ZANUSSI ZCV66480XV User Manual

User Manual
GETTING
STARTED?
EASY.
ZCV66480XV
EN User Manual
Cooker
SAFETY INFORMATION
Before the installation and use of the appliance, carefully read the
supplied instructions. The manufacturer is not responsible for any
injuries or damages that are the result of incorrect installation or
usage. Always keep the instructions in a safe and accessible
location for future reference.
CHILDREN AND VULNERABLE PEOPLE SAFETY
WARNING!
Risk of suffocation, injury or permanent disability.
•
•
•
•
•
•
•
This appliance can be used by children aged from 8 years and
above and persons with reduced physical, sensory or mental
capabilities or lack of experience and knowledge if they have
been given supervision or instruction concerning the use of the
appliance in a safe way and understand the hazards involved.
Children between 3 and 8 years of age and persons with very
extensive and complex disabilities shall be kept away unless
continuously supervised.
Children of less than 3 years of age should be kept away
unless continuously supervised.
Do not let children play with the appliance.
Keep all packaging away from children and dispose of it
appropriately.
Keep children and pets away from the appliance when it
operates or when it cools down. Accessible parts are hot.
Children shall not carry out cleaning and user maintenance of
the appliance without supervision.
GENERAL SAFETY
•
•
•
2
Only a qualified person must install this appliance and replace
the cable.
This appliance must be connected to the mains with a H05VVF type cable to withstand the temperature of the rear panel.
This appliance is intended for use up to an altitude of 2000 m
above sea level.
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
This appliance is not intended to be used on a ships, boats or
vessels.
Do not install the appliance behind a decorative door in order to
avoid overheating.
Do not install the appliance on a platform.
Do not operate the appliance by means of an external timer or
separate remote-control system.
WARNING: Unattended cooking on a hob with fat or oil can be
dangerous and may result in fire.
NEVER try to extinguish a fire with water, but switch off the
appliance and then cover flame e.g. with a lid or a fire blanket.
CAUTION: The cooking process has to be supervised. A short
term cooking process has to be supervised continuously.
WARNING: Danger of fire: Do not store items on the cooking
surfaces.
Do not use a steam cleaner to clean the appliance.
Do not use harsh abrasive cleaners or sharp metal scrapers to
clean the glass door or the glass of hinged lids of the hob since
they can scratch the surface, which may result in shattering of
the glass.
Metallic objects such as knives, forks, spoons and lids should
not be placed on the hob surface since they can get hot.
If the glass ceramic surface / glass surface is cracked, switch
off the appliance and unplug it from the mains. In case the
appliance is connected to the mains directly using junction box,
remove the fuse to disconnect the appliance from power
supply. In either case contact the Authorised Service Centre.
WARNING: The appliance and its accessible parts become hot
during use. Care should be taken to avoid touching heating
elements.
Always use oven gloves to remove or put in accessories or
ovenware.
Before maintenance cut the power supply.
Ensure that the appliance is switched off before replacing the
lamp to avoid the possibility of electric shock.
3
•
•
•
•
•
If the mains power supply cable is damaged, it must be
replaced by the manufacturer, its Authorised Service Centre or
similarly qualified persons to avoid an electrical hazard.
Use only the food sensor (core temperature sensor)
recommended for this appliance.
To remove the shelf supports first pull the front of the shelf
support and then the rear end away from the side walls. Install
the shelf supports in the opposite sequence.
The means for disconnection must be incorporated in the fixed
wiring in accordance with the wiring rules.
WARNING: Use only hob guards designed by the manufacturer
of the cooking appliance or indicated by the manufacturer of
the appliance in the instructions for use as suitable or hob
guards incorporated in the appliance. The use of inappropriate
guards can cause accidents.
SAFETY INSTRUCTIONS
INSTALLATION
WARNING! Only a qualified person
must install this appliance.
•
•
•
•
•
•
•
•
•
•
•
4
Remove all the packaging.
Do not install or use a damaged appliance.
Follow the installation instructions supplied with
the appliance.
Always take care when moving the appliance as
it is heavy. Always use safety gloves and
enclosed footwear.
Do not pull the appliance by the handle.
The kitchen cabinet and the recess must have
suitable dimensions.
Keep the minimum distance from other
appliances and units.
Make sure that the appliance is installed below
and adjacent safe structures.
Parts of the appliance carry current. Close the
appliance with furniture to prevent touching the
dangerous parts.
The sides of the appliance must stay adjacent to
appliances or units with the same height.
Do not install the appliance adjacent to a door
or under a window. This prevents hot cookware
to fall from the appliance when the door or the
window is opened.
•
Make sure to install a stabilizing means in order
to prevent tipping of the appliance. Refer to
Installation chapter.
ELECTRICAL CONNECTION
WARNING! Risk of fire and electric
shock.
•
•
•
•
•
•
•
•
•
All electrical connections should be made by a
qualified electrician.
The appliance must be earthed.
Make sure that the parameters on the rating
plate are compatible with the electrical ratings
of the mains power supply.
Always use a correctly installed shockproof
socket.
