SL600
OWNER'S MANUAL
Stair Lift
Read and understand this manual thoroughly before attempting to install or operate the lift. If you have any questions, please contact your Authorized Harmar Dealer or
Harmar’s Technical Service Department.
© 2016 Harmar Mobility, LLC • All Rights Reserved
TEC0004 20160302 P/N: 610-00003-01 Rev A
Dealer Name & Contact Information:
Serial # of Your Lift:
Install Date:
Pinnacle Stair Lift
CONTENTS
2
Contents
Peace-of-mind comes in many forms. It’s knowing you can get up and down stairs on your own. It’s regaining your independence. It’s feeling secure each and every time you ride your stair lift—knowing you don’t have to worry about power outages, or about parking it at a specific spot on the track. It’s knowing you’ve made the best decision and acquired the right stair lift for you. That’s the feeling you get when you own a Pinnacle™ Stair
Lift from Harmar.
This energy-efficient stair lift is simple to operate, durable, and lightweight. Surprisingly compact when folded, the Pinnacle™ boasts a unique patented drive system, wireless remotes and intuitive operating controls with indicator lights.
SYMBOLS USED IN THIS MANUAL
READ MANUAL - Pay close attention to the instructions in the manual.
GENERAL
Dealer Information . . . . . . . . . . . . . . . . . . . . . . . . 3
Technical Specifications . . . . . . . . . . . . . . . . . . . 3
FEATURES
Stair Lift Features . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Safety Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
OPERATION
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Stair Lift Operation . . . . . . . . . . . . . . . . . . . . . . . . 5
MAINTENANCE
Battery Charger . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Care and Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . 7
Manual Overide Operation . . . . . . . . . . . . . . . . 7
OWNER INFORMATION
Owner Information . . . . . . . . . . . . . . . . . . . . . . . . 8
TROUBLESHOOTING
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . 8
WARRANTY
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
CAUTION - Hazardous situation. If not avoided, could result in serious damage to property.
WARNING - Hazardous situation. If not avoided, could result in serious injury to installer or user.
INDICATIONS OF USE STATEMENT
The SL600 Pinnacle Stair Lift is to assist transfer of patients or mobility impaired persons, up and down between levels of a residential or private facility.
Read & Understand this Manual in its
Entirety Prior to Installation or Operation.
Follow all operating procedures in order to avoid possible injury and/or property damage. If you do not understand any portion of installation or operation, please consult our technical service department or authorized mobility dealer.
Installation Site Electrical Requirements The lift shall be connected to a dedicated 110-230 V electrical circuit that is protected by a 30mA residual current device.
Lighting Requirements The stairway where the lift is installed shall have a minimum of 50 lux lighting in the areas where the lift will be boarded.
| www.harmar.com
© 2016 Harmar Mobility, LLC • All Rights Reserved
Pinnacle Stair Lift
Dealer Information
Name: _____________________________________________________________________
Address: ___________________________________________________________________
__________________________________________________________________________
Telephone Number: __________________________________________________________
Email: _____________________________________________________________________
If you have questions concerning the operation or maintenance of your stair lift, please contact your dealer.
Technical Specifications
Weight capacity: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 350 lbs
Stair angles: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 - 52 degrees
Speed: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 fpm
Shipping weight: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 184 lbs
Interchangeable arms: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
Interchangeable side to side: . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
Operating power: . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 VDC battery
Power supply input: . . . . . . . . . . . . . . . . . . . . . . . . . .120 VAC; 60 Hz
Power supply output: . . . . . . . . . . . . . . . . . . . . . 33 VDC; 1.2 Amps
Drive system: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Worm/Rack
Rail: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Extruded aluminum
Plastic covers: . . . . . . . . . . . . . . . . . . . . . . . . . ABS - flame retardant
Trips per hour: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 max
TEC0004 20160302 P/N: 610-00003-01 Rev A SL600 • Pinnacle Stair Lift Owner's Manual 3
Pinnacle Stair Lift
Stair Lift Features
LED Indicator
Rack
Rail
Seatbelt
Armrest
Key Lock
Top Safety
4
On/Off Switch
Up/Down Control
Seat Swivel Level
Chassis Safety
Footrest Safety
Remote Control
Bottom Safety
Manual Hand Crank
Optional Signature Seat and Folding Rail Shown
Safety Features
• There are sensitive edges on the top and bottom of the carriage, and the front, back and underside of the footrest. If any of these edges touches an obstruction the lift will halt immediately and the armrest LED indicator light will turn orange. The lift may only be driven away from the obstruction.
• An interlock on the swivel seat prevents the lift from being operated unless the seat is in its normal, locked position. The remote controls are disabled for a 15 second period after the armrest control is used.
| www.harmar.com
© 2016 Harmar Mobility, LLC • All Rights Reserved
Pinnacle Stair Lift
Controls
• The red “ON/OFF” switch is located on top of the chassis. This switch is normally left in the “ON” position (I).
This switch can be turned “OFF” if you do not expect to use the lift for an extended period of time. Ensure that the lift is in the charging position.
• The main “UP/DOWN” control switch is located at the front of one armrest. Use this switch for normal operation of the lift while in a seated in a secure position.
