BHM Medical Voyager Portable Patient Lift, ErgoFit, Hammock, Hammock 6 Strap, Quick-Fit, Hygienic, Walking Sling Operating and Product Care Instructions

Voyager Portable
Operating and Product Care Instructions
001.08075.EN_rev8
February 2008
BHM
.
Medical Inc. designs and manufactures quality
engineered patient lifting equipment for the care of the
disabled in hospitals, nursing homes and home care.
Please take the time to read the entire manual, including the section on Safety Instructions and Warnings.
It contains important information that will allow you to take advantage of all the characteristics of your
BHM patient lift.
BHM Medical Inc. Credentials
•
FDA Registration # 9681684
•
CE mark (European Union Listing)
•
Global Operations for in-warranty and out-of-warranty service support for Voyager Portable lift.
•
Each finished Voyager Portable is individually tested in our laboratory.
•
Lifting Capacity 200 kg/440 lbs. Engineering safety factor exceeds European Standards.
•
Complete range of patient lift slings and supports designed and manufactured by BHM Medical Inc.
using medical quality materials and fabrics.
•
ISO 9001
•
Quick release US PATENT #6085368 / Patent Pending in other countries.
•
Voyager is a registered trademark of BHM Medical inc.
APPROVALS:
CSA 601.1
UL 2601.1
EN 60601.1
EN ISO 10535 (Lifting device) SGS
UK Test Report: DUR22107/AC/OO
Note:
BHM Medical is constantly improving its products. For this reason, it may be possible to
encounter a modification of product without revision of this guide.
Thank you for trusting your BHM Medical Partners.
How to contact us:
Head Office
BHM Medical Inc.
2001 Tanguay Street
Magog (Quebec) J1X 5Y5
Canada
Sales Headquarters
BHM Medical Inc.
6200A Tomken Road
Mississauga (Ontario) LT5 1X7
Canada
Phone: (819) 868-0441
Service calls during business hours
(8:00-12:00 and 1:00-5:00 p.m. E.S.T.)
Service calls outside regular business
hours - extension #3400
Fax:
(819) 868-2249
Web site: www.bhm-medical.com
E-mail: [email protected]
2
TABLE OF CONTENTS
INTRODUCTION........................................................................................................................................................ 4
HOW TO USE THIS MANUAL ........................................................................................................................................ 4
EQUIPMENT IDENTIFICATION ...................................................................................................................................... 4
RECEIPT OF EQUIPMENT.............................................................................................................................................. 4
KEY TO SYMBOLS ....................................................................................................................................................... 4
SAFETY INSTRUCTIONS AND WARNINGS........................................................................................................ 5
DESCRIPTION OF EQUIPMENT............................................................................................................................ 7
LIFT UNIT ................................................................................................................................................................... 7
WHAT'S INCLUDED ...................................................................................................................................................... 7
PARTS DESCRIPTION ................................................................................................................................................... 7
DIMENSION ................................................................................................................................................................. 7
BHM ERGOFIT SLING ............................................................................................................................................. 8
HAMMOCK SLING ....................................................................................................................................................... 8
Hammock Sling (THA-S, M & L) .......................................................................................................................... 8
Hammock 6 Strap Sling (THA6-S, M & L)............................................................................................................. 9
Sling Attachment Options..................................................................................................................................... 10
QUICK-FIT SLING ...................................................................................................................................................... 13
HYGIENIC SLING ....................................................................................................................................................... 15
WALKING SLING ....................................................................................................................................................... 16
OPERATION ............................................................................................................................................................. 18
HOW TO USE THE VOYAGER PORTABLE .................................................................................................................... 18
BATTERY INFORMATION.................................................................................................................................... 20
CHARGER SPECIFICATIONS #A8200.......................................................................................................................... 21
CHARGING THE BATTERY WITH CHARGER #A8200 .................................................................................................. 21
CHARGER SPECIFICATIONS #700.13500.................................................................................................................... 22
CHARGING THE BATTERY WITH CHARGER # 700.13500 ........................................................................................... 22
MAINTENANCE ....................................................................................................................................................... 23
DAILY CHECK LIST ................................................................................................................................................... 23
INSPECTION AND CLEANING ..................................................................................................................................... 23
STRAP INSPECTION ................................................................................................................................................... 24
HANDLING AND STORAGE......................................................................................................................................... 24
BATTERY REPLACEMENT .......................................................................................................................................... 24
CHARGER FUSE REPLACEMENT (CHARGER #A8200 ONLY) ...................................................................................... 25
SLING INSPECTION AND CARE................................................................................................................................... 25
ANNUAL INSPECTION ................................................................................................................................................ 26
MAINTENANCE INSPECTION CHECKLIST..................................................................................................... 27
TROUBLESHOOTING ............................................................................................................................................ 28
ACCESSORIES ......................................................................................................................................................... 30
LOG BOOK................................................................................................................................................................ 31
LIMITED WARRANTY ........................................................................................................................................... 34
Printed in Canada
BHM Medical Inc. Reserves the right to change or discontinue any specifications, design, features, model
or accessories shown without notice.
TM Trade-mark of BHM Medical Inc. All rights reserved. © BHM Medical Inc., 2008
3
INTRODUCTION
INTRODUCTION
Equipment Identification
How to use this Manual
The unit's identification number (specification,
model, serial number) appears on a silver
nameplate attached to the back of base.
DO NOT ATTEMPT TO USE THIS
EQUIPMENT WITHOUT UNDERSTANDING THIS MANUAL.
Receipt of Equipment
Upon receipt of the equipment, verify it against the
packing list to ensure it is complete and inspect
the equipment for possible damage due to
shipping. If there is any damage, DO NOT use
the equipment and notify the carrier immediately
to file a claim. Provide complete information
concerning damage claims or shipping errors to
your supplier. Include all equipment identification
numbers and group part numbers (if any) as
described above along with a full description of
damaged parts.
To ensure safe operation, read carefully the
entire manual, especially the section on
“Safety Instructions and Warnings”, before
installing, operating, or servicing this
equipment.
If anything is not completely understood,
please contact your supplier for more
details. Failure to comply with warnings in
this manual may result in injury.
Keep this manual with the lift and refer to it
as required. Contents of this manual are
subject to change without prior notice to
users.
Key to Symbols
THE FOLLOWING SYMBOLS ARE USED
ON LIFTER’S ATTACHMENT LABELS:
Throughout this manual, the following symbols
may appear. Pay particular attention to the
information provided under these headings. These
special annotations are easily recognized as
follows:
WARNING:
intended to
hazards or
which could
bodily harm.
This symbol is required to be displayed on
regulated products for sale in the European
Market. It indicates that the product
complies
with
applicable
European
Directives related to health, safety,
environment and consumer protection.
this
symbol
is
alert the user to
unsafe practices,
result in serious
SWL
Safe Working Load represents the
maximum load the lifter is rated for safe
operation.
The following symbols are used on sling labels
and related to washing instructions:
CAUTION: this symbol is intended
to alert the user of the presence of
important
operating
and
maintenance instructions, which
could prevent product damage or
possible personal injury.
60ºC
Maximum washing temperature
(140°F) permanent cycle.
60°C
Do not use bleach.
Do not dry clean.
NOTE: this symbol offers helpful
information concerning certain
operating procedures.
Tumble dry low temperature.
Do not iron.
Please refer to individual sling labels for complete
instructions regarding washing and drying.
Additional copies of this manual can be purchased
by contacting your supplier. Include the User
Manual product number and equipment
identification numbers.
