advertisement
Home Stack
Washer/Dryers
Refer to Page 3 for Model Numbers
SWD456C_806093
www.alliancelaundry.com
Part No. 806093R2
June 2017
Table of Contents
Title Page
© Copyright 2017, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
1
Parts Ordering Information
If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at
(920) 748-3950 for the name and address of the nearest authorized parts distributor.
For technical assistance, call the number listed below:
(920) 748-3121 Ripon, Wisconsin
Serial Plate Location
When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown.
SERIAL PLATE
DRY2283P_806093
2
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Model Identification
Information in this manual is applicable to these dryer models:
ATEE9AGP173TW01
ATGE9AGP113TW01
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
3
Control Cabinet and Controls
SWD1281P_806093
4
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
3
6
7
4
5
10
11
8
9
12
PART NO.
805219P
804667
503688
804018
804363
70240301
803998
70030501
804112W
514567P
803960WP
804491
DESCRIPTION
Control Assembly
Screw
Screw
Shield Bracket
Control Shield
Screw
Rear Access Panel
Expansion Clip
Wrapper Assembly
Control
Control Panel
Control Overlay
COMMENTS
Washer
Dryer
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
5
Front Panel, Door Assembly and Door Seal
6
FLW1811P_806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Front Panel, Door Assembly and Door Seal
803920
802283
802281
804428P
804429P
802285
802206
802277WP
503661
36020
801045
514250WP
804083WP
806505W
802803
801993
801019
802934
23951
802700
56079
39733
PART NO.
803710WP
800548
804239
802695P
685846
802307P
804562
22
23
24
25
26
27
18
19
20
21
15
16
17
18
11
12
13
14
9
10
7
8
REF
1
2
3
6
6
4
5
DESCRIPTION
Outer Door Bezel
Screw
Door Glass Mounting Plate
Door Glass
Nut
Inner Door Bezel Kit
Inner Door Bezel
Door Catch Assembly
Screw
Screw
Door Hinge
Nut
Glass Mounting Clip
Panel Locator
Screw
Door Latch Assembly
Wire Clamp Ring
Hose Clamp
Door Seal
Door Seal Assembly
Extension Spring
Hinge Plate
Front Panel
Screw
Nut
Screw
Access Panel Assembly
Door Assembly
Front Panel Assembly Kit
COMMENTS
White
Glass-filled polypropylene upgrade
7 required
Seal to outer tub front
Black
Gray
White; Includes items 1-12
Includes items 1-14, 20 and 21
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
7
Dispenser Assembly
FLW1717P_806093
8
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
COMMENTS REF
NA
1
2
5
6
3
4
9
10
7
8
11
PART NO.
804875
803843
801001
804173
803849
803698
804717
685725
803667
800548
804227WP
803669
DESCRIPTION
Foam Pad
Dispenser Plate
Screw
Hose Clamp
Dispenser Inlet Hose
Dispenser Assembly
Detergent Hose
Hose Clamp
Dispenser Drawer
Screw
Dispenser Handle
Compartment Cover
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
9
Mixing Valve, Fill Hose and Valve-to-Dispenser Hose
FLW1734P_806093
10
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Mixing Valve, Fill Hose and Valve-to-Dispenser Hose
REF
1
2
3
6
7
4
5
7
PART NO.
804173
803849
803809
24122
20290
F200116
803615
802254
DESCRIPTION
Hose Clamp
Dispenser Inlet Hose
Mixing Valve
Mixing Valve Screen
Washer
Water Hose
Washer
Washer
COMMENTS
6 required
Includes items 5 and 7
Filter screen
Flow restrictor; Water pressure reducer; Available for water pressure up to but not exceeding 120 psi
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
11
Outer Tub, Front and Clamp Ring
12
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
FLW1809P_806093
806093
803810
803770
806308
806313
806361
803801
803802
F430218
M400081
800462
802596
804467
805548
803879
802343
500049
29175
803837
36985
804483
803891
803864
803777
PART NO.
803415
800461
804458
804457
800452
685847
800553
25
26
27
22
23
24
25
18
19
20
21
16
17
18
18
12
13
14
15
10
11
8
9
REF
1
2
3
6
7
4
5
Outer Tub, Front and Clamp Ring
COMMENTS DESCRIPTION
Out-of-Balance Switch Assembly
Screw
Washer
Out-of-Balance Switch Bracket
Nut
Pop Rivet
Hose Clip
Warning Label
Grommet
Pressure Bulb
Hose Clip
Pressure Sensor Tube Assembly
Hose Clamp
Outer Tub Assembly
Shock Assembly
Counterweight
Tub Front
Foreign Object Deflector
Foreign Object Deflector
Foreign Object Deflector
Tub Front Seal
Clamp Ring
Nut
Washer
Screw
Screw
Clothes Guard Deflector
Clothes Guard Deflector
Tub Front Assembly
Nut
Must replace all four
Black; Includes screws
Gray; Includes screws
Tall; Gray; Includes screws
Heavy duty
Includes items 17, 24, 25 and 27
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
13
Inner Basket, Trunnion, Bearing Housing and Pulley
FLW1803P_806093
14
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
PART NO.
