Parts and diagrams. HP 3600, 3600 n, CP3505 dtn, 3000, 3000 dtn, 3600 dn, 3600 dtn, 3800 n, 3800 dn, 3800 dtn
Reklaam
Reklaam
7 Parts and diagrams
ENWW
●
●
●
●
●
Duplexing-feed drive assembly (duplex models)
●
Duplexing reverse-drive assembly (duplex models)
●
Developing separation-drive assembly
●
●
●
Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
●
Paper-pickup assembly (HP CLJ 3000)
●
Electronic transfer belt (simplex models)
●
Electronic transfer belt (duplex models)
●
Multipurpose tray assembly (tray 1)
●
Duplex-paper feed assembly (duplex models)
●
●
●
500-sheet feeder cassette (tray 3)
●
500-sheet feeder paper-pickup assembly
●
●
●
257
Ordering parts and supplies
This section describes Web resources for ordering parts and for technical support and resources for ordering related documentation and software.
Parts
Order replacement parts from the following Web sites:
● http://www.hp.com/ssg/parts/direct_order.html
● HP Parts Store: http://www.hp.com/buy/parts
● Partsurfer: http://partsurfer.hp.com
● HP Parts Portal: http://www.hp.com/go/HPparts
How to use the parts lists and diagrams
The figures in this chapter show the major subassemblies in the printer and their component parts. A parts list table follows each exploded-view assembly diagram. Each table lists the item number, the associated part number, and the description of each part. If a part is not listed in the table, then it is not a field replacement unit (FRU).
CAUTION: Be sure to order the correct part. When looking for part numbers for electrical components, pay careful attention to the voltage that is listed in the description column to ensure that the part number selected is for the correct printer model.
NOTE: In this manual, the abbreviation “PCA” stands for “printed circuit board assembly.” components described as a PCA might consist of a single circuit board or a circuit board plus other parts, such as cables and sensors.
Types of screws
Illustration Description
Screw w/washer
Size
M3X8
Part Number
XA9–1420–000CN
Screw, RS M3X6
M3X10
XA9–1499–000CN
Use
Used to secure metal components to metal components (for example, a ground wire to the frame)
Used to secure metal to metal
Screw, tapping, truss head
M4X10 XB4–7401–000CN Used to secure anything to plastic
258 Chapter 7 Parts and diagrams ENWW
Related documentation and software
Table 7-1 Technical support Web sites
HP Customer Care Online
Software drivers, support documentation, and answers to frequently asked questions
HP Technical Training (North America)
Classes and schedules http://www.hp.com/go/support http://www.hp.com/go/resellertraining
Accessories and supplies
Table 7-2 Accessories and supplies
Item Part number
Memory (DIMMs)
(HP Color LaserJet
3000/3800/CP3505
Series only)
Q7721A
Q7722A
Q7723A
500-sheet feeder (tray
3)
Q5985A
Service/exchange number
Q7721-67951
Q7722-67951
Q7723-67951
Q5985-67901
Description
Synchronous 128 MB
DDR SDRAM DIMM
Synchronous 256 MB
DDR SDRAM DIMM
Synchronous 512 MB
DDR SDRAM DIMM
Optional accessory
ENWW Ordering parts and supplies 259
Table 7-2 Accessories and supplies (continued)
Item Part number Service/exchange number
Internal (EIO) connectivity for the
HP Color LaserJet
3000, 3800, and
CP3505 Series printers
J6073A
J7934A
J7960A
J7961A
J7972G
J6035D/G
J7942A
J7951A
Printer supplies for the HP Color LaserJet
3000 Series printer
Printer supplies for the HP Color LaserJet
3600 Series printer
Printer supplies for the HP Color LaserJet
3800 and CP3505
Series printers
Cable
Q7560A
Q7561A
Q7562A
Q7563A
Q6470A
Q6471A
Q6472A
Q6473A
Q6470A
Q7581A
Q7582A
Q7583A
C6518A
Q7560-67901
Q7561-67901
Q7562-67901
Q7563-67901
Q6470-67901
Q6471-67901
Q6472-67901
Q6473-67901
Q6470-67901
Q7581-67901
Q7582-67901
Q7583-67901
Description
HP EIO highperformance hard disk
HP Jetdirect 620n print server (10/100-
TX Ethernet)
HP Jetdirect 625n print server
(10/100/1000T
Ethernet)
HP Jetdirect 635n
IPv6/IPsec/Gigabit print server
HP 1284 parallel card
HP Jetdirect 175x print server (fast
Ethernet, value feature set, 10/100-
TX, USB 1.1)
HP Jetdirect en3700 print server (fast
Ethernet, 10/100-TX,
USB 2.0)
HP Jetdirect ew2400 wired/wireless print server (fast Ethernet, value feature set,
USB 2.0)
Black print cartridge
Cyan print cartridge
Yellow print cartridge
Magenta print cartridge
Black print cartridge
Cyan print cartridge
Yellow print cartridge
Magenta print cartridge
Black print cartridge
Cyan print cartridge
Yellow print cartridge
Magenta print cartridge
USB 2.0 printer cable
(2-meter [6.5-feet] standard)
260 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-2 Accessories and supplies (continued)
Item Part number Service/exchange number
Media C2934A
C2936A
Q2419A
C4179A
C4179B
Q1298A
Q1298B
HPU1132
CHP410
HPJ1124
CHP310
Reference, service, and training materials
5851-1468
5021-0337
Description
50 sheets
HP Color LaserJet
Transparencies (letter)
50 sheets
HP Color LaserJet
Transparencies (A4)
50 sheets
HP LaserJet High
Gloss paper (letter)
200 sheets
HP LaserJet High
Gloss paper (letter)
200 sheets
HP LaserJet High
Gloss paper (A4)
HP LaserJet Tough paper (letter)
HP LaserJet Tough paper (A4)
HP Premium Choice
LaserJet paper (letter)
HP Premium Choice
LaserJet paper (A4)
HP LaserJet paper
(letter)
HP LaserJet paper
(A4)
HP LaserJet Printer
Family Print Media
Specification Guide
PCL/PLJ Technical
Reference Package
For downloadable versions, go to http://www.hp.com/ support/clj3000 , http://www.hp.com/ support/clj3600 , http://www.hp.com/ support/clj3800 , or http://www.hp.com/ support/cljcp3505 .
