advertisement
Specifications
NOTE: Specifications are correct at time of printing and are subject to change without notice.
ENGINE:
28 HP Briggs & Stratton
Make
Model
Horsepower
Displacement
Electrical System
Oil Capacity
Briggs & Stratton
541777-0110-E1
28 @ 3600 rpm
54.68 Cu. in (896 cc)
12 Volt, 20 amp. Alternator, Battery: 340
CCA
2.4 qt. (2.25 L) w/ Filter
TRANSMISSIONS:
HydroGear PJ-3H / HGM-15E 3138
Type
Hydraulic Fluid
Speeds
@ 3400 rpm
Continuous Torque
Output
Maximum Weight on Axle
Pump and Wheel Motor
Mobil 1™ 15W-50 synthetic oil or
Castrol Syntec™ 5W-50 oil
Forward: 0-10 MPH (0-16.09 km/h)
Reverse: 0-5 MPH (0-8.05 km/h)
222 ft. lbs. (301 N.m.)
750 lbs. (340 Kg)
CHASSIS:
Fuel Tank
Rear Wheels
Front Wheels
Capacity: 6 Gallons (22,7 L) Total
Tire Size: 22 x 11.00 -10 (61” Deck)
Inflation Pressure: 15 psi (1,03 bar)
Tire Size: 13 x 5.00 - 6
Inflation Pressure: 25 psi (1,72 bar)
DIMENSIONS:
Overall Length
Overall Width
81” (208 cm)
72” (183 cm) - 61” Deck
Height 70” (178 cm) with Roll Bar Up
59” (150 cm) with Roll Bar Down
Weight (apx..)
With 61” Mower Deck 1222 lbs. (554 kg)
Engine Power Rating Information
The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of
Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 2002-05). Torque values are derived at 3060 RPM; horsepower values are derived at 3600 RPM. Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual "on-site" or net power). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine.
46 www.ferrisindustries.com
Ferris Industries - a division of Simplicity Manufacturing Inc.
Owner's Limited Warranty Information
(Effective 04/28/2004)
Thank you for purchasing Ferris commercial mowing equipment. Please take a few minutes to read this limited warranty information. It contains all the information you will need to have your Ferris mower repaired in the unlikely event that a breakdown covered by this limited warranty should occur.
Owner's Responsibilities - As a condition to our obligations under this limited warranty, you shall have read the operator's manual and you shall have completed and submitted to Ferris, within 20 days from the date of purchase, the Ferris Product Registration. You must properly service and maintain your Ferris product as described in the operator's manual. Such routine maintenance, whether performed by a dealer or by you, is at your expense.
The Ferris equipment, including any defective part covered by this limited warranty, must be returned to an authorized Ferris dealer within the warranty period for warranty service. This limited warranty extends only to equipment operated under normal conditions and in accordance with Ferris' instructions.
Warranty Start Date - The limited warranty coverage begins on the day you buy your new Ferris commercial mowing equipment. An authorized Ferris dealer will assist you in filling out a Ferris Product Registration with specific information for the model you purchase and your personal information, which must be returned to Ferris.
Limited Warranty - The limited warranty, set forth below, is a written guarantee by Ferris, during the warranty period, to repair or replace parts which have a substantial defect in materials or workmanship. The warranty is "limited" because it is for a specified period of time, applies to the original purchaser only, and is subject to other restrictions.
FERRIS LIMITED WARRANTY
Ferris Industries (Ferris) warrants, in accordance with the provisions below, to the original purchaser only, for the periods described below that the commercial mower shall be free from substantial defects in material or workmanship under normal use and service. If you wish to file a claim under this limited warranty, you must provide prompt notice of your claim to an authorized Ferris dealer during the warranty period. Ferris' obligation under this limited warranty is, at Ferris' option, to repair or replace any part or parts of the mower, which, in the judgment of Ferris, are found to be defective and covered by this limited warranty. An authorized Ferris dealer will repair or replace the defective part or parts, at the dealer's place of business, at no charge for the labor or parts. This limited warranty applies only to mowers sold in the United States and Canada and is subject to the following limitations.
