Gardena Water Pump 5000 S Operating instructions

®
GARDENA
5000 S
D
Gebrauchsanweisung
Tauchpumpe
GB Operating Instructions
Submersible Pump
F
Mode d’emploi
Pompe d’évacuation pour eaux claires
NL Gebruiksaanwijzing
Dompelpomp
S Bruksanvisning
Dränkbar pump
I
Istruzioni per l’uso
Pompa sommersa
E Manual de instrucciones
Bomba sumergible
P Instruções de utilização
Bomba submersível
DK Brugsanvisning
Dykpumpe
Art. 1778
G
G
GARDENA Submersible Pump 5000 S
Welcome to the garden of GARDENA ...
2. For Your Safety
Residual-current device
According to DIN VDE (German Electrical Engineers’ Association) 0100, submersible pumps may only be used in swimming
pools, garden ponds, and fountains if the pump is operated via a
residual-current device with a residual-current rating of ≤ 30 mA.
The pump must not be operated
when there are persons in the swimming pool or garden pond.
For safety reasons we recommend that you always operate
the submersible pump via a residual-current device (DIN VDE
0100-702 and 0100-738).
v Please contact your electrician.
In Austria
In Austria, according to ÖVE B / EN 60 555 part 1 to 3, pumps
which are used in swimming pools and garden ponds, and
equipped with firm power cable should be fed via an ÖVE
approved isolating transformer – rated voltage must not exceed
230 V.
In Switzerland
In Switzerland mobile appliances which are used outdoors,
must be connected via a residual-current device.
Mains power
According to DIN VDE (German Electrical Engineers’ Association) 0620, mains power cables must not have a smaller crosssection than the rubber-sheathed cables of the designation
H05 RNF. The cable length must be at least 10 m.
Data indicated on the type plate must match technical data of
the mains supply.
v Take care that the electrical connections are made within dry
area, protected from flooding.
Protect plug and power cable from heat, oil and sharp edges.
v Don’t use the power cable for plugging off.
The power cable or the float switch must not be used for mounting or relocating the pump. For submerging or lifting / securing
the pump, fix a rope to the pump’s carrying handle.
Extension cables must meet the requirements of DIN VDE 0620.
Visual check
v Before operating the pump, first make a visual check, if there
is any damage of the pump (esp. regarding power cable and
plug).
v Observe the minimum water level and the max. delivery
height (see 8. Technical Data).
A damaged pump must not be used.
v In case of damage, please have the pump checked by our
GARDENA Service Centre.
Manual operation
During manual operation, the pump must be switched off as
soon as all the liquid has been pumped away.
v Observe the pump at all times during manual operation.
Notes on use
v Clear the outlet line before use.
Dry-running operation causes increased wear and is to be
avoided. Therefore, in manual operation the pump must be
immediately unplugged when water fails to flow.
Please read these operating instructions carefully and observe
the notes given. Use the instructions to familiarise yourself with
the submersible pump, its correct use, and the notes on safety.
For safety reasons, children under 16 as well as persons not
familiar with these operating instructions should not use this
submersible pump.
v Keep these operating instructions in a safe place.
Contents
1.
2.
3.
4.
5.
6.
7.
8.
9.
Applications Range of Your GARDENA Submersible Pump . . 10
For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Initial Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Trouble-Shooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
1. Applications Range of Your GARDENA Submersible Pump
Intended use
GARDENA Submersible Pumps have been designed for private
use around your house and garden. They are predominantly destinated for drainage after flooding, transfer of liquids, draining containers, taking water from wells and shafts, draining boats and
yachts as well as for water aeration and circulation for a limited
period of time.
Liquids to be pumped
Liquids which can be handled by the GARDENA Submersible
Pump are the following: clean and slightly contaminated water
(max. particle size 5 mm), swimming pool water (prerequisite
is the recommended dosage of additives) and soapy water.
The pump is fully submersible (waterproof sealed) and can be
immersed in the liquid down to a depth of 9 m.
Please note
10
The GARDENA Submersible Pumps are not designed for
continuous operation (e.g. continuous circulating operation) in a pond. Your pump’s life will be shortened correspondingly by such operation.
Corrosive, easily combustible or explosive substances
(e.g. gasoline, petroleum, nitro thinner), fats, oils, salt-water
and waste water of toilets and urinals must not be pumped.
The temperature of the liquid handled should not exceed
35 °C.
11
G
G
Avoid running of the pump for more than 10 min. against closed
delivery side of the pump.
Sand and other abrasive substances cause increased wear and
reduce the pump’s output.
Take care that the pump is located where the inlet openings at
the suction base are obstructed neither completely nor partly.
