SAFETY. Bad Boy Instinct, Bad Boy Instinct, 2013 RECOIL iS, 2013 INSTINCT, RECOIL iS

SAFETY

Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.

LABELS AND PICTOGRAMS

1

Except where PERMITTED BY LAW:

AVOID FALLS from the vehicle:

Reduce the RISK OF ACCIDENTS:

This vehicle is NOT A TOY:

DO NOT OVERLOAD this vehicle:

DO NOT MODIFY this vehicle:

Failure to follow these instructions could result in DEATH or SERIOUS INJURY

NEVER drive on public roads. Drivers must possess a valid drivers license in accordance with local state law.

DO NOT start moving until all occupants are PROPERLY SEATED with SEAT BELT FASTENED and HOLDING ON. KEEP entire body INSIDE VEHICLE while moving.

Always DRIVE SLOWLY in congested areas, on wet or loose terrain, and when backing up. DRIVE SLOWLY when turning and AVOID sudden stops. ALWAYS drive straight up and down slopes.

DO NOT coast, use BRAKE when going down a slope. NEVER drive this vehicle under the influence of drugs or alcohol. Before leaving vehicle set parking brake, place direction selector to neutral (N).

Drive responsibly. NEVER leave children unattended or allow children to play on the vehicle. NEVER leave the key in the vehicle when parked.

NEVER carry more than 2 occupants on a bench seat. DO NOT exceed vehicle WEIGHT CAPACITY (see Owner’s Manual).

NEVER alter this vehicle to increase travel speeds above factory specifications. Alterations NOT approved or tested by Bad Boy Buggies can create unsafe conditions and increase your chance of having an accident.

630397

NO PASSENGERS

IN TRUCK BED

READ THE

MANUAL

WARNING

READ THE

MANUAL

SECURE LOAD

MAX BED WEIGHT

500 lbs or 255 kg

MAX TAILGATE

WEIGHT 100 lbs

OR 45kg

HIGH CENTER OF

GRAVITY MAY CAUSE

TIP OVER

74821G01

P

P

MAX

500 lbs.

255 kg

MAX

5 in.

12 cm

MAX

100 lbs.

45 kg

MAX

14 o / 25%

74821G01

MAX HEIGHT FOR

CENTER OF GRAVITY

5” OR 12 cm ABOVE FLOOR

MAX SIDE

SLOPE 14°

MAY CAUSE

EXPLOSION

DO NOT FILL

FUEL CONTAINERS

IN TRUCK BED

BATTERY CHECK & SERVICE DATE

74099G01

74099-G01

DO NOT RELEASE BED

LATCH WITH ANYONE

STANDING BEHIND BED

DO NOT sit or stand on this cover.

This is NOT a storage area.

630394

630394

HIGH VOLTAGE - SHOCK HAZARD

Replace cover after servicing, DO NOT operate without cover in place.

Insulated tools required when working in or around the battery compartment.

NEVER:

operate vehicle without battery compartment cover in place drill holes in this cover while it is installed on vehicle mount any items to this cover ground accessories to vehicle frame sit or stand on battery compartment cover

ALWAYS:

use insulated tools in and around the battery compartment replace battery compartment cover before driving vehicle disconnect batteries before working on vehicle

630393

630393

To prevent battery damage, be sure all battery caps are tightly installed.

Neutralize acid before rinsing batteries.

Do NOT use a pressure washer to clean batteries.

Do NOT overfill batteries. The charging cycle will expel electrolyte and result in component damage.

To prevent battery explosion that could result in severe personal injury or death, keep all smoking materials, open flames or sparks away form the batteries.

The electrolyte in a storage battery is an acid solution which can cause severe burns to the skin and eyes.

Treat all electrolyte spills to the body and eyes with extended flushing with clear water. Contact a physician immediately.

Any electrolyte spills should be neutralized with a solution of 1/4 cup sodium bicarbonate dissolved in

1-1/2 gallons of water and then flushed with clear water.

Always wear a safety shield or approved safety goggles when adding water or charging batteries.

BATTERY DISPOSAL

Lead-acid batteries are recyclable. Return batteries to distributor, manufacturer or lead smelter for recycling. For neutralized spills, place residue in acid-resistant containers with absorbent material, sand or earth and dispose of in accordance with local, state and federal regulations for acid and lead compounds.

Contact local and/or state environmental regarding disposal information.

1 quart

(1 liter)

Clear Water

2 Teaspoons

(10 ml)

Sodium

Bicarbonate

(Baking Soda)

MONTHLY BATTERY MAINTENANCE

Spray top and sides of batteries with a solution of baking soda and water. Allow the solution to set for at least three minutes; use a soft bristle brush or cloth to wipe the tops of the batteries in order to remove any residue that could cause

Plastic

Spray

Bottle the batteries to self-discharge. Rinse the entire area with low pressure clear water.

The correct level of electrolyte is 1/2” above the plates in each cell

AFTER charging. Be sure that the plates in each cell are covered before charging, remember to top off each cell if required after charging.

630395

Page 1 - 5