Do not use multi-plug adapters and extension
cables.
Do not let mains cables touch or come near the
appliance door, especially when the door is hot.
The shock protection of live and insulated parts
must be fastened in such a way that it cannot be
removed without tools.
Connect the mains plug to the mains socket
only at the end of the installation. Make sure that
there is access to the mains plug after the
installation.
If the mains socket is loose, do not connect the
mains plug.
•
•
•
•
Do not pull the mains cable to disconnect the
appliance. Always pull the mains plug.
Use only correct isolation devices: line
protecting cut-outs, fuses (screw type fuses
removed from the holder), earth leakage trips
and contactors.
The electrical installation must have an isolation
device which lets you disconnect the appliance
from the mains at all poles. The isolation device
must have a contact opening width of minimum
3 mm.
Fully close the appliance door, before you
connect the mains plug to the mains socket.
WARNING! Risk of injury and burns.
Risk of electrical shock.
•
•
•
•
•
•
This appliance is for household use only.
Do not change the specification of this
appliance.
Make sure that the ventilation openings are not
blocked.
Do not let the appliance stay unattended during
operation.
Deactivate the appliance after each use.
Be careful when you open the appliance door
while the appliance is in operation. Hot air can
release.
Do not operate the appliance with wet hands or
when it has contact with water.
Do not use the appliance as a work surface or
as a storage surface.
WARNING! Risk of fire and explosion
•
•
•
•
•
•
•
•
USE
•
•
WARNING! Risk of damage to the
appliance.
Fats and oil when heated can release flammable
vapours. Keep flames or heated objects away
from fats and oils when you cook with them.
The vapours that very hot oil releases can cause
spontaneous combustion.
Used oil, that can contain food remnants, can
cause fire at a lower temperature than oil used
for the first time.
Do not put flammable products or items that are
wet with flammable products in, near or on the
appliance.
Do not let sparks or open flames to come in
contact with the appliance when you open the
door.
Open the appliance door carefully. The use of
ingredients with alcohol can cause a mixture of
alcohol and air.
•
•
•
•
•
•
•
•
To prevent damage or discoloration to the
enamel:
– do not put ovenware or other objects in the
appliance directly on the bottom.
– do not put water directly into the hot
appliance.
– do not keep moist dishes and food in the
appliance after you finish the cooking.
– be careful when you remove or install the
accessories.
Discoloration of the enamel or stainless steel
has no effect on the performance of the
appliance.
Use a deep pan for moist cakes. Fruit juices
cause stains that can be permanent.
Do not keep hot cookware on the control panel.
Do not let cookware boil dry.
Be careful not to let objects or cookware fall on
the appliance. The surface can be damaged.
Do not activate the cooking zones with empty
cookware or without cookware.
Do not put aluminium foil on the appliance or
directly on the bottom of the appliance.
Cookware made of cast iron, aluminium or with
a damaged bottom can cause scratches.
Always lift these objects up when you have to
move them on the cooking surface.
This appliance is for cooking purposes only. It
must not be used for other purposes, for
example room heating.
CARE AND CLEANING
WARNING! Risk of injury, fire, or
damage to the appliance.
•
•
•
•
•
•
•
Before maintenance, deactivate the appliance.
Disconnect the mains plug from the mains
socket.
Make sure the appliance is cold. There is the
risk that the glass panels can break.
Replace immediately the door glass panels
when they are damaged. Contact the
Authorised Service Centre.
Be careful when you remove the door from the
appliance. The door is heavy!
Fat and food remaining in the appliance can
cause fire.
Clean regularly the appliance to prevent the
deterioration of the surface material.
Make sure the cavity and the door are wiped dry
after each use. Steam produced during the
operation of the appliance condensates on
cavity walls and can cause corrosion. To
5
•
•
•
decrease the condensation operate the
appliance for 10 minutes before cooking.
Clean the appliance with a moist soft cloth. Only
use neutral detergents. Do not use any abrasive
products, abrasive cleaning pads, solvents or
metal objects.
If you use an oven spray, obey the safety
instructions on the packaging.
Do not clean the catalytic enamel (if applicable)
with any kind of detergent.
•
Only use lamps with the same specifications.
SERVICE
• To repair the appliance contact an Authorised
Service Centre.
• Use original spare parts only.
DISPOSAL
WARNING! Risk of injury or
suffocation.
INTERNAL LIGHTING
WARNING! Risk of electric shock.
•
•
•
•
The type of light bulb or halogen lamp used for
this appliance is for household appliances only.
Do not use it for house lighting.
Before replacing the lamp, disconnect the
appliance from the power supply.
•
Disconnect the appliance from the mains
supply.
Cut off the mains electrical cable close to the
appliance and dispose of it.
Remove the door catch to prevent children or
pets from becoming trapped in the appliance.
INSTALLATION
WARNING! Refer to Safety chapters.
Minimum distances
Dimension
mm
TECHNICAL DATA
A
Dimensions
Height
894 - 912 mm
Width
600 mm
Depth
600 mm
685
LEVELLING OF THE APPLIANCE
LOCATION OF THE APPLIANCE
You can install your freestanding appliance with
cabinets on one or two sides and in the corner.