When connected, select Manuals.
Ordering parts and supplies 261
Table 7-2 Accessories and supplies (continued)
Item Part number Service/exchange number
Assembly, service, and training CD
Q5982-60114
Service manual (this manual)
Control-panel overlays
(HP Color LaserJet
3000 Series only)
Control-panel overlays
(HP Color LaserJet
3600/3800/CP3505
Series only)
Q5982-90970
Q7533-60112
Q7533-60113
Q7533-60114
Q7533-60115
Q5982-60107
Q5982-60108
Q5982-60109
Q5982-60110
Q5982-60111
Formatter
HP Color
LaserJet 3000 Series
Q5982-67907
Q5982-67908
Q5982-69001
Q5982-69002
Formatter
HP Color
LaserJet 3800 Series
Q5982-67907
Q5982-67908
Q5982-69001
Q5982-69002
Formatter
HP Color
LaserJet CP3505
Series
CB441-67901
CB441-69001
Description
CD based service and training information
(English)
Printed copy of this manual
German, French,
Italian
Spanish, Dutch,
Portuguese, Catalan
Finnish, Norwegian,
Swedish, Slovak
Czech, Hungarian,
Polish
French, Spanish,
Portuguese
German, French,
Italian
Spanish, Dutch,
Portuguese, Catalan
Finnish, Norwegian,
Swedish, Slovak
Czech, Hungarian,
Polish base and N models
(new) base and N models
(exchange)
DN and DTN models
(new)
DN and DTN models
(exchange) base and N models
(new) base and N models
(exchange)
DN and DTN models
(new)
DN and DTN models
(exchange) new exchange
262 Chapter 7 Parts and diagrams ENWW
Table 7-2 Accessories and supplies (continued)
Item Part number Service/exchange number
Q5987-67901 I controller (formatter)
HP Color
LaserJet 3600 Series only
Power cord 8120–5301
Description
I controller
Power cord, OPT-903
3-COND 1.9-M-LG
ROHS (110v)
ENWW Ordering parts and supplies 263
External panels and covers
See front-cover assembly
Simplex model or Duplex model
See Multipurpose tray (tray1)
Figure 7-1 External panels and covers (1 of 2)
264 Chapter 7 Parts and diagrams ENWW
Table 7-3 External panels and covers (1 of 2)
6
7
4
5
2
3
Ref
1
8
11
16
Description
Link, multipurpose tray (tray 1) hinge left
Link, multipurpose tray (tray 1) hinge right
Spring, tension
Cover, left
Cover, multipurpose tray (tray 1)
Cover, cassette rear right (hinge)
Cover, cassette rear left
Cover, rear lower
Cover, right
Multipurpose tray (tray 1) extension tray assembly
Part number
RC1-6381-000CN
RC1-6382-000CN
RC1-6383-000CN
RC1-6687-000CN
RC1-6690-000CN
RC1-6691-000CN
RC1-6792-000CN
RC1-7550-000CN
RM1–2669–000CN
RM1-2710-000CN
1
1
1
1
1
2
Qty
1
1
1
1
ENWW External panels and covers 265
Figure 7-2 External panels and covers (2 of 2)
266 Chapter 7 Parts and diagrams ENWW
Table 7-4 External panels, and covers (2 of 2)
20
21
22
15B
17
17
19
14A
14B
15
15A
Ref
12
13
14
Description
Interlock-switch assembly
Upper cover assembly (fuser door) (simplex models)
Top-cover assembly (simplex models)
Cable, paper-full (simplex models)
Connector, snap-tight (simplex models)
Top-cover assembly (duplex models)
Cable, paper-full (duplex models)
Upper cover assembly (fuser door) (duplex models)
Face-down tray assembly (HP CLJ 3000)
Face-down tray assembly (HP CLJ 3600/3800/CP3505)
Cable, duplexing (duplex models)
Torsion spring
Simplex page-delivery flay
Duplex page, duplex flag
Part number
RM1-2670-000CN
RM1-2671-000CN
RM1-2672-030CN
RM1-2630-000CN
VS1-7207-003CN
RM1-2713-020CN
RM1-2620-000CN
RM1-2714-000CN
RM1-2777-020CN
RM1-2750-020CN
RM1-2617-000CN
RC1-7628-000CN
RC1-6286-000CN
RC1-6755-000CN
1
1
1
1
1
1
1
1
1
1
1
1
1
Qty
1
ENWW External panels and covers 267
Figure 7-3 Front-cover assembly (simplex model)
268 Chapter 7 Parts and diagrams ENWW
Table 7-5 Front-cover assembly (simplex model)
Ref
All
Description
Front-cover assembly (simplex models)
Part number
RM1-2673-000CN
Qty
1
ENWW External panels and covers 269
Figure 7-4 Front-cover assembly (duplex model)
270 Chapter 7 Parts and diagrams ENWW
Table 7-6 Front-cover assembly (duplex model)
Ref
All
1
Description
Front-cover assembly (duplex models)
Fan (duplex models)
Part number
RM1-2715-000CN
RK2-0954-000CN
Qty
1
1
ENWW External panels and covers 271
Internal components
Figure 7-5 Internal components (1 of 5)
272 Chapter 7 Parts and diagrams ENWW
ENWW
34
39
40
43
29
30
31
33
Table 7-7 Internal components (1 of 5)
14
15
16
18
9
10
12
13
6
7
4
5
2
3
Ref
1
20
21
23
24
25
26
26A
Description
Holder, fan
Duct, fan
Lever lock, left
Spring, tension
Lever, lock slide, left