27604P
804418
804393
804382
804376P
804374P
804699
804405P
804399
800548
803974
800464
685831
M403958
M400043
800457
805525
800452
11
12
13
14
9
10
7
8
REF
NA
1
2
5
6
3
4
15
16
17
Inner Basket, Trunnion, Bearing Housing and Pulley
DESCRIPTION
Anti-Seize Compound
Nut
Balance Ring Assembly
Lifter
Inner Basket Assembly Kit
Inner Basket Assembly
Screw
Trunnion Shaft Kit
Screw
Screw
Pulley Assembly
Washer
Screw
Washer
Screw
Washer
Bearing Housing Kit
Nut
COMMENTS
Pulley to inner basket shaft
Includes items 1-3 and 5-9
Includes hardware and tool
Left hand thread
Used on models through Serial No. 1609046804
Includes hardware and tool
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
15
Motor and Belt
FLW1735P_806093
16
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
3
6
7
4
5
8
9
10
PART NO.
503661
803949P
804878
501524
M400057
02834
M400080
804985
805726P
803861
COMMENTS DESCRIPTION
Screw
Inverter Control Assembly
Motor Control Shield
Screw
Screw
Washer
Washer
Drive Belt
Motor and Rod Assembly Kit
Motor Rod
Includes item 10
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
17
Drain Hose and Pump
18
FLW1719P_806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
PART NO.
33615
33489
36014
803976
32219
38732
F200204
503661
803814
802431
802429P
803815
803921P
802434P
802428
802427
802426P
803829
27615P
12
13
14
15
10
11
8
9
16
17
18
18
REF
1
2
3
6
7
4
5
COMMENTS DESCRIPTION
Drain Hose Sleeve
Standpipe Strap
Retainer Clip
Drain Hose
Strain Relief
Hose Stand
Hose Clamp
Screw
Drain Base Bracket
Screw
O-Ring
Drain Pump Isolator
Drain Pump Assembly
Pump Housing Assembly
Pump Housing
Gasket
Lid Assembly
Tub-to-Pump Hose
Sealant
Includes items 8-12 and 14-17
Includes items 15-17
Includes filter
Tub-to-pump hose to outer tub
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
19
Base, Side Panels and Rear Panel
FLW1721P_806093
20
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
14
15
15
16
17
18
Base, Side Panels and Rear Panel
11
12
13
9
10
7
8
REF
NA
1
2
5
6
3
4
PART NO.
122P4P
36226
56079
39733
800004WP
503661
803790
803789
803859
803851
803828
806492
34319
501855
DESCRIPTION
Porcelain Touch-Up Paint
Bumper Pad
Panel Locator
Screw
Cabinet Panel Kit
Screw
Rear Panel
Rear Panel
Shipping Plug
Shipping Plate
Drain Hose Bracket
Side Panel Kit
Leveling Leg
Rubber Foot
COMMENTS
White
Left; White; Includes corner gusset with hardware
Fixed
Removable
Right; White
Use to prevent movement on smooth surface floor coverings; Install over two existing front rubber feet (item
14)
34318
155P3
802844P
21899
803876
202470
Rubber Foot
Anchor
Anchor Floor Mount Assembly
Nut
Base Assembly
Pressure Sensor
Includes 4 rubber discs with adhesive backing
Includes 2 rubber discs with adhesive backing
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
21
Special Tools
FLW1733P_806093
22
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
PART NO.
802336
392P4
DESCRIPTION
Pulley Bolt Tightening Fixture
Wrench
COMMENTS
Use to install inner basket
Use for adjusting leveling leg nuts
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
23
Washer Lead-In Cord, Wire Ties and Harness Clips
FLW823P_806093
24
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Washer Lead-In Cord, Wire Ties and Harness Clips
COMMENTS REF
1
2
3
6
7
4
5
8
9
10
PART NO.
38663
55881
36985
504034
687500
03673
03815
20530
38384
202777
DESCRIPTION
Wire Tie
Harness Strap
Hose Clip
Wire Clip
Wire Clip
Nut
Washer
Screw
Strain Relief
Lead-In Cord
Small
Large
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
25
Dryer Loading Door
DRY2296P_806093
26
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
14
15
15
16
9
10
11
12
13
17
17
18
6
7
8
8
9
REF
1
PART NO.
514114W
1
4
5
2
3
6
510082WP
510129
503982P
510127
510181
500226
515597
510147P
503870LG
503870W
510098LG
510098W
505870
505295
511036
513958
44071201
513960W
503981W
513910
510103WP
515950P
511636WP
DESCRIPTION
Dryer Door Assembly
Dryer Door
Door Handle Wedge
Dryer Door Window
Door Strike Mount
Door Strike
Screw
Screw
Liner Door Seal
Door Liner Grill
Door Liner Grill
Liner and Seal Assembly
Liner and Seal Assembly
Screw
Screw
Hinge
Window Clip
Nut
Window Trim
Window Trim
Glass Door Window
Door Pull and Wedge Kit
Door Pull and Wedge Kit
Door and Liner Assembly
COMMENTS
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Model ATGE9AGP113TW01 through Serial No.
1606000838
Model ATGE9AGP113TW01 through Serial No.
1606000838
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Model ATGE9AGP113TW01 through Serial No.
1606000838
Includes item 7; Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Includes item 7; Model ATGE9AGP113TW01 through
Serial No. 1606000838
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Model ATGE9AGP113TW01 through Serial No.