Use small feet on the bottom of appliance to set the
appliance top surface level with other surfaces.
A
ELECTRICAL INSTALLATION
WARNING! The manufacturer is not
responsible if you do not follow the
safety precautions from Safety
chapters.
This appliance is supplied without a main plug or a
main cable.
6
Applicable types of cables for different
phases:
Phase
•
•
Min. size cable
1
3x6.0 mm²
3 with neutral
5x1.5 mm²
WARNING! The power cable must
not touch the part of the appliance
shaded in the illustration.
•
The recommended cross-section area is six
square millimetres (6 mm²).
When you refit the mains terminal cover, make
sure that the lower tabs are located inside the
bottom edge of the aperture, before you fix the
two screws into the top edge of the mains
terminal cover.
Make sure that the cover is securely fastened.
To open the cover of terminal board
obey the procedure in opposite
sequence.
TERMINAL BOARD
Do not remove blanking plates.
Make sure that the links are fitted as shown.
COVERING TERMINAL BOARD
L
L
N
N
N
7
PRODUCT DESCRIPTION
GENERAL OVERVIEW
8
1
2
3
4
5
3
2
1
1 Control panel and hob
2 Air vents for the cooling fan
3 Heating element
4 Lamp
5 Shelf support, removable
6 Socket for the core temperature sensor
7 Fan
8 Shelf positions
5
4
3
2
4
6
5
1
7
COOKING SURFACE LAYOUT
1
145 mm
1 Cooking zone 1200 W
2 Steam outlet - number and position depends
on the model
Cooking
zone 1700 W
3
3
2
180 mm
4 Cooking zone 1200 W
5 Residual heat indicator
6 Cooking zone 1700 W
180 mm
6
145 mm
5
4
COOKER CONTROL PANEL
1
6
8
2
3
4
1
5
1 Knobs for the hob
2 Knob for the top oven functions
3 Display
4 Knob for the main oven functions
5 Temperature indicator / symbol for the main
oven
6 Temperature indicator / symbol for the top oven
ACCESSORIES
• Wire shelf
For cookware, cake tins, roasts.
• Grill- / Roasting pan
To bake and roast or as pan to collect fat.
• Trivet
For roasting and grilling.
Use the trivet only with the Grill- /
roasting pan.
•
Core temperature sensor
To measure how far the food is cooked.
BEFORE FIRST USE
WARNING! Refer to Safety chapters.
After approximately 5 seconds, the flashing stops
and the display shows the time of the day you set.
2. To change the time of day, press
INITIAL CLEANING
Remove all accessories and removable shelf
supports from the oven.
Refer to "Care and cleaning" chapter.
Clean the oven and the accessories before first
use.
Put the accessories and the removable shelf
supports back to their initial position.
SETTING AND CHANGING THE TIME
flashes when you connect the appliance to
The
the electrical supply, when there was a power cut
or when the timer is not set.
or
1. Press the
to set the correct time.
the same time until
and
at
starts to flash.
When the timer function is active, you
cannot change the current time.
PREHEATING
Preheat the empty appliance before first use.
Preheat the two ovens. Heat up one
oven at a time.
1. Set the maximum temperature.
2. Let the appliance operate for 1 hour.
3. Set the function
.
4. Let the appliance operate for 15 minutes.
Accessories can become hotter than usual. The
appliance can emit an odour and smoke. This is
normal. Make sure that the airflow is sufficient.
HOB - DAILY USE
WARNING! Refer to Safety chapters.
HEAT SETTING
Symbols
RESIDUAL HEAT INDICATOR
Function
Off position
1-6
Turn the knob for the selected cooking zone to a
necessary heat setting.
To complete the cooking process, turn the knob to
the off position.
Heat settings
WARNING! There is a risk of burns
from residual heat.
The indicator comes on when a cooking zone is
hot, but it does not function if mains power is
disconnected.
Use the residual heat to decrease
energy consumption. Deactivate the
cooking zone approximately 5 - 10
minutes before the cooking process is
completed.
9
HOB - HINTS AND TIPS
WARNING! Refer to Safety chapters.
Heat setting:
COOKWARE
2
The bottom of the cookware must be
as thick and flat as possible.
Ensure pan bases are clean and dry
before placing on the hob surface.
Cookware made of enamelled steel
and with aluminium or copper bottoms
can cause a colour change on the
glass-ceramic surface.
Application:
Gentle simmering
3
Simmering
4
Frying / browning
5
Bringing to the boil
6
Bringing to the boil / quick frying /
deep-frying
EXAMPLES OF COOKING APPLICATIONS
Heat setting:
1
Application:
Keeping warm
HOB - CARE AND CLEANING
WARNING! Refer to Safety chapters.
GENERAL INFORMATION
• Clean the hob after each use.
• Always use cookware with a clean base.
• Scratches or dark stains on the surface have no
effect on how the hob operates.
• Use a special cleaner suitable for the surface of
the hob.
• Use a special scraper for the glass.