4
SAFETY INSTRUCTIONS AND WARNINGS
SAFETY INSTRUCTIONS AND WARNINGS
IMPORTANT – BEFORE USING THE PATIENT LIFTER FOR THE FIRST TIME,
PLEASE PUT THE UNIT UNDER CHARGING AT LEAST 8 HOURS TO
COMPLETELY RECHARGE BATTERIES.
A. GENERAL
IMPORTANT – READ THESE INSTRUCTIONS CAREFULLY OR SERIOUS INJURY MAY RESULT.
KEEP THESE INSTRUCTIONS AND THE KEY PROVIDED WITH THE LIFT AT ALL TIMES.
READ OPERATION AND MAINTENANCE INSTRUCTIONS IN THIS MANUAL BEFORE
INSTALLING, OPERATING, OR SERVICING THIS EQUIPMENT.
BHM Medical ceiling lifts are installed by an authorized contractor or installer
Your lift is for transferring patients only. Do not use the lift for any other purpose.
Always carry out the daily checklist before using the lift.
BHM Medical ceiling lifts are specifically designed for BHM Medical ceiling rail systems, slings
and accessories. Slings and accessories designed by any other manufacturer are prohibited
and will void BHM Medical’s warranty. Use only BHM Medical slings and accessories to
maintain patient safety and product utility.
BHM Medical ceiling lifts are intended to be used for patients within the specified weight limit
indicated for the lift. Do not attempt to lift more than the weight limit indicated.
Before attempting to transfer, the patient must be assessed by a qualified professional.
BHM Medical ceiling lifts must be used by a caregiver with proper training to work with the
patient to be transferred.
ONLY trained and qualified caregivers should transfer a patient. DO NOT attempt to use the lift
if you have not been properly trained to do so.
ALWAYS be prepared before attempting to transfer a patient.
DO NOT use a sling that is not recommended for the lift.
NEVER use a damaged, torn or frayed sling.
Always place the sling around the patient according to the instructions enclosed.
FOLLOW lifting procedures outlined in this manual.
USE all controls and safety features only according to the rules specified in this manual.
Never attempt to force a control or button on the lift.
DO NOT store the charger in a shower, bath or other areas with high humidity.
DO NOT drop the patient lift or battery. Dropping the battery or lift may cause internal damage
that is not easily seen. If the lift is suspected to be damaged, take to an authorized technician
for servicing.
IMPORTANT: Keep all components of the lift clean and dry, and have electrical and mechanical
safety checkpoints done as instructed in the Maintenance section of this manual.
Replace any precautionary or instruction labels that cannot be easily read.
Avoid violent shock during transportation.
5
SAFETY INSTRUCTIONS AND WARNINGS
B. SHOCK PREVENTION
DO NOT touch or use a lift with bare conductors or a damaged power cord. Electrically live
equipment can electrocute a patient. If the lift or charger has any exposed or damaged wires
contact your local dealer immediately.
DO NOT cut or remove the round grounding prong from any plug. All BHM lifts are equipped
with three-prong plugs to protect from shock hazard or electrocution. Any two-prong electrical
outlet must be replaced with a properly grounded three-prong outlet according to the National
Electrical Code and local codes. It is the responsibility of the customer to have the work done
by a qualified electrician.
Do not splash or expose electric parts of the device to water or moisture.
Check nameplate for voltage and cycle requirements. These requirements differ by country.
Do not attempt to use the lift in an area that has a different voltage and cycle requirement.
DO NOT attempt to expose, service or repair the lift, battery or charger.
malfunctioning, contact your local dealer.
READ the battery and charger instructions thoroughly before using or storing them.
If any unit is
C. FIRE AND EXPLOSION PREVENTION
Batteries may explode, leak and cause personal injury if not disposed of properly
•
Do not place or store the battery under direct sunlight or near a heat source
•
Do not dispose of in fire
•
Do not short the battery terminals
•
Do not incinerate
•
Flush with water if electrolyte (Acid) comes in contact with skin or eyes.
Batteries must be recycled, disposed of according to local law regulations. When returning
batteries, insulate their terminals with adhesive tape, etc. Otherwise, the residual electricity in
used batteries may cause fire or explosion.
D. EQUIPMENT WARNING LABELS
Inspect all precautionary labels on the equipment. Order and replace all labels that cannot be
easily read.
6
DESCRIPTION OF EQUIPMENT
DESCRIPTION OF EQUIPMENT
Parts Description
Lift Unit
Hook
The lift unit is an aluminium frame based system
driven by a gear reduced high torque motor.
OPERATING FEATURES
• Ultra-light; 5.45 kg (12 pounds.) battery
included.
• Electronic soft-start and soft-stop motor
control.
• Easily accessible controls on both sides of
the unit.
• Manual emergency lowering device (in case
of electrical failure).
• Emergency brake (in case of mechanical
failure). Operates on the same principle as a
car safety belt mechanism.
• Quick-Release feature allows very fast
winding and unwinding of the strap before
and after transfer operation.
• Anti-crush feature stops the lift when there is
no tension on the strap, avoiding any injury
to the patient. This feature also prevents the
strap from getting twisted inside the
machine.
• Current limiter for circuit protection in case of
overload.
• Low battery disconnect system to protect
batteries from been drained.
• Lifting speed: 4 cm/sec. (1.6 in./sec.).
• Strap length up to 2.2 m (88 inches). Tested
for 1363.6 kg (3000 lbs.)
• CSA No. 601.1, UL No. 2601-1 and CE
certifications.
• Respects EMI standards.
Strap
4 mm Allen
key
Carry handle
Battery eject
button
Control
buttons
Carry Bar
Optional
hand control
Battery
Battery
Charge indicator
Fuse
magazine
Charger
What's included
ITEM
Power cord
QTY
Voyager lift
1
Battery
1
Charger
1
Power cord
1
4 mm Allen key
1
User Manual
1
Dimension
7
SLINGS
BHM ERGOFIT SLING
USE A SLING RECOMMENDED BY
THE PATIENT’S PHYSICIAN, NURSE
OR MEDICAL SPECIALIST AS APPROPRIATE FOR THE PATIENT’S
ABILITY AND NEEDS.
Every patient has different needs. It is very
important to choose the right sling based on the
needs of the patient to be transferred as well as
their physical ability and size.
All BHM slings are made from a Polyester/ Nylon
material, which is soft and pliable, easy to care
for, and install. All slings are machine wash and
dry in medium temperature. BHM slings are
covered by a one-year warranty.
DO NOT use any kind of plastic backed
incontinence pad or seating cushion
between the patient and sling material.
That may cause the patient to slide out of
the sling during a transfer.
DO NOT exceed the maximum weight
limitation of the sling.
PLEASE READ THE FOLLOWING
CAREFULLY, BEFORE USING A
BHM MEDICAL ERGOFIT SLING.
ALWAYS CARRY OUT THE DAILY
CHECKLIST BEFORE EACH LIFT USE.
BHM MEDICAL CEILING LIFTS ARE
SPECIFICALLY DESIGNED FOR BHM
MEDICAL SLINGS AND ACCESSORIES. SLINGS AND ACCESSORIES
DESIGNED
BY
ANY
OTHER
MANUFACTURER ARE PROHIBITED
AND WILL VOID BHM MEDICAL’S
WARRANTY.
USE ONLY BHM
MEDICAL
SLINGS
AND
ACCESSORIES
TO
MAINTAIN
PATIENT SAFETY AND PRODUCT
UTILITY.
Laundry Instructions for all slings:
The following symbols are used on sling labels
and related to washing instructions:
60ºC
Maximum washing temperature 60°C
(140°F) permanent cycle.
