HOBART AM12(C) Dishwasher Instruction

INSTRUCTION M A N U A L
...
w i t h Replacement Parts
DISHWASHER
(INCLUDES MOTOR PARTS)
THlS MANUAL REPLACES AND SHOULD BE USED
INSTEAD OF FORM 12364C (9-80)
PRIOR ML'S COVERED IN THlS MANUAL:
A
product of
FORM 13830 15-81
HOBART CORPORATION
TROY, OHIO 45374
.s~aua$se4
ou sa~!nb
-aA jaued
~ u o i 4pJE?pue$sa y l ' ( l ' 6 ! j '01)
~ o o puo!$3adsu! $UOAJ pa3ueleq~a$uno3-uoue pue
( 1 ' 6 ! j ' 5 ) s ~ o o pap!s pa3ueleq~a$uno3OM$ y $ ! ~
AayseMys!p n ~ y ~ $ y 6 ! e e
~ $s!s lapow
1-fly aY1
z
- I I ! paw!$
~
pue u o ! ~ a $ o AO$OU
~d
'a~n~e~ad
-wa$ Aa$eM 'apA3 paw!$ a y l sa$elnEia~y 3 ! y ~cua$sAs
1 0 ~ ~ ~ 13!~01$3a13
03
a p l s p!los e a$e~od~o3u!
hay 1
.sAayseMys!p asu !AAa$eM ysaA4 '3!$ecuolne
-!was aAe ~ z L - I / upue
\ ~ z t - ~ \ d slapow a y l
INSTRUCTIONS AM-12
HEATER PROTECTION
Drain
A float is located in the wash tank to automatically
turn off the heat supply if the water level is too
low. Once the water level returns to a safe level,
the heating circuit i s operational if heat is demanded.
Connect the drain to the sewer using 2" pipe.
Left-hand drain is standard. Interchange plug
for a right-hand drain. If a grease trap i s required
by code, it should have a minimum flow capacity
.
of 42 gallons per minute.
Tank water is heated by steam, gas, or electricity.
Water Supply
REDUCED VOLTAGE CONTROL (STANDARD)
The supply water should have a temperature of
180"-195" F. minimum and have a flow pressure
of 15 t o 25 P.S-I. at the pressure gauge tee beside
the fill (solenoid) valve.
A control transformer is used t o provide low
voltage for the solid state control circuits. This
control transformer also supplies 115 V.A.C. t o the
control components.
INSTALLATION
LOCATION
Adequate space must be available t o open and
service the control box (6, Fig. 1). The control box
i s mounted 4-518" below the dish table height
when shipped from the factory. I t can be changed
t o 12-518" below the dish table by removing two
bolts and reinstalling in the two lower holes
provided.
Set the dishwasher in i t s desired location. Adjust
the height and level by turning the threaded feet
(7, Fig. 1). Make sure the dishwasher i s level before
making plumbing connections.
Dish tables (1, Fig. 2) should be turned down and
f i t into the dishwasher. Use a sealer between table
and tank lip t o prevent leakage. Fasten the dish
tables to the tank lip with truss head screws.
Plumbing connections must comply with applicable sanitary, safety and plumbing codes.
Use 314" pipe for connecting the water supply line
t o line strainer which i s assembled directly ahead
of the fill (solenoid) valve. The line strainer prevents foreign matter from reaching the solenoid
valve. If flow pressure exceeds 25 P.S.I., a pressure
reducing valve (not furnished) must be installed in
the water supply line.
Gas Heat
Check gas data plate (9, Fig. 1) attached t o dishwasher or tag attached t o gas burner tubing for
type of gas t o be used.
Connect gas burner t o gas supply. Check gas burner
compression fittings to assure they have not
loosened during shipment.
A capped "tee" (not supplied) i s recommended t o
catch loose particles in front of the valve.
The burner is not adjustable. If line pressure is
above 7" W.C. (natural gas) or 11" W.C. (L.P. gas),
an additional regulator valve (not supplied) must
be installed.
The burner is ignited automatically by solid state
circuitry. There is no pilot light. Gas flow i s regulated by the temperature control circuit through a
solenoid valve.
If a failure occurs in the gas heat control board or
gas pressure, the reset button, located on the side
of the gas burner control box, will pop out. This
completely shuts off the gas heat system. To reset,
push the button in. If system does not reset,
contact an authorized Hobart service office.
Steam Heat
U
Fig. 2
The steam supply must be between 15 and 50 P.S. I.
flowing pressure. Steam flow i s controlled by a
solenoid valve as well as a mechanical globe valve.
A M - 12 INSTRUCTIONS
A 314" union connection, for steam supply line,
is located behind the control box.
A solid state circuit board controls the steam valve
t o provide shut-off. When the dishwasher i s not in
use, close the globe valve in the line ahead of the
solenoid valve.
ELECTRICAL COhINECTIONS
Before making electrical connections, check the
specifications on machine data plate (4, Fig. 1) to
assure they agree with those of your electrical
service.
Electrical and grounding connections must comply
with the a ~ ~ l i c a b ~l eo r t i o n so f the National Electrical cod;' and/or 'other local electrical codes.
WARNIIVG: DISCONNECT E L E C T R I C A L
POWER SUPPLY AND PLACE A TAG A T DISCONNECT SWITCH .INDICATING CIRCUIT
IS BEING WORKED ON.
See wiring diagram attached inside o f control box
cover. Refer t o chart for correct wire and fuse sizes
when connecting dishwasher.
BRANCH CI RCUlT SIZE AND PROTECTION
Max.
60°C
Min. Ckt. Time Delay Copper
Ampacity
Fuse
Wire Size
Ph.
100-120 1
100-120
200-240 1
200-240 3
400480 3
Motor
Only
Electric
Heat Only
Motor
& Electric
Heat
25
50
30
15
ground lead t o the grounding lug (2, Fig. 3) in the
control box.
Three-phase motors must rotate the impeller in the
direction of the arrow located on the pump housing (counterclockwise). T o check rotation, remove
motor fan cover ( 5 , Fig. 1) . Close machine doors.
Connect power t o machine and push the power
switch ON then OFF. Motor fan must rotate
counterclockwise when facing fan.
$-
MACHINES WITH ELECTRIC HEAT
Volts
Fig. 3
25
I f rotation is incorrect, DISCONNECT ELECTRlCAh POWER SUPPLY and interchange any ktwo of the incoming power supply leads. Re-energize and verify correct rotation. Replace fan cover.
OPERATION
60
4
50
30
15
6
10
14
The dishwasher can be operated in AU-TORIIATIC
or MANUAL by positioning the Cycle switch (5,
Fig. 4 ) in desired position. When Cycle switch i s set
MACHIkIES WITH STEAM OR GAS HEAT
Volts
100-120
200-240
2013-240
4.00-480
Max.
Min. Ckt. Protective
Ampacity Device
Ph.
I
1
3
3
Motor &
Valves
30
15
15
15
6G°C
Copper
Wire Size
30
ao
15
14
14
14
15
6
A fused disconnect switch or circuit breaker (not
furnished) MUST be instailed in the electrical
service l'ine supplying this dishwasher and should
meet the requirements of your local electrical c ~ d e .
,411 connections are made a t the terminal blocl< in
the control box.
Connect a permanent electrical power supply t o
the incoming power sr-lpply b!ock (1, Fig. 3) and a
Fig. 4
INSTRUCTIONS AM-12
for AUTOMATIC, the WASHIRINSE switch (4,
Fig. 4) must be in the OFF position. When Cycle
switch i s set for MANUAL, wash operation i s
accomplished when WASHIR INSE switch is in
WASH position. To rinse in MANUAL operation,
hold WASH/R\NSE switch in RINSE position for
desired rinse time.
When operating the dishwasher in AUTOMATIC
setting, close door (5, Fig. 1) t o start cycle. When
pilot light (3, Fig. 4) goes off, cycle i s comp!eted.
I f cycle i s interrupted, such as opening and closing
the door t o add a dish, the timer resets and starts a
new cycle. This feature provides a complete
cycle t o insure proper cleaning ~f an added article.
6efore opening the door during a cycle, first turn
off POWER switch; then wait 10 seconds t o avoid
water splashing from the wash arms.
Fig. 6
model, the front inspection door (10, Fig. I ) must
be closed before counterbalanced doors can be
lowered.
Push POWER switch (1, Fig. 4) to ON. Push and
release timed F l L L switch (2, Fig. 4) t o start
automatic fill operation. Wait a full 2 minutes 18
seconds for the timed fill cycle to complete and
shut off.
The wash thermometer (1, Fig. 1) should register
150"-168" F. during wash cycle. The rinse thermometer (11, Fig. I),during rinsing operation,
should register 180"-195" F. minimum. These tempera-tures are necessary for dishwashing and sanitization.
Fig. 5
Place overflow tube (2, Fig. 5), overflow cover (1,
Fig. 5), end cover (1, Fig. 6), slanted strainer (2,
Fig. 6) and strainer bucket (3, Fig. 6) in position.
Scrape the dishes to remove large partic!es of food
and debris. Water-scrape the dishes by means of a
spray of water from the water system or by a
stream of recirculating water before or after
racking the dishes.
Scatter the initial charge of detergent on the
slanted strainer. Replenish as needed unless automatic detergent dispenser has been added by others.
When racking dishes DO NOT stack one on top of
another. Water must have free access t o both sides
of every dish.