CLEANING THE HOB
• Remove immediately: melted plastic, plastic
foil, sugar and food with sugar, otherwise, the
OVEN - DAILY USE
WARNING! Refer to Safety chapters.
10
•
•
dirt can cause damage to the hob. Take care to
avoid burns. Use a special hob scraper on the
glass surface at an acute angle and move the
blade on the surface.
Remove when the hob is sufficiently cool:
limescale rings, water rings, fat stains, shiny
metallic discoloration. Clean the hob with a
moist cloth and a non-abrasive detergent. After
cleaning, wipe the hob dry with a soft cloth.
Remove shiny metallic discoloration: use a
solution of water with vinegar and clean the
glass surface with a cloth.
TOP OVEN FUNCTIONS
Symbol
100 - 250
Oven function
Application
Off position
The oven is off.
Oven Lamp
To turn on the lamp without a cooking function.
Conventional Cooking
To bake and roast food on one shelf position.
Dual Circuit Grill
To grill food items in medium quantities in the middle of
the shelf. To make toasts.
Full Grill
To grill flat food and to toast bread.
MAIN OVEN FUNCTIONS
Symbol
100 - 250
Oven function
Application
Off position
The oven is off.
Oven Lamp
To turn on the lamp without a cooking function.
Defrost
This function can be used for defrosting frozen foods,
such as vegetables and fruits. The defrosting time depends on the amount and size of the frozen food.
Thermaflow®
To bake on up to two shelf positions at the same time and
to dry food. Set the temperature 20 - 40 °C lower than for
Conventional Cooking.
ACTIVATING AND DEACTIVATING THE TOP /
MAIN OVEN
It depends on the model if your
appliance has knob symbols,
indicators or lamps:
• The indicator comes on when the
oven heats up.
• The lamp comes on when the oven
operates.
• The symbol shows whether the
knob controls one of the cooking
zones, the oven functions or the
temperature.
1. Turn the knob for the top / main oven functions
to select an oven function.
2. To deactivate the oven turn the knob for the
top / main oven functions to the off position.
COOLING FAN
When the oven operates, the cooling fan turns on
automatically to keep the surfaces of the oven cool.
If you turn off the oven, the cooling fan can continue
to operate until the oven cools down.
USING THE CORE TEMPERATURE SENSOR
The core temperature sensor measures the core
temperature of the meat.
There are two temperatures to be set:
• The oven temperature. Refer to the table for
roasting.
11
•
The core temperature. Refer to the table for the
core temperature sensor.
CAUTION! Only use the core
temperature sensor supplied with the
appliance, or genuine replacement
parts.
INSERTING THE OVEN ACCESSORIES
Deep pan:
Push the deep pan between the guide bars of the
shelf support.
1. Put the point of the core temperature sensor
into the centre of the meat.
2. Put the plug of the core temperature sensor
into the socket on the side of the appliance.
The indicator for the core temperature sensor
flashes.
Wire shelf and the deep pan together:
Push the deep pan between the guide bars of the
shelf support and the wire shelf on the guide bars
above.
3. Press the button
or
to set the core
temperature.
You can set the temperature from 30 °C to 99
°C. Refer to values in the table.
4. Set the oven function and the oven
temperature.
5. Press a button to stop the signal.
An acoustic signal sounds for two minutes,
when the meat is at the set core temperature.
6. Deactivate the appliance.
7. Remove the plug of the core temperature
sensor from the socket. Remove the meat from
the appliance.
If the meat is not cooked to your satisfaction, do the
above steps again and set a higher core
temperature.
You can change the temperature at any time during
the cooking. Press the button
or
and then
again to change the set core temperature.
WARNING! Be careful when you
remove the tip and plug of the core
temperature sensor. The core
temperature sensor is hot. There is a
risk of burns.
12
•
•
All accessories have small
indentations at the top of the right
and left side to increase safety. The
indentations are also anti-tip
devices.
The high rim around the shelf is a
device which prevents cookware
from slipping.
TRIVET AND GRILL- / ROASTING PAN
WARNING! Be careful when you
remove the accessories from a hot
oven. There is a risk of burns.
You can use the trivet to roast larger pieces of meat
or poultry on one shelf position.
1. Put the trivet into the deep pan so that the
supports of the wire shelf point up.
2. Put the deep pan into the oven on the
necessary shelf position.
You can use the trivet to grill flat dishes in large
quantities and to toast.
1. Put the trivet into the deep pan so that the
supports of the wire shelf point down.
2. Put the deep pan into the oven on the
necessary shelf position.
OVEN - CLOCK FUNCTIONS
DISPLAY
A
B
C
D
A.
B.
C.
D.
Minute minder indicator
Time display
Time of day indicator
Core temperature sensor indicator
BUTTONS
Button
Function
Description
MINUS
To set the time.
PLUS
To set the time.
SETTING THE MINUTE MINDER
Press
or
again and again to set the
necessary time.
The Minute Minder starts automatically after 5
seconds.
When the set time is completed, an acoustic signal
sounds. Press any button to stop the signal.
