advertisement
▼
Scroll to page 2
of 196
2004 Model Year Electrical Guide Publication number S2004XJ Date of Issue: April 2003 © 2003 Jaguar Cars PRINTED IN USA All rights reserved. All material contained herein is based on the latest information available at the time of publication. The right is reserved to make changes at any time without notice. Jaguar XJ 2004 The Jaguar XJ Jaguar XJ 2004 Table of Contents Table of Contents: Figures ........................................................................................................... 2 – 3 Abbreviations and Acronyms ............................................................................................................ 4 Introduction ..................................................................................................................................... 5 Component Index ..................................................................................................................... 6 – 11 User Instructions ..................................................................................................................... 12 – 13 Symbols and Codes ................................................................................................................. 14 – 17 Network Configuration ................................................................................................................... 18 Major Harnesses and Fuse Box Location ......................................................................................... 19 Relay and Fuse Location ................................................................................................................. 20 Fuse Box Connectors ...................................................................................................................... 21 Harness and In-Line Connector Location .................................................................................. 22 – 24 Ground Point Location ................................................................................................................... 25 Control Module Location ......................................................................................................... 26 – 27 Control Module Pin Identification ............................................................................................ 28 – 35 Electrical Guide Figures and Data ........................................................................ follows after page 35 (pages are numbered by Figure number) Appendix (SCP and CAN Messages) ............................................................... follows Figures and Data DATE OF ISSUE: April 2003 1 Table of Contents: Figures FIGURES Fig. Description 01 Power Distribution 01.1 01.2 01.3 01.4 01.5 01.6 01.7 01.8 ............ ............ ............ ............ ............ ............ ............ ............ 02 Jaguar XJ 2004 Main Power Distribution ............................................................................ Battery Power Distribution: Part 1 .............................................................. Battery Power Distribution: Part 2 .............................................................. Ignition Switched Power Distribution: Part 1 .............................................. Ignition Switched Power Distribution: Part 2 .............................................. Switched System Power Distribution: Part 1 ............................................... Switched System Power Distribution: Part 2 ............................................... Engine Management Switched Power Distribution ...................................... Variant All Vehicles All Vehicles All Vehicles All Vehicles All Vehicles All Vehicles All Vehicles All Vehicles Battery; Starter; Generator 02.1 ............ Battery; Starter; Generator – V6 ................................................................. V6 Vehicles 02.2 ............ Battery; Starter; Generator – V8 ................................................................. V8 Vehicles 03 03.1 03.2 03.3 03.4 03.5 03.6 Engine Management ............ ............ ............ ............ ............ ............ 04 Engine Management System: V6 – Part 1 .................................................... Engine Management System: V6 – Part 2 .................................................... Engine Management System: V8 N/A – Part 1 ............................................. Engine Management System: V8 N/A – Part 2 ............................................. Engine Management System: V8 SC – Part 1 ............................................... V8 SC Engine Management System: V8 SC – Part 2 ..................................... V6 Vehicles V6 Vehicles V8 N/A Vehicles V8 N/A Vehicles V8 SC Vehicles V8 SC Vehicles Transmission 04.1 ............ Automatic Transmission ............................................................................. All Vehicles 05 05.1 05.2 05.3 05.4 Chassis ............ ............ ............ ............ 06 Dynamic Stability Control .......................................................................... Electronic Parking Brake; Variable Assist Power Steering ............................. Air Suspension System ............................................................................... Adaptive Speed Control ............................................................................. All Vehicles All Vehicles All Vehicles Adaptive Speed Control Vehicles Climate Control 06.1 ............ Climate Control: Part 1 .............................................................................. All Vehicles 06.2 ............ Climate Control: Part 2 .............................................................................. All Vehicles 06.3 ............ Rear Climate Control ................................................................................. Rear Climate Control Vehicles 07 Instrumentation 07.1 ............ Instrument Cluster ..................................................................................... All Vehicles 08 08.1 08.2 08.3 08.4 08.5 08.6 09 Exterior Lighting ............ ............ ............ ............ ............ ............ Exterior Lighting: Front .............................................................................. Exterior Lighting: Front – HID .................................................................... Exterior Lighting: Rear ................................................................................ Exterior Lighting: Rear – European Trailer Towing ....................................... Exterior Lighting: Rear – U.K. Trailer Towing ............................................... Headlamp Leveling .................................................................................... Non HID Headlamp Vehicles HID Headlamp Vehicles All Vehicles European Trailer Towing Vehicles U.K. Trailer Towing Vehicles HID Headlamp Vehicles Interior Lighting 09.1 ............ Interior Lighting ......................................................................................... All Vehicles 09.2 ............ Dimmer-Controlled Lighting: Part 1 ............................................................ All Vehicles 09.3 ............ Dimmer-Controlled Lighting: Part 2 ............................................................ All Vehicles 2 DATE OF ISSUE: April 2003 Jaguar XJ 2004 FIGURES Fig. Description 10 Steering Column; Pedals; Mirrors Table of Contents: Figures Variant 10.1 ............ Steering Column Adjust; Pedal Adjust ......................................................... All Vehicles 10.2 ............ Door Mirrors; Electrochromic Rear View Mirrors ........................................ All Vehicles 11 Seat Systems 11.1 ............ 11.2 ............ 11.3 ............ 11.4 ............ 11.5 ............ 11.6 ............ 11.7 ............ 11.8 ............ 11.9 ............ 11.10 .......... Driver Seat: 12-Way Movement with Memory ............................................ Driver Seat: 16-Way Movement with Memory ............................................ Driver Seat: Non Memory .......................................................................... Passenger Seat: 12-Way Movement ............................................................ Passenger Seat: 16-Way Movement ............................................................ Passenger Seat: 16-Way Movement with Rear Override .............................. Front Seat Heaters ..................................................................................... Powered Rear Seats: LH Seat ...................................................................... Powered Rear Seats: RH Seat ..................................................................... Rear Seat Heaters ...................................................................................... 12 Central Locking; Security 12-Way Seat Memory Vehicles 16-Way Seat Memory Vehicles Non Memory Seat Vehicles 12-Way Passenger Seat Vehicles 16-Way Passenger Seat Vehicles Powered Rear Seats Vehicles Heated Front Seats Vehicles Powered Rear Seats Vehicles Powered Rear Seats Vehicles Heated Rear Seats Vehicles 12.1 ............ Central Locking .......................................................................................... All Vehicles 12.2 ............ Security System ......................................................................................... All Vehicles 13 Wash / Wipe 13.1 ............ Wash / Wipe System .................................................................................. All Vehicles 14 Powered Windows; Sliding Roof 14.1 ............ Powered Windows; Sliding Roof ................................................................. All Vehicles 15 In-Car Entertainment 15.1 ............ In-Car Entertainment: Premium ................................................................. Premium ICE Vehicles 15.2 ............ In-Car Entertainment: Audiophile ............................................................... Audiophile ICE Vehicles 15.3 ............ Rear In-Car Entertainment ......................................................................... Rear ICE Vehicles 16 16.1 16.2 16.3 16.4 16.5 16.6 16.7 Communications; Navigation ............ ............ ............ ............ ............ ............ ............ 17 Telephone System: ROW ........................................................................... Telephone System: NAS ............................................................................. Telephone System with Voice Control: ROW .............................................. Telephone System with Voice Control: NAS ................................................ Navigation System ..................................................................................... Navigation System with Television .............................................................. Navigation System: Japan ........................................................................... ROW Vehicles NAS Vehicles ROW Voice Vehicles (except Japan) NAS Voice Vehicles Navigation Vehicles (except Japan) Navigation Vehicles with TV (except Japan) Japan Vehicles Occupant Protection 17.1 ............ Advanced Restraints System: Part 1 ............................................................ All Vehicles 17.2 ............ Advanced Restraints System: Part 2 ............................................................ All Vehicles 18 Driver Assist 18.1 ............ Parking Aid System .................................................................................... Parking Aid Vehicles 19 Ancillaries 19.1 ............ Ancillaries: Part 1 ...................................................................................... All Vehicles 19.2 ............ Ancillaries: Part 2 ...................................................................................... All Vehicles 20 20.1 20.2 20.3 20.4 Vehicle Multiplex Systems ............ ............ ............ ............ Controller Area Network ............................................................................ Standard Corporate Protocol Network; Serial Data Link: LHD ..................... Standard Corporate Protocol Network; Serial Data Link: RHD ..................... D2B Network ............................................................................................ DATE OF ISSUE: April 2003 All Vehicles LHD Vehicles RHD Vehicles All Vehicles 3 Abbreviations and Acronyms Jaguar XJ 2004 The following abbreviations and acronyms are used throughout this Electrical Guide: General and EMS Acronyms A/C APP SENSOR APP1 APP2 B+ BANK 1 BANK 2 CAN CKP SENSOR CMP SENSOR / 1 CMP SENSOR / 2 D2B DSC ECT SENSOR EFT SENSOR EGR VALVE EGT SENSOR EOT SENSOR EVAP CANISTER CLOSE VALVE EVAP CANISTER PURGE VALVE FTP SENSOR GPS HID HO2 SENSOR 1 / 1 HO2 SENSOR 1 / 2 HO2 SENSOR 2 / 1 HO2 SENSOR 2 / 2 IAT SENSOR ICE IMT VALVE / 1 IMT VALVE / 2 IP SENSOR KS / 1 KS / 2 LH LHD MAF SENSOR MAP SENSOR N/A NAS PATS PWM RH RHD ROW SC SCP TP SENSOR TP1 TP2 TURN TV V6 V8 VVT VALVE / 1 VVT VALVE / 2 +ve –ve 4 Control Module Acronyms Air Conditioning Accelerator Pedal Position Sensor Accelerator Pedal Position Sensor Element 1 Accelerator Pedal Position Sensor Element 2 Battery Voltage RH Cylinder Bank (Cylinders 1, 3, 5, 7) LH Cylinder Bank (Cylinders 2, 4, 6, 8) Controller Area Network Crankshaft Position Sensor Camshaft Position Sensor / RH Bank Camshaft Position Sensor / LH Bank D2B Network Dynamic Stability Control Engine Coolant Temperature Sensor Engine Fuel Temperature Sensor Exhaust Gas Recirculation Valve Exhaust Gas Temperature Sensor Engine Oil Temperature Sensor Evaporative Emission Canister Close Valve Evaporative Emission Canister Purge Valve Fuel Tank Pressure Sensor Global Positioning System High Intensity Discharge Heated Oxygen Sensor – RH Bank / Upstream Heated Oxygen Sensor – RH Bank / Downstream Heated Oxygen Sensor – LH Bank / Upstream Heated Oxygen Sensor – LH Bank / Downstream Intake Air Temperature Sensor In-Car Entertainment System Intake Manifold Tuning Valve / Bottom Intake Manifold Tuning Valve / Top Injection Pressure Sensor Knock Sensor / RH Bank Knock Sensor / LH Bank Left Hand Left Hand Drive Mass Air Flow Sensor Manifold Absolute Pressure Sensor Normally Aspirated North American Specification Passive Anti-Theft System Pulse Width Modulated Right Hand Right Hand Drive Rest of World Supercharged Standard Corporate Protocol Network Throttle Position Sensor Throttle Position Sensor Element 1 Throttle Position Sensor Element 2 Turn Signal Television V6 Engine V8 Engine Variable Valve Timing Valve / Bank 1 Variable Valve Timing Valve / Bank 2 Positive Negative ASCM ASM AUDIO CCM CPM DDM DSCM DSM ECM FEM HLM IC JGM MCP NCM PAM PBM RCM RCCM REM RMM SCLM VAM Adaptive Speed Control Module Air Suspension Module Audio Unit Climate Control Module Cellular Phone Module Driver Door Module Dynamic Stability Control Module Driver Seat Module Engine Control Module Front Electronic Module Headlamp Leveling Module Instrument Cluster J-Gate Module Multimedia Control Panel Navigation Control Module Parking Aid Module Parking Brake Module Restraints Control Module Rear Climate Control Module Rear Electronic Module Rear Memory Module Steering Column Lock Module Voice Activation Module DATE OF ISSUE: April 2003 Jaguar XJ 2004 Introduction Provisional Electrical Guide Format This Provisional Electrical Guide is an abridged version made up of two sections. The first section provides general information for and about the use of the book and information and illustrations to aid in the location of components. The Figure section illustrates detailed electrical circuit information for each system on the vehicle. Each Figure is identified by a Figure Number (i.e. Fig. 01.1) and Title. The data that normally accompanies each Figure is not included in this Provisional version. It is recommended that the user read through the front section of the book to develop a familiarity with the layout of the book and with the system of symbols and abbreviations used. The Table of Contents should help to guide the user. Vehicle Identification Numbers (VIN) VIN ranges are presented throughout the book in the following manner: ➞ VIN 123456 indicates “up to VIN 123456”; VIN 123456 ➞ indicates “from VIN 123456 on”. Jaguar 2003.5 Model Year XJ Electrical System Architecture Power Supplies The Jaguar 2003.5 Model Year XJ electrical system is a supply-side switched system. The ignition switch directly carries much of the ignition switched power supply load. Power supply is provided via three methods: direct battery power supply, ignition switched power supply, and “Switched System Power Supply”. The “Switched System Power Supply” circuit is controlled via the FEM (Front Electronic Module) and the REM (Rear Electronic Module). Refer to Figures 01.6 and 01.7 for circuit activation details. Fuse Boxes The electrical harness incorporates three serviceable power distribution fuse boxes: the Front Power Distribution Fuse Box located in the engine compartment, the Rear Power Distribution Fuse Box located in the trunk and the Passenger Junction Fuse Box located in the front right-hand foot well. All fuses and relays (except the trailer towing accessory kit) are located in the three fuse boxes. Vehicle Networks The Jaguar XJ employs three different networks: a CAN (Controller Area Network) for high-speed power train communications, an SCP (Standard Corporate Protocol) network for slower speed body systems communications, and a D2B (Optical) Network for very high-speed “real-time” audio data transfer. The D2B Network is a fiber optic network with a gateway to the remaining vehicle networks via the Audio Unit. Technician access to the three networks and the Serial Data Link is via the Data Link Connector. Ground Studs Circuit ground connections are made at body studs located throughout the vehicle. There are no separate power and logic grounding systems; however, there are a certain number of components that use unique ground points. THE JAGUAR XJ INSTRUMENT PANEL DATE OF ISSUE: April 2003 5 Component Index Accessory Relay .......................................................................... Fig. 19.2 Active Brake Booster ................................................................... Fig. 05.1 Active Brake Booster Solenoid ..................................................... Fig. 05.1 Adaptive Speed Control Chime Module ....................................... Fig. 05.4 Jaguar XJ 2004 Battery ....................................................................................... Fig. 01.1 .................................................................................................. Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 08.4 .................................................................................................. Fig. 08.5 Adaptive Speed Control Module .................................................. Fig. 05.4 .................................................................................................. Fig. 20.1 Blower ....................................................................................... Fig. 06.2 Air Cleaner Solenoid Valve .......................................................... Fig. 03.6 Blower Relay .............................................................................. Fig. 06.2 Air Conditioning Compressor Clutch ........................................... Fig. 06.1 Brake Cancel Switch ................................................................... Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 Air Conditioning Pressure Sensor ................................................ Fig. 03.2 .................................................................................................. Fig. 03.4 Air Conditioning Pressure Sensor ................................................ Fig. 03.6 .................................................................................................. Fig. 06.1 Air Intake Servo .......................................................................... Fig. 06.1 Air Mix Servos ............................................................................ Fig. 06.1 Air Suspension Compressor ........................................................ Fig. 05.3 Air Suspension Module ............................................................... Fig. 05.3 .................................................................................................. Fig. 08.6 .................................................................................................. Fig. 20.1 Air Suspension Pressure Sensor ................................................... Fig. 05.3 Air Suspension Relay ................................................................... Fig. 05.3 Air Suspension Valve Block ......................................................... Fig. 05.3 Air Suspension Vent Solenoid ..................................................... Fig. 05.3 Am / Fm Antenna Amplifier ........................................................ Fig. 15.1 .................................................................................................. Fig. 15.2 Blower Controller ....................................................................... Fig. 06.2 Brake Fluid Reservoir .................................................................. Fig. 05.1 Brake On / Off Switch ................................................................. Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 .................................................................................................. Fig. 08.3 Brake Pressure Sensor ................................................................. Fig. 05.1 CD Autochanger ......................................................................... Fig. 15.1 .................................................................................................. Fig. 15.2 .................................................................................................. Fig. 20.4 Cellular Phone Module ............................................................... Fig. 16.1 .................................................................................................. Fig. 16.2 .................................................................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 .................................................................................................. Fig. 20.4 Armrest Lid Switch ..................................................................... Fig. 15.3 Center Console Switch Pack ........................................................ Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 08.3 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 11.7 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 14.1 .................................................................................................. Fig. 19.1 Audio / Video Selector ................................................................ Fig. 09.2 .................................................................................................. Fig. 15.3 Cigar Lighters .............................................................................. Fig. 09.2 .................................................................................................. Fig. 19.2 Audio Unit ................................................................................. Fig. 09.2 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 15.1 .................................................................................................. Fig. 15.2 .................................................................................................. Fig. 16.1 .................................................................................................. Fig. 16.2 .................................................................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 .................................................................................................. Fig. 20.4 CKP Sensor - V6 ......................................................................... Fig. 03.1 Ambient Temperature Sensor ...................................................... Fig. 06.1 APP Sensor ................................................................................. Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Approach Lamps ......................................................................... Fig. 09.1 Auto Lamp Sensor ...................................................................... Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 08.3 .................................................................................................. Fig. 12.2 Auxiliary Coolant Pump .............................................................. Fig. 06.2 Auxiliary Lighting Switch ............................................................. Fig. 05.4 .................................................................................................. Fig. 07.1 .................................................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 08.3 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 09.3 Auxiliary Relay ............................................................................ Fig. 19.2 CKP Sensor - V8 ......................................................................... Fig. 03.3 .................................................................................................. Fig. 03.5 Climate Control Module ............................................................. Fig. 06.1 .................................................................................................. Fig. 06.2 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 20.1 Climate Control Panel ................................................................. Fig. 06.1 .................................................................................................. Fig. 09.2 Clock .......................................................................................... Fig. 09.2 .................................................................................................. Fig. 19.1 CMP Sensors - V6 ....................................................................... Fig. 03.1 CMP Sensors - V8 ....................................................................... Fig. 03.3 .................................................................................................. Fig. 03.5 Column and Pedal Adjust Switches ............................................. Fig. 10.1 Cool Air Bypass / Defrost Servos .................................................. Fig. 06.1 Cooling Fan Module and Motor .................................................. Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 Courtesy Lamps .......................................................................... Fig. 09.1 Curtain Airbag Igniters ................................................................ Fig. 17.1 Damper Actuators ...................................................................... Fig. 05.3 6 DATE OF ISSUE: April 2003 Jaguar XJ 2004 Data Link Connector ................................................................... Fig. 20.1 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Dip Beam Relay .......................................................................... Fig. 08.1 .................................................................................................. Fig. 08.2 Door Ajar Switch - Driver ............................................................ Fig. 09.1 .................................................................................................. Fig. 10.1 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 Door Ajar Switch - LH Rear ......................................................... Fig. 09.1 .................................................................................................. Fig. 12.2 Door Ajar Switch - Passenger ...................................................... Fig. 09.1 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 Door Ajar Switch - RH Rear ......................................................... Fig. 09.1 .................................................................................................. Fig. 12.2 Door Latch - Driver .................................................................... Fig. 12.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 14.1 Door Latch - Passenger ............................................................... Fig. 12.1 Door Mirrors .............................................................................. Fig. 10.2 Door Switch Pack - Driver ........................................................... Fig. 09.3 .................................................................................................. Fig. 10.2 .................................................................................................. Fig. 14.1 Door Switch Pack - LH Rear ........................................................ Fig. 09.3 .................................................................................................. Fig. 14.1 Door Switch Pack - Passenger ..................................................... Fig. 09.3 .................................................................................................. Fig. 14.1 .................................................................................................. Fig. 09.3 Door Switch Pack - RH Rear ........................................................ Fig. 14.1 Driver Door Module ................................................................... Fig. 10.1 .................................................................................................. Fig. 10.2 .................................................................................................. Fig. 11.1 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 14.1 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Driver Seat Module ..................................................................... Fig. 11.1 .................................................................................................. Fig. 11.2 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Dual Airbag Igniter - Passenger ................................................... Fig. 17.2 Dual Airbag Igniters - Driver ........................................................ Fig. 17.1 Dual Solar Sensor ....................................................................... Fig. 06.1 DVD Player ................................................................................ Fig. 15.3 Dynamic Stability Control Module ............................................... Fig. 05.1 .................................................................................................. Fig. 05.4 .................................................................................................. Fig. 20.1 ECT Sensor ................................................................................. Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Component Index Electrochromic Rear View Mirror and Compass ........................... Fig. 10.2 Electronic Road Pricing Module .................................................. Fig. 19.2 EMS Control Relay ...................................................................... Fig. 01.8 Engine Control Module ............................................................... Fig. 01.8 .................................................................................................. Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 03.1 .................................................................................................. Fig. 03.2 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.5 .................................................................................................. Fig. 03.6 .................................................................................................. Fig. 05.4 .................................................................................................. Fig. 06.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 20.1 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Engine Coolant Level Switch ....................................................... Fig. 07.1 Engine Oil Pressure Switch .......................................................... Fig. 07.1 EOT Sensor ................................................................................ Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 EVAP Canister Close Valve .......................................................... Fig. 03.3 .................................................................................................. Fig. 03.5 EVAP Canister Purge Valve ......................................................... Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Evaporator Temperature Sensor .................................................. Fig. 06.1 External Trunk Release Switch ..................................................... Fig. 12.1 Fascia Vents ............................................................................... Fig. 09.2 Footwell Lamps .......................................................................... Fig. 09.1 Front Electronic Module ............................................................. Fig. 01.6 .................................................................................................. Fig. 01.7 .................................................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 09.1 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 09.3 .................................................................................................. Fig. 10.1 .................................................................................................. Fig. 10.2 .................................................................................................. Fig. 11.7 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 13.1 .................................................................................................. Fig. 14.1 .................................................................................................. Fig. 19.1 .................................................................................................. Fig. 20.2 Front Fog Lamps ......................................................................... Fig. 08.1 .................................................................................................. Fig. 08.2 Front Fog Lamp Relay ................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 Front Impact Sensor ................................................................... Fig. 17.1 EFT Sensor - V6 .......................................................................... Fig. 03.1 EFT Sensor - V8 .......................................................................... Fig. 03.3 .................................................................................................. Fig. 03.5 EGR Valve - V8 N/A .................................................................... Fig. 03.3 EGR Valve - V8 SC ...................................................................... Fig. 03.5 DATE OF ISSUE: April 2003 7 Component Index Jaguar XJ 2004 Front Power Distribution Fuse Box .............................................. Fig. 01.1 .................................................................................................. Fig. 01.2 .................................................................................................. Fig. 01.4 .................................................................................................. Fig. 01.5 .................................................................................................. Fig. 01.8 .................................................................................................. Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 .................................................................................................. Fig. 05.3 .................................................................................................. Fig. 06.2 .................................................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 13.1 .................................................................................................. Fig. 19.2 Hood Ajar Switch ....................................................................... Fig. 12.2 Front Side Marker Lamps ............................................................ Fig. 08.1 .................................................................................................. Fig. 08.2 Ignition Switch ............................................................................ Fig. 01.1 .................................................................................................. Fig. 01.4 .................................................................................................. Fig. 01.5 .................................................................................................. Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 04.1 .................................................................................................. Fig. 07.1 .................................................................................................. Fig. 12.2 FTP Sensor ................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Fuel Filler Flap Motor ................................................................. Fig. 12.1 Fuel Injectors - V6 ...................................................................... Fig. 03.2 Fuel Injectors - V8 N/A ............................................................... Fig. 03.4 Fuel Injectors - V8 SC ................................................................. Fig. 03.6 Fuel Level Sensors ...................................................................... Fig. 07.1 Fuel Pump 1 ............................................................................... Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 Fuel Pump 2 ............................................................................... Fig. 03.6 Fuel Pump 2 Module .................................................................. Fig. 03.6 Fuel Pump Relay ......................................................................... Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 Generator - V6 ........................................................................... Fig. 02.1 Generator - V8 ........................................................................... Fig. 02.2 Glove Box Lamps ........................................................................ Fig. 09.1 Glove Box Motor ........................................................................ Fig. 19.1 Glove Box Switch ........................................................................ Fig. 19.1 Handset ..................................................................................... Fig. 16.2 Handset Receiver ........................................................................ Fig. 16.1 .................................................................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 Headlamp Units (Non-Hid) ......................................................... Fig. 08.1 Heated Rear View Mirrors ........................................................... Fig. 06.2 Heated Rear Window ................................................................. Fig. 06.2 .................................................................................................. Fig. 15.1 .................................................................................................. Fig. 15.2 Heated Rear Window Relay ........................................................ Fig. 06.2 Heated Wiper Park Relay ............................................................ Fig. 06.2 Height Sensors ............................................................................ Fig. 05.3 HID Headlamp Units .................................................................. Fig. 08.2 .................................................................................................. Fig. 08.6 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 High-Mounted Stop Lamp ........................................................... Fig. 08.3 .................................................................................................. Fig. 08.4 .................................................................................................. Fig. 08.5 Ho2 Sensors ............................................................................... Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 8 Horn Relay ................................................................................. Fig. 19.2 Horn Switch ............................................................................... Fig. 19.2 Horns ......................................................................................... Fig. 19.2 Humidity Sensor ......................................................................... Fig. 06.1 IAT Sensor 2 ............................................................................... Fig. 03.5 Ignition Capacitor ....................................................................... Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 Ignition Coil Relay ...................................................................... Fig. 01.8 Ignition Modules and Coils .......................................................... Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 IMT Solenoid Valves ................................................................... Fig. 03.1 In-Car Temperature Sensor ......................................................... Fig. 06.1 Inclination Sensor ....................................................................... Fig. 12.2 Inertia Switch ............................................................................. Fig. 01.5 Instrument Cluster ...................................................................... Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 05.2 .................................................................................................. Fig. 05.3 .................................................................................................. Fig. 05.4 .................................................................................................. Fig. 06.1 .................................................................................................. Fig. 07.1 .................................................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 08.3 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 09.3 .................................................................................................. Fig. 10.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 18.1 .................................................................................................. Fig. 20.1 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Intercooler Coolant Pump ........................................................... Fig. 03.6 IP Sensor - V6 ............................................................................. Fig. 03.1 IP Sensor - V8 N/A ...................................................................... Fig. 03.3 IP Sensor - V8 SC ........................................................................ Fig. 03.5 J Gate Module ............................................................................. Fig. 04.1 .................................................................................................. Fig. 05.1 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 20.1 Knock Sensors - V6 ..................................................................... Fig. 03.1 Knock Sensors - V8 ..................................................................... Fig. 03.3 .................................................................................................. Fig. 03.5 License Plate Lamps .................................................................... Fig. 08.3 .................................................................................................. Fig. 08.4 .................................................................................................. Fig. 08.5 Maf Sensor ................................................................................. Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 DATE OF ISSUE: April 2003 Jaguar XJ 2004 Main Beam Relay ........................................................................ Fig. 08.1 .................................................................................................. Fig. 08.2 Main Lighting Switch (Column Switchgear) .................................. Fig. 07.1 .................................................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 .................................................................................................. Fig. 08.3 Component Index Passenger Junction Fuse Box ....................................................... Fig. 01.1 .................................................................................................. Fig. 01.3 .................................................................................................. Fig. 01.4 .................................................................................................. Fig. 01.5 .................................................................................................. Fig. 01.6 Passenger Seat Belt Tension Sensor ............................................. Fig. 17.2 Map Lamps ................................................................................. Fig. 09.1 Passenger Seat Weight Pressure Sensor ....................................... Fig. 17.2 MAP Sensor - V6 ........................................................................ Fig. 03.1 Passenger Seat Weight Sensing Module ....................................... Fig. 17.2 MAP Sensor - V8 N/A .................................................................. Fig. 03.3 Passive Anti-Theft System Transceiver ......................................... Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 12.2 MAP Sensor - V8 SC .................................................................... Fig. 03.5 Megafuses .................................................................................. Fig. 01.1 .................................................................................................. Fig. 02.1 .................................................................................................. Fig. 02.2 Memory Switch Pack - Driver ..................................................... Fig. 09.3 .................................................................................................. Fig. 10.1 .................................................................................................. Fig. 10.2 .................................................................................................. Fig. 11.1 Pedal Adjust Motor ..................................................................... Fig. 10.1 Pedal Force Switch ..................................................................... Fig. 05.1 Pedal Travel Sensor .................................................................... Fig. 05.1 Power Amplifier ......................................................................... Fig. 15.2 .................................................................................................. Fig. 20.4 Memory Switch Packs - Rear ....................................................... Fig. 09.3 Power Points .............................................................................. Fig. 09.2 .................................................................................................. Fig. 19.2 Microphones - Rear .................................................................... Fig. 16.3 Power Wash Pump ..................................................................... Fig. 13.1 Microphone - RH Rear ................................................................ Fig. 16.3 Power Wash Relay ...................................................................... Fig. 13.1 Microphone (Roof Console) ......................................................... Fig. 16.3 Puddle Lamps ............................................................................. Fig. 09.1 Mid Bass Speakers ...................................................................... Fig. 15.1 .................................................................................................. Fig. 15.2 Rain Sensing Module .................................................................. Fig. 13.1 Mid-Range Speakers .................................................................... Fig. 15.2 Mode Servos ............................................................................... Fig. 06.1 Multimedia Control Panel ........................................................... Fig. 09.2 .................................................................................................. Fig. 15.3 .................................................................................................. Fig. 20.4 Navigation Control Module ......................................................... Fig. 06.1 .................................................................................................. Fig. 15.3 .................................................................................................. Fig. 16.1 .................................................................................................. Fig. 16.2 .................................................................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 .................................................................................................. Fig. 16.5 .................................................................................................. Fig. 16.6 .................................................................................................. Fig. 16.7 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 .................................................................................................. Fig. 20.4 Rear Accessory Connector .......................................................... Fig. 19.2 Rear Air Mix Servos .................................................................... Fig. 06.3 Rear Assist Handles .................................................................... Fig. 09.3 Rear Blower ................................................................................ Fig. 06.3 Rear Blower Controller ............................................................... Fig. 06.3 Rear Center Console Switch Pack ................................................ Fig. 09.2 .................................................................................................. Fig. 11.10 Rear Climate Control Module ...................................................... Fig. 06.3 .................................................................................................. Fig. 09.2 .................................................................................................. Fig. 20.1 Rear Door Lock Motors ............................................................... Fig. 12.1 Parking Brake Module ................................................................. Fig. 05.2 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Rear Electronic Module ............................................................... Fig. 01.6 .................................................................................................. Fig. 01.7 .................................................................................................. Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 .................................................................................................. Fig. 07.1 .................................................................................................. Fig. 08.3 .................................................................................................. Fig. 08.4 .................................................................................................. Fig. 08.5 .................................................................................................. Fig. 09.1 .................................................................................................. Fig. 09.3 .................................................................................................. Fig. 10.2 .................................................................................................. Fig. 11.6 .................................................................................................. Fig. 11.10 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 14.1 .................................................................................................. Fig. 18.1 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Parking Brake Motor ................................................................... Fig. 05.2 Rear Evaporator Temperature Sensor .......................................... Fig. 06.3 Parking Brake Switch .................................................................. Fig. 05.2 Rear Handset Receiver ................................................................ Fig. 16.3 Passenger Airbag Deactivation Indicator Lamp ............................ Fig. 17.2 Rear Ignition Relay ...................................................................... Fig. 01.4 Navigation GPS Antenna ............................................................. Fig. 16.5 .................................................................................................. Fig. 16.6 .................................................................................................. Fig. 16.7 Occupancy Sensing Module ........................................................ Fig. 17.2 Outlet Air Temperature Sensors .................................................. Fig. 06.1 Parking Aid Module .................................................................... Fig. 18.1 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Parking Aid Sensors .................................................................... Fig. 18.1 Parking Aid Sounders .................................................................. Fig. 18.1 Rear Memory Module ................................................................. Fig. 09.3 .................................................................................................. Fig. 11.8 .................................................................................................. Fig. 11.9 .................................................................................................. Fig. 20.2 DATE OF ISSUE: April 2003 9 Component Index Rear Mode Servo ........................................................................ Fig. 06.3 Rear Override Relay Pack ............................................................ Fig. 11.6 Jaguar XJ 2004 Seat Cushion Extend Motor - Passenger ....................................... Fig. 11.5 .................................................................................................. Fig. 11.6 Rear Power Distribution Fuse Box ............................................... Fig. 01.1 .................................................................................................. Fig. 01.2 .................................................................................................. Fig. 01.4 .................................................................................................. Fig. 01.5 .................................................................................................. Fig. 01.7 .................................................................................................. Fig. 01.8 .................................................................................................. Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 .................................................................................................. Fig. 06.2 .................................................................................................. Fig. 19.2 Seat Cushion Extend Motor and Position Sensor - Driver ................................................ Fig. 11.2 Rear Seat Back Heaters ............................................................... Fig. 11.10 Seat Cushion Rear Raise / Lower Motor - Driver ........................... Fig. 11.3 Rear Seat Back Incline / Recline Motor and Position Sensor - LH ..................................................... Fig. 11.8 Seat Cushion Rear Raise / Lower Motor - Passenger ..................... Fig. 11.4 .................................................................................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Rear Seat Back Incline / Recline Motor and Position Sensor - RH .................................................... Fig. 11.9 Rear Seat Belt Comfort Solenoid - LH .......................................... Fig. 11.8 Rear Seat Belt Comfort Solenoid - RH .......................................... Fig. 11.9 Rear Seat Belt Comfort Switch - LH ............................................. Fig. 11.8 Rear Seat Belt Comfort Switch - RH ............................................. Fig. 11.9 Rear Seat Cushion Heaters .......................................................... Fig. 11.10 Rear Seat Headrest Motor and Position Sensor - LH ..................... Fig. 11.8 Seat Cushion Front Raise / Lower Motor – Driver ......................... Fig. 11.3 Seat Cushion Front Raise / Lower Motor - Passenger .................... Fig. 11.4 .................................................................................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Seat Cushion Front Raise / Lower Motor and Position Sensor - Driver ................................................ Fig. 11.1 .................................................................................................. Fig. 11.2 Seat Cushion Heaters - Front ....................................................... Fig. 11.7 Seat Cushion Rear Raise / Lower Motor and Position Sensor - Driver ................................................ Fig. 11.1 .................................................................................................. Fig. 11.2 Seat Fore / Aft Motor - Driver ...................................................... Fig. 11.3 Seat Fore / Aft Motor - Passenger ................................................ Fig. 11.4 .................................................................................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Rear Seat Headrest Motor and Position Sensor - RH .................... Fig. 11.9 Seat Fore / Aft Motor and Position Sensor - Driver ....................... Fig. 11.1 .................................................................................................. Fig. 11.2 Rear Seat Lumbar Pump - LH ...................................................... Fig. 11.8 Seat Headrest Motor - Driver ...................................................... Fig. 11.3 Rear Seat Lumbar Pump - RH ...................................................... Fig. 11.9 Seat Headrest Motor - Passenger ................................................. Fig. 11.4 .................................................................................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Rear Seat Lumbar Solenoids - LH ................................................. Fig. 11.8 Rear Seat Lumbar Solenoids - RH ................................................ Fig. 11.9 Rear Seat Memory Switch Pack - LH ............................................ Fig. 11.8 Seat Headrest Motor and Position Sensor - Driver ....................... Fig. 11.1 .................................................................................................. Fig. 11.2 Rear Seat Memory Switch Pack - RH ............................................ Fig. 11.9 Seat Incline / Recline Motor - Driver ............................................ Fig. 11.3 Rear Seat Switch Pack - LH .......................................................... Fig. 11.6 .................................................................................................. Fig. 11.8 Seat Incline / Recline Motor - Passenger ...................................... Fig. 11.4 .................................................................................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Rear Seat Switch Pack - RH ......................................................... Fig. 11.6 .................................................................................................. Fig. 11.9 Rear Side Marker Lamps ............................................................. Fig. 08.3 Rear Vents .................................................................................. Fig. 09.2 Remote Keyless Entry Module ..................................................... Fig. 12.1 .................................................................................................. Fig. 12.2 Restraints Control Module .......................................................... Fig. 17.1 .................................................................................................. Fig. 17.2 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Seat Incline / Recline Motor and Position Sensor - Driver ............. Fig. 11.1 .................................................................................................. Fig. 11.2 Seat Lumbar Pump - 12-Way Seat - Driver ................................... Fig. 11.1 .................................................................................................. Fig. 11.3 Seat Lumbar Pump - 12-Way Seat - Passenger ............................. Fig. 11.4 Seat Lumbar Pump - 16-Way Seat - Driver ................................... Fig. 11.2 Seat Lumbar Pump - 16-Way Seat - Passenger ............................. Fig. 11.5 .................................................................................................. Fig. 11.6 Seat Lumbar Solenoids - Driver ................................................... Fig. 11.2 Roof Console .............................................................................. Fig. 09.1 .................................................................................................. Fig. 09.3 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 14.1 .................................................................................................. Fig. 16.1 .................................................................................................. Fig. 16.2 .................................................................................................. Fig. 16.4 .................................................................................................. Fig. 16.7 .................................................................................................. Fig. 18.1 .................................................................................................. Fig. 19.2 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Seat Lumbar Solenoids - Passenger .............................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Seat Back Heaters ....................................................................... Fig. 11.7 Side Airbag Igniters ..................................................................... Fig. 17.1 Seat Belt Pretensioner Igniters ..................................................... Fig. 17.1 Side Impact Sensors .................................................................... Fig. 17.1 Seat Belt Switch - Passenger ........................................................ Fig. 17.2 Slave Ignition Relay ..................................................................... Fig. 01.4 .................................................................................................. Fig. 01.8 10 Seat Position Switch - Driver ....................................................... Fig. 17.1 Seat Switch Pack - Driver ............................................................ Fig. 11.1 .................................................................................................. Fig. 11.2 .................................................................................................. Fig. 11.3 Seat Switch Pack - Passenger ....................................................... Fig. 11.4 .................................................................................................. Fig. 11.5 .................................................................................................. Fig. 11.6 Security Sounders ....................................................................... Fig. 12.2 DATE OF ISSUE: April 2003 Jaguar XJ 2004 Sliding Roof Module .................................................................... Fig. 14.1 Smog Sensor ............................................................................... Fig. 06.1 Spatial Sensors ............................................................................ Fig. 17.2 Component Index Throttle Motor Relay ................................................................... Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Starter Motor .............................................................................. Fig. 02.1 .................................................................................................. Fig. 02.2 TP Sensor ................................................................................... Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Starter Relay ............................................................................... Fig. 02.1 .................................................................................................. Fig. 02.2 Trailer Towing Connector ........................................................... Fig. 08.4 .................................................................................................. Fig. 08.5 Steering Angle Sensor ................................................................. Fig. 05.1 Trailer Towing Junction Fuse Box ................................................ Fig. 08.4 .................................................................................................. Fig. 08.5 Steering Column Lock Module .................................................... Fig. 12.2 .................................................................................................. Fig. 20.2 .................................................................................................. Fig. 20.3 Steering Column Movement Assembly ........................................ Fig. 10.1 Steering Wheel ........................................................................... Fig. 19.1 Steering Wheel Audio Switches ................................................... Fig. 15.1 .................................................................................................. Fig. 15.2 .................................................................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 Steering Wheel Heater Module ................................................... Fig. 19.1 Steering Wheel Lighting .............................................................. Fig. 09.2 Steering Wheel Speed Control Switches ....................................... Fig. 03.2 .................................................................................................. Fig. 03.4 .................................................................................................. Fig. 03.6 .................................................................................................. Fig. 05.4 Subwoofer Speakers .................................................................... Fig. 15.2 Sun Shade Motor ........................................................................ Fig. 19.2 Switched System Power Relay 1 .................................................. Fig. 01.6 Switched System Power Relay 2 .................................................. Fig. 01.6 Switched System Power Relay 3 .................................................. Fig. 01.7 Switched System Power Relay 4 .................................................. Fig. 01.7 Switched System Power Relay 5 .................................................. Fig. 01.7 Tail Lamp Units .......................................................................... Fig. 08.3 .................................................................................................. Fig. 08.4 .................................................................................................. Fig. 08.5 TCM Capacitor - V6 .................................................................... Fig. 04.1 TCM Capacitor - V8 .................................................................... Fig. 04.1 Telematics Display ...................................................................... Fig. 09.2 .................................................................................................. Fig. 12.2 .................................................................................................. Fig. 15.3 .................................................................................................. Fig. 16.1 .................................................................................................. Fig. 16.2 .................................................................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 .................................................................................................. Fig. 16.5 .................................................................................................. Fig. 16.6 .................................................................................................. Fig. 16.7 Trailer Towing Module ................................................................ Fig. 08.4 .................................................................................................. Fig. 08.5 Trailer Towing Relay ................................................................... Fig. 08.4 .................................................................................................. Fig. 08.5 Transit Isolation Relay ................................................................. Fig. 01.1 Transmission Control Module ..................................................... Fig. 02.1 .................................................................................................. Fig. 02.2 .................................................................................................. Fig. 04.1 .................................................................................................. Fig. 05.4 .................................................................................................. Fig. 20.1 Trunk and Fuel Flap Release Switch Pack ..................................... Fig. 09.2 .................................................................................................. Fig. 12.2 Trunk Lamp ................................................................................ Fig. 09.1 Trunk Latch ................................................................................ Fig. 09.1 .................................................................................................. Fig. 12.1 .................................................................................................. Fig. 12.2 Trunk Lid Lamp .......................................................................... Fig. 09.1 Turn Signal Repeaters ................................................................. Fig. 08.1 .................................................................................................. Fig. 08.2 TV Antenna Amplifiers ................................................................ Fig. 16.6 .................................................................................................. Fig. 16.7 Tweeter Speakers ........................................................................ Fig. 15.1 .................................................................................................. Fig. 15.2 Vanity Mirror Lamps ................................................................... Fig. 09.1 Variable Assist Steering Actuator ................................................. Fig. 05.2 Vehicle Information Antenna ...................................................... Fig. 16.7 Vehicle Information Control Module ........................................... Fig. 16.7 Vehicle Information Sensor ......................................................... Fig. 16.7 Vertical Accelerometers .............................................................. Fig. 05.3 Voice Activation Module ............................................................. Fig. 16.3 .................................................................................................. Fig. 16.4 .................................................................................................. Fig. 20.4 VVT Solenoid Valves ................................................................... Fig. 03.1 .................................................................................................. Fig. 03.3 Washer Fluid Level Switch .......................................................... Fig. 13.1 Telephone Antenna - Nas ........................................................... Fig. 16.2 .................................................................................................. Fig. 16.4 Wheel Speed Sensors .................................................................. Fig. 05.1 Telephone Antenna - Row ........................................................... Fig. 16.1 .................................................................................................. Fig. 16.3 Windshield Heated Wiper Park ................................................... Fig. 06.2 Televisions .................................................................................. Fig. 16.6 .................................................................................................. Fig. 16.7 Windshield Heater Relays ........................................................... Fig. 06.2 Window Motor Assemblies ......................................................... Fig. 14.1 Windshield Heaters .................................................................... Fig. 06.2 Television Screens - Rear ............................................................. Fig. 15.3 Windshield Washer Pump .......................................................... Fig. 13.1 Throttle Body - V6 ...................................................................... Fig. 03.1 Wipe / Wash Column Switch ....................................................... Fig. 13.1 Throttle Body - V8 N/A ............................................................... Fig. 03.3 Wiper Fast / Slow Relay ............................................................... Fig. 13.1 Throttle Body - V8 SC ................................................................. Fig. 03.5 Wiper Motor .............................................................................. Fig. 13.1 Throttle Motor ............................................................................ Fig. 03.1 .................................................................................................. Fig. 03.3 .................................................................................................. Fig. 03.5 Wiper On / Off Relay .................................................................. Fig. 13.1 DATE OF ISSUE: April 2003 Yaw Rate and Lateral Acceleration Sensors Cluster ...................... Fig. 05.1 Yaw Rate Sensor ......................................................................... Fig. 20.1 11 User Instructions Jaguar XJ 2004 Figure and Data Page Layout Figure Pages Each Figure represents a specific electrical system of the vehicle. The Figures are arranged numerically by system (01 - Power Distribution, 02 - Battery; Starter; Generator, etc.) with variations in the system identified by a numeral following a decimal point (01.1, 01.2, etc.). Refer to the Table of Contents: Figures for a complete list of the Figures. The Figures 01 - Power Distribution detail the distribution of power to each of the systems. Numbered reference symbols refer the user to a specific Figure and from a specific Figure back to the Power Distribution Figures. This method eliminates the need to include detailed Power Distribution information on each of the Figures. The reference symbols are defined on page 14. Each Figure appears on a right-hand page with a corresponding Data page to the left. The Figure and Data pages are folding pages. The user must fold out both pages in order to access all the information provided. Data Pages The Data page includes information to assist the user in identifying and locating components, connectors and grounds. This information is supplemented by the illustrations in this front section of the book. When network data is required for the understanding of a particular circuit, the user is directed to the Appendix. Most circuits that incorporate a control module include pinout information. The characteristics listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. This information is provided to assist the user in understanding circuit operation and should be used FOR REFERENCE ONLY. 12 DATE OF ISSUE: April 2003 Jaguar XJ 2004 CONTROL MODULE PIN OUT INFORMATION User Instructions FIGURE NUMBER COMPONENT, CONNECTOR AND GROUND INFORMATION Fig. 02.1 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module I Pin PI1-006 Description and Characteristic COMPONENTS ENGINE CRANK: B+ Component Connector(s) BATTERY — Connector Description Location — TRUNK / RH SIDE I PI1-031 PARK / NEUTRAL SIGNAL: B+ WHEN ACTIVATED O PI1-041 STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-053 GENERATOR CONTROL: VARIABLE VOLTAGE ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE I PI1-065 GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT GENERATOR – V6 PI47 BO10 IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL — — TRUNK / RH SIDE I PI1-079 GENERATOR FAULT; CHARGE WARNING C PI1-123 CAN – C PI1-124 CAN + Instrument Cluster Pin Description and Characteristic I IP5-02 KEY-IN AUDIBLE WARNING: B+ WHEN KEY IN B+ IP5-03 IGNITION SWITCHED POWER SUPPLY (II): B+ B+ IP5-04 IGNITION SWITCHED POWER SUPPLY (I): B+ SG IP5-14 SIGNAL GROUND: GROUND IP6-02 POWER GROUND: GROUND PG ENGINE, RH SIDE, FRONT I IP6-04 PATS GROUND: GROUND D IP6-05 PATS TRANSCEIVER: ENCODED COMMUNICATION MEGAFUSES D IP6-06 PATS TRANSCEIVER: ENCODED COMMUNICATION PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER C IP6-08 CAN + STARTER MOTOR — — ENGINE BLOCK / RH SIDE C IP6-09 CAN – STARTER RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R10 TRANSMISSION CONTROL MODULE GB2 16-WAY / BLACK TRANSMISSION CONTROL VALVE IP18 4-WAY / GREEN IGNITION SWITCH Transmission Control Module Pin Description and Characteristic HARNESS IN-LINE CONNECTORS B+ GB2-09 IGNITION SWITCHED POWER SUPPLY (II): B+ Connector O GB2-10 Connector Description Location PARK / NEUTRAL SIGNAL: GROUND WHEN ACTIVATED PG GB2-13 POWER GROUND: GROUND PG GB2-16 POWER GROUND: GROUND NOTE: Refer to the Appendix at the rear of this book for Network Messages. EC2 2-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EL1 2-WAY / GREY / ENGINE COMPARTMENT TO STARTER MOTOR LINK HARNESS ENGINE COMPARTMENT / BULKHEAD CENTER / REARWARD OF ENGINE GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING IP51 10-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location BC1 TRUNK / RH SIDE / ADJACENT TO BATTERY BC3 TRUNK / RH SIDE / ADJACENT TO BATTERY G4 ENGINE COMPARTMENT / ENGINE BLOCK GROUND G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER G31 CABIN / BEHIND PASSENGER AIR BAG DATA PAGE FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 DATE OF ISSUE FIGURE MODEL RANGE AND YEAR TITLE Jaguar XJ 2003.5 B B Battery; Starter; Generator – V6 R BC2 BC1 B BO1 500 A BO2 BATTERY BC3 FIGURE NUMBER 5 BO11 MEGAFUSES R10 KEY-IN RW 30 4 3 5 1 2 WR IP34-5 EC4-3 F19 25A 0 Y EL1-1 GO EC41-1 EC28-8 STARTER RELAY I RU 4 Fig. 02.1 Battery; Starter; Generator – V6 IP34-4 FRONT POWER DISTRIBUTION BOX II RU 01.5 IP34-7 IGNITION-SWITCHED CIRCUITS (II) III Y Y IP34-1 Y IP51-6 Y ECS9 EC2-2 Y PI41-40 PI41-34 IGNITION SWITCH 51 GO II B GB2-9 P, N GR O GB2-10 GB1-6 B P GB2-13 FIGURE PAGE B WR GB1-10 B P B GB2-16 GB1-9 EL2 PIS30 B B BO8 G30 (G26) TRANSMISSION CONTROL MODULE B BO9 STARTER MOTOR B G4 52 16 GR 4 YG II I GO B LOGIC Y B PIS27 IP5-4 GR NOT USED GB1-14 P, N Y PI1-6 I CRANK ENGINE REQUEST I PI1-65 20.1 IP6-8 WR IP18-3 65 D IP18-1 – IP18-4 1 6 Fig. 01.1 64 95 Fig. 01.3 16 52 Fig. 01.5 78 105 Fig. 01.7 S 7 63 Fig. 01.2 1 15 Fig. 01.4 53 77 Fig. 01.6 106 143 Fig. 01.8 E KEY TO REFERENCE SYMBOLS DATE OF ISSUE: April 2003 PI47-4 GENERATOR CONTROL CHARGE / FAULT B B B IPS2 INSTRUMENT CLUSTER II PI1-79 C – IPS6 IP5-14 IP6-2 S PI1-123 C + FIELD GENERATOR B O IP6-4 PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER II PI1-124 G IP6-9 P S 20.1 PI47-1 YR I D BG II GENERATOR WARNING 20.1 Y IP6-6 IP18-2 I 20.1 O.K. TO START G C IP6-5 GR GU S PI47-3 YR PI1-53 Y BO10 B PI47-2 WR I O IP5-2 + C GO ENGINE I PI1-31 PASSIVE ANTI-THEFT SYSTEM RW II O START PI1-41 IP5-3 S E ENGINE CONTROL MODULE G31BL I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: V6 Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 VARIANT, VIN RANGE AND DATE OF ISSUE 13 Symbols and Codes Jaguar XJ 2004 NOTE: In the examples on this page, an ‘X’ is used where a number would appear on an actual Figure. Reference Symbols Control Module Pin Symbols X Battery power supply I Input C CAN network X Ignition switched auxiliary power supply (key I, II) O Output S I SCP network X II Ignition switched power supply (key II, III) B + Battery voltage D 2 D2B network X Switched System Power Supply power supply P Power ground D Serial and encoded data X Engine Management System power supply + Sensor/signal supply V * XX.X Figure number reference – Sensor/signal ground ** CAN Controller Area Network SCP Standard Corporate Protocol network * D2B D2B network ** May also indicate Reference Ground or Logic Ground. S E May also indicate Reference Voltage. Refer to Control Module Pin-Out Information. Wiring Symbols Motor Splice Potentiometer Simplified splice Bulb Pressure transducer Capacitor Resistor Connector Solenoid Suppression diode Diode Suppression resistor Eyelet and stud Thermistor Fuse Transistor Ground Hall effect sensor Wire continued H Zener diode Light emitting diode (LED) 14 DATE OF ISSUE: April 2003 Jaguar XJ 2004 Harness Codes AC BC BF BL BO BR BS BT CC CL CP CR CV DB DD DL DT EC EL FP GB GC IJ IL IP IS LL LS LT PD PH PI PL PS PT RA RC RF RL RR RS RT SD SL SP SR SW TL TT VL VP VR VX VY YL Air Conditioning Harness Battery Ground Harness Front Bumper Harness Cabin to Trunk Lid Harness Battery Harness Rear Bumper Harness Battery Backed Sounder Harness Trunk Lid Harness Center Console Harness Center Console Link Harness Cooling Pump Harness Cabin Harness EVAP Canister Close Valve Link Harness D2B Network Harness Driver Door Harness Driver Seat Lumbar Harness Driver Door Trim Harness Engine Compartment Harness Starter Motor Solenoid Link Harness Fuel Tank Link Harness Transmission Harness Radiator Cooling Fan Harness Fuel Injector Harness Fuel Injector Harness Instrument Panel (Fascia) Harness Fuel Injector Link Harness LH Rear Seat Lumbar Harness LH Rear Seat Harness LH Rear Door Trim Harness Passenger Door Harness Telephone Harness Engine Management Harness Passenger Seat Lumbar Harness Passive Security Sounder Harness Passenger Door Trim Harness Rear Air Conditioning Harness Rear In-Car Entertainment Controls Harness Roof Harness LH Rear Door Harness RH Rear Door Harness RH Rear Seat Harness RH Rear Door Trim Harness Driver Seat Harness LH Rear Seat Motor Harness Passenger Seat Harness RH Rear Seat Motor Harness Steering Wheel Harness Telematics Harness Trailer Tow Harness LH Rear Television Harness Voice Activation Pre-Wire Harness RH Rear Television Harness RH Rear Television Link Harness LH Rear Television Link Harness RH Rear Seat Lumbar Harness DATE OF ISSUE: April 2003 Symbols and Codes Wiring Color Codes N B W K G R Y Brown Black White Pink Green Red Yellow O S L U P BRD BOF Orange Slate Light Blue Purple Braid Black fiber optic (D2B Network) Code Numbering When numbering connectors, grounds and splices, Jaguar Engineering uses a three-position format: CR001, CR002, etc. Because space is limited in this Electrical Guide the codes have, in most cases, been shortened. Thus CR001-001 becomes CR1-1, CR002-001 becomes CR2-1, etc. 15 Symbols and Codes Jaguar XJ 2004 Grounds There may be up to three eyelets on one ground stud. A, B and C are used to indicate the position of the eyelet on the stud: A – first (bottom), B – second (middle), C – third (top). Two eyelet variations are used: a single eyelet and an eyelet pair. The single eyelet has a single leg, which is identified by an S; the eyelet pair has two legs, identified as L (left) or R (right). S L R SINGLE EYELET EYELET PAIR EXAMPLE: Ground stud number 30 Ground stud number 17 G30AS G17BR Single eyelet Eyelet pair, RH leg First eyelet on stud Second eyelet on stud On figures where LHD and RHD circuits are combined and the ground designation differs from LHD to RHD, the RHD ground is shown in parentheses. If the ground designation is the same for LHD and RHD, only one ground designation is used. EXAMPLE: G30AS (G26AS) LHD Vehicles RHD Vehicles G31BL Same for LHD and RHD Vehicles Relays Serviceable Relays Serviceable relays are located in all three fuse boxes. They do not have a separate relay connector (base). All relays use the ISO pin numbering system – 1, 2, 3, 4, 5. Each relay is identified by an “R” number unique only to the fuse box in which it is located. EXAMPLE: 4 NORMALLY CLOSED V SUPPLY 3 5 SWITCHED POWER (NORMALLY OPEN) V SUPPLY 1 2 SEEKS GROUND R2 CHANGE-OVER RELAY: RELAY PIN NUMBERS AND STANDARD FUNCTIONS Non-Serviceable Relays Non-serviceable relays are located in all three fuse boxes. They are a component part of the fuse box printed circuit board (PCB) and are arranged in singles or pairs. The relays use the ISO pin numbering system – 1, 2, 3, 4, 5 (single relay or top pair relay) and 6, 7, 8, 9, 10 (bottom pair relay). Each relay is identified by an “R” number unique only to the fuse box in which it is located. Pair relays are normally depicted separately. EXAMPLE: R10 R9 4 R9 4 4 3 5 3 5 3 5 1 2 1 2 1 2 8 10 9 SINGLE PCB RELAY 6 9 10 6 7 7 PCB PAIR RELAY 16 R9 8 PCB PAIR RELAY AS DEPICTED DATE OF ISSUE: April 2003 Jaguar XJ 2004 Symbols and Codes Fuses All fuses are located in the fuse boxes. Each fuse is identified by an “F” number unique only to the fuse box in which it is located. EXAMPLE: F17 10A Networks In most instances, networks are shown as a broken grey line to indicate that there is network communication between the depicted control modules. Refer to Figures 20.1, 20.2, 20.3 and 20.4 for circuit details. EXAMPLE: SCP Y S 20.2 MESSAGE(S) MESSAGE(S) 20.2 Y U S S IP10-1 IP5-1 20.2 MESSAGE(S) MESSAGE(S) 20.2 U S IP10-2 IP5-2 CONTROL MODULE CONTROL MODULE Component Depictions EXAMPLE: COMPLETE COMPONENTS AND CONTROL MODULES DATE OF ISSUE: April 2003 INCOMPLETE COMPONENTS (EXCEPT CONTROL MODULES) ASSEMBLIES AND POWER DISTRIBUTION FUSE BOXES COMPONENTS WITH INTERNAL ELECTRONIC CIRCUIT 17 Network Configuration Jaguar XJ 2004 POWER AMPLIFIER TRANSMISSION CONTROL MODULE DRIVER SEAT MODULE ENGINE CONTROL MODULE LH HEADLAMP LEVELING MODULE NAVIGATION CONTROL MODULE DRIVER DOOR MODULE ADAPTIVE SPEED CONTROL MODULE MULTIMEDIA CONTROL PANEL DYNAMIC STABILITY CONTROL MODULE RH HEADLAMP LEVELING MODULE RESTRAINTS CONTROL MODULE GENERAL ELECTRONIC MODULE PARKING BRAKE MODULE REAR ELECTRONIC MODULE VOICE ACTIVATION MODULE CLIMATE CONTROL MODULE CELLULAR PHONE MODULE REAR CLIMATE CONTROL MODULE REAR MEMORY MODULE STEERING COLUMN LOCK MODULE J-GATE MODULE PARKING AID MODULE CD AUTOCHANGER AIR SUSPENSION MODULE INSTRUMENT CLUSTER ROOF CONSOLE AUDIO UNIT NETWORK GATEWAY NETWORK GATEWAY CAN SCP D2B SERIAL DATA LINK DATA LINK CONNECTOR SERIAL DATA LINK CAN NETWORK SCP NETWORK D2B NETWORK NOTE: TYPICAL XJ RANGE NETWORK CONFIGURATION (FULL OPTION SET). REFER TO FIGURES 20.1, 20.2, 20.3, AND 20.4 FOR CIRCUIT DETAILS. 18 DATE OF ISSUE: April 2003 Jaguar XJ 2004 Major Harnesses and Fuse Box Location FRONT POWER DISTRIBUTION FUSE BOX EC – ENGINE COMPARTMENT HARNESS PI – ENGINE MANAGEMENT HARNESS ENGINE CONTROL MODULE (RHD) INSTRUMENT CLUSTER (LHD) IP – INSTRUMENT PANEL HARNESS ENGINE CONTROL MODULE (LHD) PASSENGER JUNCTION FUSE BOX INSTRUMENT CLUSTER (RHD) CR – CABIN HARNESS FRONT DOOR HARNESS: DD – DRIVER DOOR (LHD) PD – PASSENGER DOOR (RHD) FRONT DOOR HARNESS: DD – DRIVER DOOR (RHD) PD – PASSENGER DOOR (LHD) RL – RH REAR DOOR HARNESS RR – RH REAR DOOR HARNESS BO – BATTERY HARNESS TL – TELEMATICS HARNESS CR – CABIN HARNESS BATTERY REAR POWER DISTRIBUTION FUSE BOX DATE OF ISSUE: April 2003 19 Relay and Fuse Location Jaguar XJ 2004 F19 25A F1 10A F20 30A F12 10A F4 30A R9 * R10 * R11 * R12 * R13 * R14 * F13 10A F14 10A F6 40A F22 30A F30 10A F31 15A F24 20A F32 40A F7 40A F16 20A F25 15A F33 30A F8 20A F17 10A F26 40A F34 30A F9 20A F18 15A R3 R1 R4 R2 R6 R7 R5 R8 F35 80A R1 * F14 10A F13 20A F12 10A FRONT POWER DISTRIBUTION FUSE BOX * NON-SERVICEABLE PCB RELAYS F49 40A F42 10A F28 10A F11 5A F48 20A F41 20A F27 10A F10 5A F47 5A F40 10A F26 15A F9 10A F46 25A F39 5A F25 10A F8 5A F4 5A F45 10A F38 15A F24 10A F7 5A F3 5A F44 5A F37 25A F2 5A F43 5A F36 40A F1 10A F35 10A F34 5A F20 5A F33 5A F19 5A F19 30A F27 10A F32 5A F11 5A F20 10A F28 25A F31 15A F17 5A F12 10A F21 25A F30 10A F16 5A F29 10A F15 5A R5 * R6 * R7 * R8 * F13 20A F5 40A F22 10A F30 10A F31 40A F6 10A F15 5A F24 20A F32 30A F7 40A F16 10A F25 15A F33 20A F8 10A F17 10A F26 15A F34 30A F9 25A F18 10A R3 R1 PASSENGER JUNCTION FUSE BOX * NON-SERVICEABLE PCB RELAY R4 R2 F43 15A F47 20A F53 20A F54 15A F51 10A F48 5A F52 20A F49 5A F44 15A F40 25A F46 10A REAR POWER DISTRIBUTION FUSE BOX * NON-SERVICEABLE PCB RELAYS 20 DATE OF ISSUE: April 2003 Jaguar XJ 2004 EC4 EC19 Fuse Box Connectors EC28 EC26 EC32 EC41 EC22 EC35 EC5 CR6 EC40 CR47 CR48 FRONT POWER DISTRIBUTION FUSE BOX CR56 CR80 CR81 CR82 CR49 EC7 EC55 CR68 PASSENGER JUNCTION FUSE BOX CR83 CR98 CR5 CR84 CR3 CR97 REAR POWER DISTRIBUTION FUSE BOX DATE OF ISSUE: April 2003 21 Harness and In-Line Connector Location Jaguar XJ 2004 Instrument Panel and Seat Harnesses INSTRUMENT PANEL HARNESS LHD: RHD: IP1 IP2 IP3 IP4 IP9 IP17 IP22 IP51 IP58 IP1 IP8 IP9 IP22 IP51 IP55 IP58 RHD: IP8 IP55 LHD: IP2 IP3 IP4 IP17 CC10 TL22 LHD: SD1 SD16 SD28 RHD: SP16 SP28 LH FRONT SEAT HARNESS (DRIVER / PASSENGER) LS1 LS11 SR4 LH REAR SEAT HARNESS 22 RHD: SD1 SD16 SD28 LHD: SP1 SP16 SP28 RH FRONT SEAT HARNESS (DRIVER / PASSENGER) RS1 RS11 SL4 RH REAR SEAT HARNESS DATE OF ISSUE: April 2003 Jaguar XJ 2004 Harness and In-Line Connector Location Small Harnesses RF25 LHD: DD1 DD3 RHD: PD1 PD16 LHD: DT1 DT6 RHD: RF1 RHD: DD1 DD3 LHD: PD1 PD16 RHD: DT1 DT6 LHD: PT1 PT1 RL1 RL9 RR1 RR9 LT1 RT1 FP2 FP6 RF2 RF26 BL11 CV1 CV5 BT11 DATE OF ISSUE: April 2003 23 Harness and In-Line Connector Location Jaguar XJ 2004 Telematics Harness CC1 CC2 CC3 CC4 CC5 CC6 CC7 TL22 TL28 TL31 TL95 TL93 RF26 TL55 TL14 TL35 24 DATE OF ISSUE: April 2003 Jaguar XJ 2004 G1 Ground Point Location G3 G2 G4 ENGINE BLOCK GROUND G30 G26 G8 G32 (LHD), G31 (RHD) G32 (RHD), G31 (LHD) G9 G10 G7 G15 G12 G13 G18 G17 G16 (IN ROOF) ANTENNA GROUND POINTS G25 G24 G22 G29 DATE OF ISSUE: April 2003 G23 25 Control Module Location Jaguar XJ 2004 LHD NOTE: THE TRANSMISSION CONTROL MODULE IS CONTAINED WITHIN THE TRANSMISSION. ADAPTIVE SPEED CONTROL MODULE LH HEADLAMP LEVELING MODULE RH HEADLAMP LEVELING MODULE DYNAMIC STABILITY CONTROL MODULE STEERING COLUMN LOCK MODULE ENGINE CONTROL MODULE FRONT ELECTRONIC MODULE CLIMATE CONTROL MODULE INSTRUMENT CLUSTER RESTRAINTS CONTROL MODULE AUDIO UNIT DRIVER DOOR MODULE CLIMATE CONTROL PANEL SLIDING ROOF MODULE DRIVER SEAT MODULE OCCUPANCY SENSING MODULE J-GATE MODULE REAR CLIMATE CONTROL MODULE MULTIMEDIA CONTROL PANEL REAR MEMORY MODULE AUDIO / VIDEO SELECTOR AIR SUSPENSION MODULE PARKING BRAKE MODULE POWER AMPLIFIER VEHICLE INFORMATION CONTROL MODULE DVD PLAYER (TOP) NAVIGATION CONTROL MODULE CD AUTOCHANGER VOICE ACTIVATION MODULE CELLULAR PHONE MODULE (BOTTOM) FULL OPTION SET SHOWN. FUEL PUMP 2 MODULE REAR ELECTRONIC MODULE TRAILER TOWING MODULE PARKING AID MODULE 26 DATE OF ISSUE: April 2003 Jaguar XJ 2004 Control Module Location RHD NOTE: THE TRANSMISSION CONTROL MODULE IS CONTAINED WITHIN THE TRANSMISSION. ADAPTIVE SPEED CONTROL MODULE RH HEADLAMP LEVELING MODULE LH HEADLAMP LEVELING MODULE DYNAMIC STABILITY CONTROL MODULE ENGINE CONTROL MODULE CLIMATE CONTROL MODULE FRONT ELECTRONIC MODULE STEERING COLUMN LOCK MODULE INSTRUMENT CLUSTER RESTRAINTS CONTROL MODULE AUDIO UNIT DRIVER DOOR MODULE CLIMATE CONTROL PANEL SLIDING ROOF MODULE DRIVER SEAT MODULE OCCUPANCY SENSING MODULE J-GATE MODULE REAR CLIMATE CONTROL MODULE MULTIMEDIA CONTROL PANEL REAR MEMORY MODULE AUDIO / VIDEO SELECTOR AIR SUSPENSION MODULE PARKING BRAKE MODULE POWER AMPLIFIER VEHICLE INFORMATION CONTROL MODULE DVD PLAYER (TOP) NAVIGATION CONTROL MODULE CD AUTOCHANGER VOICE ACTIVATION MODULE CELLULAR PHONE MODULE (BOTTOM) FULL OPTION SET SHOWN. FUEL PUMP 2 MODULE REAR ELECTRONIC MODULE TRAILER TOWING MODULE PARKING AID MODULE DATE OF ISSUE: April 2003 27 28 V8 SC V8 N/A V6 56 RW 30 B 29 B 2 RU 82 B 1 RU 3 — 3 — 57 — 83 R 31 GR 57 YU 83 R 4 B 4 B 84 Y 32 — 32 — 5 B 5 B 85 — 33 — 33 — 59 YR 111 B 5 B 85 — 33 — 59 — 85 — 59 YR 111 B 58 YG 110 YU 31 GR 84 Y 32 — 58 — 84 Y 111 B 58 YG 110 YU 57 YU 83 R 4 B 110 YU 31 GR 109 Y 55 RW 108 N 107 G 81 B 2 RU 30 B 29 B 1 RU 3 — 109 Y 56 RW 82 B 55 RW 108 N 81 B 107 G 30 B 2 RU 1 RU 29 B 82 B 109 Y 56 RW 81 B 108 N 55 RW 107 G 6 Y 86 — 34 — 34 — 7 GO 7 GO 35 — 8 GO 61 GW 88 Y 36 O 36 O 9 U 9 U 37 B 10 GU 90 GR 10 GU 38 OY 64 YR 11 — 11 Y 66 UY 66 UY 92 UY 40 BW 12 OY 13 Y 13 Y 67 — 93 RW 93 RW 41 GO 67 O 14 — 14 U 120 BG 41 GO 67 O 14 — 120 BG 41 GO 119 BO 40 BW 12 OY 13 Y 119 BO 92 UY 118 U 39 OG 65 — 91 B 12 OY 40 BW 66 UY 120 BR 93 RW 119 BO 92 UY 118 U 39 OG 65 — 91 B 39 OG 117 BW 38 OY 64 YR 11 — 91 B 118 U 65 WR 117 BW 90 GR 116 B 63 GR 89 YR 115 BR 9 U 37 B 10 GU 116 B 63 GR 89 YR 37 B 64 — 90 — 117 — 38 OY 116 B 63 GR 89 YR 115 BR 62 GW 114 BK 8 GO 87 GU 113 BG 7 GO 35 — 61 GW 88 Y 36 O 62 GW 114 BK 8 GO 87 GU 35 — 61 GW 88 Y 115 BG 62 GW 114 BK 87 GU 113 BG 60 YU 112 UY 6 Y 86 — 34 — 60 — 86 — 113 BG 60 YU 112 UY 6 Y 112 — PI1 / BLACK PI1 15 — 121 WU 15 — 121 WU 15 — 121 WU 42 — 68 N 94 Y 42 — 68 N 94 Y 42 — 68 N 94 Y 16 — 69 G 95 R 17 B 17 B 18 B 44 GW 70 UY 18 B 71 U 97 — 45 BK 71 U 97 — 45 BK 71 U 97 — 45 BK 124 Y 44 GW 96 — 18 B 124 Y 70 UY 96 — 44 GW 123 G 43 BG 69 G 95 R 17 B 96 — 124 Y 70 UY 123 G 43 BG 122 — 16 — 69 G 95 R 123 G 43 BG 122 — 16 — 122 — ENGINE CONTROL MODULE 19 BG 72 — 98 N 46 BK 20 BG 73 U 99 N 47 YR 73 U 99 N 47 YR 126 — 20 BG 73 U 99 N 47 YR 126 — 20 BG 126 — 72 YU 98 N 46 BK 125 — 19 BG 72 — 98 N 46 BK 125 — 19 BG 125 — 21 — 22 NR 48 YG 74 — 49 — 75 R 49 — 75 R 76 Y 23 WG 51 WU 77 — 25 — 25 — 78 Y 104 RG 104 RG 52 GR 78 Y 53 YR 26 — 26 — 54 B 80 GW 27 WR 53 WU 79 YR 28 — 28 — 134 GU 106 RW 133 — 54 B 80 GW 27 WR 105 W 53 — 79 YR 28 — 134 GU 106 RW 133 — 54 B 80 GW 27 WR 105 W 132 YB 52 GR 78 Y 26 — 79 YR 132 YB 52 GR 131 GB 103 O 130 BW 24 WG 50 YR 76 Y 77 — 51 WU 24 WG 102 B 129 N 23 WG 50 YR 76 Y 25 — 131 GB 103 O 130 BW 102 B 129 N 77 — 51 WU 24 WG 50 WU 23 WG 101 — 22 NR 100 BG 49 — 75 R 101 — 128 N 48 YG 74 — 100 BG 127 BK 21 — 22 NR 128 N 48 YG 127 BK 21 — 74 — 134 GU 106 RW 133 — 105 W 132 YB 104 — 131 GB 103 O 130 BW 102 B 129 N 101 — 128 N 100 BG 127 BK Control Module Pin Identification Jaguar XJ 2004 DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 12 YR 25 GR 13 BG 26 WG 24 BR 11 RW 23 YB 10 NB 22 NR 9 RB 21 R 8 W 20 N 7 Y 19 UY 6 GR AC101 / BLACK 16 BW 8 GB 15 UB 7 RG 14 U 6 GW 13 B 5 G 12 YW 4 O 11 UW 3 O AC100 / BLACK 10 LG 2 NR 9 U 1 UY REAR CLIMATE CONTROL MODULE 14 WU 1 U 22 B 11 RW 21 GW 10 RU 20 YG 9 RW 7 RG 8 N 9 — 10 GU 11 YU 12 GB 1 B 2 — 3 RW 4 OY 5 O 6 YG 3 Y 2 YB 1 UY 10 — 9 G 4 — 5 — 6 — 7 — 8 Y 11 U 12 BW 13 WB 14 W 15 — 16 G RA1 / BLACK 15 R 2 G RA2 / BLACK 16 RU 3 RG CR119 RA1 17 RW 4 GU AC100 RA2 18 B 5 — AC101 CLIMATE CONTROL MODULE 19 OY 8 Y 18 BW 7 G 17 G 6 Y 16 Y 5 B CR119 / BLACK 15 — 4 RG 14 — 3 WG 13 — 2 N 12 — 1 — Jaguar XJ 2004 Control Module Pin Identification 29 30 2 RU 15 RW 14 RU 16 BG 3 B 17 YR 4 BO 18 Y 5 W 19 GU 6 OY 20 — 7 GW 21 — 8 RG CR52 / BLACK 22 — 9 OG 23 WR 10 WU 24 W 11 WG 25 YR 12 YU 3 Y 19 BG 26 Y 13 YR 34 WU 18 YU 33 NG 17 RW 2 — 35 — 4 W 21 — 36 WR 20 GU 5 BK 37 NR 6 U 22 — 38 — 23 — 39 — 8 UY 24 B 40 U 9 U 25 U 41 — 10 — EC30 / BLACK 7 R 26 G 42 N 11 Y 27 YU 13 G 43 W 44 — 28 WG 12 Y 14 G 31 BW 15 G 46 NG 30 YR 45 WG 29 Y CR50 3 RW 1 NW 4 B 2 GW 6 RW 12 WU 5 WU 11 — 4 YB 10 Y 3 — 9 — 2 — 8 — CR32 / GREY CR32 PARKING BRAKE MODULE CR50 / BLACK 47 B 16 B TOP 1 WR CR52 PARKING AID MODULE 32 NW 1 NR EC30 DYNAMIC STABILITY CONTROL MODULE 1 Y 7 U Control Module Pin Identification Jaguar XJ 2004 DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 4 — 5 — 6 — 1 NW 2 N 3 B 9 — 8 G 7 Y CR88 / BLACK CR88 6 WG 5 WU 9 — 8 BO 7 — 12 NR 11 U 10 YU 15 — 14 GO 13 — CR91 / BLACK 4 — 18 BK 17 G 16 Y 3 GB 2 GU 1 G CR90 6 GR 5 GW 4 GO 9 BK 8 BR 7 BW 12 YU 11 YG 10 YR CR90 / BLACK 15 BK 14 G 13 Y CR89 2 B 8 — 1 NW 7 WU 9 — 3 — 10 Y 4 G 11 — 5 — EC23 / BLACK EC23 12 U 6 R ADAPTIVE SPEED CONTROL MODULE 3 WB 2 WR 1 YG CR91 AIR SUSPENSION MODULE 3 Y 2 BK 1 BO 6 — 5 WU 4 WR 9 — 8 WB 7 WG 12 — 11 BG 10 BG CR89 / BLACK — Jaguar XJ 2004 Control Module Pin Identification 31 32 11 RW 12 RW 1 NW 2 BK 13 Y 3 GO 14 B 15 U 5 — 16 YB 18 RW 7 BG 17 WU 6 YU CR85 / BLACK 4 BW 8 G 19 WU 9 YR 20 Y 10 WB 14 R 16 WG 2 GW 15 RU 1 GU 3 R 17 WG 18 WB 4 YB 5 G 9 R 1 OY 10 BR 2 W 7 OY 20 OG 6 WG 11 B 21 O 22 U 23 OY 10 — 24 OG 11 O 3 — 12 — 4 BW 13 B 5 — 14 B 26 B 15 BO 7 RU 16 RU CR10 25 UY 12 RW CR9 6 WB CR10 / BLACK 8 WU 9 U CR1 CR1 / BLACK 19 WB CR85 8 RU 17 RU 13 RW FRONT ELECTRONIC MODULE 7 Y 1 U 9 — 3 BW 10 — 4 — 11 O CR9 / BLACK 2 OG 8 WU EC36 5 — 12 B 6 NW 12 — 1 BR 13 BR 2 U 14 — 3 BW 15 U 4 — 16 BG 5 NR 17 BG 18 UY 6 WU 7 BK 19 BG EC36 / BLACK 21 RW 9 GU 20 GW 8 YR 10 B 22 BW 11 — Control Module Pin Identification Jaguar XJ 2004 DATE OF ISSUE: April 2003 11 YG 1 Y 12 YG 2 YB 13 — 3 NW DATE OF ISSUE: April 2003 14 — 17 GW CR73 16 WU 6 OY 7 O 2 B 4 Y 1 N 3 R CR73 / BLACK 15 WR 5 GU CR4 / BLACK 4 RW 18 — 10 WG 20 RG 9 WB 19 UY 8 WB 14 — 1 — 15 — 2 — 16 GW 3 RU 17 OY 4 R 18 OG 5 U CR4 19 N 6 YB 20 — 7 Y 21 OY 9 GO 22 RU 8 OG CR11 / NATURAL CR11 23 BK 10 BO 24 — 11 B 25 B 12 B CR12 26 B 13 WU REAR ELECTRONIC MODULE 7 G 1 YR 8 GU CR13 2 R 9 RG 3 — 10 — 4 — 10 UY 2 — 6 OG 12 OY 1 UY 5 U 9 OG 11 RW CR12 / BLACK 11 W 13 GO 2 U 14 WG 3 U 12 O 4 O 13 — 5 GB 14 — CR71 / BLACK 12 B 1 Y 6 G 3 — 15 B 7 RU 16 RU 8 RU 5 — 17 RU 17 WG 6 N 18 — 7 — 19 — CR13 / BLACK 16 WR CR71 15 OY 4 — 8 GR 20 GR 9 YG 21 — 22 GW 10 YU 11 — Jaguar XJ 2004 Control Module Pin Identification 33 34 11 BG 9 Y 20 — 7 R 6 — 17 — 5 OG 18 BR 6 YB 17 Y 5 RW 16 NW 4 G 16 — IP5 / GREY 18 — IP7 / BLACK 19 — 7 GR 19 UY 8 YR 8 GO 20 GW 9 GU 21 WB 22 — 10 — 10 GO 21 — 11 — 22 — IP7 IP5 14 B 13 — 12 GO 12 W 1 YU 1 WU 13 WR 2 RW 2 WG 14 YU 3 GR 3 BW 15 BO 4 YG 15 — INSTRUMENT CLUSTER 20 Y 19 G 18 Y 17 WB 16 W 15 RW 14 RG 13 GB 12 U 11 R 10 U 9 G 8 Y 7 — 6 GR 5 WR 4 BG 3 O 2 B 1 OY IP6 / BLACK IP6 Control Module Pin Identification Jaguar XJ 2004 DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 12 WB 25 WB 12 — 25 — 13 NG 26 BK 13 — 26 — 24 — 11 — 24 — 11 WB 9 — 22 — 23 — 22 WU 23 WR 10 — 9 WU 10 R CR37 20 — 7 O 11 — 1 OY 19 — 6 — 21 — 8 — 20 — 7 — 19 — 6 — CR37 / BLACK 21 — 8 U SD4 / BLACK SD4 18 — 5 — 12 — 2 OG 18 — 5 — 17 — 4 — 13 N 14 OY 16 — 3 — 16 — 3 — CR38 3 OG 17 — 4 — SD2 14 — 1 — 4 O 15 — 2 — 15 O 16 R 14 — 1 — 5 WU 6 U 17 O 11 GB 22 — 11 — 18 R 22 WR 7 — DD11 / BLACK 15 — 2 — 19 U 21 — 10 — 8 YB 21 O 10 RW 20 G 20 — 9 — 9 Y 20 YR 9 — 19 — 8 — 10 YG 18 YB 7 — 14 YR 16 WG 5 UY 18 — 7 — 15 RU 4 U 14 — 3 — 13 — 2 — 12 U 1 Y 1 — 15 Y 17 — 6 — 16 — 5 — 16 OY 3 GU 17 O 4 — 18 — 5 — 19 — 6 G 20 — 7 WR 21 G 8 YB DD12 / BLACK DD13 22 BR 9 — 23 — 15 — 4 — 14 — 3 — 13 — 2 — 12 — 1 — REAR MEMORY MODULE 2 GW DD12 DRIVER DOOR MODULE 17 Y 6 — CR36 / BLACK DD11 19 N 8 — SD2 / BLACK DRIVER SEAT MODULE CR41 24 — 11 — 13 GW 26 — 1 GO 12 UY 25 GO 3 — 5 B 2 OG 4 — 3 — 6 — 5 — 1 — 2 — CR41 / BLACK 10 O 4 — 6 NR SD3 / BLACK SD3 8 B 2 RU 9 — 3 — 4 — 1 — 2 — 3 Y 10 OY 4 U SD26 CR53 12 N 6 YR 1 — 2 — 3 — 4 — 1 — 2 — CR53 / BLACK 11 NW 5 R 3 U 4 GU SD26 / BLACK DD13 / NATURAL 1 YU 2 UY CR21 / BLACK CR21 7 BK 1 — 3 RU 4 YR SD24 / BLACK SD24 CR59 3 GW 4 GO 1 B 2 NG 5 — 6 — 3 — 4 — 1 — 2 — CR59 / BLACK 5 RG 6 GR SD27 / BLACK SD27 Jaguar XJ 2004 Control Module Pin Identification 35 Fig. 01.1 COMPONENTS Component Connector(s) Connector Description Location BATTERY — — TRUNK / RH SIDE FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / 4-WAY / 8-WAY / 4-WAY / 8-WAY / 12-WAY 4-WAY / 8-WAY / 8-WAY / 10-WAY IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN MEGAFUSES — — TRUNK / RH SIDE PASSENGER JUNCTION FUSE BOX CR6 CR47 CR48 CR49 CR56 EC7 EC55 10-WAY 11-WAY 11-WAY 10-WAY 10-WAY 15-WAY 11-WAY / / / / / / / REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / 4-WAY / 8-WAY / 4-WAY / 8-WAY / 12-WAY 4-WAY / 8-WAY / 8-WAY / 10-WAY BLACK BLACK BLACK BLACK BLACK / BLACK BLACK BLACK BLACK / BLACK TRANSIT ISOLATION RELAY CR95 2-WAY / WHITE BLACK BLACK BLACK BLACK BLACK / BLACK BLACK BLACK BLACK / BLACK ENGINE COMPARTMENT / RH FRONT BLACK BLACK BLACK BLACK BLACK BLACK BLACK CABIN / RH ‘A’ POST TRUNK / RH REAR TRUNK / ADJACENT TO BATTERY HARNESS IN-LINE CONNECTORS Connector Connector Description Location CR117 2-WAY / GREY / CABIN HARNESS INTERCONNECT TRUNK / ADJACENT TO BATTERY IP1 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND DRIVER SIDE INSTRUMENT PANEL END PLATE IP58 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) GROUNDS Ground Location BC1 TRUNK / RH SIDE / ADJACENT TO BATTERY BC3 TRUNK / RH SIDE / ADJACENT TO BATTERY G23 TRUNK / RH SIDE / ADJACENT TO BATTERY Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Main Power Distribution B 500 A B 5 02.1 02.2 6 05.3 08.6 BO11 BO3 B Fig. 01.1 Main Power Distribution R R BC2 BO1 B 175 A BO2 BO3 CR19 BC1 R BATTERY BC3 100 A B GO B CRS23 CR95-1 CR115 MEGAFUSES CR95-2 G23AL TIMER NW NW CRS72 CR95-2 20A TRANSIT ISOLATION RELAY CR116 B CR17 EC8 BO4 EC9 1 2 3 CR48-11 0 YU YU IP34-6 NW CR48-10 IP1-2 NW CR117-B F39 5A NW CR117-A CR97-8 F52 20A I RU 4 IP34-4 II III IGNITION SWITCH RU CR6-4 F41 20A PASSENGER JUNCTION FUSE BOX 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground BATTERY POWER BUS BATTERY POWER BUS BATTERY POWER BUS IP58-14 FRONT POWER DISTRIBUTION FUSE BOX A ACP S SCP C CAN D Serial and Encoded Data REAR POWER DISTRIBUTION FUSE BOX VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 01.2 COMPONENTS Component Connector(s) Connector Description Location FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE PI42 8-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE RL1 6-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST RR1 6-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST SD1 4-WAY / GREY / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SP1 4-WAY / GREY / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT TL14 14-WAY / GREY / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER TL35 22-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 2 NR NR NR EC40-2 F17 10A PI41-31 PIS16 NR NR 8 9 03.1 03.3 (RHD) BO4 03.5 NW 04.1 NR 10 (LHD) NR CR83-1 F5 40A 05.1 SPS1 SP1-2 (LHD) SD1-2 (RHD) 05.1 NR N NG 11 13.1 F9 25A CR84-2 12 13.1 F21 25A CR80-3 13 13.1 F27 10A CR68-2 F28 25A CR68-4 NR F26 40A NW NW 03.2 03.4 03.6 NG NG NG F30 10A CR68-1 F31 40A CR5-4 F32 30A CR5-2 NG EC46-12 (LHD) EC53-6 (RHD) 15 19.2 CRS24 NG NG NG 16 19.2 17 08.1 08.2 18 08.1 08.2 19 08.1 08.2 20 08.1 08.2 21 08.1 08.2 22 08.1 08.2 23 13.1 52 01.7 24 13.1 53 01.7 25 01.8 54 01.7 26 01.8 55 01.7 27 03.1 56 01.7 28 01.8 57 01.7 29 01.8 58 06.2 30 02.1 59 03.2 31 05.3 60 06.2 32 06.2 61 01.4 33 06.2 62 19.2 34 01.4 63 19.2 CR5-3 NR TLS2 TL14-14 CR3-4 F40 25A NR NR NR R R CR97-3 TL35-3 TLS20 R R CC1-15 03.5 02.2 01.8 03.4 03.6 BATTERY POWER BUS 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II REAR POWER DISTRIBUTION FUSE BOX Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground 11.6 37 11.6 38 19.2 A ACP S SCP C CAN D 39 11.8 40 11.9 41 15.1 15.2 42 14.1 43 02.2 44 12.2 45 11.1 11.2 11.3 50 16.5 16.6 16.7 51 16.5 16.6 16.7 46 05.2 47 15.2 48 15.2 49 14.1 RR1-1 R F51 10A 7 NW NR F34 30A 1 SP1-1 (LHD) SD1-1 (RHD) NR FRONT POWER DISTRIBUTION FUSE BOX 11.5 PI42-6 NG 03.3 36 11.4 RL1-1 EC56 F35 80A 11.3 TL14-10 NG 14 11.2 CR83-2 F6 10A NG 35 11.1 NOTE: SPS1 – Rear Passenger override only. N EC4-2 F22 30A NR NR EC4-1 F20 30A Fig. 01.2 Battery Power Distribution: Part 1 3 7 BATTERY POWER BUS EC8 Battery Power Distribution: Part 1 Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 11.4 11.5 11.6 Fig. 01.3 COMPONENTS Component Connector(s) Connector Description Location PASSENGER JUNCTION FUSE BOX CR6 CR47 CR48 CR49 CR56 EC7 EC55 10-WAY / BLACK 11-WAY / BLACK 11-WAY / BLACK 10-WAY / BLACK 10-WAY / BLACK 15-WAY / BLACK 11-WAY / BLACK CABIN / RH ‘A’ POST HARNESS IN-LINE CONNECTORS Connector Connector Description CC7 10-WAY / GREY / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE CR78 2-WAY / BLACK / BRAKE ON/OFF SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST IP1 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND DRIVER SIDE INSTRUMENT PANEL END PLATE IP22 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP51 10-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST RC2 8-WAY / BLACK / TELEMATICS HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS CABIN / BELOW CENTER CONSOLE SD1 4-WAY / GREY / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SP1 4-WAY / GREY / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT TL31 14-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Battery Power Distribution: Part 2 Battery Power Distribution: Part 2 1 CR116 RW RW RW RW CR49-5 F30 10A RW RW RW NOTE: TLS17 – Existence dependent on option specification. RW RCS1 RW CR49-6 F35 10A CR49-3 F36 40A CR49-4 NG NR F37 25A CR49-1 F38 15A CR47-10 NG SD1-1 (LHD) SP1-1 (RHD) NR NW 66 16.3 16.4 73 11.3 11.4 11.5 11.6 74 11.1 11.2 11.3 11.4 11.5 11.6 75 14.1 NW TL31-7 76 15.1 NG CR47-3 15.2 CC7-10 NG 77 12.2 IP22-9 NW NW NW NW 78 01.6 01.7 03.2 03.4 03.6 07.1 08.3 79 09.1 10.1 10.2 11.1 12.1 12.2 14.1 80 01.6 01.7 08.1 08.2 09.1 11.7 12.1 82 20.1 20.2 20.3 83 03.1 03.3 03.5 08.3 11.4 11.5 11.6 08.1 08.2 08.3 09.2 09.3 10.1 89 11.1 11.2 11.3 90 11.4 11.5 11.6 09.1 10.2 11.10 12.1 12.2 14.1 19.1 12.2 14.1 DD1-9 CRS12 CR47-4 F42 10A 16.4 DD3-1 NW F40 10A 16.3 72 14.1 NW SD28-11 (LHD) SP28-11 (RHD) 16.2 71 16.7 NG NW 65 16.1 70 15.3 RW F31 15A 16.4 69 15.3 RW NG 16.3 68 15.3 RW RC2-1 16.2 67 15.3 TLS17 TL93-16 64 16.1 NW NW NW 81 19.1 IP1-1 NW NW CR6-8 F43 5A IP51-3 NG NG CR6-2 F44 5A CR78-1 NW 84 19.2 NW CRS81 CR6-6 F45 10A NW NR F46 25A CR6-1 F47 5A CR6-7 NW SP28-11 (LHD) SD28-11 (RHD) 86 14.1 PD1-1 O O 87 07.1 IP22-3 OY OY CR6-5 F48 20A 85 11.3 NR 88 10.1 IP22-4 (LHD) NR NR NR NR CR6-10 F49 40A SD1-2 (LHD) SP1-2 (RHD) (RHD) SPS1 NR 91 11.6 BATTERY POWER BUS NOTE: SPS1 – Rear Passenger override only. 92 1.06 93 1.06 94 1.06 95 1.06 PASSENGER JUNCTION FUSE BOX 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 01.3 Fig. 01.4 COMPONENTS Component Connector(s) Connector Description Location FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN PASSENGER JUNCTION FUSE BOX CR6 CR47 CR48 CR49 CR56 EC7 EC55 10-WAY / BLACK 11-WAY / BLACK 11-WAY / BLACK 10-WAY / BLACK 10-WAY / BLACK 15-WAY / BLACK 11-WAY / BLACK CABIN / RH ‘A’ POST REAR IGNITION RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R2 REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR SLAVE IGNITION RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R9 HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST IP22 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP51 10-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP58 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP66 14-WAY / GREY / INSTRUMENT PANEL HARNESS TO REAR AIR CONDITIONING HARNESS CABIN / BELOW CENTER CONSOLE RC2 8-WAY / BLACK / TELEMATICS HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS CABIN / BELOW CENTER CONSOLE TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE GROUNDS Ground Location G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G23 TRUNK / RH SIDE / ADJACENT TO BATTERY Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Ignition Switched Power Distribution: Part 1 Fig. 01.4 Ignition Switched Power Distribution: Part 1 1 CR116 F41 20A RU RU CR6-4 IP58-14 YB YB 0 YB CRS34 CR56-7 F7 5A 1 19.2 2 19.2 I CR98-7 I CR98-6 REAR POWER DISTRIBUTION FUSE BOX I 4 RU Y IP34-4 IP34-2 Y YB CR56-5 IP51-1 II YG CR56-8 F8 5A YG IP22-5 YR III YR CR48-4 F11 5A YR TL28-5 YR CCS1 CC2-5 YR YR CC1-6 YU IGNITION SWITCH 3 I 19.2 4 I 02.1 02.2 5 I 15.1 15.2 6 I 15.1 15.2 7 16.1 16.2 8 I 16.3 16.4 9 I 16.7 10 I 15.3 11 I 16.5 16.6 16.7 12 16.5 16.6 16.7 I YU YU CR49-9 F20 5A YU TLS1 TL93-14 YU NOTE: TLS1 – Existence dependent on option specification. YU YU RC2-6 R R CR49-10 F34 5A R TL93-15 TLS10 R R I CC1-16 07.1 12.2 16.3 16.4 PASSENGER JUNCTION FUSE BOX EC8 GU 2 R9 34 3 GU 4 GU 5 EC28-4 F1 5A 1 42 ECS19 GU 01.8 01.8 R ENGINE MANAGEMENT CIRCUITS F54 15A R2 61 01.8 2 CR98-9 EC46-1 SLAVE IGNITION RELAY* CR97-1 RG IP51-5 B CR82-2 REAR IGNITION RELAY B ECS4 RG F53 20A 1 WR GU IP66-7 B CRS23 G23AL REAR POWER DISTRIBUTION FUSE BOX EC28-6 FRONT POWER DISTRIBUTION FUSE BOX *NOTE: Refer to Fig. 01.8 for complete Slave Ignition Relay circuit details. 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data 13 19.1 II RG 14 06.3 II RG 15 06.3 II RG G2AR 1 R IP51-9 4 5 2 II B 3 CR97-2 VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 RAS1 Fig. 01.5 COMPONENTS Component Connector(s) Connector Description Location FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN INERTIA SWITCH CR2 3-WAY / GREY LH ‘A’ POST PASSENGER JUNCTION FUSE BOX CR6 CR47 CR48 CR49 CR56 EC7 EC55 10-WAY / BLACK 11-WAY / BLACK 11-WAY / BLACK 10-WAY / BLACK 10-WAY / BLACK 15-WAY / BLACK 11-WAY / BLACK CABIN / RH ‘A’ POST REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR HARNESS IN-LINE CONNECTORS Connector Connector Description CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE CR77 2-WAY / BLACK / BRAKE CANCEL SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY CR120 8-WAY / BLACK / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL / LH SIDE EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING IP1 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND DRIVER SIDE INSTRUMENT PANEL END PLATE IP4 14-WAY / GREEN / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP22 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP58 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT TL14 14-WAY / GREY / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE TT5 DATA NOT AVAILABLE TT10 2-WAY / GREY / TRAILER TOWING HARNESS TRUNK / SPARE WHEEL WELL Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Ignition Switched Power Distribution: Part 2 1 GR CR116 RU GO ECS1 GO CR6-4 IP58-14 GR 16 02.1 II GO 17 12.2 II GO 18 03.1 II GO 19 07.1 II WU 20 17.1 II WU 21 17.2 II WU 22 17.2 II IP55-19 F41 20A 4 Ignition Switched Power Distribution: Part 2 GO EC7-7 F15 5A EC1-1 PI41-32 GO IP55-14 0 RU RU IP8-8 WU EC55-10 I EC55-3 F29 10A WU WU CRS70 EC1-2 RU IP58-8 WU SP28-4 IP34-4 II 02.2 07.1 03.3 03.5 WG RU IP34-7 RU RU IPS15 IP4-1 12.2 WG CR81-7 EC1-15 GB CR2-2 CR2-3 III WG WG CR56-4 WG IPS45 IP8-12 INERTIA SWITCH WG WG 24 06.1 II WG 25 06.1 II CR120-2 ECS14 EC55-1 F1 10A IGNITION SWITCH WG CC10-9 REAR POWER DISTRIBUTION FUSE BOX WG EC41-7 WG EC53-8 (LHD) EC1-5 (RHD) WG WG 28 03.2 II WU 29 05.4 II WU 30 05.4 II WU 31 11.8 II WU 32 11.9 II CR77-1 WU IP8-6 NOTE: ECS12 – Adaptive Speed Control vehicles only. WU WU CRS27 CR56-3 F3 5A 27 06.1 II ECS12 EC55-2 F2 5A WG WG 03.6 YB 33 05.2 II NG 34 11.10 II NG 35 11.7 II WU 36 10.2 II YB 37 08.2 II 08.6 WB 38 08.2 II 08.6 TLS54 NG NG CC2-7 CL3-4 WU RF1-6 WU WU ECS2 EC1-8 WB F4 5A CR56-9 F16 5A CR49-2 WB 39 05.2 II GO 40 20.1 II W 41 05.1 II IP22-6 GO IP1-8 EC7-1 F17 5A 20.2 19.1 20.3 GU EC28-3 GU GU ECS33 EC7-3 F19 5A GU 43 03.1 II 03.3 03.5 GU 44 03.2 II 03.4 03.6 WR 45 12.2 II WR 46 18.1 II WR 47 08.4 II 08.5 WR 48 16.3 II 16.4 WR 49 16.1 II 16.2 PI41-15 GU EC46-14 WR CRS39 CR49-7 F32 5A WR WR TT10-1 WR TT5-1 WR TLS57 TL14-8 CR49-8 16.3 F33 5A GO GO GO EC1-21 GO PI41-13 PASSENGER JUNCTION FUSE BOX 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage GO 50 04.1 II 05.1 GO 51 02.1 II 02.2 GO 52 02.1 II 02.2 GB1-7 PIS26 01.8 16.4 IP22-10 CRS42 42 01.4 II FRONT POWER DISTRIBUTION FUSE BOX GO GO 26 06.2 II FRONT POWER DISTRIBUTION FUSE BOX 03.4 WU TL93-13 23 06.2 II 04.1 NOTE: GB1-7 – V6 only. + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 01.5 Fig. 01.6 COMPONENTS Component Connector(s) Connector Description Location FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST PASSENGER JUNCTION FUSE BOX CR6 CR47 CR48 CR49 CR56 EC7 EC55 10-WAY / BLACK 11-WAY / BLACK 11-WAY / BLACK 10-WAY / BLACK 10-WAY / BLACK 15-WAY / BLACK 11-WAY / BLACK CABIN / RH ‘A’ POST REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR SWITCHED SYSTEM POWER RELAY 1 — — PASSENGER JUNCTION FUSE BOX – R1 SWITCHED SYSTEM POWER RELAY 2 — — PASSENGER JUNCTION FUSE BOX – R1 HARNESS IN-LINE CONNECTORS Connector Connector Description Location BF1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO FRONT BUMPER HARNESS ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CR120 8-WAY / BLACK / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL / LH SIDE EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST IP1 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND DRIVER SIDE INSTRUMENT PANEL END PLATE IP2 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP22 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP66 14-WAY / GREY / INSTRUMENT PANEL HARNESS TO REAR AIR CONDITIONING HARNESS CABIN / BELOW CENTER CONSOLE RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL GROUNDS Ground Location G9 CABIN / UPPER LH A POST G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Switched System Power Distribution: Part 1 OY 53 08.1 S 08.2 OY 54 08.1 S 08.2 O 55 19.1 S O 56 09.1 S O 57 09.1 S OY OY 58 13.1 S N N 59 12.1 S NW 60 08.1 S NW 61 09.1 S NW 62 09.1 S NW 63 06.1 S 09.2 NW 64 09.1 S 09.2 09.3 GU 65 02.1 S 02.2 12.2 O 66 08.1 S 08.2 O 67 08.1 S 08.2 O 68 08.1 S 08.2 O 69 08.1 S 08.2 O 70 09.1 S O 71 09.1 S O 72 09.1 S Y Y 73 13.1 S NW NW 74 05.4 S N 75 06.1 S N 76 09.1 S N 77 06.3 S OY R1 SCP NOTE: The Switched System Power Relays are activated by the FEM or the REM whenever messages are present on the SCP Network. After the ignition is switched off, the relays remain activated until all SCP messages are removed. 