Close the counterbalanced doors (5, Fig. 1) which
automatically closes the drain. On straight-thru
Stand plates and flat dishes up edgewise in mixed
dish rack (Fig. 7).
PREPARATION
AM-12INSTRUCTIONS
Cups, glasses, and bowls should be placed open-side
down (bottoms up) in cup, glass, and silver rack
(Fig. 7 ) .
Knives, forks, spoons and small pieces should be
scattered loosely over screen bottom of cup, glass,
and silver rack.
MAINTENANCE
W A R N I N G : DISCONIVECT E L E C T R I C A L
POWER SUPPLY AND PLACE A TAG A T THE
DISCONNECT SWITCH INDICATING CIRCUIT
IS BEING WORKED ON BEFORE BEGINNING
ANY MAINTENANCE PROCEDURE.
After filling rack, raise the doors (5, Fig. 1) and
slide rack into dishwasher. Close the doors. Wash
and rinse cycle starts automatically and stops after
completion.
CLEANING
Push POWER switch (1, Fig. 4) to OFF.
Open doors. Clean off "soiled" and "clean" dish
tables into dishwasher. Drain machine by pulling
drain lever (3, Fig. 5).
Remove and empty slanted strainer (2, Fig. 6) and
strainer basket (3, Fig. 6). Wash and rinse thoroughly.
Raise overflow cover (1, Fig. 5) and remove overflow tube (2, Fig. 5). Thoroughly cleanse and flush
dishwasher interior. Wash and rinse overflow tube
inside and out.
Leave doors open to allow interior to air dry.
Make sure that wash (5, Fig. 6 & 3, Fig. 8) and
rinse arms (6, Fig. 6 & 2, Fig. 8) rotate freely and
are free of any obstructions. Refer to MAINTENANCE i f any obstructions are present.
Check rinse nozzles (4, Fig. 6 & 1, Fig. 8) to make
sure they are free of any lime and solids.
Fig. 9
LUBRICATION
NOTE: Contact your Hobart Sales and Service
Office for proper lubricants.
Motor
DISCONIVECT ELECTRICAL POWER SUPPLY
and lubricate the motor once or twice a year with
the approved lubricant. Remove the grease plug
(1, Fig. 9) and add one pump from a standard
grease gun.
CAUTION : DO NOT over-lubricate; excessive
lubrication can do more damage than underlubrication.
WASH ARMS
Both wash arms (5, Fig. 6 & 3, Fig. 8) and both
rinse arms (6, Fig. 6 & 2, Fig. 8) should turn
freely and continue turning for a few seconds
after being whirled by hand. To check, DISCONNECT ELECTRICAL POWER SUPPLY,
rotate arms, and remove any obstructions causing
improper operation.
Fig. 8
If the slanted strainer (2, Fig. 6) or strainer
bucket (3, Fig. 6) is not properly in place, obstructions (such as food partcles or bones) may
clog the wash arm nozzles. The wash arms are
easily removed for cleaning.
B
\
INSTRUCT1ONS AM-12
To remove the lower wash arm (5, Fig. 6), first
lift off the rinse arm (6, Fig. 6), then using a
dowel (or end of punch) unscrew the rinse arni
bearing pin (7, Fig. 6) and lift off lower wash
arm. I t is not necessary t o remove the spacer
located on lower wash arm shaft.
4. Excessively hard water.
5. lncorrect
detergent
for
water
conditions.
SYMPTOM - Inadequate Rinse
POSSIBLE CAUSE:
The upper wash arm (3, Fig. 8) is removed by
unscrewing the hand knob (4, Fig. 8) and removing upper rinse arm and wash arm together.
Be careful not to drop these arms.
1. Dirty line strainer causing .reduced water flow.
Turn off water supply, remove strainer cap,
withdraw and clean screen. Reassemble.
2. Low supply line pressure.
TROUBLESHOOTING
NOTE: I f symptom persists after possible causes
have been checked-out, contact an authorized
Hobart Service Office.
SYMPTOM - Dishes not clean
A pressure gauge (3, Fig. 1) is provided in the
final rinse piping. Pressure should be 15-25
P.S.I. (20 P.S.I. is nominal). To check the rinse
pressure, turn the petcock 90" (parallel to the
line) during final rinse. It is important thst the
pet cock be closed (perpendicular to the line)
by the end of the rinse cycle or damage to the
gauge may result.
POSSIBLE CAUSE:
SYMPTOM - Leaking valve (except solenoid type)
'I.
Insufficient wash water due t o drain obstruction preventing proper drain closing.
2. Worn or torn drain "0" ring allowing wash
water to drain.
2.
b
.
3. Loss of water pressure due t o pump obstructions.
DlSCONNECT ELECTRICAL POWER SUPPLY and drain tanks. Check for any obstruction a t the pump intake.
4. lncorrect water temperature. Check circuit
breaker t o electric heat supply, or main steam
valve. Make certain valve i s completely open.
5. Iiicorrect detergent dispensing. Contact your
detergent representative
&.
POSSIBLE CAUSE:
1. Foreign material preventing proper valve
operation.
NOTE: A critical period i s soon after installation when pipe compound or metal shavings
may lodge at the valve seat. Shut off supply
line. Unscrew and lift bonnet from valve body.
Clean valve and reassemble.
2. I f a solenoid valve i s malfunctioning it is recommended that authorized Hobart Service
personnel be contacted.
SYMPTOM
- No wash tank heat
POSSIBLE CAUSE:
SYMPTOM - Spotting of silverware, glasses and
dishes
1. The machine is equipped with a low water
safety device which shuts off the heat i f water
level drops. Check for proper water level.
POSSIBLE CAUSE:
2. Circuit breaker t o heat system tripped.
1. l mproperly loaded racks.
3. Gas line closed.
2. lncorrect rinse water temp. (min. 180" F.)
4. Steam valve not open completely.
3.
SYMPTOM - No machine operation
Loss of water pressure due t o pump obstruction.
DISCONNECT ELECTRICAL POWER SUPPLY and drain tanks. Check for any obstruction a t the pump intake.
POSSIBLE CAUSE:
1. Blown fuse or tripped circuit breaker a t power
supply.
Page
9
11
13
15
17
19
21
23
25
26
27
29
31
33
35
36
37
38
39
41
43
45
47
49
51
53
55
56
Description
Conduit (R.H. Controls)
Conduit (L.H. Controls)
Control Box
AM-12 Motor & Pump
AM-12A Motor & Pump
Motor Parts
Lower Wash Arm (Thrust Washer Type)
Lower Wash Arm (Ball Bearing Type)
Upper Wash Arm (Thrust Washer Type)
Upper Wash Arm (Ball Bearing Type WIStationary Rinse)
Upper Wash Arm (Ball Bearing Type WIRotating Rinse)
Outside Rinse Piping
lnside Rinse Piping
Inside Rinse Piping (Low Water Consumption)
Door Interlock
Door (Straight - Thru)
Door (Corner)
Door Lift Unit (Straight - Thru)
Door Lift Unit (Corner)
Strainers & Drain
Track Unit
Miscellaneous
Low Water Protection
Electric Heat
Gas Burner Unit
Flue & Igniter Control (Gas)
Steam Injector
Dish Racks
REPLACEMENT PARTS AM-12
CONDUIT
(R.H. CORITROLS)
ILLUS.
PART
PL-16176 NO.
1
2
3
4
5
**6
*7
**8
*9
"*lo
*11
**I2
*13
**I4
*15
P-77657-38
FE-8-25
FE-8-11
FE-8-24
FE-8-11
FE-8-25
FE-8-33
FE-8-11
FE-8-12
P-77657-39
C-104192-9
FE-8-23
FE-8-31
FE-8-11
FE-8-12
N A M E O F PART
*110-120 v.
**200 V. & Above.
(i,
AMT.
...................................
..................
.............................................
..................
.............................................
..................
.....................
.............................................
..............................................
...................................
..................................
................
..................
.............................................
..............................................
Conduit - 314" x 32" (Waterproof)
Connector .90' "Sealtite" (314" Male Thd. x 314" Flex. Cnd.)
314" Gasket Assy
Connector - 45' "Sealtite" (314" Male Thd. x 314" Flex. Cnd.)
314" Gasket Assy
Con~lector- 90' "Sealtite" (314" Male Thd. x 314" Flex. Cnd.)
Connector .90' "Sealtite" (1" Male Thd. x 1" Flex. Cnd.)
314" Gasket Assy
1" Gasket Assy
Conduit - 314" x 10" (Waterproof)
Conduit - 1" x 9-114" (Waterproof)
Connector -Straight "Sealtite" (314" Male Thd. x 314" Flex. Cnd.)
Connector - Straight "Sealtite" (1" Male Thd. x 1" Flex. Cnd.)
314" Gasket Assy
1" Gasket Assy
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
REPLACEMENT PARTS AM-12
CONDUIT
(L.H. CONTROLS)
I LLUS.
PL-16177
1
2
3
4
5
'
PART
NO
.
FE-8-11
FE-8-25
P-77657-1
FE-744
FE-7-32
C-119190-1
FE-8-11
FE-7-35
FE-8-11
FE-7-35
C-119190-2
FE-646
SC-21-23
WL-6-7
FE-7-32
FE-7-44
P-77657-5
FE-8-24
FE-8-11
FE-8-12
FE-8-32
C-104192-10
FE-14-37
FE-7-33
B-122915
B-119311-1
FE-7-33
FE-7-30
FE-7-33
B-119311-2
FE-8-12
FE-7-36
NAME OF PART
A M T.