Lever, lock slide, right
Cam, slide, right
Lever, lock, left upper
Cover, slide plate, right
Spring, grounding
Fan
Lever, lock, right
Spring, grounding
Spring, tension
Guide, cartridge, left
Gear, 58T
Bushing
Gear, 29T
Cartridge, guide, right assembly
RC1–6571-000CN
RC1-6573-000CN
RC1-6575-000CN
RM1-2771-000CN
Contact-holder assembly RM1-2683-000CN
Media-sensor cassette assembly (HP CLJ 3600/3800/CP3505) RM1-2756-000CN
Cable, media sensor cassette assembly (HP CLJ 3600/3800/
CP3505)
RM1-2589-000CN
Guide, duplexing external (duplex models)
Cover, guide crossmember
Spring, tension
Latch, left
Latch, right
Duct, 2
Duct, 3
Cable, panel
RC1-6744-000CN
RC1-6795-000CN
RC1-7552-000CN
RC1-7554-000CN
RC1-7555-000CN
RC1-7547-000CN
RC1-7548-000CN
RM1-2596-000CN
Part number
RC1-6631-000CN
RC1-6632-000CN
RC1-6633-000CN
RC1-6634-000CN
RC1-6636-000CN
RC1-6643-000CN
RC1-6645-000CN
RC1-7618-000CN
RC1-6824-000CN
RC1-7583-000CN
RK2-0954-000CN
RC1-6640-000CN
RC1-6641-000CN
RC1-6677-000CN
RC1-6629-000CN
4
1
4
4
1
1
1
1
1
1
4
1
1
3
Qty
1
1
1
1
4
1
4
4
1
1
1
1
2
1
1
1
Internal components 273
Figure 7-6 Internal components (2 of 5)
274 Chapter 7 Parts and diagrams ENWW
ENWW
26
27
29
30
Table 7-8 Internal components (2 of 5)
17
18
19
20
13
14
15
16
20
21
23
24
9
10
11
12
7
8
Ref
6
25
Description
Cam, gear. 48T
Gear, 41T
Gear, 19T/30T
Gear, 31T
Gear, 17T/41T
Flag, developing estrangement (developing separation)
Cover, crossmember, upper
Guide, cable, right 1
Bushing
Guide, cable, right 3
Guide, cable, right 4
Crossmember, drive side plate
Cover, shutter, left
Holder, toner cartridge
Cable, scanner flat (long (HP CLJ 3000)
Cable, scanner flat (long (HP CLJ 3600/3800/CP3505)
Cable, scanner flat short
Cable, scanner
Drive-motor assembly, print-cartridge (HP CLJ 3600/3800/
CP3505: K, Y, C, M cartridges; HP CLJ 3000: Y, C, M cartridges only)
Drive-motor assembly, print-cartridge (HP CLJ 3000: K cartridge only)
Lever, sensing
Spring, tension
Cable, memory tag
Main drive assembly
Part number
RC1-6584-000CN
RC1-6589-000CN
RC1-6593-000CN
RC1-6594-000CN
RC1-6596-000CN
RC1-6605-000CN
RC1-6668-000CN
RC1-6682-000CN
RC1-6823-000CN
RC1-7544-000CN
RC1-7545-000CN
RC1-7576-000CN
RC1-6651-000CN
RC1-6771-000CN
RK2-0971-000CN
RK2-0966-000CN
RK2-0967-000CN
RM1-2594-000CN
RM1-2689-000CN
RM1-2773-000CN
RC1-7597-000CN
RC1-7598-000CN
RM1-2627-000CN
RM1-2751-000CN
1
1
1
1
1
4
1
1
4
1
1
1
4
1
1
1
1
2
1
1
1
2
1
Qty
4
Internal components 275
Figure 7-7 Internal components (3 of 5)
276 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-9 Internal components (3 of 5)
32
33
34
25
26
28
28A
10
11
16
24
7
8
5
6
2
3
Ref
1
Description
Cover, gear
Guide, cassette front, left
Guide, cassette front, right
Cam, slide, left
Rod, link, left
Rod, link, right
Foot, rear
Holder, ETB, left
Holder, ETB, right
Mount, hinge, left
Cable, duplex docking
Motor, AC 24V, 9W
Cable, sensor
Right-rear base assembly
Cassette sensor PCA
Plate, gear 3
Foot, rubber assembly, front
Plate lock release
Part number
RC1-6405-000CN
RC1-6499-000CN
RC1-6502-000CN
RC1-6638-000CN
RC1-6639-000CN
RC1-6646-000CN
RC1-6650-000CN
RC1-6673-000CN
RC1-6674-000CN
RC1-6684-000CN
RM1-2609-000CN
RK2-0939-000CN
RM1-2603-000CN
RM1-2678-000CN
RM1-2576-000CN
RL1-1069-000CN
RL1-1067-000CN
RC1-6833-000CN
1
1
1
1
1
1
1
1
1
2
1
1
2
1
1
1
1
Qty
1
Internal components 277
Figure 7-8 Internal components (4 of 5)
278 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-10 Internal components (4 of 5)
14
15
16
17
8
9
12
13
6
7
4
5
2
3
Ref
1
17
18
21
23
24
24
Description
Holder, drawer connector
Holder, drawer
Guide, cable, left
Arm, switch-link
Guide, flexible flat cable 1
Guide, flexible flat cable 2
Guard, cable
Bracket, left, rear
Sensor, temperature
Cable, environment sensor
Cable, ETB
Cable, drum motor
Cable, solenoid
Cable, cassette
Cable, drum motor (HP CLJ 3000)
Cable, drum motor (HP CLJ 3600/3800/CP3505)
Cable, paper-full
Fuser cable assembly
Cable, drive power
Scanner assembly (HP CLJ 3000)
Scanner assembly (HP CLJ 3600/3800/CP3505)
Part number
RC1-6652-000CN
RC1-6653-000CN
RC1-6681-000CN
RC1-6700-000CN
RC1-6772-000CN
RC1-6773-000CN
RC1-6825-000CN
RC1-7551-000CN
WP2-5214-000CN
RM1-2595-000CN
RM1-2608-000CN
RM1-2610-000Cn
RM1-2611-000CN
RM1-2613-000CN
RM1-2629-000CN
RM1-2614-000CN
RM1-2628-000CN
RM1-2597-000CN
RM1-2605-000CN