To cancel the Minute Minder function press
or
then press and hold
until the clock function
goes out and acoustic signal sounds.
13
OVEN - HINTS AND TIPS
WARNING! Refer to Safety chapters.
The temperature and baking times in
the tables are guidelines only. They
depend on the recipes and the quality
and quantity of the ingredients used.
Always preheat an empty oven at the
temperature required for the food for
20 minutes before you start cooking.
TOP OVEN
The top oven is the smaller of the two ovens. It has
3 shelf positions. Use it to cook smaller quantities
of food. It gives especially good results when used
to cook fruitcakes, sweets and savoury flants or
quiche.
MAIN OVEN
The main oven is particularly suitable for cooking
larger quantities of food.
BAKING
• Use the lower temperature the first time.
• You can extend baking times by 10 – 15
minutes if you bake cakes on more than one
shelf position.
• Cakes and pastries at different heights do not
always brown equally. There is no need to
change the temperature setting if an unequal
browning occurs. The differences equalize
during baking.
• Trays in the oven can twist during baking. When
the trays become cold again, the distortions
disappear.
TIPS ON BAKING
Baking results
Remedy
The bottom of the cake is
not browned sufficiently.
The shelf position is incorrect.
Put the cake on a lower shelf.
The cake sinks and becomes soggy, lumpy or
streaky.
The oven temperature is too
high.
The next time you bake, set a slightly
lower oven temperature.
The baking time is too short.
Set a longer baking time. You cannot
decrease baking times by setting
higher temperatures.
There is too much liquid in the
mixture.
Use less liquid. Be careful with mixing times, especially if you use a mixing machine.
The oven temperature is too
low.
The next time you bake, set a higher
oven temperature.
The baking time is too long.
The next time you bake, set a shorter
baking time.
The oven temperature is too
high and the baking time is
too short.
Set a lower oven temperature and a
longer baking time.
The mixture is unevenly distributed.
Spread the mixture evenly on the
baking tray.
The oven temperature is too
low.
The next time you bake, set a slightly
higher oven temperature.
The cake is too dry.
The cake browns unevenly.
The cake is not ready in
the baking time given.
14
Possible cause
CONVENTIONAL BAKING - TOP OVEN
Food
Temperature (°C)
Time (min)
Shelf position
Biscuits
170 - 190
10 - 20
2
Bread
200 - 220
30 - 35
2
Bread rolls / buns
200 - 220
10 - 15
2
Cakes: Victoria Sandwich
160 - 170
18 - 25
2
Cakes: Madeira
140 - 150
75 - 90
2
Cakes: Rich Fruit
140 - 150
120 - 150
2
Cakes: Gingerbread
140 - 150
80 - 90
2
Cakes: Meringues
90 - 100
150 - 180
2
Cakes: Flapjack
160 - 170
25 - 30
2
Casseroles: Beef / Lamb
160 - 170
150 - 180
2
Casseroles: Chicken
160 - 180
80 - 90
2
Convenience Foods
Follow manufacturer`s instructions.
2
Fish
170 - 190
20 - 30
2
Fish Pie (Potato Topped)
190 - 200
20 - 30
2
Fruit Pies, Crumbles
190 - 200
30 - 50
2
Milk Puddings
150 - 170
90 - 120
2
Pasta Lasagne etc.
170 - 180
40 - 50
2
Pastry: Choux
180 - 190
30 - 40
2
Pastry: Eclairs, Profiteroles
180 - 190
30 - 40
2
Pastry: Flaky / Puff Pies
210 - 220
30 - 40
2
Shortcrusts: Mince Pies
190 - 200
15 - 20
2
Shortcrusts: Meat Pies
190 - 210
25 - 35
2
Shortcrusts: Quiche, Tarts, Flans
180 - 200
25 - 50
2
Scones
220 - 230
8 - 12
3
Shepard`s Pie
190 - 200
30 - 40
2
Souffles
170 - 180
20 - 30
2
Vegetables: Baked Jacket Potatos
180 - 190
60 - 90
2
Vegetables: Roast Potatos
180 - 190
60 - 90
2
Yorkshire Pudding Large
220 - 210
25 - 40
2
Yorkshire Pudding Individual
210 - 220
15 - 25
Roasting Meat, Poultry
Refer to the Roasting table.
2
2
15
THERMAFLOW® BAKING - MAIN OVEN
Shelf positions are not critical but
ensure that the oven accessories are
evenly spaced when more than one is
used.
Food
Temperature (°C)
Shelf position
Biscuits
180 - 190
10 - 20
1–3
Bread
190 - 210
30 - 35
2
Cakes: Small & Queen
150 - 170
18 - 25
1–3
Cakes: Sponges
160 - 170
20 - 25
3
Cakes: Madeira
140 - 160
60 - 80
3
Cakes: Rich Fruit
130 - 140
120 - 150
3
Cakes: Christmas
130 - 140
180 - 270
3
Cakes: Apple Pie
160 - 170
50 - 60
3
- Shortbread
130 - 150
45 - 60
1–3
Fish
160 - 180
30 - 40
3
Fruit Pies, Crumbles
170 - 180
30 - 50
3
Milk Puddings
140 - 160
60 - 90
3
Pastry: Choux
180 - 190
30 - 40
3
Pastry: Shortcrust
180 - 190
25 - 35
3
Pastry: Flaky
180 - 190
30 - 40
3
Pastry: Puff
Follow manufacturer`s instructions. Reduce
the temperature for Fan oven by 20 °C.
