Lubrication. DR POWERWAGON 5.0

Lubrication

Your DR POWERWAGON 5.0 was lubricated at the Factory. The transmission is lubricated for life with 16 ounces of 90-weight gear oil and sealed at the factory. The operator needs only to provide engine lubrication, wheel and cable lubrication.

Supplies Needed:

FLUID FILM

®

or comparable lubricant

#2 Lithium Grease

WARNING!

Before performing any maintenance procedure, stop the

engine, set the parking brake and disconnect the spark plug wire.

1. There are two grease fittings on the swivel wheel: one at the top front of the wheel bracket, and one toward the center of the wheel (Figure 11). Grease these two fittings with #2 lithium grease to keep the wheel spinning freely at least every 25 hours of operation per the

Maintenance Checklist on page 16.

2. Lubricate the parking brake lever cable at the operator's end. Clutch lever cable should be lubricated at both ends (Figures

12 & 13), and the key switch, with

FLUID FILM

®

or similar lubricant.

Operate the levers to work lubricant into the cables.

Figure 11

Grease Fittings

Lubricate Clutch Cable

Lubricate

Figure 12

Lubricate

DR POWERWAGON 5.0 Safety & Operating Instructions

Figure 13

18