26

27

24

25

28

21

22

23

8

7

7

6

9

10

11

3

2

1

4

3

5

Callout Part Number Description

XTSI3007 Top Heating Element, 208-240V ~ 860W Max

XTSI3005 Top Plate

XTSI2037 Wire Tube, Left

XTSI2038 Wire Tube, Right

N/A Wire Tube, Clip

XTSI3022 Hinge Axle, Rear, (includes Clips)

N/A Hinge Axle, Washer

XAA0006 Power Cord, 240V, NEMA 6-15P Plug

1786201 Power Cord, 240V, NEMA 6-20P Plug (Canada only)

XAA0012 Power Cord Restraint

XTSI2004 Foot, Rubber

XTSA0007 Thermostat

N/A Top Cover

XTSI3004 Drip Tray (includes Knobs)

N/A Box

XTSI2015 Thermostat Control Knob

XAA0002 Pilot Light, Red, 220 Volt

N/A Pilot Light Fascia

XAA0009 Control Panel Fascia

XTSI3008 Bottom Heating Element, 208-240V 940W Max

XTSI3019 Handle, Steel

XTSI3020 Handle Grip, Plastic

XTSI2018 Handle Spring

XTSI2023 Brass Saddle Clamp

XTSI3006 Bottom Plate

XTSI3021 Hinge Axle, Rear

N/A Decal, Vollrath

N/A

N/A

N/A

Bottom Cover, Vented

Bottom Cover, Non-Vented

Wire Brush

8 O peratOr

’ s

M anual

eXploded vieW - c oUntertop

S andWich

p reSS

, m odelS

~ 40795 and

40795-c

20 19

21

22

24 3

21

22 5

4

20

1

19

18

12

18

15

16

17

14

25

66

10

27

13

1

5

2

3

7

8

9

26

28

O peratOr

’ s

M anual

9

W arranty

S tatement For

t he

v ollrath

c o

. l.l.c.

This warranty does not apply to products purchased for personal, family or household use, and The Vollrath Company LLC does not offer a written warranty to purchasers for such uses.

The Vollrath Company LLC warrants each of its products listed below against defects in materials and workmanship for the applicable period provided below. All other products manufactured or distributed by The Vollrath Company LLC are warranted against defects in materials and workmanship for a period of one year.

In all cases, the warranty runs from the date of the end user’s original purchase found on the receipt.

„ Replacement parts – The warranty period is 90 days.

For complete warranty information, product registration and new product announcement, visit www.vollrath.com.

www.vollrath.com

The Vollrath Company, L.L.C.

1236 North 18th Street

Sheboygan, WI 53081-3201

U.S.A.

Main Tel: 800.628.0830

Fax: 800.752.5620

Technical Services: 800.628.0832

Service Fax: 920.459.5462

Canada Service: 800.695.8560

© 2014 The Vollrath Company, L.L.C.

Item No. 2350014-1 en Rev 6/14