RM1-2952-000CN
RM1-2640-000CN
1
1
1
1
1
1
1
1
1
1
1
1
1
1
Qty
1
1
1
1
1
1
1
Internal components 279
9
See paper-pickup assembly
Figure 7-9 Internal components (5 of 5)
280 Chapter 7 Parts and diagrams ENWW
Table 7-11 Internal components (5 of 5)
16
17
18
19
10
11
12
14
9
9
4
5
2
3
Ref
1
Description
Cover, rear
Cover
Cable, drive flat 1
Cable, drive flat 2
Duct 1
Relay, PCA (HP CLJ 3000 only)
Relay, PCA (HP CLJ 3600/3800/CP3505 only)
Cable, panel connecting
Cable, power control
Cable, clamp
Multipurpose tray paper-pickup gear assembly
Shield, PCA
Cover, connector
Cover, paper sensor
Cover, registration sensor
Part number
RC1-6627-000CN
RC1-7577-000CN
RK2-0969-000CN
RK2-0970-000CN
RC1-7546-000CN
RM1-2582-000CN
RM1-2632-000CN
RM1-2587-000CN
RM1-2592-000CN
WT2-5944-000CN
RM1-2704-000CN
RC1-7599-000CN
RC1-6607-000CN
RC1-6611-000CN
RC1-6612-000CN
1
1
1
1
2
1
1
1
1
1
1
1
1
1
Qty
1
ENWW Internal components 281
Paper-pickup drive assembly
Figure 7-10 Paper-pickup drive assembly
282 Chapter 7 Parts and diagrams ENWW
Table 7-12 Paper-pickup drive assembly
Ref
All
Description
Paper-pickup drive assembly
Part number
RM1-2679-000CN
Qty
1
ENWW Paper-pickup drive assembly 283
Duplexing-feed drive assembly (duplex models)
Figure 7-11 Duplexing-feed drive assembly (duplex models)
284 Chapter 7 Parts and diagrams ENWW
Table 7-13 Duplexing-feed drive assembly (duplex models)
Ref
All
Description
Duplexing-feed drive assembly (duplex models)
Part number
RM1-2720-000CN
Qty
1
ENWW Duplexing-feed drive assembly (duplex models) 285
Duplexing reverse-drive assembly (duplex models)
Figure 7-12 Duplexing reverse-drive assembly (duplex models)
286 Chapter 7 Parts and diagrams ENWW
Table 7-14 Duplexing reverse-drive assembly (duplex models)
1
2
Ref
All
Description
Duplexing reverse-drive assembly (duplex models)
Cable, duplexing (duplex models)
Cable, duplexing sensor (duplex models)
Part number
RM1-2721-000CN
RM1-2616-000CN
RM1-2618-000CN
1
1
Qty
1
ENWW Duplexing reverse-drive assembly (duplex models) 287
Developing separation-drive assembly
Figure 7-13 Developing separation-drive assembly
288 Chapter 7 Parts and diagrams ENWW
Table 7-15 Developing separation-drive assembly
Ref
All
Description
Developing separation (estrangement) drive assembly
Part number
RM1-2687-000CN
Qty
1
ENWW Developing separation-drive assembly 289
Fuser drive assembly
Figure 7-14 Fuser drive assembly
290 Chapter 7 Parts and diagrams ENWW
Table 7-16 Fuser drive assembly
Ref
All
1
Description
Fuser drive assembly
Cable, fuser drive
Part number
RM1-2668-000CN
RM1-2619-000CN
Qty
1
1
ENWW Fuser drive assembly 291
Cassette (tray 2)
Figure 7-15 Cassette (tray 2)
292 Chapter 7 Parts and diagrams ENWW
Table 7-17 Cassette (tray 2)
Ref
All
6
25
NA
Description
Cassette, 250-sheet
Cover, cassette, front
Separation-pad assembly
Lift plate activator
Part number
RM1-2705-000CN
RC1-6491-000CN
RM1-2709-000CN
RC1-6833-020CN
1
1
Qty
1
1
ENWW Cassette (tray 2) 293
Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
Figure 7-16 Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
294 Chapter 7 Parts and diagrams ENWW
Table 7-18 Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
3
4
1
2
Ref
All
Description
Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
Multipurpose tray roller (HP CLJ 3600/3800/CP3505)
Cover, cassette roller assembly (HP CLJ 3600/3800/CP3505)
Cassette
Multipurpose tray separation-pad assembly (HP CLJ
3600/3800/CP3505)
Part number
RM1-2755-000CN
RM1-2741-000CN
RC1-6609-000CN
RM1-2702-000CN
RM1-2699-000CN
1
1
1
1
Qty
1
ENWW Paper-pickup assembly (HP CLJ 3600/3800/CP3505) 295
Paper-pickup assembly (HP CLJ 3000)
Figure 7-17 Paper-pickup assembly (HP CLJ 3000)
296 Chapter 7 Parts and diagrams ENWW
Table 7-19 Paper-pickup assembly (HP CLJ 3000)
9
10
11
12
7
8
Ref
All
18
25
26
Description
Paper-pickup assembly (HP CLJ 3000)
Spring, tension (HP CLJ 3000)
Bushing (HP CLJ 3000)
Bushing (HP CLJ 3000)
Pre-registration rachet (HP CLJ 3000)
Spring, compression (HP CLJ 3000)
Gear, 18T (HP CLJ 3000)
Preregistration-guide assembly (HP CLJ 3000)
Block, Multipurpose path (HP CLJ 3000)
Media sensor case
Part number
RM1-2774-000CN
RC1-6516-000CN
RC1-6517-000CN
RC1-6518-000CN
RC1-6444-000CN
RC1-6520-000CN
RC1-6521-000CN
RM1-2775-000CN
RC1-7959-000CN
RC1-6394-000CN
1
1
1
1
2
1
Qty