Do not use bleach.
Do not dry clean.
PATIENT TO BE TRANSFERRED
MUST
BE
ASSESSED
BY
A
QUALIFIED PROFESSIONAL BEFORE
ATTEMPTING TO TRANSFER.
Tumble dry low temperature.
Do not iron.
Observe a trained expert to perform the
transfer procedures and then practice
them several times with a capable
individual acting as patient before
attempting a transfer with a patient with
limited capabilities.
User instructions for:
Hammock Sling
Inspect each sling for wear, tears or
loose stitching after each wash.
READ
CAREFULLY
ALL
INSTRUCTIONS BELOW BEFORE
ATTEMPTING TO INSTALL A SLING.
Hammock Sling (THA-S, M & L)
Our most universal sling, the Hammock sling, is
a mesh type material that dries quickly but is soft
and pliable. The sling has an incorporated head
support and a unique strap system that keeps
the patient secure in the sling.
A special
polyester fabric in the seat area helps to reduce
friction and makes the sling easy to place around
a patient in a chair without lifting or remove the
patient. The patient may be transferred in a
seated, semi-reclined or fully reclined position.
Best choice for most situations – including
bathing. Fits all BHM ceiling lift models as well
IF YOU HAVE ANY DOUBTS, PLEASE
CONTACT
YOUR
REPRESENTATIVE.
WHENEVER
POSSIBLE,
HAVE
SOMEONE ASSIST YOU TO ENSURE
THE PATIENT’S SAFETY AT ALL
TIMES.
LOCAL
Before transferring a patient from a
stationary object (wheelchair, bath or
bed), slightly raise the patient off the
stationary object and check that all sling
attachments are secure. If any attachment
is not correct, lower the patient and
correct the problem, then raise the patient
and check again.
8
SLINGS
as the Ergolift Mobile Lift. Available in sizes S, M
& L. Weight capacity is 250 kg (550 lbs.)
Hammock 6 Strap Sling (THA6-S, M & L)
Almost identical to the Hammock sling above,
this sling provides extra security and a tighter fit
for patients who are low-tone or who would
prefer a more secure feeling. The head support
is tighter and the extra straps on the side provide
more lateral support. The patient may be
transferred in a seated, semi-reclined or fully
reclined position. Fits all BHM ceiling lift models
as well as the Ergolift mobile lift. Available in
sizes S, M & L. Weight capacity is 250 kg (550
lbs.).
(U-shape and white fabric)
2. Lean the patient forward in the chair and
make sure that the patient is supported.
Whenever
possible
have
someone assist you to ensure
the patient's safety at all times.
3. With the white fabric of the sling facing the
patient, grab the sling at the top of the Ushape and slide the sling down to the base
of the spine or coccyx.
SLING SIZES AND PRODUCT NUMBERS:
Approximate
weight:
Approximate
height:
Color Code
Hammock
Product #
Hammock 6
Product #
SMALL
20-46 kg
(45-100
lbs.)
120-150
cm
(4’4’11”’)
Red
THA-S
MEDIUM
46-95
kg
(100-210
lbs.)
151-180 cm
(5’-5’11”)
LARGE
95-250 kg
(210-550
lbs.)
181 cm +
(6’ +)
Yellow
THA-M
Green
THA-L
THA6-S
THA6-M
THA6-L
4. Tuck the sling down on each side to make
sure that it is just slightly under the patient’s
buttock. Check for the stitching of the sling
handle at the center to make sure that it is in
line with the patient’s spine and bring the
patient to the back of the chair or wheelchair.
Sling Placement - from Chair or
Wheelchair
1. Sling has two sides, the white fabric
indicates the side that is intended to be next
to the patient and the label and colored
handles are on the outside. The top of the
sling is slightly rounded and the bottom of
the sling has a U-shaped design.
9
SLINGS
Sling Attachment Options
Option 1 - Bridge
(Most recommended)
a) Take the two straps between the legs –
these are the short loops – and thread one
loop through the other to cross them.
5. Kneel in front of the patient so that your back
is straight and so you are at eye level with
the patient. Grab the end of the sling with
the white fabric and make sure there are no
twists in the sling. Make sure the white
fabric is facing the patient’s leg. Place one
hand on the patient’s knee to hold it in place
and gently pull the sling forward with the
other hand until the edge of the sling is
approximately even with the patient’s knee.
b) Now take the long strap on the outside of
each leg and string it through the inside
strap. By crossing the straps as you see
here, form a bridge above the patient’s legs
and protect them from any pinching or
pressure, as well as keep the knees and
hips in line.
6. Place the patient’s foot on your thigh and
slide the white section of the sling under the
leg.
8. Repeat steps 5 & 6 for the other leg.
c) Finally, place the patient’s hands inside the
sling.
10
SLINGS
OPTION 2 – Leg Separation
Using this method of sling
placement will pull the patient’s
legs apart.
Check with the
patient’s physician, nurse or
medical
specialist
before
attempting this method.
a) Thread the long strap through the short strap
on each leg.
OPTION 3 – Amputee
Do not use this method of
sling placement for a patient
who is agitated or spastic.
b) Each short strap should be looped through
the long strap on the same leg.
a) Slide the sling end with the white fabric so
that it is all the way under both legs. One
sling strap will be on top of the other.
c) Place the hands inside the sling. See sling
placement for leg separation as installed
below.
b) Thread the long strap through the short strap
that is next to it. The photo below shows
clearly an example without a patient in it.
11
SLINGS
c) When installed, there should not be any sling
material between the patient’s legs. Place
the hands inside the sling.
Sling Placement- from lying position
1. Fold the sling in half lengthwise with the
white part of the sling on the inside of the
fold and place next to the patient to be
transferred.
3. Lower the patient down on top of the sling.
Roll the patient the opposite direction to pull
the sling out the other side.
When transferring a patient from
a bed, have people on each side
of it, or raise the bed rails to
ensure the patient does not roll
off the bed.
4. Place the straps in the same way as shown
from a seated position for the Hammock
sling.
2. With someone there to assist you, carefully
roll the patient onto one side. Now place the
fold of the sling at the center of the bed or
where the spine of the patient will be. The
top of the U-shape in the sling should be at
the base of the spine or coccyx .The top of
the sling should be next to the head. Lift the
top fold and tuck next to the patient.
12
SLINGS
User Instructions for:
Quick-Fit Sling
Specially designed for patients who are stocky or
obese, especially in the midsection. Padding
around the buttock and leg area helps to provide
extra support. Upper portion of the sling is a
mesh type material that dries quickly but is soft
and pliable. This sling does not provide head
support. The patient may be lifted in a seated,
semi-reclined or fully reclined position. Fits all
BHM ceiling lift models as well as the Ergolift
mobile lift. Available in sizes S, M & L. Weight
capacity is 250 kg (550 lbs.)
Sling attachment to Carry Bar
1. Ensure the sling is properly placed around
the patient according to the instructions
above.
Do not use the Quick-Fit sling
on a patient who cannot support
his or her own head.
2. Choose the color of the loop you will need
for the position you will be placing the patient
in. If transferring to a seated position, use
the loops indicating it.
SLING SIZES AND PRODUCT NUMBERS:
Approximate
weight:
Approximate
height:
Always use the same color loop
on the rear shoulder straps for
both sides of the sling.
Color Code
Quick-fit
SMALL
20-46 kg
(45-100
lbs.)
120-150
cm
(4’4’11”’)
Red
TIR-S
MEDIUM
46-95 kg
(100-210
lbs.)
151-180
cm
(5’5’11”)
Yellow
TIR-M
LARGE
95-250 kg
(210-550
lbs.)