3
Plate Tarts
180 - 190
25 - 45
3
Quiches / Flans
170 - 180
25 - 45
3
Scones
210 - 230
8 - 12
1–3
Roasting: Meat, Poultry
160 - 180
Refer to the Roasting table.
2
ROASTING
Use heat-resistant ovenware.
Roast large roasting joints directly in the tray or on
the wire shelf placed above the tray.
Put some water in the tray to prevent the meat
juices or fat from burning.
Meat with crackling can be roasted in the roasting
tin without the lid.
16
Time (min)
Turn the roast after 1/2 - 2/3 of the cooking time.
To keep meat more succulent:
• roast lean meat in the roasting tin with the lid or
use roasting bag.
• baste large roasts and poultry with their juices
several times during roasting.
THERMAFLOW® - MAIN OVEN
Roasting
Food
Temperature (°C)
Time (min)
Beef / Beef boned
170 - 190
20 - 35 minutes per 0.5 kg (1 lb) and 20 - 30 minutes over
Mutton / Lamb
170 - 190
20 - 35 minutes per 0.5 kg (1 lb) and 25 - 35 minutes over
Pork / Veal / Ham
170 - 190
30 - 40 minutes per 0.5 kg (1 lb) and 30 - 40 minutes over
Chicken
180 - 200
20 - 25 minutes per 0.5 kg (1 lb) and 20 minutes
over
Turkey / Goose
170 - 190
15 - 20 minutes per 0.5 kg (1 lb) up to 3.5 kg (7 lb)
then 10 minutes per 0.5 kg (1 lb) over 3.5 kg (7 lb)
Duck
180 - 200
25 - 35 minutes per 0.5 kg (1 lb) and 25 - 30 minutes over
Pheasant
170 - 190
35 - 40 minutes per 0.5 kg (1 lb) and 35 - 40 minutes over
Rabbit
170 - 190
20 minutes per 0.5 kg (1 lb) and 20 minutes over
CORE TEMPERATURE SENSOR TABLE
Beef
Food
Food core temperature (°C)
Shelf position
Roast beef
55 - 65
2-3
Rump steak - browning
55 - 65
2-3
Rump steak - roasting
55 - 65
2-3
Roast beef
75 - 80
1-2
Veal
Food
Fillet of beef
Food core temperature (°C)
65
Shelf position
2-3
Lamb
Food
Leg / shoulder / saddle
Food core temperature (°C)
90
Shelf position
2
17
Pork
Food
Food core temperature (°C)
Shelf position
Roast pork
80
2-3
Neck fillets
75 - 80
2-3
Ham
70 - 75
1-2
Poultry
Food
Turkey breast
Food core temperature (°C)
75 - 80
GRILLING IN GENERAL
Shelf position
2-3
•
Grill only flat pieces of meat or fish.
WARNING! Always grill with the oven
door closed.
•
•
•
Always grill with the maximum
temperature setting.
Set the shelf into the shelf position as
recommended in the grilling table.
Always set the deep pan to collect the fat into
the first shelf position.
The grilling area is set in centre of the shelf.
DUAL GRILL - TOP OVEN
Food
18
Time (min)
Shelf position
Bacon Rashers
5-6
3
Chicken Joints
20 - 40
2
Chops - Lamb
15 - 25
2-3
Chops - Pork
20 - 25
2-3
Fish - Whole / Trout / Makarel
10 - 12
2
Fillets - Plaice / Cod
4-6
2
Kebabs
12 - 18
2-3
Kidneys - Lamb / Pig
6 - 10
2-3
Sausages
20 - 30
3
Steaks: Rare
4-6
3
Steaks: Medium
6-8
3
Steaks: Well Done
12 - 15
3
•
DEFROST
• Remove the food packaging. Put the food on a
plate.
• Do not cover it with a bowl or a plate. This can
extend the defrost time.
Use the first shelf position. The one on the
bottom.