• There are “UP” and “DOWN” buttons on the remote call/send hand control units.
• There is a three-color LED indicator light on one armrest.
• Units equipped with a key switch located at the back of one armrest. Turn this off and remove the key when you want to ensure the lift cannot be used in your absence.
Stair Lift Operation
Step 1 : To turn the stair lift on, press the red “ON/OFF” switch located on the top of the carriage to the “ON” position (I) and ensure that the key switch (if equipped) is “ON.” When the lift is turned “ON” a green light on the armrest will indicate that the lift is ready for use.
WARNING
Do not carry pets or children on your lap while riding the stair lift. The lift is designed for use by only one person at a time.
Step 2: To aid entry to the chair, the armrest on the entry side may be raised. When positioning yourself on the seat at the upper landing, ensure the seat is fully swiveled and locked in position for safety. The seat may be swiveled by depressing the swivel release handle on either side of the seat.
WARNING
Never attempt to operate the lift while standing up. Always sit in the center of the seat with the seat belt fastened around your waist.
Step 3: Ensure that you are securely seated and armrests are in down position before operating the lift. To operate the lift, continuously press the hand control switch on the side in which you wish to travel.
WARNING
Keep your feet centered on the footrest while traveling up and down the stairs.
Never dangle your feet off the footrest while riding the lift.
TEC0004 20160302 P/N: 610-00003-01 Rev A SL600 • Pinnacle Stair Lift Owner's Manual 5
6
Pinnacle Stair Lift
Stair Lift Operation (cont)
Step 4: If you release the control switch the lift will stop. Continue to press the switch or button all the way to the landing. The lift will gently stop at the appropriate, preset point.
Step 5 : To safely exit the lift, support yourself by the armrests, rise and step off the footrest. At the upper landing, ensure that the seat is fully swiveled and locked before rising. If you do not intend to use the lift again immediately, the seat and armrests may be folded up to minimize obstruction to people walking on the stairs.
WARNING
When transferring in or out of the seat use the armrests to assist you. Ensure the seat is securely latched before transferring in or out.
Step 6: To operate the lift remotely, continuously press the appropriate up or down button on the call/send hand control unit. Like all infrared devices, the signal may be interrupted if the hand control unit is not in the line of sight of the stair lift. If this happens the lift may temporarily stop but restart immediately, as long as the hand remote is pressed continuously.
If you are operating the lift remotely on behalf of another person, please ensure that they are securely seated with the seat belt engaged. Always keep the person in line of sight before commencing movement.
NOTE: An amber light and single beep indicate that the lift has touched an obstruction and may only be operated in the opposite direction of the obstruction. Clear the obstruction before proceeding.
If the light flashes orange and the lift beeps intermittently, the lift has been stopped away from the top or bottom charging stations. Please move the lift to either end of the rail to ensure the batteries remain fully charged.
The LED indicator light will turn red if there is a service issue. Turn the “ON/OFF” switch to the “OFF” position
(O) and then back to the “ON” position (I). The lights should sequence red-amber-green. If the light does not return to green, please call your service representative.
| www.harmar.com
© 2016 Harmar Mobility, LLC • All Rights Reserved
Pinnacle Stair Lift
Maintenance
Battery Charger
The stair lift should be kept fully charged at all times. When the lift stops at an upper or lower landing it will charge automatically. The power supply should be left plugged in at all times and the lift may be left on charge indefinitely, as the charger is intuitive and will not overcharge.
Note: The stairlift must be turned on to enable battery charging. Batteries will not charge when lift is turned off.
Care And Cleaning
The lift should require no technical maintenance to continue to operate at full capability. There is no grease or other lubricants used in the drive system, and no adjustments should be required. However, the lift should be inspected annually. The lift and rail should be kept clean. Dust can build up on surfaces, and soiling may occur.
The upholstery and carriage can be cleaned with a damp, soapy cloth followed by a clean, damp cloth. Do not use abrasive cleansers as these can damage the finish. If heavy soiling occurs, clean by scrubbing lightly with a soft brush.
Manual Overide Operation
If your lift fails to operate and the operator does not wish to dismount on the stairway, another person may use the manual overide tool to lower (or raise) the lift to a landing. However please follow the instructions on the bottom safety flap of the lift and turn the lift off. Insert the manual overide tool into the hole in the lower safety flap until it engages the motor shaft, and turn in the direction indicated .
WARNING
Do not operate the lift with the manual overide tool engaged.
TEC0004 20160302 P/N: 610-00003-01 Rev A SL600 • Pinnacle Stair Lift Owner's Manual 7
8
Pinnacle Stair Lift
Owner Information & Troubleshooting
Owner Information
Thank you for purchasing an SL 6001Pinnacle™ Stair Lift from Harmar. This is the most trouble-free stair lift on the market today. It is our hope this lift will provide the independence you want in your day-to-day life.
Date purchase_____________________________
Lift serial number__________________________
If warranty work or service is needed, your dealer will need the data above to receive factory information or order parts for this lift.
Troubleshooting
• If your lift does not operate, diagnose the problem by observing the LED indicator light on the armrest and listening to the beeps emitted:
• A green light indicates the lift is in operating mode and may be moved in either direction.