181 cm +
(6’ +)
Green
TIR-L
Sling Placement - from Chair or
Wheelchair
Use the same color loop on the
leg straps for both sides of the
sling.
Whenever
possible
have
someone assist you to ensure
the patient's safety at all times.
Use the same color loop on the
hip straps for both sides of the
Hammock 6-strap sling.
3. Ensure the patient’s arms are inside the
sling and that it is not caught on any
obstructions (e.g. wheelchair brake or
handle).
1. Sling has two sides, the white fabric
indicates the side that is intended to be next
to the patient, and the label and colored
handles are on the outside. The top of the
sling is straight and the bottom of the sling
has a U-shaped design.
4. See Lift Instructions for next step.
13
SLINGS
2. Lean patient forward in the chair and make
sure the patient is supported.
7. By crossing the straps as you see here, we
keep the knees and hips in line.
3. With the white fabric of the sling facing the
patient, grab the sling at the top of the Ushape and slide it down to the base of the
spine or coccyx. Tuck the sling down on
each side to make sure that it is just slightly
under the patient’s buttock. Check the seam
for the sling handle at the center to make
sure that it is in line with the patient’s spine
and bring the patient to the back of the chair.
4. Kneel in front of the patient so that your back
is straight and so you are at eye level with
the patient. Grab the end of the sling with the
white fabric and make sure there are no
twists in the sling. The white fabric should be
facing the patient’s leg. Place one hand on
the patient’s knee to hold it in place and
gently pull the sling forward with the other
hand until the edge of the sling is
approximately even with the patient’s knee.
8. Place the patient’s hands inside the sling
before attaching it to the lift.
Sling attachment to Carry Bar
1. Ensure the sling is properly placed around
the patient according to the instructions
above.
2. Choose the color of the loop you will need
for the position you will be placing the patient
in. If transferring to a seated position, use
the loops indicated for a seated position.
5. Place the patient’s foot on your thigh and
slide the white section of the sling under the
leg.
6. Take the two straps between the legs.
There is a small loop on each strap right
next to the sling. Thread one strap through
the other to cross them.
Always use the same color loop
on the rear shoulder straps for
both sides of the sling.
Use the same color loop on the
14
SLINGS
the sling has two long straps and the inside
of the sling has a padded section with a belt.
hip straps for both sides of the
sling.
3. Ensure the patient’s arms are inside the
sling and that it is not caught on any
obstructions (e.g. wheelchair brake or
handle)
4. See Lift Instructions for next step.
User Instructions for:
Hygienic Sling
This sling is excellent for changing incontinence
pads or to transfer onto a toilet as it provides an
open area from the middle of the back to the
middle of the thigh. The padding wraps around
the patient’s midsection and under each leg. In
order to use this sling, the patient must have
good muscle-tone in their shoulders and upper
body. Fits all BHM ceiling lift models as well as
the Ergolift mobile lift and Ergostand standassist. Available in sizes S, M & L. Weight
capacity is 250 kg (550 lbs.)
Whenever
possible
have
someone assist you to ensure the
patient's safety at all times.
2. Lean patient forward in the chair and make
sure the patient is supported.
3. With the white fabric of the sling facing the
patient, place it approximately halfway down
the back, or so the sling is below the
shoulder blades. Lean the patient against
the back of the chair.
Do not use Hygienic sling on a
patient who does not have good
muscle-tone in their shoulders
and neck.
Check
with
the
patient’s
physician, nurse or medical
specialist before using this sling.
SLING SIZES AND PRODUCT NUMBERS
SMALL
CHEST SIZE 68-89 cm
(27-35”)
PRODUCT # THY-S
COLOR
Red
CODE
MEDIUM
89-107 cm
(35-42”)
THY-M
Yellow
LARGE
107-125 cm
(42-49”)
THY-L
Green
4. Fold the padded fabric waistband with the
belt attached across the mid-section of the
patient and clip the belt closed. Make sure
the belt is secure.
1. Sling has two sides, the white fabric
indicates the side that is intended to be next
to the patient, and the label and colored
handles are on the outside. The bottom of
15
SLINGS
5. Tighten the belt until snug by pulling gently
on the end of the belt.
Always use the same color loop
on the shoulder straps for both
sides of the sling.
6. Kneel in front of the patient so that your back
is straight and so you are at eye level with
the patient. Grab the end of the sling with
the white fabric and make sure there are no
twists in the sling. Make sure the white
fabric is facing the patient's leg. Place the
patient's foot on your thigh and slide the
white section of the sling under the leg.
Use the same color loop on the
leg straps for both sides of the
sling.
3. Ensure the patient’s arms are over top of the
sling and that it is not caught on any
obstructions (e.g. wheelchair brake or
handle).
4. See Lift Instructions for next step.
User Instructions for:
Walking Sling
Designed to assist people with limited ability to
walk, this sling helps support and assist in
rehabilitation.
Fully padded with a security
buckle, the sling is comfortable and simple to
use. The user must have some weight bearing
ability. Fits all BHM ceiling lift models as well as
the Ergolift mobile lift. Available in sizes S, M &
L. Weight capacity is 250 kg (550 lbs.)
7. The hygienic straps need not cross to allow
better access to the toileting area. With the
hygienic sling, the arms of the patient are
always over top of the sling.
Do not use the Walking sling on a
patient who does not have weight
bearing ability and good muscletone in their shoulders and neck.
Sling attachment to Carry Bar
Check
with
the
patient's
physician, nurse or medical
specialist before using this sling.
1. Ensure the sling is properly placed around
the patient according to the instructions
above.
2. Choose the color of the loop for the position
that is best suited for the patient. For a
larger patient, choose blue for both the leg
and shoulder straps. A smaller patient may
be better suited for the black loops on both
the shoulder and leg straps.
16
SLINGS
SLING SIZES AND PRODUCT NUMBERS
SMALL
CHEST SIZE 68-89 cm
(27-35”)
PRODUCT # TEM-S
COLOR
Red
CODE
MEDIUM
89-107 cm
(35-42”)
TEM-M
Yellow
LARGE
107-125 cm
(42-49”)
TEM-L
Green
1. Sling has two sides, the white fabric
indicates the side that is intended to be next
to the patient, the label and colored handles
are on the outside. The bottom of the sling
has two long straps and the inside of the
sling has a padded waist section with a belt.
5. Tighten the belt until snug by pulling gently
on the end of it.
Whenever
possible,
have
someone assist you to ensure
the patient's safety at all times.
6. Kneel in front of the patient so that your back
is straight and so you are at eye level with
the patient. Grab the end of the sling with the
white fabric and make sure there are no
twists in the sling. The white fabric should
be facing the patient’s leg.
Place the
patient’s foot on your thigh and slide the
white section of the sling under the leg.
2. Lean patient forward in the chair and make
sure the patient is supported.
3. With the white fabric of the sling facing the
patient, place the sling approximately
halfway down the back, or so it is below the
shoulder blades. Lean the patient against
the back of the chair.
7. The straps that come from between the legs
do not attach to the lift. Thread the strap at
the chest through the longest loop on the
same side.
4. Fold the padded fabric waistband with the
belt attached across the mid-section of the
patient and clip the belt closed. Make sure
the belt is secure.
17
SLINGS
Always use the same color loop
on the rear shoulder straps for
both sides of the sling.
Use the same color loop on the
chest straps for both sides of
the sling.
3. Ensure the patient’s arms are over top of the
sling and that it is not caught on any
obstructions (e.g. wheelchair brake or
handle).
