advertisement
Replacement parts
Evaporator
Condenser
Hose
Receiver dryer
Compressor Oil
HVAC SYSTEM (HEATER, VENTILATOR AND A/C)
6. Compressor Oil
A: OPERATION
NOTE:
Before making repairs, conduct the oil return operation to return the compressor oil in circulation with the refrigerant to the compressor.
1) Increase the engine speed to 1,500 rpm.
2) Turn ON the A/C switch.
3) Turn the temperature control dial to MAX COOL.
4) Set the air inlet select switch to RECIRC position.
5) Turn the fan dial to HI.
6) Leave in this condition for 10 minutes.
B: REPLACEMENT
NOTE:
• If a component is replaced, add an appropriate amount of compressor oil (same as the amount of remaining oil in removed component).
• When replacing the compressor, the new compressor will already have the specified amount of oil in it. Install the new compressor after removing the same amount of oil that is remaining in the compressor removed.
Amount of oil replenishment
Approx. 50 cm
3
(1.7 US fl oz, 1.8 Imp fl oz)
Approx. 30 cm
3
(1.0 US fl oz, 1.1 Imp fl oz)
Approx. 10 cm
3
(0.4 US fl oz, 0.4 Imp fl oz)
Approx. 10 cm
3
(0.4 US fl oz, 0.4 Imp fl oz)
AC-31
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project
Related manuals
advertisement
Table of contents
- 4 General Description
- 27 Refrigerant Pressure with Manifold Gauge Set
- 28 Refrigerant Recovery Procedure
- 29 Refrigerant Charging Procedure
- 32 Refrigerant Leak Check
- 33 Compressor Oil
- 34 Blower Motor Unit Assembly
- 35 Blower Resistor (Manual A/C Model)
- 36 Heater Core
- 37 Control Unit
- 38 Compressor
- 39 Condenser
- 40 Condenser (Sub Fan)
- 41 Heater Cooling Unit
- 42 Evaporator
- 43 Hose and Tube
- 44 Relay and Fuse
- 45 Pressure Switch (Triple Pressure Switch)
- 46 Ambient Sensor (Auto A/C Model)
- 47 Sunload Sensor (Auto A/C Model)
- 48 Air Vent Grille
- 49 Heater Duct
- 50 Heater Vent Duct
- 51 Heater Cock Solenoid Valve
- 52 General Diagnostics
- 56 Basic Diagnostics Procedure
- 57 General Description
- 59 Electrical Component Location
- 61 Auto A/C Control Module I/O Signal
- 63 Diagnostic Chart for Self-Diagnosis
- 66 Diagnostics for A/C System Malfunction
- 75 Diagnostic Procedure for Actuators
- 86 Diagnostic Procedure for Sensors
- 95 General Diagnostic Table
- 98 General Description
- 105 Airbag Connector
- 108 Inspection Locations After a Collision
- 110 Driver’s Airbag Module
- 111 Passenger’s Airbag Module
- 112 Side Airbag Module
- 114 Airbag Control Module
- 115 Side Airbag Sensor
- 116 Roll Connector
- 117 Front Sub Sensor
- 118 Airbag Module Disposal (Deployment Processing On Vehicle)
- 122 Disposal of Airbag Module (Deploying After Removal from Vehicle)
- 128 Basic Diagnostic Procedure
- 129 Check List for Interview
- 130 General Description
- 145 Electrical Components Location
- 147 Airbag Control Module I/O Signal
- 153 Airbag Connector
- 156 Airbag Warning Light Illumination Pattern
- 157 Read Diagnostic Trouble Code (DTC)
- 158 Inspection Mode
- 159 Clear Memory Mode
- 160 Airbag Warning Light Failure
- 169 List of Diagnostic Trouble Code (DTC)
- 172 Diagnostic Procedure with Diagnostic Trouble Code (DTC)
- 228 General Description
- 232 Inspection Locations After a Collision
- 233 Seat Belt Warning System
- 236 Front Seat Belt
- 238 Rear Seat Belt
- 240 Disposal of Pretensioner
- 246 General Description
- 247 Headlight and Tail Light System
- 248 Front Fog Light System
- 249 Rear Fog Light System
- 250 Turn Signal Light and Hazard Light System
- 251 Back-up Light System
- 252 Stop Light System
- 253 Room Light System
- 254 Headlight Beam Leveler System
- 255 Combination Switch (Light)
- 257 Headlight Assembly
- 260 Headlight Bulb
- 261 Front Turn Signal Light Bulb
- 262 Clearance Light Bulb
- 263 Front Fog Light Assembly
- 264 Front Fog Light Bulb
- 265 Rear Combination Light Assembly
- 266 Tail/Stop Light Bulb
- 267 Back-up Light Bulb
- 268 Rear Turn Signal Light Bulb
- 269 Rear Fog Light Bulb
- 270 License Plate Light
- 271 High-mounted Stop Light
- 272 Side Turn Signal Light
- 273 Spot Map Light
- 274 Room Light
- 275 Luggage Room Light
- 276 Glove Box Light