Covered Parts
All Mowers
*Belts, Tires, Brake Pads
And Hoses, Battery, Blades
Warranty Period
2-years (24 months) from date of retail purchase by the original purchaser for parts & labor (90 days for rental mowers)
(Except as noted below*)
90 days from date of retail purchase by the original purchaser
*Attachments
*Engine
1 year from date of retail purchase by the original purchaser
If the engine manufacturer provides any warranty on the mower's engine, Ferris will assign that warranty to the original purchaser of the mower if such assignment is reasonably practicable. Please refer to the engine manufacturer's warranty statement, if any, that is included in the owner's packet. We are not authorized to handle warranty adjustments or repairs on engines. Ferris offers NO WARRANTY on mower engines. Ferris does not guarantee or represent that any engine manufacturer will comply with the terms of its warranty.
Items and Conditions Not Covered
This warranty does not cover, and Ferris makes NO WARRANTY regarding, the following:
• Mowers or their parts if a complete and accurate Ferris Product Registration has not been received by Ferris.
• Loss or damage to person or property other than that expressly covered by the terms of this limited warranty.
• Pickup and delivery charges and risk of loss or damage in transit to and from any authorized Ferris dealer.
• Any damage or deterioration due to normal use, wear and tear, or environmental or natural elements, or exposure.
• Cost of regular maintenance service or parts, such as but not limited to, filters, fuel, lubricants, tune-up parts, and adjustments.
• Claims arising due to failure to follow Ferris' written instructions, or improper storage or maintenance.
• Any repairs necessary due to use of parts, accessories or supplies, including gasoline, oil or lubricants, incompatible with the mowing equipment, or other than as recommended in the operator's manual or other written operational instructions provided by Ferris.
• Use of non-Ferris approved parts or accessories.
• Any overtime or other extraordinary repair charges or charges relating to repairs or replacements.
• Rental of like or similar replacement equipment during the period of any warranty, repair or replacement work.
• Loss of revenue, time or use of the mowing equipment.
• Travel, telephone or other communication charges.
• Damage from continued use of defective mowing equipment.
• Freight charges on replacement parts.
• Any mowing equipment or part which, in the judgment of Ferris, has been altered or tampered with in any way or has been subjected to misuse, abuse, abnormal usage, unauthorized repair, neglect or accident, damage in transit, or has had the serial numbers altered, effaced or removed.
• Any equipment, part or item not mentioned under "Covered Parts," above.
General Conditions
Ferris is continually striving to improve its products, and therefore reserves the right to make improvements or changes without incurring any obligation to make changes or additions to products sold previously. Any oral or written description of Ferris products is for the sole purpose of identifying the products and shall not be construed as an express warranty. No warranty claim shall give rise to a right for the purchaser to cancel or rescind any sale. No person is authorized to make any warranty or assume for Ferris any liability not strictly in accordance with this limited warranty. Any assistance Ferris provides to or procures for the purchaser outside the terms, limitations or exclusions of this limited warranty will not constitute a waiver of the terms, limitations or exclusions of this limited warranty, nor will such assistance extend or revive the limited warranty. Ferris will not reimburse the purchaser for any expenses incurred by the purchaser in repairing, correcting or replacing any defective products except for those incurred with Ferris' prior written permission and in accordance with this limited warranty.
Ferris' sole and exclusive liability with respect to this limited warranty, and the purchaser's exclusive remedy, shall be repair or replacement as set forth herein. All warranty work must be performed by an authorized Ferris dealer using only Ferris approved replacement parts.