1
1
1
ENWW Paper-pickup assembly (HP CLJ 3000) 297
Electronic transfer belt (simplex models)
Figure 7-18 Electronic transfer belt (simplex models)
298 Chapter 7 Parts and diagrams ENWW
Table 7-20 Electronic transfer belt (simplex models)
Ref
All
6
Description
Electronic transfer belt (simplex models)
Motor, DC (ETB) (simplex models)
Part number
RM1-2759-000CN
RK2-0937-000CN
Qty
1
1
ENWW Electronic transfer belt (simplex models) 299
Electronic transfer belt (duplex models)
See electronic transfer belt (simplex models)
Figure 7-19 Electronic transfer belt (duplex models)
300 Chapter 7 Parts and diagrams ENWW
Table 7-21 Electronic transfer belt (duplex models)
Ref
All
Description
Electronic transfer belt (duplex models)
Part number
RM1-2752-000CN
Qty
1
ENWW Electronic transfer belt (duplex models) 301
Multipurpose tray assembly (tray 1)
Figure 7-20 Multipurpose tray assembly (tray 1)
302 Chapter 7 Parts and diagrams ENWW
Table 7-22 Multipurpose tray assembly (tray 1)
Ref
All
Description
Multipurpose tray assembly (tray 1)
Part number
RM1-2711-000CN
Qty
1
ENWW Multipurpose tray assembly (tray 1) 303
Duplex-paper feed assembly (duplex models)
Figure 7-21 Duplex-paper feed assembly (duplex models)
304 Chapter 7 Parts and diagrams ENWW
Table 7-23 Duplex-paper feed assembly (duplex models)
2
3
Ref
1
4
Description
Duplex-paper feed assembly (duplex models)
Position-guide assembly (duplex models)
Lower guide assembly (duplex models)
Duplex-output bin full flag
Part number
RM1-2718-000CN
RM1-2719-000CN
RM1-2722-000CN
RC1-6755-000CN
1
1
Qty
1
1
ENWW Duplex-paper feed assembly (duplex models) 305
Fuser
Figure 7-22 Fuser
306 Chapter 7 Parts and diagrams ENWW
Table 7-24 Fuser
Ref
All
All
Description
Fuser assembly 110V-127V
Fuser assembly 220V-240V
Part number
RM1-2665-000CN
RM1-2743-000CN
Qty
1
1
ENWW Fuser 307
PCAs
Figure 7-23 PCAs
308 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-25 PCAs
4
4
3
3
1
2
Ref
1
5
6
7
Description
DC controller PCA assembly (HP CLJ 3000)
DC controller PCA assembly (HP CLJ 3600/3800/CP3505)
High-voltage PCA assembly
Low-voltage power PCA assembly (110V-127V)
Low-voltage power PCA assembly (220V-240V)
Control panel-assembly (HP CLJ 3000)
Control-panel assembly (HP CLJ 3600/3800/CP3505)
Driver PCA
Cartridge-sensor PCA
Duplexing PCA assembly (duplex models)
Formatter, new, HP Color LaserJet 3000 and 3000n Series only (128 MB)
Formatter, exchange, HP Color LaserJet 3000 and 3000n
Series only (128 MB)
Formatter, new, HP Color LaserJet 3000dn and 3000dtn
Series only (256 MB)
Formatter, exchange, HP Color LaserJet 3000dn and 3000dtn
Series only (256 MB)
Formatter, new, HP Color LaserJet 3800 and 3800n printers only (128 MB)
Q5982-69001
Q5982-67908
Q5982-69002
Q5982-67907
Formatter, exchange, HP Color LaserJet 3800 and 3800n printers only (128 MB)
Formatter, new, HP Color LaserJet 3800dn and 3800dtn printers only (256 MB)
Q5982-69001
Q5982-67908
Formatter, exchange, HP Color LaserJet 3800dn and 3800dtn printers only (256 MB)
Formatter, new, HP Color LaserJet CP3505
Formatter, exchange, HP Color LaserJet CP3505
I controller (formatter), HP Color LaserJet 3600 Series only Q5987-67901
Firmware, Compact Flash, HP Color LaserJet 3000 Series only Q7725-67903
Firmware, Compact Flash, HP Color LaserJet 3600/3800/
CP3505 Series only
DIMM, 64 MB DDR SDRAM, HP Color LaserJet 3600 Series only
Q5982-69002
CB441-67901
CB441-69001
Q7725-67902
Q7800-67951
Part number
RM1-2600-000CN
RM1-2580-000CN
RM1-2578-000CN
RM1-4377-000CN
RM1-4378-000CN
RK2-0996-000CN
RK2-0989-000CN
RM1-2581-000CN
RM1-2585-000CN
RM1-2584-000CN
Q5982-67907
NOTE:
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
Qty
1
1
1
1
1
PCAs 309
500-sheet feeder cassette (tray 3)
Figure 7-24 500-sheet feeder cassette (tray 3)
310 Chapter 7 Parts and diagrams ENWW
All
14
25
Table 7-26 500-sheet feeder cassette (tray 3)
Ref Description
500–sheet feeder and cassette
500–sheet cassette (only), tray 3
Cover, 500-sheet cassette
Separation-pad-holder assembly (500-sheet feeder)
Part number
Q5985–67901
RM1-2732-000CN
RC1-6945-000CN
RM1-2735-000CN
1
1
Qty
1
ENWW 500-sheet feeder cassette (tray 3) 311
500-sheet feeder paper-pickup assembly
20
Figure 7-25 500-sheet feeder paper-pickup assembly
312 Chapter 7 Parts and diagrams ENWW
Table 7-27 500-sheet feeder paper-pickup assembly