4. See Lift Instructions for next step.
8. Repeat step 7 with the other side.
5. When raising the patient in the lift, check to
make sure the sling sections between the
legs are providing snug support. If there is
not enough support, reinstall the sling
threading the chest straps through a lower
loop (grey or black).
Repeat this step until the lower portion of the
sling provides proper support.
OPERATION
How to use the Voyager
Portable
READ "SAFETY INSTRUCTIONS
AND
WARNINGS"
BEFORE
ATTEMPTING TO USE THE
VOYAGER LIFT.
9. Note that with the walking sling, the arms of
the patient are always over top of the sling.
Always carry out the daily checklist before
each lift use.
Sling attachment to Carry Bar
Damage to the lift may occur if
not properly handled. Carry the
VOYAGER PORTABLE by its
handle only. Do not carry the lift
with the reacher accessory or
other accessory not intended to
be used to carry the lift.
1. Ensure the sling is properly placed around
the patient according to the instructions
above.
2. Adjusting the sling loops higher or lower in
either the front or the back allows you to tilt
the body either direction to correct posture.
1. Install the patient sling (see sling installation)
2. Take the battery out of the charger and
insert it into the lift. Make sure the silver
contact points go inside the lift.
3. Once the patient sling is installed, unwind
the strap.
18
OPERATION
There are two ways to unwind the strap:
BEFORE LIFTING THE PATIENT:
1. Make sure that all straps are
attached to the carry bar.
First, you can press the
button
while
holding tension on the strap with the other
hand (there must be tension on the strap for
the lift to function).
The other way to do this is
to
use
the
"QUICKRELEASE"; Push the knob
(1) and pull the strap out of
the lift (2).
2. Make sure the patient's arms
are safely out of the way.
3. Make sure the sling is not
caught on an obstruction
(wheelchair brake or arm of
chair).
If any of the above occur – lower the
patient immediately and correct the
problem.
9. Lift until the patient's buttock
clears the arm supports or the
top of the bath or bed before
moving the patient. Guide the
legs past any obstacle.
10. When the patient is located
above the desired point of
transfer and ready to be
lowered, press the
button.
Push knob completely over to
ensure the QUICK-RELEASE will
work properly.
QUICK-RELEASE will not work if
there is tension on the strap.
Make sure the strap has some
slack in it before attempting to
slide the knob over.
11. Use the handles on the back of the sling to
position the patient when transferring into a
chair. Hold the handles firmly as the sling
lowers and the sling will tilt back to position
the patient.
DO NOT force the knob. It should slide
easily.
4. Attach the round hook to the trolley in the
track.
12. Once the patient is properly seated and the
straps are loose, remove the sling from the
lift.
Hold the lift with one hand at all
times when near a patient.
13. Slide the lift away from the patient.
5. Move the lift over to the patient.
14. Unhook the lift from the
trolley in the rail and use
the "QUICK RELEASE" to
shorten the strap. To do
so, push the knob (1) and
hold the strap while it
winds itself into the lift.
Hold the lift with one hand at all
times when near a patient.
6. Lower the lift below the chin before
beginning to attach the sling straps (this is
to avoid the risk of facial contact caused by
movement of the lift).
For a patient in a lying position, lower the lift
near the thorax, and then install the straps.
Push knob completely over to
ensure the "QUICK-RELEASE"
will work properly.
7. Attach the straps of the sling as described
in the sling attachment instructions for the
sling to be used. (See sling installation)
"QUICK-RELEASE" will not work
if there is tension on the strap.
Make sure the strap has some
slack in it before attempting to
slide the knob over.
8. Lift the patient slightly by pressing the
control button
.
19
OPERATION
DO NOT force the knob. It should slide
easily.
When
using
the
"QUICKRELEASE" hold the strap in your
hand and release the knob (1)
only when the strap is not going
in motion. This will prevent wear
of the internal components.
15. Sling may be removed from around the
patient.
To lower the patient more quickly, use a
power drill with a 4 mm Allen key bit.
Emergency Lowering Feature
The Voyager Portable has an emergency
manual-lowering feature in the event of an
electrical or functional failure.
If the lift malfunctions when a patient is being
transferred, the emergency manual lowering
device provides a safe way of lowering the
patient onto a chair or bed.
To operate the emergency lowering feature:
1. Find the rubber stopper and label on the side
of the lift.
5. Once the patient is lowered safely into a
chair or bed, take the lift to a certified
technician to be serviced.
Battery Information
DO NOT DROP BATTERY. A
DROPPED BATTERY MAY HAVE
INTERNAL DAMAGE THAT IS
NOT VISIBLE. IT MAY LOSE ITS
ABILITY TO RECHARGE.
Due to internal damage caused when the
battery is dropped, the battery may
indicate that it is fully charged, when in
fact the battery cannot hold a full charge.
A green light indicated on the charger
may not accurately reflect a full charge on
a damaged battery.
2. Pull the rubber stopper out of the Voyager
Portable casing – DO NOT DISCARD.
3. Move the patient over a bed or chair.
4. Using the Allen key provided with this
manual, turn the key clockwise to lower the
patient into the chair. As the key turns the
motor directly, each key turn will move the
patient slightly.
NEVER attempt to use a battery that
appears to be damaged or dented.
DO NOT store battery near a heat source.
Heat will damage the battery.
Always keep metal battery contacts clean.
20
•
24 Vdc, 2.0 Ah interchangeable
rechargeable battery.
and
•
Provides 10 to 30 transfers per battery
charge (may vary depending on patient
weight and battery condition. See graph
below).
OPERATION
Life cycle (number of charging cycles) of the
battery is largely dependent on the depth of
discharge in each cycle. The more the battery is
drained, the shorter its life span. The life of the
battery is also related to such factors as varying
temperatures and rest periods between charge
and discharge.
number of lifts that can be done with one
recharged battery.
Do not drain the battery
excessively.
This
will
dramatically reduce the battery
life span.
If the low battery buzzer sounds, be sure
to recharge the battery as soon as
possible.
Graph 1: Number of recharge vs. Depth of
discharge
Charger Specifications #A8200
120
100
100 %
Capacity %
80
60
50%
40
30%
20
0
0
0
20
0
40
0
60
80
0
•
Hospital grade charger cord and plug.
•
Charger input: 120 Vac, 60 Hz, 0.5 A. (North
America)/ 240 Vac, 50 Hz, 0.25 A European.
Charging the Battery with Charger
#A8200
00 00
10 12
DO
NOT
OPERATE
THE
CHARGER
UNIT
WITH
A
DAMAGED CORD OR IF THE
UNIT HAS BEEN DROPPED OR
DAMAGED.
Charge/discharge cycles
GRAPH #1 illustrates the relationship between
discharging depth and expected battery life.
If you use only 30% of the battery power
between each charge, you can expect the
battery to fully charge 1050 times.
DO NOT forcibly bend the power cord or
place a heavy object on it. This will
damage the cord and may cause fire or
electrical shock.
If you drain the battery until it beeps every time,
you can expect the battery to fully charge only
300 times.
DO NOT pour liquid on or near the
charger.
To prolong battery life - Put the
battery
into
the
charger
WHENEVER THE LIFT IS NOT IN
USE.
DO NOT place the
locations that are:
BHM uses sealed lead-acid batteries.
Contrary
to
nickel-cadmium,
BHM
batteries do not have any memory effect.
Therefore, batteries should not be
completely drained before recharge.
Graph 2: Number of lifts vs. Lift load
The recharging steps should be as follows:
(See step by step instructions)
30
20
10
0
200
300
in
• Extremely hot
• Dusty or dirty
• Very humid
• Moving or vibrating
Do not attempt to put a damaged battery
into a charger. Inspect the battery first for
dents or damage.