.............................................
..................
...................................
.
.
.
.......................
314" Gasket Assy
Connector .90' "Sealtite" (314" Male Thd . x 314" Flex .Cnd.)
Conduit .314" x 18" (Waterproof)
Connector .Straight "Sealtite" (314" Female Thd x 314" Flex Cnd.) . . . . . . . . . . . . . .
Connector -Straight (314" Male Thd x 314" Thinwall)
Conduit .314" Thinwall (Control Box to Coupling) . . . . . . . . . . . . . . . . . . . . . . . . .
314" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ell .90' Short (314" Male Thd x 314" Thinwall)
314" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ell .90' Short (314" Male Thd x 314" Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . .
Conduit .314" Thinwall (Control Box to Coupling)
Clamp .314" Conduit
Mach Screw .#lo-24 x 112" Rd .Hd
Lock Washer .# 10 Medium
Connector .Straight (314" Male Thd . x 314" Thinwall) . . . . . . . . . . . . . . . . . . . . . . .
Connector -Straight "Sealtite" (314" Female Thd x 314" Flex . Cnd.)
Conduit .314" x 22" (Waterproof)
Connector .45' "Sealtite" (314" Male Thd x 314" Flex Cnd.) . . . . . . . . . . . . . . . . . .
314" Gasket Assy
1" Gasket Assy
Connector .45' "Sealtite" (1" Male Thd . x 1" Flex Cnd.)
Conduit .1" x 24-112" (Waterproof)
Connector -Straight (1" Female Thd .x 1" Flex Cnd.)
Connector -Straight (1" Male Thd .x 1" Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . .
Clamp .1" Conduit
Conduit .1" x 16" (Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector -Straight (1" Male Thd x 1" Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . .
Ell .90' x 1" Pulling
Connector .Straight (1" Male Thd . x 1" Thinwall)
Conduit .1" x 4" (Thinwall) (Pulling Ell to Control Box)
1" Gasket Assy
Ell .90' Short (1" Male Thd .x 1" Thinwall)
.
..........................
.
.........................
..........................................
.................................
.......................................
.
..............
...................................
.
.
.............................................
...............................................
.
....................
..................................
.
.......................
...........................................
.
...........................................
..........................
......................
..............................................
.............................
.
.
*110-120 v
**200 V & Above .
.
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
AM-12 REPLACEMENT PARTS
CONTROL BOX UNIT
ILLUS.
PART
PL-17842 NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
SC-71-11
WL-7-12
E-112012
SD-8-25
B-112124
B-111886
B-112124
B-111886
B-205113-1
B-112173
SD-8-25
SD-8-25
SD-8-25
C-118544-1
C-111995
C-112312
SD-19-28
FE-16-29
NAME OF PART
AMT.
. .
... . ... .... .. 4
. . . . . . . . . . . .. .. . . . . . . 4
................................................ 1
. . . . . . .. . . . . . . . . . . 2
. .
. . . . . . . . . . . . . . . . . . . . . AR
. . . . . . . . . . . . . . . . . . . . . . . AR
. . . . . . . . . . . . . . . . . . AR
.. .
.. . . .
. . . . . . . . . AR
. .. .. ... . . . .. . . ... . . . ... . .. . . .. . . 1
. . . .. ..... . ... . .. . . .. ..... . . 1
.... .... . . 2
. .. . .... ... 1
. . . . .. . . . . .. . . . . . . 1
. . . .. . .
.. . . .. .. .. .
.... 1
. . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . 1
. ...... .
. . ... .. . . . ..... . . .. . . 1
.
. . . .. ..... . .. 2
. . .. . . .. . . . . . . . . . . . . . . 2
Mach. Screw - #lo-24 x 318" Phil. Truss Hd . . . . . . . . . .
.. . .
Lock Washer - #10 Ext. Shakeproof. . . .
.
. ... . . . .
Plate-Base
Self-Tapping Screw - # 10 x 318" Phil. Bind. Hd., Type B
.
.
..
Contactor - Magnetic (2 Pole) . . . . . . . . .
. ..
..
.
. .
. .
, . .
. . . ..
Contactor - Magnetic (3 Pole) . . .
..
.. . .
.. .
Contactor - Magnetic (2 Pole) (Elec. Heat) . . .
... .....
.....
.
Contactor - Magnetic (3 Pole) (Elec. Heat)
. . . . ..
..
..
Relay (Gas Heat) . .
Insulator (Gas Heat)
...
. ..
.. . . . . . . .
Self-Tapping Screw - $10 x 318" Phil. Bind. Hd., Type B (Elec. Heat) . . . .
.
..
.
Self-Tapping Screw - #20 x 318" Phil. Bind. Hd., Type B (Gas Heat)
Self-Tapping Screw - #10 x 318" Phil. Bind. Hd., Type B
.
. ..
Lug - Solderless . . . . .
. .. . .. . ..
.
. . ..
.....
Block - Terminal
. .
.
.
... . .
.
..
. ... . .
. . ..
. . .
Board - Insulating
Self-Tapping Screw - # 8 x 1-318" Phil. Rd. Hd., Type B
.... . . .
.
Fuse - Fiber Tube (1 Amp. BBS-1) (SO Hz., 3 Ph.) .
..
.
REPLACEMENT PARTS AM-12
CONTROL BOX U N I T (Cont.)
.
PART
I LLUS
PL-17842 NO
19
20
21
22
23
24
""25
*:"6
*27
"28
29
30
31
.
FE-16-30
FE-19-48
FE-19-50
SD-8-18
C-118300
D-112059
E-119092-1
E-119138-1
E-119309
D-119182
SD-12-4
SD-8-25
C-111983-1
NAME OF PART
AMT
Fuse .Fiber Tube (2 Amp . BBS-2) (50 Hz.. 1 Ph.) . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Fuse -Fiber Tube (.8 Amp . BBS.8) (60'Hz., 3 Ph.) . . . . . . . . . . . . . . . . . . . . . . . . . 2
Fuse -Fiber Tube (1.6 Amp . BBS.1.6) (60 Hz., 1 Ph.) . . . . . . . . . . . . . . . . . . . . . . . 2
Self-Tapping Screw - #8 x 318" Phil . Bind . Hd., Type B . . . . . . . . . . . . . . . . . . . . . . . 1
Terminals & Mounting Board Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Insulator - Terminal Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
........ 1
Control Box (R.H. Controls) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Control Box (L.H. Controls) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Control Box (R.H. Controls) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Control Box (L.H. Controls) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Self-Tapping Screw - $8-32 x 318" Phil . Truss Hd., Type 23 . . . . . . . . . . . . . . . . . . . . .
4
Self-Tapping Screw .# 10 x 318" Phil . Bind . Hd., Type B . . . . . . . . . . . . . . . . . . . . . : 4
Power Input Board Assy . (110-120 V., 6 0 Hz., 1 Ph.) (200-230 V., 60 Hz., 1 Ph . W/Pilot
Circuit) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Power Input Board Assy . (200-230 V., 60 Hz., 3 Ph . W/Pilot Circuit) (400-460 V., 6 0 Hz.,
3Ph.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Power Input Board Assy . (115 V., 5 0 Hz., 1 Ph.) (220 V., 50 Hz., 1 Ph .. W/Pilot Circuit) . . .
1
Power Input Board Assy . (220 V., 50 Hz.. 3 Ph ..W/Pilot Circuit) (380 V., 50 Hz., 3Ph.) . . . .
1
Power Supply Board Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Timer Board Assy . (ML-18500 & ML-18501) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Timer Board Assy . (ML-31819 & ML-31820) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Motor Protector Board Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Temperature Control Board Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Master Board Assy . (ML-18500 & ML-18501) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Master Board Assy . (ML-31819 & ML-31820) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Retainer .Clamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Clamp-Wire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Self-Tapping Screw .#8 x 318" Phil . Bind . Hd., Type B . . . . . . . . . . . . . . . . . . . . . . .
Clamp-Wire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Self-Tapping Screw - #8-32 x 112'' Phil . Truss Hd., Type 23 . . . . . . . . . . . . . . . . . . . . 2
Reed Mounting Board Assy . (Incls. item #48) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Switch-Reed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Self-Tapping Screw .#8-32 x 318" Phil. Truss Hd., Type 23 . . . . . . . . . . . . . . . . . . . . 2
Screw - Captive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Retainer - Captive Screw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4
Spacer - Lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Lid & Gasket Assy . (Incls . item #54) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Gasket - Control Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Start Switch Assy . (Momentary) (Timed Fill) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#6-19 x 318" Phil. Pan Hd . "Plastite" . . . . . . . . . . . . . . . . . . . . . 2
Lock Washer .#6 Ext . Shakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
2
Self-Tapping Screw - #10 x 318" Phil . Bind . Hd., Type B . . . . . . . . . . . . . . . . . . . . . .