Ref
All
20
21
22
22A
23
Description
500-sheet feeder paper-pickup assembly
Photointerruptor
Cable, option sensor
Sensor, media assembly
Cable, option media sensor (500-sheet feeder)
Paper-pickup-roller assembly (500-sheet feeder)
Part number
RM1-2725-000CN
WG8-5696-000CN
RM1-2625-000CN
RM1-2757-000CN
RM1-2624-000CN
RM1–2727–000CN
1
1
1
1
1
Qty
1
ENWW 500-sheet feeder paper-pickup assembly 313
500-sheet feeder PCA
1
Figure 7-26 500-sheet feeder PCA
314 Chapter 7 Parts and diagrams ENWW
Table 7-28 500-sheet feeder PCA
Ref
1
Description
PCA assembly (500-sheet feeder)
Part number
RM1-2583-000CN
Qty
1
ENWW 500-sheet feeder PCA 315
Alphabetical parts list
Table 7-29 Alphabetical parts list
Description
500-sheet feeder paper-pickup assembly
500–sheet cassette (only), tray 3
500–sheet feeder and cassette
Arm, switch-link
Block, Multipurpose path (HP CLJ 3000)
Bracket, left, rear
Bushing
Bushing
Bushing (HP CLJ 3000)
Bushing (HP CLJ 3000)
Cable, cassette
Cable, clamp
Cable, drive flat 1
Cable, drive flat 2
Cable, drive power
Cable, drum motor
Cable, drum motor (HP CLJ 3000)
Cable, drum motor (HP CLJ 3600/3800/CP3505)
Cable, duplex docking
Cable, duplexing (duplex models)
316 Chapter 7 Parts and diagrams
Part number
RM1-2725-000CN
RM1-2732-000CN
Q5985–67901
RC1-6700-000CN
RC1-7959-000CN
RC1-7551-000CN
RC1-6573-000CN
RC1-6823-000CN
RC1-6517-000CN
RC1-6518-000CN
RM1-2613-000CN
WT2-5944-000CN
RK2-0969-000CN
RK2-0970-000CN
RM1-2605-000CN
RM1-2610-000Cn
RM1-2629-000CN
RM1-2614-000CN
RM1-2609-000CN
RM1-2617-000CN
Table and page
500-sheet feeder paperpickup assembly on page 313
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (4 of 5) on page 279
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (3 of 5) on page 277
ENWW
ENWW
Table 7-29 Alphabetical parts list (continued)
Description
Cable, duplexing (duplex models)
Part number
RM1-2616-000CN
RM1-2618-000CN Cable, duplexing sensor (duplex models)
Cable, environment sensor
Cable, ETB
RM1-2595-000CN
RM1-2608-000CN
Cable, fuser drive RM1-2619-000CN
Cable, media sensor cassette assembly (HP CLJ 3600/3800/
CP3505)
Cable, memory tag
RM1-2589-000CN
RM1-2627-000CN
Cable, option media sensor (500-sheet feeder)
Cable, option sensor
Cable, panel
Cable, panel connecting
Cable, paper-full
Cable, paper-full (duplex models)
Cable, paper-full (simplex models)
Cable, power control
Cable, scanner
Cable, scanner flat (long (HP CLJ 3000)
Cable, scanner flat (long (HP CLJ 3600/3800/CP3505)
Cable, scanner flat short
Cable, sensor
Cable, solenoid
RK2-0971-000CN
RK2-0966-000CN
RK2-0967-000CN
RM1-2603-000CN
RM1-2611-000CN
RM1-2624-000CN
RM1-2625-000CN
RM1-2596-000CN
RM1-2587-000CN
RM1-2628-000CN
RM1-2620-000CN
RM1-2630-000CN
RM1-2592-000CN
RM1-2594-000CN
Table and page
Duplexing reverse-drive assembly (duplex models) on page 287
Duplexing reverse-drive assembly (duplex models) on page 287
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Fuser drive assembly on page 291
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
500-sheet feeder paperpickup assembly on page 313
500-sheet feeder paperpickup assembly on page 313
Internal components (1 of 5) on page 273
Internal components (5 of 5) on page 281
Internal components (4 of 5) on page 279
Internal components (5 of 5) on page 281
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (3 of 5) on page 277
Internal components (4 of 5) on page 279
Alphabetical parts list 317
Table 7-29 Alphabetical parts list (continued)
Description
Cam, gear. 48T
Cam, slide, left
Cam, slide, right
Cartridge, guide, right assembly
Cartridge-sensor PCA
Cassette
Part number
RC1-6584-000CN
RC1-6638-000CN
RC1-6645-000CN
RM1-2771-000CN
RM1-2585-000CN
RM1-2702-000CN
Cassette sensor PCA
Cassette, 250-sheet
Connector, snap-tight (simplex models)
Contact-holder assembly
Control panel-assembly (HP CLJ 3000)
Control-panel assembly (HP CLJ 3600/3800/CP3505)
Cover
Cover, 500-sheet cassette
RM1-2576-000CN
RM1-2705-000CN
VS1-7207-003CN
RM1-2683-000CN
RK2-0996-000CN
RK2-0989-000CN
RC1-7577-000CN
RC1-6945-000CN
Cover, cassette rear left
Cover, cassette rear right (hinge)
RC1-6792-000CN
RC1-6691-000CN
Cover, cassette roller assembly (HP CLJ 3600/3800/CP3505) RC1-6609-000CN
Cover, cassette, front
Cover, connector
Cover, crossmember, upper
Cover, gear