1606000838
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
Includes item 2; Model ATGE9AGP113TW01 through
Serial No. 1606000838
Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
White; Includes items 1-10, 15 and 17; Model
ATGE9AGP113TW01 through Serial No. 1606000838
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
27
Access Panel, Front Panel and Seal
DRY1785P_806093
28
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Access Panel, Front Panel and Seal
COMMENTS
9
10
11
12
13
REF
1
2
3
6
7
4
5
8
9
PART NO.
39733
56079
28835
512973
511056
510066WP
503688
33562
514252W
514250WP
510177
510186
500281
513781WP
DESCRIPTION
Screw
Panel Locator
Speed Clip
Switch
Front Panel Seal
Front Panel
Screw
Screw
Access Panel and Guard Assembly
Access Panel Assembly
Door Catch Assembly
Hinge Hole Plug
Warning/Caution Label
Front Panel Assembly
White; Model ATEE9AGP173TW01; Model
ATGE9AGP113TW01 starting Serial No. 1606000839
White; Model ATGE9AGP113TW01 through Serial No.
1606000838
Includes items 1-6, 10, 11, 511636WP Door Assembly,
(2) 511036 Hinge and (8) 500226 Screw
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
29
Motor, Exhaust Fan and Belt
SWD1227P_806093
30
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
17
18
19
20
13
14
15
16
21
22
23
9
10
11
12
7
8
5
6
REF
NA
1
2
3
3
PART NO.
27604P
510238P
31260
511969WP
511969LG
DESCRIPTION
Anti-Seize Compound
Blower Housing Seal
Screw
Blower Housing
Blower Housing
4
511629P
Motor and Pulley Assembly
COMMENTS
Apply to motor shaft when installing blower fan assembly
Includes items 1 and 2; Model ATGE9AGP113TW01 through Serial No. 1606000838
Includes items 1 and 2; Model ATEE9AGP173TW01;
Model ATGE9AGP113TW01 starting Serial No.
1606000839
120 Volt/60 Hertz; Includes items 5, 7 and 8; Apply anti-seize compound to motor shaft when installing blower fan assembly
510180
511255P
500011
590P3
503688
510139P
510185
56156
510133
56461P
52549
510142P
23748
500824
510158
52566
510060
510523
502535
Motor Mount Clamp
Cylinder Belt
Motor Pulley
Motor Hub Ring Kit
Screw
Blower Fan Assembly
Idler Spring
Nut
Idler Lever
Shaft
Washer
Idler Wheel and Bearing Assembly
Retaining Ring
Screw
Idler Lever and Wheel Assembly
Nut
Motor Mount
Thermistor Assembly
Screw
60 Hertz
Includes items 12-17
Black
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
31
Front Bulkhead, Air Duct, Felt Seal and Cylinder
32
DRY2317P_806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Front Bulkhead, Air Duct, Felt Seal and Cylinder
9
10
7
8
11
11
12
12
13
13
18
19
20
21
14
15
16
17
22
23
23
REF
1
1
4
4
2
3
4
5
6
6
6
PART NO.
513641
513640W
DESCRIPTION
Front Bulkhead
Front Bulkhead
COMMENTS
Galvanized
White; If black marks appear on clothes, replace front bulkhead with this part, cylinder with 510159WP Cylinder Assembly and rear bulkhead with 510905WP Rear Bulkhead Assembly
513738
513737
510207P
511637P
510102W
510265WP
510159WP
Moisture Sensor Base
Bar Sensor
Cylinder Seal Assembly
Adhesive
RB170001 Seal Kit
Cylinder Baffle
510265LGP Cylinder Assembly
Cylinder Assembly
Cylinder Assembly
2 required
Apply to cylinder seal
Includes 2 cylinder seals, 510238P Blower Housing Seal and 511637P
Adhesive
3 required
Model ATEE9AGP173TW01; Model ATGE9AGP113TW01 starting
Serial No. 1606000839
Includes item 3; Model ATGE9AGP113TW01 through Serial No.
1606000838
White; If black marks appear on clothes, replace cylinder with this part, front bulkhead with 505899WP Front Bulkhead Assembly and rear bulkhead with 510905WP Rear Bulkhead Assembly
62588
512082P
503688
501285
Screw
Drying Rack
Screw
Screw
510151W Air Duct Assembly
510151LG Air Duct Assembly
503980W
503980LG
Lint Filter
Lint Filter
Model ATGE9AGP113TW01 through Serial No. 1606000838
Model ATEE9AGP173TW01; Model ATGE9AGP113TW01 starting
Serial No. 1606000839
Model ATGE9AGP113TW01 through Serial No. 1606000838
Light gray; Model ATEE9AGP173TW01; Model ATGE9AGP113TW01 starting Serial No. 1606000839
510502W
510502LG
Lint Filter Cover
Lint Filter Cover
510189
513710
Felt Pad
Cylinder Glide
RB170003 Glide Kit
512106 Cylinder Light Lens
60954
512108
500227
501086
Drum Light Lamp
Light Housing Assembly
Screw
Screw
Model ATGE9AGP113TW01 through Serial No. 1606000838
Model ATEE9AGP173TW01; Model ATGE9AGP113TW01 starting
Serial No. 1606000839
2 required
2 required
Includes items 14 and 15
120 Volt; Includes item 18
510145
515533
515544W
Cylinder Glide Bracket 2 required
Front Bulkhead Assembly Galvanized; Includes items 1-4, 14-20 and 22
Bulkhead Assembly White; Includes items 1-4, 9, 14, 15, 17, 19, 20 and 22; If black marks appear on clothes, replace front bulkhead assembly with 510159WP
Cylinder Assembly, and rear bulkhead with 510905WP Rear Bulkhead
Assembly
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
33
Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block
DRY1787P_806093
34
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
10
11
8
9
6
7
4
5
12
13
14
15
Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block
COMMENTS REF
1
1
1
PART NO.