9 92 8 10 93 6 7 NW F10 10A O EC7-15 RW B CR9-6 ECS21 EC55-7 O SWITCHED SYSTEM POWER RELAY 1 80 F9 10A CR48-7 SWITCHED SYSTEM POWER CONTROL F12 10A CR47-2 F13 20A CR48-8 20.2 20.3 20.2 Y S + RW O NW IPS3 IP1-7 CR1-13 CR9-7 U IPS7 IP8-3 NW 20.3 S – NW CR9-1 F14 10A NW CRS14 CR47-6 NW TL28-9 CC2-11 B P CR10-11 GU FRONT ELECTRONIC MODULE G9BL F24 10A R1 94 3 95 1 EC7-13 IP55-15 4 O 5 O BFS6 BF1-7 NW 78 2 B O CR4-3 SWITCHED SYSTEM POWER RELAY 2 SWITCHED SYSTEM POWER CONTROL F25 10A ECS10 EC7-14 RW CR48-9 O 20.3 20.2 20.3 20.2 Y S + RW O O EC1-22 CRS13 CR4-4 CR13-1 U S – CR13-2 F26 15A EC55-5 F27 10A EC55-9 B CR11-12 O RFS7 RF1-1 N REAR ELECTRONIC MODULE CR120-1 G24AR N F28 10A N CR47-8 IP22-11 N IPS44 N N IP2-10 (LHD) IP22-12 (RHD) IP66-1 DD1-6 PASSENGER JUNCTION FUSE BOX 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E RW 01.7 RW 01.7 RW 01.7 SWITCHED SYSTEM POWER DISTRIBUTION: PART 2 I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground Fig. 01.6 Switched System Power Distribution: Part 1 A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 08.2 08.3 10.1 19.2 10.1 10.2 12.1 10.2 12.1 Fig. 01.7 COMPONENTS Component Connector(s) Connector Description Location FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR SWITCHED SYSTEM POWER RELAY 3 — — REAR POWER DISTRIBUTION FUSE BOX – R7 SWITCHED SYSTEM POWER RELAY 4 — — REAR POWER DISTRIBUTION FUSE BOX – R7 SWITCHED SYSTEM POWER RELAY 5 — — REAR POWER DISTRIBUTION FUSE BOX – R8 HARNESS IN-LINE CONNECTORS Connector Connector Description BL11 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS Location TRUNK / BEHIND TRUNK LID LINER BR1 10-WAY / GREY / CABIN HARNESS TO REAR BUMPER HARNESS TRUNK / RH SIDE / ADJACENT TO REAR ELECTRONIC MODULE BT11 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS TRUNK / TRUNK LID LS1 22-WAY / BLACK / CABIN HARNESS TO LH REAR SEAT HARNESS CABIN / BELOW LH REAR SEAT RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST RF25 8-WAY / BLACK / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER LH ‘A’ POST RS1 22-WAY / BLACK / CABIN HARNESS TO REAR SEAT HARNESS CABIN / BELOW REAR SEAT / RH SIDE SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE GROUNDS Ground Location G9 CABIN / UPPER LH A POST G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Switched System Power Distribution: Part 2 SCP NOTE: The Switched System Power Relays are activated by the FEM or the REM whenever messages are present on the SCP Network. After the ignition is switched off, the relays remain activated until all SCP messages are removed. R7 4 52 3 5 53 1 2 NR SWITCHED SYSTEM POWER RELAY 3 NW 80 B RW 01.6 RW 01.6 CR9-6 SWITCHED SYSTEM POWER CONTROL NR 78 08.3 S NG 79 11.8 S NG 80 11.6 S NG 81 11.1 S NG 82 11.9 S NG 83 11.6 S NG 84 09.1 S NG 85 09.1 S NG NG 86 11.8 S 11.9 NW NW 88 08.3 S 08.4 08.5 NR 89 08.3 S NR 90 08.3 S NR 91 08.3 S 08.4 08.5 NR 92 08.3 S 08.4 08.5 NR 93 15.3 S RU 94 09.1 S RU 95 09.1 S RU 96 09.1 S RU 97 09.1 S N 98 CR82-5 F15 5A NG NG 20.2 Y NG SD28-4 S + RW O 20.2 U NG RSS1 RS1-11 CR1-13 CR9-7 20.3 LSS1 LS1-11 SWITCHED SYSTEM POWER DISTRIBUTION: PART 1 NG 20.3 CRS13 RW NG CR82-3 S – CR9-1 NG CRS3 CR98-3 F16 10A NG BL11-14 BT11-14 B P CR10-11 CR97-7 FRONT ELECTRONIC MODULE 87 G9BL CR84-3 NR NW BR1-2 B NR CR4-3 BR1-1 SWITCHED SYSTEM POWER CONTROL NR NR CRS17 CR84-4 F18 10A NR BL11-15 NR BT11-15 NR BL11-16 20.3 20.2 Y S + RW O 20.3 20.2 U BT11-16 NR CR4-4 CR13-1 TL93-8 RU S – SD28-15 CR13-2 RU R7 B CR11-12 REAR ELECTRONIC MODULE G24AR 54 8 55 6 9 RU CRS7 CR82-4 F11 10A SP28-15 10 RU RU RF25-7 7 SWITCHED SYSTEM POWER RELAY 4 RFS2 N S CR81-2 F12 10A RW R8 CR81-1 F46 10A CR98-10 NG 9 56 8 10 57 6 7 CRS40 F13 20A CR97-6 F48 5A CR98-4 F49 5A CR84-5 SWITCHED SYSTEM POWER RELAY 5 CRS1 NR RW REAR POWER DISTRIBUTION FUSE BOX 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E RU 100 11.10 S NG 101 08.3 S RU 102 11.7 S RU 103 11.7 S NR NW RF2-16 NW CR98-8 1 99 11.10 S RU F47 20A I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 05.3 RU RU CR82-10 08.4 08.5 11.2 06.2 S F17 10A 78 Fig. 01.7 Switched System Power Distribution: Part 2 08.6 08.4 08.5 104 08.3 S 08.4 08.5 105 08.3 S 08.4 08.5 Fig. 01.8 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS O PI1-40 EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND Component Connector(s) Connector Description Location EMS CONTROL RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R11 ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT IGNITION COIL RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R7 REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR SLAVE IGNITION RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R9 NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description Location CP1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INTERCOOLER COOLANT PUMP HARNESS ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE CV5 12-WAY / GREY / FUEL PUMP LINK HARNESS TO EVAP CANISTER CLOSE VALVE LINK HARNESS ABOVE REAR AXLE / CENTER EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC21 2-WAY / BLACK / ENGINE HARNESS TO COOLING FAN MODULE ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE IL10 12-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK REAR OF ENGINE IS5 6-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK ENGINE COMPARTMENT / ENGINE / LH REAR IS6 6-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK ENGINE COMPARTMENT / ENGINE / RH REAR PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Engine Management Switched Power Distribution WG 2 EC8 R11 28 3 29 1 4 F12 10A PIS2 PI41-35 O BW PI41-41 NR NR EC19-2 ENGINE CONTROL MODULE 03.3 03.5 WG 107 03.1 E 03.3 03.5 NR 108 03.4 E NR 109 03.2 E 03.4 NR 110 03.2 E 03.4 NR 111 03.2 E 03.4 NR 112 03.2 E 03.4 NR 113 03.2 E 03.4 NR 114 03.2 E 03.4 NR 115 03.4 E NR 117 03.6 E NR 118 03.6 E NR 119 03.6 E NR 120 03.6 E NR 121 03.6 E NR 122 03.6 E NR 123 03.6 E NR 124 03.6 E 2 BATTERY POWER BUS PI1-40 106 03.1 E 5 EMS CONTROL RELAY BW WG WG EC19-8 EC19-3 F13 10A NR PI41-33 (N/A) ILS1 (V6) PIS23 (V8) IL10-6 NOTE: IL10-6 – V6 only. 116 03.1 03.3 03.5 27 03.1 03.3 03.5 E NR NR ISS1 IS5-1 (SC) PIS24 NR NR IS6-1 GU R9 3 34 ANCILLARY CIRCUITS GU EC28-4 F1 5A 42 ISS2 4 5 1 01.4 GU GU ECS19 EC46-2 CR82-1 2 GU 126 03.1 E GU 127 03.1 E NG 128 03.1 E NG 129 03.1 E GU 130 03.2 E GU 131 03.6 E GU 132 03.3 E 03.5 GU 133 03.3 E 03.5 GU 134 03.3 E 03.5 GU 135 03.3 E 03.5 GU 136 03.3 E 03.5 GU 137 03.4 E 03.6 RW 138 03.2 E 03.4 03.6 NG 139 03.6 E WR 140 03.1 E 03.3 03.5 WR 141 03.1 E 03.3 03.5 WG 142 03.1 E 03.3 03.5 WG 143 03.1 E 03.3 03.5 II GU SLAVE IGNITION RELAY B PI41-5 GU EC28-6 (V6) GU ECS20 EC35-1 F14 10A NG PIS1 PI41-11 GU GU EC19-6 EC21-2 GU EC41-8 (V8) ECS20 GU GU GU EC1-4 FP6-19 25 4 3 5 1 2 CV5-7 GU GU R7 PIS15 PI41-5 GU EC21-2 RW IGNITION COIL RELAY R12 26 3 F31 15A EC26-1 PI41-30 NG 4 CP1-10 WR 2 WR WG WG PI41-1 EC5-4 F34 30A PIS14 PI41-9 EC5-2 F33 30A HO2S RELAY B ECS4 EC26-2 5 1 B F30 10A PIS17 EC41-9 FRONT POWER DISTRIBUTION FUSE BOX 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data 125 03.2 E 03.4 03.6 REAR POWER DISTRIBUTION FUSE BOX G2AR 1 Fig. 01.8 Engine Management Switched Power Distribution VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 02.1 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS I PI1-006 ENGINE CRANK: B+ Component Connector(s) Connector Description Location BATTERY — — TRUNK / RH SIDE I PI1-031 PARK / NEUTRAL SIGNAL: B+ WHEN ACTIVATED O PI1-041 STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-053 GENERATOR CONTROL: VARIABLE VOLTAGE ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE I PI1-065 GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION FRONT POWER DISTRIBUTION FUSE BOX PI1-079 GENERATOR FAULT; CHARGE WARNING C PI1-123 CAN – C PI1-124 CAN + 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT I EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 GENERATOR – V6 PI47 BO10 IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL TRUNK / RH SIDE Instrument Cluster Pin Description and Characteristic I IP5-02 KEY-IN AUDIBLE WARNING: B+ WHEN KEY IN B+ IP5-03 IGNITION SWITCHED POWER SUPPLY (II): B+ B+ IP5-04 IGNITION SWITCHED POWER SUPPLY (I): B+ SG IP5-14 SIGNAL GROUND: GROUND ENGINE, RH SIDE, FRONT PG IP6-02 POWER GROUND: GROUND I IP6-04 PATS GROUND: GROUND D IP6-05 PATS TRANSCEIVER: ENCODED COMMUNICATION MEGAFUSES — — D IP6-06 PATS TRANSCEIVER: ENCODED COMMUNICATION PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER IP18 4-WAY / GREEN IGNITION SWITCH C IP6-08 CAN + STARTER MOTOR — — ENGINE BLOCK / RH SIDE C IP6-09 CAN – STARTER RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R10 TRANSMISSION CONTROL MODULE GB2 16-WAY / BLACK TRANSMISSION CONTROL VALVE Transmission Control Module Pin Description and Characteristic HARNESS IN-LINE CONNECTORS B+ GB2-09 IGNITION SWITCHED POWER SUPPLY (II): B+ Connector Connector Description EC2 2-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EL1 2-WAY / GREY / ENGINE COMPARTMENT TO STARTER MOTOR LINK HARNESS ENGINE COMPARTMENT / BULKHEAD CENTER / REARWARD OF ENGINE GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING IP51 10-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE O GB2-10 PARK / NEUTRAL SIGNAL: GROUND WHEN ACTIVATED PG GB2-13 POWER GROUND: GROUND PG GB2-16 POWER GROUND: GROUND NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location GROUNDS Ground Location BC1 TRUNK / RH SIDE / ADJACENT TO BATTERY BC3 TRUNK / RH SIDE / ADJACENT TO BATTERY G4 ENGINE COMPARTMENT / ENGINE BLOCK GROUND G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER G31 CABIN / BEHIND PASSENGER AIR BAG FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 B B R BC2 BC1 Battery; Starter; Generator – V6 B BO1 BATTERY BC3 500 A BO2 5 BO11 MEGAFUSES R10 KEY-IN RW 4 3 30 WR 5 IP34-5 EC4-3 F19 25A 0 Y 1 EL1-1 GO 2 EC41-1 EC28-8 STARTER RELAY I RU 4 Fig. 02.1 Battery; Starter; Generator – V6 IP34-4 FRONT POWER DISTRIBUTION BOX II RU 01.5 IP34-7 IGNITION-SWITCHED CIRCUITS (II) III Y Y Y IP51-6 IP34-1 Y ECS9 EC2-2 Y PI41-40 PI41-34 IGNITION SWITCH 51 GO II B GB2-9 P, N GR O GB2-10 GB1-6 B P B WR GB1-10 GB2-13 B B P GB2-16 GB1-9 EL2 PIS30 B B BO8 G30 (G26) TRANSMISSION CONTROL MODULE B BO9 STARTER MOTOR B G4 52 16 GR II 4 I GO B LOGIC Y B PIS27 IP5-4 GR NOT USED GB1-14 RW I P, N I CRANK ENGINE REQUEST PI1-31 PASSIVE ANTI-THEFT SYSTEM Y PI1-6 I PI1-65 PI1-53 Y 20.1 IP6-8 WR IP18-3 65 D GR IP18-1 – C IP18-4 20.1 B O IP6-4 7 63 95 Fig. 01.2 15 I II 16 52 Fig. 01.4 53 77 II S II S PI1-79 Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E PI47-4 GENERATOR CONTROL CHARGE / FAULT C – B B IP6-2 Fig. 01.3 PI1-123 YR I IPS6 IP5-14 B IPS2 INSTRUMENT CLUSTER 1 G C + FIELD GENERATOR P 64 PI1-124 IP6-9 PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER Fig. 01.1 20.1 Y D BG 6 GENERATOR WARNING PI47-1 IP6-6 IP18-2 1 20.1 O.K. TO START G IP6-5 GU S PI47-3 YR O C BO10 B PI47-2 WR I IP5-2 + GO ENGINE PI1-41 IP5-3 YG II O START ENGINE CONTROL MODULE G31BL I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: V6 Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 02.2 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS I PI1-006 ENGINE CRANK: B+ Component Connector(s) Connector Description Location BATTERY — — TRUNK / RH SIDE I PI1-031 PARK / NEUTRAL SIGNAL: B+ WHEN ACTIVATED O PI1-041 STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND I PI1-079 GENERATOR FAULT; CHARGE WARNING ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE C PI1-123 CAN – FRONT POWER DISTRIBUTION FUSE BOX PI1-124 CAN + 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT C EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 Instrument Cluster Pin Description and Characteristic I IP5-02 KEY-IN AUDIBLE WARNING: B+ WHEN KEY IN B+ IP5-03 IGNITION SWITCHED POWER SUPPLY (II): B+ B+ IP5-04 IGNITION SWITCHED POWER SUPPLY (I): B+ SG IP5-14 SIGNAL GROUND: GROUND GENERATOR – V8 PI48 BO10 PG IP6-02 POWER GROUND: GROUND IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN I IP6-04 PATS GROUND: GROUND INSTRUMENT CLUSTER IP6-05 PATS TRANSCEIVER: ENCODED COMMUNICATION D IP6-06 PATS TRANSCEIVER: ENCODED COMMUNICATION 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL D IP5 IP6 IP7 C IP6-08 CAN + MEGAFUSES — — TRUNK / RH SIDE C IP6-09 CAN – PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER IP18 4-WAY / GREEN IGNITION SWITCH STARTER MOTOR — — ENGINE BLOCK / RH SIDE Transmission Control Module STARTER RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R10 Pin Description and Characteristic TRANSMISSION CONTROL MODULE GB2 16-WAY / BLACK TRANSMISSION CONTROL VALVE B+ GB2-09 IGNITION SWITCHED POWER SUPPLY (II): B+ ENGINE, RH SIDE, FRONT O GB2-10 PARK / NEUTRAL SIGNAL: GROUND WHEN ACTIVATED HARNESS IN-LINE CONNECTORS PG GB2-13 POWER GROUND: GROUND Connector Connector Description PG GB2-16 POWER GROUND: GROUND EC2 2-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EL1 2-WAY / GREY / ENGINE COMPARTMENT TO STARTER MOTOR LINK HARNESS ENGINE COMPARTMENT / BULKHEAD CENTER / REARWARD OF ENGINE GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING IP51 10-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location GROUNDS Ground Location BC1 TRUNK / RH SIDE / ADJACENT TO BATTERY BC3 TRUNK / RH SIDE / ADJACENT TO BATTERY G4 ENGINE COMPARTMENT / ENGINE BLOCK GROUND G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER G31 CABIN / BEHIND PASSENGER AIR BAG FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 B B R BC2 BC1 Battery; Starter; Generator – V8 B BO1 BATTERY BC3 500 A BO2 5 BO11 MEGAFUSES R10 KEY-IN RW 3 30 4 WR 5 IP34-5 EC4-3 F19 25A 0 Y 1 EL1-1 GO 2 EC41-1 EC28-8 STARTER RELAY I RU 4 Fig. 02.2 Battery; Starter; Generator – V8 IP34-4 FRONT POWER DISTRIBUTION BOX II RU 01.5 IP34-7 IGNITION-SWITCHED CIRCUITS (II) III Y Y Y IP51-6 IP34-1 Y Y ECS9 EC2-2 PI41-40 PI41-34 IGNITION SWITCH GO 51 II B GB2-9 P, N GR O GB2-10 GB1-6 B P B WR GB1-10 GB2-13 B B P GB2-16 GB1-9 EL2 PIS30 B B BO7 G30 (G26) TRANSMISSION CONTROL MODULE B BO9 STARTER MOTOR B G4 50 16 GR 4 YG II I GO B LOGIC GR B 43 I PI1-31 IP5-4 PASSIVE ANTI-THEFT SYSTEM RW ENGINE PI1-41 IP5-3 Y I PI1-6 GO II O START BO10 B PI48-2 NG PI48-3 I BATTERY SENSE P, N CRANK ENGINE REQUEST I IP5-2 + Y C 20.1 IP6-8 WR IP18-3 GR GU 65 S D IP18-1 – G C IP6-5 IP18-4 20.1 B O IP6-4 7 63 95 Fig. 01.2 15 I II 16 52 Fig. 01.4 53 77 II S II S PI1-79 Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E PI48-1 CHARGE / FAULT C – B B IP6-2 Fig. 01.3 PI1-123 YR I IPS6 IP5-14 B IPS2 INSTRUMENT CLUSTER 1 G C + GENERATOR P 64 PI1-124 IP6-9 PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER Fig. 01.1 20.1 Y D BG 6 GENERATOR WARNING IP6-6 IP18-2 1 20.1 O.K. TO START ENGINE CONTROL MODULE G31BL I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: V8 Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 03.1 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS O O PG PG I I I I SS SS SG SG SG SG B+ B+ B+ SG SG I I SG O O O O SG I SG SG I O O SG O O I O I SG I I I I I I I O SG SG I I SG O O I SG I I SG I I D O I I O O SG SG C C I I I SG B+ PI1-001 PI1-002 PI1-004 PI1-005 PI1-006 PI1-007 PI1-008 PI1-010 PI1-012 PI1-013 PI1-017 PI1-018 PI1-019 PI1-020 PI1-022 PI1-023 PI1-024 PI1-029 PI1-030 PI1-031 PI1-036 PI1-037 PI1-038 PI1-039 PI1-040 PI1-041 PI1-043 PI1-044 PI1-045 PI1-046 PI1-050 PI1-052 PI1-053 PI1-054 PI1-055 PI1-056 PI1-065 PI1-066 PI1-068 PI1-069 PI1-070 PI1-071 PI1-073 PI1-075 PI1-076 PI1-078 PI1-079 PI1-080 PI1-081 PI1-082 PI1-083 PI1-084 PI1-091 PI1-092 PI1-093 PI1-094 PI1-095 PI1-098 PI1-099 PI1-100 PI1-102 PI1-103 PI1-105 PI1-106 PI1-107 PI1-108 PI1-109 PI1-110 PI1-111 PI1-116 PI1-123 PI1-124 PI1-127 PI1-128 PI1-129 PI1-130 PI1-134 HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE POWER GROUND 1: GROUND POWER GROUND 2: GROUND ENGINE CRANK: B+ IGNITION ON: B+ BRAKE ON / OFF SWITCH: NORMALLY OPEN / B+ WHEN ACTIVATED INERTIA SWITCH: NORMALLY CLOSED / OPEN CIRCUIT WHEN ACTIVATED SENSOR POWER SUPPLY 1: NOMINAL 5 V SENSOR POWER SUPPLY 2: NOMINAL 5 V SMALL SIGNAL GROUND1: GROUND SMALL SIGNAL GROUND 2: GROUND SENSOR GROUND 1: GROUND SENSOR GROUND 2: GROUND BATTERY POWER SUPPLY: B+ EMS SWITCHED POWER SUPPLY 1: B+ EMS SWITCHED POWER SUPPLY 2: B+ HO2 SENSOR HEATER GROUND – 1/1: GROUND HO2 SENSOR HEATER GROUND – 1/1: GROUND PARK / NEUTRAL SIGNAL: B+ WHEN ACTIVATED CRANKSHAFT SENSOR SIGNAL: PULSED SIGNAL, 70 PULSES PER ENGINE CYCLE CRANKSHAFT SENSOR SIGNAL GROUND: GROUND INTAKE MANIFOLD TUNING VALVE SOLENOID DRIVE – 1 / BOTTOM: GROUND WHEN ACTIVATED INTAKE MANIFOLD TUNING VALVE SOLENOID DRIVE – 2 / TOP: GROUND WHEN ACTIVATED EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND TP AND APP SIGNALS SHIELD: GROUND MASS AIR FLOW SENSOR SIGNAL: NOMINAL 0 – 5 V BY ENGINE OPERATING CONDITION MASS AIR FLOW SENSOR GROUND: GROUND MASS AIR FLOW SENSOR GROUND: GROUND ENGINE FUEL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES THROTTLE MOTOR RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND GENERATOR CONTROL: VARIABLE VOLTAGE THROTTLE MOTOR GROUND: GROUND HO2 SENSOR HEATER CONTROL – 2/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE HO2 SENSOR HEATER CONTROL – 2/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION EVAP CANISTER PURGE VALVE DRIVE: PWM, 10 Hz, POSITIVE DUTY CYCLE RANGE 7% – 100% BANK 2 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE BANK 2 CAMSHAFT SENSOR GROUND: GROUND ENGINE COOLANT TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INTAKE AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INJECTION PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: POTENTIOMETER – VOLTAGE INCREASES AS PRESSURE INCREASES THROTTLE POSITION SENSOR 1 SIGNAL: IDLE = 0.60 V; FULL THROTTLE = 4.30 V THROTTLE POSITION SENSOR 2 SIGNAL: IDLE = 1.48 V; FULL THROTTLE = 4.40 V ENGINE OIL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES GENERATOR FAULT; CHARGE WARNING THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR HO2 SENSOR HEATER GROUND – 2/1: GROUND HO2 SENSOR HEATER GROUND – 2/1: GROUND HO2 SENSOR 1/1 SIGNAL: VARIABLE CURRENT HO2 SENSOR 1/1 SIGNAL: CONSTANT CURRENT HO2 SENSOR HEATERS 1/2, 2/2 GROUND: GROUND HO2 SENSOR HEATER CONTROL – 1/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100% HO2 SENSOR HEATER CONTROL – 2/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100% BANK 1 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE BANK 1 CAMSHAFT SENSOR GROUND: GROUND BANK 1 KNOCK SENSOR SIGNAL: VARIABLE VOLTAGE DEPENDENT ON ENGINE VIBRATION BANK 2 KNOCK SENSOR SIGNAL: VARIABLE VOLTAGE DEPENDENT ON ENGINE VIBRATION SENSOR SHIELD: GROUND ACCELERATOR PEDAL POSITION SENSOR 1 SIGNAL: FOOT OFF = 0.75 V; FULLY DEPRESSED = 3.40 V (AUTO) 3.20 (MAN) ACCELERATOR PEDAL POSITION SENSOR 2 SIGNAL: FOOT OFF = 3.38 V; FULLY DEPRESSED = 2.05 V (AUTO) 2.14 V (MAN) SERIAL DATA LINK: SERIAL COMMUNICATION THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR HO2 SENSOR 2/1 SIGNAL: VARIABLE CURRENT HO2 SENSOR 2/1 SIGNAL: CONSTANT CURRENT BANK 1 VVT SOLENOID VALVE: PWM, 300Hz, POSITIVE DUTY CYCLE RANGE 0% – 100% BANK 2 VVT SOLENOID VALVE: PWM, 300Hz, POSITIVE DUTY CYCLE RANGE 0% – 100% FUEL INJECTORS 2, 3, 5, 8 GROUND: GROUND FUEL INJECTORS 1, 4, 6, 7 GROUND: GROUND CAN – CAN + MAP SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE INCREASES AS MANIFOLD ABSOLUTE PRESSURE INCREASES HO2 SENSOR 1/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING HO2 SENSOR 2/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING HO2 SENSORS SHIELD: GROUND THROTTLE MOTOR POWER SUPPLY: B+ WHEN RELAY ACTIVATED Component Connector(s) Connector Description Location APP SENSOR CR14 6-WAY / BLACK TOP OF ACCELERATOR PEDAL BRAKE ON / OFF SWITCH CZ1 2-WAY / GREEN TOP OF BRAKE PEDAL CKP SENSOR – V6 PI55 2-WAY / BLACK ENGINE TIMING COVER / CRANKSHAFT PULLEY CMP SENSOR 1 – V6 PI57 2-WAY / BLACK BANK 1 (RH) CAMSHAFT COVER / FRONT CMP SENSOR 2 – V6 PI56 2-WAY / BLACK BANK 2 (LH) CAMSHAFT COVER / FRONT ECT SENSOR PI25 2-WAY / BLACK ENGINE VEE / COOLANT OUTLET CASTING EFT SENSOR – V6 IL9 2-WAY / BLACK FUEL RAIL / FRONT ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE EOT SENSOR PI24 2-WAY / BLACK ADJACENT TO OIL FILTER EVAP CANISTER PURGE VALVE EC63 2-WAY / BLACK ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT HO2 SENSOR DOWNSTREAM 1/2 PI11 4-WAY / BLACK LH EXHAUST / TOP OF CATALYST HO2 SENSOR DOWNSTREAM 2/2 PI13 4-WAY / BLACK LH EXHAUST / CATALYST CENTER HO2 SENSOR UPSTREAM 1/1 PI10 4-WAY / BLACK RH EXHAUST / TOP OF CATALYST HO2 SENSOR UPSTREAM 2/1 PI12 4-WAY / BLACK LH EXHAUST / TOP OF CATALYST IMT SOLENOID VALVE 1 PI30 2-WAY / BLACK INTAKE MANIFOLD / REAR (BOTTOM) IMT SOLENOID VALVE 2 PI31 2-WAY / BLACK INTAKE MANIFOLD / REAR (TOP) IP SENSOR – V6 IL12 3-WAY / BLACK FUEL RAIL / REAR KNOCK SENSOR 1 – V6 PI20 2-WAY / BLACK ENGINE BLOCK / REAR / BANK 1 (REAR SENSOR) KNOCK SENSOR 2 – V6 PI19 2-WAY / BLACK ENGINE VEE / TOWARD FRONT / BANK 2 (FRONT SENSOR) ENGINE AIR INTAKE / ADJACENT TO AIR CLEANER MAF SENSOR PI14 5-WAY / BLACK MAP SENSOR – V6 PI29 4-WAY / BLACK INTAKE MANIFOLD / UPPER REAR THROTTLE BODY – V6 — — ENGINE AIR INTAKE / FRONT THROTTLE MOTOR PI18 2-WAY / BLACK THROTTLE BODY THROTTLE MOTOR RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R12 TP SENSOR PI26 4-WAY / BLACK THROTTLE BODY / THROTTLE SHAFT VVT SOLENOID VALVE 1 PI16 2-WAY / BLACK RH CYLINDER HEAD / FRONT VVT SOLENOID VALVE 2 PI17 2-WAY / BLACK LH CYLINDER HEAD / FRONT HARNESS IN-LINE CONNECTORS Connector Connector Description Location CR78 2-WAY / BLACK / BRAKE ON/OFF SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY EC16 12-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST IL10 12-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK REAR OF ENGINE PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Engine Management System: V6 – Part 1 142 PI1-055 PI1-056 I PI1-128 O PI1-092 I PI1-129 O PI1-093 PI1-037 I PI1-036 I PI1-094 PI1-100 PI1-069 I PI1-098 I PI1-099 I PI1-044 PI1-045 Y C + G PI1-046 I PI1-071 C – I PI1-070 D I PI1-078 I PI1-073 I PI1-050 PI1-019 W THROTTLE MOTOR RELAY PI1-012 9 GU 10 F24 20A 116 6 EC26-5 GU PI41-38 E EC19-5 PI41-39 PI1-103 I PI1-102 PI1-020 O PI1-013 PI1-052 PI1-043 FRONT POWER DISTRIBUTION FUSE BOX O PI1-080 O PI1-106 I PI1-076 I PI1-075 I PI1-008 PI1-017 PI1-018 P PI1-005 PI1-029 PI1-054 PI1-091 P PI1-004 O PI1-066 O PI1-039 O PI1-038 O PI1-110 O PI1-109 PIS30 PIS28 B B B G26BR (G30BR) 1 7 6 63 G26AL (G30AL) 64 95 Fig. 01.2 1 15 I II OY BK BG WU BG OY BG U BG Y BG UY U BK GW GU B N G N R Y O B B N ILS2 BG PIS13 IL10 -4 PIS25 IL10 -12 IL10 -10 BG PIS22 Y R BG Y W PI41-8 PI41-7 PI41-12 PI41-3 B OY EC61-5 (LHD) EC16-7 (RHD) EC61-6 (LHD) EC16-8 (RHD) EC16-7 (LHD) EC61-10 (RHD) EC16-8 (LHD) EC61-11 (RHD) W PI41-6 PI41 -18 W EC61-7 (LHD) EC16-1 (RHD) PI41 -17 ECS32 ECS31 GO UY OG OY YU Y GO GO CRS16 EC53-3 (LHD) EC53-5 (RHD) EC16 -5 PI41-10 EC16 -9 CR78-2 128 B B PI1-030 IL10 -11 PIS21 PI41-23 129 E PI1-111 PI1-116 126 E 83 E PI26 -1 PI26 -3 PI26 -2 TP1 TP2 PI26 -4 PI18 -2 PI18 -1 CR14 -5 CR14 -3 CR14 -4 CR14 -2 CR14 -6 CR14 -1 PI1-081 PI16 -2 -1 PI17 -2 -1 PI30 -2 -1 PI31 -2 -1 EC63 -2 -1 CZ1 -2 -1 ENGINE CONTROL MODULE (Continued Fig. 03.2) 1 G26AR (G30AR) Fig. 01.1 BG PIS19 B PIS12 PI1-082 PIS29 B OY B B B B B B B B B B B B PI1-127 I PI1-134 GR GR 7 B I PIS11 BG BG B OG 27 PI1-068 BG B Y I PI1-105 8 E BG PI1-108 O PI1-123 R12 127 E BG I O O GR 20.2 -2 PI29 -2 -1 -4 BG PI1-107 I PI1-031 20.3 IL9 -1 OY I PI1-095 PI1-124 SERIAL COMMUNICATION -1 OY PI1-002 I GO 20.1 -2 OY I YR 20.1 -2 IL12 -3 R WR 02.1 -1 PI24 -1 WU O R Y RU RU G N RW RW BW N UY N RW B O Y R BG N G N N GW BK BK U UY BG Y U WU OY BK O B BG Y BG GW RW Y R GO NG 04.1 -5 PI25 -2 BG PI1-001 O PI1-041 PARK; NEUTRAL (CIRCUIT CONTINUED) 141 E -4 BG YR 02.1 PI19 -2 -1 -2 OY O PI1-079 STARTER RELAY DRIVE PI20 -2 -1 -3 Y I BW 02.1 PI14 -1 BG PI1-084 O PI1-065 GENERATOR: FAULT; CHARGE WARNING PI56-2 U Y 02.1 PI56 -1 MAP SENSOR υ GW PI1-083 I PI1-130 PI1-053 GENERATOR: FIELD I PI1-010 02.1 PI57 -2 RW I II PI1-040 GENERATOR: CONTROL PI57 -1 EFT SENSOR υ OY GU 01.8 PI55 -2 υ Y I PI1-007 PI1-006 EMS CONTROL RELAY PI55 -1 R GO 02.1 143 E -1 IP SENSOR IATS 2 BG PI1-024 II ENGINE CRANK -3 -2 EOT SENSOR GO NG B E VIA INERTIA SWITCH PI13 -4 GU WG 43 -1 UY B PI1-023 18 -3 -2 NG WG E 107 1 ECT SENSOR B PI1-022 106 PI11 -4 140 E NR 7 2 MAF SENSOR υ WR -1 N -4 -2 1 KNOCK SENSORS λ N PI12 -3 N RW -1 G -4 -2 WG R PI10 -3 Y RU BRD CMP SENSORS 2/2 λ U WR U 1/2 CKP SENSOR B RW 2/1 B UY 1/1 NOTE: Shielding shown as dashed lines are braided wires. HO2 SENSORS DOWNSTREAM Fig. 03.1 Engine Management System: V6 – Part 1 BG HO2 SENSORS UPSTREAM WG Jaguar XJ 2004 1 2 VVT SOLENOID VALVES Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E TP SENSOR 2 IMT SOLENOID VALVES (1 BOTTOM; 2 TOP) I Input B + O Output P Power Ground Battery Voltage APP1 THROTTLE MOTOR EVAP CANISTER PURGE VALVE + Sensor/Signal Supply V – Sensor/Signal Ground BRAKE ON / OFF SWITCH APP SENSOR THROTTLE BODY A ACP S SCP C CAN D Serial and Encoded Data VARIANT: V6 Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 APP2 Fig. 03.2 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS I PI1-009 BRAKE CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED Component Connector(s) Connector Description AIR CONDITIONING PRESSURE SENSOR EC11 3-WAY / BLACK ADJACENT TO RADIATOR / LH SIDE Location SS PI1-012 SENSOR POWER SUPPLY 1: NOMINAL 5 V SG PI1-019 SENSOR GROUND 1: GROUND O PI1-027 FUEL PUMP DRIVE SIGNAL (TO RECM): PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% BRAKE CANCEL SWITCH CY1 2-WAY / GREY TOP OF BRAKE PEDAL SS PI1-047 SPEED CONTROL SWITCH REQUEST: STEPPED RESISTANCE COOLING FAN MODULE AND MOTOR PI1-048 SPEED CONTROL SWITCHES SIGNAL GROUND: GROUND GC1 EC20 2-WAY / GREY 2-WAY / GREY RADIATOR COOLING FAN I O PI1-051 COOLING FAN MODULE CONTROL: PWM, 140Hz, POSITIVE DUTY CYCLE RANGE 7% – 95% ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE O PI1-061 IGNITION COIL ACTIVATE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 1 – V6 IL3 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-062 IGNITION COIL ACTIVATE – CYLINDER 4: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 2 – V6 IL6 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-063 IGNITION COIL ACTIVATE – CYLINDER 6: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 3 – V6 IL4 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-087 IGNITION COIL ACTIVATE – CYLINDER 1: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 4 – V6 IL7 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-088 IGNITION COIL ACTIVATE – CYLINDER 3: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-089 IGNITION COIL ACTIVATE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 5 – V6 IL5 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-113 FUEL INJECTOR DRIVE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 6 – V6 IL8 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-114 FUEL INJECTOR DRIVE – CYLINDER 3: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL PUMP (1) FP4 4-WAY / BLACK FUEL TANK / RH SIDE O PI1-115 FUEL INJECTOR DRIVE – CYLINDER 1: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL PUMP RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R6 O PI1-118 FUEL INJECTOR DRIVE – CYLINDER 6: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION CAPACITOR PI54 2-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / CENTER O PI1-119 FUEL INJECTOR DRIVE – CYLINDER 4: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION MODULE AND COIL 1 PI2 4-WAY / BLACK RH CYLINDER HEAD O PI1-120 FUEL INJECTOR DRIVE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION MODULE AND COIL 2 PI6 4-WAY / BLACK LH CYLINDER HEAD I PI1-121 AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES IGNITION MODULE AND COIL 3 PI3 4-WAY / BLACK RH CYLINDER HEAD I PI1-131 IGNITION MONITOR BANK 1: PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE I PI1-132 IGNITION MONITOR BANK 2: PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE Rear Electronic Module Pin Description and Characteristic B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ SG CR11-12 LOGIC GROUND: GROUND I CR11-19 FUEL PUMP (1) DRIVE SIGNAL: PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% SG CR11-25 LOGIC GROUND: GROUND SG CR11-26 LOGIC GROUND: GROUND B+ CR12-08 IGNITION SWITCHED POWER SUPPLY (II) (FUEL PUMP CONTROL): B+ S CR13-01 SCP NETWORK + S CR13-02 SCP NETWORK – SG CR71-15 LOGIC GROUND: GROUND B+ CR73-01 FUEL PUMP POWER SUPPLY: B+ WHEN FUEL PUMP RELAY ACTIVATED PG CR73-02 POWER GROUND (FUEL PUMP): GROUND O CR73-03 FUEL PUMP GROUND: GROUND, PWM O CR73-04 FUEL PUMP B+: B+ IGNITION MODULE AND COIL 4 PI7 4-WAY / BLACK LH CYLINDER HEAD IGNITION MODULE AND COIL 5 PI4 4-WAY / BLACK RH CYLINDER HEAD IGNITION MODULE AND COIL 6 PI8 4-WAY / BLACK LH CYLINDER HEAD REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR STEERING WHEEL SPEED CONTROL SWITCHES — — STEERING WHEEL HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Connector Connector Description Location CR77 2-WAY / BLACK / BRAKE CANCEL SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY EC21 2-WAY / BLACK / ENGINE HARNESS TO COOLING FAN MODULE ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST FP2 6-WAY / GREY / CABIN HARNESS TO FUEL PUMP HARNESS CABIN / BELOW REAR SEAT CUSHION / RH SIDE IL10 12-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK REAR OF ENGINE IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE PI42 8-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G23 TRUNK / RH SIDE / ADJACENT TO BATTERY G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Engine Management System: V6 – Part 2 FUEL INJECTORS 110 E O PI1-114 O PI1-113 O PI1-120 O PI1-119 O PI1-118 O PI1-087 O PI1-088 I PI1-131 O PI1-089 O PI1-061 O PI1-062 I PI1-132 O PI1-063 O PI1-051 O PI1-027 I PI1-009 PI1-019 PI1-012 I PI1-121 I PI1-047 I PI1-048 112 BG IL10 -8 IL10 -3 5 2 4 6 PI2 -4 -2 -3 -1 PI3 -4 -2 -3 -1 PI4 -4 -2 -3 -1 PI6 -4 -2 -3 -1 PI7 -4 -2 -3 -1 PI8 -4 -2 -3 -1 RW E GR YB B RW GW YB B RW GW YB B RW YR GB B RW GU GB B RW 138 IGNITION CAPACITOR RW RW RW RW RW RW RW E IL10 -9 3 -2 114 E 1 Y GB B RW IL8 -1 113 E IL10 -2 -2 NR IL7 -1 U -2 NR IL6 -1 E BK BG IL10 -7 -2 111 E IL10 -1 PI1-115 IL5 -1 PIS8 U 109 O -2 BO IL4 -1 6 BO CYLINDER NUMBERING -2 NR IL3 -1 BR 5 IGNITION MODULES AND COILS 4 2 BR 6 5 NR 3 BK 4 NR 1 BG 2 3 NR 1 BG FRONT OF ENGINE PI54 PI54 -1 -2 B B B B B B BG BK BG BR BO U GU Y GB YR GW GW YB GR WU PIS9 B PIS31 B PIS10 G26CS (G30CS) FAN NG B WU WR U BG OY WU WU PI42-1 PIS21 PIS22 U BG OY WU PI41-28 BG OY WU PI41-17 PI41-18 PI41-19 YR YG EC21-1 I GC1-1 U EC53-4 GN P ECS31 EC20-2 ECS32 G3AS YR YG PI41-25 COOLING FAN MODULE AND MOTOR PI41-24 N PI41-26 B N B I CR4-3 RESUME FUEL PUMP IP55-11 (LHD) IP9-3 (RHD) SW8-6 1κ Ω R FP4-2 Y CR73-4 B FUEL TANK CRS56 510 Ω B CR77-2 SET – NOTE: The ECM communicates (CAN / SCP) with the REM for Fuel Pump diagnostics. + S G24AL CR13-1 – S CR13-2 CR71-15 CR11-25 CR11-12 N YR IP55-12 (LHD) IP9-4 (RHD) SW8-8 B CR11-26 REAR ELECTRONIC MODULE II U WG BG OY WU FUEL PUMP RELAY NOTE: Vehicles with Adaptive Speed Control – refer to Speed Control Switches, Fig. 05.4. 4 EC11 -2 -3 -1 CY1 -2 -1 CR5-1 B CRS23 R6 5 3 2 1 59 F33 20A B CR82-7 G23AL 125 E AIR CONDITIONING PRESSURE SENSOR 7 63 95 Fig. 01.2 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S 20.2 20.3 20.2 20.3 B B B B G24AR 28 STEERING WHEEL SPEED CONTROL SWITCHES 1 U CR73-01 RESISTOR PACK 64 Y B G24BL CASSETTE Fig. 01.1 VIA INERTIA SWITCH G24BR 120 Ω CANCEL II P CR73-02 CRS75 B 300 Ω 44 O FP2-1 B SET + 78 CR73-3 Y KB CR12-8 GU O FP2-4 FP4-4 YG NW CR11-19 EC46-16 (LHD) EC61-3 (RHD) R CASSETTE 6 14 EC20-1 B 1 130 E GC1-2 NOTE: ECM power supplies and grounds shown in Fig. 03.1. 180 Ω GU B ENGINE CONTROL MODULE (Continued from Fig. 03.1) 2.2κ Ω Fig. 03.2 Engine Management System: V6 – Part 2 Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage FUEL PUMP DIODE (D1) BRAKE CANCEL SWITCH REAR POWER DISTRIBUTION FUSE BOX + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: V6 Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 G24BL G24BR Fig. 03.3 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS O O PG PG I I I I SS SS SG SG SG SG B+ B+ B+ SG SG I I SG O O SG I SG SG I O O SG O O O O O O I O O I SG I I I I I I I O SG SG I I SG O O I SG I I SG I I D O I I O O SG SG C C I I I SG B+ PI1-001 PI1-002 PI1-004 PI1-005 PI1-006 PI1-007 PI1-008 PI1-010 PI1-012 PI1-013 PI1-017 PI1-018 PI1-019 PI1-020 PI1-022 PI1-023 PI1-024 PI1-029 PI1-030 PI1-031 PI1-036 PI1-037 PI1-040 PI1-041 PI1-043 PI1-044 PI1-045 PI1-046 PI1-050 PI1-052 PI1-053 PI1-054 PI1-055 PI1-056 PI1-057 PI1-058 PI1-059 PI1-060 PI1-065 PI1-066 PI1-067 PI1-068 PI1-069 PI1-070 PI1-071 PI1-073 PI1-075 PI1-076 PI1-078 PI1-079 PI1-080 PI1-081 PI1-082 PI1-083 PI1-084 PI1-091 PI1-092 PI1-093 PI1-094 PI1-095 PI1-098 PI1-099 PI1-100 PI1-102 PI1-103 PI1-105 PI1-106 PI1-107 PI1-108 PI1-109 PI1-110 PI1-111 PI1-116 PI1-123 PI1-124 PI1-127 PI1-128 PI1-129 PI1-130 PI1-134 HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE POWER GROUND 1: GROUND POWER GROUND 2: GROUND ENGINE CRANK: B+ IGNITION ON: B+ BRAKE ON / OFF SWITCH: NORMALLY OPEN / B+ WHEN ACTIVATED INERTIA SWITCH: NORMALLY CLOSED / OPEN CIRCUIT WHEN ACTIVATED SENSOR POWER SUPPLY 1: NOMINAL 5 V SENSOR POWER SUPPLY 2: NOMINAL 5 V SMALL SIGNAL GROUND1: GROUND SMALL SIGNAL GROUND 2: GROUND SENSOR GROUND 1: GROUND SENSOR GROUND 2: GROUND BATTERY POWER SUPPLY: B+ EMS SWITCHED POWER SUPPLY 1: B+ EMS SWITCHED POWER SUPPLY 2: B+ HO2 SENSOR HEATER GROUND – 1/1: GROUND HO2 SENSOR HEATER GROUND – 1/1: GROUND PARK / NEUTRAL SIGNAL: B+ WHEN ACTIVATED CRANKSHAFT SENSOR SIGNAL: PULSED SIGNAL, 70 PULSES PER ENGINE CYCLE CRANKSHAFT SENSOR SIGNAL GROUND: GROUND EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND TP AND APP SIGNALS SHIELD: GROUND MASS AIR FLOW SENSOR SIGNAL: NOMINAL 0 – 5 V BY ENGINE OPERATING CONDITION MASS AIR FLOW SENSOR GROUND: GROUND MASS AIR FLOW SENSOR GROUND: GROUND ENGINE FUEL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES THROTTLE MOTOR RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND GENERATOR CONTROL: VARIABLE VOLTAGE THROTTLE MOTOR GROUND: GROUND HO2 SENSOR HEATER CONTROL – 2/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE HO2 SENSOR HEATER CONTROL – 2/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE EGR DRIVE 1: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN EGR DRIVE 2: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN EGR DRIVE 3: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN EGR DRIVE 4: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION EVAP CANISTER PURGE VALVE DRIVE: PWM, 10 Hz, POSITIVE DUTY CYCLE RANGE 7% – 100% EVAP CANISTER CLOSE VALVE DRIVE: TO CLOSE, ECM SWITCHES CIRCUIT TO GROUND BANK 2 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE BANK 2 CAMSHAFT SENSOR GROUND: GROUND ENGINE COOLANT TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INTAKE AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INJECTION PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: POTENTIOMETER – VOLTAGE INCREASES AS PRESSURE INCREASES THROTTLE POSITION SENSOR 1 SIGNAL: IDLE = 0.60 V; FULL THROTTLE = 4.30 V THROTTLE POSITION SENSOR 2 SIGNAL: IDLE = 1.48 V; FULL THROTTLE = 4.40 V ENGINE OIL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES GENERATOR FAULT; CHARGE WARNING THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR HO2 SENSOR HEATER GROUND – 2/1: GROUND HO2 SENSOR HEATER GROUND – 2/1: GROUND HO2 SENSOR 1/1 SIGNAL: VARIABLE CURRENT HO2 SENSOR 1/1 SIGNAL: CONSTANT CURRENT HO2 SENSOR HEATERS 1/2, 2/2 GROUND: GROUND HO2 SENSOR HEATER CONTROL – 1/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100% HO2 SENSOR HEATER CONTROL – 2/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100% BANK 1 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE BANK 1 CAMSHAFT SENSOR GROUND: GROUND BANK 1 KNOCK SENSOR SIGNAL: VARIABLE VOLTAGE DEPENDENT ON ENGINE VIBRATION BANK 2 KNOCK SENSOR SIGNAL: VARIABLE VOLTAGE DEPENDENT ON ENGINE VIBRATION SENSOR SHIELD: GROUND ACCELERATOR PEDAL POSITION SENSOR 1 SIGNAL: FOOT OFF = 0.75 V; FULLY DEPRESSED = 3.40 V (AUTO) 3.20 (MAN) ACCELERATOR PEDAL POSITION SENSOR 2 SIGNAL: FOOT OFF = 3.38 V; FULLY DEPRESSED = 2.05 V (AUTO) 2.14 V (MAN) SERIAL DATA LINK: SERIAL COMMUNICATION THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR HO2 SENSOR 2/1 SIGNAL: VARIABLE CURRENT HO2 SENSOR 2/1 SIGNAL: CONSTANT CURRENT BANK 1 VVT SOLENOID VALVE: PWM, 300Hz, POSITIVE DUTY CYCLE RANGE 0% – 100% BANK 2 VVT SOLENOID VALVE: PWM, 300Hz, POSITIVE DUTY CYCLE RANGE 0% – 100% FUEL INJECTORS 2, 3, 5, 8 GROUND: GROUND FUEL INJECTORS 1, 4, 6, 7 GROUND: GROUND CAN – CAN + MAP SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE INCREASES AS MANIFOLD ABSOLUTE PRESSURE INCREASES HO2 SENSOR 1/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING HO2 SENSOR 2/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING HO2 SENSORS SHIELD: GROUND THROTTLE MOTOR POWER SUPPLY: B+ WHEN RELAY ACTIVATED Component Connector(s) Connector Description Location APP SENSOR CR14 6-WAY / BLACK TOP OF ACCELERATOR PEDAL BRAKE ON / OFF SWITCH CZ1 2-WAY / GREEN TOP OF BRAKE PEDAL CKP SENSOR – V8 PI21 2-WAY / BLACK ENGINE UNDER SIDE, FORWARD OF BELL HOUSING CMP SENSOR 1 – V8 PI23 2-WAY / BLACK BANK 1 (RH) CAMSHAFT COVER / REAR CMP SENSOR 2 – V8 PI22 2-WAY / BLACK BANK 2 (LH) CAMSHAFT COVER / REAR ECT SENSOR PI25 2-WAY / BLACK ENGINE VEE / COOLANT OUTLET CASTING EFT SENSOR – V8 PI27 2-WAY / BLACK FUEL RAIL, RH REAR EGR VALVE – V8 N/A PI15 6-WAY / BLACK INTAKE MANIFOLD, RH FRONT ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE ENGINE CONTROL MODULE PI1 134-WAY / BLACK EOT SENSOR PI24 2-WAY / BLACK ADJACENT TO OIL FILTER EVAP CANISTER PURGE VALVE EC63 2-WAY / BLACK ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER EVAP CANISTER CLOSE VALVE CV2 2-WAY / BLACK ABOVE REAR AXLE (FUEL TANK COMPONENTS) FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT FTP SENSOR FP1 3-WAY / BLACK FUEL TANK PIPING, LH SIDE (UNDER ACCESS PLATE) HO2 SENSOR DOWNSTREAM 1/2 PI11 4-WAY / BLACK LH EXHAUST / TOP OF CATALYST HO2 SENSOR DOWNSTREAM 2/2 PI13 4-WAY / BLACK LH EXHAUST / CATALYST CENTER HO2 SENSOR UPSTREAM 1/1 PI10 4-WAY / BLACK RH EXHAUST / TOP OF CATALYST HO2 SENSOR UPSTREAM 2/1 PI12 4-WAY / BLACK LH EXHAUST / TOP OF CATALYST IP SENSOR – V8 N/A PI28 3-WAY / BLACK FUEL RAIL, RH FRONT KNOCK SENSOR 1 – V8 PI20 2-WAY / BLACK ENGINE VEE, BANK 1 KNOCK SENSOR 2 – V8 PI19 2-WAY / BLACK ENGINE VEE, BANK 2 MAF SENSOR PI14 5-WAY / BLACK ENGINE AIR INTAKE / ADJACENT TO AIR CLEANER MAP SENSOR – V8 N/A PI29 4-WAY / BLACK INTAKE MANIFOLD, LOWER REAR THROTTLE BODY – V8 N/A — — ENGINE AIR INTAKE, FRONT THROTTLE MOTOR PI18 2-WAY / BLACK THROTTLE BODY THROTTLE MOTOR RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R12 TP SENSOR PI26 4-WAY / BLACK THROTTLE BODY / THROTTLE SHAFT VVT SOLENOID VALVE 1 PI16 2-WAY / BLACK RH CYLINDER HEAD / FRONT VVT SOLENOID VALVE 2 PI17 2-WAY / BLACK LH CYLINDER HEAD / FRONT HARNESS IN-LINE CONNECTORS Connector Connector Description Location CR78 2-WAY / BLACK / BRAKE ON/OFF SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY CV5 12-WAY / GREY / FUEL PUMP LINK HARNESS TO EVAP CANISTER CLOSE VALVE LINK HARNESS ABOVE REAR AXLE / CENTER EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC16 12-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Engine Management System: V8 N/A – Part 1 HO2 SENSORS UPSTREAM 1/1 NOTES: *EVAP Canister Close Valve and Fuel Tank Pressure Sensor – NAS vehicles only. HO2 SENSORS DOWNSTREAM 2/1 U 1/2 CMP SENSORS 1 2/2 λ U CKP SENSOR Fig. 03.3 Engine Management System: V8 N/A – Part 1 KNOCK SENSORS 2 1 MAF SENSOR ECT SENSOR EOT SENSOR IP SENSOR EFT SENSOR MAP SENSOR FTP SENSOR* IATS 2 υ λ υ υ υ Shielding shown as dashed lines are braided wires. 142 O PI1-093 I PI1-036 I PI1-094 PI1-100 GR I I Y PI1-069 C + G I PI1-098 I PI1-099 I PI1-044 PI1-045 C – W 27 D PI1-046 I PI1-071 I PI1-070 PI1-019 6 I PI1-078 I PI1-073 I PI1-050 PI1-012 9 GU F24 20A 116 PI1-068 EC26-5 GU PI41-38 E EC19-5 PI1-134 GR GR 7 B PI41-39 I PI1-127 I PI1-104 I PI1-103 I PI1-102 O PI1-020 PI1-052 PI1-013 PI1-043 FRONT POWER DISTRIBUTION FUSE BOX B B B B B B B B B B B B PI1-017 PI1-018 P PI1-005 PI1-029 PI1-054 PI1-091 P O PI1-080 O PI1-106 I PI1-076 I PI1-075 O PI1-057 O PI1-058 O PI1-059 O PI1-060 I PI1-008 O PI1-067 PI1-004 PI1-030 PI1-111 PI1-116 O PI1-066 O PI1-110 O PI1-109 PI1-081 PIS30 PIS28 B B G26BR (G30BR) G26AL (G30AL) 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II 52 Fig. 01.4 53 77 II S II PI41-7 PI41-12 PI41-3 B BG RG OY OY BK BG YR BG OY BG U BG Y BG UY BG U BK GW B N GU B N G N R Y B WR Y R BG Y W Y R BG Y W PI41-8 S 78 105 Fig. 01.7 S Fig. 01.6 143 Fig. 01.8 E S E OY ECS32 EC61-6 (LHD) EC16-8 (RHD) EC16-7 (LHD) EC61-10 (RHD) EC16-8 (LHD) EC61-11 (RHD) W EC61-7 (LHD) EC16-1 (RHD) EC16 -5 GO O PI41-23 GO O EC1-3 (LHD) EC53-10 (RHD) O FP6-20 EC53-3 (LHD) EC53-5 (RHD) CV5-8 132 -1 PI17 -2 -1 EC63 -2 -1 E 83 E CV2 -2 -1 E CR78-2 133 E PI41-10 PI15 -3 CR78 -2 -1 PI15 -6 PI15 -1 PI15 -4 PI15 -5 4 3 2 1 PI26 -1 PI26 -3 PI26 -2 TP1 TP2 PI26 -4 PI18 -2 EVAP CANISTER CLOSE VALVE* I Input B + O Output P Power Ground Battery Voltage BRAKE ON / OFF SWITCH + Sensor/Signal Supply V – Sensor/Signal Ground EGR VALVE A ACP S SCP C CAN D Serial and Encoded Data PI18 -1 CR14 -5 CR14 -3 CR14 -4 CR14 -2 CR14 -6 CR14 -1 PI15 -2 TP SENSOR 2 EVAP CANISTER PURGE VALVE EC16 -9 135 136 GO CRS16 STEPPER MOTOR 106 OY PI41-18 EC61-5 (LHD) EC16-7 (RHD) PI41-6 B B Fig. 01.5 ECS31 OY 1 16 EC1 -7 BG PI41-17 PIS22 ENGINE CONTROL MODULE (Continued Fig. 03.4) Fig. 01.3 BG PIS21 VVT SOLENOID VALVES 1 B RW PIS25 UY YU Y G26AR (G30AR) EC1 -5 (LHD) EC53 -9 (RHD) PI41 -14 PI16 -2 B N EC1 -6 PI41-29 PI1-082 PIS29 WG PIS13 FP6 -10 OY PI1-129 FP6 -21 Y PI1-092 I FP6 -11 BG PI1-128 BG BG I O BG PIS19 B PIS12 RG PI1-056 B RG PI1-055 O PIS11 BG BG B BG PI1-108 BG B BG I O PI1-095 THROTTLE MOTOR RELAY 10 E OY PI1-107 PI1-105 8 134 E OY I O PI1-123 R12 FP1 -1 -2 -3 R I GO 20.2 -2 PI29 -2 -1 -4 BG PI1-002 PI1-124 20.3 -1 PI27 -1 Y O PI1-037 PI1-031 SERIAL COMMUNICATION -2 GW PI1-001 PI1-079 20.1 -2 PI28 -3 RW PI1-084 O O YR 20.1 -1 PI24 -1 OY BW 02.2 -5 PI25 -2 Y 04.1 -4 R I PI1-041 PARK; NEUTRAL (CIRCUIT CONTINUED) PI19 -2 -1 -2 BG 02.2 PI20 -2 -1 -3 GU STARTER RELAY DRIVE PI14 -1 GU Y PI1-040 02.2 PI1-083 I R Y RU RU G N RW RW BW N UY N RW B O Y R BG N G N N GW BK BK U UY BG Y U YR OY BK RG O B BG Y BG GW RW Y R YU YG YR YU GO O PI1-130 PI1-006 GENERATOR: FAULT; CHARGE WARNING PI22 -2 YU 01.8 PI22 -1 YG EMS CONTROL RELAY PI23 -1 YR 02.2 I I PI1-010 ENGINE CRANK PI23 -2 YU GU II PI21 -2 GO NG I PI1-007 43 PI21 -1 GU GO II -1 141 O B PI1-024 18 -3 -2 E GU WG E VIA INERTIA SWITCH B PI1-023 107 PI13 -4 143 E UY WG E -1 B PI1-022 106 -3 -2 140 E NR 7 PI11 -4 N G -1 B UY -4 -2 WR PI12 -3 N RW -1 WG -4 -2 Y RU R PI10 -3 O BRD APP1 THROTTLE MOTOR THROTTLE BODY VARIANT: V8 N/A Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 APP SENSOR APP2 Fig. 03.4 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS I PI1-009 BRAKE CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED Component Connector(s) Connector Description AIR CONDITIONING PRESSURE SENSOR EC11 3-WAY / BLACK ADJACENT TO RADIATOR / LH SIDE Location SS PI1-012 SENSOR POWER SUPPLY 1: NOMINAL 5 V SG PI1-019 SENSOR GROUND 1: GROUND O PI1-027 FUEL PUMP DRIVE SIGNAL (TO RECM): PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% BRAKE CANCEL SWITCH CY1 2-WAY / GREY TOP OF BRAKE PEDAL SS PI1-047 SPEED CONTROL SWITCH REQUEST: STEPPED RESISTANCE COOLING FAN MODULE AND MOTOR PI1-048 SPEED CONTROL SWITCHES SIGNAL GROUND: GROUND GC1 EC20 2-WAY / GREY 2-WAY / GREY RADIATOR COOLING FAN I O PI1-051 COOLING FAN MODULE CONTROL: PWM, 140Hz, POSITIVE DUTY CYCLE RANGE 7% – 95% ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE O PI1-061 IGNITION COIL ACTIVATE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 1 – V8 N/A PI32 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-062 IGNITION COIL ACTIVATE – CYLINDER 4: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 2 – V8 N/A PI36 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-063 IGNITION COIL ACTIVATE – CYLINDER 6: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 3 – V8 N/A PI33 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-064 IGNITION COIL ACTIVATE – CYLINDER 8: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 4 – V8 N/A PI37 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-087 IGNITION COIL ACTIVATE – CYLINDER 1: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-088 IGNITION COIL ACTIVATE – CYLINDER 3: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 5 – V8 N/A PI34 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-089 IGNITION COIL ACTIVATE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 6 – V8 N/A PI38 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-090 IGNITION COIL ACTIVATE – CYLINDER 7: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 7 – V8 N/A PI35 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-112 FUEL INJECTOR DRIVE – CYLINDER 8: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 8 – V8 N/A PI39 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-113 FUEL INJECTOR DRIVE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL PUMP (1) FP4 4-WAY / BLACK FUEL TANK / RH SIDE O PI1-114 FUEL INJECTOR DRIVE – CYLINDER 3: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL PUMP RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R6 O PI1-115 FUEL INJECTOR DRIVE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION CAPACITOR PI54 2-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / CENTER O PI1-117 FUEL INJECTOR DRIVE – CYLINDER 7: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION MODULE AND COIL 1 PI2 4-WAY / BLACK RH CYLINDER HEAD O PI1-118 FUEL INJECTOR DRIVE – CYLINDER 6: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-119 FUEL INJECTOR DRIVE – CYLINDER 4: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-120 FUEL INJECTOR DRIVE – CYLINDER 1: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND I PI1-121 AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES IGNITION MODULE AND COIL 4 PI7 4-WAY / BLACK LH CYLINDER HEAD I PI1-131 IGNITION MONITOR BANK 1: PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE IGNITION MODULE AND COIL 5 PI4 4-WAY / BLACK RH CYLINDER HEAD I PI1-132 IGNITION MONITOR BANK 2: PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE IGNITION MODULE AND COIL 6 PI8 4-WAY / BLACK LH CYLINDER HEAD IGNITION MODULE AND COIL 7 PI5 4-WAY / BLACK RH CYLINDER HEAD Rear Electronic Module IGNITION MODULE AND COIL 8 PI9 4-WAY / BLACK LH CYLINDER HEAD Pin Description and Characteristic REAR ELECTRONIC MODULE CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR B+ CR4 CR11 CR12 CR13 CR71 CR73 REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR STEERING WHEEL SPEED CONTROL SWITCHES — — STEERING WHEEL SG CR11-12 LOGIC GROUND: GROUND I CR11-19 FUEL PUMP (1) DRIVE SIGNAL: PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% SG CR11-25 LOGIC GROUND: GROUND SG CR11-26 LOGIC GROUND: GROUND B+ CR12-08 IGNITION SWITCHED POWER SUPPLY (II) (FUEL PUMP CONTROL): B+ S CR13-01 SCP NETWORK + S CR13-02 SCP NETWORK – SG CR71-15 LOGIC GROUND: GROUND B+ CR73-01 FUEL PUMP POWER SUPPLY: B+ WHEN FUEL PUMP RELAY ACTIVATED PG CR73-02 POWER GROUND (FUEL PUMP): GROUND O CR73-03 FUEL PUMP GROUND: GROUND, PWM O CR73-04 FUEL PUMP B+: B+ IGNITION MODULE AND COIL 2 PI6 4-WAY / BLACK LH CYLINDER HEAD IGNITION MODULE AND COIL 3 PI3 4-WAY / BLACK RH CYLINDER HEAD HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Connector Connector Description Location CR77 2-WAY / BLACK / BRAKE CANCEL SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY EC21 2-WAY / BLACK / ENGINE HARNESS TO COOLING FAN MODULE ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST FP2 6-WAY / GREY / CABIN HARNESS TO FUEL PUMP HARNESS CABIN / BELOW REAR SEAT CUSHION / RH SIDE IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE PI42 8-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G23 TRUNK / RH SIDE / ADJACENT TO BATTERY G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Engine Management System: V8 N/A – Part 2 FUEL INJECTORS FRONT OF ENGINE 1 108 CYLINDER NUMBERING 6 4 109 E 110 E 1 8 111 E 112 E 5 113 E 7 2 114 E E 4 6 IGNITION CAPACITOR 8 -2 PI1-120 O PI1-114 O PI1-113 O PI1-117 O PI1-115 O PI1-119 O PI1-118 O PI1-112 O PI1-087 O PI1-088 I PI1-131 O PI1-089 O PI1-090 O PI1-061 O PI1-062 I PI1-132 O PI1-063 O PI1-064 O PI1-051 O PI1-027 PI1-009 PI1-019 PI1-012 I PI1-121 I PI1-047 I PI1-048 YR YB B RW GR GB B RW RW RW RW RW RW RW RW RW RW 115 E E BG BK BG BW BR BO U UY GU Y GB YR GR GW GW YB GR YR WU PI6 -4 -2 -3 -1 PI7 -4 -2 -3 -1 PI8 -4 -2 -3 -1 PI9 -4 -2 -3 -1 GW GB B RW PI2 -4 -2 -3 -1 PI3 -4 -2 -3 -1 PI4 -4 -2 -3 -1 PI5 -4 -2 -3 -1 GW YB B RW PI39 -1 GR GB B RW -2 YR YB B RW PI38 -1 138 O I 3 Y YB B RW -2 GU GB B RW PI37 -1 NR -2 UY PI36 -1 NR -2 U PI35 -1 NR -2 BO PI34 -1 NR -2 BR PI33 -1 NR 7 -2 BW 8 PI32 -1 NR 5 IGNITION MODULES AND COILS 2 7 PI54 PI54 -1 -2 BG 6 5 NR 3 BK 4 NR 1 BG 2 3 RW PIS8 B B B B B B B B B PIS31 B G26CS (G30CS) PIS9 PIS10 GU B FAN NG B WU WR U BG OY WU PI42-1 PIS21 PIS22 BG PI41-28 OY WU PI41-17 U BG OY WU PI41-18 PI41-19 YR YG WU I EC21-1 GC1-1 U EC53-4 GN ECS31 P EC20-2 ECS32 G3AS YR YG PI41-25 COOLING FAN MODULE AND MOTOR PI41-24 N PI41-26 N B I CR4-3 R R NOTE: ECM power supplies and grounds shown in Fig. 03.3. KB FP4-2 Y CR73-4 B FUEL TANK CRS56 YG RESUME SW8-6 YG + S NOTE: The ECM communicates (CAN / SCP) with the REM for Fuel Pump diagnostics. G24AL CR13-1 Y 20.2 20.3 20.2 20.3 P CR73-02 CRS75 B CR77-2 IP55-11 (LHD) IP9-3 (RHD) 1κ Ω B 44 O FP2-1 B CASSETTE 78 II VIA INERTIA SWITCH CR73-3 Y FUEL PUMP CR12-8 GU O FP2-4 FP4-4 NW CR11-19 EC46-16 (LHD) EC61-3 (RHD) B – S CR13-2 U G24BR B CR71-15 G24BL CR11-25 SET + CR11-12 N 510 Ω B CR11-26 B B B B CR73-01 300 Ω 28 180 Ω G24AR II SET – YR SW8-8 RESISTOR PACK YR IP55-12 (LHD) IP9-4 (RHD) EC11 -2 -3 REAR ELECTRONIC MODULE U WG BG CASSETTE OY CANCEL WU 120 Ω FUEL PUMP RELAY -1 CY1 -2 -1 4 STEERING WHEEL SPEED CONTROL SWITCHES CR5-1 B NOTE: Vehicles with Adaptive Speed Control – refer to Speed Control Switches, Fig. 05.4. CRS23 R6 5 3 2 1 59 F33 20A B CR82-7 G23AL AIR CONDITIONING PRESSURE SENSOR 125 BRAKE CANCEL SWITCH E FUEL PUMP DIODE (D1) REAR POWER DISTRIBUTION FUSE BOX 7 14 EC20-1 B 1 137 E GC1-2 ENGINE CONTROL MODULE (Continued from Fig. 03.3) 2.2κ Ω Fig. 03.4 Engine Management System: V8 N/A – Part 2 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: V8 N/A Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 G24BL G24BR Fig. 03.5 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS O O PG PG I I I I SS SS SG SG SG SG B+ B+ B+ SG SG I I SG O O SG I SG SG I O SG O O O O O O I O O I SG I I I I I I I I O SG SG I I SG O O I SG I I SG I I D O I I SG SG C C I I I SG B+ PI1-001 PI1-002 PI1-004 PI1-005 PI1-006 PI1-007 PI1-008 PI1-010 PI1-012 PI1-013 PI1-017 PI1-018 PI1-019 PI1-020 PI1-022 PI1-023 PI1-024 PI1-029 PI1-030 PI1-031 PI1-036 PI1-037 PI1-040 PI1-041 PI1-043 PI1-044 PI1-045 PI1-046 PI1-050 PI1-052 PI1-054 PI1-055 PI1-056 PI1-057 PI1-058 PI1-059 PI1-060 PI1-065 PI1-066 PI1-067 PI1-068 PI1-069 PI1-070 PI1-071 PI1-072 PI1-073 PI1-075 PI1-076 PI1-078 PI1-079 PI1-080 PI1-081 PI1-082 PI1-083 PI1-084 PI1-091 PI1-092 PI1-093 PI1-094 PI1-095 PI1-098 PI1-099 PI1-100 PI1-102 PI1-103 PI1-105 PI1-106 PI1-107 PI1-108 PI1-111 PI1-116 PI1-123 PI1-124 PI1-127 PI1-128 PI1-129 PI1-130 PI1-134 HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE POWER GROUND 1: GROUND POWER GROUND 2: GROUND ENGINE CRANK: B+ IGNITION ON: B+ BRAKE ON / OFF SWITCH: NORMALLY OPEN / B+ WHEN ACTIVATED INERTIA SWITCH: NORMALLY CLOSED / OPEN CIRCUIT WHEN ACTIVATED SENSOR POWER SUPPLY 1: NOMINAL 5 V SENSOR POWER SUPPLY 2: NOMINAL 5 V SMALL SIGNAL GROUND1: GROUND SMALL SIGNAL GROUND 2: GROUND SENSOR GROUND 1: GROUND SENSOR GROUND 2: GROUND BATTERY POWER SUPPLY: B+ EMS SWITCHED POWER SUPPLY 1: B+ EMS SWITCHED POWER SUPPLY 2: B+ HO2 SENSOR HEATER GROUND – 1/1: GROUND HO2 SENSOR HEATER GROUND – 1/1: GROUND PARK / NEUTRAL SIGNAL: B+ WHEN ACTIVATED CRANKSHAFT SENSOR SIGNAL: PULSED SIGNAL, 70 PULSES PER ENGINE CYCLE CRANKSHAFT SENSOR SIGNAL GROUND: GROUND EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND TP AND APP SIGNALS SHIELD: GROUND MASS AIR FLOW SENSOR SIGNAL: NOMINAL 0 – 5 V BY ENGINE OPERATING CONDITION MASS AIR FLOW SENSOR GROUND: GROUND MASS AIR FLOW SENSOR GROUND: GROUND ENGINE FUEL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES THROTTLE MOTOR RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND THROTTLE MOTOR GROUND: GROUND HO2 SENSOR HEATER CONTROL – 2/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE HO2 SENSOR HEATER CONTROL – 2/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE EGR DRIVE 1: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN EGR DRIVE 2: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN EGR DRIVE 3: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN EGR DRIVE 4: B+; EGR DRIVE 1, 2 , 3 AND 4 ARE OPERATED IN TURN GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION EVAP CANISTER PURGE VALVE DRIVE: PWM, 10 Hz, POSITIVE DUTY CYCLE RANGE 7% – 100% EVAP CANISTER CLOSE VALVE DRIVE: TO CLOSE, ECM SWITCHES CIRCUIT TO GROUND BANK 2 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE BANK 2 CAMSHAFT SENSOR GROUND: GROUND ENGINE COOLANT TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INTAKE AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INTAKE AIR TEMPERATURE SENSOR 2 SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES INJECTION PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: POTENTIOMETER – VOLTAGE INCREASES AS PRESSURE INCREASES THROTTLE POSITION SENSOR 1 SIGNAL: IDLE = 0.60 V; FULL THROTTLE = 4.30 V THROTTLE POSITION SENSOR 2 SIGNAL: IDLE = 1.48 V; FULL THROTTLE = 4.40 V ENGINE OIL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES GENERATOR FAULT; CHARGE WARNING THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR HO2 SENSOR HEATER GROUND – 2/1: GROUND HO2 SENSOR HEATER GROUND – 2/1: GROUND HO2 SENSOR 1/1 SIGNAL: VARIABLE CURRENT HO2 SENSOR 1/1 SIGNAL: CONSTANT CURRENT HO2 SENSOR HEATERS 1/2, 2/2 GROUND: GROUND HO2 SENSOR HEATER CONTROL – 1/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100% HO2 SENSOR HEATER CONTROL – 2/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100% BANK 1 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE BANK 1 CAMSHAFT SENSOR GROUND: GROUND BANK 1 KNOCK SENSOR SIGNAL: VARIABLE VOLTAGE DEPENDENT ON ENGINE VIBRATION BANK 2 KNOCK SENSOR SIGNAL: VARIABLE VOLTAGE DEPENDENT ON ENGINE VIBRATION SENSOR SHIELD: GROUND ACCELERATOR PEDAL POSITION SENSOR 1 SIGNAL: FOOT OFF = 0.75 V; FULLY DEPRESSED = 3.40 V (AUTO) 3.20 (MAN) ACCELERATOR PEDAL POSITION SENSOR 2 SIGNAL: FOOT OFF = 3.38 V; FULLY DEPRESSED = 2.05 V (AUTO) 2.14 V (MAN) SERIAL DATA LINK: SERIAL COMMUNICATION THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR HO2 SENSOR 2/1 SIGNAL: VARIABLE CURRENT HO2 SENSOR 2/1 SIGNAL: CONSTANT CURRENT FUEL INJECTORS 2, 3, 5, 8 GROUND: GROUND FUEL INJECTORS 1, 4, 6, 7 GROUND: GROUND CAN – CAN + MAP SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE INCREASES AS MANIFOLD ABSOLUTE PRESSURE INCREASES HO2 SENSOR 1/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING HO2 SENSOR 2/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING HO2 SENSORS SHIELD: GROUND THROTTLE MOTOR POWER SUPPLY: B+ WHEN RELAY ACTIVATED Component Connector(s) Connector Description Location APP SENSOR CR14 6-WAY / BLACK TOP OF ACCELERATOR PEDAL BRAKE ON / OFF SWITCH CZ1 2-WAY / GREEN TOP OF BRAKE PEDAL CKP SENSOR – V8 PI21 2-WAY / BLACK ENGINE UNDER SIDE, FORWARD OF BELL HOUSING CMP SENSOR 1 – V8 PI23 2-WAY / BLACK BANK 1 (RH) CAMSHAFT COVER / REAR CMP SENSOR 2 – V8 PI22 2-WAY / BLACK BANK 2 (LH) CAMSHAFT COVER / REAR ECT SENSOR PI25 2-WAY / BLACK ENGINE VEE / COOLANT OUTLET CASTING EFT SENSOR – V8 PI27 2-WAY / BLACK FUEL RAIL, RH REAR EGR VALVE – V8 SC PI15 6-WAY / BLACK INTAKE MANIFOLD, REAR ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE EOT SENSOR PI24 2-WAY / BLACK ADJACENT TO OIL FILTER EVAP CANISTER PURGE VALVE EC63 2-WAY / BLACK ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER EVAP CANISTER CLOSE VALVE CV2 2-WAY / BLACK ABOVE REAR AXLE (FUEL TANK COMPONENTS) FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT FTP SENSOR FP1 3-WAY / BLACK FUEL TANK PIPING, LH SIDE (UNDER ACCESS PLATE) HO2 SENSOR DOWNSTREAM 1/2 PI11 4-WAY / BLACK LH EXHAUST / TOP OF CATALYST HO2 SENSOR DOWNSTREAM 2/2 PI13 4-WAY / BLACK LH EXHAUST / CATALYST CENTER HO2 SENSOR UPSTREAM 1/1 PI10 4-WAY / BLACK RH EXHAUST / TOP OF CATALYST HO2 SENSOR UPSTREAM 2/1 PI12 4-WAY / BLACK LH EXHAUST / TOP OF CATALYST IAT SENSOR 2 PI43 2-WAY / BLACK INTAKE MANIFOLD, RH SIDE, REAR IP SENSOR – V8 SC PI28 3-WAY / BLACK FUEL RAIL, LH REAR KNOCK SENSOR 1 – V8 PI20 2-WAY / BLACK ENGINE VEE, BANK 1 KNOCK SENSOR 2 – V8 PI19 2-WAY / BLACK ENGINE VEE, BANK 2 MAF SENSOR PI14 5-WAY / BLACK ENGINE AIR INTAKE / ADJACENT TO AIR CLEANER MAP SENSOR – V8 SC PI29 4-WAY / BLACK INTAKE MANIFOLD, REAR, BELOW THROTTLE ASSEMBLY THROTTLE BODY – V8 SC — — ENGINE AIR INTAKE, REAR THROTTLE MOTOR PI18 2-WAY / BLACK THROTTLE BODY THROTTLE MOTOR RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R12 TP SENSOR PI26 4-WAY / BLACK THROTTLE BODY / THROTTLE SHAFT HARNESS IN-LINE CONNECTORS Connector Connector Description Location CR78 2-WAY / BLACK / BRAKE ON/OFF SWITCH ADJACENT TO PEDAL MOUNTING ASSEMBLY CV5 12-WAY / GREY / FUEL PUMP LINK HARNESS TO EVAP CANISTER CLOSE VALVE LINK HARNESS ABOVE REAR AXLE / CENTER EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC16 12-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Engine Management System: V8 SC – Part 1 HO2 SENSORS UPSTREAM 1/1 NOTES: *EVAP Canister Close Valve and Fuel Tank Pressure Sensor – NAS vehicles only. HO2 SENSORS DOWNSTREAM 2/1 U 1/2 1 2/2 λ U CMP SENSORS CKP SENSOR Fig. 03.5 Engine Management System: V8 SC – Part 1 MAF SENSOR KNOCK SENSORS 2 1 ECT SENSOR EOT SENSOR υ υ IP SENSOR EFT SENSOR MAP SENSOR FTP SENSOR* IATS 2 υ λ υ Shielding shown as dashed lines are braided wires. 