advertisement
DCA85USJ
MQ POWER WhisperWatt™ Series Generator
Prime Rating — 68 kW (85 kVA)
standby Rating — 75 kW (94 kVA)
60 Hertz
85
WHISPERWATT
standaRd FEatuREs
Heavy duty, 4-cycle, direct injection, turbocharged diesel engine provides maximum reliability.
Brushless alternator reduces service and maintenance requirements and meets temperature rise standards for Class
F insulation systems.
Open delta excitation design provides virtually unlimited excitation for maximum motor starting capability.
Automatic voltage regulator (AVR) provides precise regulation.
Electronic Governor Control (Crystal Sync) — maintains frequency to within ±0.25% from no load to full load.
Full load acceptance of standby nameplate rating in one step
(NFPA 110, para 5-13.2.6).
Sound attenuated, weather resistant, steel housing provides operation at 63 dB(A) at 23 feet. Fully lockable enclosure allows safe unattended operation.
Internal fuel tank with direct reading of fuel gauge.
Seven stage powder coat paint system provides durability and weather protection.
Fuel/water separator removes condensation from fuel for extended engine life. Panel mounted alarm light included.
Complete engine analog instrumentation includes DC ammeter, oil pressure gauge, water temp. gauge, fuel level gauge, tachometer/hour meter, preheat indicator, and emergency shutdown monitors.
Complete generator analog instrumentation includes voltage regulator control, ammeter phase selector switch, voltmeter phase selector switch, AC voltmeter, AC ammeter, frequency meter, panel light, and circuit breaker.
Automatic safety shutdown system monitors the engine oil pressure and coolant temperature. Warning lights indicate abnormal conditions.
Automatic start/stop control — automatically starts the generator set during a commercial power failure when used in conjunction with a transfer switch.
Complete power panel. Fully covered; three-phase terminals and single phase receptacles allow fast and convenient hookup for most applications including temporary power boxes, tools and lighting equipment. The GFCI receptacles are NEMA 5-20, and the auxilillary outputs use CS6369 twistlock receptacles.
Simultaneous single and three phase power.
Voltage selector switch offers the operator a wide range of voltages that are manually selectable. Fine tuning of the output voltage can be accomplished by adjusting the voltage regulator control knob to obtain the desired voltage.
EPA emissions certified - Tier 3 emissions compliant.
dca85usj — MQ POWER WhisPERWatt™ sERiEs gEnERatOR — REv. #10 (12/16/10)
DCA85USJ
MQ POWER WhisperWatt™ Series Generator
sPEciFicatiOns
Generator Specifications
Design
Armature Connection
Phase
Standby Output
Prime Output
3Ø Voltage (L-L/L-N)
Voltage Selector Switch at 3Ø 240/139
3Ø Voltage (L-L/L-N)
Voltage Selector Switch at 3Ø 480/277
1Ø Voltage (L-L/L-N)
(Voltage Selector Switch at 1Ø 240/120)
Power Factor
Voltage Regulation (No load to full load)
Generator RPM
Frequency
No. of Poles
Excitation
Frequency
Frequency Regulation:
No Load to Full Load
Frequency Regulation: Steady State
Insulation
Sound Level dB(A) Full load at 23 feet
Revolving field, self-ventilated
Drip-proof, single bearing
Star with Neutral
3
Zig Zag
Single
75 KW (94 KVA)
68 KW (85 KVA)
208Y/120, 220Y/127,
240Y/139
416Y/240, 440Y/254,
480Y/277
66 KW
60 KW
N/A
N/A
N/A 240/120
0.8
±0.5%
1800
60 Hz
4
Brushless with AVR
60 Hz
1.0
3~5% under varying loads from no load to 100% rated load
±0.5% of mean value for constant loads from no load to full load.