510207P
511637P
RB170001
2
3
3
503688
511082P
510905WP
DESCRIPTION
Cylinder Seal Assembly
Adhesive
Seal Kit
Screw
Rear Bulkhead Assembly
Rear Bulkhead Assembly
Apply to cylinder seal
Includes 2 cylinder seals, 510238P Blower Housing Seal and 511637P Adhesive
Includes item 1
White; Includes item 1; If black marks appear on clothes, replace rear bulkhead with this part, cylinder with
510159WP Cylinder Assembly and front bulkhead with
505899WP Bulkhead Assembly
Electric models
Electric models
Includes 3 of item 7; Electric models
501285
510237
510190P
61199
510100
510708P
23748
52549
504082
56461P
RB170002
56156
Screw
Terminal Block Shield
Terminal Block Assembly
Screw
Cylinder Roller Bracket
Cylinder Roller
Retaining Ring
Washer
Washer
Shaft
Roller Kit
Nut
Includes 2 each of items 9-13
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
35
Heater Duct and Element Assembly
Electric Models
36
DRY1789P_806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
9
10
10
7
8
5
6
REF
1
2
3
4
PART NO.
503688
500820
510025P
510528
510527
511412
23222
510701
510329P
61927
964P3
Heater Duct and Element Assembly
COMMENTS DESCRIPTION
Screw
Outlet Cover
Heater Duct and Screw Assembly
Wire Assembly
Wire Assembly
Thermal Fuse Assembly
Screw
Limit Thermostat
Heater Assembly
Heater Kit Assembly
Heater Kit
Includes items 1 and 2
Orange; Thermostat jumper; Attaches to heater assembly
Black; Fuse jumper; Attaches to heater assembly
5.35 kW; 240 Volt
5 kW; 240 Volt/60 Hertz; Includes items 4-9
5.35 kW; 240 Volt; Includes items 4-9
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
37
Heater Duct Assembly
Gas Models
38
DRY2145P_806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
3
6
7
4
5
PART NO.
503688
510101
500820
510025P
510131
51782
510702
COMMENTS DESCRIPTION
Screw
Heat Duct Shroud
Outlet Cover
Heater Duct and Screw Assembly
Combustion Duct
Screw
Limit Thermostat
Includes items 1 and 3
Black; Auto reset
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
39
Gas Valve, Igniter and Gas Conversion Kits
Gas Models
40
DRY2379P_806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
9
10
11
12
13
14
15
REF
1
2
3
6
7
4
5
8
PART NO.
510204
51782
510184P
23222
510213
503688
510149P
649P3
650P3
58804B
510506P
56124
510128
58804A
513072
Gas Valve, Igniter and Gas Conversion Kits
COMMENTS DESCRIPTION
Lead-In Pipe Assembly
Screw
Igniter and Bracket Assembly
Screw
Sensor
Screw
Burner Assembly
L.P. Conversion Kit
N.G. Conversion Kit
Secondary Coil
Gas Valve Assembly
Screw
Gas Valve Mounting Bracket
Booster and Holding Coil
Elbow
Used to convert dryers from Natural Gas (N.G.) or Mixed
Gas to Liquid Petroleum Gas (L.P.); 22,500 Btu
Used to convert dryers from L.P. to N.G. or Mixed Gas;
22,500 Btu
22,500 Btu; Includes items 10 and 14
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
41
Burner Orifice Spuds - For Higher Elevations
Gas Models
DRY2266P_806093
42
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
1
1
1
1
1
1
PART NO.
58755
503786
503778
58719
503779
503780
503781
Burner Orifice Spuds - For Higher Elevations
DESCRIPTION
L.P. Orifice
L.P. Orifice
N.G. Orifice
Screw Orifice
N.G. Orifice
N.G. Orifice
N.G. Orifice
COMMENTS
22,500 Btu; 3000-7999 feet (915-2439 m)
22,500 Btu; 8000 feet (2440 m) and higher
22,500 Btu; 3000-5999 feet (915-1829 m)
N.G.; 22,500 Btu; 6000-7999 feet (1830-2439 m)
22,500 Btu; 8000-8999 feet (2440-2739 m)
22,500 Btu; 9000-9999 feet (2740-3049 m)
22,500 Btu; 10,000 feet (3050 m) and higher
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
43
Dryer Cabinet, Exhaust Duct and Base
44
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
DRY2381P_806093
806093
Dryer Cabinet, Exhaust Duct and Base
PART NO.
