Maintenance data (fuel, oil level, etc.). Toyota Highlander

6-1. Specifications

Maintenance data (fuel, oil level, etc.)

Dimensions and weights

Overall length

Overall width

Overall height

Wheelbase

Front tread

2WD models

Rear tread

4WD models

Vehicle capacity weight

(Occupant + luggage)

Towing capacity

(Trailer weight + cargo)

Without towing package

With towing package

*

: GVM condition

188.4 in. (4785 mm)

75.2 in. (1910 mm)

Without roof rails

68.1 in. (1730 mm)

With roof rails

69.3 in. (1760 mm)

109.8 in. (2790 mm)

64.0 in. (1625 mm)

64.2 in. (1630 mm)*

64.2 in. (1630 mm)

64.8 in. (1645 mm)*

64.0 in. (1625 mm)

64.6 in. (1640 mm)*

1200 lb. (544 kg)

2000 lb. (900 kg)

5000 lb. (2000 kg)

530

6-1. Specifications

Vehicle identification

■ Vehicle identification number

The vehicle identification number (VIN) is the legal identifier for your vehicle. This is the primary identification number for your Toyota. It is used in registering the ownership of your vehicle.

This number is stamped under the right-hand front seat.

This number is also stamped on the top left of the instrument panel.

■

Manufacture’s label

This number is also on the manufacturer’s label on the driver’s side center pillar.

6

531

6-1. Specifications

■

Engine number

The engine number is stamped on the engine block as shown.

Engine

Model

Type

Bore and stroke

Displacement

Drive belt tension

Fuel

Fuel type

Octane rating

Fuel tank capacity

(Reference)

2GR-FE

6-cylinder V type, 4-cycle, gasoline

3.70 × 3.27 in. (94.0 × 83.0 mm)

210.9 cu.in.

(3456 cm

3

)

Automatic adjustment

Unleaded gasoline only

87 (Research Octane Number 91) or higher

19.2 gal. (72.5 L, 15.9 lmp.gal.)

532

6-1. Specifications

Lubrication system

Oil capacity

Drain and refill (Reference)

Without filter

With filter

Oil grade

6.0 qt. (5.7 L, 5.0 Imp.qt.)

6.4 qt. (6.1 L, 5.4 Imp.qt.)

ILSAC multi-grade engine oil

Use Toyota approved “Toyota Genuine Motor

Oil” or equivalent to satisfy the grade and viscosity shown below.

Vehicles without towing package

Recommended oil viscosity

Outside temperature

Vehicles with towing package

6

Outside temperature

533

6-1. Specifications

Oil viscosity

●

The 5W portion of the oil viscosity rating indicates the characteristic of the oil which allows cold startability. Oils with a lower value before the W allow for easier starting of the engine in cold weather.

●

The 30 in 5W-30 indicates the oil viscosity when the oil is at its operating temperature. An oil with a higher viscosity may be better suited if the vehicle is operated at high speeds, or under extreme load condition.

Cooling system

Capacity (Reference)

Coolant type

Without rear air conditioning system

9.3 qt. (8.8 L, 7.7 Imp.qt.)

10.0 qt. (9.5 L, 8.4 Imp.qt.)*

With rear air conditioning system

11.6 qt. (11.0 L, 9.7 Imp.qt.)

12.4 qt. (11.7 L, 10.3 Imp.qt.)*

Use either of the following.

• “Toyota Super Long Life Coolant”

• Similar high-quality ethylene glycol-based non-silicate, non-amine, non-nitrite, and non-borate coolant with long-life hybrid organic acid technology

Do not use plain water alone.

*: With towing package

534

6-1. Specifications

Ignition system

Spark plug

Make

Gap

DENSO FK20HR11

0.043 in. (1.1 mm)

NOTICE

■ Iridium-tipped spark plugs

Use only iridium-tipped spark plugs. Do not adjust gap when tuning engine.

Electrical system

Battery

Open voltage* at

68 ° F (20 ° C):

Charging rates

12.6

⎯ 12.8 V Fully charged

12.2

⎯ 12.4 V Half charged

11.8 ⎯ 12.0 V Discharged

(*: Voltage is checked 20 minutes after the engine and all the lights are turned off)

5 A max.

Rear differential (4WD models)

Oil capacity

Oil type

Recommended oil viscosity

1.0 qt. (0.9 L, 0.8 Imp.qt.)

Hypoid gear oil API GL-5

Above 0 ° F (-18 ° C): SAE 90

Below 0 ° F (-18 ° C): SAE 80W or 80W-90

6

535

6-1. Specifications

Automatic transaxle

Fluid capacity (drain and refill) 3.7 qt. (3.5 L, 3.1 Imp.qt.)

Fluid type Toyota Genuine ATF WS

NOTICE

■ Automatic transmission fluid type

Using automatic transmission fluid other than “Toyota Genuine ATF WS” may cause deterioration in shift quality, locking up of your transmission accompanied by vibration, and ultimately damage the automatic transmission of your vehicle.

Transfer (4WD models)

Oil capacity

Oil type

Recommended oil viscosity

1.0 qt. (0.9 L, 0.8 Imp.qt.)