Stand the pump on a brick if using in a pond.
Thermal motor protector
Automatic deaerating
valve
The universal fitting 7 allows you to connect all the hoses listed
in the previous table.
1. Cut off nipples of the universal fitting 7, which are not needed,
to match the hose connection.
2. Screw the universal fitting 7 onto the pump.
3. Connect the hose to the universal fitting 7.
We recommend that you secure 38 mm (1 1/ 2 ”) and 25 mm (1”)
hoses additionally with a GARDENA Hose Clip Art. No. 1591.
Connecting the hose :
The pump is automatically switched off on overheating by
the built-in thermal motor protector. After having cooled down,
the motor automatically switches on again (see 6. Trouble
Shooting).
The automatic deaerating valve eliminates any air pockets in
the pump. If the water level drops below the vent valve, some
water flows penetrates outside through the vent valve 4.
This is not a defect of your pump, but serves to deaerate the
pump.
4
7
4. Operation
To ensure that the pump draws the water out, the water to be
drained must be at least 45 mm deep.
The float switch 5 turns the pump on automatically when the
water level exceeds the cut-in height and the water is pumped out.
Automatic operation :
1
The float switch 5 turns the pump off again as soon as the water
level falls below the cut-out height.
1. Stand the pump on a firm surface – or –
use a rope attached to the carrying handle 2 to immerse the
pump in a well or shaft.
During automatic operation, ensure that the float switch 5
can move freely.
2. Plug the power cable 1 into a mains socket.
2
3. Initial Operation
13 mm (1/ 2 ”)
15 mm (5 / 8”)
19 mm (3 /4”)
Hose diameter
3
25 mm (1”)
38 mm (1 1/ 2 ”)
4
7
5
a
b
6
7
Hose connection
of universal fitting
Hose connection
5
7
Cut off topmost
nipple at a.
Do not cut off
any nipples.
Cut off top two
nipples at b.
The following connection kits are required for 13 mm to 19 mm
connections:
13 mm (1/ 2 ”): GARDENA Pump Connection Set, Art. No. 1750
15 mm (5/ 8 ”): GARDENA Tap Connector, Art. No. 902, and
Standard Hose Connector, Art. No. 916
19 mm (3 /4 ”): GARDENA Pump Connection Set, Art. No. 1752
Best results in delivery capacity are achieved when using 38 mm
(1 1/ 2 ”) hoses.
12
Only for 13 mm (1/ 2”) hose :
The universal fitting 7 can also be equipped with a GARDENA
Regulator Valve Art. No. 977 so that the contents of the outlet line do not flow back through the pump after pumping.
The Regulator Valve can be ordered from GARDENA Service.
Manual
operation :
1
2
Adjusting the Cut-in and Cut-out Height :
The maximum cut-in height and minimum cut-out height (see
8. Technical Data) can be adjusted.
v Push the cable of the float switch 5 into the float switch lock 3.
Do not select a cable length that is too long or short to ensure
that the float switch can turn on and off properly.
• The shorter the length of cable between the float switch 5
and the float switch lock 3, the lower the cut-in height and the
higher the cut-out height.
The pump remains in constant operation because the float switch
is bypassed.
1. Stand the pump on a firm surface – or –
use a rope attached to the carrying handle 2 to immerse the
pump in a well or shaft.
2. Plug the power cable 1 into a mains socket.
3. Fix float switch 5 vertically above the pump (with the cable
at the bottom).
As long as the float switch is positioned vertically above the
pump, the pump will operate regardless of the water level.
The residual water height of approx. 5 mm is only reached
during manual operation since the float switch turns off the
pump during automatic operation before this water level is
reached.
13
G
G
5. Cleaning
Attention !
Flushing the Pump :
Cleaning the suction
base and turbine :
9
6
8
The pumps are virtually maintenance-free.
After having pumped chlorinated swimming pool water or other
liquids leaving residues, the pump should be rinsed with clear
water.
A
Warning ! Electric shock !
Risk of injury due to electric shock.
V Disconnect the pump from the mains before cleaning the suction base and turbine.
1. Unscrew the 3 Phillips screws 8 and pull the suction base 6
off the pump.
2. Clean the suction base 6 and the turbine 9.
3. Reinstall the suction base 6 and screw in the Phillips screws 8.
For safety reasons a damaged turbine 9 can only be exchanged by the GARDENA Service Centre.
6. Trouble-Shooting
Repairs on electrical parts should only be done by our
GARDENA Service Centres.
If you have any problems with your Pump, please contact our Service.
7. Storage
Frost-free storage
Store the pump away from frost before the first frost sets in.
