advertisement
750,202M
REV. NC 02/2006
LENNOX HEARTH PRODUCTS
KITS AND ACCESSORIES
DECORATIVE UPPER AND LOWER GRILLE KITS
CHARCOAL & SATIN PEWTER
INSTALLATION INSTRUCTIONS FOR UPPER AND LOWER GRILLE KITS
FOR USE WITH LENNOX
™
35/40/45 GAS FIREPLACES
Cat. No.
#
H3565
H3567
H3573
H3575
H3581
H3583
Model
SUGK35C
UPPER GRILLE KITS - SUNRISE
Description
35” Charcoal
SUGK35SP 35” Satin Pewter
SUGK40C 40” Charcoal
SUGK40SP 40” Satin Pewter
SUGK45C 45” Charcoal
SUGK45SP 45” Satin Pewter
Model Series
MPD3530, MPD35ST,
MPB-35ST & EDV3530
EDV4035, EDVST,
MPD4035, EBVST
EDV4540,
MPD4540
Cat. No.
#
H3569
H3571
H3577
H3579
H3585
H3587
Model
SLGK35C
LOWER GRILLE KITS - SUNRISE
Description Model Series
35” Charcoal
MPD3530, MPD35ST,
MPB-35ST & EDV3530
SLGK35SP 35” Satin Pewter
SLGK40C 40” Charcoal
SLGK40SP 40” Satin Pewter
SLGK45C 45” Charcoal
EDV4035, EDVST,
MPD4035, EBVST
SLGK45SP 45” Satin Pewter
EDV4540,
MPD4540
KIT CONTENTS
ITEM QUANTITY DESCRIPTION
1 1 ea.
Grill, Upper or Lower
2 1 ea.
Instruction Sheet
Table 1 - Refer to Figure 1
Notes:
• The upper and lower grilles are ordered separately.
• Only the lower grilles include knobs (see 2 knobs shown on Crescent Style, Figure 1).
Figure 1
Cat. No.
#
H3541
H3543
H3549
H3551
H3557
H3559
Model
UPPER GRILLE KITS - CRESCENTS
Description Model Series
CUGK35C 35” Charcoal
CUGK35SP 35” Satin Pewter
MPD3530, MPD35ST,
MPB-35ST & EDV3530
CUGK40C 40” Charcoal
CUGK40SP 40” Satin Pewter
CUGK45C 45” Charcoal
EDV4035, EDVST,
MPD4035, EBVST
CUGK45SP 45” Satin Pewter
EDV4540,
MPD4540
Cat. No.
#
H3545
H3547
H3553
H3555
H3561
H3563
Model
CLGK35C
LOWER GRILLE KITS - CRESCENTS
Description
35” Charcoal
Model Series
CLGK35SP 35” Satin Pewter
CLGK40C 40” Charcoal
CLGK40SP 40” Satin Pewter
CLGK45C 45” Charcoal
CLGK45SP 45” Satin Pewter
MPD3530, MPD35ST,
MPB-35ST & EDV3530
EDV4035, EDVST,
MPD4035, EBVST
EDV4540,
MPD4540
Sunrise Style (upper grille shown)
Crescent Style
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
(lower grille shown)
Knobs
1
2
Read and understand all instructions and warnings in this document before beginning the installation.
TOOLS REQUIRED
Phillips Screwdriver
Cutting Pliers (required for modesty panels with side locating tabs only as shown in Figure 6 )
Lower Panel Remove the lower louvered or radiant panel assemby as follows:
• Hinged Panel (see Figure 3) - Gently depress the outer top corners of the louvered Control Compartment Access Panel until the spring-loaded magnetic catches "pop" it free, allowing it to swing out and down to open. With the panel in the open position, depress the spring-loaded hinge pin on left side until it disengages from the left cabinet panel hole. Pull panel away from fi replace.
GENERAL INFORMATION
These decorative grilles are offered in four attractive fi nishes and fi t on the face of the appliance in place of the standard louvers or radiant panels. If you encounter any problems, need clarifi cation of these instructions or are not qualifi ed to properly install this kit, contact you local distributor or dealer.
WARNINGS
• Hot! Do not touch! These decorative grilles are NOT heat guards. Carefully supervise children in the same room as appliance.
• The lower Grille covering the controls will become hot during operation. Use care when removing the grille to access the controls and make sure to place the grille on a surface that is non-combustible or will not be damaged by high temperatures.
• INSTALL THIS KIT ONLY WHEN THE FIREPLACE IS OFF
AND COLD!
Hinge Pin
Latch for
Glass Door
Control Compartment
Access panel
Figure 3 - Remove Hinged Lower Panel
• Hooked Panel (see Figure 4) - Remove the panel by gently lifting it upward until the hook catches on boths sides clear the locating slots.
Then pull door out to remove.
OPENING CONTROL COMPARTMENT DOOR
INSTALLATION INSTRUCTIONS:
1. Remove Louvered or Radiant Panel/Hood Assembly -
Upper Panel Remove the upper louvered or radiant panel/hood assembly by pulling the assembly up and out (see Figure 2 ) . In instances where the radiant panel is used and it is framed in with tile or other approved material, the hood must still be removed by fi rmly pulling it forward until it releases from the receiving brackets.
Lift the Lower Control Compartment
Door up and pull out to remove.
Hook Catch
Control Valve
Out
Up
Lower Control
Compartment Door
Louvered
Panels
Top Panel
Removed
Trim Panels will be either Louvered Panels or
Radiant Panels.
Figure 4 - Remove Hooked Lower Panel
Radiant
Panels
Figure 2 - Remove Upper and/or Lower Panel(s)
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
2.
If fi replace has a modesty panel with side locating tabs as shown in
Figure 5 , the left tab will require the following modifcation: instructions in Homeowners Care and Operation Manual).
b.
Using cutting pliers, cut 1/2” off the end of the left top locating tab on the modesty panel only as shown in Figure 5 .
c.
Reinstall modesty panel in fi replace control compartment.
3. Remove Magnet in the Control Compartment (if necessary) per instructions in Figure 6.
Left Locating Tab on Modesty Panel
Left Locating
Tab
Modesty Panel
Magnet
Control Compartment
Screw
Locating Tab
Modesty Panel
Cut off end of tab.
1/2”
Locating Tab
Modesty Panel
Using a phillips screwdriver, remove the control compartment magnet (left side only).
Figure 6 - Remove Magnet
4.
Light the appliance following instrutions on lighting label in control compartment or see lighting instructions in Homeowner’s Care and
Operation Manual provided with appliance. Ensure that the latch(es) below the door are engaged with the door’s vee-fl ange and fully closed before operating the fi replace.
5. Install Grilles (see Figure 7) - Remove the grilles from packaging.
Position the grilles so that the hook catches on the back of grilles slide into corresponding slots on fi replace .
Upper Grille
Hook
Lower Grille
Knob
Hook
Figure 7 - Side View of Grilles
Figure 5 - Cut off End of Left Locating Tab
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
3
Figure 8 - COMPLETED INSTALLATION
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifi cations, prices and the discontinuance of colors, styles and products. Consult your local distributor for fi replace code information.
4
Printed in U.S.A. © LENNOX HEARTH PRODUCTS 2006
P/N 750,202M REV. NC 02/2006
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
1110 West Taft Avenue • Orange, CA 92865
advertisement