advertisement
![Service Record Summary (Lubrication). Midland End Dump Trailer | Manualzz Service Record Summary (Lubrication). Midland End Dump Trailer | Manualzz](http://s3.manualzz.com/store/data/058368827_1-1b42b154c0f691328aba5f744ce82e6a-360x466.png)
5.1.4 SERVICE RECORD SUMMARY (LUBRICATION)
LOCATION DESCRIPTION FREQUENCY LUBRICANT
Hoist cylinder pivots Upper and lower.
Daily or as needed.
Chassis grease.*
Landing gear
Wheels
Gearbox and screws.
Check oil level.
Periodic basis (weekly).
Weekly, 10 Days or 5000 m
(8000 km)
Chassis grease.*
Brakes
Bearings.
Change oil.
Inspect.
25,000 miles (40,000 km).
100,000 miles (150,000 km).
SAE 80W90 gear oil.
SAE 80W90 gear oil.
Chassis grease.*
Lubricate
Slack Adjuster and Drums
(Daily)
5,000 miles (8,000 km) or monthly.
Chassis grease.* Camshaft bearing
Slack adjuster
Brake shoe anchor pin bushing
Also at brake reline.
Lubricate
Lubricate
5,000 miles (8,000 km) or monthly.
30,000 miles (50,000 km) or yearly.
As appropriate.
Chassis grease.*
* Use a good quality lithium based extreme pressure grease throughout.
MIL-G-25013C in below -40°F.
NOTE: Do not use excessive lubricant.
53
advertisement
Related manuals
advertisement
Table of contents
- 13 1 Introduction
- 14 Safety
- 15 General Safety
- 16 Operating Safety
- 16 Maintenance Safety
- 17 Unloading Safety
- 17 Travel Safety
- 18 Loading Safety
- 18 Tire Safety
- 18 Safety Signs/Decals
- 19 Sign-Off Form
- 20 Safety Sign (Decal) Locations
- 24 Operation Guidelines
- 24 To the New Operator or Owner
- 25 Terminology
- 26 Break-In
- 28 Controls
- 32 Pre-Operation Vehicle Inspection Procedure
- 35 Hooking Up/Unhooking
- 35 Hooking Up
- 37 Unhooking
- 38 End Gate
- 39 Lift Cylinder
- 40 Air System
- 40 Gate Latch Control System
- 41 Tanks
- 42 Loading/Unloading
- 47 Transporting
- 47 Operating Instructions
- 48 Braking Guidelines
- 49 Tires
- 50 Optional Equipment
- 51 Service and Maintenance
- 51 5.1 Service
- 51 Fluids and Lubricants
- 51 Greasing
- 53 Servicing Intervals
- 65 Service Record Summary (Lubrication)
- 66 Periodic Maintenance and Adjustments
- 66 Torque Specification Summary
- 68 Kingpin and Anchor Frame
- 69 Axle Alignment
- 71 Wheel Hubs/Bearings
- 75 Wheels
- 77 Tires
- 79 Brakes
- 82 Slack Adjusters
- 82 Automatic Slack Adjuster
- 83 Automatic Slack Adjuster Maintenance
- 89 Air Chamber/Spring Brake
- 90 Trailer ABS
- 91 Suspension System
- 91 Air Ride Suspension
- 95 Spring Ride Suspension
- 97 Air System
- 97 Air System Inspection
- 97 Air System Functional
- 98 Electrical System
- 99 Trouble Shooting
- 107 Bolt Torque