INFORMATION FOR TEST INSTITUTES
Main oven
Food
Function
Temperature (°C)
Time (min)
Accessories
Shelf position
Small cakes (20 small
cakes per tray)
Thermaflow®
150
20 - 30
Tray
3
Small cakes (20 small
cakes per tray)
Thermaflow®
150
20 - 35
Tray
1/4
Apple pie, 2 tins (ø 20
cm) on the grid, diagonally shifted
Thermaflow®
160
80 - 100
Grid
2
Fatless sponge cake,
1 tin (ø 26 cm) on the
grid
Thermaflow®
150
25 - 35
Grid
2
Fatless sponge cake,
1 tin (ø 26 cm) on the
grid
Thermaflow®
150
30 - 40
Grid
1/4
Shortbread/Pastry
strip
Thermaflow®
140
20 - 30
Tray
3
Shortbread/Pastry
strip
Thermaflow®
140
15 - 25
Tray
1/4
Top oven
Food
Function
Temperature (°C)
Time (min)
Accessories
Shelf position
Small cakes (20 small
cakes per tray)
Conventional
Cooking
150
20 - 30
Tray
2
Apple pie, 2 tins (ø 20
cm) on the grid, diagonally shifted
Conventional
Cooking
170
20 - 35
Grid
1
Fatless sponge cake,
1 tin (ø 26 cm) on the
grid
Conventional
Cooking
150
80 - 100
Grid
2
Shortbread/Pastry
strip
Conventional
Cooking
140
25 - 35
Tray
2
Toast
Full Grill
-
30 - 40
Grid
2
19
Food
Beef burger
Function
Temperature (°C)
Dual Circuit Grill
-
Time (min)
20 - 30
Accessories
Grid /
Roasting
pan
Shelf position
2
OVEN - CARE AND CLEANING
WARNING! Refer to Safety chapters.
NOTES ON CLEANING
Clean the front of the oven with a soft cloth with
warm water and a mild cleaning agent.
To clean metal surfaces, use a dedicated cleaning
agent.
Clean the oven interior after each use. Fat
accumulation or other food remains may result in a
fire. The risk is higher for the grill pan.
Clean all accessories after each use and let them
dry. Use a soft cloth with warm water and a
cleaning agent. Do not clean the accessories in the
dishwasher.
Clean stubborn dirt with a special oven cleaner. Do
not apply oven cleaner on the catalytic surfaces.
If you have nonstick accessories, do not clean them
using aggressive agents, sharp-edged objects or a
dishwasher. It can cause damage to the nonstick
coating.
Clean the moisture from the cavity after each use.
STAINLESS STEEL OR ALUMINIUM OVENS
Clean the oven door with a damp cloth or sponge
only. Dry it with a soft cloth.
Do not use steel wool, acids or abrasive materials
as they can damage the oven surface. Clean the
oven control panel with the same precautions.
WARNING! Keep children away when
you clean the oven at a high
temperature. The oven surface
becomes very hot and there is a risk of
burns.
CAUTION! Always turn the oven light
on while using the catalytic cleaning (if
applicable).
Before activating the catalytic cleaning
remove all the accessories from the
oven.
The walls with a catalytic coating are self-cleaning.
They absorb fat which collects on the walls while
the appliance operates.
To support the self-cleaning procedure, heat the
empty oven on a regular basis.
1. Clean the oven floor with warm water and
washing up liquid, then dry it.
2. Set the oven temperature to 250 °C and let the
oven operate for 1 hour.
3. When the appliance is cool, clean it with a soft
and moist sponge.
REMOVING THE SHELF SUPPORTS
To clean the oven, remove the shelf supports.
1. Pull the front of the shelf support away from the
side wall.
CATALYTIC CLEANING
CAUTION! Do not clean the catalytic
surface with oven sprays, abrasive
cleaning agents, soap or other
cleaning agents. This will damage the
catalytic surface.
Spots or discolouration of the catalytic
surface have no effect on catalytic
properties.
20
2. Pull the rear end of the shelf support away from
the side wall and remove it.
REMOVING AND CLEANING THE DOOR
GLASSES - MAIN OVEN
1
The door glass in your product can be
different in type and shape from the
example you see in the image. The
number of glasses can also be
different.
2
1. Push the door trim at one side to remove it.
Install the shelf supports in the opposite sequence.
A
CAUTION! Make sure that the longer
fixing wire is in the front. The ends of
the two wires must point to the rear.
Incorrect installation can cause
damage to the enamel.
2
1
REMOVING AND CLEANING THE DOOR
GLASSES - TOP OVEN
The door glass in your product can be
different in type and shape from the
examples you see in the image. The
number of glasses can also be
different.
1. Open the door.
2. Hold the door trim on the top edge of the door
at the two sides and push inwards to release
the clip seal.
1
2. Pull up the trim.
3. Remove the glass panels.
To replace the glass panels, do the
same steps in reverse. Before you
lower the trim, attach the A trim part to
the door. Refer to the image.
REPLACING THE LAMP
2
1
3. Pull the door trim to the front to remove it.
4. Remove the glass panels.
To install the panels, do the same steps in reverse.
WARNING! Risk of electric shock.
The lamp can be hot.
1. Turn off the oven.
Wait until the oven is cooled down.
2. Disconnect the oven from the mains.
3. Put a cloth on the bottom of the cavity.
The back lamp
The lamp glass cover is at the back of
the cavity.
1. Turn the lamp glass cover counterclockwise to
remove it.
2. Clean the glass cover.
3. Replace the oven lamp with a suitable 300 °C
heat-resistant oven lamp.
21
Use the same oven lamp type.
4. Install the glass cover.
TROUBLESHOOTING
WARNING! Refer to Safety chapters.
WHAT TO DO IF...
Problem
Possible cause
You cannot activate the appliance.
