Vision 17E (230 Volt)

Vision 17E 230V

Section II

Parts and Service Manual

Order Parts Here:

www.ivie-ent.com/parts

Ph:(918)254-5161

(78453B)

HOW TOO CORRECT PROBLEMS IN THE MACHINE

P

ROBLEM

There isn't any solution flow.

The solution flow does not stop.

The machine does not remove any water from the floor.

The machine does not remove all the water from the floor.

C

AUSE

A

CTION

The solution tank is empty.

Fill the solution tank.

The solution knob is turned too far to the left.

Turn the solution knob to the right.

There is an obstruction in the hose or filter.

Remove the obstruction from hose or filter.

The solution valve or linkage is damaged.

Repair or replace the valve or the linkage.

The solution valve is open.

The solution valve or linkage is damaged.

The solution valve is dirty.

There is a damaged seat and washer in the solution valve.

The valve steam is dirty.

The squeegee is up.

The vacuum motor is not running.

The vacuum motor switch is defective.

The recovery tank is full.

The vacuum shut-off float circuit is open.

The vacuum filter screen is dirty.

There is an obstruction in the vacuum tube.

There is an obstruction or damage in the squeegee, vacuum hose or standpipe.

The squeegee hose is disconnected.

The squeegee blades are damaged, worn, or incorrectly installed.

There is an obstruction or damage in the squeegee, vacuum hose or standpipe.

The filter screen is dirty.

The gasket on the cover of the recovery tank are damaged.

Defective vacuum motor.

Close the solution valve.

Repair or replace the valve or the linkage.

Clean the solution valve.

Replace the valve.

Clean and lubricate the valve stem.

Lower the squeegee.

Put the switch in the "ON" position.

Have an authorized Clarke person make repairs.

Drain the tank.

Recovery tank is full. Empty the tank.

Clean or replace the filter screen.

Remove the obstruction.

Remove the obstruction or repair the damage.

Connect the hose.

Turn or replace the squeegee blade.

Correctly install the squeegee blade.

Remove the obstruction or repair the damage.

Clean or replace the filter screen.

Replace the gasket.

Have an authorized Clarke person make repairs.

The cleaning is not even.

The scrub brush or pad are worn.

There is damage to the brush assembly casters or to the solution valve.

The motor is not running.

Replace the scrub brush or pad.

Have an authorized service person make the repairs.

Repair the wiring, replace the switch,

Service the motor, circuit breaker and the contractor.

Page -20CLARKE TECHNOLOGY Operator's Manual -Vision 17E 230V

NOTES

S

CLARKE TECHNOLOGY Operator's Manual - Vision 17E 230V Page -21-

CLARKE TECHNOLOGY

Vision17E (230V)

Machine Assembly 2/01

2 3

4

1

50

25

24 23

22

21

26

27

53

54

18

37

17

46

28

20

49

18

55

57

56

38

31 24

44

33

45

41

35

40

6

18

43

32

29

34

7

8

34

19

10

41

36

31

42

38

39

9

18

16

15

13

12

14

47

48

10

10

58



Vision 17E 230V

Machine Assembly Parts List 2/01

Ref

1

2

3

4

5

Part No.

Description

55531A Knob, Handle

34804A Handle, Control

Page 29 ASM, Solution Tank

Page 30 ASM, Recovery Tank

Page 26 ASM Brush, 230V Motor

Page 32 Gear Box Parts List

Page 33 Brush Motor Parts List

6

7

8

643418

58534A

Gasket Vacuum Motor

Spacer

44907A Motor, 230V Vacuum

Page 31 Vacuum Motor Parts List

1

3

1

9 30448A

10 K 980603

12

13

Page 23

Hose, Exhaust, Vacuum

Washer, Shake Proof

ASM, Brush Lift

Page 15 Pad or Brush Driver

14

15

33

34

35

36

16

17

18

19

20

21

22

23

24

25

26

27

28

29

31

32

37

38

39

40 833901

41 K 962987

42

43

44

45

46

Page 22

Page 28

61664A

66515A

85395A

30415A

84238A

49691B

37108A

Page 27

84237A

55502A

49690B

38952B

61244A

839401

87026A

833407

832102

832002

Pg 24/25

47604A

30407B

752020

53630A

52206A

962943

962981

962109

47 920110

48 K 920296

49 K 66939A

50 980413

51

53

54

962950

63040A

77261A

83010A

55 47201A

56 K 85414A

57 49793A

58 K 962768

NI 77094A

ASM, Non Traverse Electric

ASM, Squeegee

Cable, Squeegee

Pin, Locking

Screw, 1/4 - 20 S.S..