On/Off Switch Assy . (Maintained) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Self-Tapping Screw .#6-19 x 318" Phil . Pan Hd . "Plastite" . . . . . . . . . . . . . . . . . . . . . 2
2
Lock Washer - #6 Ext . Shakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Plate .Base (Dispenser Contactor) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Plate .Identification (Power) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket -Control Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Lock Washer - 114" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
2
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Identification (Fill) (Timed Fill) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Solid State Pilot Light Assy . (Timed Fill) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Plate - Identification (Cycle) (Timed Fill) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Toggle Switch & Label Assy . (Cycle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer - 112" Int . Shakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Toggle Switch & Label Assy . (On/Off) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Plate-Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Full Nut .5116"-18 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Lock Washer - 511 6" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Cap Screw .5116"-18 x 314" Hex Hd . (Control Box to Support) . . . . . . . . . . . . . . . . . . 2
3
Pin .Control Box & Lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Identification (Blank) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Contactor (Soap Dispenser) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Insulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Edge Guide - P.C. Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 0
Timed Fill Board Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Wiring Harness (Not Shown) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Fuse (3 Amp., 32 V.) (Use in Power Input Board) . . . . . . . . . . . . . . . . . . . . . . . . . .
1
;
.
*110-120 v .
**200 V . & Above .
- 13 -
.
.
REPLACEMENT PARTS AM-12
AM-12 MOTOR AND PUMP UNIT
.
PRIOR TO SERIAL NO 23-028-320 (AM-12)
12-052-786 (AM-12)
12-052-922 (AM-12C)
PART
NO
.
NS-246
WL-6-32
WS-21-1
D-118968
D-121567-2
KW-3-3
A-104329
D-67500-7
FP-64-15
ML-18491
SC41-11
WL-6-22
B-119265
E-118961
C-119054
C-119050
C-118960
WL-6-22
SC-41-11
SC41-11
WL-6-22
WS-17-8
SC41-5
WL-6-17
WS-348
B-119051
B-119299-1
B-119299-2
B-119299-3
B-1192994
NAME OF PART
........................................
.......................................
...................................................
............................................
..........................................
.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
..................................
......................................
.................................
.......................................
.......................................
...............................................
........................................
..........................................
..........................................
.......................................
.................................
.................................
.......................................
...................................................
..................................
......................................
...................................................
........................................
.
.....
.
.....
.
.....
.
.
.....
*Select gasket to obtain .005" to .015" clearance between pump and impeller .
AMT
Acorn Nut .7116"-20
1
Lock Washer .7/16" Light
1
Washer
1
Impeller (60 Hz.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Impeller (50 Hz.).
1
Key .#404 Woodruff
1
Shaft Seal Assy 518"
1
-0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Nipple .318" x 2-114" Lg . (S.T.O.E.)
1
Motor (Give Electrical Spec.)
1
Cap Screw .5/16"-18 x 314" Hex Hd
6
Lock Washer .5/16" Light
6
Gasket Kit (Motor to Pump) (One Set consists of: 1 Blue (.005" Thk.); 1 Brown (.OIOn Thk.);
1 Set
and 1 Yellow (.020" Thk.))
Shell-Pump
1
Gasket .Pump Discharge
1
Gasket .Pump Intake
1
Shroud .Pump Intake
1
Lock Washer .5/16" Light
4
Cap Screw .5116"-18 x 314" Hex Hd
4
Cap Screw .5116"-18 x 314" Hex Hd
2
Lock Washer .5/16" Light
2
2
Washer
Cap Screw .114"-20 x 518" Hex Hd
2
2
Lock Washer .114" Medium
Washer
2
1
Gasket .Pump Drain Hole
AM-12 Motor & Impeller Assy . (60 Hz., 1 Ph.) (Incls items # 1 , 2 , 3 , 4 , 6 , 7 , 8 & 10)
1
AM-12 Motor & Impeller Assy (60 Hz., 3 Ph.) (Incls . items #I, 2 , 3 , 4 , 6 , 7 , 8 & 10)
1
AM-12 Motor & Impeller Assy . (50 Hz., 1 Ph.) (Incls items # 1 , 2 , 3 , 5 , 6 , 7 , 8 & 10)
1
AM-12 Motor & Impeller Assy (50 Hz., 3 Ph.) (Incls items # l , 2 , 3 , 5 , 6 , 7 , 8 & 10)
1
.
SlkiVd lN3VU33VId3tl ZL-VUV
REPLACEMENT PARTS AM-12
AM-12A MOTOR AND PUMP UNIT
.
FIRST SERIAL NO 23-028-320 (AM-12)
12-052-786 (AM-12)
12-052-922 (AM-IZC)
ILLUS.
PL-16166
l\ -
PART
NO
.
1
2
3
4
5
6
7
8
9
10
11
12
*13
NS-24-6
WL-6-32
WS-21-1
D-118968
D-121567-2
KW-3-3
A-104329
D-67500-7
ML-34217
SC-41-29
WL-6-27
D-67500-97
B-277836
14
15
16
17
18
19
20
21
22
23
24
25
26
E-276281
C-119054
C-119050
C-118960
WL-6-22
SC-41-11
SC-41-11
WL-6-22
WS-17-8
SC-41-5
WL-6-17
WS-3-48
B-119051
B-277786-1
B-277786-2
B-277786-3
B-277786-4
NAME OF PART
AMT
..........................................
.......................................
...................................................
.............................................
..............................................
..........................................
.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.................................................
........................................
..................................
........................................
Acorn Nut .7116"-20
Lock Washer .7/16" Light
Washer
Impeller (60 Hz.)
Impeller (50 Hz.)
Key .#404 Woodruff
Shaft Seal Assy 518"
"0"Ring
Motor (Give Elec .Spec.)
Cap Screw .318"-16 x 718" Hex Hd
Lock Washer .318" Light
"0"Ring
Shim Kit (Motor to Pump) (One Set consists of:
and 1 Yellow (.020" Thk.))
Shell-Pump
Gasket -Pump Discharge
Gasket .Pump Intake
Shroud -Pump Intake
Lock Washer .5116" Light
Cap Screw .5116"-18 x 314" Hex Hd
Cap Screw .5116"-18 x 314" Hex Hd
Lock Washer -5116" Light
Washer
Cap Screw .114"-20 x 518" Hex Hd
Lock Washer .114" Medium
Washer
Gasket -Pump Drain Hole
AM-12A Motor & Impeller Assy (60 Hz.. 1Ph.)
AM-12A Motor &Impeller Assy (60 Hz., 3 Ph.)
AM-12A Motor & Impeller Assy . (50 Hz., 1 Ph.)
AM-12A Motor &Impeller Assy (50 Hz., 3 Ph.)
.................................................
1
1
1
1
1
1
1
1
1
2
2
1
1 Blue (.005" Thk.); 1 Brown (.010" Thk.);
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Set
............................................... 1
........................................
........................................
..........................................
........................................
.................................
.................................
.......................................
..................................................
..................................
......................................
...................................................
........................................
.
(Incls.items #1.2.3.4.6,7.8. 9 & 12) . . .
.
(Incls. items #1.2. 3 . 4 , 6 , 7 . 8 . 9 & 12) . . .
(Incls.items #1.2.3.5.6,7.8. 9 & 12) . . .
.
(Incls .items #1.2.3.5.6.7.8, 9 & 12) . . .
*Select shims to obtain .005" to .012" clearance between pump and impeller .
1
1
1
4
4
2
2
2
2
2
2
1
1
1
1
1
.
REPLACEMENT PARTS AM-12
MOTOR UNIT
(AM-12A = M L-34217)
(AM-12 = ML-18491)
PART
NO.
C-119858-2
SC-949
D-114379-3
D-114379-2
D-111493-1
R-77067
SC-9-65
SL-24
RR4-17
BB-20-18
SC-81-76
WL-8-13
D-113403
SD-15-27
WL-7-12
SD-1245
M-60395
M-79118
M-80369
SD-1245
C-113405
B-114811
C-113417
C-113552
D-65477-147-1
D-65477-147-2
D-65478-110-1
D-65478-112-1
C-22275-208
C-22275-207
C-15747-288
B-104725
D-704876
M-89258
SD-15-3
WS-2-15
BB-20-18
E-121191-1
E-121191-2
E-118969-1
E-118969-2
B-118070-1
NAME OF PART
Switch .Starting (Stationary Part) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#6-32 x 318" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Bearing (Fan End) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Bearing (Fan End) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fan .Ventilating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cover -Motor End . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#8-32 x 1/4" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Spring .N.D. #S-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Retaining Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ball Bearing .N.D. #77503 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach. Screw .#lo-24 x 7" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#10 Int . Shakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Box .Terminal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#lo-24 x 5/16" Pan Hd . "Taptite" . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#10 Ext . Shakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#8-32 x 5/16" Pan Hd., Type 23 . . . . . . . . . . . . . . . . . . . . . . .
Grommet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bushing .Snap (Field Ring) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bushing .Snap (Field Ring) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#8-32 x 5/16" Pan Hd., Type 23 . . . . . . . . . . . . . . . . . . . . . . .
Cover -Terminal Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket .Terminal Box Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector Block Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Terminal Block Base Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stator Assy . (100-1 15 V.1200.230 V .. 60 Hz.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stator Assy . (110-120 V.1220.240 V .. 5 0 Hz.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stator Assy . (200-230 V./400-460 V .. 60 Hz.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stator Assy . (200-240 V./346-415 V ..5 0 HZ.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotor Assy . (100-1 20 V./200.230 V ..60 HZ.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotor Assy . (100-120 V./200.240 V ..50 Hz.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotor Assy . (200-230 V./400.460 V ..60 Hz.) (200-240 V.1346.415 V .. 50 Hz.) . . . . . . . .