Cover, guide crossmember
Cover, left
RC1-6491-000CN
RC1-6607-000CN
RC1-6668-000CN
RC1-6405-000CN
RC1-6795-000CN
RC1-6687-000CN
Table and page
Internal components (2 of 5) on page 275
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
(HP CLJ 3600/3800/CP3505) on page 295
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
Internal components (5 of 5) on page 281
External panels and covers (1 of 2) on page 265
External panels and covers (1 of 2) on page 265
(HP CLJ 3600/3800/CP3505) on page 295
Internal components (5 of 5) on page 281
Internal components (2 of 5) on page 275
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
External panels and covers (1 of 2) on page 265
318 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-29 Alphabetical parts list (continued)
Description
Cover, multipurpose tray (tray 1)
Cover, paper sensor
Cover, rear
Cover, rear lower
Cover, registration sensor
Cover, right
Cover, shutter, left
Cover, slide plate, right
Crossmember, drive side plate
DC controller PCA assembly (HP CLJ 3000)
DC controller PCA assembly (HP CLJ 3600/3800/CP3505)
Developing separation (estrangement) drive assembly
DIMM, 64 MB DDR SDRAM, HP Color LaserJet 3600 Series only
Drive-motor assembly, print-cartridge (HP CLJ 3000: K cartridge only)
Drive-motor assembly, print-cartridge (HP CLJ 3600/3800/
CP3505: K, Y, C, M cartridges; HP CLJ 3000: Y, C, M cartridges only)
Driver PCA
Duct 1
Duct, 2
Duct, 3
Duct, fan
Duplex page, duplex flag
Duplex-output bin full flag
Duplex-paper feed assembly (duplex models)
Part number
RC1-6690-000CN
RC1-6611-000CN
RC1-6627-000CN
RC1-7550-000CN
RC1-6612-000CN
RM1–2669–000CN
RC1-6651-000CN
RC1-6824-000CN
RC1-7576-000CN
RM1-2600-000CN
RM1-2580-000CN
RM1-2687-000CN
Q7800-67951
RM1-2773-000CN
RM1-2689-000CN
RM1-2581-000CN
RC1-7546-000CN
RC1-7547-000CN
RC1-7548-000CN
RC1-6632-000CN
RC1-6755-000CN
RC1-6755-000CN
RM1-2718-000CN
Table and page
External panels and covers (1 of 2) on page 265
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
External panels and covers (1 of 2) on page 265
Internal components (5 of 5) on page 281
External panels and covers (1 of 2) on page 265
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Developing separation-drive assembly on page 289
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (5 of 5) on page 281
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Alphabetical parts list 319
Table 7-29 Alphabetical parts list (continued)
Description
Duplexing PCA assembly (duplex models)
Duplexing reverse-drive assembly (duplex models)
Part number
RM1-2584-000CN
RM1-2721-000CN
Duplexing-feed drive assembly (duplex models) RM1-2720-000CN
Electronic transfer belt (duplex models)
Electronic transfer belt (simplex models)
Face-down tray assembly (HP CLJ 3000)
Face-down tray assembly (HP CLJ 3600/3800/CP3505)
Fan
RM1-2752-000CN
RM1-2759-000CN
RM1-2777-020CN
RM1-2750-020CN
RK2-0954-000CN
Fan (duplex models) RK2-0954-000CN
Firmware, Compact Flash, HP Color LaserJet 3000 Series only Q7725-67903
Firmware, Compact Flash, HP Color LaserJet 3600/3800/
CP3505 Series only
Flag, developing estrangement (developing separation)
Q7725-67902
RC1-6605-000CN
Foot, rear
Foot, rubber assembly, front
RC1-6650-000CN
RL1-1067-000CN
Formatter, exchange, HP Color LaserJet 3000 and 3000n
Series only (128 MB)
Formatter, exchange, HP Color LaserJet 3000dn and 3000dtn
Series only (256 MB)
Formatter, exchange, HP Color LaserJet 3800 and 3800n printers only (128 MB)
Formatter, exchange, HP Color LaserJet 3800dn and 3800dtn printers only (256 MB)
Formatter, exchange, HP Color LaserJet CP3505
Formatter, new, HP Color LaserJet 3000 and 3000n Series only (128 MB)
Formatter, new, HP Color LaserJet 3000dn and 3000dtn Series only (256 MB)
Formatter, new, HP Color LaserJet 3800 and 3800n printers only (128 MB)
Q5982-69001
Q5982-69002
Q5982-69001
Q5982-69002
CB441-69001
Q5982-67907
Q5982-67908
Q5982-67907
Table and page
Duplexing reverse-drive assembly (duplex models) on page 287
Duplexing-feed drive assembly (duplex models) on page 285
Internal components (1 of 5) on page 273
Front-cover assembly (duplex model) on page 271
Internal components (2 of 5) on page 275
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
320 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-29 Alphabetical parts list (continued)
