AlPINE StAIr lIftS
Owner's Manual and Warranty Information
V e h i c l e l i f t s | s ta i r l i f t s | V e rt i c a l P l at f o r m l i f t s | B at h l i f t s | r a m P s
1
table of Contents
2
Harmar, America’s Lift Leader™, is proud to extend our world-class line of stair lifts with the Alpine series.
Engineered for ease of use and years of trouble-free operation, Alpine is built in the USA and supported by a staff with extensive industry experience in accessibility equipment.
This Owner's Manual should be read and understood in its entirety prior to attempting to operate the equipment.
All operating procedures must be followed in order to avoid possible injury and/or property damage.
CONTENTS:
Introduction and Dealer Information........................................... 3
Operation and Description of Features ....................................4-5
Important Operating Notes .......................................................... 6
Maintenance .................................................................................... 7
Troubleshooting .............................................................................. 7
Limited Warranty ............................................................................ 8
GENERAL SPECIFICATIONS
Application: Indoor, straight run stairways
Track Length: 32 feet (max)
Rated Load: Seat: 300 pounds (136 kg)
Rated Speed: 19 feet per minute
Power Supply: 115 VAC, 60 Hz, 3-wire grounded outlet
Motor: 24 VDC
Drive System: Rack and pinion
Track: Extruded aluminum
Angle of Incline: 25° to 50°
IMPORTANT
THE SERIAL NUMBER of your stair lift is:
This serial number contains important information about your lift. This number may be needed if the lift requires replacement parts.
Please keep it accessible.
Alpine Stair Lifts Manual | | www.Harmar.com
Maintenance and troubleshooting
MAINTENANCE
Regular maintenance is essential to keeping your stair lift in proper operating condition. As the owner of the equipment it is important to schedule maintenance on a regular basis. To give your equipment the highest level of care, we recommend using only authorized Harmar dealers and technicians to perform all required maintenance, service and repair work.
To assure proper operating condition of your stair lift, the following checks and /or services should be performed every six (6) months:
Tighten all fastening anchors
Verify proper operation of the footrest obstruction sensor
Lightly oil swivel seat mechanism with an all-purpose household oil
Lubricate the gear rack on the track with the lubricant provided with the lift
Clean any dirt build up on track where the wheels roll
TROUBLESHOOTING
Before calling for service, take time to check this Owner's Manual for information that will help you avoid unnecessary service calls. As well, before calling your authorized Harmar dealer, go through the following three-point check. If your lift will not operate:
1. Check for obstructions in the path of the lift.
2. Ensure that the swivel seat is in the locked, riding position.
3. Ensure that the lift's power cord is plugged into the 115 VAC outlet, or check for a blown fuse or tripped circuit breaker at the main circuit box.
If your lift will still not operate, contact your local authorized Harmar dealer for immediate service. If your lift needs servicing, use only original replacement parts and hardware to maintain quality and performance.
Alpine Stair Lifts Manual | | www.Harmar.com 3
Important Operating Notes
4
IMPORTANT OPERATING NOTES
The following guidelines must be observed at all times to prevent possible personal injury or damage to your stair lift or other property. Harmar hereby disclaims all liability (whether arising in contract, tort,
(including negligence or strict liability) or otherwise) for personal injury or property damage arising from user's failure to observe the following guidelines:
Do not exceed capacity of 300 pounds (136 kg) unless you have purchased an Alpine Express or
Alpine Signature, which is the only seat rated to handle loads above 300 pounds.
The lift is designed for indoor use only.
Do not operate the lift with a child or pet in your lap. The lift is designed for one person only.
Do not use an extension cord to supply power to your lift. The lift's power cord should be directly connected to the power source.
Center your weight on the seat.
Do not allow children to play on the lift.
Do not stand up on the lift while operating.
Always use the seat belt.
Do not operate the lift if it has been damaged in any way.
Do not attempt to service the lift yourself. Contact your local authorized Harmar dealer for all service.
Complete and mail in your warranty card or register your lift online at www.Harmar.com.
Show a family member and/or neighbor how to operate the lift in the event you require assistance.
Keep your lift and track clean and free of dirt.
Have your dealer perform general maintenance and lubrication on your lift every six (6) months to keep it looking and operating like new.
Ensure your dealer explains proper lift operation and maintenance procedures; ask questions if necessary.
Keep the lift connected to AC power at all times.
Alpine Stair Lifts Manual | | www.Harmar.com
Introduction and Dealer Information
INTRODUCTION
Your new Alpine stair lift will help you enjoy new horizons of independent living by adding safety, peace of mind and convenience to your home.
In order to achieve the maximum functionality your lift offers, it is essential that you read this Owner's
Manual carefully and understand its contents prior to using your lift. This Owner's Manual has been prepared to provide clear, concise operating and maintenance instructions.
As America’s Lift Leader™, Harmar uses special precision and care to engineer and manufacture easy, trouble-free equipment that operate dependably for years. However, as with all electrical and mechanical equipment, proper operation and periodic maintenance is required.
Please note that only authorized Harmar dealers, who are committed to providing quality service, have technicians who have been trained to install, maintain and repair Harmar lifts. Damages caused by non-Harmar authorized technicians or non-genuine replacement parts will not be covered under your Limited Warranty.
DEALER INFORMATION
Name: _______________________________________________________________
Address: ______________________________________________________________
_____________________________________________________________________
Telephone Number: ____________________________________________________
Email: ________________________________________________________________
If you have questions concerning the operation or maintenance of your stair lift, please contact your dealer.