Hose, Drain

Screw 5/16 Flat

Harness, Brush

Panel, Rear

ASM, Panel Control 230V

Screw, 10 - 32 X 1/2 S.S.

Knob, Solution Control

Harness, Vacuum Motor

Support Tank

Bracket Tank

Valve, Drain

Washer

Gasket, Drain

Clamp, Solution Cable

Clamp, Plastic

ASM, Main Frame

Terminal ¼ FIMQDIS 14 GA

Hose, Squeegee

Clamp, Hose

Elbow, Recovery

Handle, Drain Valve

Screw

Screw 1/4 - 20 x 3"

Chain

Screw 8-18 x ½

Screw

Screw 10-24

Nut 5 /

16

-18 ESNA

Nut 10-24

1

3

1

1

1

1

1

1

8

1

2

1

1

1

4

1

1

1

5

1

7

1

2

2

Retainer

Washer

Bracket, Recovery

Plate, Warning

Rivet

Supressor (00370E only)

Screw (00370E only) 2

Harness, Supressor (00370E only) 1

2

1

2

1

Screw, 10-24 x ½

Label Ground

1

3

1

1

1

1

2

3

1

1

2

2

2

1

Ref.

1

1

2

NI

NI

NI

77078A

77046A

77076A

Label, Warning

Label, TUV, GS

Label, Warning (Hands)

4

1

1

Qty

2

1

1

1

1

NOTE: K indicates a change has been made since the last publication of this manual.


1

4

6

3

1


Vision 17E (230V)

ASM, Non Traverse Axle

Drawing & Parts List Form #10510A 2/01

2

5

1

3

1

6

4

Page -24-

Ref

1

2

3

Part No.

87613A

61247A

59936C

4 54014A

5 60196A

6 K 87039A

Description

Washer, Nylon 5/8

Bracket, axle

Wheel

Fitting, Grease, ¼"-20

Shaft

Washer, Fender ¼" SS

Qty

7* Nominal

1

2

2

1

2

NOTE: Place washers as required to center the wheels

(Number of washers may vary)

NOTE: Grease wheels once a week.

NOTE: Kindicates a change has been made since the last publication of this manual.

CLARKE TECHNOLOGY Operator's Manual -Vision 17E 230V

1

2

4

3


Vision 17E (230V)

Brush Lift Drawing & Parts List 11/98

ASM

Form #16608A

5

5

3

4

2

Ref

1

2

3

4

5

Part No.

Description

65424A Lift Brush, Weldment

85600A

51516A

Screw 1/4 - 20

Bushing

608210

920208

Spacer, Handle, Bolt

Nut, ¼-20

CLARKE TECHNOLOGY Operator's Manual - Vision 17E 230V

Qty

1

2

2

2

2

Page -25-


Vision 17E (230V)

ASM, Main Frame

Drawing 2/01

Form #16923A

1

46

48

37 29

39

23

43

33

29

38

36

35

34

40

33

15

30

44

15

20

31

26

29

28

27

21

19

5

22

47

35

32

15

24

9

42

3

50

7

49

7

8 8

5

6

2

45

18

15

13

14

17

10

11

25

16

12



Vision 17E (230V)

ASM, Main Frame

Parts List 2/01

Form #16923A

40

42

43

44

36

37

38

39

29

30

31

32

25

26

27

28

21

22

23

24

17

18

19

20

13

14

15

16

9

10

11

12

Ref

1

2

3

Part No.