142 PI1-093 I PI1-036 I PI1-094 PI1-100 I GR I Y PI1-069 C + I PI1-098 I PI1-099 I PI1-044 PI1-045 G C – PI1-046 W D I PI1-071 I PI1-070 PI1-019 9 GU F24 20A 116 6 PI1-068 I PI1-078 I PI1-073 I PI1-050 EC26-5 GU PI41-38 GR GR 7 E EC19-5 B PI1-134 PI41-39 I PI1-127 I PI1-104 I PI1-103 I PI1-102 O PI1-020 PI1-052 PI1-013 PI1-043 B B B B B B B B B B B B PI1-080 O PI1-106 I PI1-076 I PI1-075 O PI1-057 O PI1-058 O PI1-059 O PI1-060 I PI1-008 PI1-017 PI1-018 P PI1-005 PI1-029 PI1-054 PI1-091 P PI1-004 O PI1-067 O PI1-066 PI1-030 PI1-111 PI1-116 I PI1-081 PIS30 PIS28 B B G26BR (G30BR) G26AL (G30AL) 7 6 63 95 Fig. 01.2 1 15 II BG RG OY OY BK BG YR BG OY BG U Y BG UY BG U BK GW B N GU B N G N R Y O WR B RW BG 16 52 Fig. 01.4 53 77 II S II BG S OY PI41-7 PI41-12 PI41-3 B Y R BG Y W Y R BG Y W PI41-8 OY ECS32 PI41-18 EC61-5 (LHD) EC16-7 (RHD) EC61-6 (LHD) EC16-8 (RHD) EC16-7 (LHD) EC61-10 (RHD) EC16-8 (LHD) EC61-11 (RHD) PI41-6 W EC61-7 (LHD) EC16-1 (RHD) EC16 -5 EC16 -9 135 136 GO O PI41-23 PI41-29 GO O O EC1-3 (LHD) EC53-10 (RHD) FP6-20 EC53-3 (LHD) EC53-5 (RHD) CV5-8 132 -2 EC63 -2 -1 CRS16 83 E CV2 -2 -1 E PI15 -3 CZ1 -2 -1 PI15 -6 PI15 -1 PI15 -4 PI15 -5 4 3 2 1 STEPPER MOTOR Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E EVAP CANISTER PURGE VALVE EVAP CANISTER CLOSE VALVE* I Input B + O Output P Power Ground Battery Voltage CR14 -2 CR14 -6 CR78-2 133 E PI41-10 E GO υ E OY PIS41 PIS40 UY YU S ECS31 PIS47 ENGINE CONTROL MODULE (Continued Fig. 03.6) Fig. 01.3 RG BG PI26 -1 PI26 -3 PI26 -2 TP1 TP2 PI26 -4 PI18 -2 BRAKE ON / OFF SWITCH + Sensor/Signal Supply V – Sensor/Signal Ground EGR VALVE A ACP S SCP C CAN D Serial and Encoded Data PI18 -1 CR14 -5 CR14 -3 CR14 -4 CR14 -1 PI15 -2 TP SENSOR 64 I BG PI41-17 G26AR (G30AR) Fig. 01.1 EC1 -7 PIS49 PIS25 IAT SENSOR 2 1 EC1 -5 (LHD) EC53 -9 (RHD) PIS48 BG YU YG YR YU GO O PI1-072 FP6 -10 PI41 -14 PI43 -1 B N EC1 -6 PI1-082 PIS29 WG PIS13 BG FRONT POWER DISTRIBUTION FUSE BOX O FP6 -21 OY O FP6 -11 Y PI1-129 BG PIS12 BG PI1-092 I BG PIS19 B BG PI1-128 B RG I O PIS11 BG BG B BG PI1-056 BG B BG PI1-055 O PI1-012 10 E OY PI1-108 PI1-095 THROTTLE MOTOR RELAY 8 134 E OY I O PI1-105 27 FP1 -1 -2 -3 R PI1-107 O PI1-123 R12 -2 PI29 -2 -1 -4 BG I GO 20.2 -1 PI27 -1 Y I PI1-037 PI1-031 20.3 -2 OY PI1-002 PI1-124 SERIAL COMMUNICATION -2 PI28 -3 GW PI1-001 O PI1-079 20.1 -1 PI24 -1 RW PI1-084 O YR 20.1 -5 PI25 -2 OY BW 02.2 -4 Y 04.1 PI19 -2 -1 -2 R I PI1-041 PARK; NEUTRAL (CIRCUIT CONTINUED) PI58 -2 -1 -3 BG 02.2 PI14 -1 GU STARTER RELAY DRIVE PI22 -2 GU Y PI1-040 02.2 I O R Y RU RU G N RW RW BW N UY N RW B O Y R BG N G N N GW BK BK U UY BG Y U YR OY BK RG O B BG Y BG GW RW Y R PI1-130 PI1-006 GENERATOR: FAULT; CHARGE WARNING PI22 -1 YU 01.8 PI23 -1 YG EMS CONTROL RELAY PI23 -2 YR 02.2 PI1-083 I PI1-010 ENGINE CRANK PI21 -2 YU GU II PI21 -1 GO NG I PI1-007 43 -1 141 GU GO II I O B PI1-024 18 -3 -2 E GU WG E VIA INERTIA SWITCH B PI1-023 107 PI13 -4 143 E UY WG E -1 B PI1-022 106 -3 -2 140 E NR 7 PI11 -4 B UY -1 N G -4 -2 WR PI12 -3 N RW -1 WG -4 -2 Y RU R PI10 -3 B BRD APP1 THROTTLE MOTOR THROTTLE BODY VARIANT: V8 SC Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 APP SENSOR APP2 Fig. 03.6 CONTROL MODULE PIN-OUT INFORMATION Engine Control Module Pin Description and Characteristic COMPONENTS I PI1-009 BRAKE CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED Component Connector(s) Connector Description Location AIR CLEANER SOLENOID VALVE EC37 2-WAY / BLACK AIR CLEANER HOUSING I PI1-011 FUEL PUMP 2 MODULE MONITOR: 1Hz FREQUENCY; 50% DUTY CYCLE = OK, 25% OR 75% DUTY CYCLE = FAULT SS PI1-012 SENSOR POWER SUPPLY 1: NOMINAL 5 V SS PI1-013 SENSOR POWER SUPPLY 2: NOMINAL 5 V AIR CONDITIONING PRESSURE SENSOR EC11 3-WAY / BLACK ADJACENT TO RADIATOR / LH SIDE O PI1-014 AIR CLEANER SOLENOID VALVE DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND BRAKE CANCEL SWITCH CY1 2-WAY / GREY TOP OF BRAKE PEDAL COOLING FAN MODULE AND MOTOR GC1 EC20 2-WAY / GREY 2-WAY / GREY RADIATOR COOLING FAN SG PI1-019 SENSOR GROUND 1: GROUND O PI1-027 FUEL PUMP DRIVE SIGNAL (TO RECM): PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% SS PI1-047 SPEED CONTROL SWITCH REQUEST: STEPPED RESISTANCE ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE I PI1-048 SPEED CONTROL SWITCHES SIGNAL GROUND: GROUND THROTTLE BODY – V8 SC — — ENGINE AIR INTAKE, REAR O PI1-051 COOLING FAN MODULE CONTROL: PWM, 140Hz, POSITIVE DUTY CYCLE RANGE 7% – 95% FUEL INJECTOR 1 – V8 SC IS1 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-053 FUEL PUMP 2 DRIVE (TO FUEL PUMP 2 MODULE): PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% FUEL INJECTOR 2 – V8 SC IS7 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-061 IGNITION COIL ACTIVATE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-062 IGNITION COIL ACTIVATE – CYLINDER 4: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 3 – V8 SC IS2 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-063 IGNITION COIL ACTIVATE – CYLINDER 6: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 4 – V8 SC IS8 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-064 IGNITION COIL ACTIVATE – CYLINDER 8: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 5 – V8 SC IS3 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-087 IGNITION COIL ACTIVATE – CYLINDER 1: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 6 – V8 SC IS9 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-088 IGNITION COIL ACTIVATE – CYLINDER 3: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 7 – V8 SC IS4 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-089 IGNITION COIL ACTIVATE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL INJECTOR 8 – V8 SC IS10 2-WAY / BLACK FUEL RAIL / INTAKE MANIFOLD O PI1-090 IGNITION COIL ACTIVATE – CYLINDER 7: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL PUMP 1 FP4 4-WAY / BLACK FUEL TANK / RH SIDE O PI1-112 FUEL INJECTOR DRIVE – CYLINDER 8: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND FUEL PUMP 2 FP3 4-WAY / BLACK FUEL TANK / LH SIDE O PI1-113 FUEL INJECTOR DRIVE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-114 FUEL INJECTOR DRIVE – CYLINDER 3: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-115 FUEL INJECTOR DRIVE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND O PI1-117 O FUEL PUMP 2 MODULE CR26 11-WAY / BLACK TRUNK / RH REAR FUEL PUMP RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R6 FUEL INJECTOR DRIVE – CYLINDER 7: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION CAPACITOR PI54 2-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / CENTER PI1-118 FUEL INJECTOR DRIVE – CYLINDER 6: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION MODULE AND COIL 1 PI2 4-WAY / BLACK RH CYLINDER HEAD O PI1-119 FUEL INJECTOR DRIVE – CYLINDER 4: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION MODULE AND COIL 2 PI6 4-WAY / BLACK LH CYLINDER HEAD O PI1-120 FUEL INJECTOR DRIVE – CYLINDER 1: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND IGNITION MODULE AND COIL 3 PI3 4-WAY / BLACK RH CYLINDER HEAD I PI1-121 AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES IGNITION MODULE AND COIL 4 PI7 4-WAY / BLACK LH CYLINDER HEAD I PI1-131 IGNITION MONITOR BANK 1: PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE IGNITION MODULE AND COIL 5 PI4 4-WAY / BLACK RH CYLINDER HEAD I PI1-132 IGNITION MONITOR BANK 2: PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE Rear Electronic Module IGNITION MODULE AND COIL 6 PI8 4-WAY / BLACK LH CYLINDER HEAD IGNITION MODULE AND COIL 7 PI5 4-WAY / BLACK RH CYLINDER HEAD IGNITION MODULE AND COIL 8 PI9 4-WAY / BLACK LH CYLINDER HEAD Pin Description and Characteristic INTERCOOLER COOLANT PUMP CP2 2-WAY / BLACK ENGINE COMPARTMENT / COOLING PACK / RH SIDE B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR STEERING WHEEL SPEED CONTROL SWITCHES — — STEERING WHEEL SG CR11-12 LOGIC GROUND: GROUND I CR11-19 FUEL PUMP (1) DRIVE SIGNAL: PWM, 150 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51% SG CR11-25 LOGIC GROUND: GROUND SG CR11-26 LOGIC GROUND: GROUND B+ CR12-08 IGNITION SWITCHED POWER SUPPLY (II) (FUEL PUMP CONTROL): B+ S CR13-01 SCP NETWORK + S CR13-02 SCP NETWORK – SG CR71-15 LOGIC GROUND: GROUND B+ CR73-01 FUEL PUMP POWER SUPPLY: B+ WHEN FUEL PUMP RELAY ACTIVATED PG CR73-02 POWER GROUND (FUEL PUMP): GROUND O CR73-03 FUEL PUMP GROUND: GROUND, PWM O CR73-04 FUEL PUMP B+: B+ HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Connector Connector Description Location CP1 CR77 EC16 EC21 EC46 EC53 EC61 FP2 IP9 IP55 IS5 IS6 PI41 PI42 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INTERCOOLER COOLANT PUMP HARNESS 2-WAY / BLACK / BRAKE CANCEL SWITCH 12-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS 2-WAY / BLACK / ENGINE HARNESS TO COOLING FAN MODULE 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS 6-WAY / GREY / CABIN HARNESS TO FUEL PUMP HARNESS 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS 6-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK 6-WAY / BLACK / ENGINE HARNESS TO FUEL INJECTOR LINK 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES 8-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE ADJACENT TO PEDAL MOUNTING ASSEMBLY CABIN / RH ‘A’ POST ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE CABIN / RH ‘A’ POST CABIN / ABOVE LH FOOTWELL CABIN / LH UPPER ‘A’ POST CABIN / BELOW REAR SEAT CUSHION / RH SIDE CABIN / ADJACENT TO HOOD RELEASE CABIN / RH ‘A’ POST ENGINE COMPARTMENT / ENGINE / LH REAR ENGINE COMPARTMENT / ENGINE / RH REAR ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE GROUNDS Ground Location G23 G24 G26 G30 TRUNK / RH SIDE / ADJACENT TO BATTERY TRUNK / RH SIDE / REAR ELECTRONIC MODULE ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Engine Management System: V8 SC – Part 2 FRONT OF ENGINE FUEL INJECTORS 1 8 IS5 -2 119 E IS5 -4 121 E IS6 -2 O PI1-114 O PI1-113 O PI1-117 O PI1-115 O PI1-119 O PI1-118 O PI1-112 O PI1-087 O PI1-088 I PI1-131 O PI1-089 O PI1-090 O PI1-061 O PI1-062 I PI1-132 O PI1-063 O PI1-064 O PI1-051 O PI1-027 O PI1-053 I PI1-011 I PI1-009 PI1-019 PI1-012 I PI1-121 O PI1-014 I PI1-047 I PI1-048 7 2 4 6 IGNITION CAPACITOR 8 -2 E IS6 -4 IS6 -5 RW E BG BK BG BW BR BO U UY GU Y GB YR GR GW GW YB GR YR WU YR YB B RW GR GB B RW GW GB B RW GR GB B RW PI6 -4 -2 -3 -1 PI7 -4 -2 -3 -1 PI8 -4 -2 -3 -1 PI9 -4 -2 -3 -1 RW 124 E YR YB B RW PI2 -4 -2 -3 -1 PI3 -4 -2 -3 -1 PI4 -4 -2 -3 -1 PI5 -4 -2 -3 -1 138 PI1-120 5 GW YB B RW IS10 -1 123 E IS6 -3 -2 Y YB B RW IS9 -1 122 E IS5 -5 -2 GU GB B RW IS8 -1 NR -2 BW IS7 -1 120 E IS5 -3 -2 NR IS4 -1 BU -2 NR IS3 -1 118 E O 3 PIS44 RW RW PIS46 PIS45 RW RW RW RW RW RW RW RW B B B B PIS42 B B 117 -2 BK IS2 -1 NR CYLINDER NUMBERING -2 BG IS1 -1 NR 7 6 4 PI54 PI54 -1 -2 BW 8 IGNITION MODULES AND COILS 2 7 NR 5 BU 6 5 NR 3 3 BK 4 1 NR 1 BG 2 Fig. 03.6 Engine Management System: V8 SC – Part 2 B B B B INTERCOOLER PUMP PIS43 B B ECS3 B B NG CP2-1 CP1-9 139 E CP2-2 G3BL G26CS (G30CS) PIS9 PIS10 GU B 137 E GC1-2 FAN NG B 14 EC20-1 WU WR WU Y U BG OY WU U WU PI42-1 I EC21-1 GC1-1 GN BG OY WU PIS21 PIS22 U BG OY WU U PI41-28 PI41-17 PI41-18 PI41-19 PI42-7 YR YG EC20-2 EC53-4 BG OY ECS31 G3AS COOLING FAN MODULE AND MOTOR ECS32 YR YG PI41-25 P U N PI41-24 PI41-26 B FUEL PUMP 1 KB B FP2-4 Y FP4-2 I CRS56 FP2-1 B R CR4-3 B CR12-8 NW Y 78 II O B G24BL 44 VIA INERTIA SWITCH CR73-4 B G24AL GU O CR73-3 CRS75 B NOTE: ECM power supplies and grounds shown in Fig. 03.5. B CR11-19 R FP4-4 ENGINE CONTROL MODULE (Continued from Fig. 03.5) N EC46-16 (LHD) EC61-3 (RHD) + S Y CR13-1 20.2 20.3 20.2 20.3 P CR73-02 – S U CR13-2 G24BR CASSETTE 2.2κ Ω RESUME SW8-6 KB IP55-11 (LHD) IP9-3 (RHD) 1κ Ω R B Y FP2-2 FP3-4 300 Ω 131 180 Ω 28 II E SET – IP55-12 (LHD) IP9-4 (RHD) RESISTOR PACK EC37 -2 FUEL TANK EC11 -2 -3 G24AR CRS56 B CY1 -2 FUEL PUMP RELAY G24AL -1 WU WU PI42-2 STEERING WHEEL SPEED CONTROL SWITCHES WU EC16-12 (LHD) EC61-8 (RHD) CR68-5 I B CR26-1 CRS23 W 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Y PI42-3 AIR CLEANER SOLENOID VALVE 1 Y Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E AIR CONDITIONING PRESSURE SENSOR I Input B + O Output P Power Ground Battery Voltage EC46-13 (LHD) EC53-7 (RHD) BRAKE CANCEL SWITCH + Sensor/Signal Supply V – Sensor/Signal Ground S SCP C CAN D Serial and Encoded Data 4 R6 5 3 2 1 59 F24 20A B CR82-7 G23AL 125 O E CR26-7 FUEL PUMP DIODE (D1) FUEL PUMP 2 MODULE A ACP F33 20A N CR26-9 CR26-4 Y NOTE: Vehicles with Adaptive Speed Control – refer to Speed Control Switches, Fig. 05.4. G24BL P CR26-2 CR5-1 -1 CR11-26 REAR ELECTRONIC MODULE B -1 CR11-12 O B U WG BG OY YR SW8-8 WU U CASSETTE GU CANCEL B CR73-01 CR26-3 B 120 Ω CR11-25 N O CR26-10 Y FUEL PUMP 2 510 Ω R FP2-5 FP3-2 SET + B B B B CR71-15 CR77-2 YG VARIANT: V8 SC Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 REAR POWER DISTRIBUTION FUSE BOX G24BR Fig. 04.1 CONTROL MODULE PIN-OUT INFORMATION Transmission Control Module Pin Description and Characteristic COMPONENTS B+ GB2-09 IGNITION SWITCHED POWER SUPPLY (II): B+ Component Connector(s) Connector Description IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN Location O GB2-10 PARK / NEUTRAL SIGNAL: GROUND WHEN ACTIVATED PG GB2-13 POWER GROUND: GROUND B+ GB2-14 BATTERY POWER SUPPLY: B+ J-GATE MODULE IP32 16-WAY / BLACK J GATE ASSEMBLY PG GB2-16 POWER GROUND: GROUND TCM CAPACITOR – V6 GB17 2-WAY / BLACK ENGINE COMPARTMENT / BULKHEAD TCM CAPACITOR – V8 PI59 2-WAY / BLACK ENGINE COMPARTMENT / BULKHEAD TRANSMISSION CONTROL MODULE GB2 16-WAY / BLACK TRANSMISSION CONTROL VALVE NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description Location GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING GROUNDS Ground Location G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER G32 CABIN / BEHIND INSTRUMENT CLUSTER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 GO 51 II 03.5 03.3 03.1 02.2 02.1 GR GR ECM: PARK, NEUTRAL (CIRCUIT CONTINUED) NR NR GBS4 GB1-8 O 6 O 5 O 4 O 3 O 2 O 1 TCC PRESSURE REGULATOR SOLENOID GB2-10 NOTE: GB1-6 – V6 only. NR 8 O B Fig. 04.1 Automatic Transmission SHIFT SOLENOID O B GB2-9 GB1-6 V6 Automatic Transmission PRESSURE REGULATOR SOLENOIDS GB2-14 NR υ I FLUID TEMPERATURE SENSOR GB17-1 B GB17-2 CAN REFER TO APPENDIX TCM / CAN MESSAGES 09.2 GEAR SELECTOR AND MODE SWITCH ILLUMINATION 07.1 KEY-IN AUDIBLE WARNING (CIRCUIT CONTINUED) V6 TCM CAPACITOR (V6) B B B GBS3 GB1-10 B B PIS30 TURBINE SPEED SENSOR I P I II O GEARSHIFT INTERLOCK SOLENOID N OUTPUT SPEED SENSOR 50 IP32-1 R G30 (G26) GO B P GB2-16 GB1-9 B P GB2-13 D O 2 I V8 NR 8 NR PIS54 I NR D GEAR POSITION SWITCH R 5 5 B V8 IP32-3 4 N I PI59-1 PI59-2 3 R GB2-14 RW I P B MODE SWITCH 4 I 3 TCM CAPACITOR (V8) 20.1 Y C + IP32-9 B B PIS53 P P G – C CAN MESSAGES: • GEAR SELECTOR POSITIONS 2 3 4 5 • BRAKE ON / OFF 20.1 20.1 G 20.1 Y R IPS11 IP32-4 RU IP34-3 NOT-IN-PARK SWITCH C + IP34-4 KEY LOCK SOLENOID * IP32-11 20.1 G30 (G26) R C – IP32-10 GB2-2 GB2-16 B 20.1 GB2-6 B PIS30 Y + C GB2-13 G C – IP32-12 TRANSMISSION CONTROL MODULE B P IP32-2 B IPS5 IGNITION SWITCH G32AL J-GATE MODULE AUTOMATIC TRANSMISSION * NOTE: Key Lock SOlenoid – ROW only. 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 4 Fig. 05.1 CONTROL MODULE PIN-OUT INFORMATION Dynamic Stability Control Module Pin Description and Characteristic COMPONENTS B+ EC30-01 BATTERY POWER SUPPLY – PUMP: B+ Component Connector(s) Connector Description Location ACTIVE BRAKE BOOSTER — — ENGINE COMPARTMENT BULKHEAD / DRIVER SIDE – EC30-03 STEERING ANGLE SENSOR SIGNAL (A): PULSED SIGNAL B+ EC30-04 IGNITION SWITCHED POWER SUPPLY (II): B+ SG EC30-05 SENSOR GROUND – YAW RATE, STEERING ANGLE SENSORS: GROUND ACTIVE BRAKE BOOSTER SOLENOID EC3 6-WAY / BLACK ACTIVE BRAKE BOOSTER I EC30-06 STEERING ANGLE SENSOR SIGNAL (B): PULSED SIGNAL BRAKE FLUID RESERVOIR EC52 2-WAY / BLACK ENGINE COMPARTMENT / BRAKE BOOSTER AND MASTER CYLINDER ASSEMBLY ENGINE COMPARTMENT / BRAKE BOOSTER SS EC30-07 YAW RATE, STEERING ANGLE SENSORS SUPPLY VOLTAGE: B+ SG EC30-08 BRAKE FLUID LEVEL SENSOR SIGNAL GROUND: GROUND BRAKE PRESSURE SENSOR EC34 3-WAY BLACK I EC30-09 BRAKE FLUID LEVEL SENSOR SIGNAL: BRAKE FLUID LEVEL LOW = GROUND DYNAMIC STABILITY CONTROL MODULE EC30 47-WAY / BLACK ENGINE COMPARTMENT, RH FRONT C EC30-11 CAN + J-GATE MODULE IP32 16-WAY / BLACK J GATE ASSEMBLY PEDAL FORCE SWITCH EC3 6-WAY / BLACK ACTIVE BRAKE BOOSTER PEDAL TRAVEL SENSOR EC10 3-WAY BLACK ACTIVE BRAKE BOOSTER STEERING ANGLE SENSOR IP37 4-WAY / GREY STEERING COLUMN WHEEL SPEED SENSOR – LH FRONT EC44 2-WAY / BLACK LH FRONT WHEEL HUB C EC30-12 CAN + O EC30-13 VEHICLE SPEED SIGNAL (SLIDING ROOF THRESHOLD) : < 62 KM/H (38.5 MPH) = GROUND; > 62 KM/H (38.5 MPH) = B+ C EC30-14 CAN – C EC30-15 CAN – PG EC30-16 POWER GROUND – VALVES: GROUND SS EC30-17 ACTIVE BRAKE BOOSTER SOLENOID SUPPLY VOLTAGE: NOMINAL 5 V WHEEL SPEED SENSOR – RH FRONT EC15 2-WAY / BLACK LH REAR WHEEL HUB SS EC30-18 BRAKE PRESSURE SENSOR SUPPLY VOLTAGE: NOMINAL 5 V WHEEL SPEED SENSOR – LH REAR CV6 2-WAY / BLACK RH FRONT WHEEL HUB SG EC30-19 SENSOR GROUND – BRAKE PRESSURE SENSOR: GROUND WHEEL SPEED SENSOR – RH REAR CV8 2-WAY / BLACK RH REAR WHEEL HUB I EC30-20 BRAKE PRESSURE SENSOR SIGNAL, NOMINAL 0.5 – 4.5 V: VOLTAGE INCREASES AS PRESSURE INCREASES YAW RATE AND LATERAL ACCELERATION SENSORS CLUSTER IP23 6-WAY / BLACK CENTER CONSOLE / REWARD OF J GATE SG EC30-24 ACTIVE BRAKE BOOSTER TRAVEL SENSOR SIGNAL GROUND: GROUND C EC30-25 CAN – (LOCAL) SS EC30-26 ACTIVE BRAKE BOOSTER TRAVEL SENSOR SUPPLY VOLTAGE: NOMINAL 5 V HARNESS IN-LINE CONNECTORS SS EC30-27 ACTIVE BRAKE BOOSTER FORCE SWITCH NORMALLY OPEN (NOMINAL 5 V) : OPEN / CLOSED CIRCUIT Connector Connector Description Location CV5 12-WAY / GREY / FUEL PUMP LINK HARNESS TO EVAP CANISTER CLOSE VALVE LINK HARNESS ABOVE REAR AXLE / CENTER I EC30-28 ACTIVE BRAKE BOOSTER FORCE SWITCH SIGNAL: GROUND C EC30-29 CAN + (LOCAL) SS EC30-30 ACTIVE BRAKE BOOSTER FORCE SWITCH NORMALLY CLOSED (NOMINAL 5 V) : CLOSED / OPEN CIRCUIT EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST O EC30-31 ACTIVE BRAKE BOOSTER SOLENOID DRIVE: GROUND (PWM) FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE B+ EC30-32 BATTERY POWER SUPPLY – VALVES: B+ IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST SG EC30-33 RH FRONT WHEEL SPEED SENSOR SIGNAL GROUND: GROUND IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST I EC30-34 RH FRONT WHEEL SPEED SENSOR SIGNAL: 46 PULSES PER WHEEL REVOLUTION I EC30-36 LH REAR WHEEL SPEED SENSOR SIGNAL: 46 PULSES PER WHEEL REVOLUTION SG EC30-37 LH REAR WHEEL SPEED SENSOR SIGNAL GROUND: GROUND GROUNDS I EC30-40 ACTIVE BRAKE BOOSTER TRAVEL SENSOR SIGNAL, NOMINAL 0.5 – 4.5 V: VARIABLE VOLTAGE Ground Location G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G32 CABIN / BEHIND INSTRUMENT CLUSTER SG EC30-42 RH REAR WHEEL SPEED SENSOR SIGNAL GROUND: GROUND I EC30-43 RH REAR WHEEL SPEED SENSOR SIGNAL: 46 PULSES PER WHEEL REVOLUTION I EC30-45 LH FRONT WHEEL SPEED SENSOR SIGNAL: 46 PULSES PER WHEEL REVOLUTION SG EC30-46 LH FRONT WHEEL SPEED SENSOR SIGNAL GROUND: GROUND PG EC30-47 POWER GROUND – PUMP: GROUND FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Dynamic Stability Control BRAKE PRESSURE SENSOR REFER TO APPENDIX DSC / CAN MESSAGES 41 CAN W II 9 GO 50 10 II IP32-1 Y NR B NW B EC30-32 20.1 20.1 Y IP32-9 PUMP EC34 -2 G 20.1 20.1 IP32-10 Y + C 20.1 20.1 20.1 20.1 H H H H CV6-2 CV6-1 CV8-2 YAW RATE AND LATERAL ACCELERATION SENSORS CLUSTER STEERING ANGLE SENSOR CV8-1 G EC44-1 EC15-2 EC15-1 N B N C – EC30-18 C + EC30-19 BG R B IP37 -2 IP37 -3 IP37 -4 IP37 -1 Y U R BK + – C C IP23 -5 IP23 -3 IP23 -2 IP23 -1 BK R Y U WG I G Y B YU Y IP32-12 EC34 -1 EC30-20 EC30-12 G RH REAR WHEEL SPEED SENSOR EC44-2 C + G IP32-11 – C LH REAR WHEEL SPEED SENSOR GU EC30-15 DYNAMIC STABILITY CONTROL DISABLE EC34 -3 VALVES EC30-11 – C DSC SWITCH RH FRONT WHEEL SPEED SENSOR B I + C LH FRONT WHEEL SPEED SENSOR EC30-4 EC30-1 B Fig. 05.1 Dynamic Stability Control EC30-45 C – NG EC30-14 EC30-46 B P IP32-2 SLIDING ROOF: VEHICLE SPEED (CIRCUIT CONTINUED) B IPS5 14.1 G O IPS10 WU I EC30-34 EC30-13 IPS14 NG G32AL EC30-33 J-GATE MODULE WR I WR EC30-36 EC46-10 NR NR EC30-37 EC46-11 W I EC52-2 EC52-1 FP6-6 EC46-8 EC30-3 EC30-9 FP6-7 IP55-5 EC30-6 IP55-8 R O R EC30-7 EC30-8 IP55-18 BK BK EC30-5 IP8-11 Y + C EC30-29 LOCAL CV5-10 U I UY CV5-9 R Y I BRAKE FLUID RESERVOIR CV5-12 W N EC30-42 I FP6-9 EC46-7 N CV5-11 R W EC30-43 U W FP6-8 IP55-16 U – C EC30-25 IP55-17 B B G G U U YU YU YR YR WG WG BW BW RW RW EC30-24 EC30-26 PRESSURE PUMP I EC30-40 EC30-27 EC30-30 I EC30-28 O EC30-31 EC30-17 EC3 -4 CONTROL VALVES VALVES EC3 -3 EC3 -5 EC3 -2 EC3 -1 EC10 -3 EC10 -1 EC10 -2 B P EC30-16 PUMP B P EC30-47 DYNAMIC STABILITY CONTROL MODULE G2BR ACTIVE BRAKE BOOSTER SOLENOID G2BL PEDAL FORCE SWITCH ACTIVE BRAKE BOOSTER 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 PEDAL TRAVEL SENSOR Fig. 05.2 CONTROL MODULE PIN-OUT INFORMATION Instrument Cluster Pin Description and Characteristic COMPONENTS PG IP6-02 POWER GROUND: GROUND Component Connector(s) Connector Description Location INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL PARKING BRAKE MODULE CR32 CR50 12-WAY / GREY 4-WAY / BLACK TRUNK / RH SIDE / ADJACENT TO REM S IP6-10 SCP – O IP6-15 VAPS – DRIVE O IP6-16 VAPS + DRIVE B+ IP6-17 IGNITION SWITCHED POWER SUPPLY (VAPS): B+ S IP6-20 SCP + NOTE: Refer to the Appendix at the rear of this book for Network Messages. PARKING BRAKE MOTOR CV7 6-WAY / BLACK REAR SUSPENSION SUB FRAME PARKING BRAKE SWITCH TL82 8-WAY / BLACK CENTER CONSOLE / REWARD OF J GATE VARIABLE ASSIST STEERING ACTUATOR EC33 2-WAY / BLACK STEERING RACK PINION HOUSING HARNESS IN-LINE CONNECTORS Connector Connector Description CV1 6-WAY / GREY / FUEL PUMP LINK HARNESS TO PARKING BRAKE MOTOR HARNESS Location REAR OF FUEL TANK / RH SIDE FP2 6-WAY / GREY / CABIN HARNESS TO FUEL PUMP HARNESS CABIN / BELOW REAR SEAT CUSHION / RH SIDE FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST TL35 22-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE GROUNDS Ground Location G18 CABIN / BELOW REAR SEAT / LH SIDE G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE G31 CABIN / BEHIND PASSENGER AIR BAG FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Electronic Parking Brake; Variable Assist Power Steering Electronic Parking Brake; Variable Assist Power Steering Fig. 05.2 WU TL93-12 46 NW B CRS33 CR32-12 REFER TO APPENDIX EPB / SCP MESSAGES 20.3 20.2 20.3 20.2 Y S + CR32-1 SCP U RW O CR50-3 S – CR32-7 453 Ω RW 150 Ω TL82-4 TL82-6 RW FP2-6 TL35-5 CR32-10 I CR32-6 CV1-1 CR32-4 CV1-2 FP6-3 CV1-3 CV7-3 H WU CV7-5 YB YB FP6-4 CV7-6 Y Y YB I CV7-1 GW GW Y CV1-5 RW RW GW CR50-2 WU FP6-5 FP2-3 O WU WU WU CR50-1 CV1-4 CV7-4 PARKING BRAKE MOTOR RELEASE 453 Ω WU WU 150 Ω TL82-8 TL35-6 I CR32-5 WB 39 II NOTE: TLS55 – Heated Rear Seats vehicles only. APPLY YB 33 100 Ω II TL82-1 BK 100 Ω TL82-2 SWITCH ILLUMINATION BK 20.3 TLS55 20.2 Y S + IP6-20 VEHICLE SPEED 20.3 PARKING BRAKE SWITCH B IP6-17 20.2 U W O IP6-10 G18BL W IP9-5 (LHD) IP55-2 (RHD) IP6-16 S – RW O RW IP9-6 (LHD) IP55-3 (RHD) IP6-15 EC33-1 EC33-2 VARIABLE ASSIST STEERING ACTUATOR B P IP6-2 B IPS2 G31BL INSTRUMENT CLUSTER B P CR50-4 G24CS PARKING BRAKE MODULE ELECTRONIC PARKING BRAKE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II VARIABLE ASSIST POWER STEERING Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 05.3 CONTROL MODULE PIN-OUT INFORMATION Air Suspension Module Pin Description and Characteristic COMPONENTS B+ CR88-01 BATTERY POWER SUPPLY: B+ Component Connector(s) Connector Description AIR SUSPENSION COMPRESSOR EC60 2-WAY / BLACK LH FRONT OF VEHICLE / REARWARD OF FRONT BUMPER BEAM AIR SUSPENSION MODULE CR88 CR89 CR90 CR91 9-WAY / BLACK 12-WAY / BLACK 15-WAY / BLACK 18-WAY / BLACK CABIN REAR BULKHEAD / BEHIND REAR SEAT BACK / RH SIDE AIR SUSPENSION PRESSURE SENSOR CR92 3-WAY / BLACK TRUNK / UNDER SPARE WHEEL / AIR SUSPENSION VALVE BLACK AIR SUSPENSION RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R1 TRUNK / UNDER SPARE WHEEL Location B+ CR88-02 SWITCHED SYSTEM POWER SUPPLY (WAKE UP): B+ PG CR88-03 POWER GROUND: GROUND C CR88-07 CAN + C CR88-08 CAN – O CR89-01 LH FRONT DAMPER ACTUATOR DRIVE – : PWM – O CR89-02 LH REAR DAMPER ACTUATOR DRIVE – : PWM – O CR89-03 HEADLAMP LEVELING SENSOR: PWM O CR89-04 LH FRONT DAMPER ACTUATOR DRIVE + : PWM + AIR SUSPENSION VALVE BLOCK CR22 6-WAY / BLACK O CR89-05 RH FRONT DAMPER ACTUATOR DRIVE + : PWM + AIR SUSPENSION VENT SOLENOID EC62 2-WAY / BLACK AIR SUSPENSION COMPRESSOR ASSEMBLY O CR89-07 LH REAR DAMPER ACTUATOR DRIVE + : PWM + DAMPER ACTUATOR – LH FRONT EC47 2-WAY / BLACK LH FRONT DAMPER / TOP O CR89-08 RH REAR DAMPER ACTUATOR DRIVE + : PWM + DAMPER ACTUATOR – RH FRONT EC12 2-WAY / BLACK RH FRONT DAMPER / TOP O CR89-10 RH FRONT DAMPER ACTUATOR DRIVE – : PWM – DAMPER ACTUATOR – LH REAR TL33 2-WAY / BLACK LH REAR DAMPER / TOP O CR89-11 RH REAR DAMPER ACTUATOR DRIVE – : PWM – SS CR90-01 LH FRONT HEIGHT SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V I CR90-02 LH FRONT HEIGHT SENSOR SIGNAL : VARIABLE VOLTAGE 0 – 5 V SG CR90-03 LH FRONT HEIGHT SENSOR SIGNAL GROUND: GROUND SS CR90-04 RH FRONT HEIGHT SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V I CR90-05 RH FRONT HEIGHT SENSOR SIGNAL : VARIABLE VOLTAGE 0 – 5 V SG CR90-06 RH FRONT HEIGHT SENSOR SIGNAL GROUND: GROUND SS CR90-07 LH REAR HEIGHT SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V I CR90-08 LH REAR HEIGHT SENSOR SIGNAL: VARIABLE VOLTAGE 0 – 5 V DAMPER ACTUATOR – RH REAR CR23 2-WAY / BLACK RH REAR DAMPER / TOP FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT HEIGHT SENSOR – LH FRONT EC45 6-WAY / BLACK FRONT SUSPENSION SUB FRAME / LH SIDE HEIGHT SENSOR – LH REAR CV3 6-WAY / BLACK REAR SUSPENSION SUB FRAME / LH SIDE 6-WAY / BLACK FRONT SUSPENSION SUB FRAME / RH SIDE SG CR90-09 LH REAR HEIGHT SENSOR SIGNAL GROUND: GROUND SS CR90-10 RH REAR HEIGHT SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V I CR90-11 RH REAR HEIGHT SENSOR SIGNAL: VARIABLE VOLTAGE 0 – 5 V SG CR90-12 RH REAR HEIGHT SENSOR SIGNAL GROUND: GROUND HEIGHT SENSOR – RH FRONT EC18 SS CR90-13 PRESSURE SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V HEIGHT SENSOR – RH REAR CV4 6-WAY / BLACK REAR SUSPENSION SUB FRAME / RH SIDE I CR90-14 PRESSURE SENSOR SIGNAL: VARIABLE VOLTAGE 0 – 5 V INSTRUMENT CLUSTER CR90-15 PRESSURE SENSOR SIGNAL GROUND: GROUND 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL SG IP5 IP6 IP7 B+ CR91-01 AIR SPRING SOLENOID VALVES POWER SUPPLY: PWM + VERTICAL ACCELEROMETER – FRONT EC13 3-WAY / GREY RH FRONT WHEEL ARCH O CR91-02 LH FRONT AIR SPRING SOLENOID VALVE DRIVE: PWM – VERTICAL ACCELEROMETER – REAR TL34 3-WAY / GREY TRUNK / RH SIDE / FORWARD OF CONTROL MODULES O CR91-03 RH FRONT AIR SPRING SOLENOID VALVE DRIVE: PWM – O CR91-05 LH REAR AIR SPRING SOLENOID VALVE DRIVE: PWM – O CR91-06 RH REAR AIR SPRING SOLENOID VALVE DRIVE: PWM – HARNESS IN-LINE CONNECTORS O CR91-08 RESERVOIR SOLENOID VALVE DRIVE: PWM – Connector Connector Description B+ CR91-10 COMPRESSOR VENT VALVE POWER SUPPLY: PWM + O CR91-11 COMPRESSOR VENT VALVE DRIVE: PWM – CV5 12-WAY / GREY / FUEL PUMP LINK HARNESS TO EVAP CANISTER CLOSE VALVE LINK HARNESS ABOVE REAR AXLE / CENTER O CR91-12 AIR SUSPENSION RELAY ACTIVATE: PWM – EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST CABIN / RH ‘A’ POST Location I CR91-14 REAR VERTICAL ACCELEROMETER SIGNAL: VARIABLE VOLTAGE 0 – 5 V EC16 12-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS SS CR91-16 ACCELEROMETER SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST I CR91-17 FRONT VERTICAL ACCELEROMETER SIGNAL: VARIABLE VOLTAGE 0 – 5 V EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST SG CR91-18 ACCELEROMETER SIGNAL GROUND: GROUND FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE Instrument Cluster Pin Description and Characteristic GROUNDS S IP6-10 SCP – Ground Location C IP6-18 CAN + C IP6-19 CAN – G1 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY S IP6-20 SCP + G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G17 CABIN / BELOW REAR SEAT / RH SIDE NOTE: Refer to the Appendix at the rear of this book for Network Messages. FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Air Suspension System NW 6 REFER TO APPENDIX ASM / CAN MESSAGES B N 98 S Y O CR88-1 CAN 08.6 CR89-3 B Fig. 05.3 Air Suspension System HEADLAMP UNITS: HEADLAMP LEVELING SENSOR INPUT CR88-2 AIR SUSPENSION VALVE BLOCK 20.3 20.2 Y S + LH FRONT DAMPER ACTUATOR AIR SPRING SOLENOIDS IP6-20 BRAKE ON / OFF; TRAILER TOW 20.3 20.2 U LH RH FRONT FRONT S – IP6-10 + Y C 20.1 Y 20.1 IP6-18 – + C – RH REAR RESERVOIR SOLENOID PRESSURE SENSOR LH REAR DAMPER ACTUATOR RH REAR DAMPER ACTUATOR CR88-7 G C C LH REAR RH FRONT DAMPER ACTUATOR IP6-19 G 20.1 20.1 CR88-8 EC47 EC47 -1 -2 INSTRUMENT CLUSTER YG B CR22 CR22 -6 -1 CR22 -2 CR22 -3 CR22 -4 CR22 -5 EC12 EC12 -1 -2 TL33 -1 TL33 -2 CR23 CR23 -1 -2 CR92 CR92 CR92 -2 -1 -3 CR91-1 G G EC45-5 LH FRONT HEIGHT SENSOR EC61-1 CR91-2 CR90-1 GU H GU EC45-4 EC61-14 I CR91-3 GB EC61-2 WB O CR90-2 GB EC45-1 WR O WU O CR91-5 CR90-3 WG O GO GO EC18-5 RH FRONT HEIGHT SENSOR EC1-17 CR90-4 GW H CR91-6 EC18-4 EC46-17 CR91-8 I CR90-5 GR EC46-15 G I GR EC18-1 BO O GW CR90-14 BK CR90-6 CR90-15 BW BW CV3-5 RH REAR HEIGHT SENSOR BR H BW CV5-4 FP6-16 BR CV3-4 BR CV5-6 BK FP6-18 BK CV3-1 Y CR90-13 CR90-7 I FP6-17 – YR CV4-5 LH REAR HEIGHT SENSOR H FP6-1 YG CV4-4 CV4-1 CR90-10 FP6-15 YU – WU EC16-3 BG BG O CR89-10 I CR90-11 FP6-2 WU O + EC16-4 WG O YU CV5-2 EC61-4 CR89-5 YG CV5-3 YU BO BO CR89-1 YR CV5-1 YG WR EC61-15 O CR90-9 + YR WR O CR89-4 BK CV5-5 + CR90-8 WG CR89-7 CR90-12 – TL93-9 BK BK O CR89-2 + TL93-10 WB O CR89-8 Y Y EC13-3 Y CRS31 EC1-11 – G CR89-11 G EC13-2 EC1-12 BK I CR91-17 BK EC13-1 BG O CR91-16 BK CRS32 EC1-13 R1 CR91-18 31 FRONT VERTICAL ACCELEROMETER 3 4 5 NR O Y 2 NR CR91-12 EC16-2 TL34-3 TL93-8 I U O COMPRESSOR ECS4 G2AR U CR91-11 CR91-14 BK TL34-1 B EC60-1 FRONT POWER DISTRIBUTION FUSE BOX GO BK EC60-2 B EC41-9 AIR SUSPENSION RELAY TL93-6 GO TL34-2 EC32-2 1 EC40-1 Y B R F6 40A EC61-9 YU B CR91-10 TL93-7 REAR VERTICAL ACCELEROMETER EC62-1 YU EC61-13 EC62-2 B P VENT SOLENOID AIR SUSPENSION COMPRESSOR CR88-3 G17AL AIR SUSPENSION MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 G1BS Fig. 05.4 CONTROL MODULE PIN-OUT INFORMATION Adaptive Speed Control Module Pin Description and Characteristic COMPONENTS B+ EC23-01 SWITCHED SYSTEM POWER SUPPLY: B+ Component Connector(s) Connector Description PG EC23-02 POWER GROUND: GROUND C EC23-04 CAN – ADAPTIVE SPEED CONTROL CHIME MODULE IP11 4-WAY / BLACK INSTRUMENT PANEL / BEHIND GLOVE BOX O EC23-06 CHIME MODULE DRIVE: CHIME ACTIVATE ADAPTIVE SPEED CONTROL MODULE EC23 12-WAY / BLACK LH FRONT OF VEHICLE / REARWARD OF FRONT BUMPER B+ EC23-07 IGNITION SWITCHED POWER SUPPLY (II): B+ AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN C EC23-10 CAN + DYNAMIC STABILITY CONTROL MODULE EC30 47-WAY / BLACK ENGINE COMPARTMENT, RH FRONT I/O EC23-12 FORWARD ALERT SWITCH / INDICATOR DRIVE: MONITOR FORWARD ALERT SWITCH / FORWARD ALERT INDICATOR DRIVE ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL Dynamic Stability Control Module Location Pin Description and Characteristic STEERING WHEEL SPEED CONTROL SWITCHES — — STEERING WHEEL C EC30-11 CAN + TRANSMISSION CONTROL MODULE GB2 16-WAY / BLACK TRANSMISSION CONTROL VALVE C EC30-12 CAN + C EC30-14 CAN – C EC30-15 CAN – HARNESS IN-LINE CONNECTORS Engine Control Module Connector Connector Description IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS Location CABIN / ADJACENT TO HOOD RELEASE Pin Description and Characteristic IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST SS PI1-047 SPEED CONTROL SWITCH REQUEST: STEPPED RESISTANCE PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE I PI1-048 SPEED CONTROL SWITCHES SIGNAL GROUND: GROUND C PI1-123 CAN – C PI1-124 CAN + GROUNDS Ground Location Instrument Cluster G1 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY Pin Description and Characteristic G31 CABIN / BEHIND PASSENGER AIR BAG C IP6-08 CAN + C IP6-09 CAN – C IP6-18 CAN + C IP6-19 CAN – FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. Transmission Control Module Pin Description and Characteristic C GB2-02 CAN – C GB2-06 CAN + NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Adaptive Speed Control WU 29 NW EC23-1 U U IP50-7 IP55-1 B IP50-6 IP11-1 B S 270 Ω II EC23-7 74 FORWARD ALERT SWITCH WU 30 B II Fig. 05.4 Adaptive Speed Control I O R O EC23-6 EC23-12 R I IP11-3 IP55-7 B IPS35 G31AL AUXILIARY LIGHTING SWITCH B P Y 20.1 IP11-4 C + B IPS6 EC23-10 G31BL G 20.1 C – EC23-4 ADAPTIVE SPEED CONTROL CHIME MODULE B P EC23-2 G1AL ADAPTIVE SPEED CONTROL MODULE CAN 2.2κ Ω RESUME 1κ Ω Y 20.1 SET + C + 20.1 C – 20.1 PI1-123 CASSETTE YG SET – SW8-6 120 Ω CANCEL YG IP55-11 (LHD) IP9-3 (RHD) YG PI41-24 G C – EC30-14 BRAKE FORCE ENGINE CONTROL: REFER TO FIGURE SERIES 03. 300 Ω HEADWAY + C + EC30-11 G 20.1 HEADWAY – 180 Ω Y PI1-124 510 Ω 20.1 Y C + EC30-12 I 20.1 G C – EC30-15 PI1-48 CASSETTE YR SW8-8 RESISTOR PACK YR IP55-12 (LHD) IP9-4 (RHD) YR PI41-25 I PI1-47 DYNAMIC STABILITY CONTROL MODULE STEERING WHEEL SPEED CONTROL SWITCHES ENGINE CONTROL MODULE NOTE: Vehicles without Adaptive Speed Control – refer to Speed Control Switches, Figs. 03.2, 03.4, 03.6. Y + C 20.1 GB2-6 G – C 20.1 Y C + IP6-8 TRANSMISSION STATUS 20.1 20.1 GB2-2 G C – IP6-9 WARNINGS; MESSAGE CENTER 20.1 Y C + IP6-18 20.1 G C – IP6-19 TRANSMISSION CONTROL MODULE 1 7 6 63 REFER TO APPENDIX ASC / CAN MESSAGES Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage INSTRUMENT CLUSTER + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Adaptive Speed Control Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 BRAKE CONTROL: REFER TO FIG. 05.1. Fig. 06.1 CONTROL MODULE PIN-OUT INFORMATION Climate Control Module Pin Description and Characteristic COMPONENTS I I I I I I I SS O I I I I I I SG AC100-01 AC100-02 AC100-03 AC100-04 AC100-05 AC100-06 AC100-07 AC100-08 AC100-09 AC100-10 AC100-11 AC100-12 AC100-13 AC100-14 AC100-15 AC100-16 IN-CAR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES EVAPORATOR TEMPERATURE SENSOR SIGNAL , NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES DUAL SOLAR SENSOR SIGNAL – LH: VOLTAGE DECREASES A LIGHT INCREASES DUAL SOLAR SENSOR SIGNAL – RH: VOLTAGE DECREASES A LIGHT INCREASES RH AIR MIX SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE RH MODE SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE RH COOL AIR BYPASS / DEFROST SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V PANEL ILLUMINATION: SIGNAL FROM RCCM TO PANEL FOR ILLUMINATION REQUIREMENTS LH OUTLET AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES RH OUTLET AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES AIR INTAKE SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE LH AIR MIX SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE LH MODE SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE LH COOL AIR BYPASS / DEFROST SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE SENSOR SIGNAL GROUND: GROUND Component Connector(s) Connector Description AIR CONDITIONING COMPRESSOR CLUTCH PI49 2-WAY / BLACK LOWER LH SIDE OF ENGINE AIR CONDITIONING PRESSURE SENSOR EC11 3-WAY / BLACK ADJACENT TO RADIATOR / LH SIDE AIR INTAKE SERVO AC103 7-WAY / BLACK CLIMATE CONTROL UNIT AIR INTAKE AIR MIX SERVO – RH AC9 7-WAY / BLACK CLIMATE CONTROL UNIT / RH SIDE O D I I O O O O O O O I D O SG O O O O O O O O AC101-02 AC101-03 AC101-04 AC101-06 AC101-07 AC101-08 AC101-09 AC101-10 AC101-11 AC101-12 AC101-13 AC101-14 AC101-16 AC101-17 AC101-18 AC101-19 AC101-20 AC101-21 AC101-22 AC101-23 AC101-24 AC101-25 AC101-26 PANEL COMMUNICATION CLOCK: SYNCHRONIZATION PULSES: 1 KHZ, 50% DUTY PANEL COMMUNICATION SWITCH DATA: INDICATES SWITCH BEING PRESSED PANEL COMMUNICATION BLANK: INDICATES TO CCM TO MAKE PANEL BLANK DURING CRANK PANEL BUZZER: INDICATES TO CCM TO MAKE AUDIO BEEP RH AIR MIX SERVO DRIVE – : B+ WHEN ACTIVATED LH AIR MIX SERVO DRIVE – : B+ WHEN ACTIVATED AIR INTAKE SERVO DRIVE + : B+ WHEN ACTIVATED RH MODE SERVO DRIVE + : B+ WHEN ACTIVATED LH MODE SERVO DRIVE + : B+ WHEN ACTIVATED RH COOL AIR BYPASS / DEFROST SERVO DRIVE – : B+ WHEN ACTIVATED LH COOL AIR BYPASS / DEFROST SERVO DRIVE – : B+ WHEN ACTIVATED HUMIDITY SENSOR SIGNAL: 0.7 VOLTS = 10% HUMIDITY (DRY); 2.5 VOLTS = 60% HUMIDITY (TYPICAL); 3.0 VOLTS = 90% HUMIDITY (DAMP) PANEL COMMUNICATION DATA: INDICATES TO PANEL WHICH LCD SEGMENTS OR LED’S ARE TO BE ILLUMINATED PANEL COMMUNICATION STX: SYNCHRONIZATION PULSES: 30 HZ, 3% DUTY PANEL SHIELD: GROUND PANEL BACK LIGHTING: CCM INDICATES TO PANEL TO BACKLIGHT LCD RH AIR MIX SERVO DRIVE + : B+ WHEN ACTIVATED LH AIR MIX SERVO DRIVE + : B+ WHEN ACTIVATED AIR INTAKE SERVO DRIVE – : B+ WHEN ACTIVATED RH MODE SERVO DRIVE – : B+ WHEN ACTIVATED LH MODE SERVO DRIVE – : B+ WHEN ACTIVATED RH COOL AIR BYPASS / DEFROST SERVO DRIVE + : B+ WHEN ACTIVATED LH COOL AIR BYPASS / DEFROST SERVO DRIVE + : B+ WHEN ACTIVATED B+ B+ O O C C I I C C SG I I PG CR119-02 CR119-03 CR119-04 CR119-05 CR119-06 CR119-07 CR119-08 CR119-11 CR119-16 CR119-17 CR119-18 CR119-19 CR119-20 CR119-22 SWITCHED SYSTEM POWER SUPPLY: B+ IGNITION SWITCHED POWER SUPPLY (II): B+ COMPRESSOR CLUTCH DRIVE + : B+ WHEN ACTIVATED COMPRESSOR CLUTCH DRIVE – : GROUND WHEN ACTIVATED CAN + CAN – SMOG SENSOR HC SIGNAL: RESISTANCE TO SENSOR GROUND (CR119-18) VARIES WITH HYDROCARBON / CO CONCENTRATION DIMMER CONTROLLED ILLUMINATION: PWM, 80Hz, GROUND = 0% DUTY CYCLE, B+ = 100% DUTY CYCLE CAN + CAN – AMBIENT AIR; SMOG SENSOR SIGNAL GROUND: GROUND AMBIENT AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES SMOG SENSOR NOX SIGNAL: RESISTANCE TO SENSOR GROUND (CR119-18) VARIES WITH NOX CONCENTRATION POWER GROUND: GROUND Location AIR MIX SERVO – LH AC8 7-WAY / BLACK CLIMATE CONTROL UNIT / LH SIDE AMBIENT TEMPERATURE SENSOR EC48 2-WAY / BLACK BEHIND FRONT BUMPER / CENTER RIGHT CLIMATE CONTROL MODULE AC100 AC101 CR119 16-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK CLIMATE CONTROL UNIT / DRIVER SIDE CLIMATE CONTROL PANEL CC20 12-WAY / BLACK CENTER CONSOLE COOL AIR BYPASS / DEFROST SERVO – RH AC5 7-WAY / BLACK CLIMATE CONTROL UNIT / RH SIDE COOL AIR BYPASS / DEFROST SERVO – LH AC4 7-WAY / BLACK CLIMATE CONTROL UNIT / LH SIDE DUAL SOLAR SENSOR IP45 3-WAY / NATURAL INSTRUMENT PANEL / FRONT CENTER ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE EVAPORATOR TEMPERATURE SENSOR AC1 2-WAY / BLACK CLIMATE CONTROL UNIT / EVAPORATOR HUMIDITY SENSOR IP48 4-WAY / NATURAL CLIMATE CONTROL UNIT / DRIVER SIDE IN-CAR TEMPERATURE SENSOR IP48 4-WAY / NATURAL CLIMATE CONTROL UNIT / DRIVER SIDE INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL CLIMATE CONTROL UNIT / RH SIDE MODE SERVO – RH AC7 7-WAY / BLACK MODE SERVO – LH AC6 7-WAY / BLACK CLIMATE CONTROL UNIT / LH SIDE NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP OUTLET AIR TEMPERATURE SENSOR – RH AC3 2-WAY / BLACK CLIMATE CONTROL UNIT / RH OUTLET OUTLET AIR TEMPERATURE SENSOR – LH AC2 2-WAY / BLACK CLIMATE CONTROL UNIT / LH OUTLET SMOG SENSOR EC42 6-WAY / GREY ENGINE COMPARTMENT / FORWARD OF COOLING PACK / CENTER HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC16 12-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST IP20 16-WAY / BLUE / AIR CONDITIONING HARNESS TO INSTRUMENT PANEL HARNESS CABIN / LH SIDE TO CLIMATE CONTROL UNIT PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE Engine Control Module GROUNDS Pin Description and Characteristic Ground Location SS SG I PI1-012 PI1-019 PI1-121 SENSOR POWER SUPPLY 1: NOMINAL 5 V SENSOR GROUND 1: GROUND AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES G7 CABIN / LH SIDE OF TRANSMISSION TUNNEL G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL C C PI1-123 PI1-124 CAN – CAN + FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. Instrument Cluster Pin Description and Characteristic C C S S IP6-08 IP6-09 IP6-10 IP6-20 CAN + CAN – SCP – SCP + NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Climate Control: Part 1 WG 25 II B AMBIENT AIR TEMPERATURE SENSOR RH OUTLET AIR TEMPERATURE SENSOR N υ CR119-2 RW 09.2 υ υ υ EC11 -1 BG ECS31 OY EC11 -3 ECS32 BG OY EC11 -2 PI1-19 + PI1-12 – WU PI41-19 Y C 20.1 G C C– CR119-7 20.1 Y 20.1 PI1-123 I C+ I AC100-02 I AC100-10 I AC100-11 I CR119-19 CR119-16 PI1-121 CR119-18 G 20.1 C– CR119-17 AIR CONDITIONING PRESSURE SENSOR ENGINE CONTROL MODULE I CR119-08 I CR119-20 I AC100-01 I AC101-14 I AC100-03 I 20.3 20.2 Y S + + C UW BW AC1 AC1 -1 -2 AC2 AC2 -1 -2 AC3 AC3 -1 -2 20.2 U S – – C BW 20.1 AC100-04 + O CR119-04 – O CR119-05 NR LG UW OY BW Y YG UY WU O O RG B G BW BW BW BW BW BW BW INSTRUMENT CLUSTER AC100-08 Y 20.2 U NOTE: Navigation vehicles – Climate Control Panel inputs via Telematics Display / Navigation Control Module / SCP / CAN. S – TL2-14 NAVIGATION CONTROL MODULE 24 WG II 63 GR O B CC20-11 CC20-10 NW S CC10-5 CC20-8 CC10-4 UY CC20-5 CC20-3 BK CCS3 CC20-2 P CC20-6 CC20-1 O AC101-17 RU IP20-7 Y YG EC42 -6 EC42 -3 IP48 IP48 -1 -2 IP48 -3 IP48 -4 IP45 -3 IP45 -1 IP45 -2 B WG UY BW WU U O R B IPS8 PI49 -1 PI49 -2 U RG B PI41 -36 PI41 -42 RG B U G3BL 27 + O AC101-09 – O AC101-22 I AC100-12 + O AC101-20 – O AC101-07 I AC100-05 + O AC101-21 – O AC101-08 I AC100-13 + O AC101-10 – O AC101-23 I AC100-06 + O AC101-11 – O AC101-24 I AC100-14 + O AC101-25 – O AC101-12 I AC100-07 + O AC101-26 – O AC101-13 I AC100-15 EC61 -12 (LHD) EC16 -6 (RHD) EC61 -21 (LHD) EC46 -18 (RHD) IP20 IP20 -15 -9 IP20 -14 IP20 -1 IP20 -12 IP20 -13 EC61 -17 (LHD) EC16 -11 (RHD) BW BW BW BW BW GB GB GB GB GB ACS2 ACS1 RB NR YW N Y G R W B NB YB GW RW BR U GR YR RG WG BG UB GB BW YW NR RB AC101-16 IP20-4 GB BW D UB BG WG GB BW RG YR GR GB BW U BR RW GB BW GW YB NB GB BW B W R GB BW G Y AC101-3 AC4 AC4 -1 -3 CLIMATE CONTROL PANEL (VEHICLES WITHOUT NAVIGATION) O D RG RG CC10-13 AC100-9 IP20-8 CC10-6 O RW RU RG D G15AR AC101-19 IP20-2 CC10-7 O U RW RU D IP20-11 CC10-12 RW AC101-18 UY U CC20-4 I AC101-2 IP20-10 CC10-11 O B UY U AC101-4 IP20-3 CC10-10 I G B CC20-9 I IP20-5 CC10-8 B I AC101-6 GU G CC20-7 I IP20-6 GU G I GR GR GU O B CC20-12 BK GB GB GB GB S + TL2-4 20.3 EC42 -4 EC61 -16 (LHD) EC16 -10 (RHD) 20.1 AC100-16 20.2 EC42 -2 ECS8 (LHD) ECS34 (RHD) EC61 -19 (LHD) EC1 -14 (RHD) EC61 -20 (LHD) EC1 -18 (RHD) IP6-9 IP6-10 20.3 EC42 -1 OY BW IP6-8 IP6-20 20.3 Y RH C+ G 20.1 PI1-124 PIS22 PI41-18 LG BW II Y CR119-6 OY WU NR BW BW 20.1 PIS21 PI41-17 OY LH I CR119-11 CAN BG υ HC NOX EC48 EC48 -1 -2 BG AIR CONDITIONING COMPRESSOR CLUTCH DUAL SOLAR SENSOR HUMIDITY SENSOR B S REFER TO APPENDIX CCM / CAN MESSAGES IN-CAR TEMPERATURE SENSOR SMOG SENSOR CR119-3 75 DIMMER-CONTROLLED LIGHTING (NON NAVIGATION VEHICLES) LH OUTLET AIR TEMPERATURE SENSOR EVAPORATOR TEMPERATURE SENSOR Fig. 06.1 Climate Control: Part 1 B AC4 AC4 -5 -7 AC4 -6 AC5 AC5 -1 -3 AC5 AC5 -5 -7 AC5 -6 AC6 AC6 -3 -1 AC6 AC6 -5 -7 AC6 -6 AC7 AC7 -3 -1 AC7 AC7 -5 -7 AC7 -6 AC8 AC8 -3 -1 AC8 AC8 -5 -7 AC8 -6 AC9 AC9 -3 -1 AC9 AC9 -5 -7 AC9 -6 N AC103 -3 AC103 -1 -1 -5 -6 -7 (RHD) -3 -5 -7 -6 (LHD) P CR119-22 G7BS (G8BS) CLIMATE CONTROL MODULE (Continued Fig. 06.2) 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage LH COOL AIR BYPASS / DEFROST SERVO RH COOL AIR BYPASS / DEFROST SERVO + Sensor/Signal Supply V – Sensor/Signal Ground LH MODE SERVO A ACP S SCP C CAN D Serial and Encoded Data RH MODE SERVO LH AIR MIX SERVO VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 RH AIR MIX SERVO AIR INTAKE SERVO Fig. 06.2 CONTROL MODULE PIN-OUT INFORMATION Climate Control Module Pin Description and Characteristic COMPONENTS O AC101-01 BLOWER MOTOR DRIVE SIGNAL: HIGH BLOWER = HIGH VOLTAGE; LOW BLOWER = LOW VOLTAGE Component Connector(s) Connector Description Location I AC101-15 BLOWER MOTOR SPEED SIGNAL: 0 VOLTS WHEN RELAY IS OPEN; WHEN RELAY CLOSED LOWER VOLTAGE INDICATES MORE BLOWER VOLTAGE AUXILIARY COOLANT PUMP CP4 2-WAY / BLACK ENGINE COMPARTMENT / RH SIDE / REARWARD OF COOLING PACK O CR119-09 HEATED WIPER PARK; HEATED WINDSHIELD RELAY(S) ACTIVATE: TO ACTIVATE, CCM SWITCHES CIRCUIT TO GROUND BLOWER AC105 2-WAY / BLACK CLIMATE CONTROL UNIT / BETWEEN AIR INTAKE AND MAIN UNIT O CR119-10 BLOWER RELAY ACTIVATE: TO ACTIVATE, CCM SWITCHES CIRCUIT TO GROUND BLOWER CONTROLLER AC104 4-WAY / BLACK CLIMATE CONTROL UNIT / BETWEEN AIR INTAKE AND MAIN UNIT / TOP O CR119-21 HEATED REAR WINDOW RELAY ACTIVATE: TO ACTIVATE, CCM SWITCHES CIRCUIT TO GROUND BLOWER RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R1 CLIMATE CONTROL MODULE AC100 AC101 CR119 16-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK CLIMATE CONTROL UNIT / DRIVER SIDE FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT NOTE: Refer to the Appendix at the rear of this book for Network Messages. HEATED REAR VIEW MIRROR – DRIVER DD9 22-WAY / BLACK DRIVER DOOR HEATED REAR VIEW MIRROR – PASSENGER PD9 22-WAY / BLACK PASSENGER DOOR HEATED REAR WINDOW RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R5 HEATED REAR WINDOW HW1 HW2 1-WAY / BLACK 1-WAY / BLACK CABIN / BEHIND REAR SEAT BACK / LH SIDE (CONNECTOR LOCATION) CABIN / BEHIND REAR SEAT BACK / LH SIDE (CONNECTOR LOCATION) HEATED WIPER PARK RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R13 REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR WINDSHIELD HEATED WIPER PARK CR27 CR39 1-WAY / BLACK 1-WAY / BLACK CABIN / LH UPPER ‘A’ POST (CONNECTOR LOCATION) CABIN / RH WINDSHIELD HEATER – LH CR20 CR27 1-WAY / BLACK 1-WAY / BLACK CABIN / LH UPPER ‘A’ POST (CONNECTOR LOCATION) CABIN / LH UPPER ‘A’ POST (CONNECTOR LOCATION) WINDSHIELD HEATER – RH CR39 CR43 1-WAY / BLACK 1-WAY / BLACK CABIN / RH UPPER ‘A’ POST (CONNECTOR LOCATION) CABIN / RH UPPER ‘A’ POST (CONNECTOR LOCATION) WINDSHIELD HEATER RELAY – LH — — FRONT POWER DISTRIBUTION FUSE BOX – R3 WINDSHIELD HEATER RELAY – RH — — FRONT POWER DISTRIBUTION FUSE BOX – R13 UPPER ‘A’ POST (CONNECTOR LOCATION) HARNESS IN-LINE CONNECTORS Connector Connector Description CP1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INTERCOOLER COOLANT PUMP HARNESS Location ENGINE COMPARTMENT / ADJACENT TO RADIATOR RH SIDE CR24 2-WAY / BLACK / CABIN HARNESS TO HEATED REAR WINDOW HARNESS CABIN / BEHIND REAR SEAT BACK / LH SIDE CR25 2-WAY / NATURAL / CABIN HARNESS TO AIR CONDITIONING HARNESS CABIN / ADJACENT TO BLOWER MOTOR DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC2 2-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC54 2-WAY / GREY / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PD16 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST GROUNDS Ground Location G3 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G7 CABIN / LH SIDE OF TRANSMISSION TUNNEL G8 CABIN / ABOVE RH SIDE OF TRANSMISSION TUNNEL G9 CABIN / UPPER LH A POST G10 CABIN / RH A POST FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Climate Control: Part 2 Climate Control: Part 2 U O AC104-2 AC101-1 R I U AC104-3 AC101-15 BW AC104-4 BW CR25-2 AC104-1 G8AS (G7AR) BLOWER CONTROLLER R1 58 4 3 5 W F7 40A 87 1 CR83-4 W AC105-1 CR25-1 AC105-2 2 S BLOWER BLOWER RELAY RU O NR F8 10A CR84-1 NR EC1-16 B NR CP1-5 B CP4-2 CP4-1 CP1-4 B ECS3 CR84-8 CR119-10 G3BL AUXILIARY COOLANT PUMP R5 60 CONTROL AND SENSOR INPUTS: FIG. 06.1 3 4 UY 5 F19 30A 23 1 CR80-1 UY UY CR24-1 HW2 HW1 2 II HEATED REAR WINDOW HEATED REAR WINDOW RELAY GW O OY CR81-6 CR119-21 F20 10A CR80-2 OY B OY DD1-11 CRS8 DD9-10 DD9-9 B DDS1 B DD3-6 G9AL (G10AL) REAR POWER DISTRIBUTION FUSE BOX DRIVER HEATED REAR VIEW MIRROR OY OY PD16-11 B PD9-10 PD9-9 B PDS1 B PD1-7 G10AR (G9AR) PASSENGER HEATED REAR VIEW MIRROR R13 33 3 4 F7 40A 26 1 GW GW 5 EC32-4 EC2-1 B CR27 CR39 2 G9DS II HEATED WIPER PARK RELAY RW O CR119-9 RW EC61-18 (LHD) EC46-9 (RHD) EC41-10 CLIMATE CONTROL MODULE (Continued from Fig. 06.1) R3 32 3 4 WINDSHIELD HEATED WIPER PARK (HEATED WIPER PARK VEHICLES) (HEATED WINDSHIELD VEHICLES) F32 40A 26 1 GO GO 5 EC4-4 EC54-1 B CR27 CR20 2 G9DS II NOTE: CCM power supplies and grounds shown on Fig. 06.1. LH WINDSHIELD HEATER LH WINDSHIELD HEATER RELAY R13 33 3 4 F7 40A 1 GW GW 5 EC32-4 EC2-1 B CR43 CR39 2 G10CSB RH WINDSHIELD HEATER RH WINDSHIELD HEATER RELAY FRONT POWER DISTRIBUTION FUSE BOX 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 06.2 Fig. 06.3 CONTROL MODULE PIN-OUT INFORMATION Rear Climate Control Module Pin Description and Characteristic COMPONENTS I RAI-01 REAR MODE SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE Component Connector(s) Connector Description I RAI-02 LH REAR AIR MIX SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE I RAI-03 RH REAR AIR MIX SERVO POSITION SENSOR SIGNAL, NOMINAL 0 – 5 V: CLOSED DIRECTION = LOWER VOLTAGE; OPEN DIRECTION = HIGHER VOLTAGE REAR AIR MIX SERVO – RH RA8 5-WAY / BLACK REAR CLIMATE CONTROL UNIT / RH SIDE / TOP C RAI-08 CAN + REAR AIR MIX SERVO – LH RA7 5-WAY / BLACK REAR CLIMATE CONTROL UNIT / LH SIDE / TOP Location I RAI-09 REAR EVAPORATOR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES REAR BLOWER RA4 2-WAY / BLACK REAR CLIMATE CONTROL UNIT / FRONT SS RAI-11 SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V REAR BLOWER CONTROLLER RA3 4-WAY / BLACK REAR CLIMATE CONTROL UNIT / LH SIDE / FRONT REAR CLIMATE CONTROL MODULE RA1 RA2 16-WAY / BLACK 12-WAY / BLACK REAR CENTER CONSOLE SG RAI-12 SENSOR SIGNAL GROUND: GROUND I RAI-13 BLOWER MOTOR SPEED SIGNAL: HIGH BLOWER = HIGH VOLTAGE; LOW BLOWER = LOW VOLTAGE O RAI-14 BLOWER MOTOR DRIVE SIGNAL: 0 VOLTS WHEN RELAY IS OPEN; WHEN RELAY CLOSED, LOWER VOLTAGE INDICATES MORE BLOWER VOLTAGE REAR EVAPORATOR TEMPERATURE SENSOR RA10 2-WAY / BLACK REAR CLIMATE CONTROL UNIT / EVAPORATOR C RAI-16 CAN – REAR MODE SERVO RA9 5-WAY / BLACK REAR CLIMATE CONTROL UNIT / LH SIDE / BOTTOM PG RA2-01 POWER GROUND: GROUND I RA2-03 DIMMER CONTROLLED LIGHTING: B+ PWM O RA2-04 REAR MODE SERVO DRIVE + : B+ WHEN ACTIVATED O RA2-05 REAR MODE SERVO DRIVE – : B+ WHEN ACTIVATED O RA2-06 LH REAR AIR MIX SERVO DRIVE + : B+ WHEN ACTIVATED B+ RA2-07 IGNITION SWITCHED POWER SUPPLY (II): B+ B+ RA2-08 SWITCHED SYSTEM POWER SUPPLY: B+ O RA2-10 RH REAR AIR MIX SERVO DRIVE – : B+ WHEN ACTIVATED O RA2-11 RH REAR AIR MIX SERVO DRIVE + : B+ WHEN ACTIVATED Ground Location O RA2-12 LH REAR AIR MIX SERVO DRIVE – : B+ WHEN ACTIVATED G32 CABIN / BEHIND INSTRUMENT CLUSTER HARNESS IN-LINE CONNECTORS Connector Connector Description Location IP66 14-WAY / GREY / INSTRUMENT PANEL HARNESS TO REAR AIR CONDITIONING HARNESS CABIN / BELOW CENTER CONSOLE GROUNDS NOTE: Refer to the Appendix at the rear of this book for Network Messages. FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Rear Climate Control REAR EVAPORATOR TEMPERATURE SENSOR Rear Climate Control LH REAR AIR MIX SERVO RH REAR AIR MIX SERVO REAR MODE SERVO υ 15 RG II 77 N S 20.1 REFER TO APPENDIX REAR CCM / CAN MESSAGES B RA2-7 RA10 RA10 -1 -2 B RA2-8 Y RA7 RA7 -3 -1 G BW C + U BW RA7 -5 RA8 RA8 -3 -1 YB GB YG U BW RA7 RA7 -2 -4 RA8 -5 RA8 RA8 -2 -4 RA9 RA9 -3 -1 Y YU GU RA9 RA9 -2 -4 U BW UY RA9 -5 O OY RA1-8 CAN 20.1 G C – G I RA1-16 RA1-9 YB I DIMMER-CONTROLLED LIGHTING 09.2 RW RA1-2 I GB –O RA2-3 RA2-12 YG +O RA2-6 Y I RA1-3 YU –O RA2-11 GU +O RA2-10 UY I RA1-1 O –O RA2-5 OY +O RA2-4 BW RAS11 RA1-12 U RAS10 RA1-11 W O RA3-2 RA1-14 WB I G B P RA2-1 B IP66-10 REAR CLIMATE CONTROL MODULE (INCLUDES CONTROL PANEL) 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E B RG RA3-4 RA3-3 RA1-13 RA4-2 RA4-1 14 II B IP66-14 REAR BLOWER RA3-1 REAR BLOWER CONTROLLER G32BS I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Rear Climate Control Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 06.3 Fig. 07.1 CONTROL MODULE PIN-OUT INFORMATION Instrument Cluster Pin Description and Characteristic COMPONENTS I IP5-01 AIR BAG WARNING: HARD WIRED TO AIR BAG INDICATOR Component Connector(s) Connector Description AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN 2-WAY / BLACK ENGINE COOLANT EXPANSION TANK / BOTTOM Location I IP5-02 KEY-IN AUDIBLE WARNING: B+ WHEN KEY IN B+ IP5-03 IGNITION SWITCHED POWER SUPPLY (II): B+ B+ IP5-04 IGNITION SWITCHED POWER SUPPLY (I): B+ ENGINE COOLANT LEVEL SWITCH CP3 I IP5-05 LOW ENGINE COOLANT LEVEL WARNING: GROUND WHEN COOLANT LEVEL LOW ENGINE OIL PRESSURE SWITCH PI46 1-WAY / BLACK ENGINE BLOCK / ADJACENT TO OIL FILTER I IP5-07 KEY-IN AUDIBLE WARNING (J-GATE): GROUND WHEN NOT-IN-PARK FUEL LEVEL SENSOR – LH (N/A) FP7 4-WAY / BLACK FUEL TANK / LH SIDE I IP5-08 SEAT BELT AUDIBLE WARNING REQUEST: AUDIBLE WARNING REQUEST ACTIVE = GROUND FUEL LEVEL SENSOR – LH (SC) FP3 4-WAY / BLACK FUEL TANK / LH SIDE SG IP5-14 SIGNAL GROUND: GROUND FUEL LEVEL SENSOR – RH FP4 4-WAY / BLACK FUEL TANK / RH SIDE IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) IP26 6-WAY / BLACK STEERING COLUMN / LH SIDE REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR PG IP6-02 POWER GROUND: GROUND B+ IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ C IP6-08 CAN + C IP6-09 CAN – S IP6-10 SCP – C IP6-18 CAN + C IP6-19 CAN – S