The battery will not overcharge.
100
unit
440
weight (lbs.)
The graph above (GRAPH #2) illustrates the
relationship between the load lifted and the
21
OPERATION
on the charger will turn off, or will not go on.
This is only the case when the battery is
99.9% charged.
•
To test the charger, use the battery in the lift
a few times then put the battery in the
charger. If the light sill does not go on, see
the "Troubleshooting" section.
Charger Specifications #700.13500
•
Eject the battery from the lift unit by using
the "Battery Eject Button" (1). Keep your
hand near the opening to catch the battery
(2).
Keep one hand near the opening
for the battery (2) before pushing
eject button. Do not allow the
battery to eject and fall.
•
Insert the battery into the charger (3) with
the silver contact points of the battery going
into the charger.
•
The charging indicator light will illuminate red
to white to green depending on the battery
drain. If the light does not go on, check the
"Troubleshooting" section in this manual for
assistance.
•
If the battery is low, the light will show red or
orange when you place the battery in the
charger. The light will gradually turn to a
white or yellow color, then to green when
fully charged.
•
Class 2 power cord rated at 2.5 A (100-240
Vac 50-60 Hz).
•
Charger input: 100-240 Vac, 50-60 Hz, 50VA
•
Charger output 27 Vdc 1A.
•
Input fuse – 1A 250 V located inside the
charger.
Green light showing
power to the charger
Solid
yellow
light
showing battery 85%
charge
Yellow light blinking
showing battery under
charge
Whenever possible, leave the
battery in the charger when the lift is
not in use.
At minimum, charge the battery until
the light is green before using again.
This will extend the life of the
battery.
•
Charging the Battery with Charger #
700.13500
When the lift is needed again, pull the
battery out of the charger, and gently slide it
back into the Voyager Portable lift. The silver
contacts should be inside the lift.
•
The power cord can remain plugged into the
wall indefinitely, convenient for overnight
recharging.
•
If the battery has been in the charger for an
extended period of time or if the battery has
not been drained: it is possible that the light
(Available Oct. 2001)
Check to make sure the green light on the
charger is illuminated. This indicates that the
charger is on.
22
MAINTENANCE
•
Insert the battery into the charger with the
silver contact points of the battery going into
the charger.
Preventive maintenance specified in this
manual can prevent accidents and reduce
repair costs.
•
The charging indicator light will flash yellow
while the battery is charging. If the battery is
approximately within 85% of being fully
charged, the charging indicator light will
illuminate solid yellow.
Note all service or repairs to the VOYAGER
or its accessories in the log book at the end
of this manual. Have the document signed
by a certified technician
•
If the battery is low, it will take approximately
2 hours for a full charge.
Daily Check List
THE FOLLOWING PROCEDURE MUST BE
FOLLOWED BEFORE EACH USE.
Whenever possible, leave the
battery in the charger when the
lift is not in use.
At minimum, charge the battery
until the light is solid yellow (not
flashing) before using again.
This will extend the life of the
battery.
•
•
When the lift is needed again, pull the
battery out of the charger and, gently slide it
back into the Voyager portable lift. The
silver contacts should be inside the lift.
•
Has the battery been charged? Charge the
battery whenever the lift is not in use.
•
Inspect the battery before placing it in the
Voyager portable. If the battery appears to
have any damage – DO NOT USE IT.
Replace the battery immediately (Product #
A8500)
•
Inspect the lift for any damage. If the lift
casing does not look properly aligned, or
there are any cracks or other damage on the
lift, or any parts are missing - DO NOT USE
IT. Contact your local representative to have
the lift serviced.
•
Attach the lift to the trolley in the rail. Inspect
the visible strap for any signs of wear, frays,
loose threads or other damage. If there is
any evidence of damage- DO NOT USE IT.
Contact your local representative to have the
lift serviced.
•
Inspect the sling for tears, frayed straps or
loose stitching. If the sling has any of the
above damage –DO NOT USE IT. Contact
your local representative to have the sling
replaced or repaired.
•
Inspect the reacher and adjustable extension
strap (if you have these options) for wear.
Check the adjustable extension strap for
frays or loose stitching. Check the reacher
for damage in the metal hook or handle. DO
NOT USE if there is any damage.
•
Inspect the hook at the top of the strap to
ensure it is properly attached and there is no
damage to the hook.
The power cord can remain plugged into the
wall indefinitely, convenient for overnight
recharging.
•
The battery can be left in the charger for an
extended period of time without damaging
either the charger or battery.
•
If the green light does not go on when the
charger is plugged into an electrical outlet,
see “Troubleshooting”
MAINTENANCE
ALWAYS CARRY OUT THE DAILY
CHECKLIST BEFORE EACH LIFT
USE.
DO NOT attempt to open the VOYAGER
PORTABLE. Only a certified technician is
authorized
to
open
the
VOYAGER
PORTABLE.
Alterations
made
to
the
VOYAGER
PORTABLE by someone other than a
certified technician may cause serious injury.
VOYAGER PORTABLE and accessories must
be inspected ANNUALLY by a certified
technician in addition to the daily and other
periodic visual checks done by the user
specified in this section.
Inspection and Cleaning
Clean the voyager body with a dry soft cloth, or a
soft cloth lightly moistened with a mild detergent
23
MAINTENANCE
solution. Do not use any type of solvent that may
damage the finish.
and patient safety is greatly
compromised.
In any case, manufacturer
recommends to change strap at
least every two years.
By
continuing to use the lift without
changing the strap, caregiver
and patient safety is greatly
compromised.
DO NOT immerse lift in water.
To ensure a better rolling surface for the trolley
wheels, clean the inside of the track every 4
months. To do so, insert a damp cloth in the
opening and slide it from one end of the track to
the other.
Take
note
of
results
of
inspection in the log book at the
end of this manual.
Always replace rail end stopper
(if they have been removed) after
servicing.
Handling and Storage
Avoid violent shock during transportation.
Strap Inspection
The lift should not remain stored for long periods
of time without recharging the batteries.
This equipment is built with a strap that can
withstand a load of 1364 kg (3000 lbs.)
Nonetheless, if this strap is damaged or shows
signs of wear, the acceptable load on the strap
before rupture can drop rapidly and present a
danger for the patient or caregiver.
BHM
Medical
recommends
charging of batteries at least
every two weeks even if the lift is
not used.
This will prevent
premature aging of batteries.
BHM
Medical
recommends
thoroughly
inspecting the strap every 2 months as follows:
1.
2.
Battery Replacement
Completely unwind the strap.
Look for any signs of wear.
BHM uses sealed lead-acid batteries. Contrary
to nickel-cadmium, BHM batteries do not have
any memory effect. Therefore, batteries should
not be completely drained before recharge.
Loose threads in stitched area.
Replace the battery when it has been dropped or
if there is a noticeable reduction in the number of
transfers that can be performed between
charges. If you notice the Voyager Portable
“beeping’
–
see
the
instructions
in
“Troubleshooting” section to ensure it is a
problem with the battery.
Noticeable discoloration by having
a lighter color strap than the double
thickness stitched area.
Side wear.
To replace a battery, contact your local dealer or
representative and order product # A8500.
Middle wear.
DO NOT ATTEMPT TO USE A
BATTERY NOT AUTHORIZED BY
BHM MEDICAL.
BHM batteries are specially
designed for BHM charging
systems. Attempting to use an
unauthorized
battery
may
seriously damage the lift and/or
the charger.
