TrueZONE ARD, EARD, and ZD
Series Damper Assemblies
INSTALLATION INSTRUCTIONS
For Full Installation Instructions
Visit www.forwardthinking.honeywellhome.com to
download installation instructions and learn more
about TrueZONE products.
INSTALLATION
1.
Unpack the damper and install into ductwork.
NOTE: For insulated duct, slide the insulation
under the actuator and tape it to the
actuator’s outside flange to seal.
NOTE: In unconditioned spaces, mount the
actuator only on the side or top of the
damper. Mounting on the bottom of the
damper may result in condensation
dripping into the actuator.
2.
Set the range stop to the desired position.
Position 0 means fully closed.
NOTE: On ARD/ZD models, range stops prevent full closure. On EARD model,
range stop prevents full open.
Table 1. Approximate ARD/ZD Bleed Rate.
Position
Bleed Rate
3.
0
Closed
1
16%
2
30%
3
50%
Wire the actuator. See “Typical Wiring Examples” on page 2.
a. For 2 wire usage, wire M1 and M6. See Fig. 1.
b. For 3 wire usage, break the plastic tab to
access M4. See Fig. 2.
c. For EARD wiring, use only 2 VENT terminals.
See Fig. 4
33-00079EFS-07
TRUEZONE ARD, EARD, AND ZD SERIES DAMPER ASSEMBLIES
Field Converting ARD Damper from Normally Open to Normally
Closed
NOTE: To have the lights and position indicator be
accurate, you would need to replace the
M847D-ZONE actuator with the M847DVENT actuator. If this is installed in an attic or
crawlspace which is not visible to the customer, and having the lights and indicator be
reversed is not a concern to you, the M847DZONE actuator can be used. The EARD dampers come from the factory as spring-closed/
power-open dampers.
1.
2.
3.
4.
Remove the actuator.
Locate the two plastic grommets on the damper
and move them from one side to other.
Rotate the damper to closed position.
Replace the actuator on the opposite side of the
damper.
Typical Wiring Examples
TrueZONE DAMPERS TO HZ432 ZONE PANEL
EIM
M1 COMMON
ZONE 1
DAMPER
M1
M4
M6
R
M6 CLOSED
CONV
M35493
POWER
HEAT
COOL
FAN
U1
U2
U3
Fig. 1. 2-Wire Operation (Red LED only).
TrueZONE DAMPERS TO HZ432 ZONE PANEL
M1 COMMON
ZONE 1
DAMPER
M1
M4
M6
R
TO THERMOSTAT
FURNACE
C
R
W
W2
Y
A
Y2
G
M4 GREEN LED
M6 CLOSED
M35494
VENT
EARD
Fig. 2. 3-Wire Operation (Red and Green LEDs).
VENT
NOTE: 2- and 3-wire operation are Power Close/
Spring Open. Additional wire only adds green
LED.
A
B
C
D
C
R
THERMOSTAT
SYSTEM
TRANSFORMER
24
VAC
S4
S4
120
VAC
S3
S3
M35495
C
K
RC
EXTERNAL
TRANSFORMER
R
24
VAC
Fig. 4. Wiring an EARD fresh air damper to a
THM5421R EIM controlled by either Prestige or
RedLINK VisionPRO thermostat.
U1
U1
DAMPER
M1
M6
M35633
Fig. 3. EARD fresh air Damper with external
transformer.
33-00079EFS—07
SENSORS
2
INSTALLATION
1.
3.
0
Fermé
1
16 %
2
30 %
3
50 %
?
33-00079EFS-07
ENSEMBLES DE REGISTRE TRUEZONE SÉRIES ARD, EARD ET ZD
EIM
M1 COMMUN
ZONE 1
DAMPER
M1
M4
M6
R
VERS THERMOSTAT
M6 FERMÉ
CONV
MF35493
POWER
HEAT
COOL
FAN
U1
U2
U3
APPAREIL DE
CHAUFFAGE
C
R
W
W2
Y
A
Y2
G
M1 COMMUN
ZONE 1
DAMPER
M1
M4
M6
R
M4 DEL VERTE
M6 FERMÉ
VENT.
MF35494
EARD
VENT.
A
B
C
D
S4
S4
S3
S3
C
R
THERMOSTAT
TRANSFORMATEUR
DU SYSTÈME
24
V c.a.
MF35495
120 V c.a.
C
K
RC
TRANSFORMATEUR
EXTERNE
R
24
V c.a.
U1
U1
REGISTRE
M1
M6
MF35633
CAPTEURS
4
INSTALACIÓN
1.
2.
NOTA:
3.
Índice de purga
0
Cerrado
1
16%
2
30%
3
50%
33-00079EFS-07
ENSAMBLES DE REGULADORES TRUEZONE DE LAS SERIES ARD, EARD Y ZD
1.
2.
3.
4.
Ejemplos típicos de cableado
REGULADORES TrueZONE A PANEL DE ZONA HZ432
EIM
M1 COMÚN
ZONE 1
DAMPER
M1
M4
M6
R
AL TERMOSTATO
M6 CERRADO
CONV
POWER
HEAT
COOL
FAN
U1
U2
U3
MS35493
SISTEMA DE
CALEFACCIÓN
C
R
W
W2
Y
A
REGULADORES TrueZONE A PANEL DE ZONA HZ432
Y2
G
M1 COMÚN
ZONE 1
DAMPER
M1
M4
M6
R
M4 VERDE
M6 CERRADO
VENTILACIÓN
EARD
MS35494
VENTILACIÓN
A
B
C
C
R
TERMOSTATO
D
S4
S4
TRANSFORMADOR
DEL SISTEMA
24
V CA
S3
S3
MS35495
120 V CA
C
K
RC
TRANSFORMADOR
EXTERNO
R
24
V CA
U1
U1
REGULADOR
M1
M6
MS35633
Fig. 3. Amortiguador EARD de aire fresco con
transformador externo.
33-00079EFS—07
SENSORES
6
ENSAMBLES DE REGULADORES TRUEZONE DE LAS SERIES ARD, EARD Y ZD
NOTES / REMARQUES / NOTAS
7
33-00079EFS—07
ENSAMBLES DE REGULADORES TRUEZONE DE LAS SERIES ARD, EARD Y ZD
Resideo Inc., 1985 Douglas Drive North,
Golden Valley, MN 55422
www.resideo.com
33-00079EFS—07 M.S. Rev. 11-19 | Printed in United States
This product is manufactured by Resideo Technologies, Inc., Golden Valley, MN, 1-800-468-1502
©2019 Resideo Technologies, Inc. The Honeywell Home trademark is used under license from Honeywell International Inc. All rights reserved.">