IP6-20 SCP + SG IP7-03 MAIN LIGHTING SWITCH SIGNAL GROUND: GROUND I IP7-04 TRIP COMPUTER – MESSAGE CENTER SIGNALS: VARIABLE RESISTANCE I IP7-11 ENGINE OIL PRESSURE SWITCH SIGNAL: GROUND WHEN ACTIVATED I IP7-14 TRIP CYCLE SWITCH – MESSAGE CENTER SIGNAL: VARIABLE RESISTANCE SG IP7-15 AUXILIARY LIGHTING SWITCH SIGNAL GROUND: GROUND HARNESS IN-LINE CONNECTORS Connector Connector Description CP1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INTERCOOLER COOLANT PUMP HARNESS Location ENGINE COMPARTMENT / ADJACENT TO RADIATOR / RH SIDE Rear Electronic Module FP6 22-WAY / NATURAL / CABIN HARNESS TO FUEL PUMP HARNESS TOP OF FUEL TANK / RH SIDE Pin Description and Characteristic IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ IP17 16-WAY / GREEN / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE I CR4-15 RH SIDE FUEL LEVEL SENSOR SIGNAL: VARIABLE RESISTANCE PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE I CR4-16 LH SIDE FUEL LEVEL SENSOR SIGNAL: VARIABLE RESISTANCE GROUNDS PG CR11-11 POWER GROUND: GROUND SG CR11-23 FUEL LEVEL SENSORS SIGNAL GROUND: GROUND Ground Location SG CR11-25 LOGIC GROUND: GROUND G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE S CR13-01 SCP + S CR13-02 SCP – G31 CABIN / BEHIND PASSENGER AIR BAG NOTE: Refer to the Appendix at the rear of this book for Network Messages. FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Instrument Cluster O 87 B IP6-3 4 YG 16 GR I + LOGIC 20.2 20.3 20.2 20.3 IP6-20 B – U S IP5-4 II Y S SCP REFER TO APPENDIX CAN / IC MESSAGES IP6-10 B RH SIDE FUEL LEVEL SENSOR IP5-3 20.1 NW 78 Y B CR4-3 C + LOGIC IP6-8 20.1 REFER TO APPENDIX SCP / IC MESSAGES G C – IP6-9 CAN 20.1 Y 20.3 20.2 G Y S + CR13-1 C + IP6-18 20.1 20.3 20.2 U WR I FP6-12 BK II RESTRAINTS CONTROL MODULE: AIRBAG INDICATOR DRIVE (CIRCUIT CONTINUED) 17.1 RESTRAINTS CONTROL MODULE: SEAT BELT AUDIBLE WARNING DRIVE (CIRCUIT CONTINUED) 17.1 B IP5-12 YU YU IP17-2 I IP5-1 BK WU I AIRBAG WARNINGS YR IP17-1 I IP5-8 CR4-16 04.1 R CR11-11 CR11-25 SEAT BELT AUDIBLE WARNING I KEY-IN AUDIBLE WARNING I KEY-IN AUDIBLE WARNING IP5-7 20Ω E F 160Ω FP7-1 (N/A) FP3-1 (SC) B P AIRBAG WARNING INDICATOR BK FP7-3 (N/A) FP3-3 (SC) FP6-14 B CRS75 LH SIDE FUEL LEVEL SENSOR REAR ELECTRONIC MODULE J GATE: NOT-IN-PARK (CIRCUIT CONTINUED) 160Ω FP4-3 FPS1 WU B YR F FP4-1 FP6-13 CR11-23 GO E BK CR13-2 C – 20Ω WR CR4-15 S – IP6-19 19 G24BL KEY-IN 4 RU RW IP34-4 IP34-5 IP5-2 LOW ENGINE COOLANT LEVEL WARNING IGNITION SWITCH G 3.9 ΚΩ I IP33-2 9.1 ΚΩ OG I OG IP8-7 IP5-5 OG B CP1-6 CP3-2 CP3-1 ENGINE COOLANT LEVEL SWITCH B CP1-7 B ECS4 G2AR MESSAGE CENTER IP7-4 MLS / KM P 1.1 ΚΩ TRIP A / B LOW OIL PRESSURE WARNING BG I BG IP8-2 IP7-11 BG PI41-16 PI46-1 ENGINE OIL PRESSURE SWITCH RESET 360 ΚΩ BO TRIP COMPUTER SWITCHES IP33-7 IP7-15 AUXILIARY LIGHTING SWITCH 330 ΚΩ YU 470 ΚΩ TRIP CYCLE SWITCH I IP26-5 MESSAGE CENTER B IP7-14 BW B P IP6-2 IP7-3 MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) B IPS6 IP5-14 IP26-6 B IPS2 G31BL INSTRUMENT CLUSTER 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E Fig. 07.1 Instrument Cluster I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 FUEL TANK Fig. 08.1 CONTROL MODULE PIN-OUT INFORMATION Front Electronic Module Pin Description and Characteristic COMPONENTS PG CR1-26 POWER GROUND: GROUND Component Connector(s) Connector Description Location S CR9-01 SCP – AUTO LAMP SENSOR IP36 6-WAY / BLACK INSTRUMENT PANEL / CENTER FRONT B+ CR9-06 BATTERY POWER SUPPLY: LOGIC: B+ AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN S CR9-07 SCP + CENTER CONSOLE SWITCH PACK CR9-12 LOGIC GROUND: GROUND 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE SG CL1 CL2 DIP BEAM RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R5 O CR10-04 LH TURN SIGNAL ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST O CR10-10 RH TURN SIGNAL ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND PG CR10-11 POWER GROUND: GROUND PG CR10-13 POWER GROUND: GROUND PG CR10-14 POWER GROUND: GROUND O CR10-15 SIDE MARKER LAMPS ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND PG CR85-02 POWER GROUND: GROUND O EC36-07 O EC36-13 LH SIDE LAMP ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-15 HEADLAMP DIP BEAM RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-18 FRONT FOG LAMP RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-19 RH TURN SIGNAL REPEATER ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-21 HEADLAMP MAIN BEAM RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-22 RH SIDE LAMP ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND FRONT FOG LAMP – LH BF9 2-WAY / BLACK FRONT BUMPER / LH SIDE FRONT FOG LAMP – RH BF8 2-WAY / BLACK FRONT BUMPER / RH SIDE FRONT FOG LAMP RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R6 FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT FRONT SIDE MARKER LAMP – LH BF7 2-WAY / BLACK FRONT BUMPER / LH SIDE FRONT SIDE MARKER LAMP – RH BF6 2-WAY / BLACK FRONT BUMPER / RH SIDE HEADLAMP UNIT – LH (NON-HID) EC57 9-WAY / BLACK ENGINE COMPARTMENT / LH FRONT HEADLAMP UNIT – RH (NON-HID) EC6 9-WAY / BLACK ENGINE COMPARTMENT / RH FRONT INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL LH TURN SIGNAL REPEATER ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND Instrument Cluster Pin Description and Characteristic O IP5-09 HAZARD INDICATOR: PULSED B+ SG IP5-14 SIGNAL GROUND: GROUND PG IP6-02 POWER GROUND: GROUND B+ IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ S IP6-10 SCP – S IP6-20 SCP + I IP7-01 MAIN LIGHTING SWITCH SIGNALS: TURN SIGNALS; HAZARD WARNING: TURN = VARIABLE RESISTANCE; HAZARD = GROUND MAIN BEAM RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R2 MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) IP26 6-WAY / BLACK STEERING COLUMN / LH SIDE TURN SIGNAL REPEATER – LH EC49 2-WAY / BLACK LH FRONT FENDER TURN SIGNAL REPEATER – RH EC31 2-WAY / BLACK RH FRONT FENDER I IP7-02 MAIN LIGHTING SWITCH SIGNALS: EXIT DELAY: VARIABLE RESISTANCE SG IP7-03 MAIN LIGHTING SWITCH SIGNAL GROUND: GROUND I IP7-06 FOG LAMPS SWITCH SIGNAL: VARIABLE RESISTANCE I IP7-12 MAIN LIGHTING SWITCH SIGNALS: MAIN; FLASH: VARIABLE RESISTANCE Connector Connector Description I IP7-13 MAIN LIGHTING SWITCH SIGNALS: OFF; SIDE; DIP; AUTOLAMP: VARIABLE RESISTANCE BF1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO FRONT BUMPER HARNESS ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER SG IP7-15 AUXILIARY LIGHTING SWITCH SIGNAL GROUND: GROUND CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) I IP7-21 AUTOLAMP SENSOR SIGNAL: VARIABLE RESISTANCE HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST GROUNDS Ground Location G1 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G3 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G9 CABIN / UPPER LH A POST G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G31 CABIN / BEHIND PASSENGER AIR BAG FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Exterior Lighting: Front SCP O 87 B IP6-3 NW 60 NW 80 LOGIC B CR9-6 B B IPS35 I IP36-4 + Y S 20.2 20.3 20.3 20.2 Y IP6-20 IP7-21 IP36-1 – OY EC36-7 S + EC49-2 54 S EC49-1 CR9-7 U S 20.2 20.3 20.3 20.2 IP6-10 G31AL BK BK O WB IP36-6 REFER TO APPENDIX SCP / FEM LIGHTING MESSAGES LOGIC B S Fig. 08.1 Exterior Lighting: Front U LH TURN SIGNAL REPEATER S – CR9-1 AUTOLAMP SENSOR BR BR O OY EC36-13 EC57-6 53 S EC57-8 SIDE BW BW O CR10-4 AUTOLAMP EC57-9 EC53-2 TURN 470 Ω DIP BEAM R5 WR 270 Ω I 2 U EC36-15 OFF OG 1 EC57-4 EC40-5 DIP 20 B O EC40-8 MAIN G1AR LH HEADLAMP UNIT EXIT DELAY 1 WG 270 Ω R6 I IP7-2 IP26-3 EXIT DELAY 2 4 3 21 5 EXIT DELAY 3 2 UY O EC36-18 1 BF1-10 EC40-3 RW RW RW F18 15A 180 Ω B BF9-2 BFS1 BF9-1 B LH FRONT FOG LAMP 22 EC41-3 56 Ω BFS2 RW FRONT FOG LAMP RELAY 220 Ω EC57-3 EC57-7 EC35-8 DIP BEAM RELAY AUTOLAMP 470 Ω 5 F9 20A O 180 Ω 3 19 IP7-13 IP26-4 SIDE LAMPS 4 G2AR B BF8-2 B BF1-9 BF8-1 LH TURN 270 Ω WU 470 Ω WU IPS22 IP26-1 R2 I IP7-1 17 RH TURN EC36-21 FLASH 2 1 18 OG B EC6-7 EC35-4 EC6-3 MAIN EC40-4 G3BR OY 270 Ω W 470 Ω 5 F16 20A RW O 220 Ω RH FRONT FOG LAMP 4 3 I IP7-12 IP26-2 MAIN BEAM MAIN BEAM RELAY F8 20A EC6-4 EC35-3 DIP FRONT POWER DISTRIBUTION FUSE BOX BW BR BR O CR10-10 IP7-3 IP26-6 EC6-9 EC1-19 TURN MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) BW BW O EC36-22 O EC6-6 68 S EC6-8 SIDE RH HEADLAMP UNIT WU WU CL2-2 WU CC10-3 CL3-7 BK BK CCS3 BK CL3-3 EC36-19 Y 1.2 ΚΩ CL1-5 BG BG O 1.2 ΚΩ CL1-7 Y Y CL3-5 O HAZARD SWITCH AND INDICATOR G15AR BO CENTER CONSOLE SWITCH PACK BO BO CR10-15 3.9 ΚΩ YB BF1-8 BFS5 BO BO B IP7-15 IP33-7 FOG LAMP SWITCHES IP5-14 P AUXILIARY LIGHTING SWITCH B BK B B B B B IPS6 B IP6-2 B O CR9-12 CR85-2 CR1-26 CR10-14 CR10-11 G31BL P P P P G9BL FRONT ELECTRONIC MODULE G9CL G9BR 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground BF6-2 RH FRONT SIDE MARKER LAMP (NAS ONLY) P CR10-13 IPS2 INSTRUMENT CLUSTER 6 S LH FRONT SIDE MARKER LAMP (NAS ONLY) BF6-1 470 Ω (LHD) 820 Ω (RHD) 66 IP7-6 820 Ω (LHD) 470 Ω (RHD) REAR EC61-22 BO BF7-2 I IP33-5 (LHD) IP33-6 (RHD) FRONT O BF7-1 O 1 69 S EC31-1 RH TURN SIGNAL REPEATER IP5-9 CC10-2 O EC31-2 A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Non HID Headlamp Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 67 S Fig. 08.2 CONTROL MODULE PIN-OUT INFORMATION Front Electronic Module Pin Description and Characteristic COMPONENTS PG CR1-26 POWER GROUND: GROUND Component Connector(s) Connector Description Location S CR9-01 SCP – AUTO LAMP SENSOR IP36 6-WAY / BLACK INSTRUMENT PANEL / CENTER FRONT B+ CR9-06 BATTERY POWER SUPPLY: LOGIC: B+ AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN S CR9-07 SCP + CENTER CONSOLE SWITCH PACK CR9-12 LOGIC GROUND: GROUND 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE SG CL1 CL2 DIP BEAM RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R5 O CR10-04 LH TURN SIGNAL ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST O CR10-10 RH TURN SIGNAL ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND PG CR10-11 POWER GROUND: GROUND PG CR10-13 POWER GROUND: GROUND PG CR10-14 POWER GROUND: GROUND O CR10-15 SIDE MARKER LAMPS ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND PG CR85-02 POWER GROUND: GROUND O EC36-07 O EC36-13 LH SIDE LAMP ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-15 HEADLAMP DIP BEAM RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-18 FRONT FOG LAMP RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-19 RH TURN SIGNAL REPEATER ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-21 HEADLAMP MAIN BEAM RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND O EC36-22 RH SIDE LAMP ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND FRONT FOG LAMP – LH BF9 2-WAY / BLACK FRONT BUMPER / LH SIDE FRONT FOG LAMP – RH BF8 2-WAY / BLACK FRONT BUMPER / RH SIDE FRONT FOG LAMP RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R6 FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT FRONT SIDE MARKER LAMP – LH BF7 2-WAY / BLACK FRONT BUMPER / LH SIDE FRONT SIDE MARKER LAMP – RH BF6 2-WAY / BLACK FRONT BUMPER / RH SIDE HID HEADLAMP UNIT – LH EC57 9-WAY / BLACK ENGINE COMPARTMENT / LH FRONT HID HEADLAMP UNIT – RH EC6 9-WAY / BLACK ENGINE COMPARTMENT / RH FRONT INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL LH TURN SIGNAL REPEATER ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND Instrument Cluster Pin Description and Characteristic O IP5-09 HAZARD INDICATOR: PULSED B+ SG IP5-14 SIGNAL GROUND: GROUND PG IP6-02 POWER GROUND: GROUND B+ IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ S IP6-10 SCP – S IP6-20 SCP + I IP7-01 MAIN LIGHTING SWITCH SIGNALS: TURN SIGNALS; HAZARD WARNING: TURN = VARIABLE RESISTANCE; HAZARD = GROUND MAIN BEAM RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R2 MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) IP26 6-WAY / BLACK STEERING COLUMN / LH SIDE TURN SIGNAL REPEATER – LH EC49 2-WAY / BLACK LH FRONT FENDER TURN SIGNAL REPEATER – RH EC31 2-WAY / BLACK RH FRONT FENDER I IP7-02 MAIN LIGHTING SWITCH SIGNALS: EXIT DELAY: VARIABLE RESISTANCE SG IP7-03 MAIN LIGHTING SWITCH SIGNAL GROUND: GROUND I IP7-06 FOG LAMPS SWITCH SIGNAL: VARIABLE RESISTANCE I IP7-12 MAIN LIGHTING SWITCH SIGNALS: MAIN; FLASH: VARIABLE RESISTANCE Connector Connector Description I IP7-13 MAIN LIGHTING SWITCH SIGNALS: OFF; SIDE; DIP; AUTOLAMP: VARIABLE RESISTANCE BF1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO FRONT BUMPER HARNESS ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER SG IP7-15 AUXILIARY LIGHTING SWITCH SIGNAL GROUND: GROUND CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) I IP7-21 AUTOLAMP SENSOR SIGNAL: VARIABLE RESISTANCE HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL EC61 22-WAY / NATURAL / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / LH UPPER ‘A’ POST GROUNDS Ground Location G1 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G3 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G9 CABIN / UPPER LH A POST G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G31 CABIN / BEHIND PASSENGER AIR BAG FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Exterior Lighting: Front – HID Fig. 08.2 Exterior Lighting: Front – HID REFER TO APPENDIX SCP / FEM LIGHTING MESSAGES SCP O 87 B IP6-3 NW 60 B CR9-6 LOGIC BK BK O OY EC36-7 EC49-2 WB IP36-6 B IPS35 54 S EC49-1 LH TURN SIGNAL REPEATER B S B NW 80 LOGIC I IP36-4 Y + S 20.2 20.3 20.3 20.2 20.2 20.3 20.3 20.2 Y CR9-7 IP6-20 IP7-21 IP36-1 – U S U S – OY BR BR O EC36-13 CR9-1 IP6-10 G31AL S + EC57-6 53 S EC57-8 SIDE AUTOLAMP SENSOR BW BW O CR10-4 EC57-9 EC53-2 TURN AUTOLAMP 470 Ω EC102-1 DIP BEAM R5 WR 270 Ω I EC36-15 OFF 20 WG II EC57-1 B G1AR LH HID HEADLAMP UNIT R6 56 Ω 4 3 5 EC36-18 LH TURN WU WU IPS22 IP26-1 1 B BF1-9 G2AR B BF8-2 RH TURN BF8-1 RH FRONT FOG LAMP R2 FLASH 270 Ω 17 W 470 Ω B BFS2 RW FRONT FOG LAMP RELAY IP7-1 BF9-1 LH FRONT FOG LAMP 22 EC41-3 I B BF9-2 BFS1 BF1-10 EC40-3 RW RW RW F18 15A 2 UY O 220 Ω EC57-3 EC57-7 I 21 470 Ω EC101-8 O IP7-2 IP26-3 270 Ω P EC101-7 MAIN EXIT DELAY 3 220 Ω DIP B EC35-8 EXIT DELAY 2 EC102-4 EC101-1 YB HEADLAMP LEVELING MODULE* EXIT DELAY 1 180 Ω 37 DIP BEAM RELAY 270 Ω DIP EC57-4 EC40-5 EC40-8 AUTOLAMP 470 Ω 1 EC102-3 OG F9 20A 2 U O 180 Ω 5 IP7-13 IP26-4 SIDE LAMPS 3 19 EC102-2 4 5 OG F16 20A I IP7-12 IP26-2 MAIN BEAM 4 3 2 RW O EC36-21 1 EC6-7 EC35-4 MAIN 18 38 EC40-4 WB B II BW MAIN BEAM RELAY IP7-3 IP26-6 MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) EC6-1 EC103-7 B P EC103-8 OY F8 20A DIP EC6-4 EC35-3 EC6-3 EC104-1 EC103-1 G3BR EC104-2 EC104-3 FRONT POWER DISTRIBUTION FUSE BOX EC104-4 DIP WU CL2-2 WU WU HEADLAMP LEVELING MODULE* CC10-3 CL3-7 BK BK CCS3 BK CL3-3 1.2 ΚΩ CL1-5 CR10-10 Y Y CL1-7 CL3-5 Y TURN IP5-9 CC10-2 EC6-9 EC1-19 O BW BW O EC36-22 HAZARD SWITCH AND INDICATOR G15AR BR BR O 1.2 ΚΩ O EC6-6 RH HID HEADLAMP UNIT CENTER CONSOLE SWITCH PACK YB EC36-19 I BO B IP7-15 IP33-7 FOG LAMP SWITCHES IP5-14 B BK B B B B B IPS6 B P IP6-2 B BO CR9-12 CR85-2 CR1-26 CR10-14 CR10-11 P P G31BL BO O BO CR10-15 EC61-22 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + P Power Ground Battery Voltage O BF6-2 RH FRONT SIDE MARKER LAMP (NAS ONLY) FRONT ELECTRONIC MODULE O Output BFS5 BF6-1 * NOTE: Ballast integral within module. Refer to Fig. 08.6 for additional Headlamp Leveling Module details. G9CL G9BR 6 LH FRONT SIDE MARKER LAMP (NAS ONLY) BO BF1-8 + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data 66 S BF7-2 BO P G9BL INSTRUMENT CLUSTER O BF7-1 P P CR10-13 IPS2 AUXILIARY LIGHTING SWITCH 1 69 S EC31-1 RH TURN SIGNAL REPEATER 820 Ω (LHD) 470 Ω (RHD) 470 Ω (LHD) 820 Ω (RHD) O EC31-2 IP7-6 IP33-5 (LHD) IP33-6 (RHD) REAR BG BG O 3.9 ΚΩ FRONT EC6-8 SIDE VARIANT: HID Headlamp Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 67 S 68 S Fig. 08.3 CONTROL MODULE PIN-OUT INFORMATION Instrument Cluster Pin Description and Characteristic COMPONENTS O IP5-09 HAZARD INDICATOR: PULSED B+ Component Connector(s) Connector Description Location SG IP5-14 SIGNAL GROUND: GROUND AUTO LAMP SENSOR IP36 6-WAY / BLACK INSTRUMENT PANEL / CENTER FRONT PG IP6-02 POWER GROUND: GROUND AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN B+ IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ BRAKE ON / OFF SWITCH CZ1 2-WAY / GREEN TOP OF BRAKE PEDAL S IP6-10 SCP – CENTER CONSOLE SWITCH PACK IP6-20 SCP + CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE S HIGH-MOUNTED STOP LAMP RF27 2-WAY / BLACK PARCEL SHELF / CENTER I IP7-01 MAIN LIGHTING SWITCH SIGNALS: TURN SIGNALS; HAZARD WARNING: TURN = VARIABLE RESISTANCE; HAZARD = GROUND INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL I IP7-02 MAIN LIGHTING SWITCH SIGNALS: EXIT DELAY: VARIABLE RESISTANCE SG IP7-03 MAIN LIGHTING SWITCH SIGNAL GROUND: GROUND I IP7-06 FOG LAMPS SWITCH SIGNAL: VARIABLE RESISTANCE LICENSE PLATE LAMP – LH BT7 2-WAY / BLACK TRUNK LID I IP7-12 MAIN LIGHTING SWITCH SIGNALS: MAIN; FLASH: VARIABLE RESISTANCE LICENSE PLATE LAMP – RH BT6 2-WAY / BLACK TRUNK LID MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) IP26 6-WAY / BLACK STEERING COLUMN / LH SIDE REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REAR SIDE MARKER LAMP – LH BR7 2-WAY / BLACK REAR BUMPER / LH SIDE REAR SIDE MARKER LAMP – RH BR6 2-WAY / BLACK REAR BUMPER / RH SIDE I IP7-13 MAIN LIGHTING SWITCH SIGNALS: OFF; SIDE; DIP; AUTOLAMP: VARIABLE RESISTANCE SG IP7-15 AUXILIARY LIGHTING SWITCH SIGNAL GROUND: GROUND I IP7-21 AUTOLAMP SENSOR SIGNAL: VARIABLE RESISTANCE Rear Electronic Module Pin Description and Characteristic B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ PG CR11-11 POWER GROUND: GROUND TAIL LAMP UNIT – LH CR8 7-WAY / BLACK TRUNK / LH REAR SG CR11-12 LOGIC GROUND: GROUND TAIL LAMP UNIT – RH CR7 7-WAY / BLACK TRUNK / RH REAR SG CR11-25 LOGIC GROUND: GROUND SG CR11-26 LOGIC GROUND: GROUND O CR12-05 LICENSE PLATE LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR12-06 LH REAR SIDE MARKER LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR12-12 RH REAR SIDE MARKER LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND HARNESS IN-LINE CONNECTORS Connector Connector Description BL11 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS Location TRUNK / BEHIND TRUNK LID LINER BR1 10-WAY / GREY / CABIN HARNESS TO REAR BUMPER HARNESS TRUNK / RH SIDE / ADJACENT TO REAR ELECTRONIC MODULE S CR13-01 SCP + BT11 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS TRUNK / TRUNK LID S CR13-02 SCP – CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) I CR13-13 BRAKE ON / OFF SWITCH SIGNAL: B+ WHEN ACTIVATED CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST O CR71-03 LH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-04 RH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-05 RH TAIL LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-06 LH TAIL LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-09 REVERSE LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND Ground Location O CR71-10 REAR FOG LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL O CR71-11 RH STOP LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE O CR71-12 LH STOP LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND G31 CABIN / BEHIND PASSENGER AIR BAG SG CR71-15 LOGIC GROUND: GROUND PG CR73-02 POWER GROUND (FUEL PUMP): GROUND GROUNDS FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Exterior Lighting: Rear OG O 87 B IP6-3 NW 60 B CR4-3 REFER TO APPENDIX SCP / REM LIGHTING MESSAGES 18.1 PARKING AID: REVERSE SELECTED (CIRCUIT CONTINUED) O WB IP36-6 B IPS35 SCP LOGIC B S B NW 78 LOGIC I IP36-4 + Y S 20.2 20.3 20.3 20.2 Y IP6-20 IP7-21 IP36-1 – O NR RF27-1 RF2-15 S + CR13-1 U S 20.2 20.3 20.3 20.2 U IP6-10 G31AL HIGH–MOUNTED STOP LAMP O O AUTOLAMP GO CR78-2 WR 270 Ω GO CRS16 CR8-3 STOP NW CR13-13 G O IP7-13 CRS68 I I IP26-4 SIDE LAMPS 180 Ω O CR71-12 DIP BEAM CR71-6 83 105 S CR8-1 CR8-2 OFF GO NG TAIL UY O AUTOLAMP UY CR71-10 CZ1 -2 470 Ω 104 S RF27-2 10 ΚΩ S – CR13-2 AUTOLAMP SENSOR 470 Ω Fig. 08.3 Exterior Lighting: Rear CRS35 CR8-6 FOG -1 EXIT DELAY 1 WG 270 Ω I NW U O CR71-3 IP7-2 IP26-3 EXIT DELAY 2 CR8-5 88 S CR8-7 TURN 180 Ω EXIT DELAY 3 OG O 56 Ω CR71-9 BRAKE ON / OFF SWITCH 220 Ω OG CRS36 CR8-4 REVERSE LH TURN LH TAIL LAMP UNIT 270 Ω WU 470 Ω RH TURN 220 Ω WU IPS22 IP26-1 I IP7-1 OG OG O CR12-6 89 S BR7-1 LH REAR SIDE MARKER LAMP (NAS ONLY) FLASH 270 Ω W 470 Ω NR BR7-2 BR1-4 I IP7-12 IP26-2 MAIN BEAM W O CR71-11 CR7-3 BW STOP NR IP7-3 IP26-6 GB O MAIN LIGHTING SWITCH (COLUMN SWITCHGEAR) CR71-5 78 S CR7-1 CR7-2 TAIL UY WU WU CL2-2 WU CR7-6 FOG CC10-3 CL3-7 1.2 ΚΩ BK BK CCS3 CL3-3 BK CL1-5 CL1-7 Y Y CL3-5 CC10-2 NG O O Y 1.2 ΚΩ CR71-4 O CR7-5 TURN IP5-9 HAZARD SWITCH AND INDICATOR G15AR 101 S CR7-7 OG CR7-4 CENTER CONSOLE SWITCH PACK REVERSE RH TAIL LAMP UNIT 3.9 ΚΩ YB I IP7-6 IP33-5 (LHD) IP33-6 (RHD) FRONT 820 Ω (LHD) 470 Ω (RHD) REAR 470 Ω (LHD) 820 Ω (RHD) CR12-12 BO B IP7-15 IP33-7 FOG LAMP SWITCHES OY OY O IP5-14 IPS6 B P B B CRS75 B B B B B B AUXILIARY LIGHTING SWITCH G31BL CR71-15 CR11-11 P U CR11-25 U O CR11-12 CR12-5 U BL11-4 U BT11-4 NR BT7-2 LH BT7-1 BT6-2 RH BT6-1 U G24BR G24BL 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data S NR LICENSE PLATE LAMPS REAR ELECTRONIC MODULE 91 BTS1 G24AR INSTRUMENT CLUSTER 90 S BR6-1 RH REAR SIDE MARKER LAMP (NAS ONLY) CR11-26 IPS2 IP6-2 NR BR6-2 BR1-3 VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 92 S Fig. 08.4 CONTROL MODULE PIN-OUT INFORMATION Rear Electronic Module Pin Description and Characteristic COMPONENTS O CR4-20 TRAILER CONNECTED SIGNAL: GROUND = TRAILER CONNECTED Component Connector(s) Connector Description Location O CR12-05 LICENSE PLATE LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND BATTERY — — TRUNK / RH SIDE HIGH-MOUNTED STOP LAMP RF27 2-WAY / BLACK PARCEL SHELF / CENTER BT7 2-WAY / BLACK TRUNK LID O CR71-03 LH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND LICENSE PLATE LAMP – LH O CR71-04 RH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND LICENSE PLATE LAMP – RH BT6 2-WAY / BLACK TRUNK LID O CR71-05 RH TAIL LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND REAR ELECTRONIC MODULE CR71-06 LH TAIL LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-09 REVERSE LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-10 REAR FOG LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-11 RH STOP LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-12 LH STOP LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR O CR4 CR11 CR12 CR13 CR71 CR73 TAIL LAMP UNIT – LH CR8 7-WAY / BLACK TRUNK / LH REAR TAIL LAMP UNIT – RH CR7 7-WAY / BLACK TRUNK / RH REAR TRAILER TOWING CONNECTOR TT8 TT18 DATA NOT AVAILABLE DATA NOT AVAILABLE NOTE: Refer to the Appendix at the rear of this book for Network Messages. TRAILER TOWING JUNCTION FUSE BOX TT12 DATA NOT AVAILABLE TRAILER TOWING MODULE TT15 TT16 TT17 DATA NOT AVAILABLE DATA NOT AVAILABLE DATA NOT AVAILABLE TRAILER TOWING RELAY TT9 DATA NOT AVAILABLE HARNESS IN-LINE CONNECTORS Connector Connector Description Location BL11 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS TRUNK / BEHIND TRUNK LID LINER BT11 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS TRUNK / TRUNK LID CR106 8-WAY / BLACK / TRAILER TOWING HARNESS TRUNK / RH SIDE CR107 8-WAY / BLACK / TRAILER TOWING HARNESS TRUNK / RH SIDE RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST TT10 2-WAY / GREY / TRAILER TOWING HARNESS TRUNK / SPARE WHEEL WELL GROUNDS Ground Location BC1 TRUNK / RH SIDE / ADJACENT TO BATTERY BC3 TRUNK / RH SIDE / ADJACENT TO BATTERY G29 TRUNK / SPARE WHEEL WELL FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Exterior Lighting: Rear – European Trailer Towing RG O RG CR4-20 18.1 CRS69 PARKING AID: TRAILER CONNECTED (CIRCUIT CONTINUED) U LIGHTING INPUTS: REFER TO FIG. 08.3. U O CR12-5 Fig. 08.4 Exterior Lighting: Rear – European Trailer Towing U BL11-4 U NR BT7-2 LH BT7-1 BT6-2 RH BT6-1 91 S BTS1 BT11-4 U NR 92 S LICENSE PLATE LAMPS O O RF2-15 NR RF27-1 104 S RF27-2 10 ΚΩ HIGH–MOUNTED STOP LAMP O O O CR71-12 CRS68 P CR106-3 TT1-3 P N STOP TT12-2 F1 15A G O CR71-6 B B N BC2 CR106-2 OW N TT11 TT12-4 G OW TT1-1 TT1-2 NW 105 S CR106-1 TT12-3 F2 20A TAIL BC1 N BATTERY BC3 UY O CR71-10 TT12-1 F3 15A PY CRS35 TT1-6 FOG TRAILER TOWING JUNCTION FUSE BOX BW U O CR71-3 G TT1-5 TT1-7 NW 88 S CR106-7 TURN OG O N NG TT9-3 TT9-5 WR 47 II CR107-3 LH TAIL LAMP UNIT GB O CR71-5 TRAILER TOWING RELAY TT1-4 REVERSE CR71-11 TT9-2 G CR106-4 W O B TT9-1 OG CRS36 CR71-9 CR107-2 O O CR71-4 REAR ELECTRONIC MODULE TTS9 NG B N B N TT18-9 TT16-1 B PO REVERSE LAMPS PO TT17-6 TT18-8 O RH TAIL LAMP O FOG LAMPS YR YR P P O OW LH TAIL LAMP U LH TURN SIGNAL UR RH TURN SIGNAL UR TT18-4 B P B TTS4 TT18-3 BR TT2-4 REVERSE P RH TAIL LAMP UNIT OW TT15-5 TT8-3 TT8-7 B PY O TTS2 B P TT2-7 TT10-2 BR I CR107-7 TURN TT15-2 P NG G RG TT16-4 B P S I TT17-1 FOG GB TT2-5 TT16-8 O TT17-5 UY GB O TAIL CR106-6 O O TT17-3 TT15-6 BW O B TT15-3 TRAILER TOWING CONNECTOR GR B TT16-7 G29AS TRAILER TOWING MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E 78 S CR107-1 TT2-6 TT16-3 O U TT18-1 PY TT15-4 O TT17-7 TT18-7 PY RW I O OW O TT16-6 O TT17-2 TT18-6 O NR G TT2-1 TT2-2 TT16-5 O TT17-4 TT18-2 STOP LAMPS STOP O OG CR107-4 I TT17-9 TT18-5 TT16-2 O TT2-3 CR106-5 OP I G U W TT15-1 TT18-10 O CR107-5 I TT17-10 N B GR I TT17-8 I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: European Trailer Towing Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 101 S Fig. 08.5 CONTROL MODULE PIN-OUT INFORMATION Rear Electronic Module Pin Description and Characteristic COMPONENTS O CR4-20 TRAILER CONNECTED SIGNAL: GROUND = TRAILER CONNECTED Component Connector(s) Connector Description Location O CR12-05 LICENSE PLATE LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND BATTERY — — TRUNK / RH SIDE HIGH-MOUNTED STOP LAMP RF27 2-WAY / BLACK PARCEL SHELF / CENTER BT7 2-WAY / BLACK TRUNK LID O CR71-03 LH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND LICENSE PLATE LAMP – LH O CR71-04 RH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND LICENSE PLATE LAMP – RH BT6 2-WAY / BLACK TRUNK LID O CR71-05 RH TAIL LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND REAR ELECTRONIC MODULE CR71-06 LH TAIL LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-09 REVERSE LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-10 REAR FOG LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-11 RH STOP LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND O CR71-12 LH STOP LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR O CR4 CR11 CR12 CR13 CR71 CR73 TAIL LAMP UNIT – LH CR8 7-WAY / BLACK TRUNK / LH REAR TAIL LAMP UNIT – RH CR7 7-WAY / BLACK TRUNK / RH REAR TRAILER TOWING CONNECTORS TT8 TT18 DATA NOT AVAILABLE DATA NOT AVAILABLE NOTE: Refer to the Appendix at the rear of this book for Network Messages. TRAILER TOWING JUNCTION FUSE BOX TT12 DATA NOT AVAILABLE TRAILER TOWING MODULE TT15 TT16 TT17 DATA NOT AVAILABLE DATA NOT AVAILABLE DATA NOT AVAILABLE TRAILER TOWING RELAY TT9 DATA NOT AVAILABLE HARNESS IN-LINE CONNECTORS Connector Connector Description Location BL11 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS TRUNK / BEHIND TRUNK LID LINER BT11 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS TRUNK / TRUNK LID CR106 8-WAY / BLACK / TRAILER TOWING HARNESS TRUNK / RH SIDE CR107 8-WAY / BLACK / TRAILER TOWING HARNESS TRUNK / RH SIDE RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST TT3 DATA NOT AVAILABLE TRAILER TOWING HARNESS TT10 2-WAY / GREY / TRAILER TOWING HARNESS TRUNK / SPARE WHEEL WELL TT20 DATA NOT AVAILABLE TRAILER TOWING HARNESS GROUNDS Ground Location BC1 TRUNK / RH SIDE / ADJACENT TO BATTERY BC3 TRUNK / RH SIDE / ADJACENT TO BATTERY G29 TRUNK / SPARE WHEEL WELL FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Exterior Lighting: Rear – U.K. Trailer Towing RG O Fig. 08.5 Exterior Lighting: Rear – U.K. Trailer Towing RG CR4-20 18.1 CRS69 PARKING AID: TRAILER CONNECTED (CIRCUIT CONTINUED) U LIGHTING INPUTS: REFER TO FIG. 08.3. U O U CR12-5 BL11-4 U NR BT7-2 LH BT7-1 BT6-2 RH BT6-1 91 S BTS1 BT11-4 U NR 92 S LICENSE PLATE LAMPS O O RF2-15 NR RF27-1 104 S RF27-2 10 ΚΩ B B UR BC2 HIGH–MOUNTED STOP LAMP N TT11 O O 15A O CR71-12 BC1 CRS68 P CR106-3 TT1-3 P BATTERY BC3 N STOP TT12-2 F1 15A G O CR71-6 N CR106-2 OW N TT12-4 G OW TT1-1 TT1-2 NW 105 S CR106-1 TT12-3 F2 20A TAIL N UY O CR71-10 TT12-1 F3 15A PY CRS35 TT1-6 FOG TRAILER TOWING JUNCTION FUSE BOX BW U O CR71-3 G TT1-5 TT1-7 NW 88 S CR106-7 TURN OG O N NG TT9-3 WR 47 II TT9-5 WR OG CR107-3 LH TAIL LAMP UNIT GB O CR71-5 TRAILER TOWING RELAY TT1-4 REVERSE CR71-11 TT9-2 G CR106-4 W O B TT9-1 TT20M/F-1 CRS36 CR71-9 CR107-2 O O CR71-4 REAR ELECTRONIC MODULE TTS9 NG B N N TT8-6 TT16-1 TT15-1 TT8-4 PO TT8-1 PO TT17-6 TT3M/F-1 I B P O TTS2 B CR107-4 O O PY PY TT16-6 TT8-7 TT15-4 O O YR YR P P STOP LAMPS OW OW U LH TURN SIGNAL UR B B 7 63 95 Fig. 01.2 15 I II TT10-2 BR TT2-4 REVERSE TT15-2 RH TAIL LAMP UNIT OW I CR107-7 TURN P TT15-5 PY O TT15-6 BW O P TT15-3 B GR B TT16-7 Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E TRAILER TOWING MODULE I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data NG G RG BR I TT17-1 G29AS 1 S TT16-4 O B TTS4 FOG GB TT2-5 TT16-8 TT17-5 TRAILER TOWING CONNECTORS 64 O O UR TT7-4 TT7-3 Fig. 01.1 O TT17-3 P 6 O O U TT7-1 1 O TT17-7 TT7-7 UY TT16-3 TT17-2 TT7-6 LH TAIL LAMP 78 S CR107-1 TAIL CR106-6 GB O TT17-4 TT7-2 RH TURN SIGNAL O TT17-9 TT7-5 FOG LAMPS NR G TT2-1 TT2-2 TT2-6 RW I RH TAIL LAMP STOP O OG TT16-5 TT8-3 P TT2-3 CR106-5 TT16-2 O G U OP I REVERSE LAMPS O CR107-5 W I B TT17-10 N B GR I B TT17-8 VARIANT: U.K. Trailer Towing Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 TT2-7 101 S Fig. 08.6 CONTROL MODULE PIN-OUT INFORMATION Air Suspension Module Pin Description and Characteristic COMPONENTS B+ CR88-01 BATTERY POWER SUPPLY: B+ Component Connector(s) Connector Description Location AIR SUSPENSION MODULE CR88 CR89 CR90 CR91 9-WAY / BLACK 12-WAY / BLACK 15-WAY / BLACK 18-WAY / BLACK CABIN REAR BULKHEAD / BEHIND REAR SEAT BACK / RH SIDE HID HEADLAMP UNIT – LH EC57 9-WAY / BLACK ENGINE COMPARTMENT / LH FRONT HID HEADLAMP UNIT – RH EC6 9-WAY / BLACK ENGINE COMPARTMENT / RH FRONT B+ CR88-02 SWITCHED SYSTEM POWER SUPPLY (WAKE UP): B+ PG CR88-03 POWER GROUND: GROUND O CR89-03 HEADLAMP LEVELING SENSOR: PWM NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description Location EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST GROUNDS Ground Location G1 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY G3 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G17 CABIN / BELOW REAR SEAT / RH SIDE FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Headlamp Leveling 37 Headlamp Leveling YB II W D B EC57-1 EC101-7 EC101-2 20.2 20.3 20.2 20.3 EC57-5 EC101-6 EC101-9 YB NW 6 EC101-10 I PWM EC57-2 B EC101-4 EC101-11 CR88-1 N 98 B S EC101-12 CR88-2 STEPPER MOTOR AND ACTUATOR B P EC101-8 EC57-3 G1AR HEADLAMP LEVELING MODULE LH HID HEADLAMP UNIT PWM Y O SUSPENSION SENSOR INPUTS FIG. 05.3 Y CR89-3 ECS15 EC1-9 38 WB II W D B EC6-1 EC103-7 EC103-2 EC6-5 EC103-6 Y B P EC103-9 I PWM EC6-2 EC103-4 CR88-3 EC103-10 G17AL EC103-11 AIR SUSPENSION MODULE EC103-12 P EC103-8 STEPPER MOTOR AND ACTUATOR B EC6-3 G3BR HEADLAMP LEVELING MODULE RH HID HEADLAMP UNIT 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: HID Headlamp Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 08.6 Fig. 09.1 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS O DD12-13 DRIVER DOOR PUDDLE LAMP ACTIVATE: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ Component Connector(s) Connector Description Location O DD12-21 DRIVER APPROACH LAMP ACTIVATE: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ I DD12-25 DRIVER DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR APPROACH LAMP – DRIVER DOOR DD9 22-WAY / BLACK DRIVER DOOR MIRROR APPROACH LAMP – PASSENGER DOOR PD9 22-WAY / BLACK PASSENGER DOOR MIRROR S DD13-03 SCP NETWORK + COURTESY LAMP – LH REAR RF21 3-WAY / BLACK LH REAR ASSIST HANDLE S DD13-04 SCP NETWORK – COURTESY LAMP – RH REAR RF22 3-WAY / BLACK RH REAR ASSIST HANDLE SG DD13-07 LOGIC GROUND: GROUND DOOR AJAR SWITCH – DRIVER DD7 DD10 DD7 DD10 2-WAY / BLACK 3-WAY / BLACK 2-WAY / BLACK 3-WAY / BLACK DRIVER DOOR DOOR AJAR SWITCH – LH REAR RL7 RL10 2-WAY / BLACK 3-WAY / BLACK LH REAR DOOR DOOR AJAR SWITCH – PASSENGER PD7 PD10 2-WAY / BLACK 3-WAY / BLACK PASSENGER DOOR RR7 RR10 2-WAY / BLACK 3-WAY / BLACK RH REAR DOOR PG DD13-08 POWER GROUND: GROUND B+ DD13-11 BATTERY POWER SUPPLY: LOGIC: B+ B+ DD13-12 SWITCHED SYSTEM POWER SUPPLY: B+ Front Electronic Module DRIVER DOOR Pin Description and Characteristic DOOR AJAR SWITCH – RH REAR I CR1-01 PASSENGER DOOR AJAR SWITCH SIGNAL: GROUND WHEN ACTIVATED FOOTWELL LAMP – LH FRONT IP13 2-WAY / WHITE INSTRUMENT PANEL / LH SIDE / UNDER O CR1-02 PASSENGER DOOR PUDDLE LAMP ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ FOOTWELL LAMP – LH REAR SD23 2-WAY / WHITE LH FRONT SEAT / LOWER REAR I CR1-03 MASTER LIGHTING SWITCH SIGNAL: GROUND WHEN ACTIVATED FOOTWELL LAMP – RH FRONT IP14 2-WAY / WHITE INSTRUMENT PANEL / RH SIDE / UNDER O CR1-05 PASSENGER DOOR APPROACH LAMP ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ FOOTWELL LAMP – RH REAR SP23 2-WAY / WHITE RH FRONT SEAT / LOWER REAR FRONT ELECTRONIC MODULE CR9-01 SCP – B+ CR9-06 BATTERY POWER SUPPLY: LOGIC: B+ S CR9-07 SCP + SG CR9-12 LOGIC GROUND: GROUND CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST S GLOVE BOX LAMP – LH IP28 2-WAY / GREY GLOVE BOX O CR10-06 FRONT FOOTWELL LAMPS ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND GLOVE BOX LAMP – RH IP43 2-WAY / GREY GLOVE BOX PG CR10-11 POWER GROUND: GROUND PG CR10-13 POWER GROUND: GROUND B+ CR85-01 SWITCHED SYSTEM POWER SUPPLY: B+ Rear Electronic Module MAP LAMP – LH REAR RF21 3-WAY / BLACK LH REAR ASSIST HANDLE MAP LAMP – RH REAR RF22 3-WAY / BLACK RH REAR ASSIST HANDLE PUDDLE LAMP – DRIVER DOOR DT2 2-WAY / WHITE DRIVER DOOR TRIM PUDDLE LAMP – LH REAR DOOR LT2 2-WAY / WHITE LH REAR DOOR TRIM PUDDLE LAMP – PASSENGER DOOR PT2 2-WAY / WHITE PASSENGER DOOR TRIM PUDDLE LAMP – RH REAR DOOR RT2 2-WAY / WHITE RH REAR DOOR TRIM REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF TRUNK LAMP CR18 2-WAY / BLACK TRUNK / CENTER FRONT TRUNK LATCH BT2 8-WAY / BLACK TRUNK LID TRUNK LID LAMP BT3 2-WAY / BLACK TRUNK LID VANITY MIRROR LAMP – LH RF4 2-WAY / BLACK LH SUN VISOR VANITY MIRROR LAMP – RH RF5 2-WAY / BLACK RH SUN VISOR Pin Description and Characteristic B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ I CR4-17 RH REAR DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR SG CR11-10 TRUNK LATCH SIGNAL GROUND: GROUND PG CR11-11 POWER GROUND: GROUND I CR11-16 LH REAR DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR SG CR11-25 LOGIC GROUND: GROUND O CR12-11 TRUNK LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND S CR13-01 SCP + HARNESS IN-LINE CONNECTORS S CR13-02 SCP – Connector Connector Description Location BL11 BT11 DD1 DD3 DD3 DT6 IP2 LT1 PD1 PD16 PT1 RF2 RF25 RL1 RL9 RR1 RR9 RT1 SD28 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS 16-WAY / BLUE / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS 12-WAY / GREY / LH REAR DOOR HARNESS TO LH REAR DOOR TRIM HARNESS 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS 12-WAY / GREY / PASSENGER DOOR HARNESS TO PASSENGER DOOR TRIM HARNESS 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS 8-WAY / BLACK / CABIN HARNESS TO ROOF HARNESS 6-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS 16-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS 6-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS 16-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS 12-WAY / GREY / RH REAR DOOR HARNESS TO RH REAR DOOR TRIM HARNESS 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS TRUNK / BEHIND TRUNK LID LINER TRUNK / TRUNK LID CABIN / DRIVER SIDE ‘A’ POST CABIN / DRIVER SIDE ‘A’ POST CABIN / DRIVER SIDE ‘A’ POST CABIN / BEHIND DRIVER DOOR TRIM CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE CABIN / LH REAR DOOR TRIM CABIN / PASSENGER SIDE ‘A’ POST CABIN / PASSENGER SIDE ‘A’ POST CABIN / BEHIND PASSENGER DOOR TRIM CABIN / RH ‘D’ POST CABIN / UPPER LH ‘A’ POST CABIN / LH ‘B/C’ POST CABIN / LH ‘B/C’ POST CABIN / RH ‘B/C’ POST CABIN / RH ‘B/C’ POST CABIN / RH REAR DOOR TRIM CABIN / BELOW DRIVER SEAT I CR13-14 TRUNK AJAR SWITCH SIGNAL: GROUND (SIGNAL) WHEN TRUNK IS AJAR O CR13-20 LH REAR DOOR PUDDLE LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ O CR13-22 RH REAR DOOR PUDDLE LAMP ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ O CR71-01 REAR COURTESY LAMPS ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND NOTE: Refer to the Appendix at the rear of this book for Network Messages. GROUNDS Ground Location G9 G10 G12 G13 G17 G24 G32 CABIN / UPPER LH A POST CABIN / RH A POST CABIN / BELOW DRIVER SEAT CABIN / BELOW PASSENGER SEAT CABIN / BELOW REAR SEAT / RH SIDE TRUNK / RH SIDE / REAR ELECTRONIC MODULE CABIN / BEHIND INSTRUMENT CLUSTER The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Interior Lighting NW 79 B + DD13-11 B S * NOTE: Double Locking vehicles. 20.2 REFER TO APPENDIX DDM, FEM AND REM INTERIOR LIGHTING MESSAGES WB 20.3 DD13-3 N 76 SCP Y S – S 20.2 20.3 WB DD13-4 DD13-12 GO DD7-1 DD10-2* DD7-2 DD10-3* I DD12-13 DD12-25 DRIVER DOOR AJAR SWITCH BK IPS4 REMOTE ENTRY BK DT2-2 B B B DDS1 DD3-8 B DDS1 DD9-19 WB CRS2 G9AL (G10AL) WB RF25-3 RF3-3 DRIVER DOOR MIRROR G9AL (G10AL) S B DD3-8 APPROACH LAMP DD13-8 62 IP14-2 RH FRONT FOOTWELL LAMP DD9-18 P NW IP14-1 B DD12-21 DD13-7 S WB B DT6-3 DT2-1 G O DDS3 G9AR (G10AR) DT6-4 B DRIVER DOOR PUDDLE LAMP BK DD1-7 GW GW O 61 IP13-2 LH FRONT FOOTWELL LAMP WB IP2-4 BK NW IP13-1 U Fig. 09.1 Interior Lighting COURTESY LAMPS O DRIVER DOOR MODULE 72 S RF3-9 RH MAP LAMP B RF3-1 NW 80 B + CR9-6 B S B B RF2-1 B G17BR I 20.2 20.3 LH MAP LAMP ROOF CONSOLE WB O CR1-3 RF25-4 20.3 CR9-1 R RF3-2 MASTER LIGHTING SWITCH U – S CR85-1 R RFS1 RF3-1 20.2 CR9-7 NW 64 Y S B O CR10-6 RF4-3 ROOF CONSOLE BK BK PD16-17 LH VANITY MIRROR LAMP BK PDS3 GU PD7-1 PD10-2* PD7-2 PD10-3* G10AL (G9AL) GU I O CR1-1 PD16-22 GW GW GW CR1-2 PD1-11 PT1-5 B PT2-2 PASSENGER DOOR AJAR SWITCH B PT1-6 PT2-1 B PASSENGER DOOR PUDDLE LAMP B * NOTE: Double Locking vehicles. B B G O CR9-12 PD16-15 B PD9-18 B PDS1 PD9-19 B P RH VANITY MIRROR LAMP G10AR (G9AR) B PASSENGER DOOR MIRROR B RF2-1 B RFS1 RF21-3 G9CL UY FRONT ELECTRONIC MODULE G9BL RU MAP LAMP G17BR 96 S RF21-2 RF21-1 COURTESY LAMP LH REAR ASSIST HANDLE + NW 78 CR4-3 Y S 20.2 20.3 20.2 20.3 CR13-1 B – U S B CR13-2 BK RL1-5 GW RL7-1 RL10-2* RL7-2 RL10-3* G12BL GW CR11-16 RL9-8 MAP LAMP G13BL CRS6 CR71-1 GW GW I GR O CR4-17 RR9-8 GR CR13-20 RL9-6 GR LT1-1 B LT2-1 RH REAR DOOR AJAR SWITCH GW O CR13-22 AJAR SWITCH BT2-8 WG BT11-5 BO BT2-6 WG GW RT1-1 BO I BL11-11 B B P O RT2-2 CR11-11 63 Fig. 01.2 15 I II 16 52 Fig. 01.4 53 77 II S II S B RRS2 RU SD23-1 94 S SD23-2 B UY RR1-2 UY RU SP28-16 G13BR SP23-1 95 S SP23-2 RH REAR FOOTWELL LAMP B 85 S CR18-2 B B IPS5 G32AL Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E RW BL11-10 RW BT11-10 NG BT3-1 BT3-2 84 S I Input B + P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground RH GLOVE BOX LAMP B IP29-1 IP29-2 GLOVE BOX LAMP SWITCH A ACP S SCP C CAN D Serial and Encoded Data 56 S IP43-2 IPS9 B O IP28-1 IP28-2 LH GLOVE BOX LAMP TRUNK LID LAMP O Output O IP43-1 TRUNK LAMP CRS9 REAR ELECTRONIC MODULE Fig. 01.3 UY SD28-16 CR11-25 G24BL 7 B RT1-2 NG RW CR12-11 RW 95 UY CR11-10 CRS75 1 RF22-3 B RL1-2 RH REAR DOOR PUDDLE LAMP BO B 64 B RLS2 RW Fig. 01.1 97 S RF22-2 LH REAR FOOTWELL LAMP CR18-1 6 RU UY RFS3 RF2-7 G12BR B RT2-1 CR13-14 BL11-5 BT11-11 GW RR9-6 TRUNK LATCH 1 B LT1-2 LT2-2 LH REAR DOOR PUDDLE LAMP * NOTE: Double Locking vehicles. WG UY COURTESY LAMP RR7-1 RR10-2* RR7-2 RR10-3* UY RH REAR ASSIST HANDLE BK RR1-5 UY O LH REAR DOOR AJAR SWITCH BK RF22-1 I VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 71 S RF5-2 PD1-7 APPROACH LAMP P CR10-11 O RF5-3 G CR1-5 CR10-13 BK 70 S RF4-2 57 S Fig. 09.2 CONTROL MODULE PIN-OUT INFORMATION Climate Control Module Pin Description and Characteristic COMPONENTS O AC101-19 PANEL BACK LIGHTING: CCM INDICATES TO PANEL TO BACKLIGHT LCD Component Connector(s) Connector Description Location I CR119-11 DIMMER CONTROLLED ILLUMINATION: PWM, 80Hz, GROUND = 0% DUTY CYCLE, B+ = 100% DUTY CYCLE AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE AUDIO / VIDEO SELECTOR TL20 TL85 TL86 TL87 20-WAY / BLACK 20-WAY / BLACK 20-WAY / BLACK 20-WAY / BLACK CABIN REAR BULKHEAD / BEHIND REAR SEAT BACK / LH SIDE Front Electronic Module Pin Description and Characteristic S CR9-01 SCP – S CR9-07 SCP + AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN SG CR9-12 LOGIC GROUND: GROUND CENTER CONSOLE SWITCH PACK CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE PG CR10-11 POWER GROUND: GROUND CIGAR LIGHTER – FRONT TL69 3-WAY / BLACK CENTER CONSOLE PG CR10-13 POWER GROUND: GROUND CIGAR LIGHTER – REAR TL70 3-WAY / BLACK REAR CENTER CONSOLE B+ CR85-01 SWITCHED SYSTEM POWER SUPPLY: B+ CLOCK IP19 6-WAY / BLACK INSTRUMENT PANEL / CENTER VENT O CR85-11 BULB BACK LIGHTING ACTIVATE: B+ PWM CLIMATE CONTROL MODULE CR85-12 LED BACK LIGHTING ACTIVATE: B+ PWM 16-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK CLIMATE CONTROL UNIT / DRIVER SIDE O AC100 AC101 CR119 CENTER CONSOLE CLIMATE CONTROL PANEL CC20 12-WAY / BLACK Instrument Cluster FASCIA VENT – LH IP52 2-WAY / BLACK INSTRUMENT PANEL / LH SIDE Pin Description and Characteristic FASCIA VENT – RH IP54 2-WAY / BLACK INSTRUMENT PANEL / RH SIDE SG IP5-14 SIGNAL GROUND: GROUND FRONT ELECTRONIC MODULE IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ S IP6-10 SCP – 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST B+ CR1 CR9 CR10 CR85 EC36 S IP6-20 SCP + INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL IP7-05 DIMMER SIGNAL: VARIABLE VOLTAGE SG IP7-15 AUXILIARY LIGHTING SWITCH SIGNAL GROUND: GROUND SS I IP7-16 DIMMER SUPPLY VOLTAGE: B+ J GATE MODULE IP32 16-WAY / BLACK J GATE ASSEMBLY MULTIMEDIA CONTROL PANEL RC1 RC3 RC5 8-WAY / BLACK 20-WAY / BLACK FIBER OPTIC CONNECTOR REAR SEAT ARM REST OR REAR FLOOR CONSOLE POWER POINT – FRONT IP21 3-WAY / BLACK FRONT CENTER CONSOLE GLOVE BOX POWER POINT – REAR TL72 3-WAY / BLACK REAR CENTER CONSOLE REAR CENTER CONSOLE SWITCH PACK CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE REAR CLIMATE CONTROL MODULE RA1 RA2 16-WAY / BLACK 12-WAY / BLACK REAR CENTER CONSOLE STEERING WHEEL LIGHTING — — STEERING WHEEL TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE TRUNK AND FUEL FLAP RELEASE SWITCH PACK IP50 10-WAY / BLACK INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) IP2 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP20 16-WAY / BLUE / AIR CONDITIONING HARNESS TO INSTRUMENT PANEL HARNESS CABIN / LH SIDE TO CLIMATE CONTROL UNIT IP66 14-WAY / GREY / INSTRUMENT PANEL HARNESS TO REAR AIR CONDITIONING HARNESS CABIN / BELOW CENTER CONSOLE RC2 8-WAY / BLACK / TELEMATICS HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS CABIN / BELOW CENTER CONSOLE TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE GROUNDS Ground Location G9 CABIN / UPPER LH A POST G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G18 CABIN / BELOW REAR SEAT / LH SIDE G31 CABIN / BEHIND PASSENGER AIR BAG G32 CABIN / BEHIND INSTRUMENT CLUSTER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 NW 64 Dimmer-Controlled Lighting: Part 1 NOTE: CRS19 – Refer to Fig. 09.3 for additional circuits. B S 20.3 20.2 B RW CRS19 CR85-12 Y RW RW RW O CR85-1 Fig. 09.2 Dimmer-Controlled Lighting: Part 1 IP52-1 IP52-2 IP17-7 LH FASCIA VENT S + CR9-7 20.3 U 20.2 S – RW RW O IP2-1 CR85-11 CR9-1 B B IPS5 IP19-5 IP19-2 RW B IP57-1 G32AL CLOCK CENTER FASCIA VENT RW B BK TL89-6 BK TLS55 TL89-7 CR9-12 B B RW G18BL CR10-11 B REAR CENTER CONSOLE SWITCH PACK P IP50-5 P RW FRONT ELECTRONIC MODULE G9BL B TL69-2 TL69-3 FRONT CIGAR LIGHTER O 87 B IP6-3 RW 20.2 20.3 20.2 Y B IP33-3 B IPS36 IP33-4 G31AL LOGIC AUXILIARY LIGHTING SWITCH RW 20.3 IP50-10 TRUNK AND FUEL FLAP RELEASE SWITCH PACK CR10-13 G9CL IP57-2 B TL70-2 S + TL70-3 IP6-20 U REAR CIGAR LIGHTER S – IP6-10 RW B IP32-3 B IPS5 IP32-2 G32AL NW RW IP7-16 IP33-9 TL93-11 RW RW RW TLS8 B TL72-2 I TL72-3 REAR POWER POINT IP7-5 IP33-8 J GATE MODULE SWITCH AND GEAR SELECTOR LIGHTING BO RW IP7-15 IP33-7 DIMMER B IPS39 RW AUXILIARY LIGHTING SWITCH B TL23-1 B IPS6 B IPS5 IP54-2 B G32AL RH FASCIA VENT TLS13 TL23-2 G18BR REAR VENTS B IP54-1 RW IP5-14 B IP21-2 G31BL INSTRUMENT CLUSTER IP21-3 G32AR FRONT POWER POINT RW B TL20-7 TL20-10 AUDIO / VIDEO SELECTOR CASSETTE CASSETTE RW B SW8-4 RW BK RW CC12-12 RW CCS2 CC12-9 G15AR RW CC2-1 RW RW RC2-4 B RC1-1 RC1-8 TL28-1 MULTIMEDIA CONTROL PANEL NOTE: CCS2 – Navigation vehicles only. TELEMATICS DISPLAY B SW9-1 B IPS2 G31BL STEERING WHEEL SWITCH LIGHTING B TLS6* TLS56** RC2-5 NOTE: *TLS6 – vehicles with Rear DVD; **TLS56 – vehicles without Rear DVD. G18BL RW RW B RA2-3 IP66-8 RA2-1 B IP66-10 G32BS BK BK CCS3 RW BK CL3-3 CL1-5 CL1-1 RW RW CL3-1 RW TL28-3 RW CC2-3 REAR CLIMATE CONTROL MODULE B CC8-17 CC8-1 G15AL G15AR RW AUDIO UNIT CENTER CONSOLE SWITCH PACK 63 I S CR119-11 O NOTE: CCS3 – Non Navigation vehicles only. UY AC101-19 UY IP20-11 NW UY CC10-11 B CC20-12 I CC20-5 BK P CC20-6 BK CCS3 G15AR CLIMATE CONTROL MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data CLIMATE CONTROL CONTROL PANEL (VEHICLES WITHOUT NAVIGATION) VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 09.3 CONTROL MODULE PIN-OUT INFORMATION Front Electronic Module Pin Description and Characteristic COMPONENTS S CR9-01 SCP – Component Connector(s) Connector Description S CR9-07 SCP + SG CR9-12 LOGIC GROUND: GROUND AUXILIARY LIGHTING SWITCH IP50 10-WAY / GREY INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL PG CR10-11 POWER GROUND: GROUND PG CR10-13 POWER GROUND: GROUND B+ CR85-01 SWITCHED SYSTEM POWER SUPPLY: B+ O CR85-12 LED BACK LIGHTING ACTIVATE: B+ PWM Location Instrument Cluster DOOR SWITCH PACK – DRIVER DT4 20-WAY / BLACK DRIVER DOOR TRIM Pin Description and Characteristic DOOR SWITCH PACK – LH REAR LT3 8-WAY / BLACK LH REAR DOOR TRIM DOOR SWITCH PACK – PASSENGER PT4 8-WAY / BLACK PASSENGER DOOR TRIM SG IP5-14 SIGNAL GROUND: GROUND DOOR SWITCH PACK – RH REAR RT3 8-WAY / BLACK RH REAR DOOR TRIM B+ IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ MEMORY SWITCH PACK – DRIVER DT5 8-WAY / BLACK DRIVER DOOR TRIM S IP6-10 SCP – MEMORY SWITCH PACK – LH REAR LT5 8-WAY / BLACK LH REAR DOOR TRIM S IP6-20 SCP + MEMORY SWITCH PACK – RH REAR RT5 8-WAY / BLACK RH REAR DOOR TRIM REAR ASSIST HANDLE – LH RF14 2-WAY / BLACK CABIN ROOF / LH SIDE I IP7-05 DIMMER SIGNAL: VARIABLE VOLTAGE REAR ASSIST HANDLE – RH RF15 2-WAY / BLACK CABIN ROOF / LH SIDE SG IP7-15 AUXILIARY LIGHTING SWITCH SIGNAL GROUND: GROUND ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF SS IP7-16 DIMMER SUPPLY VOLTAGE: B+ REAR MEMORY MODULE CR21 CR37 CR38 CR41 CR53 CR59 4-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK 6-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK REAR BULKHEAD / BEHIND REAR SEAT BACK REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR Rear Electronic Module Pin Description and Characteristic PG CR11-11 POWER GROUND: GROUND SG CR11-25 LOGIC GROUND: GROUND O CR12-02 REAR WINDOW ISOLATE: TO ISOLATE, REM INTERRUPTS GROUND SUPPLY Rear Memory Module Pin Description and Characteristic SG CR37-14 REAR SEAT MEMORY SWITCH PACK REFERENCE GROUND: GROUND HARNESS IN-LINE CONNECTORS SG CR37-15 REAR SEAT MEMORY SWITCH PACK REFERENCE GROUND: GROUND Connector Connector Description SG CR37-26 SIGNAL GROUND: GROUND DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM LT1 12-WAY / GREY / LH REAR DOOR HARNESS TO LH REAR DOOR TRIM HARNESS CABIN / LH REAR DOOR TRIM PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PD16 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PT1 12-WAY / GREY / PASSENGER DOOR HARNESS TO PASSENGER DOOR TRIM HARNESS CABIN / BEHIND PASSENGER DOOR TRIM RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST RL9 16-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST RR9 16-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST RT1 12-WAY / GREY / RH REAR DOOR HARNESS TO RH REAR DOOR TRIM HARNESS CABIN / RH REAR DOOR TRIM NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location GROUNDS Ground Location G9 CABIN / UPPER LH A POST G10 CABIN / RH A POST G18 CABIN / BELOW REAR SEAT / LH SIDE G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE G31 CABIN / BEHIND PASSENGER AIR BAG FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Dimmer-Controlled Lighting: Part 2 RW NW 64 RW RW DD1-8 B 20.2 20.3 20.2 BK DT4-15 DT4-20 NOTE: DTS2 – Memory vehicles only. CR85-1 20.3 DTS2 DT1-7 S Fig. 09.3 Dimmer-Controlled Lighting: Part 2 DRIVER DOOR SWITCH PACK Y S + CR9-7 U RW S – BK DT5-2 CR9-1 BK DTS1 DT5-1 BK BK DDS3 DT1-9 BK DD1-7 G9AR (G10AR) DRIVER MEMORY SWITCH PACK B NOTE: CRS19 – refer to Fig. 09.2 for additional circuits. CR9-12 B B CR10-11 RW RW O P P CR85-12 CRS19 RW RW RR9-5 RW RTS2 RT1-3 R RT3-5 R RT3-1 RT1-8 R RR9-1 CR10-13 NOTE: RTS2 – Memory vehicles only. G9CL RH REAR DOOR SWITCH PACK FRONT ELECTRONIC MODULE G9BL RW BK RT5-2 O 87 B LOGIC 20.2 Y BK RT1-7 BK RR9-14 CR37-14 RH REAR MEMORY SWITCH PACK IP6-3 20.3 RT5-1 S + BK IP6-20 20.3 20.2 U RW S – BK LT5-2 IP6-10 LT1-7 BK CR37-26 RL9-14 CR37-15 G18AR LH REAR MEMORY SWITCH PACK NW REAR MEMORY MODULE IP7-16 IP33-9 RW I RW IP7-5 IP33-8 BO RW RL9-5 IP7-15 IP33-7 DIMMER LT5-1 BK RW RW LT1-3 LTS2 R LT3-5 NOTE: LTS2 – Memory vehicles only. R LT3-1 LT1-8 R R CRS54 RL9-1 P CR12-2 LH REAR DOOR SWITCH PACK AUXILIARY LIGHTING SWITCH P P CR11-11 CR11-25 B B B B CRS75 B IPS6 IP5-14 RW G31BL RF14-2 INSTRUMENT CLUSTER REAR ELECTRONIC MODULE * B G24BL RF14-1 LH REAR ASSIST HANDLE * NOTE: Rear Window isolate; refer to Fig. 14.1. RW RW RW RFS6 RF1-3 B RF15-2 RF15-1 RH REAR ASSIST HANDLE RW B RF3-10 B RFS1 RF3-1 B RF2-1 HALO ILLUMINATION G17BR ROOF CONSOLE RW RW PD1-9 RW PT1-1 BK PT4-5 PT4-1 BK PT1-2 PASSENGER DOOR SWITCH PACK 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data BK PDS3 BK PD16-17 G10AL (G9AL) VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 10.1 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS O DD12-07 MEMORY SET INDICATOR ACTIVATE: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ Component Connector(s) Connector Description I DD12-10 MEMORY 1, 2, 3, SET INPUT SIGNAL: VARIABLE RESISTANCE I DD12-25 DRIVER DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR COLUMN AND PEDAL ADJUST SWITCHES IP27 8-WAY / BLACK STEERING COLUMN COWL DOOR AJAR SWITCH – DRIVER DD7 DD10 2-WAY / BLACK 3-WAY / BLACK DRIVER DOOR DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL S DD13-03 SCP NETWORK + S DD13-04 SCP NETWORK – SG DD13-07 LOGIC GROUND: GROUND PG DD13-08 POWER GROUND: GROUND B+ DD13-11 BATTERY POWER SUPPLY: LOGIC: B+ B+ DD13-12 SWITCHED SYSTEM POWER SUPPLY: B+ Front Electronic Module Location Pin Description and Characteristic I CR1-09 PEDAL ADJUST SWITCH OUT SIGNAL: GROUND WHEN ACTIVATED I CR1-12 PEDAL ADJUST SWITCH IN SIGNAL: GROUND WHEN ACTIVATED MEMORY SWITCH PACK – DRIVER DT5 8-WAY / BLACK DRIVER DOOR TRIM PG CR1-26 POWER GROUND: GROUND PEDAL ADJUST MOTOR CR103 CR104 3-WAY / BLACK 2-WAY / BLACK DRIVER PEDAL ASSEMBLY S CR9-01 SCP – STEERING COLUMN MOVEMENT ASSEMBLY IP10 10-WAY / BLACK UPPER STEERING COLUMN S CR9-07 SCP + I CR9-11 PEDAL ADJUST MOTOR POSITION SENSOR SIGNAL: VARIABLE VOLTAGE 0 – 5 V O CR10-02 PEDAL ADJUST MOTOR DRIVE – OUT: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ HARNESS IN-LINE CONNECTORS Connector Connector Description DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST POWER GROUND: GROUND DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST POWER GROUND: GROUND DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM DT6 16-WAY / BLUE / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM IP2 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE O CR10-09 PEDAL ADJUST MOTOR DRIVE – IN: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ PG CR10-11 POWER GROUND: GROUND PG CR10-13 PG CR10-14 B+ CR85-01 SWITCHED SYSTEM POWER SUPPLY: B+ SG CR85-15 PEDAL ADJUST MOTOR POSITION SENSOR SIGNAL GROUND: GROUND SS CR85-17 PEDAL ADJUST MOTOR POSITION SENSOR SIGNAL SUPPLY VOLTAGE: NOMINAL 5 V GROUNDS Instrument Cluster Ground Location Pin Description and Characteristic G9 CABIN / UPPER LH A POST SG IP5-14 SIGNAL GROUND: GROUND G10 CABIN / RH A POST G31 CABIN / BEHIND PASSENGER AIR BAG B+ IP6-01 Location BATTERY POWER SUPPLY (COLUMN MOTOR): B+ PG IP6-02 POWER GROUND: GROUND B+ IP6-03 BATTERY POWER SUPPLY (LOGIC): B+ FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. S IP6-10 SCP – O IP6-11 STEERING COLUMN MOTOR DRIVE – DOWN / OUT: B+ WHEN ACTIVATED O IP6-12 STEERING COLUMN MOTOR DRIVE – UP / IN : B+ WHEN ACTIVATED O IP6-13 STEERING COLUMN IN / OUT FUNCTION SOLENOID DRIVE: B+ WHEN ACTIVATED O IP6-14 STEERING COLUMN UP / DOWN FUNCTION SOLENOID DRIVE: B+ WHEN ACTIVATED S IP6-20 SCP + I IP7-07 FUNCTION SELECT SIGNAL: VARIABLE RESISTANCE SG IP7-08 STEERING COLUMN POSITION FEEDBACK POTENTIOMETERS SIGNAL GROUND: GROUND I IP7-17 STEERING COLUMN MOVEMENT SWITCH SIGNAL: VARIABLE VOLTAGE SG IP7-18 STEERING COLUMN MOVEMENT / SELECT SIGNAL GROUND: GROUND O IP7-19 STEERING COLUMN POSITION FEEDBACK POTENTIOMETERS SUPPLY VOLTAGE: B+ I IP7-20 STEERING COLUMN UP / DOWN POSITION FEEDBACK POTENTIOMETER SIGNAL: VARIABLE VOLTAGE NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Steering Column Adjust; Pedal Adjust NW 79 B + N 76 WR DT6-11 BK DD1-7 BK DT1-9 SCP GO MEMORY FUNCTIONS IP10-3 I DD12-25 DRIVER DOOR AJAR SWITCH BK DT5-1 IP10-4 BK BK B DDS1 DD13-8 DD13-7 G9AR (G10AR) DRIVER MEMORY SWITCH PACK B P DDS3 DD1-7 G9AR (G10AR) 20.3 I DD7-1 DD10-2* DD7-2 DD10-3* MEMORY 1 BK DTS1 20.2 DD13-4 DD12-10 BK DDS3 S * NOTE: Double Locking vehicles. MEMORY 2 BK 20.3 O O DT1-10 MEMORY 3 BK U DD12-7 O DT5-4 MEMORY SET – DD13-12 WR DT5-3 MEMORY SET INDICATOR 20.2 DD13-3 B S Y S DD13-11 Steering Column Adjust; Pedal Adjust B STEERING COLUMN MOTOR DD3-8 G9AL (G10AL) DRIVER DOOR MODULE IP10-9 O 87 B IP6-3 88 + 20.2 20.3 20.2 20.3 B IP6-20 – OY Y S LOGIC U S IP10-10 IP6-10 B IP6-1 IP10-1 COLUMN MOTORS U O IP6-12 R O B B IPS2 IP6-11 IP10-2 RG O IP6-14 G13BL GB O STEERING COLUMN SOLENOIDS IP6-13 UY O GR IP27-5 820 Ω IP7-19 I IP7-7 IP10-6 GW I IP7-20 IP10-7 GO 330 Ω Y IP7-8 I IP27-1 1.5 ΚΩ IP7-17 IP10-5 GU I IP7-9 IP10-8 2.2 ΚΩ B BR IP27-3 IP7-18 B P B STEERING COLUMN POSITION SENSOR B STEERING COLUMN MOVEMENT ASSEMBLY IPS6 IP5-14 IPS2 IP6-2 G31BL INSTRUMENT CLUSTER NW 64 S B B IPS35 RW IP27-7 IP27-4 COLUMN ADJUST + ENTRY / EXIT PEDAL ADJUST IP2-9 IP27-2 + Y S 20.2 20.3 20.2 20.3 CR9-7 – RW U S CR9-1 I CR1-12 U G31AL COLUMN ADJUST B CR85-1 U IP2-3 WU I CR85-17 CR1-9 CR103-1 W O COLUMN AND PEDAL ADJUST SWITCHES CR10-2 CR104-1 R O B B B B CR1-26 CR10-14 CR10-11 P P CR10-9 P P CR10-13 G9BR CR104-2 O I CR9-11 CR103-2 U CR85-15 CR103-3 PEDAL ADJUST MOTOR G9BL FRONT ELECTRONIC MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 10.1 Fig. 10.2 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS O DD11-01 DRIVER DOOR MIRROR DRIVE – LEFT: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ Component Connector(s) Connector Description O DD11-02 DRIVER DOOR MIRROR DRIVE – RIGHT: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ O DD11-03 DRIVER DOOR MIRROR DRIVE – UP: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ DOOR MIRROR – DRIVER DD9 22-WAY BLACK DRIVER DOOR O DD11-04 DRIVER DOOR MIRROR DRIVE – DOWN: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ DOOR MIRROR – PASSENGER PD9 22-WAY BLACK PASSENGER DOOR SS DD11-05 DRIVER DOOR MIRROR POSITION SENSORS SIGNAL SUPPLY VOLTAGE: B+ DRIVER DOOR MODULE DD11-14 DRIVER DOOR MIRROR LEFT / RIGHT POSITION FEEDBACK SIGNAL : VARIABLE VOLTAGE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM I I DD11-15 DRIVER DOOR MIRROR UP / DOWN POSITION FEEDBACK SIGNAL : VARIABLE VOLTAGE SG DD11-19 DRIVER DOOR MIRROR POSITION SENSORS SIGNAL GROUND: GROUND I DD12-02 RH MIRROR MOVEMENT SELECT SIGNAL: GROUND WHEN SELECTED I DD12-03 LH MIRROR MOVEMENT SELECT SIGNAL: GROUND WHEN SELECTED O DD12-07 MEMORY SET INDICATOR ACTIVATE: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ I DD12-08 MIRROR FOLD FLAT SWITCH SIGNAL: GROUND WHEN SELECTED I DD12-10 MEMORY 1, 2, 3, SET INPUT SIGNAL: VARIABLE RESISTANCE I DD12-14 MIRROR UP SWITCH SIGNAL: GROUND WHEN SELECTED I DD12-15 MIRROR DOWN SWITCH SIGNAL: GROUND WHEN SELECTED I DD12-16 MIRROR LEFT SWITCH SIGNAL: GROUND WHEN SELECTED I DD12-17 MIRROR RIGHT SWITCH SIGNAL: GROUND WHEN SELECTED S DD13-03 SCP NETWORK + S DD13-04 SCP NETWORK – O DD13-05 DRIVER DOOR MIRROR FOLD FLAT: IN-TO-OUT: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ O DD13-06 DRIVER DOOR MIRROR FOLD FLAT: OUT-TO-IN: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ SG DD13-07 LOGIC GROUND: GROUND PG DD13-08 POWER GROUND: GROUND B+ DD13-11 BATTERY POWER SUPPLY: LOGIC: B+ B+ DD13-12 SWITCHED SYSTEM POWER SUPPLY: B+ Location DOOR SWITCH PACK – DRIVER DT4 20-WAY / BLACK DRIVER DOOR TRIM ELECTROCHROMIC REAR VIEW MIRROR AND COMPASS RF7 8-WAY / BLACK FORWARD OF ROOF CONSOLE FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST MEMORY SWITCH PACK – DRIVER DT5 8-WAY / BLACK DRIVER DOOR TRIM REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR HARNESS IN-LINE CONNECTORS Connector Connector Description DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS Location CABIN / DRIVER SIDE ‘A’ POST DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM Front Electronic Module DT6 16-WAY / BLUE / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PD16 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST Pin Description and Characteristic I CR1-07 PASSENGER DOOR MIRROR LEFT / RIGHT POSITION FEEDBACK SIGNAL : VARIABLE VOLTAGE SS CR1-08 PASSENGER DOOR MIRROR POSITION SENSORS SIGNAL SUPPLY VOLTAGE: B+ I CR1-11 PASSENGER DOOR MIRROR UP / DOWN POSITION FEEDBACK SIGNAL : VARIABLE VOLTAGE O CR1-20 PASSENGER DOOR MIRROR DRIVE – UP: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ O CR1-21 PASSENGER DOOR MIRROR DRIVE – DOWN: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ GROUNDS SG CR1-22 PASSENGER DOOR MIRROR POSITION SENSORS SIGNAL GROUND: GROUND O CR1-23 PASSENGER DOOR MIRROR DRIVE – LEFT: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ Ground Location O CR1-24 PASSENGER DOOR MIRROR DRIVE – RIGHT: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ G9 CABIN / UPPER LH A POST PG CR1-26 POWER GROUND: GROUND G10 CABIN / RH A POST G17 CABIN / BELOW REAR SEAT / RH SIDE G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE S CR9-01 SCP – S CR9-07 SCP + PG CR10-11 POWER GROUND: GROUND PG CR10-13 POWER GROUND: GROUND PG CR10-14 POWER GROUND: GROUND B+ CR85-01 SWITCHED SYSTEM POWER SUPPLY: B+ FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. Rear Electronic Module Pin Description and Characteristic B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ SG CR11-12 LOGIC GROUND: GROUND O CR11-18 REVERSE GEAR SIGNAL (DIM REQUEST): TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ S CR13-01 SCP + S CR13-02 SCP – NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Door Mirrors; Electrochromic Rear View Mirrors NW 79 B DD13-11 N 76 DD13-12 20.2 20.3 20.3 20.2 Y U S – 20.2 20.3 20.3 20.2 U WR WR DT5-3 DT6-11 S S – CR9-1 DD13-4 MEMORY SET INDICATOR 64 CR85-1 S + CR9-7 DD13-3 B S NW B Y S + O * NOTE: Fold-flat Mirror vehicles only. DD12-7 * NOTE: Fold-flat Mirror vehicles only. DRIVER DOOR MIRROR O DT5-4 MEMORY SET O DT1-10 Fig. 10.2 Door Mirrors; Electrochromic Rear View Mirrors PASSENGER DOOR MIRROR I DD12-10 FOLD-FLAT* FOLD-FLAT* ELECTROCHROMIC MIRROR ELECTROCHROMIC MIRROR MEMORY 3 MEMORY 2 MEMORY 1 BK DT5-1 DD9 -4 DRIVER MEMORY SWITCH PACK DD9 -2 DD9 -3 DD9 -1 DD9 -7 DD9 -6 DD9 -8 DD9 -5 DD9 -16 DD9 -15 O O GU DT4-17 GU DT1-1 DT4-16 O I I DT1-2 R YR O DD11-15 YR YR DT1-5 I DD12-14 OY DD11-14 DT4-8 BK BK DDS3 BK DT1-9 OG DD12-17 Y DT4-6 DT4-20 DT1-6 DT4-7 DT4-10 FOLD-FLAT* CR1-23 I DD11-19 OY PD16-14 U U CR1-22 PD16-18 DD12-16 YB G9AR (G10AR) OG PD1-8 OY O U OY DT1-3 BK DD11-1 DD12-15 OY DD1-7 OY I YB P P P P I DT1-8 DD12-8 DRIVER DOOR SWITCH PACK CR1-26 CR10-14 CR10-11 B B B B CR10-13 G9BL * NOTE: Fold-flat Mirror vehicles only. G9BR FRONT ELECTRONIC MODULE BK BK B BK DDS3 DD1-7 B R DD13-5 B DDS1 DD3-8 R O DD13-7 DDS8 R DD3-2 YR YR O P DDS7 DD13-6 DD13-8 YR DD3-6 DRIVER DOOR MODULE NW 78 36 B WU II CR4-3 B RF7-1 YG O YG RF7-4 20.3 20.2 20.3 20.2 Y B S + CR13-1 REVERSE GEAR B RF7-5 U S – CRS46 RF1-7 O CR13-2 OG CR11-18 OG RF2-4 RF7-2 CRS45 RF1-8 I REVERSE B B P CR11-12 RF7-3 B RFS1 B RF2-1 G24AR NOTE: Door Mirror Heaters – refer to Fig. 06.2. G17BR REAR ELECTRONIC MODULE ELECTROCHROMIC REAR VIEW MIRROR AND COMPASS ** ** NOTE: Includes Compass, when fitted. 