Maintenance. Bowflex TC5, BowFlex TC5, TreadClimber TC5

Maintenance

Read all maintenance instructions fully before you start any repair work. In some conditions, an assistant is required to do the necessary tasks.

Equipment must be regularly examined for damage and repairs. The owner is responsible to make sure that regular maintenance is done. Worn or damaged components must be repaired or replaced immediately. Only manufacturer supplied components can be used to maintain and repair the equipment.

This product, its packaging, and components contain chemicals known to the State of California to cause cancer, birth defects, or reproductive harm. This Notice is provided in accordance with California’s Proposition

65. If you would like additional information, please refer to our Web site at www.nautilus.com/prop65.

To reduce the risk of electrical shock or unsupervised usage of the equipment, always remove the batteries from the machine and wait 5 minutes before cleaning, maintaining or repairing the machine.

Daily: Before each use, inspect for loose, broken, damaged, or worn parts. Do not use the machine if any of these conditions exist. Use a dry cloth to wipe off any perspiration after each use.

Weekly: Check for smooth roller operation. Clean the machine to remove dust, dirt, or grime. Clean the top of the belt with a slightly damp, soapy cloth and wipe carefully and thoroughly with a dry cloth. Do not let any liquid get below the belts or into the Base Frame.

Monthly: Make sure all bolts and screws are tight. Tighten if necessary.

NOTICE: Do not clean with a petroleum based solvent or an automotive cleaner. Be sure to keep

the Console free of moisture.

23

Maintenance

24

Walking Belt and Deck Lubrication

The TreadClimber ® machine is equipped with a low maintenance deck and belt system. Belt friction can affect the function and life of the machine. Your TreadClimber ® fi tness machine came with a starter supply of lubrication for the belts.

Lubrication Schedule

User Level

Light

Moderate

Heavy

Total Workout Hours per Week less than 3 hours

3 to 5 hours

5 or more hours

When to Lubricate every 3 months every 2 months every month

We recommend that you use one of the following:

• Lube-N-Walk ® Treadmill Lubrication Kit (available from www.bowflex.com or your local specialty fitness dealer)

• 100% pure silicone (available at most hardware and auto parts stores)

For the best results lubricate the Treadles periodically with a silicone lubricant using the following instructions:

1. Remove the batteries from the machine.

2. Carefully lift each belt and apply silicone lubricant in the center of the Treadle deck along the entire reachable length of the deck. Apply 0.15 to 0.25 oz. of the lubricant on the deck underneath each belt.

NOTICE: Always use a 100% pure silicone lubricant. Do not use a degreaser like WD-40 ® as this could seriously impact performance.

Note: The Walking Belts may need to be loosened to allow for access during lubrication. Consult the “Adjusting the Walking Belts” procedure if necessary.

3. Stay to one side of the machine and grasp the handlebars for support.

4. With one foot push the nearest belt toward the back of the machine at a very slow speed for approximately 15 seconds. Do not step on any excess lubricant, grease, or oil while pushing the belt.

5. Take care to clean up any excess lubricant from the Treadles. We also recommend a periodic inspection of the

Treadle surfaces below the belts. If the decks appear worn, contact a TreadClimber ® Representative (refer to the

Contacts section of this manual).