FERRIS SHALL HAVE NO
LIABILITY FOR ANY OTHER COST, LOSS OR DAMAGE, INCLUDING BUT NOT LIMITED TO, ANY INCIDENTAL, COMPENSATORY, INDIRECT,
PUNITIVE, SPECIAL OR CONSEQUENTIAL LOSS OR DAMAGE. FERRIS' AGGREGATE LIABILITY WITH RESPECT TO A DEFECTIVE PROD-
UCT OR PART SHALL BE LIMITED TO AN AMOUNT EQUAL TO THE MONIES PAID BY THE PURCHASER FOR THAT DEFECTIVE PRODUCT
OR PART. THIS LIMITED WARRANTY, AND FERRIS' OBLIGATIONS HEREUNDER, ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WAR-
RANTIES, EXPRESS OR IMPLIED, INCLUDING, WITHOUT LIMITATION, THE IMPLIED WARRANTY OF MERCHANTABILITY AND THE IMPLIED
WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE. FERRIS SHALL NOT BE LIABLE TO THE PURCHASER, OR TO ANYONE CLAIMING
UNDER THE PURCHASER, FOR ANY OTHER OBLIGATIONS OR LIABILITIES, INCLUDING, BUT NOT LIMITED TO, OBLIGATIONS OR LIABILI-
TIES ARISING OUT OF BREACH OF CONTRACT OR WARRANTY, NEGLIGENCE OR OTHER TORT OR ANY THEORY OF STRICT LIABILITY,
WITH RESPECT TO FERRIS PRODUCTS OR FERRIS' ACTS OR OMISSIONS OR OTHERWISE.
It is the express wish of the parties that this agreement and any related documents be drafted in English. Il est la volonté expresse des parties que cette convention et tous les documents s'y rattachent soient rédigés en anglais.
Product Specifications:
ENGINE:
28 HP Briggs & Stratton
Make
Model
Oil Capacity
Briggs & Stratton
541777-0110-E1
2.4 qt. (2.25 L) w/ Filter
CHASSIS:
Fuel Tank
Rear Wheels
Front Wheels
Capacity: 6 Gallons (22,7 L) Total
Tire Size: 22 x 11.00 -10
Inflation Pressure: 15 psi (1,03 bar)
Tire Size: 13 x 5.00 - 6
Inflation Pressure: 25 psi (1,72 bar)
OPERATOR’S
MANUAL
IS1500ZX Series
Zero-Turn Riding Mower
Common Service Parts:
BELTS AND BLADES:
TRACTOR
Pump Drive Belt 5100555
61” MOWER DECK
Deck Drive Belt
Mower Blade
5022061
5020842
Briggs & Stratton Power Products Group, LLC.
5375 North Main Street
Munnsville, NY 13409
800-933-6175 www.ferrisindustries.com
advertisement
Related manuals
advertisement
Table of contents
- 4 Operator Safety
- 13 Identification Numbers
- 14 Safety Decals
- 15 Safety Interlock System
- 16 Features & Controls
- 16 Control Functions
- 18 Operation
- 18 General
- 18 Checks Before Starting
- 19 Starting the Engine
- 19 Stopping the Rider
- 19 Pushing the Rider by Hand
- 20 Zero Turn Driving Practice
- 22 Mowing
- 22 Mowing Recommendations
- 23 Mowing Methods
- 24 Attaching a Trailer
- 25 Raise & Lower the Roll Bar
- 26 Storage
- 26 Starting After Long Term Storage
- 27 Regular Maintenance
- 27 Maintenance Schedule
- 28 Checking Tire Pressures
- 28 Checking/Adding Fuel
- 28 Fuel Filter
- 28 Oil & Filter Change
- 29 Check Hydraulic Oil Level
- 29 Hydraulic Oil Filter Change
- 30 Lubrication
- 31 Battery Maintenance
- 32 Servicing the Mower Blades
- 34 Troubleshooting, Adjustments & Service
- 34 Troubleshooting the Tractor
- 35 Troubleshooting the Mower
- 36 Troubleshooting Common Cutting Problems
- 37 Seat Adjustment
- 37 Ground Speed Control Lever Adjustment
- 37 Speed Balancing Adjustment
- 38 Neutral Adjustment
- 38 Return to Neutral Adjustment
- 39 Parking Brake Adjustment
- 40 Rear Suspension Adjustment
- 41 Mowing Height Adjustment
- 41 Foot Pedal Adjustment
- 42 Deck Lift Rod Timing Adjustment
- 43 Deck Leveling Adjustment
- 44 Hydraulic Pump Drive Belt Replacement
- 45 Mower Belt Replacement
- 46 Battery Service
- 48 Specifications