Hypoid gear oil API GL-5

Above 0 ° F (-18 ° C): SAE 90

Below 0 ° F (-18 ° C): SAE 80W or 80W-90

536

6-1. Specifications

Brakes

Pedal clearance*

Pedal free play

1

Brake pad wear limit

3.3 in. (84.4 mm) Min.

0.08 ⎯ 0.12 in. (2 ⎯ 3 mm)

0.04 in. (1.0 mm)

Parking brake lining wear limit

Parking brake pedal travel*

2

0.04 in. (1.0 mm)

8 ⎯ 10 clicks

Fluid type SAE J1703 or FMVSS No. 116 DOT 3

*

1

: Minimum pedal clearance when depressed with a force of 110 lbf (490 N,

50 kgf) while the engine is running

*

2

: Parking brake pedal travel when depressed with a force of 66 lbf (294 N, 30 kgf)

Steering

Free play Less than 1.2 in. (30 mm)

6

537

6-1. Specifications

Tires and wheels

Type A

Tire size

Tire inflation pressure

(Recommended cold tire inflation pressure)

Wheel size

Wheel nut torque

P245/65R17 105S

Driving under normal conditions

Front:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Rear:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Spare:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Driving at high speeds above 100 mph

(160 km/h) (in countries where such speeds are permitted by law)

Add 5 psi (30 kPa, 0.3 kgf/cm

2

or bar) to the front tires and rear tires. Never exceed the maximum cold tire inflation pressure indicated on the tire sidewall.

17

×

7 1/2 J

76 ft•lbf (103 N•m, 10.5 kgf•m)

538

6-1. Specifications

Type B

Tire size

Tire inflation pressure

(Recommended cold tire inflation pressure)

Wheel size

Wheel nut torque

P245/55R19 103S

Driving under normal conditions

Front:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Rear:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Spare:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Driving at high speeds above 100 mph

(160 km/h) (in countries where such speeds are permitted by law)

Add 5 psi (30 kPa, 0.3 kgf/cm

2

or bar) to the front tires and rear tires. Never exceed the maximum cold tire inflation pressure indicated on the tire sidewall.

When towing trailer

Add 6 psi (40 kPa, 0.4 kgf/cm2 or bar) to the rear tires. Never exceed the maximum cold tire inflation pressure indicated on the tire sidewall.

19

×

7 1/2 J

76 ft•lbf (103 N•m, 10.5 kgf•m)

6

539

6-1. Specifications

Type C

Tire size

Tire inflation pressure

(Recommended cold tire inflation pressure)

Wheel size

Wheel nut torque

P245/65R17 105S, T165/90D18 107M

(spare)

Driving under normal conditions

Front:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Rear:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Driving at high speeds above 100 mph

(160 km/h) (in countries where such speeds are permitted by law)

Add 5 psi (30 kPa, 0.3 kgf/cm

2

or bar) to the front tires and rear tires. Never exceed the maximum cold tire inflation pressure indicated on the tire sidewall.

Spare:

60 psi (420 kPa, 4.2 kgf/cm

2

or bar)

17

×

7 1/2 J, 18

×

4T (spare)

76 ft•lbf (103 N•m, 10.5 kgf•m)

540

6-1. Specifications

Type D

Tire size

Tire inflation pressure

(Recommended cold tire inflation pressure)

Wheel size

Wheel nut torque

P245/55R19 103S, T165/90D18 107M

(spare)

Driving under normal conditions

Front:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Rear:

30 psi (210 kPa, 2.1 kgf/cm

2

or bar)

Driving at high speeds above 100 mph

(160 km/h) (in countries where such speeds are permitted by law)

Add 5 psi (30 kPa, 0.3 kgf/cm

2

or bar) to the front tires and rear tires. Never exceed the maximum cold tire inflation pressure indicated on the tire sidewall.

When towing trailer

Add 6 psi (40 kPa, 0.4 kgf/cm2 or bar) to the rear tires. Never exceed the maximum cold tire inflation pressure indicated on the tire sidewall.

Spare:

60 psi (420 kPa, 4.2 kgf/cm

2

or bar)

19

×

7 1/2 J, 18

×

4T (spare)

76 ft•lbf (103 N•m, 10.5 kgf•m)

6

541

6-1. Specifications

Light bulbs

Exterior

Headlights

Light Bulbs

Front turn signal lights

Parking/front side marker lights

Front fog lights*

Rear turn signal lights

Back-up lights

Stop/tail and rear side marker lights

Bulb No.

⎯

⎯

⎯

⎯

⎯

⎯

⎯

W

60/55

21

5

55

21

16

21/5

Interior

License plate lights

Outer foot lights*

Vanity lights

Personal/interior lights (front)

Personal/interior lights (center)*

Interior light

Door courtesy lights

A: H11 halogen bulbs

C: HB2 halogen bulbs

*

: If equipped

⎯

⎯

⎯

⎯

⎯

⎯

⎯

5

5

8

5

5

8

5

B: Wedge base bulbs (amber)

D: Wedge base bulbs (clear)

Type

C

B

B

A

D

D

D

D

D

D

D

D

D

D

542