Capacitor Cover & Insulator Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Capacitor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Retainer .Capacitor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#lo-24 x 114" Pan Hd . "Taptite" . . . . . . . . . . . . . . . . . . . . . . .
Washer (Shims screw to prevent bottoming) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ball Bearing .N.D. #77503 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Bearing (Pump End) (60 Hz.) (AM-12A Only) . . . . . . . . . . . . . . . . . . . . . .
Bracket .Bearing (Pump End) (50 Hz.) (AM-12A Only) . . . . . . . . . . . . . . . . . . . . . .
Bracket .Bearing (Pump End) (60 Hz.) (AM-12 Only) . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Bearing (Pump End) (50 Hz.) (AM-12 Only) . . . . . . . . . . . . . . . . . . . . . . .
Plug (Not Shown) (Use with items #38,39, 40 & 41) . . . . . . . . . . . . . . . . . . . . . . . .
*1 Phase .
**3 Phase .
AMT
1
2
1
1
1
1
2
1
1
1
4
4
1
2
2
2
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
1
1
.
llNn LNUV HSVM U3MO1
REPLACEMENT PARTS AM-12
LOWER WASH ARM UNIT
(THRUST WASHER TYPE)
.
ILLUS
PART
PL-16196 NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
D-119032
D-67500-57
SC-41-30
WL-6-28
E-118973-2
B-119034
B-119229
C-119222
B-119227
D-119198
WL-6-7
SC-21-21
M-24160
M-22731-3
M-74046
R-89159
C-119087
M-21110
V-21137
SC-21-14
D-67500-57
WL-6-1
SC-50-26
R-89158
C-119113
N A M E OF PART
Tube-Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .318"-16 x 1" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .318" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tee .Lower Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shaft .Lower Wash Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spring .Compression . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HubAssy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer .Thrust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wash Arm & Hub Assy . (Incls. items #8,9, 1 1 & 12) . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#lo-24 x 114" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rinse Arm Bearing Pin & Thrust Washer Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nozzle .Rinse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plug .Rinse Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Arm .Inside Rinse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rinse Arm Body Assy . (Incls .item #18) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bearing .Rinse Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Pivot Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#8-32 x 318" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#8 Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Set Screw .#lo-24 x 318" Sq . Hd., Cup Pt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Arm .Outside Rinse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lower Rinse Arm Assy . (Incls .items #14 thru 20,22, 23 & 24) . . . . . . . . . . . . . . . . . .
AMT .
1
REPLACEMENT PARTS AM-12
LOWER WASH A R M UNIT
(BALL BEARING TYPE)
.
ILLUS
PART
PL-17806-1 NO
i :
\
.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
.
D-119032
D-67500-57
SC-41-30
WC6-28
E-118973-2
B-119034
B-286944
D-286948
BA-2-40
D-67500-19
C-286947
D-287987
WL-6-7
SC-21-23
B-286946
B-122440
M-22731-3
C-122443-2
D-122633
V-21137
SC-21-14
D-67500-57
WL-6-1
SC-110-44
C-122442-2
D-122635-2
N A M E OF PART
AMT
Tube-Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Cap Screw .318"-16 x 1" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
2
Lock Washer .318'' Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tee .Lower Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Shaft .Lower Wash Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Spacer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Hub . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ball .114" Dia . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 3
uO"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
1
Retainer .Ball . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Wash Arm &Hub Assy . (Incls. items #8, 9.10.11. 1 3 & 14) . . . . . . . . . . . . . . . . . . .
Lock Washer .# 10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
2
Mach . Screw .# 10-24 x 112" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bearing Pin & Washer Assy . : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Pug-RinseArm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Nozzle .Rinse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Arm .Rinse (4 Nozzle Holes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Body .Lower Rinse Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Plate .Pivot Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Mach . Screw .#8-32 x 318" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
"OWRing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Lock Washer .#8 Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4
2
Set Screw .5116"-18 x 318" Soc. Hdls., Cone Pt . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Arm .Rinse (5 Nozzle Holes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lower Rinse Arm Assy . (Incls . items #16 thru 21.23, 24 & 25) . . . . . . . . . . . . . . . . . .
1
.
( M A 1 kl3HSWM 1SnklHl)
LINT\ WtJV HSVM H3ddfl
REPLACEMENT PARTS AM-12
UPPER WASH ARM UNIT
(THRUST WASHER TYPE)
PART
.
NAME OF PART
NO
SC-41-9
WL-6-22
E-118972-2
C-119033
C-119222
B-119227
D-119198
WL-6-7
SC-21-21
C-118978
R-14524
P-103952
.................................
.......................................
.............................................
.........................................
.................................................
............................................
.
.........................
........................................
.................................
.............................................
...........................................
............................................
Cap Screw .5/16"-18 x 112" Hex Hd
Lock Washer .5/16" Light
Ell .Upper Wash
Shaft .Upper Wash Arm
HubAssy
Washer-Thrust
Wash Arm & Hub Assy (Incls . items #5.6. 8 & 9)
Lock Washer .#10 Medium
Mach Screw .#lo-24 x 114" Rd . Hd
Nut -Wash Arm
Core .Rinse Nozzle
Top .Rinse Nozzle
.
AMT
2
2
1
1
1
1
1
2
2
1
1
1
.
AM-12 REPLACEMENT PARTS
UPPER WASH ARM UNIT
(BALL BEARING TYPE)
(WITH STATIONARY RINSE)
ILLUS.
PART
PL-17075-1 NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
SC-41-9
WL-6-22
E-118972-2
C-119033
D-286948
D-67500-19
BA-2-40
C-286947
D-286943
WL-6-7
SC-21-23
C-118978
R-14524
P-103952
NAME OF P A R T
AMT.
2
Cap Screw - 5116"-18 x 112" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Lock Washer - 5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ell - Upper Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
1
Shaft - Upper Wash A r m . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hub . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ball - 1/4" Dia . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 3
Retainer - Ball . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer Arm & Hub Assy. (Incls. itmes # 5 , 6 , 7 , 8 , 1 0 & 11) . . . . . . . . . . . . . . . . . . . .
Lock Washer - #10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach. Screw - # 10-24 x 1/2" Rd. Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nut-WashArm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Core - Rinse Nozzle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Top - Rinse Nozzle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REPLACEMENT PARTS AM-12
-1
@-
2
3
.
UPPER WASH ARM UNIT
(BALL BEARING TYPE)
(WITHROTATING RINSE)
ILLUS.
PART
PL-17106-2NO .
1
2
3
4
5
6
7
8
9
10
11
12
13
1.4
15
16
17
18
19
20
21
SC-41-9
WL-6-22
E-118972-2
B-122437
D-286948
D-67500-19
BA-240
C-286947
D-287987
WL-6-7
SC-21-23
B-122438
D-122401
C-287908
B-122440
SC-11044
B-122632
C-122445
RR-11-3
M-22731-3
C-287913
C-287932-2
NAME O F PART
AMT
Cap Screw .5/16"-18 x 112" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Ell .Upper Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Shaft .Upper Wash Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Hub . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Ball .1/4" Dia . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
1
Retainer .Ball . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer Arm & Hub Assy . (Incls . items # 5 . 6 . 7 . 8 . 1 0 & 11) . . . . . . . . . . . . . . . . . . . . 1
Lock Washer .#10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Mach . Screw .#lo-24 x 112" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Upper Rinse Shaft Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Hub-RinseArm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Arm .Outside Rinse (5 Nozzle Holes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plug .Rinse Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Set Screw .5/16"-18 x 3/8" Soc. Hdls., Cone Pt . "Nylok" . . . . . . . . . . . . . . . . . . . . . 2
Washer -Thrust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
1
Handle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Retaining Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nozzle .Rinse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 1
Arm -Inside Rinse (6 Nozzle Holes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Rinse Arm Assy . (Incls . items #12 thru 21) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
.
REPLACEMENT PARTS AM-12
OUTSIDE RINSE PlPllVG UNIT
PART
NO
.
C-119290
A-119127
SC41-13
WL-6-22
D-67500-12
SC41-16
WS-17-8
SC41-5
WS-3-48
WL-6-17
NS-15-1
D-119292
D-67500-12
P-63262-26
WL-6-22
NS-15-11
A-106468-5
P-86218
C-119066
A-102516
M-82231
A-102517
M-82236
M-82238
D-67500-59
FE-8-10
FE-6-45
D-119004-2
FE-645
FE-76
P-6819068
FE-7-3
FE-8-10
C-277915
NS-15-11
WL-6-22
SC41-15
C-276678
B-277 112
B-118270
C-119291
M-74338
A-104729
*M-74343
B-112062-1
N A M E OF PART
Connector Assy . (Rinse to Vacuum Breaker) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plug .118" Sq . Hd . Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .5116"-18 x 1" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .5/16"-18 x 1-318" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .114"-20 x 518" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Outside Rinse Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flange & Nipple Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .5116"-18 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Solenoid Valve .314" (1 15 V., 50160 Hz.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pet Cock .114" . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Line Strainer (314") (Incls . items #21,22, 23, 24 & 25) . . . . . . . . . . . . . . . . . . . . . .
Screen (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Seal (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clamp (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thumb Screw . . . . . . ' . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0" Ring (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
112" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight (112" Male Thd . x 112" Thinwall) . . . . . . . . . . . . . . . . . . . . . . .