The appliance is not connected to an electrical supply or it
is connected incorrectly.
Check if the appliance is correctly connected to the electrical supply.
You cannot activate the appliance.
The fuse is blown.
Make sure that the fuse is the
cause of the malfunction. If the
fuse is blown again and again,
contact a qualified electrician.
Residual heat indicator does
not come on.
The zone is not hot because it
operated only for a short time.
If the zone operated sufficiently
long to be hot, speak to an Authorised Service Centre.
The oven does not heat up.
The oven is deactivated.
Activate the oven.
The oven does not heat up.
The clock is not set.
Set the clock.
The oven does not heat up.
The necessary settings are not
set.
Make sure that the settings are
correct.
The lamp does not operate.
The lamp is defective.
Replace the lamp.
The display shows "12.00".
There was a power cut.
Reset the clock.
The display shows F11.
The plug of the core temperature sensor is not correctly installed into the socket.
Put the plug of the core temperature sensor as far as possible into the socket.
Steam and condensation settle
on the food and in the cavity of
the oven.
You left the dish in the oven for
too long.
Do not leave the dishes in the
oven for longer than 15 - 20
minutes after the cooking
process ends.
SERVICE DATA
If you cannot find a solution to the problem yourself,
contact your dealer or an Authorised Service
Centre.
The necessary data for the service centre is on the
rating plate. The rating plate is on the front frame of
22
Remedy
the oven cavity. Do not remove the rating plate from
the oven cavity.
We recommend that you write the data here:
Model (MOD.)
.........................................
Product number (PNC)
.........................................
Serial number (S.N.)
.........................................
ENERGY EFFICIENCY
PRODUCT INFORMATION FOR HOB ACCORDING TO EU 66/2014
Model identification
ZCV66480XV
Type of hob
Hob inside Freestanding Cooker
Number of cooking zones
4
Heating technology
Radiant Heater
Diameter of circular cooking
zones (Ø)
Left front
Left rear
Right front
Right rear
18.0 cm
14.5 cm
14.5 cm
18.0 cm
Energy consumption per cooking
zone (EC electric cooking)
Left front
Left rear
Right front
Right rear
177.3 Wh/kg
180.3 Wh/kg
180.3 Wh/kg
179.4 Wh/kg
Energy consumption of the hob (EC electric hob)
179.3 Wh/kg
EN 60350-2 - Household electric cooking
appliances - Part 2: Hobs - Methods for measuring
performance.
•
HOB - ENERGY SAVING
You can save energy during everyday cooking if you
follow below hints.
• When you heat up water, use only the amount
you need.
• If it is possible, always put the lids on the
cookware.
•
•
•
•
Before you activate the cooking zone put the
cookware on it.
The cookware bottom should have the same
diameter as the cooking zone.
Put the smaller cookware on the smaller cooking
zones.
Put the cookware directly in the centre of the
cooking zone.
Use the residual heat to keep the food warm or
to melt it.
PRODUCT FICHE AND INFORMATION FOR OVENS ACCORDING TO EU 65-66/2014
Supplier's name
Zanussi
Model identification
ZCV66480XV
Energy Efficiency Index
Top oven: 105.6
Main oven: 95.4
Energy efficiency class
Top oven: A
Main oven: A
23
Energy consumption with a standard load, conventional
mode
Top oven: 0.75 kWh/cycle
Main oven: not applicable
Energy consumption with a standard load, fan-forced mode
Top oven: not applicable
Main oven: 0.83 kWh/cycle
Number of cavities
2
Heat source
Electricity
Volume
Top oven: 39 l
Main oven: 77 l
Type of oven
Oven inside Freestanding Cooker
Mass
55.4 kg
EN 60350-1 - Household electric cooking
appliances - Part 1: Ranges, ovens, steam ovens
and grills - Methods for measuring performance.
When the cooking duration is longer than 30
minutes, reduce the oven temperature to minimum
3 - 10 minutes before the end of the cooking time,
depending on the duration of the cooking. The
residual heat inside the oven will continue to cook.
Use the residual heat to warm up other dishes.
Keep breaks between baking as short as possible
when you prepare few dishes at one time.
OVEN - ENERGY SAVING
The oven contains features which help
you save energy during everyday
cooking.
Cooking with fan
General hints
When possible, use the cooking functions with fan
to save energy.
Make sure that the oven door is closed properly
when the oven operates. Do not open the door too
often during cooking. Keep the door gasket clean
and make sure it is well fixed in its position.
Use metal dishes to improve energy saving.
When possible, do not preheat the oven before you
put the food inside.
Keep food warm
Choose the lowest possible temperature setting to
use residual heat and keep a meal warm.
ENVIRONMENTAL CONCERNS
with the symbol with the household waste.
Return the product to your local recycling facility or
contact your municipal office.
Recycle materials with the symbol
. Put the
packaging in relevant containers to recycle it. Help
protect the environment and human health by
recycling waste of electrical and electronic
appliances. Do not dispose of appliances marked
24
*
25
26
27
867337957-D-262019
WWW.ZANUSSI.COM/SHOP