Description

63423B Weldment, Main Frame

84238A

53618A

Screw 5

Adapter

/

3

16

/

8

-18 x ¾ Flat Hd SS

X 3 /

8

4

5

64456A

87026A

6 85384A

7 K 85395A

8 64505A

Handle

Washer, S.S. ¼" Flat

Screw ¼ - 20 X ½

Screw ¼ - 20 X ½

85822A

31227A

66960A

38009A

Hinge Tank

Screw 3 /

8

-16 x 7 /

8

Shirt, Main Frame

Retainer, Skirt

980442

68733A

81104A

52117A

Guide, Plastic

Wave Washer

Kick Stand

Nut ¼ - 20 Nylock

920110

52047A

69028A

85391A

Caster, Swivel

Nut, 5 /

16

- 18 Elastic

Cap

Wldmt. Squeegee Swival

60698A

170915

66939A

87614A

Screw ¼ - 20 1

Squeegee, Bracket, Weldment 1

Screw ¼-20 x ¾

Retainer, Motor Pivot

4

1

Qty

1

6

1

2

6

1

4

1

2

1

1

3

2

1

6

1

1

2

6

84233A

67867A

85396A

61252A

Washer 3 /

8

Int., Ext.

Screw ¼ - 20 Flat

Nut, Squeegee Spacer

Screw

1

6

1

1

87027A

30517A

58612A

68730B

Bracket, Swing Squeegee

Washer

Bushing Squeegee

Spring, Squeegee

1

1

1

3

33

34

35

10735A

67422A

85397A

85397A

Bracket, Arm Weldment

Weldment, Brake, Pedal*

1

1

Shaft Parking Brake* 1

Screw 10 - 24 X 3 /

8

(00370B)* 13

87036A

66536A

67133A

17519A

Screw 10 - 24 X 3 /

8

(00370E)* 15

Washer #10 SS* 2

Pin, Pivot, Brake*

Rod, Adj. Brake*

2

1

87613A

722021

608340

925597

Brake, Pad, Weldment*

Washer, Nylon*

Clamp Hose

Spring, Brake, Latch*

1

1

1

2

45

46

66961A

10773A

47 81112A

48 84229A

49 K 49068A

50 K 980614

Pin 3 /

8

Dia. SS

Retainer Skirt

Kit, Parking Brake

Nut, 5 /

16

-18 thin ESNA

Screw, 5 /

16

-18 x .88

Wire, Ground

Washer, ¼ Starlock

1

2

Ref

1

1

1

1

NOTE: *Item 29, 35, 36, 37, 38, 39, 40,43 included with

Item #46, Parking Brake Kit 10773A. Standard on

00370E only)

NOTE: KIndicates a change has taken place since last publication of this manual.



Vision 17E (230V)

Brush Motor Assembly

Drawing and Parts List 2/01

Form #17114A

1

3

2

17

4

5

6

16

15

14

9

10

11

12

13

7

8

4

5

6

7

Ref

1

2

3

8

9

Part No.

Description

47604A Terminal, Brush Motor

44711A

80501A

Gear Mtr 250 RPM 230V

Key (with #4)

81104A

980662

67865A

63600A

84242A

20308A

Nut 1/4 - 20 Nylock

Washer

Spacer Tilt handle

Guide RH

Screw 1/4 - 20 X 5/8

Adapter Motor

Page -28-

Qty

2

1

1

2

1

1

2

1

Ref

10

11

12

Part No.

980679

980210

980652

13 85811A

14 K 85727A

15 980638

16

17

61238A

68761A

Description

Spacer Washer

Washer Impeller

Washer, Lock 5/16

Screw 5/16 Hex

Screw 3/8 - 16 X 1 Hex Head

Lockwasher 3/8

Bracket Motor Lift

Guide L.H.

NOTE:

K indicates a change has been made since the last publication of this manual.

1

4

4

1

1

Qty

1

1

1



Vision17E (230V)

Panel Assembly

Drawing & Parts List 2/01

Form # 17647A

1

1

2

9

13 12

10

11

9

8

10

15

14

7

16

3

5

6

7

4

5

2

3

Ref

1

8

9

10

11

NI

NI

NI

NI

NI

46103A

920056

920224

980603

12

13

43604A

912059

14 54349A

15 912201

16

K

170870

NI 42909A

49689B

77094A

699202

47808A

49064A

Part No.