Conduit .112" (Low Water Protection Box t o Coupling) . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight (112" Male Thd . x 112" Thinwall) . . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight "Sealtite" (112" Female Thd . x 318" Flex . Cnd.) . . . . . . . . . . . . . .
Conduit .3/23'' x 25" (Waterproof) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .90' "Sealtite" (112" Male Thd . x 318" Flex . Cnd.) . . . . . . . . . . . . . . . . . .
112" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gauge -Water Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .5/16"-18 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .5116"-18 x 1-114" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector Assy . (Vacuum Breaker t o Solenoid) . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vacuum Breaker .314" (Incls . item #40) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Float Assy . & Bonnet Gasket Service Kit (Vacuum Breaker) . . . . . . . . . . . . . . . . . . . .
Connector Assy. (Vacuum Breaker to Solenoid) . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vacuum Breaker .314" (Incls .item #43) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap .Vacuum Breaker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vacuum Breaker Float & Seal Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coil .Solenoid (1 15 V.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
*Use with SLOAN Vacuum Breaker .
**Use with WATTS Vacuum Breaker
.
AMT
1
1
2
2
1
1
1
2
2
2
2
1
1
1
1
.1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
.
'
S l t l V d lN3VU33Vld3tl ZL-WV
.................................
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PH. .XaH
. . ,,8/S
. x 81-,,91/S - Mal3S d e 3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .lzl211
. . . ,,9T/S
. . . .- .IaqseM
. Z U ! V0-I
~"O,,
...........................................
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Lssv
. . .ropauuo3
. . . .2 u xasu!X
"O,,
.....................................
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Lssv
. . . a. l.u.e .~ .d9.rol3auuo3
. . . .~u!ZIasu!x
"O,,
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . l9%!1,,9 I/S - IazlseM
Wo?
................................
- Mal3S - d e 3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. PH
. . .XaH
. . .,,8/S
. . .x.81-,,9I/S
a1zzoN a s u x - do^
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . aIzzoN
a s y - aro3
.................................
- Ma13S d e 3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PH
. . XaH
. . ,,8/S x 81-,,9T/S
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . l@!?
. . . .,,9T/S
. . . -. WseM
. .% u xV o ?
.......................................
lzl8!1,,9 T /S - ra9seM Wo'I
......................................
81-,,9T/S - JnN Ttnd
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .u!d XaH
asurx raddn - j ~ o d d n s
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .ad!d Lssv
ad!d a s 4 8 ~ a d d n
......................................
mn!paK
O T # - IaqseM ~ 3 0 1
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PH 'PZI ,,8/£
x PZ-OT# - Mal3S 'Y3eH
"0.9
'
I H V d dO 3WVN
01-IV3S
OZ
ZZ-9-?M
67
6-OOSL9-a
81
7-S6681T-3
LT
ZT-OOSL9-a
91
PE89LZ-a
ST
6-OOSL9-a
PT
ZZ-9-TM
ET
01-TV3S
ZT
ZS6EOT-d
11
PZSPT-ZI
OT
OPTV3S
6
ZZ-9-TM
8
ZT-OOSL9-a
L
ZZ-9-?M
9
IT-ST-SN
S
OLO6IT-3
P
P668IT-'3
E
L-9-TM
Z
ZZ-12-3s
T
'ON 1 - 9 L O L L - ld
I H V ~ srni I
ZL-INV SlHVd .LN3VU33Vld3H
REPLACEMENT PARTS AM-12
INSIDE RllUSE PIPING U N I T
(LOW WATER CONSUMPTION)
ILLUS.
PART
PL-17807-1 NO.
1
2
3
4
5
6
7
8
9
10
11
D-67500-12
WL-6-22
SC-41-10
D-287947
SC-41-9
WL-6-22
D-67500-9
D-276834
D-67500-9
WL-6-22
SC-41-9
NAME OF PART
AMT.
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lockwasher-5/16"Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw - 5116"-18 x 518" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Upper Rinse Pipe Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw - 5/16"-18 x 112" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer - 5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rinse Connector & Flange Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer - 5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw - 5/16"-18 x 112" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
1
2
2
1
2
2
1
1
1
2
2
REPLACEMENT PARTS AM-12
DOOR INTERLOCK UNIT
PART
NO
.
13-119062
VJL-6-17
NS-15-1
FE-8-10
FE-6-45
D-119004-1
B-119065-1
FE-6-45
FE-7-6
P-68190-5
FE-7-1
WL-6-7
WS-19-6
SC-21-34
D-288490
SC-2 1-25
B-288455
WS-29-10
WL-6-7
NS-11-18
B-106803
B-288456
SD-25-12
B-119075
C-119057
B-119300
SD-12-35
N A M E OF PART
Retainer .Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114'' Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
112" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight (112" Male Thd . x 1/2" Thinwall) . . . . . . . . . . . . . . . . . . . . . . .
Conduit .112" Thinwall (Heat Box to Coupling) . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight (112" Male Thd . x 112" Thinwall) . . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight "Sealtite" (112" Male Thd . x 318'' Flex . Cnd.) . . . . . . . . . . . . . . . .
Conduit .318" x 11" (N"v'terproof) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .Straight "Sealtite" (112'' Male Thd . x 318'' Flex . Cnd.) . . . . . . . . . . . . . . . .
Lock Washer .#10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#lo-32 x 1-314" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Housing .Interlock Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .# 10-24 x 314" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spacer & Insert Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .# 10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Nut .#lo-24 Hex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket .Interlock Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interlock Switch & Cover Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#8-18 x 112" Phil . Pan Hd . "Shakeproof" . . . . . . . . . . . . . . . . . .
Retainer .Magnet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Magnet -Door Interlock Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket .Magnet Retainer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#8-32 x 1/2" Phil . Pan Hd., Type 23 . . . . . . . . . . . . . . . . . . . . .
AMT
1
1
1
1
1
1
1
1
1
1
1
2
2
2
1
2
1
2
2
2
1
1
2
1
1
1
2
.
AM-12 REPLACEMENT PARTS
DOOR UNIT
(STRAIGHT T H R U INSTALLATION)
PART
NO.
E-119006-2
B-119103
PC-5-2
C-119236
D-112378-23
E-119006-1
D-119133
NS-18-6
WS-17-8
C-119168
SC-21-23
WL-6 -7
C-119086
B-119007
NAME OF PART
AMT
Door - Counterbalanced (L.H.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rivet - Flat Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cotter Pin - 1/16" x 112" . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Latch - Inspection Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Guide-Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door - Counterbalanced (R.H.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door & Lift Assy. (NonCounterbalanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jam Nut -5116"-18 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket - Door Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach. Screw - #lo-24 x 1/2" Rd. Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer - # I 0 Medium. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bumper -Door Stop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Stop Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
1
1
1
1
6
1
1
2
2
1
2
2
2
2
REPLACEMENT PARTS AM-12
DOOR URllT
(CORNER INSTALLATION)
ILLUS.
PART
PL-14405 NO.
1
2
3
4
5
6
7
8
E-119005
E-119098
E-119006-1
D-112378-23
SC-21-23
WL-6-7
C-119086
B-119007
NAME O F PART
AMT.
. .. .. ... . . .
. . . . . . . . .. .... . . . . . . .. ..
..
. . .. . . . . . . . . . . . . . . . . . . ..
... .. ......
. . . . . . . . . . .. . . .. . .
...............................................
. . . . .. ..... ... . .... ........
. . . . . . . . . . . . . . . .. . . . . . . . . . .. . .
.. .
. . . . . . .. . . . ....... ........
... . ... . . .... ....
. . . . . .. . . .. . . . .. . . .. ..
Door - Inspection. . . . .
.
. ...
Door - Counterbalanced (Front) .
... ..
.. ..
. .
..... .
Door - Counterbalanced (R.H.)
Guide-Door
.. .
.. .
Mach. Screw - #lo-24 x 112" Rd. Hd
Lock Washer - #10 Medium
. ... . .
.
..
. . .. . . .. . . .
.
Bumper - Door Stop . .
.
....
. .
Door Stop Assy
1
1
1
6
2
2
2
2
AM-12 REPLACEMENT PARTS
DOOR LIFT UNIT
(STRAIGHT THRU INSTALLATION)
PART
NO
.
NS-15-11
C-119071
D-119079-1
P-79008
B-119055
E-119016
NS-15-11
WL-6-22
SC-53-16
B-11905 3
B-119017
B-119104
NS-32-35
M-74068
B-119011
WL-6-22
NS-25-9
B-119012
B-119076
N A M E O F PART
......................................
...............................................
.........................................
..............................................
........................................
......................................
.......................................
...............................
............................................
.......................................
.........................................
.....................................
............................................
................................................
.......................................
..........................................
...............................................
...............................................
Full Nut .5116"-18 Hex Fin
Hook-Spring
Spring .Counterbalance
Hanger .Spring
Button .Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Lift Assy
Full Nut .5116"-18 Hex Fin
Lock Washer .5/16" Light
Mach Screw .5116"-18 x 518" Truss Hd
Gasket .Door Lift
Bearing Bracket & Pin Assy
Bushing .Door Lift Pin
Stop Nut .5116"-18 "Flexloc"
Spacer .Door Link
Link-Door
Lock Washer .5/16" Light
Acorn Nut -5116"-18
Spacer .Door
Plug-Handle
.