Alpine Stair Lifts Manual | | www.Harmar.com 5
Operation and Description of features
OPERATION AND DESCRIPTION OF FEATURES
To avoid causing damage to your stair lift or other property, and to avoid personal injury, you should become familiar with the location and function of the features included on your lift before using it. It is particularly important that you familiarize yourself with the safety devices described below.
OPERATING CONTROL: A constant pressure rocker switch is located on the arm rest. The rocker switch must be toggled to move the lift. The lift stops any time the rocker switch is released. The lift automatically stops at the ends of the track. During normal operation, press and hold the rocker switch in the proper direction until the stair lift stops itself.
WIRELESS REMOTE CONTROLS: There are two wireless remote controls included with your lift, one for the top of the stairway and one for the bottom. To operate the wireless remote controls, press and hold one of the buttons (one button is up and one is down). When a button is pressed, the lift will begin to move after a half-second delay.
6
Operating control
Swivel seat lever
Folding footrest
An Alpine is pictured above, your model may vary.
Alpine Stair Lifts Manual | | www.Harmar.com
Folding armrest
(included on some models)
Folding seat
(included on some models)
On / Off Power Switch
Infrared sensor for remote controls
Operation and Description of features
FOLDING SEAT AND ARMREST (included as an option on some models):
Seat and armrest folds up to provide more stairway room when the lift is not in use.
FOLDING FOOTREST: T he footrest can be folded up and out of the way when the lift is not in use. The footrest must be in the down position when riding the lift. Sensors are provided in the footrest to detect obstructions. When an obstruction is encountered, the lift will stop. The obstruction must be removed in order for the lift to operate.
SWIVEL SEAT: The swivel seat lever is provided on both sides of the seat, allowing the seat to be swiveled 70° and 90° at both the upper and lower landings. To operate the swivel, raise the lever. Ensure that the swivel seat locks into position before sitting down or getting off. A safety sensor on the swivel seat prohibits the lift from being used when the seat is not locked in the riding position.
SAFETY BELT: The safety belt must be securely fastened around waist or chest before operating the lift.
FINAL LIMIT SWITCH: In the unlikely event that the lift would over-travel its lift and render all controls inoperable. A service technician must check the lift to put it back into service.
1.
Alpine: Track and drive system for straight-run stair lifts.
2.
Compact design: Footrest folds up when unit is not in use.
3.
Track: Easy care, partially enclosed structure with mounting covers.
4.
Swivel seat: Lever release allows seat to swivel and lock at 70º and 90º at both levels thus allowing rider to safely exit.
Alpine Stair Lifts Manual | | www.Harmar.com 7
AlPINE StAIr lIftS
three year warranty certificate
PLEASE FILL OUT ALL FIELDS AND RETURN WITHIN TEN (10) DAYS OF PRODUCT PURCHASE.
Fax completed form to 1-866-234-5680 or mail to Harmar, ATTN: Warranty Department, 2075 47th Street, Sarasota,
Florida, 34234. Harmar warrants to the original purchaser of stair lift manufactured by use to be free from defects in material and workmanship for a 3-Year period on all component parts of the lift.
ExCEpTIonS To ThIS LImITEd WArrAnTy ArE:
· Batteries are warranted for a 1-year period
· damage resulting from improper installation or operation
· negligence, alterations, abuse or misuse of the equipment
· Fire, acts
· torn or dirty upholstery
· shipping damage
· Parts used that are not supplied by harmar, llc
· labor fees for installation work or service calls of 3 years from the date of original purchase of the unit. Harmar Summit, LLC and its dealers shall not be liable for any consequential, special or incidental damages arising out of the purchase or use of the unit or resulting from the breach of this Limited Warranty, or any implied warranty. The limit of liability of Harmar Summit, LLC and its dealer hereunder shall be the unit’s purchase price. Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, or legal remedies, so these above limitations may not apply to you. All warranty claims must be reported to the dealer from whom the lift was purchased as they have responsibility for handling your warranty claim. The dealer is to contact the Service Department of Harmar Summit, LLC and provide the serial number of the lift along with a description of the events leading to the warranty claim. Dealers may charge for labor, service, travel, or other associated costs to make repairs, and such charges are not covered by this Limited Warranty. It is permissible to have any repairs or replacement work done as a result of any defects in material and workmanship by someone other than the Dealer under this Limited Warranty. However, the Limited Warranty does not cover any charges or expenses assessed by any such other person or company performing such repairs or replacement work. All parts used to replace defective materials must be genuine Harmar Summit, LLC parts to be covered by this Limited Warranty. This Limited Warranty gives produCT InformATIon
Model: ________________________________________________
Serial Number: ________________________________________
Purchase Date: ________________________________________
InSTALLEr InformATIon
Company Name: ______________________________________
Contact Name: ________________________________________
Address: _______________________________________________
________________________________________________________
________________________________________________________
Phone: ________________________________________________
Fax: ____________________________________________________
Email: _________________________________________________ purChASEr InformATIon
Name: ___________________________________________________
Address: _________________________________________________
__________________________________________________________
__________________________________________________________
Phone: __________________________________________________
Email: ___________________________________________________
AddITIonAL InformATIon how did you hear about harmar?
Harmar Dealer
Internet Search
Advertisement
Friend or Acquaintance
Saw Harmar product somewhere
Other____________________________
Which___________________ do you have internet access? Yes No
I purchased my harmar lift because of?
Style/Appearance
Dealer Recommendation
Already Own a Harmar
Ease of Use
Referral from Friend
Price/Value
Harmar 800-833-0478 www.harmar.com 2075 47 th Street Sarasota, florida 34234
© 2012 Harmar 04/04/2012
8