8. Technical Data
Type
5000 S (Art. No. 1778)
Rated power
200 W
Max. delivery capacity
5,000 l / h
Max. pressure
0.5 bar
Max. delivery height
5m
Max. submersion depth
9m
Problem
Probable cause
Remedy
Flat suction down to approx.
5 mm
Pump is running,
but doesn’t deliver.
Air cannot escape, since
pressure line is closed.
v Open pressure line
(e.g. kinked pressure pipe).
Contaminated water with
particle size of max.
5 mm
v Wait for max. 60 seconds
until the pump deaerates
automatically over the vent
valve. If necessary, switch
off and start it again.
Power cable
10 m H05 RNF
Pump connection
38 mm (1 1/ 2 ”) / 25 mm (1”) graduated nipple,
option GARDENA Water hose Plug-in-system
Min. water level for operation
45 mm
Weight approx.
4.0 kg
Max. media temperature
35 °C
Mains voltage /
mains frequency
230 V / 50 Hz
Min.cut-in height
380 mm
Min./ max. cut-out height
100 mm / 140 mm
Air locks in the suction base.
Turbine clogged.
Pump doesn’t start or
suddenly stops during
operation.
Pump runs, but output
suddenly decreases.
14
v Disconnect plug and clean
turbine (see 5. Cleaning).
When starting the pump,
water height falls below the
min. water level.
v Submerge pump deeper.
Thermal overload switch has
switched the pump off due
to overheating.
v Disconnect plug and clean
turbine (see 5. Cleaning).
Observe max. media temperature of 35 °C.
No power.
v Check fuses and electric
connections.
Dirt particles are jammed
in the suction base.
v Disconnect plug and clean
suction base (see 5. Cleaning).
Suction base is clogged.
v Disconnect plug and clean
suction base (see 5. Cleaning).
Noise level
L WA1)
46 dB (A)
1) Measuring method according to EN 60335 -1
Cut-in / Cut-out height
The cut-in and cut-out height varies.
The residual water depth (draining in the flat position down
to approx. 5 mm) is only reached during manual operation
(see 4. Operation).
Safety and
Approval
The GARDENA Submersible Pump is manufactured in accordance
with the current electrical safety regulations of the Appliance
Safety Law (GSG) and inspected by the TÜV (German institution
for technical surveillance).
15
G
Performance characteristics
G
m
bar
5
0.5
4
0.4
EU Certificate of Conformity
The undersigned
GARDENA Kress + Kastner GmbH · Hans-Lorenser-Str. 40 · D-89079 Ulm
500
0S
3
0.3
This certificate becomes void if the unit is modified without our approval.
2
0.2
1
0.1
0
0
1000
2000
3000
4000
Description of the units :
Types :
Art. No. :
EU directives :
5000
l/h
Harmonised
European standards :
9. Service
Warranty
hereby certifies that, when leaving our factory, the unit indicated below is in accordance with the
harmonised EU guidelines, EU standards of safety and product specific standards.
GARDENA guarantees this product for 2 years (from date of
purchase). This guarantee covers all serious defects of the unit
that can be proved to be material or manufacturing faults. Under
warranty we will either replace the unit or repair it free of charge
if the following conditions apply:
• The unit must have been handled properly and in keeping
with the requirements of the operating instructions.
• Neither the purchaser or a non-authorised third party have
attempted to repair the unit.
The turbine is a wearing part and is not covered by the guar-antee.
This manufacturer’s guarantee does not affect the user’s existing
warranty claims against the dealer / seller.
Year of CE marking :
Submersible Pump
5000 S
1778
Machinery Directive 98 / 37/ EC
Electromagnetic Compatibility 89 / 336 / EC
Low Voltage Directive 73 / 23 / EC
Directive 93 / 68 / EC
EN 292 -1
EN 292 - 2
EN 60335 -1
EN 60335 - 2 - 41
2002
Ulm, 29.05.2001
Thomas Heinl
Technical Dept. Manager
If you have any problems with your pump, please contact our
Customer Service or return the defective unit together with
a short description of the problem directly to one of the
GARDENA Service Centres listed on the back of this leaflet.
Product Liability
16
We expressly point out that, in accordance with the product
liability law, we are not liable for any damage caused by our units
if it is due to improper repair or if parts exchanged are not original
GARDENA parts or parts approved by us, and, if the repairs were
not carried out by a GARDENA Service Centre or an authorised
specialist. The same applies to spare parts and accessories.
17
Deutschland
GARDENA Kress + Kastner GmbH
GARDENA Service
Hans-Lorenser-Straße 40
D-89079 Ulm
Produktfragen: (07 31) 490 - 123
Reparaturen: (07 31) 490 - 290
Argentina
Argensem S.A.