AMT
2
1
1
1
2
1
4
4
4
2
2
2
2
2
2
2
2
2
2
.
REPLACEMENT PARTS AM-12
DOOR LIFT UNIT
(CORNER INSTALLATION)
PART
NO
.
B-119076
B-119046
WS-5-32
NS-25-9
WL-6-22
B-119042
B-119048
NS-32-35
NS-15-11
C-119071
D-119079-2
B-119072
WS-17-8
PC-5-11
SC-53-16
B-119272
WS-17-8
WL-6-22
NS-15-11
M-74532
WS-1042
E-119095
NAME OF PART
AMT
...............................................
...................................................
..........................................
.......................................
.......................... ..................
............................................
.....................................
......................................
..........................................
.........................................
...........................................
...................................................
........................................
...............................
.
.................................................
...................................................
.......................................
......................................
..................................................
...................................................
..............................................
Plug-Handle
2
Pin -Door Lift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Washer
2
Acorn Nut .5116"-18
2
Lock Washer .5/16" Light
2
Link -Door Lift
;
2
Spacer .Door Link
2
Stop Nut .5116"-18 "Flexloc"
2
Full Nut .5116"-18 Hex Fin
2
Hook .Spring (Lower)
1
Spring .Counterbalance
1
Hook .Spring (Upper)
1
Washer
1
Cotter Pin .3/32" x 314"
1
Mach Screw .5116"-18 x 518" Truss Hd
8
Pivot Assy
2
Washer
8
Lock Washer .5/16" Light
8
Full Nut .5116"-18 Hex Fin
8
2
Bushing
Washer
AR
Door Lift Assy
1
.
REPLACEMENT PARTS AM-12
STRAINERS AND DRAIN URIIT
I LLUS.
PART
PL-I6170 NO
1
2
3
4
5
6
7
8
9
10
!1
12
13
14
15
.
D-118964
C-118967
D-118999
D-119035
SC-41-11
WL-6-22
WS-17-8
FP-28-32
D-118976
C-119239
D-67500-82
D-67500-89
E-119099-1
C-277025
NS-18-1
WL-6-17
C-119119
NS-15-1
WL-6-17
NAME OF PART
AMT
.........................................
.............................................
...........................................
...........................................
Sump Cover & Retainer
Strainer .Slanted
Strainer Basket Assy
Overflow Cover Assy
Cap Screw .5116"-18 x 314" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Washer
Plug .2" Sq Hd . Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Body-Drainvalve
Sleeve .Drain Valve Body
"OnRing
"0" Ring (Overflow Tube)
Tube .Overflow
Overflow Guide Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jam Nut .114"-20 Hex Fin
Lock Washer .114" Medium
Rod .Overflow Lift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .114"-20 Hex Fin
Lock Washer .114" Medium
Axle .Drain Lever
Drain Lever Assy
Washer
Lock Washer .#10 Medium
Mac11 Screw .#lo-24 x 318" Rd . Hd
.
...................................................
.
............................................
........................................
.................................................
.......................................
........................................
.......................................
......................................
.......................................
......................................
............................................
.............................................
..................................................
.......................................
.................................
1
1
1
1
8
8
8
1
1
1
1
1
1
1
2
2
1
1
1
1
1
1
1
1
.
REPLACEMENT PARTS AM-12
TRACK UNIT
ILLUS.
PART
PL-14071 NO.
*1
*2
*3
*4
*5
*6
*7
**8
S-74528
E-119093
NS-36-5
SC-22-27
D-119129
S-74527
E-119080
E-119084
N A M E O F PART
............................................
............................................
......................................
.................................
.............................................
............................................
...............................................
AMT.
Track R.H. Rack
Track -Front Rack
Stop Nut - #12-24 "Elastic"
Mach. Screw - #12-24 x 518" Flat Hd
Support - Track.
Track - L.H. Rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Track - Rear Rack
Track-Rack
*Corner Installation.
**Straight Thru Installation.
1
1
6
6
1
1
1
2
- PP-
S l t l V d l M 3 V U 3 3 V l d 3 t l ZL-VUV
REPLACEMENT PARTS AM-12
MISCELLANEOUS
PART
NO
.
.
iiij
<:<
=
k.
'
E-119183
B-119244
D-67500-31
B-119254
WL-6-17
NS-15-1
A-119237
SC-53-20
B-119047
C-119083
WL-6-22
NS-15-11
C-119081
C-119082
A-119043
WL-6-7
NS-11-18
A-107218
A-103746
C-119139
C-119137
C-286684
M-74348
SC-53-2
D-119041
C-119039
C-286687
D-276923-5
D-276923-6
B-288059
B-288174
D-288192
WLd-17
NS-15-1
N A M E OF P A R T
Panel .Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap & Stud Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0"Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Retainer .Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting Foot Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .5116"-18 x 1" Truss Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spacer .Tank & Chamber . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Insert .Tank Corner (R.H. Rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .5116"-18 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Insert .Tank Corner (Front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Insert .Tank Corner (L.H. Rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Guard Capillary Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Nut .#lo-24 Hex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coupling .Thermometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nut (Capillary Retainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Retainer .Cap . Tube (L.H.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Retainer .Cap . Tube (R.H.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ring -Wash Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Speed Nut .#lo-24 Type "U" . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#lo-24 x 112" Truss Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Housing .Thermometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermometer Panel Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ring .Rinse Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermometer .3 F t . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermometer .8 F t . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Baffle-Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bumper .Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Deflector -Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AMT
1
3
3
3
3
3
4
6
6
1
6
6
2
1
4
4
4
1
2
2
2
1
3
3
1
1
1
1
1
1
1
1
2
2
REPLACEMENT PARTS AM-12
LOW WATER PROTECTION UNIT
.
PART
I LLUS
PL-17844 NO
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
.
SD-12-20
C-288466-2
C-112005
NS-15-1
WL-6-17
NS-18-28
WL-14-31
B-111944
D-288468-2
D-288485-1
D-288468-1
B-119294
B-113420
A-112146
D-67500-72
B-119270
C-112467
RR-10-13
C-122674
B-119271
NAME OF PART
AMT
.
....................
.
...............................................
......................................
.......................................
..................................
..............................................
6
Self-Tapping Screw .#8-32 x 112" Phil Truss Hd.. Type 23
Lid & Gasket Assy . (Incls item #3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Gasket (Lid)
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
4
Lock Washer .114" Medium
1
Jam Nut .112"-20 Hex Fin
1
Lock Washer .112" Ext . Shakeproof
1
Washer-Thrust
Heat Box (Use with Steam & Gas Heat) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Heat Box (Use with Elec. Heat) (110-120 V.) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heat Box (Use with Elec Heat) (200 V & Above)
;
1
2
Clamp .Cable (Tie)
4
Terminal -Male (Double) (200 V & Above) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Retainer -Terminal (200 V & Above) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1
"0"Ring
Probe & Switch Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1
Retainer .Float
1
RetainingRing
1
FloatAssy
Kit .Low Water Protection (Incls items #6,7, 8 , 1 5 , 1 6 , 1 7 , 18 & 19) . . . . . . . . . . . . . . AR
.
.
......... ................
...........................................
.
.
.................................................
..............................................
..............................................
.................................................
.
.
REPLACEMENT PARTS AM-12
ELECTRIC HEAT
.
ILLUS
PART
PL-17863 NO
rig
.
k
1
*2
*3
*4
*5
*6
*7
*8
**9
**lo
"*I1
""12
**13
**I4
**I5
2:*16
17
18
19
20
21
22
23
24
25
.
M-77612
FE-6-9
FE-8-11
FE-6-6
FE-5-84
C-119240
SC-21-37
WL-6-16
FE-6-6
WS-13-45
B-122909
C-119308
WS-13-45
FE-6-27
NS-15-1
WL-6-16
NS-15-13
WL-6-27
P-86444
NS-9-30
WL-14-7
B-119274
B-119275
B-119276
B-277983-1
NAME OF PART
AMT
Lug .Solderless . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Bushing .314" Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
314" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Lock Nut .314" Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
Conduit .314" x 2-13/16" Lg . (R.T.F.L.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Junction Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Mach . Screw .114"-20 x 318" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Lock Washer .114" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Lock Nut .314" Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Gasket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Box -Junction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Nipple - 314" Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
2
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Full Nut - 318"-16 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Lock Washer .318" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Insulator -Terminal (Above 250 V.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Mach .Nut .#lo-32 Hex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AR
Lock Washer .#10 Ext . Shakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AR
Strap -Jumper (Short) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AR
Strap -Jumper (Long) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AR
Gasket - Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Heater -Electric (100-120 V., 60 Hz., 1 Ph . 115 V., 50 Hz., 1 Ph.) (Incls .items #20, 22, 23
&24) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
Heater -Electric (200-230 V., 60 Hz., 1 & 3 Ph., W/Pilot Circuit; 220 V., 50 Hz., 1 & 3 Ph.,
W/Pilot Circuit) (Incls. items #20,22, 23 & 24) . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Heater -Electric (380 V., 50 Hz., 3 Ph.) (Incls. items #20, 22, 23 & 24) . . . . . . . . . . . . .
1
Heater -Electric (400-460 V., 60 Hz., 3 Ph.) (Incls . items #20, 22, 23 & 24) . . . . . . . . . . 1
.
*L.H. Controls .
**R.H.Controls.
(Items #1 thru 16. 115 V.)