122P4P
503688
510146
510032WP
510136
511004
514632P
510903
521P3
511005
510137
510002WP
528P3
526P3
510135
514245
26509
36048
514428
513797P
804667
510001WP
56079
39733
56128
11
12
13
14
9
10
7
8
REF
NA
1
2
5
6
3
4
19
20
21
22
15
16
17
18
23
24
DESCRIPTION
Porcelain Touch-Up Paint
Screw
Bracket
Top Kit
Top Hinge
Gas Clearance Label
Cabinet Rear Panel
Access Panel Plate
Flexible Venting Kit
Electric Clearance Label
Exhaust Duct
Cabinet Side Panel
Directional Exhaust Kit
Hold Down Kit
Leveling Leg
Dryer Base
Washer
Screw
Screw
Output Control Assembly
Screw
Cabinet Side Panel
Panel Locator
Screw
Bumper Pad
COMMENTS
White
Model ATGE9AGP113TW01
Model ATEE9AGP173TW01
Each dryer requires 2 pieces
Right
Used to vent dryer out the sides
For mobile home installations
Left
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
45
Dryer Lead-In Cord
Gas Models
DRY1790P_806093
46
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
3
PART NO.
20530
38384
202777
DESCRIPTION
Screw
Strain Relief
Lead-In Cord
COMMENTS
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
47
Dryer Terminals and Terminal Extractor Tools
DRY1767P_806093
48
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Dryer Terminals and Terminal Extractor Tools
COMMENTS REF
1
2
2
5
6
3
4
PART NO.
500338
00255
00256
00188
283P4
190P4
128P4
DESCRIPTION
10 Position Housing
Female Terminal
Female Terminal
Female Terminal
Terminal Extractor Tool
Extractor Tool
Extractor Tool
1/4 inch; (1) 12 gauge wire; Electric models
1/4 inch; (1) or (2) 18 gauge wires; Gas models
For 1 or 2 wire application
For use on Molex connectors
For use on electric dryer terminals
For use on gas dryer terminals
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
49
Dryer Labels
DRY2402P_806093
50
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
3
6
7
4
5
8
9
10
11
PART NO.
803260
505281
44127701
502791
500281
59414
511004
500049
505215
511005
500497
DESCRIPTION
Warning Label
Disconnect Power Warning Label
Warning Label
Venting Instruction Label
Warning/Caution Label
Remove Door Label
Gas Clearance Label
Warning Label
Gas Label
Electric Clearance Label
Exhaust Warning Label
COMMENTS
Turn off controls
Electric shock
Model ATGE9AGP113TW01
Electric schock, rotating parts
Stainless steel flexible gas line; Model
ATGE9AGP113TW01
Model ATEE9AGP173TW01
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
51
Washer Labels
FLW1722P_806093
52
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
1
2
2
5
6
3
4
7
8
PART NO.
803011
802074
802838
802367
513371
505281
685928
803260
500314
COMMENTS DESCRIPTION
Notice Label
Oversudsing Label
Oversudsing Label
Warning Label
Read Instructions Label
Disconnect Power Warning Label
Left Hand Thread Label
Warning Label
Warning Label
English
Spanish
Reduce fire risk; Door locked
Disconnect power
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
53
Shipping Materials
FLW1737P_806093
54
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
NA
NA
NA
3
4
1
2
PART NO.
800462
803858
800624
804488
M400014
M400043
804454
DESCRIPTION
Screw
Shipping Spacer
Washer
Label
Washer
Screw
Shipping Brace
COMMENTS
Remove shipping brace
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
55
Wire Harnesses and Wires
SWD1284P_806093
56
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
REF
NA
NA
NA
2
3
1
1
4
5
PART NO.
45001
45380
804433
514020
513971
806031
806029
806028
513991
DESCRIPTION
18 Gauge Wire
12 Gauge Wire
Pressure Sensor Harness
Electric Harness
Gas Harness
Front Control Harness
Motor Harness
Door Lock Harness Assembly
Security Cabinet Harness
COMMENTS
Black; Order wire by the foot and terminals as required
Orange; Order wire by the foot and terminals as required
Dryer; Model ATEE9AGP173TW01
Dryer; Model ATGE9AGP113TW01
Washer
NOTE: Individual wires are not available separately. Order complete wire harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires.