Class F
63
Engine Specifications
Make / Model
Emissions
Starting System
Design
Displacement
No. cylinders
Bore x Stroke (mm)
Gross Engine Power Output
BMEP
Piston Speed
Compression Ratio
Engine Speed
Overspeed Limit
Oil Capacity
Battery
Fuel System
Recommended Fuel
Maximum Fuel Flow (per hour)
Maximum Inlet Restriction (Hg)
Fuel Tank Capacity
Fuel consumption
At full load
At 3/4 load
At 1/2 load
At 1/4 load
John Deere / 4045HF285
EPA Tier 3 Certified
Electric
4-cycle, water cooled, direct injection turbocharged
274.6 in 3 (4500 cc)
4
106 x 127
113.0 bhp (84.3 kWm)
162 psi (1119 kPa)
1500 ft./min. (7.62 m/s)
17:1
1800 rpm
2100 rpm
3.49 gallons (13.2 liters)
12V 72Ah x 1
ASTM-D975-No.1 & No.2-D
15.9 gallons (60 liters)
5.9 in. (150 mm)
126 gallons (150 liters) gph lph
5.3
4.3
3.1
20.1
16.2
11.9
2.0
7.6
dca85usj — MQ POWER WhisPERWatt™ sERiEs gEnERatOR — REv. #10 (12/16/10)
Cooling System
Fan Load
Coolant Capacity (with radiator)
Coolant Flow Rate (per minute)
Heat Rejection to Coolant (per minute)
Heat Rejection to Room (per minute)
Maximum Coolant Friction Head
Maximum Coolant Static Head
Ambient Temperature Rating
Air
Combustion Air
Maximum Air Cleaner Restriction
Alternator Cooling Air
Radiator Cooling Air
Minimum Air Opening to Room
Minimum DischargeOpening
Exhaust System
Gas Flow (full load)
Gas Temperature
Maximum Back Pressure
1.6 hp (1.2 kW)
3.70 gallons (14.0 liters)
38 gallons (144 liters)
3300 Btu (3.5 MJ)
582 Btu (0.614 MJ)
4.0 psi (27.6 kPa)
32 feet (9.8 meters)
104°F (40°C)
226 cfm (6.4 m 3 /min)
25 in. H
2
O (6.25 kPa)
911 cfm (45 m 3 /min)
1589 cfm (30 m 3 /min)
7.85 sq. ft. (0.73 sq. m)
3.87 sq. ft. (0.36 sq. m)
674 cfm (19.1 m 3 /min)
1094°F (590°C)
30.0 in. H
2
O (7.5 kPa)
Amperage
Rated voltage
1Ø 120 Volt
1Ø 240 Volt
3Ø 240 Volt
3Ø 480 Volt
Main Line Circuit Breaker Rating
Over Current Relay Trip Set Point
480V Mode Only
Maximum amps
188.9Amps (4 wire)
250A x 2 (Zigzag)
94.4Amps (4 wire)
250A (Zigzag)
204 Amps
102 Amps
250 Amps
102 Amps
WaRRanty*
john deere
12 months from date of purchase with unlimited hours or 24 months from date of purchase with 2000 hours (whichever comes first).
generator
24 months from date of purchase or 2000 hours (whichever occurs first).
trailer
12 months excluding normal wear items.
*Refer to the express written, one-year limited warranty sheet for additional information
NOTICE
Generator is not intended for use in enclosed areas or where free flow of air is restricted.
Backfeed to a utility system can cause electrocution, shock and/ or property damage. dO nOt connect to any building’s electrical system except through an approved device.
Specifications are subject to change without notice.
DCA85USJ
MQ POWER WhisperWatt™ Series Generator
gEnERatOR OutPut PanEl ultRa-silEnt FEatuREs
low noise Muffler
— Large capacity low noise muffler minimizes exhaust sound.
soundproof casing
— The new design divides the cabinet into three sections, separating the engine, muffler and radiator for more efficient cooling and reduces noise from the engine and fans.
new cooling system
— An advanced design uses two separate air intake systems to cool the generator. The engine fan draws air in to cool the engine and generator housing while a second electric fan directly cools the radiator. With less air being drawn into the generator through each fan, considerably less noise is produced through the top of the generator.
Environmental design
— Constructed using an integrated environmental skid and fuel tank. This design fully contains fuel leakage and any liquid that might leak from the engine such as lube oil or radiator coolant. All potentially hazardous liquids are contained without contaminating the surrounding area.
Outside Air
Electric Fan Radiator
Diesel
Engine
Control
Box
Outside Air
AC Generator
OPtiOnal cOntROl FEatuREs
Emergency stop switch
— when manually activated shuts down generator in the event of an emergency.
audible alarm
—
alerts operator of abnormal conditions.
OPtiOnal gEnERatOR FEatuREs
Electronic governor control (crystal sync)
— maintains frequency to within ±0.25% from no load to full load.
Battery charger
— provides fully automatic and selfadjusting charging to the generator's battery system.
jacket Water heater
climates.
— for easy starting in cold weather
special Batteries
cranking power.
— long life batteries provide extra engine
spring isolaters
— provides extra vibration protection for standby applications.
low coolant level shutdown
warning light.
— provides protection from critically low coolant levels. Includes control panel
trailer Mounted Package
— meets National Highway
Traffic Safety Administration (NHTSA) regulations. Trailer is equipped with electronic or surge brakes with tandem axle configuration.
OPtiOnal OutPut cOnnEctiOns
cam-lock connectors
— provides quick disconnect alternative to bolt-on connectors.
Pin and sleeve connectors
— provides industry standard
connectors for all voltage requirements.
Output cable
configuration.
— available in any custom length and size
Flow of Cooling Air dca85usj — MQ POWER WhisPERWatt™ sERiEs gEnERatOR — REv. #10 (12/16/10)
diMEnsiOns
DCA85USJ
MQ POWER WhisperWatt™ Series Generator
Weight
Dry Weight
Wet Weight
Max. Lifting
Point Capacity
5,094 lbs. (2,310 kg)
6,048 lbs. (2,743 kg)
14,050 lbs. (6,370 kg)
Your Multiquip dealer is:
Hardy Diesels & Equipment Inc.
15749 Lyons Valley Rd.
Jamul, CA 91935
800-341-7027 www.HardyDiesel.com
© COPYRIGHT 2010 MULTIQUIP INC.
DCA85USJ2 Rev. #10 (12/16/10)
Generator can be placed on a
MQ Power Model TRLR85US
Tandem Axle Trailer
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project
Related manuals
advertisement