.
REPLACEMENT PARTS AM-12
GAS BURRIER UNIT
PART
NO
.
P-23963-11
FP-47-36
FP-24-45
FP-35-46
FP-19-10
FP-35-63
FP-35-60
FP-22-6
FP-35 -6 1
C-277809
WL-6-6
SC-21-22
B-277872
FP-35-46
FP-35-62
FP-11-15
FP-35-46
FP-22-6
C-119301
IVL-6-17
NS-15-1
C-119278
SC-41-10
FP-35-65
FP-13-11
NS-15-11
WL-6-23
FP-35-49
C-121025
SC-21-44
WL-6-17
A-119151
B-119171
SD-8-18
E-119146
A-105763-1
A-105763-4
D-105 172-1
D-105172-2
D-119296
B-105045-1
B-105045-2
SC-21-80
WL-6-7
SC-21-80
WL-6-7
C-119295
C-119284
WL-6-1
SC-21-91
SC-21-23
WL-6-7
WL-6-17
NS-15-1
WS-19-6
N A M E O F PART
AMT
..........................................
..............................
...................................
.
.................................................
...................................
...................................
.
.........................................
...................................
.
....................................
........................................
.................................
......................................
.........................
.
.............................
....................................
.....................................
.
.
......................................
.......................................
..............................................
.................................
...................................
.
............................................
......................................
.
...............................
.
..............................................
. .
.......................
...........................................
.................................
.......................................
......................
. .
.
............................
..............................................
.
...........................
..............................................
.................................
.......................................
.................................
Tube .114" O.D. Gas
Elbow .90' (118" Male Pipe x 1/4" Tube)
Coupling .318" to 118" Reducing
Nipple .318" x 1" Lg (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tee-318"
Nipple .318" x 4-112" Lg . (T.B.E.)
Nipple .318" x 3-114" Lg (T.B.E.)
Union .318" (Grd . Seat)
Nipple .318" x 3-112" Lg (T.B.E.)
Bracket .Control Box Mounting
Lock Washer .#10 Light
Mach Screw .$10-24 x 318" Rd . Hd
Valve .Gas (120 V.. 60 Hz.)
Nipple .318" x 1" Lg . (T.B.E.) (Nat or Mixed Gas)
Nipple .318" x 4-118" Lg . (T.B.E.) (L.P. Gas)
Gas Cock .318" (Lever Handle)
Nipple .318" x 1" Lg (T.B.E.)
Union .318" (Grd Seat) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Pipe Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Medium
Full Nut .114"-20 Hex Fin
Support -Pipe
Cap Screw .5116"-18 x 518" Hex Hd
Nipple .318" x 5-118" Lg (T.B.E.)
Elbow .318" x 90'
Full Nut .5116"-18 ex Fin
Lock Washer .5/16" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .318" x 1-112" Lg . (T.B.E.) (Nat or Nixed Gas) . . . . . . . . . . . . . . . . . . . . . . .
Regulator -Pressure (Nat .or Mixed Gas)
Mach Screw .114"-20 x 1-112" Rd .Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ;
Spacer .Burner
Cover .Pilot Hole . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Self-Tapping Screw .#8 x 318" Phil Bind Hd., Type B
Burner Housing Assy
Jet .Gas Burner (Nat . or Mixed Gas)
Jet .Gas Burner (L.P. Gas)
Gas Burner Assy . (Nat . or Mixed Gas) (Incls . item #36)
Gas Burner Assy ( L P Gas) (Incls item #37)
Support .Pilot
Pilot (Nat or Mixed Gas)
;............
Pilot (L.P. Gas)
Mach Screw .#lo-32 x 318" Rd . Hd
Lock Washer - # l o Medium
Mach Screw .#lo-32 x 318" Rd . Hd
Lock Washer .#10 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bracket .Pilot Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrode Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#8 Lisht
Mach . Screw .#8-32 x 5/16" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .#lo-24 x 112" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .# l o Medium
Lock Washer .114" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .114"-20 Hex Fin
IVasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
.
.
.
.........................................
.......................................
.......................................
*R.H. Controls .
""L.H. Controls .
1
1
1
1
1
1
1
1
1
2
4
4
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
8
8
1
1
1
i
1
2
2
2
2
1
1
2
2
2
2
4
4
4
.
REPLACEMENT PARTS AM-12
FLUE AND IGNITER CONTROL UNIT
(GAS HEAT)
PART
NO
.
SD-12-20
C-288466-3
C-112005
D-288469
B-276636
FE-6-5
FE-6-5 1
SC-7-49
D-121028
C-119282
13-121027
WL-3-12
NS-9-12
FE-8-10
FE-7-5
P-7765845
FE-7-7
FE-8-10
B-121040
WL-8-27
FE-8-11
FE-844
P-72654-13
FE-844
NS-15-1
WL-6-17
SC-41-50
D-119090
NS-15-13
WL-6-27
B-119153
B-119152
SC-41-29
NS-15 -1
WL-6-17
NAME OF PART
AMT
Self-Tapping Screw .$8-32 x 112" Phil. Truss Hd.. Type 23 . . . . . . . . . . . . . . . . . . . .
Lid & Gasket Assy . (Incls. item #3) (Use With Gas Heat)
Gasket (Lid) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Box-Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lead Wire Assy . (Grounding) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Nut .112" Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Nut .314" Conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Screw .$8-32 x 1-118" Rd . Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gas Heat Igniter Circuit Assy . (Incls . item # 19) . . . . . . . . . . . . . . . . . . . . . . . . . . .
Insulator (Igniter Circuit) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spacer .Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .#8 Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mach . Nut .#8-32 Hex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
112" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .45O "Sealtite" (112" Male Thd . x 112" Flex . Cnd.) . . . . . . . . . . . . . . . . . .
Conduit .112" x 12" Lg . (Waterproof) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .90° "Sealtite" (112" Male Thd . x 112'' Flex . Cnd.) . . . . . . . . . . . . . . . . . .
112'' Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch .Thermal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .318" Int . Sllakeproof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
314" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .45O (314" Male Thd . x 314" Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . .
Conduit .314'' x 2" (Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .45O (314" Male Thd . x 314" Thinwall) . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .114"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .1/4" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .1/4",- 20 s 112" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FlueAssy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .318"-16 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Brasher .318" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Electric Heater Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket .Cover Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .318"-16 x 718" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .1/4"-20 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .114" Medium . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
......................
6
1
1
1
1
1
1
3
1
1
3
3
3
1
1
1
1
1
1
1
1
1
1
1
2
2
2
1
1
1
1
1
1
2
2
.
REPLACEMENT PARTS AM-12
STEAM IRIJECTOR
.
I LLUS
PART
PL-16175 NO
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
.
FP-13-22
FP-36-92
FP-22-17
FP-36-10
FP-19-79
P-86218
C-277915
FP-36-6
FP-13-22
FP-36-92
A-114683
FP-9-8
P-70149-2
FP-36-92
FP-36-92
IvI-82228
M-82231
M-82234
M-82236
M-82238
D-67500-59
A-108156-3
FP-36-92
FP-13-22
FP-36-92
P-74696
FP-36-92
FP-13-20
FP-36-5
FP-13-22
FP-36-92
FE-7-3
P-68190-38
FE-7-3
FE-8-10
NS-15-13
IVL-6-27
B-119153
B-119152
SC-41-29
P-67039-2
FP-54-30
FP-49 -15
FP-54-44
R-8 306 3
FP-54-35
NS-186
WL-6-22
P-67036
P-67039-2
SC-41-17
B-112066-1
N A M E O F PART
Elbow .314" x 90° . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Union .314" (Grd . Seat) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 4-314" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tee .314" x 1/4" x 314" Reducing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pet Cock .114" (T Handle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gauge -Water Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 3-112" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Elbow .314" x 90° . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318'' Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valve .314" Globe (Incls . item #12) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Disc .314" Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Handle .314" Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-3/8" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Line Strainer .314" (Incls . items #17 thru 21) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Screen (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate -Seal (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clamp (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thumbscrew . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
"0" Ring (314" Line Strainer) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Solenoid Valve -314" (115 V., 50160 Hz.) (Pilot Circuit) . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318'' Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Elbow .314" x 90° . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valve .314" Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Elbow .314" x 45' . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 3" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Elbow.3/4"x90° . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 1-318" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .90' "Sealtite" (112" Male Thd . x 318" Flex . Cnd.) . . . . . . . . . . . . . . . . . .
Conduit .318" x 8-318'' (Waterproof) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector .90' "Sealtite" (112" Male Thd . x 318" Flex . Cnd.) . . . . . . . . . . . . . . . . . .
112" Gasket Assy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Full Nut .318"-16 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .318" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket .Cover Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .318"-16 x 718" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Adapter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 3" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Elbow .314" x 90' . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .314" x 2-112" Lg . (T.B.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater -Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Nipple .1" x 10" Lg . (S.T.O.E.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jam Nut .5116"-18 Hex Fin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lock Washer .5/16" Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket .Adapter Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Plate .Adapter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cap Screw .5116"-18 x 1-112" Hex Hd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coil .Solenoid Valve (1 15 V.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AMT .
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
4
4
1
1
4
1
AM-12 REPLACEMENT PARTS
DISH RACKS
PART
NO.
A-105113
A-105114
NAME OF PART
.................................................
............................... ............
Rack-Peg
Rack -Combination
AMT.
1
1