806093
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
57
Notes
58
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Parts Index
A
Access Panel and Guard Assembly
514252W................................................................. 29
Access Panel Assembly
514250WP .......................................................... 7, 29
Access Panel Plate
510903 .................................................................... 45
Adhesive
511637P ............................................................ 33, 35
Air Duct Assembly
510151LG ............................................................... 33
510151W................................................................. 33
Anchor
155P3...................................................................... 21
Anchor Floor Mount Assembly
802844P.................................................................. 21
Anti-Seize Compound
27604P.............................................................. 15, 31
B
Balance Ring Assembly
804393 .................................................................... 15
Ballast Weight
803810 .................................................................... 13
Bar Sensor
513737 .................................................................... 33
Base Assembly
803876 .................................................................... 21
Bearing Housing Kit
805525 .................................................................... 15
Blower Fan Assembly
510139P.................................................................. 31
Blower Housing
511969LG................................................................ 31
511969WP............................................................... 31
Blower Housing Seal
510238P.................................................................. 31
Booster and Holding Coil
58804A.................................................................... 41
Bracket
510146 .................................................................... 45
Bulkhead Assembly
515544W................................................................. 33
Bumper Pad
36226 ...................................................................... 21
56128 ...................................................................... 45
Burner Assembly
510149P.................................................................. 41
C
Cabinet Panel Kit
800004WP .............................................................. 21
Cabinet Rear Panel
514632P.................................................................. 45
806093
Cabinet Side Panel
510001WP............................................................... 45
510002WP............................................................... 45
Clamp Ring
803802 .................................................................... 13
Clothes Guard Deflector
804467 .................................................................... 13
805548 .................................................................... 13
Combustion Duct
510131 .................................................................... 39
Compartment Cover
803669 ......................................................................9
Control
514567P ....................................................................5
Control Assembly
805219P ....................................................................5
Control Overlay
804491 ......................................................................5
Control Panel
803960WP.................................................................5
Control Shield
804363 ......................................................................5
Cylinder Assembly
510159WP............................................................... 33
510265LG................................................................ 33
510265WP............................................................... 33
Cylinder Baffle
510102W ................................................................. 33
Cylinder Belt
511255P ..................................................................31
Cylinder Glide
513710 .................................................................... 33
Cylinder Glide Bracket
510145 .................................................................... 33
Cylinder Light Lens
512106 .................................................................... 33
Cylinder Roller
510708P ..................................................................35
Cylinder Roller Bracket
510100 .................................................................... 35
Cylinder Seal Assembly
510207P ............................................................33, 35
D
Detergent Hose
804717 ......................................................................9
Directional Exhaust Kit
528P3 ...................................................................... 45
Disconnect Power Warning Label
505281 .............................................................. 51, 53
Dispenser Assembly
803698 ......................................................................9
Dispenser Drawer
803667 ......................................................................9
Dispenser Handle
804227WP.................................................................9
Dispenser Inlet Hose
803849 ................................................................ 9, 11
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
N/A items do not appear in index.
59
Dispenser Plate
803843 ...................................................................... 9
Door and Liner Assembly
511636WP............................................................... 27
Door Assembly
804083WP ................................................................ 7
Door Catch Assembly
510177 .................................................................... 29
802803 ...................................................................... 7
Door Glass
802695P.................................................................... 7
Door Glass Mounting Plate
804239 ...................................................................... 7
Door Handle Wedge
510129 .................................................................... 27
Door Hinge
802934 ...................................................................... 7
Door Latch Assembly
802317P.................................................................... 7
Door Liner Grill
503870LG ............................................................... 27
503870W................................................................. 27
Door Lock Harness Assembly
806028 .................................................................... 57
Door Pull and Wedge Kit
510103WP .............................................................. 27
515950P.................................................................. 27
Door Seal
804428P.................................................................... 7
Door Seal Assembly
804429P.................................................................... 7
Door Strike
510181 .................................................................... 27
Door Strike Mount
510127 .................................................................... 27
Drain Base Bracket
803814 .................................................................... 19
Drain Hose
803976 .................................................................... 19
Drain Hose Bracket
803828 .................................................................... 21
Drain Hose Sleeve
33615 ...................................................................... 19
Drain Pump Assembly
803921P.................................................................. 19
Drain Pump Isolator
803815 .................................................................... 19
Drive Belt
804985 .................................................................... 17
Drum Light Lamp
60954 ...................................................................... 33
Dryer Base
514245 .................................................................... 45
Dryer Door
510082WP .............................................................. 27
Dryer Door Assembly
514114W ................................................................. 27
Dryer Door Window
503982P.................................................................. 27
Drying Rack
512082P.................................................................. 33
E
Elbow
513072 .................................................................... 41
Electric Clearance Label
511005............................................................... 45, 51
Electric Harness
514020 .................................................................... 57
Exhaust Duct
510137 .................................................................... 45
Exhaust Warning Label
500497 .................................................................... 51
Expansion Clip
70030501 ..................................................................5
Extension Spring
802285 ......................................................................7
Extractor Tool
128P4 ...................................................................... 49
190P4 ...................................................................... 49
F
Felt Pad
510189 .................................................................... 33
Female Terminal
00188 ...................................................................... 49
00255 ...................................................................... 49
00256 ...................................................................... 49
Flexible Venting Kit
521P3 ...................................................................... 45
Foam Pad
804875 ......................................................................9
Foreign Object Deflector
806308 .................................................................... 13
806313 .................................................................... 13
806361 .................................................................... 13
Front Bulkhead
513640W ................................................................. 33
513641 .................................................................... 33
Front Bulkhead Assembly
515533 .................................................................... 33
Front Control Harness
806031 .................................................................... 57
Front Panel
510066WP............................................................... 29
802277WP.................................................................7
Front Panel Assembly
513781WP............................................................... 29
Front Panel Assembly Kit
806505W ...................................................................7
Front Panel Seal
511056..................................................................... 29
G
Gas Clearance Label
511004............................................................... 45, 51
Gas Harness
513971 .................................................................... 57
Gas Label
505215 .................................................................... 51
N/A items do not appear in index.