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data R PD1-14 G9AL (G10AL) G9AR (G10AR) PD9 -14 YG OY CR1-24 O Y PD9 -15 PD16 -4 PD16-20 OG O DD11-2 I DT1-4 BK DTS1 O PD9 -16 YG PD16-19 CR1-7 O O PD9 -5 WU OY I PD9 -8 PD16-21 CR1-8 I PD9 -6 O WU DD11-5 PD9 -7 PD16-16 O CR1-11 B PD9 -1 PD9 -11 B OG OG I PD9 -3 PD1-10 CR1-20 DD1 -13 YG WU DT4-5 DD1 -10 PD9 -2 O CR1-21 O DD11-3 DD12-2 O O B OG DD12-3 GW GW RH I PD9 -4 DD9 -11 YG DD11-4 LH DD9 -14 VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 YR PD1-12 PD16 -5 B Fig. 11.1 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS O DD12-07 MEMORY SET INDICATOR ACTIVATE: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ Component Connector(s) Connector Description Location I DD12-10 MEMORY 1, 2, 3, SET INPUT SIGNAL: VARIABLE RESISTANCE DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM DRIVER SEAT MODULE SD2 SD3 SD4 SD24 SD26 SD27 22-WAY / BLACK 6-WAY / BLACK 26-WAY / BLACK 4-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK DRIVER SEAT UNDERSIDE MEMORY SWITCH PACK – DRIVER DT5 8-WAY / BLACK DRIVER DOOR TRIM SEAT CUSHION FRONT RAISE / LOWER MOTOR AND POSITION SENSOR – DRIVER SD6 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT CUSHION REAR RAISE / LOWER MOTOR AND POSITION SENSOR – DRIVER SD12 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT FORE / AFT MOTOR AND POSITION SENSOR – DRIVER SD8 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT HEADREST MOTOR AND POSITION SENSOR – DRIVER SD9 5-WAY / BLACK DRIVER SEAT BACK / UPPER S DD13-03 SCP NETWORK + S DD13-04 SCP NETWORK – O DD13-06 DRIVER DOOR MIRROR FOLD FLAT: OUT-TO-IN: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ B+ DD13-11 BATTERY POWER SUPPLY: LOGIC: B+ Driver Seat Module Pin Description and Characteristic S SD2-01 SCP+ I SD2-04 SEAT CUSHION FRONT RAISE REQUEST: ACTIVE = B+ I SD2-05 SEAT CUSHION FRONT LOWER REQUEST: ACTIVE = B+ I SD2-10 SEAT BACK RECLINE REARWARD REQUEST: ACTIVE = B+ I SD2-11 SEAT BACK RECLINE FORWARD REQUEST: ACTIVE = B+ S SD2-12 SCP – I SD2-15 HEAD REST RAISE REQUEST: ACTIVE = B+ I SD2-16 HEADREST LOWER REQUEST: ACTIVE = B+ I SD2-17 SEAT RAISE REQUEST: ACTIVE = B+ I SD2-18 SEAT LOWER REQUEST: ACTIVE = B+ SEAT INCLINE / RECLINE MOTOR AND POSITION SENSOR – DRIVER SD13 5-WAY / BLACK DRIVER SEAT BACK / LOWER I SD2-19 SEAT FORWARD REQUEST: ACTIVE = B+ SEAT LUMBAR PUMP – 12-WAY SEAT – DRIVER DL4 6-WAY / BLACK DRIVER SEAT BACK / LOWER I SD2-20 SEAT REARWARD REQUEST: ACTIVE = B+ SEAT SWITCH PACK – DRIVER SD5 SD29 12-WAY / BLACK 14-WAY / BLACK DRIVER SEAT / OUTBOARD O SD3-01 SEAT HEIGHT MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD3-02 SEAT HEIGHT MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ PG SD3-05 POWER GROUND: GROUND HARNESS IN-LINE CONNECTORS B+ SD3-06 BATTERY POWER SUPPLY: B+ Connector Connector Description I SD4-07 SEAT CUSHION FRONT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST I SD4-08 SEAT HEIGHT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST I SD4-09 HEADREST POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL DL2 6-WAY / BLACK / DRIVER SEAT HARNESS TO DRIVER SEAT LUMBAR HARNESS CABIN / BEHIND DRIVER SEAT BACK I SD4-10 SEAT BACK RECLINE POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM SG SD4-11 SIGNAL GROUND: GROUND DT6 16-WAY / BLUE / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM B+ SD4-13 BATTERY POWER SUPPLY – LOGIC: B+ SD1 4-WAY / GREY / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT I SD4-22 SEAT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL SG SD4-25 SIGNAL GROUND: GROUND SG SD4-26 LOGIC GROUND: GROUND O SD24-01 SEAT POSITION MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD24-02 SEAT POSITION MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ Location GROUNDS Ground Location G9 CABIN / UPPER LH A POST O SD26-03 SEAT BACK RECLINE MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ G10 CABIN / RH A POST O SD26-04 SEAT BACK RECLINE MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT PG SD27-01 POWER GROUND: GROUND B+ SD27-02 BATTERY POWER SUPPLY: B+ O SD27-03 HEADREST POSITION MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD27-04 HEADREST POSITION MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD27-05 SEAT CUSHION FRONT MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD27-06 SEAT CUSHION FRONT MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Driver Seat: 12-Way Movement with Memory Fig. 11.1 Driver Seat: 12-Way Movement with Memory DRIVER SEAT MOTORS AND POSITION SENSORS NW 79 B DD13-11 + Y S 20.2 20.3 20.2 20.3 DD13-3 WR WR DT5-3 MEMORY SET INDICATOR DT6-11 O – DT1-10 U S MEMORY POSITIONS DD13-4 DD12-7 H O DT5-4 MEMORY SET O H H H B P DD13-8 MEMORY 3 B DDS1 B SD6 -5 SD6 -1 SD6 -4 SD6 -2 SD12 -1 SD12 -2 SD12 -4 SD12 -3 SD13 -2 SD13 -1 SD13 -4 SD13 -3 RG GR O WB GO OG U WB GU U R WB DD3-8 G9AL (G10AL) DRIVER DOOR MODULE MEMORY 2 BK BK BK DDS3 DD1-7 BK DT1-9 MEMORY 1 BK DTS1 DT5-1 RHD LHD 35 89 NR DRIVER MEMORY SWITCH PACK 45 NG 74 SD8 SD8 -1 -2 (LHD) (LHD) SD8 SD8 -2 -1 (RHD) (RHD) YU UY SD8 -4 SD8 -3 SD9 -4 SD9 -1 SD9 -3 SD9 -2 WU WB GW GO WU WB B SD3-6 G9AR (G10AR) H I DD12-10 + Y S 20.2 20.3 20.2 20.3 SDS2 SDS1 SD2-1 B SD27-2 – U S SD2-12 NG 81 S NG B SDS3 SD4-13 RG O SD27-5 NG GR O U SD5-12 SD5-5 SD27-6 I SD2-4 O I SD4-7 NG GO O UY SD29-8 SD5-11 SD3-1 I SD2-5 OG O NG SD3-2 Y SD5-7 SD5-4 I U I SD2-17 SD4-8 WB SD4-11 YB SD5-10 I GU O SD2-18 SD26-4 U O GB SD5-3 SD26-3 I SD2-11 R I BK SD4-10 SD5-1 YU O RW SD5-9 SD24-1 I SD2-10 UY O SD24-2 N SD5-2 I WU I SD2-19 SD4-22 WB BK SD5-6 SD4-25 YR SD5-8 I GW O SD2-20 SD27-3 GO O RU SD29-5 SD27-4 I SD2-15 WU I SD4-9 WG SD29-12 I BK SD2-16 B P SD3-5 SD27-1 DRIVER SEAT MODULE BK B SDS4 B SD1-4 B SD1-3 G12AL (G13AL) G12AR (G13AR) BK SDS5 SD28-1 BK SD28-1 B P BK BK SDS5 SD4-26 U SD29-1 G12AR (G13AR) U SD29-9 DL2-3 DL4-2 N DL2-1 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E BK SDS5 BK SD28-1 DL4-1 DRIVER SEAT SWITCH PACK 6 B DL2-6 G12AR (G13AR) N SD29-4 1 B DL4-3 DRIVER LUMBAR PUMP I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: 12-Way Seat Memory Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.2 CONTROL MODULE PIN-OUT INFORMATION Driver Seat Module Pin Description and Characteristic COMPONENTS S SD2-01 SCP+ Component Connector(s) Connector Description Location I SD2-04 SEAT CUSHION FRONT RAISE REQUEST: ACTIVE = B+ I SD2-05 SEAT CUSHION FRONT LOWER REQUEST: ACTIVE = B+ DRIVER SEAT MODULE SD2-10 SEAT BACK RECLINE REARWARD REQUEST: ACTIVE = B+ SEAT BACK RECLINE FORWARD REQUEST: ACTIVE = B+ 22-WAY / BLACK 6-WAY / BLACK 26-WAY / BLACK 4-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK DRIVER SEAT UNDERSIDE I SD2 SD3 SD4 SD24 SD26 SD27 SEAT CUSHION EXTEND MOTOR AND POSITION SENSOR – DRIVER SD7 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT CUSHION FRONT RAISE / LOWER MOTOR AND POSITION SENSOR – DRIVER SD6 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT CUSHION REAR RAISE / LOWER MOTOR AND POSITION SENSOR – DRIVER I SD2-11 S SD2-12 SCP – I SD2-15 HEAD REST RAISE REQUEST: ACTIVE = B+ I SD2-16 HEADREST LOWER REQUEST: ACTIVE = B+ I SD2-17 SEAT RAISE REQUEST: ACTIVE = B+ I SD2-18 SEAT LOWER REQUEST: ACTIVE = B+ I SD2-19 SEAT FORWARD REQUEST: ACTIVE = B+ I SD2-20 SEAT REARWARD REQUEST: ACTIVE = B+ I SD2-21 SEAT CUSHION EXTEND REARWARD REQUEST: ACTIVE = B+ SD12 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER I SD2-22 SEAT CUSHION EXTEND FORWARD REQUEST: ACTIVE = B+ SEAT FORE / AFT MOTOR AND POSITION SENSOR – DRIVER SD8 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER O SD3-01 SEAT HEIGHT MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ SEAT HEADREST MOTOR AND POSITION SENSOR – DRIVER SD9 5-WAY / BLACK DRIVER SEAT BACK / UPPER SEAT INCLINE / RECLINE MOTOR AND POSITION SENSOR – DRIVER SD13 5-WAY / BLACK DRIVER SEAT BACK / LOWER SEAT LUMBAR PUMP – 16-WAY SEAT – DRIVER DL3 2-WAY / BLACK DRIVER SEAT BACK / LOWER SEAT LUMBAR SOLENOIDS – DRIVER DL1 6-WAY / BLACK DRIVER SEAT BACK / UPPER SEAT SWITCH PACK – DRIVER SD5 SD29 12-WAY / BLACK 14-WAY / BLACK DRIVER SEAT / OUTBOARD O SD3-02 SEAT HEIGHT MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ PG SD3-05 POWER GROUND: GROUND B+ SD3-06 BATTERY POWER SUPPLY: B+ I SD4-07 SEAT CUSHION FRONT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL I SD4-08 SEAT HEIGHT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL I SD4-09 HEADREST POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL I SD4-10 SEAT BACK RECLINE POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL SG SD4-11 SIGNAL GROUND: GROUND SG SD4-12 SIGNAL GROUND: GROUND B+ SD4-13 BATTERY POWER SUPPLY – LOGIC: B+ I SD4-22 SEAT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL Connector Connector Description I SD4-23 SEAT CUSHION EXTEND POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL DL2 6-WAY / BLACK / DRIVER SEAT HARNESS TO DRIVER SEAT LUMBAR HARNESS CABIN / BEHIND DRIVER SEAT BACK SG SD4-25 SIGNAL GROUND: GROUND SD1 4-WAY / GREY / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SG SD4-26 LOGIC GROUND: GROUND SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT O SD24-01 SEAT POSITION MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD24-02 SEAT POSITION MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ GROUNDS O SD24-03 SEAT CUSHION EXTEND MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ Ground Location O SD24-04 SEAT CUSHION EXTEND MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ G12 CABIN / BELOW DRIVER SEAT O SD26-03 SEAT BACK RECLINE MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ G13 CABIN / BELOW PASSENGER SEAT O SD26-04 SEAT BACK RECLINE MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ HARNESS IN-LINE CONNECTORS Location FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. PG SD27-01 POWER GROUND: GROUND B+ SD27-02 BATTERY POWER SUPPLY: B+ O SD27-03 HEADREST POSITION MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD27-04 HEADREST POSITION MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD27-05 SEAT CUSHION FRONT MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O SD27-06 SEAT CUSHION FRONT MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Driver Seat: 16-Way Movement with Memory RHD LHD 35 89 NR DRIVER LUMBAR SOLENOIDS DRIVER SEAT MOTORS AND POSITION SENSORS B Fig. 11.2 Driver Seat: 16-Way Movement with Memory SD3-6 45 NG 74 B SD27-2 20.3 20.2 Y S + H SD2-1 MEMORY POSITIONS 11.1 20.3 20.2 U H H H H H S – SD2-12 81 NG S NG SD6 -5 SD6 -1 RG GR SD6 -4 SD6 -2 SD12 -1 SD12 -2 SD12 -4 SD12 -3 SD13 -2 SD13 -1 SD13 -4 SD13 -3 O WB GO OG U WB GU U R WB B SDS3 SD4-13 SD8 SD8 -1 -2 (LHD) (LHD) SD8 SD8 -2 -1 (RHD) (RHD) SD8 -4 SD8 -3 SD9 -4 SD9 -1 SD9 -3 SD9 -2 SD7 -1 SD7 -5 SD7 -4 SD7 -2 WU WB GW GO WU WB YR RU WR WB NG U SD5-12 SD5-5 I RG O SD2-4 YU UY SD27-5 GR O SD27-6 UY SD5-11 I O I SD2-5 SDS2 SD4-7 SD3-1 Y SD5-7 SD5-4 I DL1 -5 DL1 -3 G Y R U OG O SD2-17 DL1 -2 GO O NG DL1 -4 SDS1 SD3-2 U I SD4-8 YB SD5-10 WB I SD2-18 SD4-11 GU O SD26-4 GB NG SD5-3 SD29-8 I U O SD2-11 SD26-3 BK R I SD5-1 SD4-10 RW SD5-9 I YU O SD2-10 SD24-1 UY O SD24-2 N SD5-2 I WU I SD2-19 SD4-22 WB SD4-25 YR SD5-8 I GW O SD2-20 SD27-3 GO O SD27-4 RU SD29-5 I WU I SD2-15 SD4-9 YR O SD24-4 WG SD29-12 I RU O SD2-16 SD24-3 WR I SD4-23 WR SD29-14 WB I SD2-22 SD4-12 BK SD5-6 O SD29-7 I SD2-21 P P SD4-26 SD3-5 BK B SDS5 B SDS4 SD27-1 BK SD28-1 SD1-4 BK B B SD1-3 G12AL (G13AL) DRIVER SEAT MODULE G12AR (G13AR) G G SD29-10 DL2-5 Y Y SD29-2 DL2-2 R BK BK SD28-1 BK SDS5 R SD29-3 DL2-4 U SD29-1 U SD29-9 G12AR (G13AR) DL2-3 N DL2-1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 DRIVER LUMBAR PUMP I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S DL3-2 DL3-1 DRIVER SEAT SWITCH PACK 1 B N SD29-4 II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data B DL2-6 BK SDS5 BK SD28-1 G12AR (G13AR) VARIANT: 16-Way Seat Memory Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.3 COMPONENTS Component Connector(s) Connector Description Location SEAT CUSHION FRONT RAISE / LOWER MOTOR – DRIVER SD6 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT CUSHION REAR RAISE / LOWER MOTOR – DRIVER SD12 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT FORE / AFT MOTOR – DRIVER SD8 5-WAY / BLACK DRIVER SEAT CUSHION / UNDER SEAT HEADREST MOTOR – DRIVER SD9 5-WAY / BLACK DRIVER SEAT BACK / UPPER SEAT INCLINE / RECLINE MOTOR – DRIVER SD13 5-WAY / BLACK DRIVER SEAT BACK / LOWER SEAT LUMBAR PUMP – 12-WAY SEAT – DRIVER DL4 6-WAY / BLACK DRIVER SEAT BACK / LOWER SEAT SWITCH PACK – DRIVER SD5 SD29 12-WAY / BLACK 14-WAY / BLACK DRIVER SEAT / OUTBOARD HARNESS IN-LINE CONNECTORS Connector Connector Description DL2 6-WAY / BLACK / DRIVER SEAT HARNESS TO DRIVER SEAT LUMBAR HARNESS Location CABIN / BEHIND DRIVER SEAT BACK SD1 4-WAY / GREY / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT GROUNDS Ground Location G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Driver Seat: Non Memory Driver Seat: Non Memory DRIVER SEAT MOTORS RHD LHD 35 89 SD6 -5 SD6 -1 SD12 -1 SD12 -2 U UY Y YB SD13 -2 SD13 -1 SD8 SD8 -1 -2 (LHD) (LHD) SD8 SD8 -2 -1 (RHD) (RHD) GB RW N SD9 -4 YR SD9 -1 RU WG NR U SD5-12 SD5-5 85 NW 73 UY SD18-8 SD5-11 45 NG 74 Y SD5-7 SD5-4 YB SD5-10 GB SD5-3 B B SD1-4 SD5-1 RW SD5-9 N SD5-2 B B SD1-3 SD5-6 YR SD5-8 G12AL (G13AL) RU SD18-5 WG SD18-12 BK BK SD28-1 BK SDS5 U SD18-1 G12AR (G13AR) U SD18-9 DL2-3 B DL4-3 DL4-2 N 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E BK SD28-1 DL4-1 DL2-1 DRIVER LUMBAR PUMP DRIVER SEAT SWITCH PACK 1 BK SDS5 G12AR (G13AR) N SD18-4 B DL2-6 I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Non Memory Seat Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.3 Fig. 11.4 COMPONENTS Component Connector(s) Connector Description Location SEAT CUSHION FRONT RAISE / LOWER MOTOR – PASSENGER SP6 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT CUSHION REAR RAISE / LOWER MOTOR – PASSENGER SP12 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT FORE / AFT MOTOR – PASSENGER SP8 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT HEADREST MOTOR – PASSENGER SP9 5-WAY / BLACK PASSENGER SEAT BACK / UPPER SEAT INCLINE / RECLINE MOTOR – PASSENGER SP13 5-WAY / BLACK PASSENGER SEAT BACK / LOWER SEAT LUMBAR PUMP – 12-WAY SEAT – PASSENGER PL4 6-WAY / BLACK PASSENGER SEAT BACK / LOWER SEAT SWITCH PACK – PASSENGER SP5 SP24 12-WAY / BLACK 14-WAY / BLACK PASSENGER SEAT / OUTBOARD HARNESS IN-LINE CONNECTORS Connector Connector Description Location PL2 6-WAY / BLACK / PASSENGER SEAT HARNESS TO PASSENGER SEAT LUMBAR HARNESS CABIN / BEHIND PASSENGER SEAT BACK SP1 4-WAY / GREY / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT GROUNDS Ground Location G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Passenger Seat: 12-Way Movement Passenger Seat: 12-Way Movement PASSENGER SEAT MOTORS RHD LHD 74 45 SP6 -5 SP6 -1 SP12 -1 SP12 -2 U UY Y YB SP13 -2 SP13 -1 SP8 SP8 -2 -1 (LHD) (LHD) SP8 SP8 -1 -2 (RHD) (RHD) GB RW N SP9 -4 YR SP9 -1 RU WG NG U SP5-12 SP5-5 73 NW 85 UY SP24-8 SP5-11 90 NR 36 Y SP5-7 SP5-4 YB SP5-10 GB SP5-3 B B SP1-4 SP5-1 RW SP5-9 N SP5-2 B B SP1-3 SP5-6 YR SP5-8 G13AL (G12AL) RU SP24-5 WG SP24-12 BK BK SP28-12 BK SPS4 U SP24-1 G13AR (G12AR) U SP24-9 PL2-3 PL4-2 N PL2-1 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E BK SPS4 BK SP28-12 PL4-1 PASSENGER SEAT SWITCH PACK 6 BK PL2-6 G13AR (G12AR) N SP24-4 1 B PL4-3 PASSENGER LUMBAR PUMP I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: 12-Way Passenger Seat Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.4 Fig. 11.5 COMPONENTS Component Connector(s) Connector Description SEAT CUSHION EXTEND MOTOR – PASSENGER SP26 5-WAY / BLACK Location PASSENGER SEAT CUSHION / UNDER SEAT CUSHION FRONT RAISE / LOWER MOTOR – PASSENGER SP6 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT CUSHION REAR RAISE / LOWER MOTOR – PASSENGER SP12 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT FORE / AFT MOTOR – PASSENGER SP8 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT HEADREST MOTOR – PASSENGER SP9 5-WAY / BLACK PASSENGER SEAT BACK / UPPER SEAT INCLINE / RECLINE MOTOR – PASSENGER SP13 5-WAY / BLACK PASSENGER SEAT BACK / LOWER SEAT LUMBAR PUMP – 16-WAY SEAT – PASSENGER PL3 2-WAY / BLACK PASSENGER SEAT BACK / LOWER SEAT LUMBAR SOLENOIDS – PASSENGER PL1 6-WAY / BLACK PASSENGER SEAT BACK / UPPER SEAT SWITCH PACK – PASSENGER SP5 SP24 12-WAY / BLACK 14-WAY / BLACK PASSENGER SEAT / OUTBOARD HARNESS IN-LINE CONNECTORS Connector Connector Description Location PL2 6-WAY / BLACK / PASSENGER SEAT HARNESS TO PASSENGER SEAT LUMBAR HARNESS CABIN / BEHIND PASSENGER SEAT BACK SP1 4-WAY / GREY / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT GROUNDS Ground Location G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Passenger Seat: 16-Way Movement PASSENGER SEAT MOTORS RHD LHD 74 45 NG U SP5-12 SP6 -5 SP6 -1 SP12 -1 SP12 -2 U UY Y YB SP13 -2 SP13 -1 PASSENGER LUMBAR SOLENOIDS SP8 SP8 -2 -1 (LHD) (LHD) SP8 SP8 -1 -2 (RHD) (RHD) GB RW N Fig. 11.5 Passenger Seat: 16-Way Movement SP9 -4 YR SP9 -1 SP26 -1 SP26 -5 RU WG WR O SP5-5 UY SP5-11 RHD LHD 90 36 PL1 -4 PL1 -2 PL1 -5 PL1 -3 G Y R U NR Y SP5-7 SP5-4 YB SP5-10 RHD LHD 73 85 GB NW SP5-3 SP24-8 B B SP1-4 SP5-1 RW SP5-9 N SP5-2 YR SP5-8 RU SP24-5 WG SP24-12 WR SP24-14 B B SP1-3 SP5-6 O SP24-7 G13AL (G12AL) G G SP24-10 PL2-5 Y Y SP24-2 PL2-2 R BK SP28-12 BK BK SPS4 R SP24-3 PL2-4 U SP24-1 U SP24-9 G13AR (G12AR) PL2-3 N BK N SP24-4 PL2-1 PL3-2 PL3-1 BK PL2-6 BK SPS4 BK SP28-12 G13AR (G12AR) PASSENGER LUMBAR PUMP PASSENGER SEAT SWITCH PACK 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: 16-Way Passenger Seat Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.6 CONTROL MODULE PIN-OUT INFORMATION Rear Electronic Module Pin Description and Characteristic COMPONENTS PG CR11-11 POWER GROUND: GROUND Component Connector(s) Connector Description Location SG CR11-25 LOGIC GROUND: GROUND REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REAR OVERRIDE RELAY PACK SP31 SP32 8-WAY / BLACK 8-WAY / BLACK PASSENGER SEAT CUSHION / UNDER REAR SEAT SWITCH PACK – LH LS5 22-WAY / BLACK LH REAR SEAT CUSHION / OUTBOARD REAR SEAT SWITCH PACK – RH RS5 22-WAY / BLACK RH REAR SEAT CUSHION / OUTBOARD SEAT CUSHION EXTEND MOTOR – PASSENGER SP26 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT CUSHION FRONT RAISE / LOWER MOTOR – PASSENGER SP6 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT CUSHION REAR RAISE / LOWER MOTOR – PASSENGER SP12 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER SEAT FORE / AFT MOTOR – PASSENGER SP8 5-WAY / BLACK PASSENGER SEAT CUSHION / UNDER O CR12-02 REAR WINDOW ISOLATE: TO ISOLATE, REM INTERRUPTS GROUND SUPPLY NOTE: Refer to the Appendix at the rear of this book for Network Messages. SEAT HEADREST MOTOR – PASSENGER SP9 5-WAY / BLACK PASSENGER SEAT BACK / UPPER SEAT INCLINE / RECLINE MOTOR – PASSENGER SP13 5-WAY / BLACK PASSENGER SEAT BACK / LOWER SEAT LUMBAR PUMP – 16-WAY SEAT – PASSENGER PL3 2-WAY / BLACK PASSENGER SEAT BACK / LOWER SEAT LUMBAR SOLENOIDS – PASSENGER PL1 6-WAY / BLACK PASSENGER SEAT BACK / UPPER SEAT SWITCH PACK – PASSENGER SP5 SP24 12-WAY / BLACK 14-WAY / BLACK PASSENGER SEAT / OUTBOARD HARNESS IN-LINE CONNECTORS Connector Connector Description LS1 22-WAY / BLACK / CABIN HARNESS TO LH REAR SEAT HARNESS Location CABIN / BELOW LH REAR SEAT PL2 6-WAY / BLACK / PASSENGER SEAT HARNESS TO PASSENGER SEAT LUMBAR HARNESS CABIN / BEHIND PASSENGER SEAT BACK RS1 22-WAY / BLACK / CABIN HARNESS TO REAR SEAT HARNESS CABIN / BELOW REAR SEAT / RH SIDE SP1 4-WAY / GREY / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT GROUNDS Ground Location G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Passenger Seat: 16-Way Movement with Rear Override PASSENGER SEAT MOTORS RHD LHD 74 45 SP6 -5 SP6 -1 SP12 -1 SP12 -2 U UY Y YB NG U SP5-12 SP13 -2 SP13 -1 RU RG PASSENGER LUMBAR SOLENOIDS SP8 SP8 -2 -1 (LHD) (LHD) SP8 SP8 -1 -2 (RHD) (RHD) GB SP9 -4 SP32 -7 SP9 -1 SP26 -1 SP26 -5 RU WG WR O GO SP5-5 SP32 -6 Fig. 11.6 Passenger Seat: 16-Way Movement with Rear Override SP32 -9 REAR OVERRIDE RELAY PACK SP32 -10 UY 2 4 5 2 4 5 2 4 5 2 4 5 NR YB 85 PL1 -3 SP31 -5 G Y R U 37 91 SP32 -1 SP31 -1 SP32 -2 SP31 -2 SP32 -4 SP31 -3 SP32 -5 SP31 -4 SP5-3 SP24-8 BW B SP1-4 RHD RU NW B LHD SP32 -3 SP5-10 73 PL1 -5 Y SP5-4 LHD PL1 -2 NR SP5-7 RHD PL1 -4 1 3 1 3 36 1 90 3 LHD 1 RHD 3 SP5-11 BW LS1-20 (LHD) RSI-20 (RHD) SP5-1 RW RS5-17 (LHD) LS5-17 (RHD) SP5-9 BG BG LS1-14 (LHD) RS1-14 (RHD) G RS5-16 (LHD) LS5-16 (RHD) SP5-2 BR NG LS1-12 (LHD) RS1-12 (RHD) GW RS5-15 (LHD) LS5-15 (RHD) SP5-8 BO RHD 83 80 S RS5-18 (LHD) LS5-18 (RHD) BR LHD S BO LS1-2 (LHD) RS1-2 (RHD) RU RS5-14 (LHD) LS5-14 (RHD) SP24-5 REAR SEAT SWITCH PACK (LH / LHD; RH / RHD) WG SP24-12 WR SP24-14 B B SP1-3 SP5-6 O SP24-7 G13AL (G12AL) R R P CRS54 G G SP24-10 PL2-5 P Y Y SP24-2 BK SP28-12 BK SPS4 CR11-25 PL2-4 U N BK N PL2-1 PL3-2 PL3-1 BK PL2-6 BK SPS4 BK *NOTE: Rear Window Isolate – refer to Fig. 14.1. SP28-12 G13AR (G12AR) PASSENGER LUMBAR PUMP PASSENGER SEAT SWITCH PACK 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S B CRS75 PL2-3 SP24-4 1 B B REAR ELECTRONIC MODULE* U SP24-9 G13AR (G12AR) CR11-11 R SP24-3 SP24-1 P PL2-2 R BK CR12-2 Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Powered Rear Seats Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 G24BL Fig. 11.7 COMPONENTS Component Connector(s) Connector Description Location CENTER CONSOLE SWITCH PACK CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST SEAT BACK HEATER – DRIVER SD15 2-WAY / BLACK DRIVER SEAT BACK SEAT BACK HEATER – PASSENGER SP15 2-WAY / BLACK PASSENGER SEAT BACK SEAT CUSHION HEATERS – DRIVER SD14 4-WAY / BLACK DRIVER SEAT CUSHION SEAT CUSHION HEATERS – PASSENGER SP14 4-WAY / BLACK PASSENGER SEAT CUSHION HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE SD1 4-WAY / GREY / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL GROUNDS Ground Location G9 CABIN / UPPER LH A POST G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Front Seat Heaters NW 80 B RU 103 RU CR10-7 B S SD28-14 CR1-18 (LHD) CR1-19 (RHD) B S WB WB CR9-6 102 WG I CR10-8 WG SD28-13 CR1-16 (LHD) CR1-17 (RHD) SD14-3 CR10-16 (LHD) CR10-17 (RHD) SD28-2 SD14-4 SD14-1 INNER CUSHION SEAT HEATER SWITCHES RW LH II CL1-6 CL2-5 RW CL3-8 RW CC2-8 RW TL28-7 I B CR85-18 BK CCS3 BK CL3-3 WU RH CL1-5 CL1-4 WU CL3-2 WU CC2-9 WU TL28-8 MEMORY VEHICLES B B R SDS4 SD1-4 BK OUTER CUSHION DRIVER SEAT CUSHION HEATERS RH NG 35 SD14-2 TEMPERATURE SENSOR RU RU O LH Fig. 11.7 Front Seat Heaters SD15-2 SD15-1 G12AL (G13AL) I CR85-19 G15AR BK STATE BK SD28-1 CENTER CONSOLE SWITCH PACK BK DRIVER SEAT BACK HEATER NON-MEMORY VEHICLES SDS5 G12AR (G13AR) NOTE: CCS3 – Non Navigation vehicles only. WB WB SP28-14 CR1-19 (LHD) CR1-18 (RHD) WG I WG SP28-13 CR1-17 (LHD) CR1-16 (RHD) SP14-3 RU RU O SP14-2 TEMPERATURE SENSOR CR10-17 (LHD) CR10-16 (RHD) SP28-2 SP14-4 SP14-1 INNER CUSHION OUTER CUSHION PASSENGER SEAT CUSHION HEATERS B B B B CR1-26 CR10-14 CR10-11 P P P P BK CR10-13 G9BR 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E G9BL I Input B + O Output P Power Ground Battery Voltage SPS4 R SP15-2 SP15-1 G13AR (G12AR) FRONT ELECTRONIC MODULE + Sensor/Signal Supply V – Sensor/Signal Ground BK BK SP28-12 PASSENGER SEAT BACK HEATER A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Heated Front Seats Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.8 CONTROL MODULE PIN-OUT INFORMATION Rear Memory Module Pin Description and Characteristic COMPONENTS CR37-02 MEMORY 1, 2, 3, SET INPUT SIGNAL: VARIABLE RESISTANCE Component Connector(s) Connector Description Location O CR37-03 MEMORY SET INDICATOR ACTIVATE: TO ACTIVATE, RMM SWITCHES CIRCUIT TO B+ I CR37-09 SEAT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL REAR MEMORY MODULE CR37-10 SEAT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL 4-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK 6-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK REAR BULKHEAD / BEHIND REAR SEAT BACK I CR21 CR37 CR38 CR41 CR53 CR59 LH REAR SEAT BACK / UPPER I B+ CR37-13 SWITCHED SYSTEM POWER SUPPLY (LOGIC): B+ SG CR37-15 REAR SEAT MEMORY SWITCH PACK REFERENCE GROUND: GROUND SG CR37-24 SIGNAL GROUND: GROUND SG CR37-25 SIGNAL GROUND: GROUND REAR SEAT BACK INCLINE / RECLINE MOTOR AND POSITION SENSOR – LH SL1 5-WAY / BLACK S CR38-01 SCP + REAR SEAT BELT COMFORT SOLENOID – LH CR112 3-WAY / BLACK LH REAR SEAT BELT TENSIONER I CR38-10 SEAT BACK RECLINE REARWARD REQUEST: ACTIVE = B+ REAR SEAT BELT COMFORT SWITCH – LH CR109 2-WAY / BLACK LH REAR SEAT BELT BUCKLE SEAT BACK RECLINE FORWARD REQUEST: ACTIVE = B+ REAR SEAT HEADREST MOTOR AND POSITION SENSOR – LH SL2 5-WAY / BLACK LH REAR SEAT BACK / UPPER REAR SEAT LUMBAR PUMP – LH LL3 2-WAY / BLACK LH REAR SEAT BACK / UPPER REAR SEAT LUMBAR SOLENOIDS – LH LL1 5-WAY / BLACK LH REAR SEAT BACK / UPPER I CR38-11 S CR38-12 SCP – I CR38-15 HEAD REST RAISE REQUEST: ACTIVE = B+ I CR38-16 HEADREST LOWER REQUEST: ACTIVE = B+ O CR53-03 SEAT BACK RECLINE MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ REAR SEAT MEMORY SWITCH PACK – LH LT5 8-WAY / BLACK LH REAR DOOR TRIM O CR53-04 SEAT BACK RECLINE MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ REAR SEAT SWITCH PACK – LH LS5 22-WAY / BLACK LH REAR SEAT CUSHION / OUTBOARD B+ CR59-02 BATTERY POWER SUPPLY (LH SEAT): B+ O CR59-03 HEADREST POSITION MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ HARNESS IN-LINE CONNECTORS O CR59-04 HEADREST POSITION MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ NOTE: Refer to the Appendix at the rear of this book for Network Messages. Connector Connector Description Location LL2 6-WAY / BLACK / LH REAR SEAT HARNESS TO LH REAR SEAT LUMBAR HARNESS CABIN / BEHIND REAR SEAT BACK / LH SIDE LS1 22-WAY / BLACK / CABIN HARNESS TO LH REAR SEAT HARNESS CABIN / BELOW LH REAR SEAT LS11 6-WAY / GREY / CABIN HARNESS TO LH REAR SEAT MOTOR HARNESS CABIN / BELOW LH REAR SEAT LT1 12-WAY / GREY / LH REAR DOOR HARNESS TO LH REAR DOOR TRIM HARNESS CABIN / LH REAR DOOR TRIM RL9 16-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST SL4 20-WAY / BLACK / LH REAR SEAT HARNESS TO LH REAR SEAT MOTOR HARNESS CABIN / BELOW REAR SEAT / RH SIDE GROUNDS Ground Location G17 CABIN / BELOW REAR SEAT / RH SIDE G18 CABIN / BELOW REAR SEAT / LH SIDE FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Powered Rear Seats: LH Seat NG 39 Fig. 11.8 Powered Rear Seats: LH Seat LH REAR SEAT MOTORS AND POSITION SENSORS B LH REAR SEAT LUMBAR SOLENOIDS CR59-2 NG 86 B S 20.3 CR37-13 Y 20.2 H S + H CR38-1 20.3 U 20.2 S – CR38-12 WR WR LT5-3 MEMORY SET INDICATOR LT1-6 O LT1-10 O CR37-3 O LT5-4 MEMORY SET WR RL9-7 O RL9-12 RG LS11-5 LS11-3 LS1-19 GO WU WB LL1 -4 LL1 -2 LL1 -5 LL1 -3 G Y R U GW LS1-17 GO LS1-16 CR59-4 RU LS1-5 I SL4-5 GO NG SL4-8 WU I CR38-15 WU LS1-21 CR37-9 SL4-6 WB WB LS1-15 CR37-25 WG LS1-6 GB GW SL4-4 GW O LS5-3 WB SL4-3 LS1-13 CR59-3 LS5-13 WR CR37-15 O WG RU BK RL9-14 LH REAR SEAT MEMORY SWITCH PACK LS5-6 RG WB CR37-24 MEMORY 1 RU SL2 -2 SL4-2 WB LS5-8 SL2 -3 WR CR37-10 S SL2 -1 RU WR I MEMORY 2 79 SL2 -4 SL4-1 RU CR53-3 BK SL1 -3 RG CR53-4 O LT1-7 SL1 -4 I MEMORY 3 BK SL1 -1 CR37-2 O LT5-1 SL1 -2 SL4-7 I CR38-16 GB LS1-3 I CR38-11 BK RW LS5-10 RW LS1-4 CR37-26 I CR38-10 B P CR59-1 REAR MEMORY MODULE G LS5-11 G Y B CRS37 BK BK LSS3 LS1-18 LS5-4 LS5-9 R LS5-7 R LL2-4 U SL4-13 N G18AR Y LL2-2 SL4-14 U LS5-1 G Y SL4-15 R BK G18AR LL2-5 SL4-16 LS5-2 G18AL U LL2-3 N SL4-10 BK N LL2-1 LL3-2 LL3-1 BK LL2-6 BK BK LSS3 SL4-9 B LS1-18 BK CRS37 G18AR LH REAR SEAT LUMBAR PUMP LH REAR SEAT SWITCH PACK WU 31 U II CR109-1 B CR112-1 CR109-2 LH REAR SEAT BELT COMFORT SWITCH 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E E B CRS57 G17BR LH REAR SEAT BELT COMFORT SOLENOID Fig. 01.5 S CR112-2 I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Powered Rear Seats Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.9 CONTROL MODULE PIN-OUT INFORMATION Rear Memory Module Pin Description and Characteristic COMPONENTS O CR21-01 SEAT BACK RECLINE MOTOR DRIVE – REARWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ Component Connector(s) Connector Description Location O CR21-02 SEAT BACK RECLINE MOTOR DRIVE – FORWARD: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ O CR21-03 HEADREST POSITION MOTOR DRIVE – RAISE: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ REAR MEMORY MODULE CR21-04 HEADREST POSITION MOTOR DRIVE – LOWER: TO ACTIVATE, DSCM SWITCHES CIRCUIT TO B+ 4-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK 6-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK REAR BULKHEAD / BEHIND REAR SEAT BACK O CR21 CR37 CR38 CR41 CR53 CR59 RH REAR SEAT BACK / UPPER I CR37-01 MEMORY 1, 2, 3, SET INPUT SIGNAL: VARIABLE RESISTANCE SG CR37-11 SIGNAL GROUND: GROUND SG CR37-12 SIGNAL GROUND: GROUND B+ CR37-13 SWITCHED SYSTEM POWER SUPPLY (LOGIC): B+ REAR SEAT BACK INCLINE / RECLINE MOTOR AND POSITION SENSOR – RH SR1 5-WAY / BLACK SG CR37-14 REAR SEAT MEMORY SWITCH PACK REFERENCE GROUND: GROUND REAR SEAT BELT COMFORT SOLENOID – RH CR114 3-WAY / BLACK RH REAR SEAT BELT TENSIONER O CR37-16 MEMORY SET INDICATOR ACTIVATE: TO ACTIVATE, RMM SWITCHES CIRCUIT TO B+ REAR SEAT BELT COMFORT SWITCH – RH CR111 2-WAY / BLACK RH REAR SEAT BELT BUCKLE I CR37-22 SEAT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL I CR37-23 SEAT POSITION SENSOR SIGNAL: 5 V PULSED SIGNAL REAR SEAT HEADREST MOTOR AND POSITION SENSOR – RH SR2 5-WAY / BLACK RH REAR SEAT BACK / UPPER SG CR37-26 SIGNAL GROUND: GROUND REAR SEAT LUMBAR PUMP – RH YL3 2-WAY / BLACK RH REAR SEAT BACK / UPPER S CR38-01 SCP + REAR SEAT LUMBAR SOLENOIDS – RH YL1 5-WAY / BLACK RH REAR SEAT BACK / UPPER S CR38-12 SCP – REAR SEAT MEMORY SWITCH PACK – RH RT5 8-WAY / BLACK RH REAR DOOR TRIM I CR38-19 HEAD REST RAISE REQUEST: ACTIVE = B+ REAR SEAT SWITCH PACK – RH RS5 22-WAY / BLACK RH REAR SEAT CUSHION / OUTBOARD I CR38-20 HEADREST LOWER REQUEST: ACTIVE = B+ I CR38-21 SEAT BACK RECLINE REARWARD REQUEST: ACTIVE = B+ I CR38-22 SEAT BACK RECLINE FORWARD REQUEST: ACTIVE = B+ PG CR41-05 POWER GROUND (RH SEAT): GROUND B+ CR41-06 BATTERY POWER SUPPLY (RH SEAT): B+ HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Connector Connector Description Location RR9 16-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST RS1 22-WAY / BLACK / CABIN HARNESS TO REAR SEAT HARNESS CABIN / BELOW REAR SEAT / RH SIDE RS11 6-WAY / GREY / CABIN HARNESS TO REAR SEAT HARNESS CABIN / BELOW REAR SEAT / RH SIDE RT1 12-WAY / GREY / RH REAR DOOR HARNESS TO RH REAR DOOR TRIM HARNESS CABIN / RH REAR DOOR TRIM SR4 20-WAY / BLACK / RH REAR SEAT HARNESS TO RH REAR SEAT MOTOR HARNESS CABIN / BELOW REAR SEAT / LH SIDE YL2 6-WAY / BLACK / RH REAR SEAT HARNESS TO RH REAR SEAT LUMBAR HARNESS CABIN / BEHIND REAR SEAT BACK / RH SIDE GROUNDS Ground Location G17 CABIN / BELOW REAR SEAT / RH SIDE G18 CABIN / BELOW REAR SEAT / LH SIDE FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Powered Rear Seats: RH Seat NR 40 Fig. 11.9 Powered Rear Seats: RH Seat RH REAR SEAT MOTORS AND POSITION SENSORS B RH REAR SEAT LUMBAR SOLENOIDS CR41-6 NG 86 B S 20.3 CR37-13 Y 20.2 H S + H CR38-1 20.3 U 20.2 S – CR38-12 WR WR RT5-3 MEMORY SET INDICATOR RT1-6 O RT1-10 O CR37-16 O RT5-4 MEMORY SET WR RR9-7 O RR9-12 RG RS11-5 RS11-3 RS1-19 GO WU WB YL1 -4 YL1 -2 YL1 -5 YL1 -3 G Y R U GW RS1-17 GO RS1-16 CR21-4 RU RS1-5 I SR4-5 GO NG SR4-8 WR I CR38-19 WU RS1-21 CR37-23 SR4-6 W WB RS1-15 CR37-12 WG RS1-6 GB GW SR4-4 GW O RS5-3 WB SR4-3 RS1-13 CR21-3 RS5-13 WR CR37-14 O WG RU BK RR9-14 RH REAR SEAT MEMORY SWITCH PACK RS5-6 RG WB CR37-11 MEMORY 1 RU SR2 -2 WR WG RS5-8 SR2 -3 SR4-2 WU CR37-22 S SR2 -1 RU CR21-1 82 SR2 -4 SR4-1 RU I MEMORY 2 BK SR1 -3 RG CR21-2 O RT1-7 SR1 -4 I MEMORY 3 BK SR1 -1 CR37-1 O RT5-1 SR1 -2 SR4-7 I CR38-20 GB RS1-3 I CR38-22 BK RW RS5-10 RW RS1-4 CR37-26 I CR38-21 B P CR41-5 REAR MEMORY MODULE G RS5-11 G SR4-16 Y RS5-2 B CRS37 BK BK RSS3 RS1-18 RS5-4 R R YL2-4 U SR4-13 N RS5-7 Y YL2-2 SR4-14 RS5-9 G Y U RS5-1 G18AR G18AR YL2-5 SR4-15 R BK G18AL U YL2-3 N SR4-10 BK N YL2-1 YL3-2 YL3-1 BK YL2-6 BK BK RSS3 SR4-9 B RS1-18 BK CRS37 G18AR RH REAR SEAT LUMBAR PUMP RH REAR SEAT SWITCH PACK WU 32 U II CR111-1 B CR114-1 CR111-2 RH REAR SEAT BELT COMFORT SWITCH 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E E B CRS57 G17BR RH REAR SEAT BELT COMFORT SOLENOID Fig. 01.5 S CR114-2 I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Powered Rear Seats Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.10 COMPONENTS Component Connector(s) Connector Description REAR CENTER CONSOLE SWITCH PACK TL89 8-WAY / BLACK Location REAR CENTER CONSOLE REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REAR SEAT BACK HEATER – LH SL4 20-WAY / BLACK LH REAR SEAT BACK REAR SEAT BACK HEATER – RH SR4 20-WAY / BLACK RH REAR SEAT BACK REAR SEAT CUSHION HEATERS – LH LS4 4-WAY / BLACK LH REAR SEAT CUSHION REAR SEAT CUSHION HEATERS – RH RS4 4-WAY / BLACK RH REAR SEAT CUSHION HARNESS IN-LINE CONNECTORS Connector Connector Description LS1 22-WAY / BLACK / CABIN HARNESS TO LH REAR SEAT HARNESS Location CABIN / BELOW LH REAR SEAT LS11 6-WAY / GREY / CABIN HARNESS TO LH REAR SEAT MOTOR HARNESS CABIN / BELOW LH REAR SEAT RS11 6-WAY / GREY / CABIN HARNESS TO REAR SEAT HARNESS CABIN / BELOW REAR SEAT / RH SIDE SL4 20-WAY / BLACK / LH REAR SEAT HARNESS TO LH REAR SEAT MOTOR HARNESS CABIN / BELOW REAR SEAT / RH SIDE SR4 20-WAY / BLACK / RH REAR SEAT HARNESS TO RH REAR SEAT MOTOR HARNESS CABIN / BELOW REAR SEAT / LH SIDE TL35 22-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER GROUNDS Ground Location G17 CABIN / BELOW REAR SEAT / RH SIDE G18 CABIN / BELOW REAR SEAT / LH SIDE G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Rear Seat Heaters 78 NW B RU 100 RU CR4-9 B S WB WB CR4-3 99 Rear Seat Heaters LS1-17 CR71-7 B S WG I CR71-8 WG LS1-16 CR13-17 LS4-3 LS4-4 TEMPERATURE SENSOR RU RU O CR71-16 LS11-12 LS4-1 LS4-2 INNER CUSHION REAR SEAT HEATER SWITCHES LH II LH REAR SEAT CUSHION HEATERS RH NG 34 WG LH TL89-5 TL89-1 WG TL35-1 I BK CR4-10 BK TLS55 WU RH TL89-7 TL89-2 WU TL35-12 I B B CRS37 BK OUTER CUSHION B SL4-12 LS11-6 R SL3-2 SL3-1 R SL4-11 G18AR CR11-13 LH REAR SEAT BACK HEATER G18BL STATE REAR CENTER CONSOLE SWITCH PACK WB WB CR4-8 RS11-4 WR I CR13-16 WR RS4-3 RS11-2 RS4-4 TEMPERATURE SENSOR RU RU O CR71-17 RS11-1 RS4-1 RS4-2 INNER CUSHION OUTER CUSHION RH REAR SEAT CUSHION HEATERS B B P B CR11-11 RS11-6 B SR4-12 R SR3-2 SR3-1 R SR4-11 G17BL REAR ELECTRONIC MODULE G24BL 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage RH REAR SEAT BACK HEATER + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Heated Rear Seats Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 11.10 Fig. 12.1 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS O DD11-06 REMOTE KEYLESS ENTRY MODULE POWER SUPPLY: B+ Component Connector(s) Connector Description Location O DD11-08 LOCK DRIVE: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ O DD11-09 UNLOCK DRIVE: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ CENTER CONSOLE SWITCH PACK DD11-10 DOUBLE LOCK DRIVE: TO ACTIVATE, DDCM SWITCHES CIRCUIT TO B+ 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE O CL1 CL2 D DD11-13 REMOTE KEYLESS ENTRY MODULE SIGNAL: ENCODED COMMUNICATIONS DOOR AJAR SWITCH – DRIVER DD11-16 DRIVER DOOR ALARM SET / LOCK SWITCH (NORMALLY OPEN): OPEN CIRCUIT / GROUND DD7 DD10 2-WAY / BLACK 3-WAY / BLACK DRIVER DOOR I DOOR AJAR SWITCH – PASSENGER PD7 PD10 2-WAY / BLACK 3-WAY / BLACK PASSENGER DOOR 1 DD11-17 DRIVER DOOR ALARM RESET / UNLOCK SWITCH (NORMALLY OPEN): OPEN CIRCUIT / GROUND D DD11-18 REMOTE KEYLESS ENTRY MODULE SIGNAL: ENCODED COMMUNICATIONS I DD11-20 REMOTE KEYLESS ENTRY RETURN I DD12-25 DRIVER DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR DOOR LATCH – DRIVER DD2 8-WAY / BLACK DRIVER DOOR TRIM DOOR LATCH – PASSENGER PD2 8-WAY / BLACK PASSENGER DOOR TRIM DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM I DD13-02 DRIVER UNLOCK STATUS SWITCH SIGNAL: GROUND WHEN ACTIVATED S DD13-03 SCP NETWORK + EXTERNAL TRUNK RELEASE SWITCH BT5 2-WAY / WHITE TRUNK LID S DD13-04 SCP NETWORK – FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST SG DD13-07 LOGIC GROUND: GROUND PG DD13-08 POWER GROUND: GROUND I DD13-10 DRIVER LOCK STATUS SWITCH SIGNAL: GROUND WHEN ACTIVATED B+ DD13-11 BATTERY POWER SUPPLY: LOGIC: B+ B+ DD13-12 SWITCHED SYSTEM POWER SUPPLY: B+ Front Electronic Module I Pin Description and Characteristic CR1-01 PASSENGER DOOR AJAR SWITCH SIGNAL: GROUND WHEN ACTIVATED FUEL FILLER FLAP MOTOR CR15 2-WAY / BLACK TRUNK / RH SIDE REAR DOOR LOCK MOTOR – DRIVER RL2 RR2 8-WAY / BLACK 8-WAY / BLACK DRIVER REAR DOOR DRIVER REAR DOOR REAR DOOR LOCK MOTOR – PASSENGER RR2 RL2 8-WAY / BLACK 8-WAY / BLACK PASSENGER REAR DOOR PASSENGER REAR DOOR REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR S CR9-01 SCP – B+ CR9-06 BATTERY POWER SUPPLY: LOGIC: B+ S CR9-07 SCP + I CR9-08 GLOBAL OPEN / CLOSE SWITCH SIGNAL: GROUND WHEN ACTIVATED REMOTE KEYLESS ENTRY MODULE IP60 4-WAY / BLACK BEHIND INSTRUMENT PANEL / DRIVER SIDE SG CR9-12 LOGIC GROUND: GROUND TRUNK LATCH BT2 8-WAY / BLACK TRUNK LID B+ CR85-01 SWITCHED SYSTEM POWER SUPPLY: B+ I CR85-06 VALET SWITCH SIGNAL: GROUND WHEN ACTIVATED I EC36-05 FUEL FLAP RELEASE SWITCH SIGNAL: GROUND WHEN ACTIVATED I EC36-08 TRUNK RELEASE SWITCH SIGNAL: GROUND WHEN ACTIVATED HARNESS IN-LINE CONNECTORS Rear Electronic Module Connector Connector Description Location BL11 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS TRUNK / BEHIND TRUNK LID LINER BT11 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS TRUNK / TRUNK LID CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CABIN / BELOW CENTER CONSOLE / LH SIDE CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS Pin Description and Characteristic DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST O CR4-01 UNLOCK MOTOR DRIVE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST O IP3 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP17 16-WAY / GREEN / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE CR4-02 LOCK MOTOR DRIVE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ I CR4-07 TRUNK CLOSE SWITCH SIGNAL: GROUND (SIGNAL) WHEN TRUNK IS AJAR O CR4-11 DOUBLE LOCK MOTOR DRIVE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ O CR4-12 DOUBLE LOCK MOTOR DRIVE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ PD16 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST O CR11-03 FUEL FILLER FLAP MOTOR ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ RL9 16-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST O CR11-04 TRUNK RELEASE MOTOR ACTIVATE: OPEN / CLOSE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ RR9 16-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST O CR11-05 TRUNK RELEASE MOTOR ACTIVATE: CLOSE / OPEN: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL O CR11-06 LOCK MOTOR DRIVE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ O CR11-07 UNLOCK MOTOR DRIVE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ I CR11-08 TRUNK RELEASE MOTOR OPEN STATUS SIGNAL: GROUND (SIGNAL) WHEN ACTIVATED GROUNDS SG CR11-10 TRUNK LATCH SIGNAL GROUND: GROUND Ground Location PG CR11-11 POWER GROUND: GROUND G9 CABIN / UPPER LH A POST G10 CABIN / RH A POST SG CR11-12 LOGIC GROUND: GROUND I CR11-21 PASSENGER DOOR LATCH LOCK STATUS SWITCH SIGNAL: GROUND WHEN ACTIVATED I CR11-22 PASSENGER DOOR LATCH UNLOCK STATUS SWITCH SIGNAL: GROUND WHEN ACTIVATED G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL SG CR11-25 LOGIC GROUND: GROUND G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE G31 CABIN / BEHIND PASSENGER AIR BAG I CR12-09 EXTERNAL TRUNK RELEASE SWITCH SIGNAL: GROUND WHEN ACTIVATED S CR13-01 SCP + S CR13-02 SCP – I CR13-14 TRUNK AJAR SWITCH SIGNAL: GROUND (SIGNAL) WHEN TRUNK IS AJAR I CR13-15 TRUNK RELEASE MOTOR CLOSED STATUS SIGNAL: GROUND (SIGNAL) WHEN ACTIVATED FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Central Locking 79 SCP NW B DD13-11 N 76 + 20.2 20.3 20.2 20.3 DD13-12 – U S YB DD11-8 YG DD11-9 DD2-2 OY BK DD1-7 ALARM SET / LOCK SWITCH DD2-5 G9AR (G10AR) BK I PD16-17 BK PDS3 G10AL (G9AL) PASSENGER DOOR LATCH U U U IP3-4 N R BK RR2-1 (LHD) RL2-1 (RHD) RR2-3 (LHD) RL2-3 (RHD) GO DD7-1 DD10-2* I BK BK DDS3 B P DD13-7 B DDS1 DD13-8 B G9AL (G10AL) NW 80 NW 64 S B CRS56 BK BL11-1 + BK BK CCS3 GLOBAL OPEN / CLOSE SWITCH CL2-8 BK CL3-3 WU WU CL3-9 YU TL28-10 WU CC2-10 YG Y YG RR9-11 (LHD) RL9-11 (RHD) CR4-1 RG RG BT5-1 BT5-2 Y 20.2 B 20.3 BT11-6 – U S 20.2 RU 20.3 B FUEL FILLER FLAP MOTOR G23AL U U BT11-12 R I CR9-8 BT2-1 OG OY NR IP9-7 IP50-3 FUEL FLAP RELEASE SWITCH G31AL NR PD16-17 BK BK PDS3 GU 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II BT2-8 CR11-10 O O PD7-1 PD10-2* PD7-2 PD10-3* PD16-22 WG WG BT11-5 WG Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S B CR1-1 G9CL 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E E CRS75 G24AR B B B CR11-12 P CR11-11 CR11-25 G24BL FRONT ELECTRONIC MODULE Fig. 01.5 S NOTES: Check market specification for fitment of Remote Keyless Entry. Double locking components and circuits – Double Locking vehicles only. I CR13-14 BL11-5 B I CR9-12 PASSENGER DOOR AJAR SWITCH I CR4-7 BL11-3 I GU * NOTE: Double Locking vehicles. 6 AJAR SWITCH BO BL11-11 BT11-3 I CR13-15 TRUNK LATCH G10AL (G9AL) 1 BT2-7 EC36-5 TRUNK AND FUEL FLAP RELEASE SWITCH PACK BK CLOSE SWITCH OY BO O EC36-8 I CR11-8 BL11-9 BT11-11 O CR11-4 OG BL11-8 BT11-9 BT2-6 I R BL11-7 BT11-8 O CR11-5 R OY YR U BL11-12 BT11-7 BT2-3 IP50-6 O CR11-3 BO IPS35 I CR12-9 CR15-1 CR15-2 BT2-5 B LOCK O UNLOCK I WU IP9-1 RG BL11-6 B CRS23 CR9-7 CENTER CONSOLE SWITCH PACK IP50-8 O DOUBLE CR4-11 Y OG TRUNK RELEASE SWITCH O LOCK CR4-2 RR9-9 (LHD) RL9-9 (RHD) CR85-6 TL28-11 YR CR11-7 YB BT2-2 CL1-5 G15AR LOCK O UNLOCK EXTERNAL TRUNK RELEASE SWITCH G24AL S B CR85-1 YU CC2-12 CRS26 RR9-10 (LHD) RL9-10 (RHD) BK BT11-1 CR9-1 YU Y Y B CR9-6 CL3-6 O DOUBLE CR4-12 DD3-8 DRIVER DOOR MODULE YU CRS30 PASSENGER REAR DOOR LOCK MOTOR B * NOTE: Double Locking vehicles. CL2-1 YG YG RL9-9 (LHD) RR9-9 (RHD) RR2-2 (LHD) RL2-2 (RHD) DD12-25 DRIVER DOOR AJAR SWITCH G9AR (G10AR) O LOCK CR11-6 YB D DD11-18 DD3-7 DD7-2 DD10-3* RL9-11 (LHD) RR9-11 (RHD) CRS29 DD11-20 R IP3-5 REMOTE KEYLESS ENTRY MODULE I DD3-3 R IP60-1 Y RL9-10 (LHD) RR9-10 (RHD) DRIVER REAR DOOR LOCK MOTOR DD11-13 G IP17-10 IP60-3 D DD1-15 G YG RL2-2 (LHD) RR2-2 (RHD) DD11-6 N IP17-9 G O DD1-14 N IP60-2 RL2-3 (LHD) RR2-3 (RHD) YB YB YB IP60-4 I CR11-22 DD11-17 RL2-1 (LHD) RR2-1 (RHD) B VALET SWITCH RU PD16-6 PD2-4 UNLOCK STATUS SWITCH I CR11-21 RU PD2-6 REMOTE LOCK / UNLOCK NOTE: CCS3 – Non Navigation vehicles only. OY PD16-7 PD2-8 BK I DD2-7 DD1-7 Y PD16-8 OY LOCK STATUS SWITCH DRIVER DOOR LATCH BK YG PD16-10 Y REAR ELECTRONIC MODULE I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 N B S – YB YG DD11-16 O ALARM RESET / UNLOCK SWITCH U PD16-9 PD2-3 I R DD2-6 YB PD2-1 DD13-2 BK DDS3 LOCK O UNLOCK DD13-10 RU BK 20.2 78 CR4-3 S + CR13-2 PD2-2 DD2-4 20.3 Y CR13-1 I DD2-8 UNLOCK STATUS SWITCH 20.2 O DOUBLE Y LOCK STATUS SWITCH 20.3 O LOCK DD11-10 DD2-3 NW B NOTE: The CAN / SCP J-Gate Gear Selector position message is used for “drive away” locking control. Refer to Fig. 04.1. DD13-4 DD2-1 REFER TO APPENDIX FEM, DDM AND REM CENTRAL LOCKING MESSAGES LOCK; UNLOCK; SECURITY DD13-3 B S Y S Fig. 12.1 Central Locking CR13-6 59 S Fig. 12.2 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS O D I 1 D I DD11-06 DD11-13 DD11-16 DD11-17 DD11-18 DD11-20 REMOTE KEYLESS ENTRY MODULE POWER SUPPLY: B+ REMOTE KEYLESS ENTRY MODULE SIGNAL: ENCODED COMMUNICATIONS DRIVER DOOR ALARM SET / LOCK SWITCH (NORMALLY OPEN): OPEN CIRCUIT / GROUND DRIVER DOOR ALARM RESET / UNLOCK SWITCH (NORMALLY OPEN): OPEN CIRCUIT / GROUND REMOTE KEYLESS ENTRY MODULE SIGNAL: ENCODED COMMUNICATIONS REMOTE KEYLESS ENTRY RETURN Component Connector(s) Connector Description Location AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE AUTO LAMP SENSOR IP36 6-WAY / BLACK INSTRUMENT PANEL / CENTER FRONT O I DD12-06 DD12-25 DDM SECURITY: DDM GROUND DRIVER DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR CENTER CONSOLE SWITCH PACK CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE S S SG PG B+ DD13-03 DD13-04 DD13-07 DD13-08 DD13-11 SCP NETWORK + SCP NETWORK – LOGIC GROUND: GROUND POWER GROUND: GROUND BATTERY POWER SUPPLY: LOGIC: B+ DOOR AJAR SWITCH – DRIVER DD7 DD10 2-WAY / BLACK 3-WAY / BLACK DRIVER DOOR DOOR AJAR SWITCH – LH REAR RL7 RL10 2-WAY / BLACK 3-WAY / BLACK LH REAR DOOR DOOR AJAR SWITCH – PASSENGER PD7 PD10 2-WAY / BLACK 3-WAY / BLACK PASSENGER DOOR DOOR AJAR SWITCH – RH REAR RR7 RR10 2-WAY / BLACK 3-WAY / BLACK RH REAR DOOR DOOR LATCH – DRIVER DD2 8-WAY / BLACK DRIVER DOOR TRIM DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM Engine Control Module C C Pin Description and Characteristic PI1-123 PI1-124 CAN – CAN + Front Electronic Module ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST Pin Description and Characteristic I O CR1-01 CR1-25 PASSENGER DOOR AJAR SWITCH SIGNAL: GROUND WHEN ACTIVATED FEM SECURITY SYSTEM GROUND SENSING: GROUND WHEN FEM IS INSTALLED S I B+ S SG CR9-01 CR9-03 CR9-06 CR9-07 CR9-12 SCP – TELEMATICS DISPLAY SECURITY GROUND SENSING: OPEN CIRCUIT IF TELEMATICS DISPLAY IS REMOVED BATTERY POWER SUPPLY: LOGIC: B+ SCP + LOGIC GROUND: GROUND O O CR10-04 CR10-10 LH TURN SIGNAL ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND RH TURN SIGNAL ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND B+ I I P CR85-03 CR85-06 CR85-07 CR85-14 IGNITION SWITCHED POWER SUPPLY (II): B+ VALET SWITCH SIGNAL: GROUND WHEN ACTIVATED AUDIO UNIT SECURITY GROUND SENSING: OPEN CIRCUIT IF AUDIO UNIT IS REMOVED STEERING COLUMN LOCK MODULE GROUND: GROUND I I O EC36-02 EC36-08 EC36-20 HOOD AJAR SWITCH SIGNAL: GROUND WHEN ACTIVATED TRUNK RELEASE SWITCH SIGNAL: GROUND WHEN ACTIVATED HORN RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND Instrument Cluster Pin Description and Characteristic I B+ B+ O SG IP5-02 IP5-03 IP5-04 IP5-10 IP5-14 KEY-IN AUDIBLE WARNING: B+ WHEN KEY IN IGNITION SWITCHED POWER SUPPLY (II): B+ IGNITION SWITCHED POWER SUPPLY (I): B+ SECURITY INDICATOR DRIVE: ACTIVE = PULSED GROUND SIGNAL GROUND: GROUND PG I D D C C S S IP6-02 IP6-04 IP6-05 IP6-06 IP6-08 IP6-09 IP6-10 IP6-20 POWER GROUND: GROUND PATS GROUND: GROUND PATS TRANSCEIVER: ENCODED COMMUNICATION PATS TRANSCEIVER: ENCODED COMMUNICATION CAN + CAN – SCP – SCP + HOOD AJAR SWITCH EC14 2-WAY / BLACK ENGINE COMPARTMENT / BEHIND RH HEADLAMP UNIT IGNITION SWITCH IP34 7-WAY / BLACK STEERING COLUMN INCLINATION SENSOR CR28 6-WAY / BLACK TRUNK / LH REAR INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER IP18 4-WAY / GREEN IGNITION SWITCH REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REMOTE KEYLESS ENTRY MODULE IP60 4-WAY / BLACK BEHIND INSTRUMENT PANEL / DRIVER SIDE ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF SECURITY SOUNDER – ACTIVE BS1 3-WAY / BLACK TRUNK / RH SIDE / FORWARD SECURITY SOUNDER – PASSIVE PS1 PS2 1-WAY / BLACK 1-WAY / BLACK TRUNK / RH SIDE / FORWARD STEERING COLUMN LOCK MODULE IP24 4-WAY / BLACK UPPER STEERING COLUMN TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE TRUNK AND FUEL FLAP RELEASE SWITCH PACK IP50 10-WAY / BLACK INSTRUMENT PANEL / OUTBOARD OF STEERING COLUMN TRUNK LATCH BT2 8-WAY / BLACK TRUNK LID HARNESS IN-LINE CONNECTORS Rear Electronic Module Connector Connector Description Location Pin Description and Characteristic B+ O I I I I CR4-03 CR4-05 CR4-06 CR4-07 CR4-17 CR4-19 BATTERY POWER SUPPLY (LOGIC): B+ ACTIVE SECURITY SOUNDER ACTIVATE: ENCODED COMMUNICATION INTRUSION SENSOR SIGNAL: GROUND (PULSED) TRUNK CLOSE SWITCH SIGNAL: GROUND (SIGNAL) WHEN TRUNK IS AJAR RH REAR DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR FEM SECURITY SYSTEM GROUND SENSING: GROUND WHEN FEM IS INSTALLED I SG PG I SG CR11-09 CR11-10 CR11-11 CR11-16 CR11-25 INCLINATION SENSOR SIGNAL TRUNK LATCH SIGNAL GROUND: GROUND POWER GROUND: GROUND LH REAR DOOR AJAR SWITCH SIGNAL: GROUND WHEN DOOR IS AJAR LOGIC GROUND: GROUND O I CR12-01 CR12-07 SCLM POWER SUPPLY: B+ DDM SECURITY SYSTEM GROUND SENSING: GROUND WHEN DDM IS INSTALLED S S O O O PG I CR13-01 CR13-02 CR13-08 CR13-09 CR13-10 CR13-12 CR13-14 SCP + SCP – PASSIVE SECURITY SOUNDER ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO B+ INCLINATION SENSOR POWER SUPPLY: B+ INTRUSION SENSOR POWER SUPPLY: B+ ACTIVE SECURITY SOUNDER GROUND SUPPLY: GROUND TRUNK AJAR SWITCH SIGNAL: GROUND (SIGNAL) WHEN TRUNK IS AJAR BL11 BT11 CC2 CL3 CR45 DD1 DD3 IP1 IP3 IP9 IP17 PD16 RF2 RL1 RL9 RR1 RR9 TL28 16-WAY / BLACK / CABIN HARNESS TO TRUNK LID HARNESS 16-WAY / GREY / CABIN TO TRUNK LID LINK HARNESS TO TRUNK LID HARNESS 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS 6-WAY / BLACK / CABIN HARNESS TO BATTERY BACKED SOUNDER HARNESS 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS 16-WAY / GREEN / CABIN HARNESS TO INSTRUMENT PANEL HARNESS 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS 6-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS 16-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS 6-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS 16-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS TRUNK / BEHIND TRUNK LID LINER TRUNK / TRUNK LID CABIN / BELOW CENTER CONSOLE CABIN / BELOW CENTER CONSOLE / LH SIDE ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER CABIN / DRIVER SIDE ‘A’ POST CABIN / DRIVER SIDE ‘A’ POST CABIN / BEHIND DRIVER SIDE INSTRUMENT PANEL END PLATE CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE CABIN / ADJACENT TO HOOD RELEASE CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE CABIN / PASSENGER SIDE ‘A’ POST CABIN / RH ‘D’ POST CABIN / LH ‘B/C’ POST CABIN / LH ‘B/C’ POST CABIN / RH ‘B/C’ POST CABIN / RH ‘B/C’ POST CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL O O CR71-03 CR71-04 LH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND RH REAR TURN SIGNAL ACTIVATE: TO ACTIVATE, REM SWITCHES CIRCUIT TO GROUND GROUNDS NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated Ground Location G1 G9 G10 G15 G17 G23 G24 G31 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY CABIN / UPPER LH A POST CABIN / RH A POST CABIN / RH SIDE OF TRANSMISSION TUNNEL CABIN / BELOW REAR SEAT / RH SIDE TRUNK / RH SIDE / ADJACENT TO BATTERY TRUNK / RH SIDE / REAR ELECTRONIC MODULE CABIN / BEHIND PASSENGER AIR BAG CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 NOTE: ECM power supplies and grounds shown on Figs. 03.1, 03.3 and 03.5. Security System GR 16 B II + C – C 20.1 PATS PI1-124 G 20.3 U 20.2 20.3 20.3 C – GO O IP6-9 PI1-123 IP5-10 20.3 NG IP36-2 W 20.2 D KEY-IN RU 4 RW IP34-4 20.2 SERIAL COMMUNICATION IP36-3 78 CR4-3 CR4-6 YU YU RF3-6 RF2-5 B P U 08.3 REAR TURN SIGNAL ACTIVATE O 08.3 REAR TURN SIGNAL ACTIVATE CR71-3 O B RFS1 RF3-1 O O CR13-10 B CR71-4 RF2-1 INTRUSION SENSOR PASSIVE ANTI-THEFT SYSTEM I RF2-6 B IP5-2 IGNITION SWITCH NW B S – OY RF3-7 AUTOLAMP SENSOR I IP34-5 U OY O RF3-8 77 SECURITY INDICATOR ENGINE CONTROL MODULE S + CR13-2 C + G 20.1 Y 20.2 IP6-10 IP5-4 IP6-8 20.1 REFER TO APPENDIX FEM / DDM / REM CENTRAL LOCKING MESSAGES. SECURITY MESSAGES ARE NOT INCLUDED IN THE APPENDIX. 