Description

47316B Switch, Rocker DPST

66178B

962212

Panel, Control

Screw, 6 - 32 X 7/8

42086A

41437A

85383A

82100A

Cord, Power Supply

Circuit, Breaker 5 amps

Screw, 10 - 32 X 3/4

Locknut, 1/2 Conduit

Rectifier, Bridge

Nut 6 - 32 Elastic

Nut, 10 - 32 Hex

Washer, Shakeproof #1103

Strip, Insulation

Terminal, Block

Gasket

Fuse Holder

Washer

Fuse

Harness, Wiring Power

Label, Ground

Tie, Wire

Terminal ¼ FIFQDIC

Wire Jumper

1

1

2

2

1



1

1

1

1

1

1

3

2

2

1

1

1

1

Qty

2

1

3

6

3

5

4

Page -29-

2


Vision 17E (230V)

Squeegee Assembly Drawing & Parts List 11/98

Form 18809A

4 1 3

5 1

6

7

8

3

4

5

Ref

1

2

Part No.

Description

66921B Retainer, Squeegee

30902A Blade, Squeegee Rear

27703A

30903A

85398A

Squeegee, Casting

Blade, Squeegee Front

Screw ¼ - 20 X ½

838201

839702

962841

Spacer, Wheel Guide

Wheel, Brush Guide

Screw, 5 /

16

- 18 x 1¼

Blades Available:

30918A Blade, Sq., Front Nitrile/EPDM

30919A Blade, Sq., Rear Nitrile/EPDM

1

1

Qty

2

2

1

1

18

2

2

2


8

7

6


Vision 17E (230V)

Solution Tank Assembly


Form #19169A

25

26

1

2

22

23

15

14

28

29

10

30

40

31

16

38

39

17 4

5

36

27

10

34

41

32

33

12

13

35

13

14

15

16

10

12

8

9

6

7

4

5

Ref

1

2

3

17

18

19

Part No.

Description

692409 Chain Cover

85519A

832322

Screw ¼ - 20 X 3

Cover, Sol. Tank

/

8

878535

60317A

53614A

849401

53618A

35138A

962798

30416A

752020

832002

839401

38964B

962943

722021

833401

Strainer, Sol. Tank

Adapter, Filter

Elbow, Solution

Valve, Solution

Adapter, 3 /

8

x 3 /

Hose, Solution

8

Screw 10-24 X ½

Hose, Drain

Clamp, Hose

Clamp, Hose

Drain

Tank, Solution

Screw

Clamp, Hose

Gasket, Drain


1

1

1

1

1

1

1

1

1

1

1

1

Qty

1

1

1

1

1

1

19

20

21

6

37

9

18

8

7

Ref

20

21

22

Part No.

980630

920264

52206A

23 833407

24 K 81110A

25 962987

26

27

28

29

30

31

32

33

34

35

36

37

833901

84237A

81217A

68762A

68646A

81110A

64476A

53030A

980651

80031A

52755A

52503A

Description

Washer

Nut ¾ - 16 Hex

Chain, Cover

Gasket, Drain

Nut, 10-24

Screw, 10-24 x

Spring, Taper

Washer

Bolt, Shoulder

Cover, Handle

Cable, Solution

3

Ratchet, Handle

/

Handle, Drain Valve

Screw, 10-32 x ½

Nut ¼-20 Nylock

8

Plate, Squeegee Lift

Plate, Wear

Nut, 10-24 Nylock S.S.

Handle, Squeegee Lift

38 36101A

39 84236A

40 K 980603

41 K 49067A

Screw, 6-32

Washer, Shakeproof

Wire, 18" Gauge

10

3

24

1

1

2

1

1

1

2

1

1

1

1

1

Qty

1

1

1

6

1

1

1

2

1

1


17

16

20

21

18

19


Vision 17E (230V)

Recovery Tank Assembly


Form #19170A

1

2

4

5

6

7

8

11

10

4

11

14

Ref

1

2

Part No.

Description

58012A Strainer, Rec. Tank

59314A Tube, Stand, Recovery

4

5

6

7

837304

962798

692409

832322

8 34256A

10 K 81110A

11 920797

12 66933A

O'Ring Seal

Screw, 10-24 x ½

Chain, Cover

Cover, Solution Tank

Gasket, Rec. Drain

Nut 10-24

Nut, Drain Valve Lock

Elbow, Retainer

Page -32-

12

13

Qty

1

1

1

1

2

1

1

1

2

1

15

16

17

18

19

20

21

NI

Ref

13

14

15

Part No.