60
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
Gas Valve Assembly
510506P.................................................................. 41
Gas Valve Mounting Bracket
510128 .................................................................... 41
Gasket
802427 .................................................................... 19
Glass Door Window
513910 .................................................................... 27
Glass Mounting Clip
802700 ...................................................................... 7
Glide Kit
RB170003 ............................................................... 33
Grommet
29175 ...................................................................... 13
Igniter and Bracket Assembly
510184P ..................................................................41
Inner Basket Assembly
804374P ..................................................................15
Inner Basket Assembly Kit
804376P ..................................................................15
Inner Door Bezel
804562 ......................................................................7
Inner Door Bezel Kit
802307P ....................................................................7
Inverter Control Assembly
803949P ..................................................................17
H
Harness Strap
55881 ...................................................................... 25
Heat Duct Shroud
510101 .................................................................... 39
Heater Assembly
510329P.................................................................. 37
Heater Duct and Screw Assembly
510025P............................................................ 37, 39
Heater Kit
964P3...................................................................... 37
Heater Kit Assembly
61927 ...................................................................... 37
Hinge
511036 .................................................................... 27
Hinge Hole Plug
510186 .................................................................... 29
Hinge Plate
802206 ...................................................................... 7
Hold Down Kit
526P3...................................................................... 45
Hose Clamp
F200204 .................................................................. 19
685725 ...................................................................... 9
802281 ...................................................................... 7
803891 .................................................................... 13
804173 ................................................................ 9, 11
Hose Clip
36985 ................................................................ 13, 25
800553 .................................................................... 13
Hose Stand
38732 ...................................................................... 19
Housing, 10 Position
500338 .................................................................... 49
L
Label
804488 .................................................................... 55
Lead-In Cord
202777 .............................................................. 25, 47
Lead-In Pipe Assembly
510204 .................................................................... 41
Left Hand Thread Label
685928 .................................................................... 53
Leveling Leg
34319 ...................................................................... 21
510135 .................................................................... 45
Lid Assembly
802426P ..................................................................19
Lifter
804382 .................................................................... 15
Light Housing Assembly
512108 .................................................................... 33
Limit Thermostat
510701 .................................................................... 37
510702 .................................................................... 39
Liner and Seal Assembly
510098LG................................................................ 27
510098W ................................................................. 27
Liner Door Seal
510147P ..................................................................27
Lint Filter
503980LG................................................................ 33
503980W ................................................................. 33
Lint Filter Cover
510502LG................................................................ 33
510502W ................................................................. 33
L.P. Conversion Kit
649P3 ...................................................................... 41
L.P. Orifice
503786 .................................................................... 43
58755 ...................................................................... 43
I
Idler Lever
510133 .................................................................... 31
Idler Lever and Wheel Assembly
510158 .................................................................... 31
Idler Spring
510185 .................................................................... 31
Idler Wheel and Bearing Assembly
510142P.................................................................. 31
806093
M
Mixing Valve
803809 .................................................................... 11
Mixing Valve Screen
24122 ...................................................................... 11
Moisture Sensor Base
513738 .................................................................... 33
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
N/A items do not appear in index.
61
Motor and Pulley Assembly
511629P .................................................................. 31
Motor and Rod Assembly Kit
805726P.................................................................. 17
Motor Control Shield
804878 .................................................................... 17
Motor Harness
806029 .................................................................... 57
Motor Hub Ring Kit
590P3...................................................................... 31
Motor Mount
510060 .................................................................... 31
Motor Mount Clamp
510180 .................................................................... 31
Motor Pulley
500011 .................................................................... 31
Motor Rod
803861 .................................................................... 17
N
O
P
R
S
802838 .................................................................... 53
Panel Locator
56079 ...................................................... 7, 21, 29, 45
Pop Rivet
685847 .................................................................... 13
Porcelain Touch-Up Paint
122P4P.............................................................. 21, 45
Pressure Bulb
803837 .................................................................... 13
Pressure Sensor
202470 .................................................................... 21
Pressure Sensor Harness
804433 .................................................................... 57
Pressure Sensor Tube Assembly
804483 .................................................................... 13
Pulley Assembly
803974 .................................................................... 15
Pulley Bolt Tightening Fixture
802336 .................................................................... 23
Pump Housing
802428 .................................................................... 19
Pump Housing Assembly
802434P ..................................................................19
Notice Label
803011 .................................................................... 53
Nut
F430218 .................................................................. 13
03673 ...................................................................... 25
21899 ...................................................................... 21
23951 ........................................................................ 7
36020 ........................................................................ 7
44071201 ................................................................ 27
52566 ...................................................................... 31
56156 ................................................................ 31, 35
685846 ...................................................................... 7
800452 .............................................................. 13, 15
802343 .................................................................... 13
804418 .................................................................... 15
N.G. Conversion Kit
650P3...................................................................... 41
N.G. Orifice
503778 .................................................................... 43
503779 .................................................................... 43
503780 .................................................................... 43
503781 .................................................................... 43
Read Instructions Label
513371 .................................................................... 53
Rear Access Panel
803998 ......................................................................5
Rear Bulkhead Assembly
510905WP............................................................... 35
511082P ..................................................................35
Rear Panel
803789 .................................................................... 21
803790 .................................................................... 21
Remove Door Label
59414 ...................................................................... 51
Retainer Clip
36014 ...................................................................... 19
Retaining Ring
23748 ................................................................ 31, 35
Roller Kit
RB170002 ............................................................... 35
Rubber Foot
34318 ...................................................................... 21
501855 .................................................................... 21
O-Ring
802429P.................................................................. 19
Outer Door Bezel
803710WP ................................................................ 7
Outer Tub Assembly
803864 .................................................................... 13
Outlet Cover
500820 .............................................................. 37, 39
Out-of-Balance Switch Assembly
803415 .................................................................... 13
Out-of-Balance Switch Bracket
804457 .................................................................... 13
Output Control Assembly
513797P.................................................................. 45
Oversuding Label
802074 .................................................................... 53
Screw
M400043 ........................................................... 15, 55
M400057 ................................................................. 17
20530 ................................................................ 25, 47
23222 ................................................................ 37, 41
31260 ...................................................................... 31
33562 ...................................................................... 29
36048 ...................................................................... 45
N/A items do not appear in index.