Venezuela 1075
(1618) El Talar - Buenos Aires
Australia
NYLEX Corporation Ltd.
25 - 29 Nepean Highway
P.O. Box 68
Mentone, Victoria 3194
Austria
GARDENA Österreich Ges. m.b.H.
Stettnerweg 11-15
2100 Korneuburg
Belgium
MARKT (Belgium) NV/ SA
Sterrebeekstraat 163
1930 Zaventem
Brazil
M. Cassab
Av. das Nações Unidas, 20.882
Santo Amaro, CEP 04795-000
São Paulo - S.P.
Bulgaria / България
ДЕНЕКС ООД
Бул. ”Г.М.Димитров” 16 ет.4
София 1797
Canada
GARDENA Canada Ltd.
100, Summerlea Road
Brampton, Ontario
Canada L6T 4X3
Chile
Antonio Martinic Y CIA. LTDA.
Gilberto Fuenzalida 185 Loc.
Las Condes - Santiago de Chile
Costa Rica
Compania Exim
Euroiberoamericana S.A.
350 Sur del Automercado
Los Yoses
San Pedro
Cyprus
FARMOKIPIKI LTD
P.O. Box 7098
74, Digeni Akrita Ave.
1641 Nicosia
Czech Republic
GARDENA spol. s.r.o.
Шнpskб 20 a, и.p. 1153
62700 Brno
Denmark
GARDENA Danmark A / S
Naverland 8
2600 Glostrup
Finland
Habitec Oy
Martinkyläntie 52
01720 Vantaa
France
GARDENA France
Service Après-Vente
BP 50080
95948 ROISSY CDG Cedex
Great Britain
GARDENA UK Ltd.
27- 28 Brenkley Way
Blezard Business Park
Seaton Burn
Newcastle upon Tyne
NE13 6DS
Greece
Agrokip G. Psomadopoulos & Co.
20, Lykourgou str.
Kallithea - Athens
Hungary
GARDENA Magyarország Kft.
Késmárk utca 22
1158 Budapest
Iceland
Heimilistaeki hf
Saetun 8
P.O. Box 5340
125 Reykjavik
Republic of Ireland
Michael McLoughlin & Sons
Hardware Limited
Long Mile Road
Dublin 12
Italy
GARDENA Italia S.r.l.
Via Donizetti 22
20020 Lainate (Mi)
Japan
KAKUDAI Mfg. Co. Ltd.
1- 4 - 4, Itachibori Nishi-ku
Osaka 550
Luxembourg
Magasins Jules Neuberg
Grand Rue 30
Case Postale No. 12
Luxembourg 2010
Netherlands
GARDENA Nederland B.V.
Postbus 50176
1305 AD ALMERE
Neth. Antilles
Jonka Enterprises N.V.
Sta. Rosa Weg 196
P.O. Box 8200
Curaçao
New Zealand
NYLEX New Zealand Limited
Private Bag 94001
South Auckland Mail Centre
10 Offenhauser Drive
East Tamaki, Manukau
Norway
GARDENA Norge A / S
Postboks 214
2013 Skjetten
Poland
GARDENA Polska Sp. z o.o.
Szymanów 9 d
05 - 532 Baniocha
Portugal
MARKT (Portugal), Lda.
Recta da Granja do Marquês
Edif. GARDENA
Algueirão
2725-596 Mem Martins
Russia / Россия
АО АМИДА ТТЦ
ул. Моcфилмовcкая 66
117330 Моcква
Singapore
Variware
Holland Road Shopping Centre
227-A 1st Fl., Unit 29
Holland Avenue
Singapore 1027
Slowenia / Croatia
Silk d.o.o. Trgovina
Brodišče 15
1236 Trzin
South Africa
GARDENA South Africa (Pty.) Ltd.
P.O. Box 11534
Vorna Valley 1686
Spain
ANMI Andreu y Miriam S.A.
Calle Pere IV, 111
08018 Barcelona
Sweden
GARDENA Svenska AB
Box 9003
20039 Malmö
Switzerland
GARDENA Kress + Kastner AG
Bitziberg 1
8184 Bachenbülach
Ukraine / Украина
АОЗТ АЛЬЦЕСТ
ул. Гайдара 50
г. Киев 01033
Turkey
Dost Diþ Ticaret Mümessillik A.Þ.
Yeþilbaðlar Mah. Baþkent
Cad. No. 26
Pendik - Ýstanbul
USA
GARDENA
3085 Shawnee Drive
Winchester, VA 22604
1778 - 20.960.01/ 0021
© GARDENA Kress + Kastner GmbH
Postfach 27 47, D - 89070 Ulm
http: //www.gardena.com