Description

38966B

53629A

85395A

82100A

87612A

14092A

85519A

39323A

56459A

51828A

Tank, Recovery

Elbow, recovery Drain

Screw, ¼-20 x ½

Nut, ½ Conduit

Seal, Washer

Switch, Float Shut-Off

Screw, ¼-20 x 3

Tube, Recovery

Strainer, Relief

Strap, Hose

/

8


1

1

1

1

1

1

2

Qty

1

1

2


1

4

5

6

7

9


Vision 17E (230V)

Vacuum Motor


Form #44907A

2

8

3

13

20

14

15

16

10

11

21

17

12

Ref # Part No.

Description

1 not available

6

7

4

5

2

3

54809A

53905A

51914A

51401A

50618A

638313

Housing - Vent

Fan

Qty

Clamp

Carbon Brushes 230V

Commutator End Bracket 1

Load Spring 1

2

2

1

2

8

9

53100A

902679

10 902648

11 59803A

Disc

Ball Bearing

Ball Bearing

Neoprene Washer

1

1

1

1

15

16

17

18

Ref # Part No.

Description

12 50610A Fan End Bracket

13

14

58501A

53914A

Spacer

Vacuum Fan

658201

53908A

57904A

980205

Spacer

Stationary Fan

Fan Shell

Washer

19

20

21

920329

53906A

53914A

Nut

Fan

Fan - Rotating


18

19

Page -33-

1

1

1

1

1

1

1

Qty

1

1

2


Vision 17E (230V)

ASM, Gear Box #54238A


1

2

3

4

5

6

7

8

9

Page -34-

4

5

6

7

Ref

1

2

3

8

9

NI

Part No.

Description

57846A Ring, Snap

58143A

52050A

Seal, Oil, Small

Cap End

56668A

51176A

58316A

902605

54883A

58144A

O - Ring

Bearing, Large

Shaft and Gear

Bearing, Small

Housing

Seal, Oil Large

Grease

Qty

1

1

1

1

1

1`

1

1

1

1oz



Vision 17E (230V)

Brush Motor 44711A

Parts List 8/97

S

EAM

L

OCATION

13

7 12

15

5

6

4

1 2

3

14

16

12

17

11

8

9

10

10

11

12

13

6

7

8

9

14

15

16

17

Item

1

2

3

4

5

Part No.

56477A

50140A

902654

902550

51837A

50520A

56480A

962546

50519A

448396

40819A

55654A

55655A

59805A

50515A

80501A

54238A

Description Qty

Stator Frame Assembly (w/Magnets & Clips) 1

Armature Assembly (w. B.E. & F.E. Bearings)

Bearings B.E.

1

1

Bearing F.E.

Commutator Bracket Assembly

(w/Brush BRD Assembly Leads)

Commutator Bracket

1

1

Strain Relief

Brush Board Screw

Brush Board Assembly (w/ Springs & Brushes)

Brush Spring

2

1

1

2

Brush Assembly

Lead Assembly

Lead Assembly

Helical Washer

1

1

4

4

Thru Bolt

Shaft Key

B.E. Bracket Assembly (Gear Box)

1

2

1

1


13

Page -35-


Vision 17E (230V)

Model #00370B - 230V Electrical Schematic 2/01



Vision 17E

Model #00370B - 230V Connection Diagram 2/01



Vision 17E (230V Europe)

Model #00370E - Electrical Schematic 2/01



Vision 17E (230V Europe)

Model #00370E - Connection Diagram 2/01


Vision 17E (230 Volt)

Vision 17E 230V

Parts and Service Manual

www.ivie-ent.com/parts

(78453B)

HOW TOO CORRECT PROBLEMS IN THE MACHINE

NOTES

Related manuals

Alto

Vision 17E

Clarke

Alto Vision 17E

Alto

Vision 17E

Clarke

Alto Vision 17E

T & S Brass & Bronze Works

B-1400

Alto

Vision 17BT

Clarke

Encore

Clarke

Encore S20E

Clarke

Encore S20