If there are any signs of wear as
indicated here or other visual
defects,
strap
should
be
changed immediately.
By
continuing to use the lift without
changing the strap, caregiver
24
MAINTENANCE
Charger Fuse Replacement
Sling Inspection and Care
(Charger #A8200 only)
For maximum patient safety and hygiene, read
the following instructions:
If the charger light does not illuminate when
there is a battery in it, do the following steps:
Chemical Attack
Oil, grease, creosote or paint stains are
harmless but other forms of chemical attack of a
sufficient degree may lead to deterioration or
extreme softening of the webbing, which would
lead to the fibres being rubbed off (almost as
powder in extreme cases). It is best to avoid
fumes, spray or mists of acid and alkalis or
organic solvents. If contamination is suspected,
wash out well in warm water. Avoid contact with
excessive heat, which is likely to affect the
product.
1. Make sure the battery is properly placed in
the charger. The silver contact points should
be inside the charger.
2. Check to make sure the power cord is
correctly plugged in to the charger and the
wall.
3. If the light still doesn’t work, plug the charger
into a different outlet in a different area to
ensure that the outlet is working properly.
4. Pull the power cord out of the charger.
Under the socket on the charger, there is a
drawer or magazine where there is a fuse.
Using a pen or screwdriver, pull the drawer
out gently. Pull the burnt fuse out of the
drawer that is next to the charger (see
diagram below) and discard.
Take the
replacement fuse and place it in the same
slot where the burnt fuse was. Slide the
drawer back into the charger. Plug the
power cord into the charger. Place the
battery into the charger and check for the
light.
Cleaning
Certain chemical substances mentioned above
may be removed by diluted heavy duty cleaner
and warm water. Ensure that any cleaning
agents are removed by rinsing thoroughly in
warm water, maximum 60°C (140°F), and
allowed to dry naturally away from any source of
direct heat.
For normal washing and cleaning, follow the
care instructions on the label of the product.
Storage
Slings should be stored
sunlight, stress, pressure,
humidity. The sling should
contact with sharp objects,
possible damaging material.
5. If the light does not illuminate, contact your
local dealer or representative for assistance.
away from direct
excessive heat or
be kept away from
corrosives or other
Loose threads in stitched area.
Noticeable discoloration by having
a
lighter color strap than the double
thickness stitched area.
Replace the fuse with the following:
Fuse: GMC 0.5 A 250 V North America (When
input is 120 Vac) Product # C8FGMC0.5
Side wear.
Middle wear.
GMC 0.25 A 250 V European (When input
is 240 Vac) Product # C8FGMC0.250
4. Check for any sign of wear on sling straps as
described above and at the strap-sling
junction. Buckles should be checked to
ensure
that
the
locking/unlocking
mechanism opens and closes easily.
The fuse may also be ordered through your local
dealer or representative.
25
MAINTENANCE
5. Check for any sign of deterioration of the
sling material. Check for general external
wear, local abrasion, cuts, holes or burns in
the webbing and for chemical attack.
6. Look at “stitched areas” for broken, worn,
pulled or unravelled stitches.
7. Sling should be cleaned as indicated on the
tag.
If there is any sign of wear or deterioration as
indicated above or other visual defect, sling
should be changed immediately. By continuing
to use the lift without changing the sling,
caregiver and patient safety is greatly
compromised.
Take note of inspection results in
the log book at the end of this
manual.
Annual Inspection
The Voyager Portable and its accessories must
be inspected annually by a certified technician.
VOYAGER
PORTABLE
AND
ACCESSORIES
MUST
BE
SERVICED EVERY 12 MONTHS AS
A MINIMUM REQUIREMENT.
Do not attempt to do the inspection unless
you are certified to do so.
As part of the annual inspection, an annual
load test with the safe working load must be
performed on the VOYAGER PORTABLE as
required for CE MARK MAINTENANCE.
After annual inspection, have the log book
signed by the certified technician.
26
MAINTENANCE INSPECTION CHECKLIST
Maintenance Inspection Checklist
TO BE INSPECTED BY USER
ITEM
INITIALLY
BEFORE
EVERY
USE
EVERY
2
MONTHS
EVERY
6
MONTHS
EVERY
YEAR
EVERY
2 YEARS
LIFT DEVICE
Inspect for missing hardware or broken panel.
X
X
Inspect strap for wear.
X
Battery recharge.
X
X
X
Inspect round hook on the strap of the lift for
damage or cracks.
X
Inspect trolley in rail for damage, rust or cracks.
Replace if damaged.
X
Overall inspection by authorized personnel
X
SLING AND HARDWARE
Check all sling attachments for sign of wear.
X
Inspect sling material for wear or deterioration.
X
Inspect sling straps for wear.
X
Inspect for any defect or loose threads in the
“stitched areas”.
X
Cleaning sling as indicated on the tag.
When Necessary
ACCESSORIES
Verify strap extension for wear
X
Verify arm extension for wear
X
MAINTENANCE BY A CERTIFIED TECHNICIAN
Replace strap.
X
Inspect the welding aspect on the frame to
detect cracks.
X
Inspect connecting joints for proper attachment.
X
Verify that the emergency brake on the drum is
turning freely.
X
Verify emergency devices for good functioning.
X
Maintenance inspection points are suggested by the manufacturer, however in certain cases,
some inspections should be done on a more frequent basis. By continuing to use the lift
without replacing the listed parts in this maintenance inspection checklist, caregiver and
patient safety is greatly compromised.
.
27
TROUBLESHOOTING
TROUBLESHOOTING
DO NOT attempt to open the VOYAGER PORTABLE. Only a certified technician is
authorized to open the VOYAGER PORTABLE.
Alterations made to the VOYAGER PORTABLE by someone other than a certified
technician may cause serious injury.
PROBLEMS
TO CHECK
The unit does not work when you press • Make sure the hand control is plugged correctly into the
the
or
buttons on the hand
unit.
control.
• Use the control switches directly on the unit. If they are
working, it indicates a problem with the hand control; you
would then need to change the hand control.
The unit does not work when you press •
the
or
buttons on both sides of
the lift.
•
•
•
The unit starts and stops repetitively.
•
•
Is the battery charged and correctly installed?
Ensure the battery is inserted into the lift with the silver
contact points inside the lift.
Place the battery into the charger and check the light on the
charger. If the light remains red, leave the battery in the
charger for approximately 2 hours.
Is the “QUICK RELEASE” knob completely to the left
(locked) position? If not, the lift will not operate. Tighten the
tension on the strap to help move the “Quick Release”
knob.
Is there tension on the strap? The “Anti Crush” feature will
prevent the lift from working if there is no tension.
If all of the previous points have been checked without
success, you probably have a motor or electric problem,
you then need to call your BHM Medical representative.
If the load is more than safe working load, the unit will not
work due to an overload protection on the motor.
Has the lift been making a “beeping” sound? The battery is
low and needs to be charged.
The lift emits a “beep” during utilization. •
The unit may stop lifting but you can
still lower it.
Batteries are low, recharge them
Charge indicator on the charger •
#A8200 (green-red) does not light up
when the battery is in the charger
•
•
Check the orientation of the battery. The silver contact
points should be inside the charger.
Is the charger plugged into a standard outlet?
Check the condition of the fuse. If needed, change it with a
spare one. (see “Maintenance” section of this manual)
Has the battery been in the charger for many hours? See
“Battery Information” and “Charging the Battery “ in
“Maintenance” section.
Battery is damaged – have it replaced.
•
The light on the charger #A8200 shows •
green when the battery is inserted; yet
the lift will only work when there is no
one in the lift. When you attempt to
transfer someone, the lift stops.