- 278 General Description
- 282 Wiper and Washer System
- 283 Combination Switch (Wiper)
- 285 Wiper Blade
- 287 Washer Tank and Motor
- 288 Front Wiper Arm
- 289 Front Wiper Motor and Link
- 291 Front Washer Nozzle
- 292 Rear Wiper Arm
- 293 Rear Wiper Motor
- 294 Rear Washer
- 295 Wiper Control Relay
- 296 Headlight Washer
- 298 General Description
- 299 Radio System
- 300 Front Accessory Power Supply Socket System
- 301 Radio Body
- 302 Front Speaker
- 303 Antenna
- 304 Antenna Amplifier
- 305 Front Accessory Power Supply Socket
- 314 General Description
- 318 Power Window System
- 319 Power Window Control Switch
- 322 Remote Control Mirror System
- 323 Scalp Cap
- 324 Outer Mirror Assembly
- 326 Outer Mirror
- 327 Remote Control Mirror Switch
- 329 Front Door Glass
- 333 Front Regulator and Motor Assembly
- 334 Rear Door Glass
- 336 Rear Regulator and Motor Assembly
- 337 Windshield Glass
- 340 Inner Rearview Mirror
- 341 Rear Gate Glass
- 342 Rear Window Defogger System
- 343 Rear Window Defogger
- 344 Rear Quarter Glass
- 346 Roof Window Glass
- 356 General Description
- 357 Combination Meter System
- 364 Combination Meter Assembly
- 367 Speedometer
- 368 Tachometer
- 369 Fuel Gauge
- 370 Water Temperature Gauge
- 371 Ambient Sensor
- 396 General Description
- 403 Door Lock Control System
- 408 Keyless Entry System
- 416 Front Inner Remote
- 417 Front Outer Handle
- 418 Front Door Latch Assembly
- 419 Front Door Lock Actuator
- 420 Rear Inner Remote
- 421 Rear Outer Handle
- 422 Rear Door Latch Assembly
- 423 Rear Door Lock Actuator
- 424 Rear Gate Outer Handle
- 425 Rear Gate Latch Assembly
- 426 Rear Gate Latch Lock Actuator
- 427 Front Hood Lock Assembly
- 428 Remote Openers
- 429 Ignition Key Lock
- 430 Key Lock Cylinder
- 431 Immobilizer Control Module
- 432 Immobilizer Antenna
- 433 Keyless Entry Control Module
- 434 Double Lock Module
- 435 Keyless Transmitter
- 438 General Description
- 440 Sunroof Control System
- 441 Sunroof Lid
- 442 Sunroof Assembly
- 444 Sunroof Motor
- 445 Sunroof Switch
- 448 General Description
- 464 Front Grille
- 465 Hood Grille
- 468 Front Under Cover
- 469 Front Bumper
- 476 Rear Bumper
- 477 Mud Guard
- 478 Cowl Panel
- 479 Side Sill Spoiler
- 480 Side Garnish
- 481 Front Door Trim
- 482 Rear Door Trim
- 483 Glove Box
- 484 Roof Rail
- 485 Console Box
- 486 Instrument Panel Assembly
- 489 Upper Inner Trim
- 490 Lower Inner Trim
- 491 Rear Quarter Trim
- 492 Sun Visor
- 493 Roof Trim
- 494 Rear Gate Trim
- 495 Floor Mat
- 496 Luggage Floor Mat
- 497 Instrument Panel Center Compartment
- 498 Heat Shield Cover
- 500 General Description
- 507 Front Hood Panel
- 508 Front Fender Panel
- 509 Front Door Panel
- 511 Front Sealing Cover
- 512 Rear Door Panel
- 514 Rear Sealing Cover
- 515 Rear Gate Panel
- 518 Rear Gate Garnish Assembly
- 520 General Description
- 523 Actuator
- 525 Cruise Control Module
- 526 Cruise Control Main Switch
- 527 Cruise Control Command Switch
- 528 Stop and Brake Switch
- 529 Clutch Switch
- 530 Inhibitor Switch (AT model)
- 531 Neutral Position Switch (MT model)
- 534 Basic Diagnostic Procedure
- 536 General Description
- 538 Electrical Components Location
- 539 Cruise Control Module I/O Signal
- 541 Subaru Select Monitor
- 543 Diagnostic Procedure with Symptom
- 559 List of Diagnostic Trouble Code (DTC)
- 561 Diagnostic Procedure with Diagnostic Trouble Code (DTC)
- 574 Basic Diagnostic Procedure
- 576 General Description
- 577 Electrical Components Location
- 578 Engine Control Module (ECM) I/O Signal
- 580 Subaru Select Monitor
- 582 Diagnostic Procedure with Symptom
- 585 List of Diagnostic Trouble Code (DTC)
- 588 Diagnostic Procedure with Diagnostic Trouble Code (DTC)
- 601 Basic Diagnostic Procedure
- 602 General Description
- 604 Electrical Components Location
- 605 Immobilizer Control Module I/O Signal
- 606 Subaru Select Monitor
- 607 Read Diagnostic Trouble Code (DTC)
- 608 Clear Memory Mode
- 609 Diagnostics Chart for Immobilizer Warning Light
- 613 List of Diagnostic Trouble Code (DTC)
- 614 Diagnostics Procedure with Diagnostic Trouble Code (DTC)