• An amber light indicates the lift is touching an obstruction and may be operated only in the direction away from the obstruction.
• A flashing amber light, accompanied by an intermittent beep for 30 seconds indicates the lift has been stopped off the charge station. This repeats every 5 minutes until the lift is returned to the charge station. It is recommended that the lift be immediately moved to a charge station (located at either end of the rail).
• A red light indicates a problem that may require a service call. If the light remains red after attempting to reset the lift by turning it “OFF” and then “ON” again, please contact your local dealer or Harmar and describe the problem. A local technician will need to be contacted to repair the problem if it cannot be repaired over the phone .
Minor faults
Single long beep (will reset once fault is cleared)
•
•
•
•
•
Seat swiveled out of position
Edge safety detected
Under foot rest
Current overload condition
A Low battery voltage condition
Pulsing Beep
Lift stopped off of charge strip. Will sound after 30 second for 30 seconds. It will repeat ever 10 minutes until lift is operated or returned to charge strips.
Major Tones
Tones Beeps
Runaway . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
No Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Conflicting Switches Footrest UP & Footrest DOWN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Conflicting Switches Obstruction UP & Obstruction Down . . . . . . . . . . . . . . . . . . . . . . . . .4
Conflicting Switches Footrest DOWN & Obstruction UP . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Conflicting Switches Footrest UP & Obstruction DOWN . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Conflicting Switches STOP UP & STOP DOWN switches both Detected . . . . . . . . . . . . .7
Conflicting Switches STOP UP & STOP DOWN switches both not Detected . . . . . . . . .8
| www.harmar.com
© 2016 Harmar Mobility, LLC • All Rights Reserved
Pinnacle Stair Lift
PINNACLE™ STAIR LIFT
THREE YEAR WARRANTY CERTIFICATE
Please fill out all fields and return within ten (10) days of product purchase.
Fax completed form to 1-866-234-5680 or mail to Harmar, ATTN Warranty Department, 2075 47th Street, Sarasota Florida 34234. Harmar Mobility, LLC,
18505 E. 163rd St., Lake Winnebago, MO 64034, warrants to the original purchaser of a Pinnacle stair lift manufactured by us to be free from defects in material and workmanship for a 3-year period on all component parts of the lift.
Exceptions to this Limited Warranty are:
• Batteries are warranted for a 1-year period • Torn or dirty upholstery
• Damage resulting from improper installation or operation • Shipping damage
• Negligence, alterations, abuse or misuse of the equipment
• Fire, flood, acts of God
• Parts used that are not supplied by Harmar Mobility, LLC
• Labor fees for installation work or service calls
No warranty is extended, express or implied, whether of merchantability or fitness for a particular purpose, after expiration of 3 years from the date of original purchase of the unit. Harmar Mobility, LLC and its dealers shall not be liable for any consequential, special or incidental damages arising out of the purchase or use of the unit or resulting from the breach of this Limited Warranty, or any implied warranty. The limit of liability of Harmar Mobility,
LLC and its dealer hereunder shall be the unit’s purchase price. Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, or legal remedies, so these above limitations may not apply to you. All warranty claims must be reported to the dealer from whom the lift was purchased as they have responsibility for handling your warranty claim. The dealer is to contact the Service Department of Harmar Mobility, LLC and provide the serial number of the lift along with a description of the events leading to the warranty claim. Dealers may charge for labor, service, travel, or other associated costs to make repairs, and such charges are not covered by this Limited Warranty.
It is permissible to have any repairs or replacement work done as a result of any defects in material and workmanship by someone other than the Dealer under this Limited Warranty. However, the Limited Warranty does not cover any charges or expenses assessed by any such other person or company performing such repairs or replacement work. All parts used to replace defective materials must be genuine Harmar Mobility, LLC parts to be covered by this Limited Warranty. This Limited Warranty gives you specific legal rights, and you may have other rights which vary from state to state.
Product Information
Model: _______________________________________
Serial Number: ________________________________
Purchase Date: ________________________________
Installer Information
Company Name: _______________________________
Contact Name: ________________________________
Address: _____________________________________
_____________________________________________
Phone: _______________________________________
Fax: _________________________________________
Email: ________________________________________
TEC0004 20160302 P/N: 610-00003-01 Rev A
Purchaser Information
Name: _______________________________________
Address: _____________________________________
_____________________________________________
Phone: _______________________________________
Email: ________________________________________
Additional Information
How did you hear about Harmar?
Harmar Dealer
Internet
Magazine
Friend or Acquaintance
Saw Harmar product
Other______________________
Do you have internet access? Yes No
I purchased my Harmar lift because of?
Style/Appearance
Harmar Representative
Previous Experience
Ease of Use
Recommendation
Price/Value
SL600 • Pinnacle Stair Lift Owner's Manual 9
Pinnacle Stair Lift
NOTES
10 | www.harmar.com
© 2016 Harmar Mobility, LLC • All Rights Reserved
SL600
OWNER'S MANUAL
Stair Lift
www.harmar.com | 800-833-0478
2075 47th Street Sarasota, Florida 34234