The light on the charger #A8200 always •
lights up red – does not turn to green •
Try a different battery in the charger if available.
Take the battery and charger to a certified technician.
28
TROUBLESHOOTING
PROBLEMS
after an overnight charge.
TO CHECK
PROBLEMS
TO CHECK
Battery is always dead after a few • Replace battery with a new one, the life of the current one
transfers (3 to 5).
is probably nearly over.
(See the "Battery Information")
The light on the charger shows green • Battery has either been dropped or damaged in some other
(yellow for charger #700.13500) when
way. Replace the battery.
the battery is inserted, yet the lift will
only do one or two transfers.
Charger #700.13500: Green light is not •
illuminated
•
•
Charger #700.13500: When battery is •
inserted into the charger, the yellow
light does not flash or illuminate solid.
•
The battery does not slide into the lift.
•
•
Cannot remove battery from the lift.
•
•
•
Is the charger plugged into a standard outlet?
Try plugging the charger into another outlet to see if it will
work.
Contact your local dealer or representative.
Check the orientation of the battery. The silver contact
points should be inside the charger.
Contact your local dealer or representative.
Check if there is any damage to the battery that would
interfere in the lift battery’s slot. IF THERE IS DAMAGE DO NOT USE THE BATTERY.
Try to slide in another battery to see if there is any damage
in the lift battery’s slot. If so, call your BHM Medical
representative, if not discard the damaged battery.
See “Operation” instructions “Charging the Battery” on how
to remove the battery.
If the battery will not come out of the lift, tilt the lift to the
side so that the battery opening is under the lift. With your
hand guarding the opening for the battery, press the eject
button on the front of the Voyager Portable while gently
tapping the lift to help jolt the battery out of the lift. ONCE
THE BATTERY IS REMOVED – DISCARD BATTERY AND
REPLACE.
If you cannot remove the battery after trying the above,
contact your local dealer or representative for assistance.
29
ACCESSORIES
ACCESSORIES
BATTERY
Product No. A8500
HOOK
Product No. 000.08000
CHARGERS
Product No. A8200
STANDARD TROLLEY
Product No. A5900
Product No 700.13500
SWIVEL ADAPTOR
Product No. 700.10950
HOSPITAL GRADE
POWER CORD
Product No. E7525 North America
E7521 Europe
E7527 UK
E7528 Australia
ARM EXTENSION
Product No. A8300
FUSE
Product No.
C8FGMC0.5 (120/24 volt) North America
C8FGMC0.25 (240/24 volt) European
HAND CONTROL
Product No. 700.13600
ADJUSTABLE STRAP EXTENSION
Product No. A3710
30
LOG BOOK
LOG BOOK
Product Name :
VOYAGER PORTABLE
Product Serial Number :
Date of purchase :
Warranty Period :
Distributed By :
Owner Checklist :
•
•
•
•
•
Ensure the lift is serviced regularly as the Maintenance Inspection Checklist on page 63.
Contact an authorized BHM Medical Distributor / Service Agent immediately if there are any problems with the
operation of the device.
Ensure the log book is completed and signed.
Record any repairs required.
Withdraw the patient lifter from service if inspection reveals that user safety is jeopardized in any way from use
of the patient lifter.
TO BE COMPLETED AFTER EACH SERVICE OR INSPECTION
Service Type
Pre-delivery
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
____________________ ____________________
Printed
Signature
31
LOG BOOK
Service Type
Pre-delivery
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
____________________ ____________________
Printed
Signature
32
LOG BOOK
Service Type
Pre-delivery
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
Service Type
Pre-delivery
____________________ ____________________
Printed
Signature
Periodic inspection
Minor
Major
Condition report :
Action taken :
Date :
Inspected by:
_________________
____________________ ____________________
Printed
Signature
33
LIMITED WARRANTY
LIMITED WARRANTY
This warranty is extended only to the original purchaser/user of BHM Medical products.
Subject to the limitations and exclusions hereafter, BHM Medical Inc. warrants its products to be
free from defects in material under normal use and service, within the periods stated below from
the date of purchase. If within such warranty period any such product shall be proven to be
defective, such product shall be repaired or replaced at BHM Medical option. This warranty
does not include any labour or shipping charges incurred in replacement part installation or
repair of any such product. BHM Medical sole obligation and your exclusive remedy under this
warranty shall be limited to such repair and/or replacement.
The proper operation of this product is dependant on the compliance with the instructions
regarding operation and maintenance. Failure to comply strictly with those instructions will void
this warranty.
Patient Lifter
Lifter’s Accessories
Weighing Devices
Slings
Tracks and Installation
Easytrack / Easytrack FS Systems
Batteries - All Lifts (except portable track lift)
Batteries – Portable Track Lift
1 year
1 year
1 year
1 year
1 year
1 year
1 year
3 months
For warranty service, please contact the distributor from whom you purchased the BHM Medical
product.
Do not return products to our factory without prior authorization. BHM Medical will issue a Return
Authorization (RA) Number. C.O.D. shipments will be refused; all shipments to BHM Medical
must be prepaid. For this warranty to be valid, the purchaser must present its original proof of
purchase at the moment of the claim. The defective unit, assembly or part must be returned to
BHM Medical for inspection. The part or components repaired or replaced are guaranteed for the
remaining period of the initial warranty.
Limitations and Exclusions:
The warranty above does not apply to serial numbered products if the serial number has been
erased, removed or defaced.
No warranty claim shall apply where the product or any other part thereof has been altered,
varied, modified, or damaged; either accidentally or through improper or negligent use and
storage. Warranty does not apply to products modified without BHM Medical’s express written
consent (including but not limited to products modified with unauthorized parts or attachments),
products damaged by reason of repairs made to any component without the specific consent of
BHM Medical, or to products damaged by circumstances beyond BHM Medical’s control. BHM
Medical will solely determine evaluation of warranty claim. The warranty does not apply to
problems arising from normal wear or failure to adhere to the instructions in this manual. This
limited warranty does not cover non defect damage, damage caused by improper installation
(other than installation performed by BHM Medical) operation or care (including but not limited to
abuse, misuse, failure to provide reasonable or necessary maintenance, unauthorized repairs or
any alterations to the products). BHM Medical Inc. slings are void of warranty if not laundered as
per instructions on the Sling Label.
BHM Medical Inc. shall not be liable for damages losses or inconveniences caused by a carrier.
34
LIMITED WARRANTY
Only the original installation performed by BHM Medical or by its authorized subcontractors is
covered by this limited warranty. Any modification to the original installation not authorized by
BHM Medical will void this limited warranty. The limited warranty does not cover any problems
with, or relating to the premises where the products are installed or to the property of the
purchaser and shall remain the responsibility of the purchaser.
This limited warranty is in lieu of any other warranties, express or implied, and of any other
obligations or liability on BHM Medical’s part. Under no circumstances shall BHM Medical be
liable for consequential, incidental or special damages arising in connection with use, or inability
to use, the products. In no event shall BHM Medical’s liability for breach of warranty, or for any
delay in the performance of this warranty due to cause beyond the control of BHM Medical,
breach of contract, negligence or strict liability exceed the cost of the product covered hereby.
BHM Medical neither assumes nor authorises any person to assume for it any other obligation or
liability in connection to the sale installation, maintenance or service to the products.
The purchaser may have other rights under existing provincial of federal laws and where any
terms of this warranty are prohibited by such laws, they are deemed, null and void, but the
reminder of the warranty shall remain in effect.
35
001.08075.EN_rev8
February 2008
">