62
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
39733 ...................................................... 7, 21, 29, 45
500226 .................................................................... 27
500227 .................................................................... 33
500824 .................................................................... 31
501086 .................................................................... 33
501285 .............................................................. 33, 35
501524 .................................................................... 17
502535 .................................................................... 31
503661 .................................................... 7, 17, 19, 21
503688 ...................... 5, 29, 31, 33, 35, 37, 39, 41, 45
505295 .................................................................... 27
505870 .................................................................... 27
514428 .................................................................... 45
515597 .................................................................... 27
51782 ................................................................ 39, 41
56124 ...................................................................... 41
61199 ...................................................................... 35
62588 ...................................................................... 33
685831 .................................................................... 15
70240301 .................................................................. 5
800461 .................................................................... 13
800462 .................................................................... 13
800548 ............................................................ 7, 9, 15
801001 ...................................................................... 9
801019 ...................................................................... 7
801045 ...................................................................... 7
801993 ...................................................................... 7
802431 .................................................................... 19
802596 .................................................................... 13
804399 .................................................................... 15
804462 .................................................................... 55
804667 ................................................................ 5, 45
804699 .................................................................... 15
Screw Orifice
58719 ...................................................................... 43
Seal Kit
RB170001 ......................................................... 33, 35
Sealant
27615P.................................................................... 19
Secondary Coil
58804B.................................................................... 41
Security Cabinet Harness
513991 .................................................................... 57
Sensor
510213 .................................................................... 41
Shaft
56461P.............................................................. 31, 35
Shield Bracket
804018 ...................................................................... 5
Shipping Brace
804454 .................................................................... 55
Shipping Plate
803851 .................................................................... 21
Shipping Plug
803859 .................................................................... 21
Shipping Spacer
803858 .................................................................... 55
Shock Assembly
803777 .................................................................... 13
Side Panel Kit
806492 .................................................................... 21
Speed Clip
28835 ...................................................................... 29
Standpipe Strap
33489 ...................................................................... 19
806093
Strain Relief
32219 ...................................................................... 19
38384 ................................................................ 25, 47
Switch
512973 .................................................................... 29
T
Terminal Block Assembly
510190P ..................................................................35
Terminal Block Shield
510237 .................................................................... 35
Terminal Extractor Tool
283P4 ...................................................................... 49
Thermal Fuse Assembly
511412..................................................................... 37
Thermistor Assembly
510523 .................................................................... 31
Top Hinge
510136 .................................................................... 45
Top Kit
510032WP............................................................... 45
Trunnion Shaft Kit
804405P ..................................................................15
Tub Front
803770 .................................................................... 13
Tub Front Assembly
803879 .................................................................... 13
Tub Front Seal
803801 .................................................................... 13
Tub-to-Pump Hose
803829 .................................................................... 19
V
Venting Instruction Label
502791 .................................................................... 51
W
Warning Label
44127701 ................................................................ 51
500049 .............................................................. 13, 51
500314 .................................................................... 53
802367 .................................................................... 53
803260 .............................................................. 51, 53
Warning/Caution Label
500281 .............................................................. 29, 51
Washer
M400014 ................................................................. 55
M400080 ................................................................. 17
M400081 ................................................................. 13
M403958 ................................................................. 15
02834 ...................................................................... 17
03815 ...................................................................... 25
20290 ...................................................................... 11
26509 ...................................................................... 45
504082 .................................................................... 35
52549 ................................................................ 31, 35
800457 .................................................................... 15
800464 .................................................................... 15
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
N/A items do not appear in index.
63
800624 .................................................................... 55
802254 .................................................................... 11
803615 .................................................................... 11
804458 .................................................................... 13
Water Hose
F200116 .................................................................. 11
Window Clip
513958 .................................................................... 27
Window Trim
503981W................................................................. 27
513960W................................................................. 27
Wire Assembly
510527 .................................................................... 37
510528 .................................................................... 37
Wire Clamp Ring
802283 ...................................................................... 7
Wire Clip
504034 .................................................................... 25
687500 .................................................................... 25
Wire Tie
38663 ...................................................................... 25
Wire, 12 Gauge
45380 ...................................................................... 57
Wire, 18 Gauge
45001 ...................................................................... 57
Wrapper Assembly
804112W ................................................................... 5
Wrench
392P4...................................................................... 23
N/A items do not appear in index.
64
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
806093
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project
Related manuals
advertisement