20.3 CR13-1 – S B Y 20.1 20.2 IP6-20 YG I SCP Y S IP5-3 4 Y + Fig. 12.2 Security System G17BR ROOF CONSOLE GR O GR CR13-8 WR IP18-3 IP6-5 S IP18-1 D IP18-4 B P B B B CRS23 B YG YG GO GO CR28-6 CR28-5 CR28-4 G23AL B O B CRS56 CR13-9 O IPS2 IP6-2 IP6-6 BG B IPS6 IP5-14 GR GU 65 B D I PS2 CR45-2 B PS1 CR45-1 G24AL PASSIVE SECURITY SOUNDER CR11-9 O IP18-2 IP6-4 INCLINATION SENSOR G31BL 45 WR II INSTRUMENT CLUSTER PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER + Y S 20.2 CR45-3 NG 44 20.3 NW 79 B + Y S DD13-11 – 20.2 – U S 20.2 U S 20.2 20.3 IP24-3 20.3 B DD13-3 IP24-1 20.3 YR IP24-2 IP1-3 CR4-5 O BK DDS3 DD1-7 O BK DD2-6 G9AR (G10AR) DD11-17 DD2-7 ALARM SET / LOCK SWITCH G DD1-5 DD12-6 R B DD11-16 IP17-3 P + 17 REMOTE SECURITY U IP3-4 IP60-4 IP17-9 IP60-2 DD11-13 G R IP3-5 BK D DD11-18 DD3-7 GO DD7-1 DD10-2* GU 19.2 HORN RELAY ACTIVATE (CIRCUIT CONTINUED) O BW 08.1 08.2 FRONT TURN SIGNAL ACTIVATE BR 08.2 FRONT TURN SIGNAL ACTIVATE CR10-4 08.1 I I BG CC8-8 CR1-25 I SECURITY GROUND SENSING CR4-19 BK B G12BL BG CC2-4 BG TL28-4 I CR85-7 DD13-8 G13BL G9AL (G10AL) BW DRIVER DOOR MODULE CC12-16 BW CC2-2 BW TL28-2 I CR9-3 GW RR7-1 RR10-2* RR7-2 RR10-3* BO YU CL1-5 G15AR BT11-11 BT2-6 O BK CL3-3 VALET SWITCH CL2-1 YU CL3-6 YU CC2-12 YU TL28-10 I CR4-17 * NOTE: Double Locking vehicles. NOTE: CCS3 – Non Navigation vehicles only BK GW RR9-8 RH REAR DOOR AJAR SWITCH SECURITY GROUND SENSING TELEMATICS DISPLAY CCS3 I CR11-16 RL9-8 LH REAR DOOR AJAR SWITCH BO BK GW RL7-1 RL10-2* BK RR1-5 AUDIO UNIT P GW RL7-2 RL10-3* SECURITY GROUND SENSING BK B DDS1 DD3-8 BK RL1-5 DD13-7 B G9AR (G10AR) UY UY O CR1-1 * NOTE: Double Locking vehicles. BK DDS3 GU PD16-22 PASSENGER DOOR AJAR SWITCH DD12-25 BK DD1-7 20.3 CR10-10 PD7-1 PD10-2* PD7-2 PD10-3* DRIVER DOOR AJAR SWITCH BK I EC36-2 O BK PDS3 G10AL (G9AL) BK DD7-2 DD10-3* BK PD16-17 * NOTE: Double Locking vehicles. REMOTE KEYLESS ENTRY MODULE 20.2 DD11-20 R IP60-1 20.3 GW O HOOD AJAR SWITCH I DD3-3 R G1AL G IP17-10 IP60-3 U EC14-1 EC14-2 D DD1-15 G CLOSE SWITCH BT2-7 AJAR SWITCH BT2-8 BO CR11-10 BL11-11 O BT11-3 O I CR4-7 BL11-3 I WG CR85-6 CENTER CONSOLE SWITCH PACK WG BT11-5 WG TRUNK LATCH I CR13-14 BL11-5 B P CR11-11 B B IPS36 YR IP50-6 TRUNK RELEASE SWITCH YR IP50-8 IP9-1 B I EC36-8 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S CRS75 B CR11-25 G9CL FRONT ELECTRONIC MODULE TRUNK AND FUEL FLAP RELEASE SWITCH PACK 6 B CR9-12 G31AL 1 ACTIVE SECURITY SOUNDER CR9-1 CR85-3 B N 20.2 EC36-20 DD11-6 N BS1-1 B O DD1-14 N II U S – CR9-6 B SECURITY GROUND SENSING B CR45-5 CR9-7 B GO Y S CR85-14 NW 80 U I CR12-7 DRIVER DOOR LATCH U BS1-2 I DD2-5 ALARM RESET / UNLOCK SWITCH CR13-12 G O GU CR45-4 B P STEERING COLUMN LOCK MODULE I BS1-3 CR12-1 DD13-4 BK GU D YR B P NG CR45-6 IP24-4 Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground G24BL A ACP S SCP C CAN D Serial and Encoded Data REAR ELECTRONIC MODULE VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 NOTE: Check market specification for fitment of the following Security System options: • Remote Keyless Entry Module • Steering Column Lock Module • Inclination Sensor • Intrusion Sensor • Passive Security Sounder • Active Security Sounder Fig. 13.1 CONTROL MODULE PIN-OUT INFORMATION Front Electronic Module I Pin Description and Characteristic COMPONENTS CR1-04 RAIN SENSING MODULE SIGNAL: PULSED SIGNAL Component Connector(s) Connector Description Location FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT O CR1-06 RAIN SENSING MODULE POWER SUPPLY: B+ PG CR1-26 POWER GROUND: GROUND SG CR9-12 LOGIC GROUND: GROUND B+ CR10-01 SWITCHED SYSTEM POWER SUPPLY: B+ PG CR10-11 POWER GROUND: GROUND PG CR10-13 POWER GROUND: GROUND PG CR10-14 POWER GROUND: GROUND PG CR85-02 POWER GROUND: GROUND O CR85-04 WINDSHIELD WASHER PUMP DRIVE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND SG CR85-08 WIPE / WASH SWITCHES SIGNAL GROUND: GROUND I CR85-09 MOMENTARY WIPE SWITCH SIGNAL: VARIABLE RESISTANCE I CR85-10 WASH / WIPE SWITCH SIGNAL: VARIABLE RESISTANCE I CR85-13 INTERMITTENT WIPE SWITCH SIGNAL: VARIABLE RESISTANCE I CR85-16 WIPER MASTER SWITCH SIGNAL: VARIABLE RESISTANCE O EC36-01 WIPER ON / OFF RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND I EC36-03 POWER WASH PUMP EC24 2-WAY / BLACK ENGINE COMPARTMENT / ADJACENT TO WASHER FLUID RESERVOIR POWER WASH RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R11 RAIN SENSING MODULE RF6 3-WAY / BLACK CABIN / WINDSHIELD CENTER WASHER FLUID LEVEL SWITCH EC25 2-WAY / BLACK ENGINE COMPARTMENT / WASHER FLUID RESERVOIR WIPERS PARKED SIGNAL: GROUND = PARKED WINDSHIELD WASHER PUMP EC51 2-WAY / BLACK ENGINE COMPARTMENT / ADJACENT TO WASHER FLUID RESERVOIR I EC36-06 WASHER FLUID LEVEL SIGNAL: GROUND WHEN ACTIVATED WIPE / WASH COLUMN SWITCH IP40 6-WAY / BLACK STEERING COLUMN PG EC36-10 RAIN SENSING MODULE POWER GROUND: GROUND WIPER FAST / SLOW RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R8 O EC36-16 POWER WASH RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND WIPER MOTOR EC27 4-WAY / BLACK ENGINE COMPARTMENT BULKHEAD O EC36-17 WIPER FAST / SLOW RELAY ACTIVATE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO GROUND WIPER ON / OFF RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R4 NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description Location EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST EC53 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / ABOVE LH FOOTWELL IP3 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP4 14-WAY / GREEN / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST RF25 8-WAY / BLACK / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER LH ‘A’ POST GROUNDS Ground Location G2 ENGINE COMPARTMENT / BELOW FRONT POWER DISTRIBUTION FUSE BOX G9 CABIN / UPPER LH A POST G26 ENGINE COMPARTMENT / RH SIDE / REARWARD OF SUSPENSION TOWER G30 ENGINE COMPARTMENT / LH SIDE / REARWARD OF SUSPENSION TOWER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Wash / Wipe System OY 58 S WB B CR10-1 WB IP40-2 WASH / WIPE Fig. 13.1 Wash / Wipe System IP4-2 I CR85-10 6 5 PARK BW I 4 EC36-3 RUN EC27-3 PARK SWITCH Y 3 Y RG I IP3-12 IP40-5 R8 CR85-13 INTERMITTENT WIPE 4 3 5 1 2 EC22-3 R EC22-4 2 11 B HIGH SPEED EC27-4 G30AS (G26AS) EC27-2 WIPER MOTOR 1 WIPER FAST / SLOW RELAY BG O LOW SPEED EC27-1 EC36-17 EC41-6 AUTO OFF 12 R4 4 3 5 1 2 B EC22-1 INTERMITTENT YB YB IP40-4 SLOW IP4-13 I 13 G2AL CR85-16 MASTER WIPER ON / OFF RELAY BR O FAST EC36-1 EC5-1 R11 YR YR IP3-13 IP40-3 MOMENTARY WIPE I 23 G IP4-12 6 24 POWER WASH PUMP POWER WASH RELAY BG EC36-16 WG WG RF6-1 RF25-2 YB RF6-3 RF25-1 B P FRONT POWER DISTRIBUTION FUSE BOX I CR1-4 B B RF6-2 EC28-5 O CR1-6 YB O EC24-2 EC24-1 7 CR85-8 O B RW EC32-3 F4 30A WIPE / WASH COLUMN SWITCH B 9 10 CR85-9 G IP40-6 8 EC53-1 RF2-8 P EC36-10 BW O CR85-4 RAIN SENSING MODULE Y BW EC1-20 73 EC51-2 EC51-1 S WINDSHIELD WASHER PUMP B B ECS4 WU EC25-1 G2AR I EC25-2 EC36-6 WASHER FLUID LEVEL SWITCH B BK B B B B CR9-12 CR85-2 CR1-26 CR10-14 CR10-11 P P P P P CR10-13 G9CL G9BL FRONT ELECTRONIC MODULE G9BR 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 G2AL Fig. 14.1 CONTROL MODULE PIN-OUT INFORMATION Driver Door Module Pin Description and Characteristic COMPONENTS I DD11-16 DRIVER DOOR ALARM SET / LOCK SWITCH (NORMALLY OPEN): OPEN CIRCUIT / GROUND Component Connector(s) Connector Description Location 1 DD11-17 DRIVER DOOR ALARM RESET / UNLOCK SWITCH (NORMALLY OPEN): OPEN CIRCUIT / GROUND CENTER CONSOLE SWITCH PACK CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE DOOR LATCH – DRIVER DD2 8-WAY / BLACK DRIVER DOOR TRIM DOOR SWITCH PACK – DRIVER DT4 20-WAY / BLACK DRIVER DOOR TRIM O DD12-12 REAR WINDOW ISOLATE STATUS LED ACTIVATE: TO ACTIVATE, DDM SWITCHES CIRCUIT TO B+ I DD12-22 REAR WINDOW ISOLATE SWITCH SIGNAL: NORMALLY CLOSED SWITCH, OPEN CIRCUIT WHEN SELECTED S DD13-03 SCP NETWORK + DOOR SWITCH PACK – LH REAR LT3 8-WAY / BLACK LH REAR DOOR TRIM PASSENGER DOOR TRIM S DD13-04 SCP NETWORK – DOOR SWITCH PACK – PASSENGER PT4 8-WAY / BLACK SG DD13-07 LOGIC GROUND: GROUND DOOR SWITCH PACK – RH REAR RT3 8-WAY / BLACK RH REAR DOOR TRIM B+ DD13-11 BATTERY POWER SUPPLY: LOGIC: B+ DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR Front Electronic Module Pin Description and Characteristic O CR1-14 POWER WINDOWS ENABLE: TO ACTIVATE, FEM SWITCHES CIRCUIT TO B+ O CR1-15 GLOBAL CLOSE SIGNAL: 20 ms PULSED SIGNAL S CR9-01 SCP – B+ CR9-06 BATTERY POWER SUPPLY: LOGIC: B+ S CR9-07 SCP + I CR9-08 GLOBAL OPEN / CLOSE SWITCH SIGNAL: GROUND WHEN ACTIVATED SG CR9-12 LOGIC GROUND: GROUND ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF Rear Electronic Module SLIDING ROOF MODULE CR30 10-WAY / GREY ABOVE ROOF CONSOLE Pin Description and Characteristic WINDOW MOTOR ASSEMBLY – DRIVER DD6 8-WAY / GREY DRIVER DOOR WINDOW MOTOR ASSEMBLY – PASSENGER PD6 8-WAY / GREY PASSENGER DOOR B+ CR4-03 BATTERY POWER SUPPLY (LOGIC): B+ WINDOW MOTOR ASSEMBLY – LH REAR RL6 8-WAY / GREY LH REAR DOOR WINDOW MOTOR ASSEMBLY – RH REAR RR6 8-WAY / GREY RH REAR DOOR PG CR11-11 POWER GROUND: GROUND SG CR11-25 LOGIC GROUND: GROUND O CR12-02 REAR WINDOW ISOLATE: TO ISOLATE, REM INTERRUPTS GROUND SUPPLY Connector Connector Description Location S CR13-01 SCP + CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE S CR13-02 SCP – CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM DT6 16-WAY / BLUE / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM EC1 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST LT1 12-WAY / GREY / LH REAR DOOR HARNESS TO LH REAR DOOR TRIM HARNESS CABIN / LH REAR DOOR TRIM PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PD16 22-WAY / BLACK / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PT1 12-WAY / GREY / PASSENGER DOOR HARNESS TO PASSENGER DOOR TRIM HARNESS CABIN / BEHIND PASSENGER DOOR TRIM RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST RL1 6-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST RL9 16-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST RR1 6-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST RR9 16-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST RT1 12-WAY / GREY / RH REAR DOOR HARNESS TO RH REAR DOOR TRIM HARNESS CABIN / RH REAR DOOR TRIM TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. GROUNDS Ground Location G9 CABIN / UPPER LH A POST G10 CABIN / RH A POST G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G17 CABIN / BELOW REAR SEAT / RH SIDE G24 TRUNK / RH SIDE / REAR ELECTRONIC MODULE FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Powered Windows; Sliding Roof NW 80 B + Y S CR9-6 20.2 B 20.3 CR9-7 U – S B 20.2 B RFS1 RF2-1 GR RF3-1 RF3-5 20.3 BK BK BK CCS3 CL3-3 CL1-5 G15AR WU WU CL2-8 GLOBAL OPEN / CLOSE SWITCH CL3-9 WU WU CC2-10 TL28-11 B NW RU CR30-7 B G17BL B + SLIDING ROOF MODULE Y S 20.2 20.3 20.2 20.3 DD13-3 – U S DD13-4 I 75 DD11-16 DD2-5 R CRS4 I DD11-17 DD2-7 I REMOTE GLOBAL CRS41 DD6-2 RU DD1-12 DD6-6 POSITION SENSORS MOTOR CONTROL BW DD12-22 BK DDS3 RELAY R DD1-22 RU BR DT6-2 NR DD6-7 O BK DD1-7 DYNAMIC STABILITY CONTROL: VEHICLE SPEED (CIRCUIT CONTINUED) CR30-10 R DRIVER DOOR LATCH 05.1 EC1-10 CR30-2 CR1-15 DD13-11 ALARM RESET / UNLOCK SWITCH CR30-6 G RU ROOF CONSOLE FRONT ELECTRONIC MODULE ALARM SET / LOCK SWITCH G CR30-8 G9CL 79 BK UY RF1-10 72 CR30-1 R GLOBAL O CR9-12 NOTE: CCS3 – Non Navigation vehicles only. BK R ENABLE O RF3-4 NG CR30-9 CR1-14 CENTER CONSOLE SWITCH PACK DD2-6 SLIDING ROOF SWITCH I CR9-8 GR RF1-9 UY G17BR CR9-1 Fig. 14.1 Powered Windows; Sliding Roof UY O DD13-7 B DD6-3 DD6-8 B DDS1 B DD3-8 G9AL (G10AL) BO DD12-12 G9AR (G10AR) DD6-4 DRIVER DOOR MODULE DRIVER WINDOW MOTOR ASSEMBLY UY BK DT4-19 DT4-18 REAR WINDOW ISOLATE STATUS DT6-13 BR 86 DT4-9 BW DRIVER WINDOW DT4-1 (LHD) DT4-12 (RHD) DT4-2 (LHD) DT4-11 (RHD) PASSENGER WINDOW DT4-12 (LHD) DT4-1 (RHD) DT4-11 (LHD) DT4-2 (RHD) LH REAR WINDOW BK BK DD1-7 BK BK DDS3 BW BO W DT6-10 DT4-3 DD1-18 DT6-8 DD1-19 DT4-14 DT6-5 YB DT4-13 PASSENGER WINDOW MOTOR ASSEMBLY GO Y RR9-2 YB YB YB DD1-21 RR9-3 42 DRIVER DOOR SWITCH PACK R R RL6-2 RL9-4 RU W W PT4-2 BK B 20.3 BK PTS3 BK GW B RL6-3 WG PT4-6 RL6-6 RLS5 PT1-4 WG PT4-1 PT1-2 G10AL (G9AL) Y 20.2 BK PD16-17 CR4-3 B RLS2 RL6-8 B RL1-2 GO RLS6 PT1-3 G12BR RL6-4 PASSENGER DOOR SWITCH PACK S + POSITION SENSORS MOTOR CONTROL RU RL9-13 NW RELAY NG RL6-7 REAR WINDOW ISOLATE 78 G10AR (G9AR) PD6-4 RL9-3 DD1-20 DT6-1 B PD1-7 GW Y Y B PDS1 PD6-8 WG PDS2 RL9-2 GO GO B PD6-3 WG PD16-2 GW GW Y RH REAR WINDOW DD1-17 POSITION SENSORS MOTOR CONTROL W PDS4 PD16-1 WG WG GO W W DD1-16 DT6-12 GW PD6-6 PD16-3 DT6-7 WG RU RU BO W PD6-2 PD1-2 DT6-9 DT4-20 G9AR (G10AR) RELAY R R DT6-6 DT4-4 BK DTS1 DT1-9 NR PD6-7 REAR WINDOW ISOLATE LH REAR WINDOW MOTOR ASSEMBLY CR13-1 20.3 U 20.2 S – W W CR13-2 LT3-2 B B R R O P CR11-11 CR12-2 CRS54 R R RL9-1 LT1-8 WG LT3-1 B CRS75 LT1-4 WG LT3-6 49 RR6-7 R LH REAR DOOR SWITCH PACK CR11-25 R RU G24BL Y Y R R R RR9-1 RT1-8 Y RT1-5 7 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E RR6-8 YB RRS6 RH REAR WINDOW MOTOR ASSEMBLY I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data B RRS2 B RR1-2 G13BR RR6-4 RH REAR DOOR SWITCH PACK 6 B RR6-3 YB RT3-6 POSITION SENSORS RR6-6 RRS5 RT1-4 YB RT3-1 MOTOR CONTROL RU RR9-13 RT3-2 1 RR6-2 RR9-4 REAR ELECTRONIC MODULE RELAY NR LT1-5 VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 15.1 CONTROL MODULE PIN-OUT INFORMATION Audio Unit – Premium Pin Description and Characteristic COMPONENTS PG CC8-01 POWER GROUND: GROUND Component Connector(s) Connector Description Location B+ CC8-02 IGNITION SWITCHED POWER SUPPLY (I): B+ I CC8-07 TELEPHONE MUTE SIGNAL AM / FM ANTENNA AMPLIFIER CC8-08 AUDIO UNIT SECURITY SYSTEM GROUND SENSING: GROUND WHEN AUDIO UNIT INSTALLED 2-WAY / BLACK 3-WAY / BLACK CABIN / LH ‘D’ POST I TL26 TL11 S CC8-09 SCP + AUDIO UNIT CC8-10 SCP – CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE S B+ CC8-11 BATTERY POWER SUPPLY: B+ I CC8-17 DIMMER CONTROLLED ILLUMINATION: PWM, 80Hz, GROUND = 0% DUTY CYCLE, B+ = 100% DUTY CYCLE CD AUTOCHANGER TL5 DB2 3-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / THIRD FROM TOP I CC8-18 STEERING WHEEL SWITCHES: STEPPED RESISTANCE O CC8-19 D2B NETWORK WAKE-UP HEATED REAR WINDOW HW1 HW2 1-WAY / BLACK 1-WAY / BLACK CABIN / BEHIND REAR SEAT BACK / LH SIDE (CONNECTOR LOCATION) CABIN / BEHIND REAR SEAT BACK / LH SIDE (CONNECTOR LOCATION) MID BASS SPEAKER – LH FRONT DD4 PD4 2-WAY / WHITE 2-WAY / WHITE LH FRONT DOOR MID-BASS SPEAKER – LH REAR RL4 2-WAY / WHITE LH REAR DOOR MID BASS SPEAKER – RH FRONT PD4 DD4 2-WAY / WHITE 2-WAY / WHITE RH FRONT DOOR MID-BASS SPEAKER – RH REAR RR4 2-WAY / WHITE RH REAR DOOR STEERING WHEEL AUDIO SWITCHES — — STEERING WHEEL TWEETER SPEAKER – LH FRONT DT3 PT3 2-WAY / WHITE 2-WAY / WHITE LH FRONT DOOR TWEETER SPEAKER – LH REAR LT4 2-WAY / WHITE LH REAR DOOR TWEETER SPEAKER – RH FRONT PT3 DT3 2-WAY / WHITE 2-WAY / WHITE RH FRONT DOOR TWEETER SPEAKER – RH REAR RT4 2-WAY / WHITE RH REAR DOOR I CC9-01 ANTENNA SG CC9-02 ANTENNA SHIELD D2 CC21-01 D2B NETWORK TRANSMIT D2 CC21-02 D2B NETWORK RECEIVE NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description CC7 10-WAY / GREY / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) CC19 2-WAY / BLACK / AUDIO UNIT ANTENNA CABIN / BEHIND CENTER CONSOLE DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST LT1 12-WAY / GREY / LH REAR DOOR HARNESS TO LH REAR DOOR TRIM HARNESS CABIN / LH REAR DOOR TRIM PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE PT1 12-WAY / GREY / PASSENGER DOOR HARNESS TO PASSENGER DOOR TRIM HARNESS CABIN / BEHIND PASSENGER DOOR TRIM RL1 6-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST RR1 6-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST RT1 12-WAY / GREY / RH REAR DOOR HARNESS TO RH REAR DOOR TRIM HARNESS CABIN / RH REAR DOOR TRIM TL31 14-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL GROUNDS Ground Location G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 In-Car Entertainment: Premium 76 NW B CC8-11 5 YR I R I 20.2 CC19-1 BRD CC8-2 Y R CC9-1 B CC9-2 20.3 YR B TL26-1 6 I TL11-2 BRD CC19-2 TL26-2 AM COAXIAL CABLES S + CC8-9 20.3 20.2 Fig. 15.1 In-Car Entertainment: Premium U FM S – P CC8-10 RADIO ILLUMINATION 09.3 RW CC8-17 SECURITY SYSTEM: RADIO REMOVED SENSING TELEPHONE: MUTE 16.4 16.3 16.2 12.2 BG HEATED REAR WINDOW AM / FM ANTENNA AMPLIFIER I O 16.1 U LH REAR TWEETER SPEAKER LH REAR MID-BASS SPEAKER CC8-8 LH FRONT TWEETER SPEAKER LH FRONT MID-BASS SPEAKER I CC8-7 D2B NETWORK: “WAKE-UP” 20.4 OG O CC8-19 3.01 Κ Ω RL4 -2 RL4 -1 WU YU LT4 -2 LT4 -1 DD4 DD4 -2 -1 (LHD) (LHD) PD4 PD4 -2 -1 (RHD) (RHD) DT3 DT3 -2 -1 (LHD) (LHD) PT3 PT3 -2 -1 (RHD) (RHD) PHONE, VOICE 1ΚΩ VOLUME + WU + ve CC8-3 154 Ω MEMORY + CC8-4 CASSETTE CC7-4 WU WU RLS3 RL1-3 YU TL31-4 YU YU RLS4 RL1-6 SW8-6 93.1 Ω VOLUME – CC7-1 CC8-14 53.5 Ω YU CC7-2 CC8-13 CASSETTE RW SW8-3 RW CC10-1 TL31-10 Y TL31-11 W (LHD) WR (RHD) Y (LHD) YR (RHD) DD3-9 (LHD) PD1-5 (RHD) YG 03.2 YG CC7-8 IP55-11 (LHD) IP9-3 (RHD) NW BOF D 2 20.4 20.4 BOF DDS6 (LHD) PDS6 (RHD) 20.4 20.4 BOF DB2-1 20.4 OG 63 YR RR1-6 64 95 Fig. 01.2 1 15 BK I II 52 Fig. 01.4 53 77 II S II S PT1-12 (LHD) DT1-12 (RHD) WR (LHD) W (RHD) YR (LHD) Y (RHD) WR (LHD) W (RHD) RR4 -2 RT4 -1 RT4 -2 PD4 PD4 -1 -2 (LHD) (LHD) DD4 DD4 -1 -2 (RHD) (RHD) PT3 PT3 -1 -2 (LHD) (LHD) DT3 DT3 -1 -2 (RHD) (RHD) B P CC8-1 G15AL RH REAR MID-BASS SPEAKER AUDIO UNIT 16 RT1-12 YR WG RR4 -1 Fig. 01.3 YR (LHD) Y (RHD) YR 2 O Fig. 01.1 PT1-11 (LHD) DT1-11 (RHD) WG RT1-11 YR RRS4 D CD AUTOCHANGER 7 TL31-6 WG RRS3 CC21-2 G25AL 6 CC7-7 WG RR1-3 YR PDS5 (LHD) DDS5 (RHD) D TL5-1 1 WG WR (LHD) W (RHD) YR (LHD) Y (RHD) PDS6 (LHD) DDS6 (RHD) PD1-6 (LHD) DD3-10 (RHD) TL31-5 YR YR WR (LHD) W (RHD) YR (LHD) Y (RHD) PD1-5 (LHD) DD3-9 (RHD) TL5-3 P DT1-12 (LHD) PT1-12 (RHD) CC21-1 BOF 2 D2B NETWORK: “WAKE-UP” DT1-11 (LHD) PT1-11 (RHD) 2 DB2-2 D TL31-9 CC7-6 CC8-6 B TL5-2 YR WG WG CC8-5 – ve TL31-8 CC7-9 CC8-15 + ve 41 DDS5 (LHD) PDS5 (RHD) DD3-10 (LHD) PD1-6 (RHD) WR YR YR – ve PI41-24 WR WR + ve CC8-16 03.4 W (LHD) WR (RHD) Y (LHD) YR (RHD) CC8-18 STEERING WHEEL AUDIO SWITCHES 03.6 Y (LHD) YR (RHD I RESISTOR PACK ECM: SENSOR GROUND W (LHD) WR (RHD) Y (LHD) YR (RHD LT1-12 W Y Y – ve SELECT W W + ve W (LHD) WR (RHD) WU LT1-11 YG MEMORY – 475 Ω WU TL31-3 YU YU – ve 261 Ω WU CC7-3 Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data RH REAR TWEETER SPEAKER RH FRONT MID-BASS SPEAKER VARIANT: Premium ICE Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 RH FRONT TWEETER SPEAKER Fig. 15.2 CONTROL MODULE PIN-OUT INFORMATION Audio Unit – Premium Pin Description and Characteristic COMPONENTS PG CC8-01 POWER GROUND: GROUND Component Connector(s) Connector Description Location B+ CC8-02 IGNITION SWITCHED POWER SUPPLY (I): B+ O CC8-03 LH REAR AUDIO + AM / FM ANTENNA AMPLIFIER CC8-04 LH REAR AUDIO – 2-WAY / BLACK 3-WAY / BLACK CABIN / LH ‘D’ POST O TL26 TL11 O CC8-05 RH REAR AUDIO + AUDIO UNIT CC8-06 RH REAR AUDIO – CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE O I CC8-07 TELEPHONE MUTE SIGNAL I CC8-08 AUDIO UNIT SECURITY SYSTEM GROUND SENSING: GROUND WHEN AUDIO UNIT INSTALLED CD AUTOCHANGER TL5 DB2 3-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / THIRD FROM TOP S CC8-09 SCP + HEATED REAR WINDOW HW1 HW2 1-WAY / BLACK 1-WAY / BLACK CABIN / BEHIND REAR SEAT BACK / LH SIDE (CONNECTOR LOCATION) CABIN / BEHIND REAR SEAT BACK / LH SIDE (CONNECTOR LOCATION) MID BASS SPEAKER – LH FRONT DD4 PD4 2-WAY / WHITE 2-WAY / WHITE LH FRONT DOOR MID-BASS SPEAKER – LH REAR RL4 2-WAY / WHITE LH REAR DOOR MID BASS SPEAKER – RH FRONT PD4 DD4 2-WAY / WHITE 2-WAY / WHITE RH FRONT DOOR MID-BASS SPEAKER – RH REAR RR4 2-WAY / WHITE RH REAR DOOR MID-RANGE SPEAKER – LH FASCIA IP25 2-WAY / WHITE INSTRUMENT PANEL / LH SIDE MID-RANGE SPEAKER – RH FASCIA IP30 2-WAY / WHITE INSTRUMENT PANEL / RH SIDE POWER AMPLIFIER TL9 TL10 DB7 12-WAY / WHITE 18-WAY / WHITE FIBER OPTIC CONNECTOR TRUNK / LH SIDE S CC8-10 SCP – B+ CC8-11 BATTERY POWER SUPPLY: B+ O CC8-13 LH FRONT AUDIO – O CC8-14 LH FRONT AUDIO + O CC8-15 RH FRONT AUDIO – O CC8-15 RH FRONT AUDIO + I CC8-17 DIMMER CONTROLLED ILLUMINATION: PWM, 80Hz, GROUND = 0% DUTY CYCLE, B+ = 100% DUTY CYCLE I CC8-18 STEERING WHEEL SWITCHES: STEPPED RESISTANCE O CC8-19 D2B NETWORK WAKE-UP I CC9-01 ANTENNA SG CC9-02 ANTENNA SHIELD D2 CC21-01 D2B NETWORK TRANSMIT STEERING WHEEL AUDIO SWITCHES — — STEERING WHEEL D2 CC21-02 D2B NETWORK RECEIVE SUBWOOFER SPEAKER – LH TL3 2-WAY / WHITE PARCEL SHELF SUBWOOFER SPEAKER – RH TL61 2-WAY / WHITE PARCEL SHELF Power Amplifier TWEETER SPEAKER – LH FRONT Pin Description and Characteristic 2-WAY / WHITE 2-WAY / WHITE LH FRONT DOOR DT3 PT3 TWEETER SPEAKER – LH REAR LT4 2-WAY / WHITE LH REAR DOOR D2B DB7-01 D2B NETWORK TRANSMIT TWEETER SPEAKER – RH FRONT DB7-02 D2B NETWORK RECEIVE 2-WAY / WHITE 2-WAY / WHITE RH FRONT DOOR D2B PT3 DT3 TWEETER SPEAKER – RH REAR RT4 2-WAY / WHITE RH REAR DOOR PG TL9-02 POWER GROUND: GROUND B+ TL9-03 BATTERY POWER SUPPLY: B+ O TL9-05 D2B NETWORK WAKE-UP PG TL9-08 POWER GROUND: GROUND B+ TL9-09 BATTERY POWER SUPPLY: B+ HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) O TL10-02 RH SUBWOOFER AUDIO + CC19 2-WAY / BLACK / AUDIO UNIT ANTENNA CABIN / BEHIND CENTER CONSOLE O TL10-03 LH SUBWOOFER AUDIO – DD3 10-WAY / GREY / DRIVER DOOR HARNESS TO INSTRUMENT PANEL HARNESS CABIN / DRIVER SIDE ‘A’ POST O TL10-04 LH REAR AUDIO + DT1 16-WAY / GREEN / DRIVER DOOR HARNESS TO DRIVER DOOR TRIM HARNESS CABIN / BEHIND DRIVER DOOR TRIM O TL10-05 LH FRONT AUDIO + IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE O TL10-06 RH FRONT AUDIO – IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST O TL10-07 LH FASCIA AUDIO + O TL10-08 RH FASCIA AUDIO – LT1 12-WAY / GREY / LH REAR DOOR HARNESS TO LH REAR DOOR TRIM HARNESS CABIN / LH REAR DOOR TRIM O TL10-10 RH SUBWOOFER AUDIO – PD1 14-WAY / BLUE / CABIN HARNESS TO PASSENGER DOOR HARNESS CABIN / PASSENGER SIDE ‘A’ POST O TL10-11 LH SUBWOOFER AUDIO + PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE O TL10-12 LH REAR AUDIO – PT1 12-WAY / GREY / PASSENGER DOOR HARNESS TO PASSENGER DOOR TRIM HARNESS CABIN / BEHIND PASSENGER DOOR TRIM O TL10-13 RH REAR AUDIO – RL1 6-WAY / GREY / LH REAR DOOR HARNESS TO CABIN HARNESS CABIN / LH ‘B/C’ POST O TL10-14 RH REAR AUDIO + RR1 6-WAY / GREY / RH REAR DOOR HARNESS TO CABIN HARNESS CABIN / RH ‘B/C’ POST O TL10-15 LH FRONT AUDIO – RT1 12-WAY / GREY / RH REAR DOOR HARNESS TO RH REAR DOOR TRIM HARNESS CABIN / RH REAR DOOR TRIM O TL10-16 RH FRONT AUDIO + TL22 16-WAY / GREEN / TELEMATICS HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE O TL10-17 LH FASCIA AUDIO – O TL10-18 RH FASCIA AUDIO + TL31 14-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL GROUNDS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Ground Location G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 In-Car Entertainment: Audiophile In-Car Entertainment: Audiophile WU WU LT1-11 NW 76 B 47 B 48 NR CC8-11 YR 5 I 20.3 Y S + U 20.2 D2B NETWORK: ”WAKE-UP” 20.4 OG O WU + ve TL9-5 TL10-4 S – RW 09.3 I BOF D 2 TL31-4 BOF BOF 16.4 16.3 16.2 U 20.4 20.4 2 W + ve W TL10-5 DB7-1 YR TL31-11 DD3-10 (LHD) PD1-6 (RHD) OG 20.4 WU O CC8-19 WU TL31-1 Y TL31-2 R TL26-1 R DD4-2 (LHD) PD4-2 (RHD) LH FRONT MID-BASS SPEAKER DD4-1 (LHD) PD4-1 (RHD) WU (LHD) RW (RHD) DD3-5 (LHD) Y (LHD) PD1-3 (RHD) WG (RHD) DD3-4 (LHD) PD1-4 (RHD) DT1-11 (LHD) PT1-11 (RHD) W (LHD) WR (RHD) Y (LHD) YR (RHD) DT1-12 (LHD) PT1-12 (RHD) DT3-2 (LHD) PT3-2 (RHD) LH FRONT TWEETER SPEAKER DT3-1 (LHD) PT3-1 (RHD) I CC19-1 CC9-1 BRD TL26-2 BRD CC19-2 WU WU + ve CC9-2 WU TLS46 TL10-7 TL22-7 IP25-2 Y Y – ve Y TLS47 TL10-17 TL22-8 LH FASCIA MID-RANGE SPEAKER IP25-1 R + ve TL10-11 P HEATED REAR WINDOW Y I B COAXIAL CABLES DD3-9 (LHD) PD1-5 (RHD) Y Y – ve TL11-2 AM FM W TL31-10 Y I RL4-1 CC8-7 D2B NETWORK: “WAKE-UP” 6 RLS4 LH REAR MID-BASS SPEAKER 2 D CC8-8 16.1 YU RL1-6 TL10-15 TELEPHONE: MUTE RL4-2 YU D BOF CC21-2 O WU RLS3 DB7-2 2 BG 12.2 20.4 CC21-1 D SECURITY SYSTEM: RADIO REMOVED SENSING 20.4 WU RL1-3 YU TL10-12 CC8-17 WU TL31-3 YU – ve CC8-10 RADIO ILLUMINATION LT4-1 TL9-9 CC8-9 20.3 LH REAR TWEETER SPEAKER B CC8-2 20.2 LT1-12 TL9-3 NR LT4-2 YU YU B Fig. 15.2 LH SUBWOOFER SPEAKER TL3-2 W – ve TL10-3 TL3-1 AM / FM ANTENNA AMPLIFIER W + ve TL10-2 3.01 Κ Ω PHONE, VOICE 1ΚΩ TL10-10 VOLUME + TL61-1 RW + ve RW 261 Ω IP30-2 WG WG TLS49 TL10-8 CASSETTE TL22-10 RH FASCIA MID-RANGE SPEAKER IP30-1 YG MEMORY – 475 Ω TL22-9 WG – ve RW TLS48 TL10-18 154 Ω MEMORY + RH SUBWOOFER SPEAKER TL61-2 Y – ve SW8-6 93.1 Ω VOLUME – SELECT TL31-13 CASSETTE RW RW SW8-3 CC10-1 I B P CC8-18 WG TL31-12 CC8-1 RESISTOR PACK RW (LHD) WU (RHD) PD1-3 (LHD) WG (LHD) DD3-5 (RHD) Y (RHD) WG RW RW 53.5 Ω G15AL PD1-4 (LHD) DD3-4 (RHD) PT1-11 (LHD) DT1-11 (RHD) WR (LHD) W (RHD) YR (LHD) Y (RHD) PT1-12 (LHD) DT1-12 (RHD) PT3-2 (LHD) DT3-2 (RHD) RH FRONT TWEETER SPEAKER PT3-1 (LHD) DT3-1 (RHD) STEERING WHEEL AUDIO SWITCHES AUDIO UNIT ECM: SENSOR GROUND 03.6 03.4 YG 03.2 YG WR + ve PI41-24 IP55-11 (LHD) IP9-3 (RHD) WR TL10-16 TL10-6 B TL5-2 D BOF 20.4 BOF 20.4 2 PD1-5 (LHD) DD3-9 (RHD) YR YR – ve NW 41 WR TL31-8 TL31-9 YR PD1-6 (LHD) DD3-10 (RHD) PD4-2 (LHD) DD4-2 (RHD) RH FRONT MID-BASS SPEAKER PD4-1 (LHD) DD4-1 (RHD) DB2-2 D 2 DB2-1 D2B NETWORK: “WAKE-UP” 20.4 OG TL5-3 B P TL10-14 P TL9-2 BK WG + ve B O WG TL31-5 YR YR – ve TL10-13 P WG TL31-6 WG RRS3 RR1-3 RR4-2 YR RR1-6 YR RRS4 RH REAR MID-BASS SPEAKER RR4-1 TL9-8 TL5-1 G25AL G25BS WG CD AUTOCHANGER WG RT1-11 POWER AMPLIFIER YR RT4-2 YR RT1-12 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Audiophile ICE Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 RT4-1 RH REAR TWEETER SPEAKER Fig. 15.3 COMPONENTS Component Connector(s) Connector Description ARMREST LID SWITCH RC7 3-WAY / BLACK Location REAR SEAT ARMREST AUDIO / VIDEO SELECTOR TL20 TL85 TL86 TL87 20-WAY / BLACK 20-WAY / BLACK 20-WAY / BLACK 20-WAY / BLACK CABIN REAR BULKHEAD / BEHIND REAR SEAT BACK / LH SIDE DVD PLAYER TL32 TL47 4-WAY / NATURAL 13-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / TOP MULTIMEDIA CONTROL PANEL RC1 RC3 RC5 8-WAY / BLACK 20-WAY / BLACK FIBER OPTIC CONNECTOR REAR SEAT ARM REST OR REAR FLOOR CONSOLE NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE TELEVISION SCREEN – LH REAR VL1 20-WAY / GREEN LH FRONT SEAT HEAD REST TELEVISION SCREEN – RH REAR VR1 20-WAY / GREEN RH FRONT SEAT HEAD REST HARNESS IN-LINE CONNECTORS Connector Connector Description CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE RC4 20-WAY / BLACK / TELEMATICS HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS CABIN / BELOW CENTER CONSOLE TL91 20-WAY / BLACK / TELEMATICS HARNESS TO RH REAR TELEVISION HARNESS CABIN / BELOW RH FRONT SEAT TL92 20-WAY / GREEN / TELEMATICS HARNESS TO LH REAR TELEVISION HARNESS CABIN / BELOW LH FRONT SEAT VL2 21-WAY / BLACK / TELEMATICS HARNESS TO LH REAR TELEVISION HARNESS CABIN / BEHIND LH FRONT SEAT BACK FINISHER VR2 21-WAY / BLACK / TELEMATICS HARNESS TO RH REAR TELEVISION HARNESS CABIN / BEHIND RH FRONT SEAT BACK FINISHER GROUNDS Ground Location G18 CABIN / BELOW REAR SEAT / LH SIDE Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Rear In-Car Entertainment RW 70 RW 69 B RC3-1 RC1-04 YU 10 I D2B NETWORK: ”WAKE-UP” DIMMER-CONTROLLED LIGHTING RC3-3 B RC3-2 RC1-07 20.4 RC3-4 RC3-5 OG O RC3-6 RC1-6 09.2 RC3-7 RC3-8 RW I RC3-9 RC1-01 20.4 RC3-10 RC3-11 BOF D RC3-12 2 RC5-01 20.4 BOF RC3-13 D RC3-14 2 RC5-02 RC3-15 RC3-16 68 RC3-17 RW RW RC7-3 RC7-1 I RC3-18 RC1-03 RC3-20 ARMREST LID SWITCH RC3-19 RC3-E RC1-08 O OG BRD R RU RG RW W WB B WU B WG B WR Y BRD YB BRD YG BRD O OG BRD R RU RG RW W WB B WU B WG B WR Y BRD YB BRD YG BRD RC4-1 RC4-3 RC4-2 RC4-4 RC4-5 RC4-6 RC4-7 RC4-8 RC4-9 RC4-10 RC4-11 RC4-12 RC4-13 RC4-14 RC4-15 RC4-16 RC4-17 RC4-18 RC4-20 RC4-19 RC4-E B B B TLS6 RC2-5 TL20-8 B TL86-1 TL86-3 TL86-2 TL86-4 TL86-5 TL86-6 TL86-7 TL86-8 TL86-9 TL85-1 TL86-10 TL85-2 TL86-11 TL85-3 TL86-12 TL85-4 TL86-13 TL85-5 TL86-14 TL85-7 TL86-15 TL85-6 TL86-16 TL85-8 TL86-17 TL85-10 TL86-18 TL85-11 TL86-20 TL85-12 TL86-19 TL85-13 TL86-E TL85-14 TL85-15 TL20-10 TL85-9 TL85-16 B TL85-17 MULTIMEDIA CONTROL PANEL G18BL TL85-18 TL85-19 TL85-20 NR 93 S RW 67 YR BRD YB YU BRD YG O OG OY BRD B TL47-7 TL32-2 TL47-6 TL47-13 TL47-12 TL47-8 TL47-3 TL47-9 B B TLS6 TL47-5 P TL47-10 TL32-4 TL85-E TL20-20 B TL66-12 TL66-8 TL87-1 TL66-3 TL87-2 TL66-9 TL87-3 TL66-5 TL87-4 TL66-10 TL87-5 TL66-E TL87-7 TL87-10 TL87-12 TL29-6 TL29-4 TL29-19 TL87-13 K W R W BRD W N W BRD W TL20-3 TL87-14 TL20-4 TL87-15 TL20-2 TL87-9 TL20-1 TL87-16 TL20-6 TL87-17 TL20-5 TL87-18 TL87-19 TL87-20 NAVIGATION CONTROL MODULE NOTE: Refer to Figs. 16.7 and 16.8 for Telematics Display power supplies and grounds. CC11-3 CC11-8 CC11-2 CC11-1 CC11-9 CC11-7 TL87-E K W R W N W CC2-13 CC2-14 BRD W CC2-15 W BRD W BRD CC2-16 BRD W CC2-17 K W R W N W CC2-18 TELEMATICS DISPLAY 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E TL92-4 TL92-5 TL92-7 TL92-6 TL92-8 TL92-10 TL92-11 TL92-12 TL92-13 TL92-14 TL92-15 TL92-9 TL92-16 TL92-17 TL92-18 TL92-19 TL92-20 TL92-E VL2-2 VL2-3 VL2-4 VL2-5 VL2-7 VL2-6 VL2-8 VL2-10 VL2-11 VL2-12 VL2-13 VL2-14 VL2-15 VL2-9 VL2-16 VL2-17 VL2-18 VL2-19 VL2-20 YR YU YR BK YB BRD B N G O R B BRD RW BRD RG OG OY UY O BRD VL2-E VL1-1 VL1-2 VL1-3 VL1-4 VL1-5 VL1-7 VL1-6 VL1-8 VL1-10 VL1-11 VL1-12 VL1-13 VL1-14 VL1-15 VL1-9 VL1-16 VL1-17 VL1-18 VL1-19 VL1-20 VL1-E TL66-13 TL87-11 TL29-17 TL92-3 VL2-1 TL66-6 DVD PLAYER TL29-18 TL92-2 YR YU YR BK YB BRD B N G O R B BRD RW BRD RG OG OY UY O BRD LH REAR TELEVISION SCREEN TL87-8 TL29-5 TL92-1 DVD EJECT TL87-6 NOTE: Refer to Figs. 16.7 and 16.8 for Navigation Control Module power supplies and grounds. YR YU YR BK YB BRD B N G O R B BRD RW BRD RG OG OY UY O BRD TL66-7 TL47-E G18BL Rear In-Car Entertainment YG YB YR BK YU BRD U N G O R GB BRD RW BRD RG OG OY UY U BRD TL91-1 TL91-2 TL91-3 TL91-4 TL91-5 TL91-7 TL91-6 TL91-8 TL91-10 TL91-11 TL91-12 TL91-13 TL91-14 TL91-15 TL91-9 TL91-16 TL91-17 TL91-18 TL91-19 TL91-20 TL91-E YG YB YR BK YU BRD U N G O R GB BRD RW BRD RG OG OY UY U BRD VR2-1 VR2-2 VR2-3 VR2-4 VR2-5 VR2-7 VR2-6 VR2-8 VR2-10 VR2-11 VR2-12 VR2-13 VR2-14 VR2-15 VR2-9 VR2-16 VR2-17 VR2-18 VR2-19 VR2-20 VR2-E YG YB YR BK YU BRD U N G O R GB BRD RW BRD RG OG OY UY U BRD VR1-1 VR1-2 VR1-3 VR1-4 VR1-5 VR1-7 VR1-6 VR1-8 VR1-10 VR1-11 VR1-12 VR1-13 VR1-14 VR1-15 VR1-9 VR1-16 VR1-17 VR1-18 VR1-19 VR1-20 VR1-E RH REAR TELEVISION SCREEN TL20-13 TL20-14 TL20-12 TL20-11 TL20-16 TL20-15 AUDIO / VIDEO SELECTOR I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Rear ICE Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 15.3 Fig. 16.1 CONTROL MODULE PIN-OUT INFORMATION Audio Unit I Pin Description and Characteristic COMPONENTS CC8-07 TELEPHONE MUTE SIGNAL Component Connector(s) Connector Description Location AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE CELLULAR PHONE MODULE TL7 TL94 DB3 32-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / BOTTOM Cellular Phone Module Pin Description and Characteristic D2 DB3-01 D2B NETWORK RECEIVE D2 DB3-02 D2B NETWORK TRANSMIT O TL7-01 PHONE BATTERY CHARGING SUPPLY O TL7-03 PHONE ON /OFF (RESPONSE TO INCOMING AUDIO) O TL7-04 MUTE COMMAND – TL7-07 TRANSMIT – TL7-08 RECEIVE HANDSET RECEIVER PH2 10-WAY / TELEPHONE CENTER CONSOLE NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP PG TL7-09 POWER GROUND: GROUND ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF SG TL7-11 MICROPHONE SHIELD: GROUND TELEMATICS DISPLAY TL7-12 BATTERY POWER SUPPLY: B+ 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE B+ CC12 CC13 CC14 CC15 CC16 TELEPHONE ANTENNA – ROW TL56 2-WAY / BLACK REAR BUMPER – LH SIDE B+ TL7-13 BATTERY POWER SUPPLY: B+ B+ TL7-14 IGNITION SWITCHED POWER SUPPLY (I): B+ I TL7-17 MICROPHONE + I TL7-18 MICROPHONE – D TL7-20 TELEPHONE SERIAL COMMUNICATIONS DATA D TL7-22 TELEPHONE SERIAL COMMUNICATIONS DATA I TL7-23 D2B NETWORK WAKE-UP – TL7-24 COMPUTER Connector Connector Description I TL7-25 POWER GROUND: GROUND CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE I TL7-26 TELEPHONE LOGIC GROUND: GROUND RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST I TL7-29 IGNITION SWITCHED POWER SUPPLY (II): B+ RF26 8-WAY / BLACK / TELEMATICS HARNESS TO ROOF HARNESS CABIN / LH ‘D’ POST TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL HARNESS IN-LINE CONNECTORS Location NOTE: Refer to the Appendix at the rear of this book for Network Messages. GROUNDS Ground Location G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Telephone System: ROW 64 RW Telephone System: ROW B TL7-12 65 RW B TL7-13 7 YU I 49 WR II 20.4 B TL7-14 B TL7-29 BOF D 2 DB3-1 20.4 TL94-1 D 20.4 TL56-1 BRD 2 DB3-2 D2B NETWORK: ”WAKE UP” R I BOF TL56-2 TL94-2 OG TELEPHONE ANTENNA O TL7-23 U I TL2-13 W O N TL7-1 NAVIGATION CONTROL MODULE W O O TL7-3 U I U U CC8-7 O TLS4 CC1-19 TL7-4 NOTE: TLS4 – Navigation vehicles only. MUTE O TL7-20 R TL7-22 U CC1-17 PH2-6 TL18-6 WB U CC12-10 PH2-5 TL18-5 Y D I PH2-8 TL18-8 G D AUDIO UNIT PH2-4 TL18-4 W B WB TL7-26 PH2-7 TL18-7 U U TL7-8 TELEMATICS DISPLAY PH2-2 TL18-2 G G TL7-24 PH2-3 TL18-3 Y Y TL7-7 G O RF3-12 RF26-2 BRD W BRD HANDSET RECEIVER W RF26-3 RF3-11 PH2-9 TL7-18 W TL7-11 Y MICROPHONE TL18-9 I Y RF26-1 I TL7-17 BK P ROOF CONSOLE TL7-9 BK P TL7-25 BK TLS7 G25AL CELLULAR PHONE MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: ROW Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 16.1 Fig. 16.2 CONTROL MODULE PIN-OUT INFORMATION Audio Unit I Pin Description and Characteristic COMPONENTS CC8-07 TELEPHONE MUTE SIGNAL Component Connector(s) Connector Description Location AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE CELLULAR PHONE MODULE TL7 TL94 DB3 32-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / BOTTOM HANDSET TL45 TL48 2-WAY / BLACK 10-WAY / TELEPHONE CENTER CONSOLE NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP Cellular Phone Module Pin Description and Characteristic D2 DB3-01 D2B NETWORK RECEIVE D2 DB3-02 D2B NETWORK TRANSMIT O TL7-01 PHONE BATTERY CHARGING SUPPLY O TL7-02 HANDS FREE AUDIO TO PHONE O TL7-03 PHONE ON /OFF (RESPONSE TO INCOMING AUDIO) O TL7-04 MUTE COMMAND I TL7-05 MANUAL TEST DATA I TL7-06 PHONE BATTERY VOLTAGE PG TL7-09 POWER GROUND: GROUND ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF SG TL7-10 ANALOG GROUND: GROUND TELEMATICS DISPLAY TL7-11 MICROPHONE SHIELD: GROUND B+ TL7-12 BATTERY POWER SUPPLY: B+ B+ TL7-13 BATTERY POWER SUPPLY: B+ B+ TL7-14 IGNITION SWITCHED POWER SUPPLY (I): B+ 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE SG CC12 CC13 CC14 CC15 CC16 I TL7-17 MICROPHONE + TELEPHONE ANTENNA – NAS TL56 2-WAY / BLACK PARCEL SHELF / LH SIDE I TL7-18 MICROPHONE – D TL7-20 TELEPHONE SERIAL COMMUNICATIONS DATA D TL7-21 TELEPHONE SERIAL COMMUNICATIONS DATA D TL7-22 TELEPHONE SERIAL COMMUNICATIONS DATA Connector Connector Description I TL7-23 D2B NETWORK WAKE-UP CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE I TL7-25 POWER GROUND: GROUND RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST I TL7-26 TELEPHONE LOGIC GROUND: GROUND RF26 8-WAY / BLACK / TELEMATICS HARNESS TO ROOF HARNESS CABIN / LH ‘D’ POST I TL7-29 IGNITION SWITCHED POWER SUPPLY (II): B+ TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL HARNESS IN-LINE CONNECTORS NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location GROUNDS Ground Location G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Telephone System: NAS 64 RW Telephone System: NAS B TL7-12 65 RW B TL7-13 7 YU I 49 WR II 20.4 B TL7-14 B TL7-29 BOF D 2 DB3-1 20.4 BOF D 2 DB3-2 D2B NETWORK: ”WAKE UP” 20.4 OG O RU O TL7-23 TL7-1 TL48-3 BG TL7-26 U I TL48-2 WG O TL2-13 TL7-2 TL48-8 YU O TL7-3 NAVIGATION CONTROL MODULE TL48-9 Y I TL7-6 U I U U TLS4 CC1-19 CC8-7 O MUTE TL48-1 U I TL7-5 TL7-4 TL48-10 NOTE: TLS4 – Navigation vehicles only. BO TL7-10 AUDIO UNIT TL45-1 TL7-20 U I U CC12-10 TL48-5 TL7-22 BRD TL56-1 TL56-2 TELEPHONE ANTENNA TL48-6 W D TL7-21 TELEMATICS DISPLAY TL45-2 G D CC1-17 R TL48-7 YB D TL48-4 HANDSET G G RF3-12 RF26-2 BRD W W BRD W RF26-3 W Y RF3-11 RF26-1 O TL68-13 W BRD W TL7-11 G TL68-1 I TL7-18 TL68-15 TL68-2 Y MICROPHONE N TL68-12 Y TL68-3 I TL7-17 BK P ROOF CONSOLE TL7-9 BK P TL7-25 BK TLS7 G25AL CELLULAR PHONE MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: NAS Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 16.2 Fig. 16.3 CONTROL MODULE PIN-OUT INFORMATION Audio Unit Pin Description and Characteristic COMPONENTS I CC8-07 TELEPHONE MUTE SIGNAL Component Connector(s) Connector Description Location I CC8-08 AUDIO UNIT SECURITY SYSTEM GROUND SENSING: GROUND WHEN AUDIO UNIT INSTALLED AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE CELLULAR PHONE MODULE TL7 TL94 DB3 32-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / BOTTOM HANDSET RECEIVER PH2 10-WAY / TELEPHONE CENTER CONSOLE MICROPHONE – LH REAR TL55 4-WAY / BLACK ROOF / LH REAR MICROPHONE – RH REAR TL55 4-WAY / BLACK ROOF / RH REAR NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP REAR HANDSET RECEIVER PH1 10-WAY / TELEPHONE REAR SEAT ARM REST OR REAR FLOOR CONSOLE MICROPHONE (ROOF CONSOLE) RF3 20-WAY / BLACK CABIN ROOF STEERING WHEEL AUDIO SWITCHES — — STEERING WHEEL TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE TELEPHONE ANTENNA – ROW TL56 2-WAY / BLACK REAR BUMPER – LH SIDE VOICE ACTIVATION MODULE TL68 DB4 22-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / SECOND FROM BOTTOM D2 CC21-01 D2B NETWORK TRANSMIT D2 CC21-02 D2B NETWORK RECEIVE Cellular Phone Module Pin Description and Characteristic D2 DB3-01 D2B NETWORK RECEIVE D2 DB3-02 D2B NETWORK TRANSMIT O TL7-01 PHONE BATTERY CHARGING SUPPLY O TL7-03 PHONE ON /OFF (RESPONSE TO INCOMING AUDIO) O TL7-04 MUTE COMMAND – TL7-07 TRANSMIT – TL7-08 RECEIVE PG TL7-09 POWER GROUND: GROUND SG TL7-11 MICROPHONE SHIELD: GROUND B+ TL7-12 BATTERY POWER SUPPLY: B+ B+ TL7-13 BATTERY POWER SUPPLY: B+ B+ TL7-14 IGNITION SWITCHED POWER SUPPLY (I): B+ I TL7-17 MICROPHONE + I TL7-18 MICROPHONE – D TL7-20 TELEPHONE SERIAL COMMUNICATIONS DATA D TL7-22 TELEPHONE SERIAL COMMUNICATIONS DATA D2B NETWORK WAKE-UP I TL7-23 – TL7-24 COMPUTER I TL7-25 POWER GROUND: GROUND I TL7-26 TELEPHONE LOGIC GROUND: GROUND I TL7-29 IGNITION SWITCHED POWER SUPPLY (II): B+ HARNESS IN-LINE CONNECTORS Voice Activation Module Connector Connector Description CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE Pin Description and Characteristic PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE D2 DB4–01 D2B NETWORK TRANSMIT RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST D2 DB4–02 D2B NETWORK RECEIVE RF26 8-WAY / BLACK / TELEMATICS HARNESS TO ROOF HARNESS CABIN / LH ‘D’ POST TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL I TL68–01 MICROPHONE + SG TL68–02 MICROPHONE SHIELD O TL68–03 MICROPHONE + GROUNDS B+ TL68–06 IGNITION SWITCHED POWER SUPPLY (II) (START / RUN STATUS) Ground Location G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER SG TL68–07 MICROPHONE SHIELD B+ TL68–08 IGNITION SWITCHED POWER SUPPLY (I) SG TL68–09 MICROPHONE SHIELD PG TL68–11 POWER GROUND I TL68–12 MICROPHONE – O TL68–13 MICROPHONE – O TL68–14 D2B NETWORK WAKE UP SG TL68–15 MICROPHONE SHIELD I TL68–18 MICROPHONE + I TL68–19 MICROPHONE – I TL68–20 MICROPHONE + I TL68–21 MICROPHONE – B+ TL68–22 BATTERY POWER SUPPLY FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 ECM: SENSOR GROUND 03.6 03.4 Telephone System with Voice Control: ROW YG 03.2 Fig. 16.3 Telephone System with Voice Control: ROW YG PI41-24 IP55-11 (LHD) IP9-3 (RHD) 64 RW B TL7-12 65 RW B TL7-13 7 3.01 Κ Ω 49 1ΚΩ YU I PHONE, VOICE WR II VOLUME + U B I TL7-14 TL2-13 B TL7-29 NAVIGATION CONTROL MODULE 154 Ω MEMORY + 261 Ω D2B NETWORK: ”WAKE UP” CASSETTE OG O U TL7-23 U YG MEMORY – 475 Ω 20.4 I CC1-19 CC8-7 SW8-6 93.1 Ω VOLUME – AUDIO UNIT 53.5 Ω SELECT CASSETTE MUTE SW8-3 U O U U TLS4 TL7-4 CC1-17 I CC12-10 RESISTOR PACK NOTE: TLS4 – Navigation vehicles only. STEERING WHEEL AUDIO SWITCHES TELEMATICS DISPLAY RW I RW CC8-18 BOF D TL94-1 20.4 2 20.4 TL56-1 BRD TL56-2 TL94-2 BOF D 2 CC21-1 TELEPHONE ANTENNA DB3-1 BOF D R I CC10-1 20.4 2 20.4 BOF D 2 DB3-2 CC21-2 I U 20.4 OG G G G RF26-2 BRD W W BRD RF26-1 RF3-11 O O TL68-13 TL68-2 TL68-15 TL18-9 I BRD TLS30 TL7-20 W TL18-5 Y Y D TLS29 TL7-22 PH2-9 O PH2-5 R TL18-6 PH2-6 TL7-11 Y O TL68-1 G G I TL7-18 W Y Y MICROPHONE I TL68-12 W RF26-3 Y TL7-7 D RF3-12 PH2-3 TL18-3 Y O TL68-14 PH2-2 TL18-2 G TL68-6 TL7-24 D2B NETWORK: ”WAKE UP” PH2-8 TL18-8 TL7-8 DB4-2 B PH2-4 W U 20.4 2 WR II TLS27 TL7-3 BOF D N TL18-4 O O O 20.4 DB4-1 B TL68-8 48 BOF D 2 YU 8 AUDIO UNIT TLS31 TL7-1 B TL68-22 W W O RW 66 TL68-3 I W WB TL7-17 TL7-26 WB TLS28 B TL18-7 PH2-7 ROOF CONSOLE R HANDSET RECEIVER R TL55-1 I TL68-18 BRD W N TL68-7 G BRD TL55-2 N PH1-4 TL81-4 I W TL68-19 W PH1-8 TL81-8 LH REAR MICROPHONE** O R R TL55-3 BRD TL55-4 PH1-5 TL81-5 I TL68-20 R TL68-9 B W R PH1-6 TL81-6 Y BRD O I BK P TL68-21 B TL81-7 TL68-11 RH REAR MICROPHONE** **NOTE: Rear handset components, wiring and circuitry – Multi-zone Voice vehicles only. G25AR VOICE ACTIVATION MODULE REAR HANDSET RECEIVER ** BK P **NOTE: Rear handset components, wiring and circuitry – Multi-zone Voice vehicles only. PH1-7 TL7-9 BK P TL7-25 BK TLS7 G25AL CELLULAR PHONE MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: ROW Voice Vehicles (except Japan) VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 16.4 CONTROL MODULE PIN-OUT INFORMATION Audio Unit Pin Description and Characteristic COMPONENTS I CC8-07 TELEPHONE MUTE SIGNAL Component Connector(s) Connector Description Location I CC8-08 AUDIO UNIT SECURITY SYSTEM GROUND SENSING: GROUND WHEN AUDIO UNIT INSTALLED AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE CELLULAR PHONE MODULE TL7 TL94 DB3 32-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / BOTTOM D2 CC21-01 D2B NETWORK TRANSMIT D2 CC21-02 D2B NETWORK RECEIVE Cellular Phone Module HANDSET RECEIVER PH2 10-WAY / TELEPHONE CENTER CONSOLE NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP PHONE ON /OFF (RESPONSE TO INCOMING AUDIO) ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF TL7-04 MUTE COMMAND STEERING WHEEL AUDIO SWITCHES — — STEERING WHEEL TL7-07 TRANSMIT TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE Pin Description and Characteristic D2 DB3-01 D2B NETWORK RECEIVE D2 DB3-02 D2B NETWORK TRANSMIT O TL7-01 PHONE BATTERY CHARGING SUPPLY O TL7-03 O – – TL7-08 RECEIVE PG TL7-09 POWER GROUND: GROUND SG TL7-11 MICROPHONE SHIELD: GROUND B+ TL7-12 BATTERY POWER SUPPLY: B+ B+ TL7-13 BATTERY POWER SUPPLY: B+ TELEPHONE ANTENNA – NAS TL56 2-WAY / BLACK PARCEL SHELF / LH SIDE B+ TL7-14 IGNITION SWITCHED POWER SUPPLY (I): B+ VOICE ACTIVATION MODULE TL7-17 MICROPHONE + 22-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / SECOND FROM BOTTOM I TL68 DB4 I TL7-18 MICROPHONE – D TL7-20 TELEPHONE SERIAL COMMUNICATIONS DATA D TL7-22 TELEPHONE SERIAL COMMUNICATIONS DATA I TL7-23 D2B NETWORK WAKE-UP – TL7-24 COMPUTER I TL7-25 POWER GROUND: GROUND I TL7-26 TELEPHONE LOGIC GROUND: GROUND I TL7-29 IGNITION SWITCHED POWER SUPPLY (II): B+ HARNESS IN-LINE CONNECTORS Voice Activation Module Connector Connector Description CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS Location CABIN / BELOW CENTER CONSOLE CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST Pin Description and Characteristic RF26 8-WAY / BLACK / TELEMATICS HARNESS TO ROOF HARNESS CABIN / LH ‘D’ POST D2 DB4–01 D2B NETWORK TRANSMIT TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL D2 DB4–02 D2B NETWORK RECEIVE I TL68–01 MICROPHONE + GROUNDS SG TL68–02 MICROPHONE SHIELD Ground Location G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER O TL68–03 MICROPHONE + B+ TL68–06 IGNITION SWITCHED POWER SUPPLY (II) (START / RUN STATUS) B+ TL68–08 IGNITION SWITCHED POWER SUPPLY (I) PG TL68–11 POWER GROUND I TL68–12 MICROPHONE – O TL68–13 MICROPHONE – O TL68–14 D2B NETWORK WAKE UP SG TL68–15 MICROPHONE SHIELD B+ TL68–22 BATTERY POWER SUPPLY FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. NOTE: Refer to the Appendix at the rear of this book for Network Messages. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 ECM: SENSOR GROUND 03.6 03.4 Telephone System with Voice Control: NAS YG 03.2 Telephone System with Voice Control: NAS YG PI41-24 IP55-11 (LHD) IP9-3 (RHD) 64 RW B TL7-12 65 RW U B TL7-13 7 3.01 Κ Ω YU I PHONE, VOICE 49 1ΚΩ B TL7-14 WR II VOLUME + NAVIGATION CONTROL MODULE B TL7-29 U MEMORY + 261 Ω D2B NETWORK: ”WAKE UP” CASSETTE 20.4 I TL2-13 154 Ω OG U CC1-19 O I CC8-7 TL7-23 YG MEMORY – 475 Ω Fig. 16.4 AUDIO UNIT SW8-6 93.1 Ω VOLUME – 53.5 Ω MUTE SELECT U O U U TLS4 TL7-4 CASSETTE CC1-17 I CC12-10 NOTE: TLS4 – Navigation vehicles only. SW8-3 TELEMATICS DISPLAY RESISTOR PACK STEERING WHEEL AUDIO SWITCHES RW I RW CC8-18 CC10-1 W O N TL18-4 TL7-1 BOF D 2 20.4 20.4 20.4 20.4 BOF CC21-1 BOF D 2 D 2 O D D DB3-1 BOF CC21-2 TL18-8 TL7-3 2 TL18-5 RW 8 48 2 BOF D 2 WR W WB 20.4 TL18-7 20.4 OG TL18-2 TL18-3 TL7-24 G G RF26-2 BRD W W BRD TL68-13 TL68-2 TL68-15 RF26-1 I BRD TL18-9 TL68-3 I HANDSET RECEIVER TL7-17 BK P TL7-9 BK P BK P TL68-11 TL7-25 BK TLS7 G25AL G25AR VOICE ACTIVATION MODULE 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E CELLULAR PHONE MODULE I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data TL56-1 TL56-2 TELEPHONE ANTENNA PH2-9 TL7-11 ROOF CONSOLE 1 TL45-2 W Y O TL68-1 TL7-7 I PH2-3 BRD TL7-18 W Y Y RF3-11 O O W RF26-3 MICROPHONE I TL68-12 TL45-1 Y Y RF3-12 R PH2-2 G G O TL68-14 PH2-7 U U TL68-6 TL7-8 D2B NETWORK: ”WAKE UP” B WB TL7-26 DB4-2 B PH2-6 20.4 DB4-1 B TL68-8 II BOF D YU I AUDIO UNIT TL18-6 TL7-22 B TL68-22 PH2-5 R Y D 66 PH2-8 O G TL7-20 DB3-2 PH2-4 W O VARIANT: NAS Voice Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 16.5 COMPONENTS Component Connector(s) Connector Description Location NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP NAVIGATION GPS ANTENNA TL8 2-WAY / BLACK PARCEL SHELF TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE GROUNDS Ground Location G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Navigation System R 50 Navigation System B TL2-1 R 11 I R B TL2-11 TL8-1 BRD TL37-2 BOF 20.4 TL37-1 TL8-2 D 2 NAVIGATION GPS ANTENNA DB6-1 BOF 20.4 D 2 DB6-2 D2B NETWORK: ”WAKE UP” 20.4 20.3 20.2 OG O TL2-3 Y S + TL2-4 20.3 U 20.2 S – Y TL29-7 16.4 TELEPHONE: MUTE 16.3 16.2 U 16.1 R B Y TL2-14 CC1-7 CC12-4 U I TL2-13 R B U TL29-20 51 CC12-1 CC1-8 12 I CC12-2 CC12-15 RW I 09.3 DIMMER–CONTROLLED LIGHTING 16.1 16.2 12.2 SECURITY GROUND SENSING CC12-9 Y Y TL30-1 CC1-1 CC12-19 G TL30-7 O CC12-21 W CC1-4 W W BRD W CC1-5 CC12-11 BK TL2-2 P CC12-12 G25AR G15AR TELEMATICS DISPLAY NAVIGATION CONTROL MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E CC12-16 CC12-22 BK P TELEPHONE: MUTE W TL30-8 BRD BW I CC1-3 W 16.4 CC12-20 O TL30-3 16.3 CC12-10 CC1-2 TL30-2 U I G I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Navigation Vehicles (except Japan) VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 16.5 Fig. 16.6 COMPONENTS Component Connector(s) Connector Description Location NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP NAVIGATION GPS ANTENNA TL8 2-WAY / BLACK PARCEL SHELF TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE TELEVISION ANTENNA 1 — — PARCEL SHELF TELEVISION ANTENNA 2 — — PARCEL SHELF TELEVISION ANTENNA 3 — — RH ‘B/C’ POST / UPPER TELEVISION ANTENNA 4 — — RH ‘B/C’ POST / UPPER TV ANTENNA AMPLIFIER 1 TL51 2-WAY / BLACK PARCEL SHELF TV ANTENNA AMPLIFIER 2 TL52 2-WAY / BLACK PARCEL SHELF TV ANTENNA AMPLIFIER 3 TL53 2-WAY / BLACK RH ‘B/C’ POST / UPPER TV ANTENNA AMPLIFIER 4 TL54 2-WAY / BLACK RH ‘B/C’ POST / UPPER HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CC5 8-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE GROUNDS Ground Location G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Navigation System with Television R 50 R B TL2-1 TL37-1 R 11 I Navigation System with Television B TL8-1 BRD TL37-2 TL8-2 TL2-11 BOF 20.4 NAVIGATION GPS ANTENNA D 2 DB6-1 BOF 20.4 D 2 DB6-2 R B 51 CC12-1 D2B NETWORK: ”WAKE UP” 20.4 20.3 20.2 OG O TL2-3 Y S + Y TL29-7 S – 16.4 16.3 16.2 U 16.1 DIMMER–CONTROLLED LIGHTING 16.1 16.2 12.2 SECURITY GROUND SENSING CC12-4 U TL29-20 09.2 CC12-9 CC1-7 U TL2-14 TELEPHONE: MUTE I RW I Y U 20.2 12 CC12-2 TL2-4 20.3 R B U I CC1-8 CC12-15 BW I Y Y TL29-2 CC12-16 CC1-9 G TL29-15 CC1-10 CC12-17 O O TL29-14 CC1-11 CC12-6 W VIDEO WB W BRD W TL29-16 CC5-2 CC13-2 CC1-13 W BRD TV ANTENNA AMPLIFIER 1 W R R CC5-3 CC14-1 BRD Y Y TV ANTENNA AMPLIFIER 2 G CC1-2 CC12-20 O O TL30-2 CC1-3 CC12-21 W R I W TL30-8 BRD CC12-22 TL30-3 W BRD CC1-5 TV ANTENNA AMPLIFIER 3 CC12-11 R BRD CC16-2 BK BK TL2-2 7 63 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E TL54-1 BRD CC5-8 TL54-2 TV ANTENNA AMPLIFIER 4 P CC12-12 G15AR NAVIGATION CONTROL MODULE TELEVISION ANTENNA 3 R CC5-7 CC16-1 G25AR TL53-2 W I P TL53-1 BRD CC5-6 CC15-2 W TELEVISION ANTENNA 2 R CC5-5 CC15-1 CC1-4 BRD TL52-2 CC12-19 G W TL52-1 BRD CC5-4 CC14-2 CC1-1 TL30-7 TELEVISION ANTENNA 1 CC12-8 I AUDIO TL51-2 CC12-18 CC1-14 TL30-1 TL51-1 BRD BRD CC12-5 WB R CC5-1 CC13-1 CC1-12 TL29-1 R I W TL29-3 Fig. 01.1 TELEPHONE: MUTE CC12-7 G 6 16.4 I TL2-13 1 16.3 CC12-10 TELEVISION ANTENNA 4 TELEMATICS DISPLAY I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Navigation Vehicles with TV (except Japan) VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 16.6 Fig. 16.7 COMPONENTS Component Connector(s) Connector Description Location NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP NAVIGATION GPS ANTENNA TL8 2-WAY / BLACK PARCEL SHELF ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF TELEMATICS DISPLAY CC12 CC13 CC14 CC15 CC16 22-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK 2-WAY / BLACK CENTER CONSOLE TELEVISION ANTENNA 1 — — PARCEL SHELF TELEVISION ANTENNA 2 — — PARCEL SHELF TELEVISION ANTENNA 3 — — RH ‘B/C’ POST / UPPER TELEVISION ANTENNA 4 — — RH ‘B/C’ POST / UPPER TV ANTENNA AMPLIFIER 1 TL51 2-WAY / BLACK PARCEL SHELF TV ANTENNA AMPLIFIER 2 TL52 2-WAY / BLACK PARCEL SHELF TV ANTENNA AMPLIFIER 3 TL53 2-WAY / BLACK RH ‘B/C’ POST / UPPER TV ANTENNA AMPLIFIER 4 TL54 2-WAY / BLACK RH ‘B/C’ POST / UPPER VEHICLE INFORMATION ANTENNA TL63 2-WAY / BLACK INSTRUMENT PANEL / LH SIDE VEHICLE INFORMATION CONTROL MODULE TL16 TL36 TL64 10-WAY / NATURAL 2-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / FORWARD OF MODULE STACK VEHICLE INFORMATION SENSOR CR108 2-WAY / BLACK UPPER LH ‘A’ POST HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CC5 8-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE RF26 8-WAY / BLACK / TELEMATICS HARNESS TO ROOF HARNESS CABIN / LH ‘D’ POST TL88 2-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS CABIN / BELOW LH FRONT SEAT GROUNDS Ground Location G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G25 TRUNK / LH SIDE / ADJACENT TO CD AUTOCHANGER Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Navigation System: Japan 50 R R B TL2-1 11 B I 20.4 TL37-1 R Fig. 16.7 Navigation System: Japan TL8-1 BRD TL37-2 TL8-2 TL2-11 NAVIGATION GPS ANTENNA BOF D 2 DB6-1 20.4 BOF D 2 DB6-2 R B 51 CC12-1 D2B NETWORK: ”WAKE UP” 20.4 20.3 20.2 OG O B TL2-3 20.2 Y S + U Y TL29-7 S – 16.3 16.2 16.1 U CC12-15 RF26-2 BRD MICROPHONE TL30-12 CC1-10 RF26-1 CC12-17 CC1-11 CC12-6 W VIDEO TL29-3 TL30-6 WB W BRD W TL29-16 CC13-2 W BRD TV ANTENNA AMPLIFIER 1 W CC1-14 I CC14-1 Y Y TL30-1 TL30-5 TL64-1 TL63-1 AUDIO TL30-4 TL30-10 CC1-3 CC12-21 TL30-8 CC15-1 CC1-4 BRD N CR108-1 N TL88-1 W TL30-9 BRD TL30-3 W W BRD CC1-5 CC12-11 CC16-1 CC16-2 BK BK P TL2-2 TL16-5 63 Fig. 01.2 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage CC5-8 TELEMATICS DISPLAY + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data TL54-2 TV ANTENNA AMPLIFIER 4 P G15AR NAVIGATION CONTROL MODULE G25AR 95 BRD CC12-12 G25AR VEHICLE INFORMATION CONTROL MODULE 1 BK TL54-1 CC5-7 BRD P 64 R R I TL36-2 Fig. 01.1 TELEVISION ANTENNA 3 I VEHICLE INFORMATION SENSOR 6 TL53-2 CC5-6 TV ANTENNA AMPLIFIER 3 BRD TL88-2 BRD W TL36-1 BRD CR108-2 W TL53-1 CC5-5 BRD CC12-22 TELEVISION ANTENNA 2 R R I W CC15-2 W TL16-7 7 CC12-20 W TL16-2 TV ANTENNA AMPLIFIER 2 O TL30-2 K VEHICLE INFORMATION ANTENNA 1 CC1-2 O TL16-1 TL64-2 TL52-2 CC5-4 G TL30-7 W BRD TL63-2 BRD CC12-19 G R TL16-6 I CC14-2 CC1-1 TL52-1 CC5-3 BRD B R R R I TL16-4 TELEVISION ANTENNA 1 CC12-8 B YU TL51-2 CC5-2 CC12-18 TL16-3 9 TL51-1 BRD BRD CC12-5 CC1-13 R CC5-1 CC13-1 CC1-12 TL29-1 R I W WB RW TELEPHONE: MUTE O TL29-14 I ROOF CONSOLE 71 SECURITY GROUND SENSING 16.4 CC12-7 O Y RF3-11 12.2 16.3 G TL29-15 W RF26-3 Y 16.2 CC12-16 CC1-9 G I TL30-11 W BW I Y TL29-2 W 16.1 CC12-10 I G BRD U I CC1-8 Y RF3-12 DIMMER–CONTROLLED LIGHTING CC12-4 U TL2-13 G 09.2 CC12-9 CC1-7 U TL29-20 16.4 I RW I Y TL2-14 TELEPHONE: MUTE 12 CC12-2 TL2-4 20.3 R VARIANT: Japan Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 TELEVISION ANTENNA 4 Fig. 17.1 COMPONENTS Component Connector(s) Connector Description CURTAIN AIRBAG IGNITER – DRIVER CR62 2-WAY / YELLOW Location DRIVER SIDE ‘D’ POST / MIDDLE CURTAIN AIRBAG IGNITER – PASSENGER CR33 2-WAY / YELLOW PASSENGER SIDE ‘D’ POST / MIDDLE DUAL AIRBAG IGNITERS – DRIVER SW11 SW12 2-WAY / BLACK 2-WAY / BLACK STEERING WHEEL FRONT IMPACT SENSOR EC50 2-WAY / BLACK ENGINE COMPARTMENT / CENTER FRONT RESTRAINTS CONTROL MODULE CR86 CR87 24-WAY / BLACK 40-WAY / BLACK TRANSMISSION TUNNEL / UNDER CENTER CONSOLE SEAT BELT PRETENSIONER IGNITER – CENTER REAR CR65 2-WAY / YELLOW BEHIND REAR SEAT BACK SEAT BELT PRETENSIONER IGNITER – DRIVER SD19 4-WAY / GREY DRIVER SEAT BELT BUCKLE SEAT BELT PRETENSIONER IGNITER – DRIVER SIDE REAR CR64 2-WAY / YELLOW DRIVER SIDE ‘D’ POST / UPPER SEAT BELT PRETENSIONER IGNITER – PASSENGER SP19 4-WAY / GREY PASSENGER SEAT BELT BUCKLE SEAT BELT PRETENSIONER IGNITER – PASSENGER SIDE REAR CR66 2-WAY / YELLOW PASSENGER SIDE ‘D’ POST / UPPER SEAT POSITION SWITCH – DRIVER SD20 6-WAY / GREY DRIVER SEAT TRACK SIDE AIRBAG IGNITER – DRIVER SD17 2-WAY / BLACK DRIVER SEAT BACK SIDE AIRBAG IGNITER – PASSENGER SP17 2-WAY / BLACK PASSENGER SEAT BACK SIDE IMPACT SENSOR – DRIVER CR60 2-WAY / BLACK DRIVER SIDE ‘B/C’ POST / LOWER SIDE IMPACT SENSOR – DRIVER REAR CR61 2-WAY / BLACK DRIVER SIDE ‘D’ POST / LOWER SIDE IMPACT SENSOR – PASSENGER CR35 2-WAY / BLACK PASSENGER SIDE ‘B/C’ POST / LOWER SIDE IMPACT SENSOR – PASSENGER REAR CR51 2-WAY / BLACK PASSENGER SIDE ‘D’ POST / LOWER HARNESS IN-LINE CONNECTORS Connector Connector Description EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS Location CABIN / RH ‘A’ POST SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT GROUNDS Ground Location G7 CABIN / LH SIDE OF TRANSMISSION TUNNEL G12 CABIN / BELOW DRIVER SEAT Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Advanced Restraints System: Part 1 Advanced Restraints System: Part 1 CASSETTE 20 WU II SERIAL COMMUNICATION 20.3 20.2 CR86-5 B YR IP76-4 CR86-12 W D YU YR YR CR86-1 O CR86-22 SW10-4 SW12-2 CASSETTE Y Y IP76-2 07.1 SW12-1 SW SW8-1 IP76-3 O CR86-19 INSTRUMENT CLUSTER: SEAT BELT AUDIBLE WARNING (CIRCUIT CONTINUED) SW10-3 CASSETTE YR CR86-6 07.1 NB SW8-2 STAGE TWO CR86-11 INSTRUMENT CLUSTER: AIRBAG WARNING (CIRCUIT CONTINUED) YR SB SW8-10 STAGE ONE SW10-1 DRIVER DUAL AIRBAG IGNITERS SW11-1 CASSETTE Y Y IP76-1 CR86-2 CR87-3 NR SW8-9 SW10-2 SW11-2 O CR62-2 N FRONT IMPACT SENSOR DRIVER CURTAIN AIRBAG IGNITER N EC46-19 EC50-2 CR87-19 W OY W EC50-1 EC46-20 CR87-20 CR87-4 CR87-1 CR62-1 RW RW SD16-2 SD17-2 DRIVER SIDE AIRBAG IGNITER NG DRIVER SIDE IMPACT SENSOR CR60-2 BW CR87-27 WU CR60-1 CR87-2 CR87-31 CR87-28 BW SD16-1 SD17-1 GR GR SD16-3 GU GU NR PASSENGER SIDE IMPACT SENSOR CR35-2 SD16-4 CR87-32 CR87-29 SD19-2 DRIVER SEAT BELT PRETENSIONER IGNITER SD19-1 WR CR35-1 CR87-30 CR87-5 RW CR33-2 PASSENGER CURTAIN AIRBAG IGNITER BO DRIVER REAR SIDE IMPACT SENSOR CR61-2 BW CR87-13 U CR87-14 CR61-1 CR33-1 CR87-6 CR87-21 RW RW SP16-2 SP17-2 PASSENGER SIDE AIRBAG IGNITER BW YR PASSENGER REAR SIDE IMPACT SENSOR CR51-2 CR87-15 O SP16-3 DRIVER SEAT POSITION SWITCH H UY SD20-2 SP16-4 CR87-34 SP19-2 WU WU UY SP17-1 WR WR CR87-16 CR51-1 BW SP16-1 CR87-22 CR87-33 SP19-1 CR87-23 SD28-9 U U SD20-1 CR87-35 CR87-24 SD28-10 Y CR64-2 BK BK BK SDS5 SD28-1 H SD19-4 G12AR (G13AR) PASSENGER SEAT BELT PRETENSIONER IGNITER RW Y RW SD19-3 CR87-25 SD28-3 CR64-1 CR87-36 CR87-39 YR DRIVER SEAT BELT SWITCH CR65-2 YR PASSENGER AIRBAG DEACTIVATION LAMP 17.2 CR86-15 BR O CR87-40 CR87-37 CR65-1 YU P CR86-16 CENTER REAR SEAT BELT PRETENSIONER IGNITER YU CR66-2 B DRIVER SIDE REAR SEAT BELT PRETENSIONER IGNITER PASSENGER SIDE REAR SEAT BELT PRETENSIONER IGNITER CR66-1 CR87-38 G7AS (G7AL) RESTRAINTS CONTROL MODULE (Continued Fig. 17.2) 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 17.1 Fig. 17.2 COMPONENTS Component Connector(s) Connector Description Location DUAL AIRBAG IGNITER – PASSENGER IP15 IP56 2-WAY / BLACK 2-WAY / BLACK INSTRUMENT PANEL / PASSENGER SIDE OCCUPANCY SENSING MODULE SP30 26-WAY / BLACK PASSENGER SEAT / UNDER PASSENGER AIRBAG DEACTIVATION INDICATOR LAMP IP68 3-WAY / BLACK INSTRUMENT PANEL / PASSENGER SIDE PASSENGER SEAT BELT TENSION SENSOR SP33 4-WAY / GREY PASSENGER SEAT BELT BUCKLE PASSENGER SEAT WEIGHT PRESSURE SENSOR SP3 3-WAY / BLACK PASSENGER SEAT CUSHION PASSENGER SEAT WEIGHT SENSING MODULE SP2 10-WAY / BLACK PASSENGER SEAT / UNDER RESTRAINTS CONTROL MODULE CR86 CR87 24-WAY / BLACK 40-WAY / BLACK TRANSMISSION TUNNEL / UNDER CENTER CONSOLE SEAT BELT SWITCH – PASSENGER SP19 4-WAY / GREY PASSENGER SEAT BELT BUCKLE SPATIAL SENSOR – CENTER CONSOLE (LHD) CL6 2-WAY / BLACK CENTER CONSOLE SWITCH PACK HOUSING / PASSENGER SIDE SPATIAL SENSOR – CENTER CONSOLE (RHD) CL7 2-WAY / BLACK CENTER CONSOLE SWITCH PACK HOUSING / PASSENGER SIDE SPATIAL SENSOR – HEADLINER INNER RF16 2-WAY / BLACK HEADLINER / ABOVE PASSENGER SEAT / INNER SPATIAL SENSOR – HEADLINER OUTER RF18 2-WAY / BLACK HEADLINER / ABOVE PASSENGER SEAT / OUTER SPATIAL SENSOR – PASSENGER ‘A’ POST CR105 2-WAY / BLACK PASSENGER ‘A’ POST / UPPER HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE IP3 14-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST SP28 20-WAY / BLACK / PASSENGER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW PASSENGER SEAT TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE GROUNDS Ground Location G7 CABIN / LH SIDE OF TRANSMISSION TUNNEL G12 CABIN / BELOW DRIVER SEAT G13 CABIN / BELOW PASSENGER SEAT Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Advanced Restraints System: Part 2 WU 22 II B SP30-22 + – O U C LOCAL U SP30-24 SP28-10 C + CR87-17 SP28-6 SP30-25 BR BR CR105-1 O C LOCAL PASSENGER ”A” POST SPATIAL SENSOR SP28-5 C – CR87-18 SP30-5 GW GW RU SP28-9 CR105-2 Fig. 17.2 Advanced Restraints System: Part 2 SP30-6 CR87-26 RU SP19-3 SP28-3 BK H SP19-4 BK SPS3 BK SP28-1 PASSENGER SEAT BELT SWITCH NW NW CL6-1 (LHD) CL7-1 (RHD) CENTER CONSOLE SPATIAL SENSOR NW CL3-11 Y Y TL93-4 SP28-20 Y CL3-10 CL6-2 (LHD) CL7-2 (RHD) NW NW CC2-22 SP30-3 Y Y CC2-21 TL93-3 SP28-19 SP30-4 CR86-14 BG RF16-1 SP28-18 OG RF2-11 RF16-2 RW SP30-1 OG OG BW RW IP77-1 CR86-13 SP28-17 IP15-1 STAGE TWO BG BG RF2-12 BW IP77-2 IMPACT SENSORS; PASSENGER SEAT BELT SWITCH: REFER TO FIGURE 17.1. HEADLINER INNER SPATIAL SENSOR G13AR (G12AR) IP15-2 PASSENGER DUAL AIRBAG IGNITERS SP30-2 CR86-4 Y Y IP56-1 IP77-3 STAGE ONE BO RF18-1 HEADLINER OUTER SPATIAL SENSOR SP28-7 GU U IP77-4 CR86-3 SP30-7 IP56-2 GU GU RF2-9 RF18-2 U BO BO RF2-10 SP28-8 SP30-8 R SP3-A SP2-H B SP3-B O CR86-15 BR SP2-K BR IP3-2 WU IP68-3 IP68-1 Y SP3-C SP2-D SP30-10 CR86-16 SP2-G + SP2-F LOCAL – SP30-11 SP2-E RESTRAINTS CONTROL MODULE (Continued from Fig. 17.1) C + LOCAL OY C R G7AS (G7AL) SP30-9 UY C C – SP30-12 SP2-C NOTE: RCM power supply shown in Fig. 17.1. Y SP33-1 B P R PASSENGER SEAT WEIGHT PRESSURE SENSOR SP33-3 PASSENGER AIRBAG DEACTIVATED INDICATOR LAMP BW SP2-J SP2-B B SP33-2 P SP2-A BK SP30-23 BK SPS3 BK SP28-1 G13AR (G12AR) PASSENGER SEAT BELT TENSION SENSOR 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II OCCUPANCY SENSING MODULE PASSENGER SEAT WEIGHT SENSING MODULE Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 21 II Fig. 18.1 CONTROL MODULE PIN-OUT INFORMATION Instrument Cluster Pin Description and Characteristic COMPONENTS C IP6-08 CAN + Component Connector(s) Connector Description Location C IP6-09 CAN – S IP6-10 SCP – INSTRUMENT CLUSTER IP6-20 SCP + 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL S IP5 IP6 IP7 TRUNK / SPARE WHEEL WELL PARKING AID MODULE CR52 26-WAY / BLACK Parking Aid Module PARKING AID SENSOR – FRONT LH BF5 3-WAY / BLACK FRONT BUMPER Pin Description and Characteristic PARKING AID SENSOR – FRONT LH CENTER BF4 3-WAY / BLACK FRONT BUMPER B+ CR52-01 IGNITION SWITCHED POWER SUPPLY (II): B+ PARKING AID SENSOR – FRONT RH BF2 3-WAY / BLACK FRONT BUMPER SS CR52-02 FRONT SENSOR SIGNAL SUPPLY VOLTAGE: B+ PARKING AID SENSOR – FRONT RH CENTER BF3 3-WAY / BLACK FRONT BUMPER PG CR52-03 POWER GROUND: GROUND PARKING AID SENSOR – REAR LH BR5 3-WAY / BLACK REAR BUMPER SG CR52-04 REAR SENSOR SIGNAL GROUND: GROUND PARKING AID SENSOR – REAR LH CENTER BR4 3-WAY / BLACK REAR BUMPER D CR52-05 SERIAL DATA LINK PARKING AID SENSOR – REAR RH BR2 3-WAY / BLACK REAR BUMPER I CR52-06 CHIME INHIBIT SIGNAL PARKING AID SENSOR – REAR RH CENTER BR3 3-WAY / BLACK REAR BUMPER I CR52-07 PARKING AID SWITCH SIGNAL: GROUND WHEN ACTIVATED I CR52-08 TRAILER CONNECTED STATUS: GROUND = TRAILER CONNECTED PARKING AID SOUNDER – FRONT IP46 2-WAY / BLACK INSTRUMENT PANEL / DRIVER SIDE I CR52-09 REVERSE LAMPS STATUS: B+ = REVERSE LAMPS ON PARKING AID SOUNDER – REAR TL6 2-WAY / BLACK PARCEL SHELF / RH SIDE D CR52-10 REAR LH CENTER SENSOR SIGNAL DATA REAR ELECTRONIC MODULE CR52-11 REAR LH SENSOR SIGNAL DATA D CR52-12 FRONT LH CENTER SENSOR SIGNAL DATA D CR52-13 FRONT LH SENSOR SIGNAL DATA O CR52-14 PARKING AID SOUNDERS + CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR D SS CR52-15 REAR SENSOR SIGNAL SUPPLY VOLTAGE: B+ ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF SG CR52-16 REAR SENSOR SIGNAL GROUND: GROUND O CR52-17 REAR PARKING AID SOUNDER – O CR52-18 FRONT PARKING AID SOUNDER – O CR52-19 PARKING AID STATUS LED ACTIVATE: TO ACTIVATE, PAM SWITCHES CIRCUIT TO B+ D CR52-23 REAR RH CENTER SENSOR SIGNAL DATA Connector Connector Description D CR52-24 REAR RH SENSOR SIGNAL DATA BF1 10-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO FRONT BUMPER HARNESS ENGINE COMPARTMENT / BEHIND RH WHEEL ARCH LINER D CR52-25 FRONT RH CENTER SENSOR SIGNAL DATA BR1 10-WAY / GREY / CABIN HARNESS TO REAR BUMPER HARNESS TRUNK / RH SIDE / ADJACENT TO REAR ELECTRONIC MODULE D CR52-26 FRONT RH SENSOR SIGNAL DATA EC46 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO CABIN HARNESS CABIN / RH ‘A’ POST IP1 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND DRIVER SIDE INSTRUMENT PANEL END PLATE HARNESS IN-LINE CONNECTORS Location Rear Electronic Module RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST TL35 22-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER Pin Description and Characteristic O CR11-17 PARKING AID CHIME INHIBIT SIGNAL S CR13-01 SCP + S CR13-02 SCP – GROUNDS Ground NOTE: Refer to the Appendix at the rear of this book for Network Messages. Location G17 CABIN / BELOW REAR SEAT / RH SIDE G29 TRUNK / SPARE WHEEL WELL FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Parking Aid System WR 46 B II CR52-1 + OG I 08.3 PARKING AID SWITCH B B RFS1 PARKING AID STATUS G17BR RG I 08.4 REAR EXTERIOR LIGHTING: TRAILER CONNECTED (CIRCUIT CONTINUED) 08.5 CR52-8 GU + VEHICLE SPEED 20.1 Y S 20.2 20.3 20.2 20.3 20.2 20.3 20.2 20.3 IP6-20 CR52-19 W D 20.2 20.3 SERIAL COMMUNICATION – U S CR52-5 IP6-10 ROOF CONSOLE INSTRUMENT CLUSTER RU RU RU O + CRS38 IP1-10 IP46-1 FRONT PARKING AID SOUNDER G C O RF2-2 RF3-13 20.1 IP6-9 CR52-7 GU RF3-1 – I RF2-3 RF3-20 B RF2-1 GW Y C IP6-8 REVERSE LAMPS: ACTIVATED (CIRCUIT CONTINUED) CR52-9 GW Fig. 18.1 Parking Aid System CR52-14 Y Y IP1-9 IP46-2 + Y S CR13-1 O – CR52-18 – U S CR13-2 CHIME INHIBIT RU TL6-1 REAR PARKING AID SOUNDER CR11-17 NOTE: “Chime Inhibit” signal > 15 km/h (10 mph) sensors disabled < 10 km/h (6 mph) sensors enabled YR RU CR52-17 RU BF1-1 Y RW RU EC46-6 CR52-2 Y BF2-2 REAR ELECTRONIC MODULE O – TL35-8 BFS3 O CR52-6 RU YR RU FRONT RH SENSOR I TL35-7 TL6-2 BF2-1 OY BF1-2 Y D EC46-22 RW BR2-1 W W D CR52-26 RW BRS1 BR1-5 CR52-15 BR1-6 CR52-24 BR2-2 BO BG BF2-3 BR2-3 RU RW BF3-1 BR3-1 YR FRONT RH CENTER SENSOR YR BF1-3 BF3-2 YR D EC46-21 WR D CR52-25 WR BR1-7 CR52-23 BR3-2 BO BR3-3 RU RW BR4-1 BF4-1 YU YU BF1-4 BF4-2 YU D EC46-3 CR52-12 WU WU D BR1-8 CR52-10 BR4-2 BO REAR LH CENTER SENSOR BG BR4-3 BF4-3 RW RU BR5-1 BF5-1 YR FRONT LH SENSOR REAR RH CENTER SENSOR BG BF3-3 FRONT LH CENTER SENSOR REAR RH SENSOR YR BF1-5 BF5-2 BO BO BFS4 BF5-3 YR EC46-4 BO BF1-6 D WG WG D CR52-13 CR52-11 CR52-4 CR52-16 BR1-9 BR5-2 BG BG BO EC46-5 B BG BRS2 BR1-10 REAR LH SENSOR BR5-3 P CR52-3 G29BS PARKING AID MODULE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: Parking Aid Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 CAN Fig. 19.1 CONTROL MODULE PIN-OUT INFORMATION Front Electronic Module Pin Description and Characteristic COMPONENTS PG CR1-26 POWER GROUND: GROUND Component Connector(s) Connector Description Location B+ CR9-06 BATTERY POWER SUPPLY: LOGIC: B+ CENTER CONSOLE SWITCH PACK CL1 CL2 8-WAY / BLACK 8-WAY / BLACK CENTER CONSOLE PG CR10-11 POWER GROUND: GROUND CLOCK IP19 6-WAY / BLACK INSTRUMENT PANEL / CENTER VENT PG CR10-13 POWER GROUND: GROUND FRONT ELECTRONIC MODULE CR10-14 POWER GROUND: GROUND I CR85-18 LH FRONT SEAT HEATER SWITCH SIGNAL: PWM 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST PG CR1 CR9 CR10 CR85 EC36 I CR85-19 RH FRONT SEAT HEATER SWITCH SIGNAL: PWM GLOVE BOX MOTOR IP16 3-WAY / BLACK GLOVE BOX O CR85-20 SEAT HEATERS SWITCHED ON SIGNAL: B+ WHEN ACTIVATED GLOVE BOX SWITCH IP12 2-WAY / BLACK GLOVE BOX O EC36-09 GLOVE BOX RELEASE ACTIVATE STEERING WHEEL SW7 4-WAY / BLACK STEERING WHEEL STEERING WHEEL HEATER MODULE SW5 4-WAY / BLACK STEERING WHEEL NOTE: Refer to the Appendix at the rear of this book for Network Messages. HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC2 22-WAY / BLACK / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE CL3 16-WAY / GREY / CENTER CONSOLE HARNESS TO CENTER CONSOLE LINK HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE IP2 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP17 16-WAY / GREEN / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE TL28 16-WAY / GREY / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW CENTER CONSOLE / RH SIDE OF TRANSMISSION TUNNEL GROUNDS Ground Location G9 CABIN / UPPER LH A POST G15 CABIN / RH SIDE OF TRANSMISSION TUNNEL G31 CABIN / BEHIND PASSENGER AIR BAG G32 CABIN / BEHIND INSTRUMENT CLUSTER FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT. The following abbreviations are used to represent values for Control Module Pin-Out data I O B+ Input Output Battery Voltage PG SS SG Power Ground Sensor / Signal Supply V Sensor / Signal Ground C S D2 CAN Network SCP Network D2B Network D Serial and Encoded Data V Voltage (DC) PWM Pulse Width Modulated CAUTION: The information on this data page is furnished to aid the user in understanding circuit oper ation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY. NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components connected and fitted. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Ancillaries: Part 1 NW 80 B CR9-6 SLIP RING R 13 II SEAT HEATER SWITCHES LH R SW9-2 SW6-2 B SW5-3 O O RH SW5-1 B SW7-4 CASSETTE Y O NG 35 RW LH II CL1-6 RW CL2-5 CL3-8 RW CC2-8 RW TL28-7 Fig. 19.1 Ancillaries: Part 1 CR85-20 I Y Y SW8-5 IP17-5 W W SWS1 SW1-3 SW7-1 STEERING WHEEL HEATER I SW5-4 SLIP RING B B P CR85-18 SWS2 SW5-2 B SW6-1 SW9-1 B IPS2 G31BL BK BK CCS3 BK CL3-3 WU RH CL1-5 WU CL1-4 CL3-2 WU CC2-9 WU STEERING WHEEL HEATER MODULE I CR85-19 TL28-8 W G15AR B SW7-3 SW7-2 TEMPERATURE SENSOR STATE CENTER CONSOLE SWITCH PACK B B B B NOTE: CCS3 – Non Navigation vehicles only. STEERING WHEEL P CR1-26 P P CR10-14 CR10-11 P CR10-13 FRONT ELECTRONIC MODULE G9BL G9BR STEERING WHEEL HEATER NW 80 B 55 CR9-6 O S B B IPS5 OG IP12-1 IP12-2 OG IP2-2 NW B RW I IP19-6 B P GU EC36-9 GU IP9-2 IP19-5 I IP16-3 B P CLOCK G32AL GLOVE BOX MOTOR B B B B P P P CR1-26 CR10-14 CR10-11 P CR10-13 FRONT ELECTRONIC MODULE G9BL GLOVE BOX DOOR 7 6 63 CLOCK Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage B IPS5 G32AL IP16-2 1 DIMMER-CONTROLLED LIGHTING I O G9BR 09.2 IP19-2 CR9-2 GLOVE BOX SWITCH G32AL 81 B IP16-1 + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 19.2 COMPONENTS Component Connector(s) Connector Description ACCESSORY RELAY — — Location REAR POWER DISTRIBUTION FUSE BOX – R3 AUXILIARY RELAY — — REAR POWER DISTRIBUTION FUSE BOX – R8 CIGAR LIGHTER – FRONT TL69 3-WAY / BLACK CENTER CONSOLE CIGAR LIGHTER – REAR TL70 3-WAY / BLACK REAR CENTER CONSOLE ELECTRONIC ROAD PRICING MODULE CR121 2-WAY / BLACK INSTRUMENT PANEL FRONT POWER DISTRIBUTION FUSE BOX EC4 EC5 EC19 EC22 EC26 EC28 EC32 EC35 EC40 EC41 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK ENGINE COMPARTMENT / RH FRONT HORN RELAY — — FRONT POWER DISTRIBUTION FUSE BOX – R14 HORN SWITCH — — STEERING WHEEL HORNS EC58 2-WAY / BLACK BEHIND FRONT BUMPER / LH SIDE POWER POINT – FRONT IP21 3-WAY / BLACK FRONT CENTER CONSOLE GLOVE BOX POWER POINT – REAR TL72 3-WAY / BLACK REAR CENTER CONSOLE REAR ACCESSORY CONNECTOR CR40 3-WAY / BLACK TRUNK / RH REAR REAR POWER DISTRIBUTION FUSE BOX CR3 CR5 CR68 CR80 CR81 CR82 CR83 CR84 CR97 CR98 4-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 12-WAY / BLACK 4-WAY / BLACK 8-WAY / BLACK 8-WAY / BLACK 10-WAY / BLACK TRUNK / RH REAR ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF SUN SHADE MOTOR CR70 4-WAY / GREY REAR WINDOW HARNESS IN-LINE CONNECTORS Connector Connector Description Location IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP9 8-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / ADJACENT TO HOOD RELEASE IP51 10-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST RF2 16-WAY / BLUE / CABIN HARNESS TO ROOF HARNESS CABIN / RH ‘D’ POST TL14 14-WAY / GREY / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER GROUNDS Ground Location G1 ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY G10 CABIN / RH A POST G17 CABIN / BELOW REAR SEAT / RH SIDE G18 CABIN / BELOW REAR SEAT / LH SIDE G23 TRUNK / RH SIDE / ADJACENT TO BATTERY G32 CABIN / BEHIND INSTRUMENT CLUSTER Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 FEM: HORN RELAY ACTIVATE (CIRCUIT CONTINUED) Ancillaries: Part 2 Fig. 19.2 Ancillaries: Part 2 GW 12.2 R14 15 3 4 YB 5 F25 15A CASSETTE GW SW8-7 GW GW ECS6 IP8-1 2 1 NW 84 CR121-1 EC58-1 EC5-3 3A 16 B EC41-5 CR121-2 HORN RELAY HORN SWITCH B G10DL FRONT POWER DISTRIBUTION FUSE BOX YG ELECTRONIC ROAD PRICING MODULE EC58-2 CASSETTE G1AR SW8-6 HORNS STEERING WHEEL ECM: SENSOR GROUND 03.6 03.4 YG 03.2 YG PI41-24 IP55-11 (LHD) IP9-3 (RHD) ELECTRONIC ROAD PRICING HORNS O 72 S RF3-9 R8 62 3 4 WU 5 CR84-7 F44 15A 1 1 B WU TL69-1 TL14-2 2 REAR CIGAR LIGHTER I B GARAGE DOOR SWITCHES GARAGE DOOR OPENER RF3-1 B RFS1 WB B AUXILIARY RELAY RF2-1 TL69-3 CR84-6 F43 15A B WB TL70-1 TL14-3 G17BR TL70-3 FRONT CIGAR LIGHTER ROOF CONSOLE WR CR68-7 F26 15A R3 GARAGE DOOR OPENER 63 3 1 TL72-1 TL72-3 REAR POWER POINT 4 5 WG CR68-6 F25 15A 2 B WR TL14-4 B WG IP51-10 2 IP21-1 TLS13 IP21-3 B FRONT POWER POINT I G32AR G18BR ACCESSORY RELAY YB 3 I CR70-2 38 N CR40-2 WR CR80-4 F22 10A B B RF2-1 G B RFS1 RF3-14 SUN SHADE SWITCH RF3-1 B CR70-3 RF1-2 B CR82-2 CR70-1 G17AR 63 CR40-1 G23AR REAR ACCESSORY CONNECTOR SUN SHADE MOTOR SUN SHADE 7 B CRS23 G23AL REAR POWER DISTRIBUTION FUSE BOX ROOF CONSOLE 6 CR40-3 B G G17BR 1 WR CIGAR LIGHTERS, POWER POINTS, ACCESSORY CONNECTOR Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 20.1 COMPONENTS Component Connector(s) Connector Description Location ADAPTIVE SPEED CONTROL MODULE EC23 12-WAY / BLACK LH FRONT OF VEHICLE / REARWARD OF FRONT BUMPER AIR SUSPENSION MODULE CR88 CR89 CR90 CR91 9-WAY / BLACK 12-WAY / BLACK 15-WAY / BLACK 18-WAY / BLACK CABIN REAR BULKHEAD / BEHIND REAR SEAT BACK / RH SIDE CLIMATE CONTROL MODULE AC100 AC101 CR119 16-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK CLIMATE CONTROL UNIT / DRIVER SIDE DATA LINK CONNECTOR IP39 16-WAY / BLACK TRANSMISSION TUNNEL / DRIVER SIDE DYNAMIC STABILITY CONTROL MODULE EC30 47-WAY / BLACK ENGINE COMPARTMENT, RH FRONT ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL J GATE MODULE IP32 16-WAY / BLACK J GATE ASSEMBLY REAR CLIMATE CONTROL MODULE RA1 RA2 16-WAY / BLACK 12-WAY / BLACK REAR CENTER CONSOLE TRANSMISSION CONTROL MODULE GB2 16-WAY / BLACK TRANSMISSION CONTROL VALVE YAW RATE SENSOR IP23 6-WAY / BLACK CENTER CONSOLE / REWARD OF J GATE HARNESS IN-LINE CONNECTORS Connector Connector Description Location CR120 8-WAY / BLACK / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL / LH SIDE GB1 16-WAY / GREY / ENGINE HARNESS TO TRANSMISSION HARNESS ADJACENT TO TRANSMISSION BELL HOUSING IP55 22-WAY / BLACK / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP66 14-WAY / GREY / INSTRUMENT PANEL HARNESS TO REAR AIR CONDITIONING HARNESS CABIN / BELOW CENTER CONSOLE PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE TL22 16-WAY / GREEN / TELEMATICS HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE TL93 8-WAY / BLACK / CENTER CONSOLE HARNESS TO TELEMATICS HARNESS CABIN / BELOW REAR CENTER CONSOLE GROUNDS Ground Location G31 CABIN / BEHIND PASSENGER AIR BAG NOTE: Refer to the Appendix at the rear of this book for Network Messages. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Controller Area Network Fig. 20.1 Controller Area Network 82 NW B IP39-16 40 GO B II + Y C IP6-18 + C – C Y IP23-2 Y – Y IP55-16 U IP23-1 U G C IP6-19 S + Y Y TL22-2 TL93-1 TL22-1 TL93-2 Y C U IP55-17 YAW RATE SENSOR AIR SUSPENSION MODULE + Y C – EC30 -25 EC30 -29 G INSTRUMENT CLUSTER C – Y Y PI1-124 G C Y PI1-123 G GB1-3 Y ECS28 G G GB1-4 C + + EC30-11 G C – – ENGINE CONTROL MODULE Y EC30-15 Y IP55-21 G C EC30-14 PI41-21 Y C EC30-12 PI41-20 G GBS2 GB1-2 ECS27 Y Y GBS1 GB1-1 CR120-3 G C + G IP55-22 CR120-4 + Y C CR119-6 CR119-16 C – – Y CR119-17 C + C G IP32-11 C – – C IP32-10 CR120-6 CLIMATE CONTROL MODULE + Y IP66-4 G IP66-5 Y C RA1-8 G C Y IP66-11 J GATE MODULE EC23-10 – Y Y G G IP32-12 Y C + IP32-9 CR120-5 G C CR119-7 DYNAMIC STABILITY CONTROL MODULE + G Y C + LOCAL – – G C EC23-4 RA1-16 ADAPTIVE SPEED CONTROL MODULE REAR CLIMATE CONTROL MODULE LEFT HAND DRIVE + Y C IP6-18 + C – C Y IP23-2 Y – Y IP55-16 U IP23-1 U G C IP6-19 S + Y TL22-2 Y TL93-1 G TL22-1 Y C U IP55-17 AIR SUSPENSION MODULE YAW RATE SENSOR + Y C – EC30 -25 NOTE: ECS27, ECS28 – Adaptive Speed Control vehicles only. Y Y PI1-124 – PI1-123 Y G GB1-3 Y EC30 -29 G C C – ECS28 G G GB1-4 C + G Y + G Y C EC30-11 C – – Y IP55-21 G C EC30-15 Y CR120-3 G IP55-22 C + G CR120-4 + Y C CR119-6 CR119-16 C – – G C CR119-7 Y CR119-17 C + G CR120-6 CLIMATE CONTROL MODULE C IP32-11 C – – C IP32-10 – + – 63 95 Fig. 01.2 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S B G C BK IP39-5 REAR CLIMATE CONTROL MODULE Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground G31AR NOTE: The circuits include all vehicle options. A ACP S SCP C CAN D Serial and Encoded Data P IP39-4 RA1-16 RIGHT HAND DRIVE 1 G IP66-5 RA1-8 ADAPTIVE SPEED CONTROL MODULE 64 Y IP66-4 Y C EC23-4 Fig. 01.1 IP66-11 J GATE MODULE G C Y Y G G IP32-12 Y C + IP32-9 CR120-5 EC23-10 7 C – IP39-14 INSTRUMENT CLUSTER DYNAMIC STABILITY CONTROL MODULE + 6 G C + EC30-14 PI41-21 ENGINE CONTROL MODULE 1 IPS32 IP66-12 EC30-12 PI41-20 G GBS2 GB1-2 ECS27 Y Y GBS1 GB1-1 G C C + IP39-6 LOCAL C Y IP6-9 TRANSMISSION CONTROL MODULE + IPS33 IP6-8 GB2-2 120 Ω – CR88-8 S – G C C IP6-20 GB2-6 – + 120 Ω G TL93-2 C CR88-7 IP6-10 + C – IP39-14 IP66-12 NOTE: ECS27, ECS28 – Adaptive Speed Control vehicles only. C C + IP39-6 G IP6-9 TRANSMISSION CONTROL MODULE + Y IPS32 G C GB2-2 120 Ω IPS33 IP6-8 G C – CR88-8 S – GB2-6 – C IP6-20 IP6-10 + + 120 Ω G G C CR88-7 IP39-9 VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 DATA LINK CONNECTOR Fig. 20.2 COMPONENTS Component Connector(s) Connector Description Location AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE DATA LINK CONNECTOR IP39 16-WAY / BLACK TRANSMISSION TUNNEL / DRIVER SIDE DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM DRIVER SEAT MODULE SD2 SD3 SD4 SD24 SD26 SD27 22-WAY / BLACK 6-WAY / BLACK 26-WAY / BLACK 4-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK DRIVER SEAT UNDERSIDE ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE FRONT ELECTRONIC MODULE CR1 CR9 CR10 CR85 EC36 26-WAY / BLACK 12-WAY / BLACK 17-WAY / BLACK 20-WAY / BLACK 22-WAY / BLACK CABIN / LH ‘A’ POST HID HEADLAMP UNIT – LH EC57 9-WAY / BLACK ENGINE COMPARTMENT / LH FRONT HID HEADLAMP UNIT – RH EC6 9-WAY / BLACK ENGINE COMPARTMENT / RH FRONT INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP PARKING AID MODULE CR52 26-WAY / BLACK TRUNK / SPARE WHEEL WELL PARKING BRAKE MODULE CR32 CR50 12-WAY / GREY 4-WAY / BLACK TRUNK / RH SIDE / ADJACENT TO REM REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR REAR MEMORY MODULE CR21 CR37 CR38 CR41 CR53 CR59 4-WAY / BLACK 26-WAY / BLACK 22-WAY / BLACK 6-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK REAR BULKHEAD / BEHIND REAR SEAT BACK RESTRAINTS CONTROL MODULE CR86 CR87 24-WAY / BLACK 40-WAY / BLACK TRANSMISSION TUNNEL / UNDER CENTER CONSOLE ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF STEERING COLUMN LOCK MODULE IP24 4-WAY / BLACK UPPER STEERING COLUMN HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST IP2 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP22 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT TL35 22-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER GROUNDS Ground Location G31 CABIN / BEHIND PASSENGER AIR BAG NOTE: Refer to the Appendix at the rear of this book for Network Messages. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Standard Corporate Protocol Network; Serial Data Link: LHD Standard Corporate Protocol Network; Serial Data Link: LHD NW 82 Fig. 20.2 B IP39-16 + Y S + – – Y S + – D 2 Y Y U S C + SD2-1 SD2-12 U Y C – – U S IP6-10 INSTRUMENT CLUSTER Y CRS61 Y TLS51 TL35-22 U U CRS60 NOTE: TLS50, TLS51 – Navigation vehicles only. U TL35-21 TLS50 U U U CRS48 SD28-6 + Y – Y + DD13-4 Y S + U – IP24-4 U S – U S TL2-14 DD1-2 IP24-3 NAVIGATION CONTROL MODULE DRIVER DOOR MODULE IP39-2 Y S TL2-4 DD1-1 U S S + IPS43 IP2-8 DD13-3 IP39-10 Y Y Y S S – IPS42 IP2-7 DRIVER SEAT MODULE IP39-9 CC10-15 S IP6-19 CRS58 U U – S B II IP6-20 G Y U CRS47 SD28-5 + IP6-18 CRS59 Y Y U S GO 40 Y CC10-14 CC8-10 Y REAR ELECTRONIC MODULE S – CC21-1 CR13-2 FRONT ELECTRONIC MODULE Y S CC8-9 BOF TL35-15 CR13-1 U S + AUDIO UNIT S CR9-1 + 2 PARKING BRAKE MODULE CR9-7 – D CC21-2 U CR32-7 REAR MEMORY MODULE BOF TL35-14 U S CR38-12 + Y CR32-1 U S Y S CR38-1 STEERING COLUMN LOCK MODULE STANDARD CORPORATE PROTOCOL NETWORK NOTE: ECS7 – HID Headlamp vehicles only. W D EC101-2 W W ECS7 EC57-5 W D IPS25 IP8-4 IP39-7 HEADLAMP LEVELING MODULE LH HID HEADLAMP UNIT W D CR86-11 W D EC103-2 EC6-5 RESTRAINTS CONTROL MODULE HEADLAMP LEVELING MODULE RH HID HEADLAMP UNIT W D W CRS22 CR52-5 W IP22-8 W W IP8-9 W PI41-22 D PI1-105 PARKING AID MODULE ENGINE CONTROL MODULE B P IP39-4 W D RF3-8 W BK IP39-5 RF1-3 INTRUSION SENSOR SERIAL DATA LINK G31AR ROOF CONSOLE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E NOTE: The circuits include all vehicle options. I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: LHD Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 DATA LINK CONNECTOR Fig. 20.3 COMPONENTS Component Connector(s) Connector Description Location AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE DATA LINK CONNECTOR IP39 16-WAY / BLACK TRANSMISSION TUNNEL / DRIVER SIDE DRIVER DOOR MODULE DD11 DD12 DD13 20-WAY / BLACK 26-WAY / BLACK 26-WAY / NATURAL DRIVER DOOR / BEHIND TRIM DRIVER SEAT MODULE SD2 SD3 SD4 SD24 SD26 SD27 22-WAY / BLACK 6-WAY / BLACK 26-WAY / BLACK 4-WAY / BLACK 4-WAY / BLACK 6-WAY / BLACK DRIVER SEAT UNDERSIDE ENGINE CONTROL MODULE PI1 134-WAY / BLACK ENGINE COMPARTMENT BULKHEAD / PASSENGER SIDE HID HEADLAMP UNIT – LH EC57 9-WAY / BLACK ENGINE COMPARTMENT / LH FRONT HID HEADLAMP UNIT – RH EC6 9-WAY / BLACK ENGINE COMPARTMENT / RH FRONT INSTRUMENT CLUSTER IP5 IP6 IP7 22-WAY / GREY 20-WAY / BLACK 22-WAY / BLACK INSTRUMENT PANEL NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP PARKING AID MODULE CR52 26-WAY / BLACK TRUNK / SPARE WHEEL WELL PARKING BRAKE MODULE CR32 CR50 12-WAY / GREY 4-WAY / BLACK TRUNK / RH SIDE / ADJACENT TO REM REAR ELECTRONIC MODULE CR4 CR11 CR12 CR13 CR71 CR73 20-WAY / BLACK 26-WAY / NATURAL 12-WAY / BLACK 22-WAY / BLACK 17-WAY / BLACK 4-WAY / BLACK TRUNK / RH REAR RESTRAINTS CONTROL MODULE CR86 CR87 24-WAY / BLACK 40-WAY / BLACK TRANSMISSION TUNNEL / UNDER CENTER CONSOLE ROOF CONSOLE RF3 20-WAY / BLACK CABIN ROOF STEERING COLUMN LOCK MODULE IP24 4-WAY / BLACK UPPER STEERING COLUMN HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC10 22-WAY / GREEN / CENTER CONSOLE HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BELOW CENTER CONSOLE / LH SIDE (LHD), RH SIDE (RHD) DD1 22-WAY / BLACK / CABIN HARNESS TO DRIVER DOOR HARNESS CABIN / DRIVER SIDE ‘A’ POST IP2 10-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND LH SIDE INSTRUMENT PANEL END PLATE IP8 14-WAY / GREY / ENGINE COMPARTMENT HARNESS TO INSTRUMENT PANEL HARNESS CABIN / RH ‘A’ POST IP22 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS CABIN / BEHIND INSTRUMENT PANEL END PLATE / LH SIDE (LHD), RH SIDE (RHD) PI41 42-WAY / BLACK / ENGINE HARNESS TO ENGINE COMPARTMENT HARNESSES ENGINE COMPARTMENT / TOP OF SUSPENSION TOWER / PASSENGER SIDE RF1 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS CABIN / UPPER RH ‘A’ POST SD28 20-WAY / BLACK / DRIVER SEAT HARNESS TO CABIN HARNESS CABIN / BELOW DRIVER SEAT TL35 22-WAY / BLACK / CABIN HARNESS TO TELEMATICS HARNESS TRUNK / LH SIDE / BEHIND CD AUTOCHANGER GROUNDS Ground Location G31 CABIN / BEHIND PASSENGER AIR BAG NOTE: Refer to the Appendix at the rear of this book for Network Messages. Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 Standard Corporate Protocol Network; Serial Data Link: RHD Standard Corporate Protocol Network; Serial Data Link: RHD + S – S Y CR9-7 Y S TL35-14 U BOF D 2 + Y S CC21-2 CC8-9 BOF D 2 – Y + – CC8-10 – AUDIO UNIT U S CR38-12 CR13-2 REAR MEMORY MODULE Y REAR ELECTRONIC MODULE C SD2-1 – CRS59 SD2-12 CRS61 U CRS65 SD28-5 SD28-6 Y S IP6-20 C U S IP6-10 TLS51 U TL35-21 – IP6-19 TL35-22 CRS60 INSTRUMENT CLUSTER TLS50 NOTE: TLS50, TLS51 – Navigation vehicles only. U U CRS64 Y U U CRS58 U U S Y Y Y Y S + IP6-18 G Y + U CC10-15 Y S CR13-1 U S Y CC10-14 U S CC21-1 CR38-1 IP2-7 TL35-15 PARKING BRAKE MODULE S U Y S Y + Y DD13-4 Y S + U – IP24-4 U S – U S TL2-14 DD1-2 IP24-3 STEERING COLUMN LOCK MODULE NAVIGATION CONTROL MODULE DRIVER DOOR MODULE S + IP39-2 Y S TL2-4 DD1-1 U S IP39-10 IPS43 IP22-2 DD13-3 – Y Y DRIVER SEAT MODULE S – IPS42 IP22-1 + IP39-9 FRONT ELECTRONIC MODULE U CR32-7 + B II Y CR32-1 – S GO 40 U CR9-1 + B IP39-16 IP2-8 U NW 82 Y Fig. 20.3 STANDARD CORPORATE PROTOCOL NETWORK NOTE: ECS7 – HID Headlamp vehicles only. W D W W ECS7 EC57-5 EC101-2 W D IPS25 IP8-4 IP39-7 HEADLAMP LEVELING MODULE LH HID HEADLAMP UNIT W D CR86-11 W D EC6-5 EC103-2 RESTRAINTS CONTROL MODULE HEADLAMP LEVELING MODULE RH HID HEADLAMP UNIT W D W CRS22 CR52-5 W IP22-8 W W IP8-9 W PI41-22 D PI1-105 ENGINE CONTROL MODULE PARKING AID MODULE B P IP39-4 W D RF3-8 W BK IP39-5 RF1-3 INTRUSION SENSOR SERIAL DATA LINK G31AR ROOF CONSOLE 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E NOTE: The circuits include all vehicle options. I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: RHD Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 DATA LINK CONNECTOR Fig. 20.4 COMPONENTS Component Connector(s) Connector Description Location AUDIO UNIT CC8 CC9 CC21 20-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR CENTER CONSOLE CD AUTOCHANGER TL5 DB2 3-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / THIRD FROM TOP CELLULAR PHONE MODULE TL7 TL94 DB3 32-WAY / BLACK 2-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / BOTTOM MULTIMEDIA CONTROL PANEL RC1 RC3 RC5 8-WAY / BLACK 20-WAY / BLACK FIBER OPTIC CONNECTOR REAR SEAT ARM REST OR REAR FLOOR CONSOLE NAVIGATION CONTROL MODULE DB6 TL2 TL29 TL30 TL37 FIBER OPTIC CONNECTOR 20-WAY / BLACK 26-WAY / BLACK 12-WAY / BLACK 2-WAY / BLACK TRUNK / LH SIDE / MODULE STACK / SECOND FROM TOP POWER AMPLIFIER TL9 TL10 DB7 12-WAY / WHITE 18-WAY / WHITE FIBER OPTIC CONNECTOR TRUNK / LH SIDE VOICE ACTIVATION MODULE TL68 DB4 22-WAY / BLACK FIBER OPTIC CONNECTOR TRUNK / LH SIDE / MODULE STACK / SECOND FROM BOTTOM HARNESS IN-LINE CONNECTORS Connector Connector Description Location CC1 22-WAY GREEN / TELEMATICS HARNESS TO CENTER CONSOLE HARNESS CABIN / BELOW CENTER CONSOLE DB1 2-WAY / BLACK / TELEMATICS HARNESS TO D2B NETWORK HARNESS TRUNK / LH SIDE DB5 2-WAY / BLACK / D2B NETWORK HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS TRUNK / LH SIDE RC2 8-WAY / BLACK / TELEMATICS HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS CABIN / BELOW CENTER CONSOLE RC6 2-WAY / BLACK / D2B NETWORK HARNESS TO REAR IN-CAR ENTERTAINMENT CONTROLS HARNESS CABIN / BELOW CENTER CONSOLE TL95 2-WAY / BLACK / CENTER CONSOLE HARNESS TO D2B NETWORK HARNESS CABIN / BELOW REAR CENTER CONSOLE Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control modules and control module pins. DATE OF ISSUE: April 2003 Jaguar XJ 2004 D2B Network 20.3 20.2 Y S + 20.3 20.2 U CC21-2 S – OG CC8-19 CC1-18 BOF BOF 2 TL95-1 BOF D DB1-2 BOF BOF 2 CC21-1 CC8-10 OG BOF D CC8-9 SCP D2B Network TL95-2 DB1-1 O D2B WAKE–UP AUDIO UNIT BOF D 2 DB2-2 BOF D 2 OG TL5-3 DB2-1 O D2B WAKE–UP CD AUTOCHANGER BOF D 2 DB3-2 BOF D 2 OG TL7-23 DB3-1 O D2B WAKE–UP CELLULAR PHONE MODULE BOF D 2 DB4-2 BOF D 2 OG TLS5 DB4-1 O D2B WAKE–UP TL68-14 VOICE ACTIVATION MODULE BOF BOF D BOF 2 RC5-2 DB5-2 BOF BOF D OG RC6-2 BOF 2 OG RC5-1 O D2B WAKE–UP RC6-1 DB5-1 RC1-6 RC2-7 MULTIMEDIA CONTROL PANEL 20.3 20.2 Y S + 20.2 U 2 DB6-2 S – BOF D 2 DB6-1 TL2-14 OG The 7-module D2B network shown depicts the greatest number of modules available. D2B networks containing less than 7 modules are always connected in the sequence shown from top to bottom. Audio Unit – Master Module 1 – CD Autochanger 2 – Cellular Phone Module 3 – Voice Activation Module 4 – Multimedia Control Panel 5 – Navigation Control Module 6 – Power Amplifier BOF D TL2-4 20.3 NOTES: O D2B WAKE–UP TL2-3 NAVIGATION CONTROL MODULE When modules are not fitted to the vehicle, the fiber optic cables and the connectors are deleted. Therefore, each network containing less than 7 modules has a unique fiber optic and “wake up” circuit. For D2B network diagnostics via SCP – refer to Figs. 20.2 and 20.3. BOF D 2 DB7-2 BOF D 2 OG O D2B WAKE–UP DB7-1 TL9-5 POWER AMPLIFIER 1 7 6 63 Fig. 01.1 64 95 Fig. 01.2 1 15 I II Fig. 01.3 16 52 Fig. 01.4 53 77 II S II S Fig. 01.5 78 105 Fig. 01.7 S Fig. 01.6 106 143 Fig. 01.8 E S E I Input B + O Output P Power Ground Battery Voltage + Sensor/Signal Supply V – Sensor/Signal Ground A ACP S SCP C CAN D Serial and Encoded Data VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: April 2003 Fig. 20.4 Jaguar XJ 2004 Appendix This Appendix contains a listing of SCP and CAN Network messages. NOTE: Passive Anti-Theft System and Security System messages are not included in this appendix. The following acronyms and abbreviations are used throughout this section: A/C ABS ASC ASCM ASM AT CMD AUDIO CAL CAN CATS CCM CID CPM D2B D2B D2B OPC DDCM DDM DSC DSCM DSM DTC ECM ECM FEM Gateway IC JGM LED MIL MSG NCM OBD ODO PBM PTT RCCM REM RMM RPM SCLM SCP SMS STM TCM TCS VAM WDS Air Conditioning Anti-Lock Braking Adaptive Speed Control Adaptive Speed Control Module Air Suspension Module Commands for configuring and controlling telecommunication devices Audio Unit Calibrate Controller Area Network Adaptive Damping Climate Control Module CAN Identifier Cellular Phone Module D2B Network Fiber Optic Network Instructions for translating and routing data for D2B use Driver Door Control module Driver Door Module Dynamic Stability Control Dynamic Stability Control Module Driver Seat Module Diagnostic Trouble Code Engine Control Module Engine Control Module Front Electronic Module Device that converts messages between different types of networks Instrument Cluster J-Gate Module Light Emitting Diode Malfunction Indicator Lamp Message Navigation Control Module On Board Diagnostics (OBD II, EOBD) Odometer Parking Brake Module Push to Talk Rear Climate Control Module Rear Electronic Module Rear Memory Module Revolutions Per Minute Steering Column Lock Module Standard Corporate Protocol Network Short Message Service for Mobile Communications Switch to Test Mode Transmission Control Module Traction Control System Voice Activation Module Worldwide Diagnostic System DATE OF ISSUE: April 2003 i ii All Park Lamp Command - Off IC DDM All Mirror Retract Motion Status - Enable(d) All Mirror Extend Motion Status - Disable(d) DDM FEM DDM All Master Controller Door Lock Switch Status - Inactive All Mirror Retract Motion Status - Disable(d) FEM All Master Controller Door Lock Switch Status - Active NCM FEM All Headlamp Status - On All Mirror Retract Motion Command - Enable(d) FEM All Headlamp Status - Off NCM IC All Headlamp Command - On All Mirror Retract Motion Command - Disable(d) IC DDM All Front Window Operation Enable Command - Enable(d) All Headlamp Command - Off FEM DDM All Front Window Operation Enable Command - Disable(d) FEM All Front High Beam Lamp Status - Off All Front High Beam Lamp Status - On IC REM All Front Courtesy Lamp Command - Off All Front High Beam Lamp Command - On REM All Front Courtesy Lamp Command - Off IC FEM All Floor Courtesy Lamp Command - On All Front High Beam Lamp Command - Off FEM All Floor Courtesy Lamp Command - Off FEM DDM All Door Unlock Enable Command - Enable(d) All Front Fog Lamp Status - On REM All Door Lock Status - Unlock(ed) FEM REM All Door Lock Status - Lock(ed) All Front Fog Lamp Status - Off FEM All Daytime Running Lamp Status - On IC FEM All Daytime Running Lamp Status - Off All Front Fog Lamp Command - On NCM All Daytime Running Lamp Command - On IC NCM All Daytime Running Lamp Command - Off All Front Fog Lamp Command - Off Source Message Name PBM X X X X REM X X X X X X X X X X X X X X X FEM X X X X X X IC X X X X X NCM AUDIO Receivers X X X X X X X X X X DDM DSM RMM SCLM Appendix Jaguar XJ 2004 SCP Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 DDM DDM REM All Remote Door Lock with Transmitter Id Status - Unlock(ed) All Remote Headlamp Command - On All Super / Double Door Lock Status - Lock(ed) IC IC IC Anti-Lock Brake System Active Status - No Anti-Lock Brake System Active Status - Yes DDM All Window Open Command - Enable(d) Alternator Failure Telltale Status - On DDM All Window Open Command - Disable(d) IC DDM All Window Close Command - Enable(d) Alternator Failure Telltale Status - Off DDM All Window Close Command - Disable(d) IC DDM All Remote Door Lock with Transmitter Id Status - Lock(ed) All Turn Lamp Command - On DDM All Rear Window Operation Enable Command - Enable(d) IC DDM All Rear Window Operation Enable Command - Disable(d) All Turn Lamp Command - Off FEM All Rear Park Lamp Command - On IC All Rear Fog Lamp Command - On FEM IC All Rear Fog Lamp Command - Off All Rear Park Lamp Command - Off FEM All Rear Courtesy Lamp Command - On FEM FEM All Rear Courtesy Lamp Command - Off All Rear Opera Lamp Command - On IC All Rear Brake Lamp Command - On FEM IC All Rear Brake Lamp Command - Off All Rear Opera Lamp Command - Off IC All Photo Cell Dark Status - Yes (True) REM IC All Photo Cell Dark Status - No (False) All Rear Fog Lamp Status - On FEM All Park Lamp Status - On REM FEM All Park Lamp Status - Off All Rear Fog Lamp Status - Off IC Source All Park Lamp Command - On Message Name X X PBM X X X X X X X X X X X X X X X X X X X REM X X X X X X X X X X X X X X FEM X X X X X X X X X IC NCM AUDIO Receivers X DDM DSM X X RMM SCLM Jaguar XJ 2004 Appendix SCP Message Matrix iii iv REM DDM REM REM REM REM REM FEM FEM DDM Chime Configuration 1 Command - Disable(d) Chime Configuration 1 Command - Enable(d) Chime Configuration 1 Command - Enable(d) Chime Configuration 2 Command - Enable(d) Chime Configuration 3 Command - Enable(d) Decklid Door Ajar Switch Status - Active Decklid Door Ajar Switch Status - Inactive Decklid Door Open Command - Yes (True) Decklid Door Unlock Enable Command - Disabled Decklid Remote Door Lock Command - Unlock(ed) DDM DDM Driver Front Door Ajar Switch Status - Inactive Driver Front Door Lock Status - Unlock(ed) DDM Driver Front Door Ajar Switch Status - Active DDM NCM Download Block to Display Command Driver Front Door Lock Status - Lock(ed) AUDIO Download Block to Display Command DDM NCM Display Access Terminate Command Driver Front Door Lock Cylinder State Status AUDIO Display Access Terminate Command REM NCM Display Access Display String Command - Overwrite Display Driver Front Door Lock Command - Unlock(ed) AUDIO Display Access Display String Command - Overwrite Display REM NCM Display Access Display String Command - Clear Display Driver Front Door Lock Command - Lock(ed) AUDIO Display Access Display String Command - Clear Display IC AUDIO Cellular Phone+A131 in Use Status - Yes (True) Display Access Confirmation Status - Reject AUDIO Cellular Phone in Use Status - No (False) IC REM Display Access Confirmation Status - Accept REM Brake Lamp Pedal Switch Status - Inactive IC Backlighting Intensity and Dimming Curve with Headlamps Command - On Brake Lamp Pedal Switch Status - Active IC Source Backlighting Intensity and Dimming Curve with Headlamps Command - Off Message Name X X PBM X X X X X X X X REM X X X X X X FEM X X X X X X X X X X X X X X X X X X X X IC X X X X NCM X X X X X X AUDIO Receivers X X X X DDM X X DSM RMM SCLM Appendix Jaguar XJ 2004 SCP Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 AUDIO AUDIO NCM NCM NCM NCM NCM NCM NCM NCM Gateway AUDIO to NCM Gateway AUDIO to NCM (Multiframe) Gateway Display to CCM Gateway NCM to AUDIO Gateway NCM to CPM (AT Cmd) (continuation frame) Gateway NCM to CPM (AT Cmd) (first frame) Gateway NCM to CPM (D2B Opc) (continuation frame) Gateway NCM to CPM (D2B Opc) (first frame) Gateway NCM to SMS (SMS Data) (continuation frame) Gateway NCM to SMS (SMS Data) (first frame) IC Gateway CCM to VAM Fuel Level - Sensor Analog / Digital Output Status IC REM Fuel Input / Output Status Gateway CCM to Display FEM REM Front Windshield Wiper Mode Status PBM PBM Mode IC PBM Electric Park Brake Fault Status Engine RPM with High Resolution Rate-of-Change with Throttle Position Status REM REM Driver Rear Door Ajar Switch Status - Inactive Driver Rear Seat Heater Current Status REM Driver Rear Door Ajar Switch Status - Active IC DDM Driver Front Super / Double Door Lock Status - Lock(ed) Driver Rear Seat Heater Command - On REM Driver Front Super / Double Door Lock Command - Unlock(ed) IC REM Driver Front Super / Double Door Lock Command - Lock(ed) Driver Rear Seat Heater Command - Off FEM Driver Front Seat Heater Current Status REM Driver Front Door Unlock Enable Status - Enable(d) IC REM Driver Front Door Unlock Enable Status - Disable(d) Driver Front Seat Heater Command - On NCM Driver Front Door Unlock Enable Command - Enable(d) IC NCM Driver Front Door Unlock Enable Command - Disable(d) Driver Front Seat Heater Command - Off Source Message Name X PBM X X X X X X REM X X X X X FEM X X X X X X X X X X IC X X X X X NCM X X X X X X X X X X AUDIO Receivers X X X X DDM DSM RMM SCLM Jaguar XJ 2004 Appendix SCP Message Matrix v vi FEM FEM FEM IC IC Illuminated Entry Command - On Interior Component Theft Switch Status Key-in-Ignition Status - No (False) Key-in-Ignition Status - Yes (True) IC Ignition Switch Position with Initialize Status - Yes (True) Illuminated Entry Command - Off IC Ignition Switch Position with Initialize Status - No (False) REM AUDIO Gateway VAM to NCM Horn Configuration 3 Command - Enable(d) AUDIO Gateway VAM to CCM REM AUDIO Gateway VEMS to NCM (D2B Opc) (first frame) Horn Configuration 2 Command - Enable(d) AUDIO Gateway VEMS to NCM (D2B Opc) (continuation frame) REM AUDIO Gateway VEMS to NCM (AT Cmd) (first frame) Horn Configuration 1 Command - Enable(d) AUDIO Gateway VEMS to NCM (AT Cmd) (continuation frame) REM AUDIO Gateway SMS to NCM (SMS Data) (first frame) Horn Configuration 1 Command - Disable(d) AUDIO Gateway SMS to NCM (SMS Data) (continuation frame) FEM AUDIO Gateway CPM to NCM (D2B Opc) (first frame) Hood Door Ajar Switch Status - Inactive AUDIO Gateway CPM to NCM (D2B Opc) (continuation frame) FEM AUDIO Gateway CPM to NCM (AT Cmd) (first frame) Hood Door Ajar Switch Status - Active AUDIO Gateway CPM to NCM (AT Cmd) (continuation frame) IC NCM Gateway NCM to VAM IC NCM Gateway NCM to VEMS (D2B) (continuation frame) Heated Steering Wheel Command - On NCM Gateway NCM to VEMS (D2B) (first frame) Heated Steering Wheel Command - Off NCM Gateway NCM to VEMS (AT Cmd) (first frame) FEM NCM Gateway NCM to VEMS (AT Cmd) (continuation frame) Heated Steering Wheel Current Status Source Message Name X X X X PBM X X X X X X X REM X X X X X X X X X X FEM X X X X IC X X X X X X X X X X X X X X NCM X X X X X X X X AUDIO Receivers X X X X X X DDM X X X X DSM X X RMM SCLM Appendix Jaguar XJ 2004 SCP Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 FEM IC REM RMM Network Bus Wake-up Command - Yes (True) Network Bus Wake-up Command - Yes (True) Network Bus Wake-up Command - Yes (True) Network Bus Wake-up Command - Yes (True) Only or Rear Center Fuel Door Lock Command - Unlock(ed) FEM IC PBM Network Bus Wake-up Command - Yes (True) Odometer Rolling Count Status DSM Network Bus Wake-up Command - Yes (True) IC Memory Features Recall Cancel Command - Yes (True) DDM FEM Memory Features Recall Cancel Command - Yes (True) Network Bus Wake-up Command - Yes (True) DSM Memory Features Recall Cancel Command - Yes (True) AUDIO DDM Network Bus Wake-up Command - Yes (True) DDM IC Memory Feature Menu Status Memory Features Recall Cancel Command - Yes (True) FEM Low Washer Fluid Tell Tale Command - On Memory Features 3 Command - Set / Save FEM Low Washer Fluid Tell Tale Command - Off DDM IC Low Fuel Level Status - Yes (True) Memory Features 3 Command - Recall IC Low Fuel Level Status - No (False) DDM IC Left Side Turn Signal Turn Lamp Command - On Memory Features 2 Command - Set / Save IC Left Side Turn Signal Turn Lamp Command - Off DDM FEM Left Side Mid Vehicle Turn Lamp OK Status - Yes (True) Memory Features 2 Command - Recall FEM Left Side Mid Vehicle Turn Lamp OK Status - No (False) DDM REM Left Rear Turn Lamp OK Status - Yes (True) Memory Features 1 Command - Set / Save REM Left Rear Turn Lamp OK Status - No (False) DDM FEM Left Front Turn Lamp OK Status - Yes (True) Memory Features 1 Command - Recall FEM Source Left Front Turn Lamp OK Status - No (False) Message Name PBM X X X REM X X X X X X X X X X X X FEM X X X X X X X X X X X X X X X X X IC X X X NCM AUDIO Receivers X X X DDM X X X X X X X X X X DSM RMM SCLM Jaguar XJ 2004 Appendix SCP Message Matrix vii viii DDM FEM FEM Request All Door Lock Status Request All Door Lock Status Request All Front Fog Lamp Command AUDIO Remote control #1 Button status - Button 7 (PTT) Active DDM AUDIO Remote control #1 Button status - Button 6 (VOL+) Active Remote Panic Command - Enable(d) AUDIO Remote control #1 Button status - Button 5 (VOL-) Active AUDIO AUDIO Remote control #1 Button status - Button 4 (SELECT) Active Remote control #1 Button status - Button Inactive AUDIO REM Passenger's Rear Door Ajar Switch Status - Inactive Remote control #1 Button status - Button 3 (SEEK UP) Active REM Passenger's Rear Door Ajar Switch Status - Active AUDIO DDM Passenger's Mirror Up Motion Command - Enable(d) Remote control #1 Button status - Button 2 (SEEK DOWN) Active DDM Passenger's Mirror Right Motion Command - Enable(d) DDM DDM Passenger's Mirror Left Motion Command - Enable(d) Remote All Door Super/Double Lock Command - Unlock DDM Passenger's Mirror Left Motion Command - Disable(d) DDM DDM Passenger's Mirror Down Motion Command - Enable(d) Remote All Door Super/Double Lock Command - Lock REM Passenger's Glove Box Door Lock Status - Unlock FEM REM Passenger's Glove Box Door Lock Status - Lock REM FEM Passenger’s Front Seat Heater Current Status Pedal Adjustment Status - Disable(d) IC Passenger's Front Seat Heater Command - On Passenger’s Rear Seat Heater Current Status IC Passenger's Front Seat Heater Command - Off IC FEM Passenger's Front Door Ajar Switch Status - Inactive Passenger's Rear Seat Heater Command - On FEM Passenger's Front Door Ajar Switch Status - Active IC PBM Parking Brake Switch Status - Inactive Passenger's Rear Seat Heater Command - Off PBM Source Parking Brake Switch Status - Active Message Name PBM X X X X X X X X X REM X X X X X X X X X X X X X FEM X X X X X X X X X X IC X X X X X X X NCM X X X X X X AUDIO Receivers X X X X DDM DSM RMM SCLM Appendix Jaguar XJ 2004 SCP Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 FEM REM NCM FEM REM REM Request All Park Lamp Command Request All Park Lamp Command Request All Park Lamp Status Request All Photo Cell Dark Status Request All Rear Brake Lamp Command Request All Rear Fog Lamp Command DSM FEM IC REM RMM REM Request Driver Front Door Ajar Switch Status Request Driver Front Door Ajar Switch Status Request Driver Front Door Ajar Switch Status Request Driver Front Door Ajar Switch Status Request Driver Front Door Lock Cylinder State Status IC Request Decklid Door Ajar Switch Status AUDIO FEM Request Decklid Door Ajar Switch Status Request Driver Front Door Ajar Switch Status DDM Request Decklid Door Ajar Switch Status Request Driver Front Door Ajar Switch Status PBM Request Brake Lamp Pedal Switch Status PBM Request Anti-Lock Brake System Active Status NCM REM Request Alternator Failure Telltale Status Request Backlighting Intensity and Dimming Curve with Headlamps Command FEM Request Alternator Failure Telltale Status FEM RMM Request All Rear Window Operation Enable Command Request Backlighting Intensity and Dimming Curve with Headlamps Command REM Request All Rear Window Operation Enable Command AUDIO DSM Request All Rear Window Operation Enable Command Request Backlighting Intensity and Dimming Curve with Headlamps Command REM Request All Rear Park Lamp Command IC FEM Request All Headlamp Command Request All Rear Fog Lamp Status IC FEM Request All Front Window Operation Enable Command FEM Request All Front High Beam Lamp Command Request All Front High Beam Lamp Status IC Source Request All Front Fog Lamp Status Message Name PBM X X X X X REM X X X FEM X X X X X X X X X X X X X IC NCM AUDIO Receivers X X X X X X X X X X X DDM DSM RMM SCLM Jaguar XJ 2004 Appendix SCP Message Matrix ix x DSM FEM RMM Request Memory Feature Menu Status Request Memory Feature Menu Status IC NCM Request Memory Feature Menu Status Request Low Washer Fluid Telltale Command Request Low Fuel Level Status IC RMM Request Key-in-Ignition Status IC REM Request Key-in-Ignition Status Request Left Side Mid Vehicle Turn Lamp OK Status FEM Request Key-in-Ignition Status Request Left Rear Turn Lamp OK Status PBM Request Key-in-Ignition Status IC DSM Request Key-in-Ignition Status Request Left Front Turn Lamp OK Status REM RMM Request Ignition Switch Position with Initialize Status DDM REM Request Ignition Switch Position with Initialize Status Request Key-in-Ignition Status NCM Request Ignition Switch Position with Initialize Status Request Interior Component Theft Switch Status FEM Request Ignition Switch Position with Initialize Status REM Request Hood Door Ajar Switch Status PBM IC Request Hood Door Ajar Switch Status Request Ignition Switch Position with Initialize Status IC Request Fuel Input / Output Status DSM IC Request Front Windshield Wiper Mode Status Request Ignition Switch Position with Initialize Status IC Request PBM Mode DDM IC Request Driver Rear Door Ajar Switch Status AUDIO FEM Request Driver Rear Door Ajar Switch Status Request Ignition Switch Position with Initialize Status DDM Request Driver Rear Door Ajar Switch Status Request Ignition Switch Position with Initialize Status AUDIO REM Source Request Driver Rear Door Ajar Switch Status Request Driver Front Door Lock Status Message Name X PBM X X X X X X REM X X X X X X X FEM X X X X X X X X X X X X X X X X X X IC NCM AUDIO Receivers X DDM DSM RMM SCLM Appendix Jaguar XJ 2004 SCP Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 IC IC IC Request Right Rear Turn Lamp OK Status Request Right Side Mid Vehicle Turn Lamp OK Status Request Steering Column Lock System Status REM FEM FEM IC IC Right Rear Turn Lamp OK Status - Yes (True) Right Side Mid Vehicle Turn Lamp OK Status - No (False) Right Side Mid Vehicle Turn Lamp OK Status - Yes (True) Right Side Turn Signal Turn Lamp Command - Off Right Side Turn Signal Turn Lamp Command - On FEM Right Front Turn Lamp OK Status - No (False) FEM FEM Request Vehicle Speed Control Active Status REM DDM Request Vehicle Inertia Switch #1 Status Right Rear Turn Lamp OK Status - No (False) FEM Request Vehicle Configuration Valet Mode Status Right Front Turn Lamp OK Status - Yes (True) DDM IC Request Vehicle Configuration Valet Mode Status Request Vehicle Configuration Trailer Connected Status NCM IC Request Right Front Turn Lamp OK Status RMM IC Request Passenger's Rear Door Ajar Switch Status Request Vehicle Configuration Status FEM Request Passenger's Rear Door Ajar Switch Status Request Transmission Park / Neutral Switch Status DDM Request Passenger's Rear Door Ajar Switch Status DSM AUDIO Request Passenger's Rear Door Ajar Switch Status Request Transmission Park / Neutral Switch Status FEM Request Passenger's Glove Box Door Lock Status DDM REM Request Passenger's Front Door Ajar Switch Status Request Transmission Park / Neutral Switch Status IC Request Passenger's Front Door Ajar Switch Status FEM DDM Request Passenger's Front Door Ajar Switch Status Request Transmission Park / Neutral Switch Status AUDIO Request Passenger's Front Door Ajar Switch Status REM AUDIO Request Parking Brake Switch Status Request Transmission Park / Neutral Switch Status Source Message Name X PBM X X X X X X X X X X X X X REM X X X X X X X X X FEM X X X X X X X X X X X X IC NCM AUDIO Receivers X DDM DSM RMM X SCLM Jaguar XJ 2004 Appendix SCP Message Matrix xi xii FEM REM FEM REM SCLM Steering Column Lock Enable Status - Off Steering Column Lock Enable Status - Off Steering Column Lock Enable Status - On Steering Column Lock Enable Status - On Steering Column Lock System Status Vehicle Configuration Module Programmed Status - Yes (True) REM REM RMM Vehicle Configuration Module Programmed Status - Yes (True) Vehicle Inertia Switch #1 Status - Active FEM Vehicle Configuration Module Programmed Status - Yes (True) REM DSM Vehicle Configuration Module Programmed Status - Yes (True) Vehicle Configuration Valet Mode Status - Inactive DDM Vehicle Configuration Module Programmed Status - Yes (True) REM RMM Vehicle Configuration Module Programmed Status - No (False) Vehicle Configuration Valet Mode Status - Active REM Vehicle Configuration Module Programmed Status - No (False) REM FEM Vehicle Configuration Module Programmed Status - No (False) Vehicle Configuration Trailer Connected Status - Yes DSM Vehicle Configuration Module Programmed Status - No (False) REM DDM Vehicle Configuration Module Programmed Status - No (False) Vehicle Configuration Trailer Connected Status - No AUDIO IC Transmission PRNDL Range Selected Status Vehicle Configuration Module Programmed Status - No (False) IC Transmission Park / Neutral Switch Status-Inactive AUDIO Time of Day (with Mode) Status IC NCM Terminate Display Definition Command Transmission Park / Neutral Switch Status-Active AUDIO Terminate Display Definition Command IC IC Steering Column Lock Enable Command - On Terminate Display Confirmation Status - Reject IC Steering Column Lock Enable Command - Off IC IC Steering Column Lock Command - Unlock Terminate Display Confirmation Status - Accept IC Source Steering Column Lock Command - Lock Message Name X PBM X X X X X REM X X X X X X X FEM X X X X X X X X X X X X X X X X X X X X IC X X X X NCM X X AUDIO Receivers X X X X X X DDM X X X DSM X X RMM X X SCLM Appendix Jaguar XJ 2004 SCP Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 AUDIO NCM Voice Control Mode Status - On Voice Training Mode Entry IC Vehicle Speed - Driven and Undriven Wheels - High Resolution Status AUDIO IC Vehicle Speed Control Active Status - Yes (True) Voice Control Mode Status - Off IC REM Source Vehicle Speed Control Active Status - No (False) Vehicle Inertia Switch #1 Status - Inactive Message Name X PBM X REM X X X FEM X X IC NCM X X AUDIO Receivers X X DDM X DSM X RMM SCLM Jaguar XJ 2004 Appendix SCP Message Matrix xiii xiv ECM TCM CAN flash program ECM WDS CAN flash program TCM WDS ECM ECM ECM ECM TCM TCM TCM TCM TCM DSCM DSCM DSCM DSCM DSCM DSCM CAN indicated engine torque CAN engine friction torque CAN actual engine torque CAN driver demand torque CAN torque reduction request CAN transmission torque limit CAN torque converter slip CAN transmission input speed CAN transmission output speed CAN ABS configuration CAN vehicle reference speed CAN ABS fault codes CAN ODO rolling count CAN ABS malfunction CAN OBD ABS clear acknowledge DSCM DSCM CAN steering wheel speed CAN TCS engine torque control DSCM CAN steering wheel angle DSCM DSCM CAN lateral acceleration signal CAN traction shift map DSCM CAN yaw rate signal DSCM DSCM CAN brake line pressure CAN ABS status DSCM CAN engine drag torque request DSCM DSCM CAN temporary torque request CAN ABS fault code MIL status DSCM CAN engine torque request IC WDS CAN flash program WDS TCM CAN ignition off timer WDS Source CAN flash program WDS ECM Message Name X X X X X DSCM X X X X X X X X X X X X X X X X ECM X X X X X X X X X X X TCM X X X X X IC X X X X X ASCM X X CCM Receivers RCCM JGM X X X X ASM X X WDS Appendix Jaguar XJ 2004 CAN Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 DSCM DSCM ECM ECM ECM ECM ECM ECM ECM ECM ECM ECM ECM ECM ECM ECM ASCM ASCM ASCM ASCM ASCM ASCM ASCM ASCM ASCM ASCM ECM ECM ECM ECM ECM CAN yaw control CAN DSC switch status CAN transmission input indicated torque CAN engine acceleration CAN throttle position CAN accelerator pedal position CAN engine speed CAN alternator status CAN cruise status CAN kickdown CAN OBD II clear fault codes CAN brake pedal pressed CAN crank in progress CAN traction acknowledge CAN inhibit ASM compressor CAN fuel cap warning CAN ASC display commands CAN headway setting CAN follow warning light CAN display set speed CAN follow speed CAN brake demand pressure CAN ASC status CAN ASCM configuration flag CAN active brake booster enable CAN spare ASCM CAN set speed CAN target speed CAN ECM ASC fail CAN headway increment CAN cancel request DSCM DSCM CAN TCS brake control CAN brake actual pressure Source Message Name X X X X X X X X X X X DSCM X X X X X ECM X X X X X X X X X X X X TCM X X X X X X X X X X X X X X X IC X X X X X X X X X X X ASCM X X X CCM Receivers X X RCCM X X JGM X X X X ASM WDS Jaguar XJ 2004 Appendix CAN Message Matrix xv xvi TCM TCM TCM TCM CAN gear position actual CAN gear position selected CAN transmission shift map CAN transmission oil temperature JGM CAN J-gate fault JGM JGM CAN traction mode switch CAN performance mode switch JGM IC CAN backlight intensity CAN intermediate position fault IC CAN backlight status JGM IC CAN trailer connected CAN J-gate position selected IC CAN IC ASC enable ASM IC CAN trip units CAN damper status IC CAN natural light ASM IC CAN wiper status CAN over gross vehicle weight IC CAN indicator left ASM IC CAN indicator right CAN vehicle too low IC CAN fuel pump status ASM IC CAN fuel level raw 2 CAN CATS fault IC CAN fuel level raw 1 ASM IC CAN fuel level damped ASM IC CAN restricted climate control blowers CAN ASM fault IC CAN ASM compressor status IC DSCM CAN active brake booster status CAN dipped beam status DSCM CAN bake pressure demand acknowledge CAN parking brake status Source Message Name X X DSCM X X X X X X X X X X X X X X X X ECM X X X X X TCM X X X X X IC X X X X X X X X X X X X X ASCM X X CCM Receivers RCCM X X JGM X ASM WDS Appendix Jaguar XJ 2004 CAN Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 TCM TCM TCM TCM TCM TCM TCM TCM TCM TCM ECM ECM ECM ECM ECM ECM CCM CCM CCM CCM CCM CCM ECM ECM ECM ECM ECM ECM ECM ECM CAN torque converter status CAN gear selection fault CAN idle neutral control CAN performance mode indication CAN TCM fault code MIL status CAN OBD TCM clear acknowledge CAN transmission fault codes CAN gear position target CAN J-gate selection fault CAN torque converter multiplication CAN pressure transducer CAN engine intake temperature CAN A/C compressor clutch inhibit command CAN electrical load management CAN A/C load control CAN cooling fan feedback CAN ambient temperature CAN A/C status CAN A/C load status CAN cooling fan request CAN configuration control CAN solenoid current CAN fuel used CAN engine OBD MIL CAN throttle malfunction red CAN throttle malfunction amber CAN ECM fault code MIL status CAN ECM configuration flag CAN engine fault codes CAN engine coolant temperature ECM TCM CAN TCM configuration flag CAN SC fuel pump 2 warning TCM Source CAN transmission malfunction Message Name X X DSCM X X X X X X X X X X X X X X X ECM X X X TCM X X X X X X X X X X IC ASCM X X X X X X X CCM Receivers X RCCM X X X JGM X ASM WDS Jaguar XJ 2004 Appendix CAN Message Matrix xvii xviii ECM CCM RCCM CAN steering wheel power save command CAN front to rear climate control status CAN rear to front climate control status CCM RCCM ECM WDS CAN rear climate control display status CAN powertrain configuration CAN diagnostic data in ASCM IC CCM CAN climate control display status CAN display climate control command CAN climate control voice status IC ECM CAN LH rear seat heat power save command CAN voice climate control command ECM IC CAN steering wheel power status CAN RH rear seat heat power save command IC CAN rear fog status ECM IC CAN front fog status CAN passenger seat heat power save command IC CAN sidelight status ECM IC CAN main beam status CAN driver seat heat power save command IC CAN LH rear seat heat power status DSCM CAN wheel speed sensor fault IC DSCM CAN undriven wheel speed CAN RH rear seat heat power status DSCM CAN driven wheel speed IC DSCM CAN RH rear wheel speed IC DSCM CAN LH rear wheel speed CAN front passenger seat heat power status DSCM CAN RH front wheel speed CAN driver seat heat power status DSCM CAN LH front wheel speed IC ECM CAN barometric pressure CAN odometer reading ECM Source CAN engine oil temperature Message Name X DSCM X X X X X X X X X X X X X X ECM X X X X X X X X TCM X X X X X X X X X X X IC X X X X X ASCM X X X X X X X X CCM Receivers X X X RCCM JGM X ASM WDS Appendix Jaguar XJ 2004 CAN Message Matrix DATE OF ISSUE: April 2003 DATE OF ISSUE: April 2003 WDS RCCM WDS WDS WDS WDS ECM TCM CAN diagnostic data in RCCM CAN diagnostic data out RCCM CAN diagnostic data in ECM CAN diagnostic data in TCM CAN diagnostic data in IC CAN diagnostic data in DSCM CAN diagnostic data out ECM CAN diagnostic data out TCM CAN diagnostic data out DSCM DSCM IC ASM CAN diagnostic data out ASM CAN diagnostic data out IC CCM WDS WDS CAN diagnostic data in RCCM CAN diagnostic data in ASM ASCM CAN diagnostic data out ASCM CAN diagnostic data out RCCM Source Message Name X DSCM X ECM X TCM X IC ASCM X CCM Receivers X RCCM JGM X ASM X X X X X X X X WDS Jaguar XJ 2004 Appendix CAN Message Matrix xix
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project
Related manuals
advertisement