Description
Formatter, new, HP Color LaserJet 3800dn and 3800dtn printers only (256 MB)
Formatter, new, HP Color LaserJet CP3505
Front-cover assembly (duplex models)
Front-cover assembly (simplex models)
Fuser assembly 110V-127V
Fuser assembly 220V-240V
Fuser cable assembly
Fuser drive assembly
Gear, 17T/41T
Gear, 18T (HP CLJ 3000)
Gear, 19T/30T
Gear, 29T
Gear, 31T
Gear, 41T
Gear, 58T
Guard, cable
Guide, cable, left
Guide, cable, right 1
Guide, cable, right 3
Guide, cable, right 4
Guide, cartridge, left
Guide, cassette front, left
Guide, cassette front, right
Part number
Q5982-67908
CB441-67901
RM1-2715-000CN
RM1-2673-000CN
RM1-2665-000CN
RM1-2743-000CN
RM1-2597-000CN
RM1-2668-000CN
RC1-6596-000CN
RC1-6521-000CN
RC1-6593-000CN
RC1-6575-000CN
RC1-6594-000CN
RC1-6589-000CN
RC1–6571-000CN
RC1-6825-000CN
RC1-6681-000CN
RC1-6682-000CN
RC1-7544-000CN
RC1-7545-000CN
RC1-6629-000CN
RC1-6499-000CN
RC1-6502-000CN
Table and page
Front-cover assembly (duplex model) on page 271
Internal components (4 of 5) on page 279
Fuser drive assembly on page 291
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Alphabetical parts list 321
Table 7-29 Alphabetical parts list (continued)
Description
Guide, duplexing external (duplex models)
Guide, flexible flat cable 1
Guide, flexible flat cable 2
High-voltage PCA assembly
Holder, drawer
Holder, drawer connector
Holder, ETB, left
Holder, ETB, right
Holder, fan
Holder, toner cartridge
I controller (formatter), HP Color LaserJet 3600 Series only
Interlock-switch assembly
Latch, left
Latch, right
Lever lock, left
Lever, lock slide, left
Lever, lock slide, right
Lever, lock, left upper
Lever, lock, right
Lever, sensing
Lift plate activator
Link, multipurpose tray (tray 1) hinge left
Link, multipurpose tray (tray 1) hinge right
Part number
RC1-6744-000CN
RC1-6772-000CN
RC1-6773-000CN
RM1-2578-000CN
RC1-6653-000CN
RC1-6652-000CN
RC1-6673-000CN
RC1-6674-000CN
RC1-6631-000CN
RC1-6771-000CN
Q5987-67901
RM1-2670-000CN
RC1-7554-000CN
RC1-7555-000CN
RC1-6633-000CN
RC1-6636-000CN
RC1-6643-000CN
RC1-7618-000CN
RC1-6640-000CN
RC1-7597-000CN
RC1-6833-020CN
RC1-6381-000CN
RC1-6382-000CN
Table and page
Internal components (1 of 5) on page 273
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
External panels and covers (1 of 2) on page 265
External panels and covers (1 of 2) on page 265
322 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-29 Alphabetical parts list (continued)
Description
Low-voltage power PCA assembly (110V-127V)
Low-voltage power PCA assembly (220V-240V)
Lower guide assembly (duplex models)
Main drive assembly
Part number
RM1-4377-000CN
RM1-4378-000CN
RM1-2722-000CN
RM1-2751-000CN
Media sensor case RC1-6394-000CN
Media-sensor cassette assembly (HP CLJ 3600/3800/CP3505) RM1-2756-000CN
Motor, AC 24V, 9W
Motor, DC (ETB) (simplex models)
RK2-0939-000CN
RK2-0937-000CN
Mount, hinge, left
Multipurpose tray (tray 1) extension tray assembly
Multipurpose tray assembly (tray 1)
Multipurpose tray paper-pickup gear assembly
Multipurpose tray roller (HP CLJ 3600/3800/CP3505)
RC1-6684-000CN
RM1-2710-000CN
RM1-2711-000CN
RM1-2704-000CN
RM1-2741-000CN
Multipurpose tray separation-pad assembly (HP CLJ
3600/3800/CP3505)
Paper-pickup assembly (HP CLJ 3000)
Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
Paper-pickup drive assembly
Paper-pickup-roller assembly (500-sheet feeder)
PCA assembly (500-sheet feeder)
Photointerruptor
Plate lock release
RM1-2699-000CN
RM1-2774-000CN
RM1-2755-000CN
RM1-2679-000CN
RM1–2727–000CN
RM1-2583-000CN
WG8-5696-000CN
RC1-6833-000CN
Table and page
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
External panels and covers (1 of 2) on page 265
Internal components (5 of 5) on page 281
(HP CLJ 3600/3800/CP3505) on page 295
(HP CLJ 3600/3800/CP3505) on page 295
(HP CLJ 3600/3800/CP3505) on page 295
Paper-pickup drive assembly on page 283
500-sheet feeder paperpickup assembly on page 313
500-sheet feeder PCA on page 315
500-sheet feeder paperpickup assembly on page 313
Internal components (3 of 5) on page 277
Alphabetical parts list 323
Table 7-29 Alphabetical parts list (continued)
Description
Plate, gear 3
Position-guide assembly (duplex models)
Pre-registration rachet (HP CLJ 3000)
Preregistration-guide assembly (HP CLJ 3000)
Relay, PCA (HP CLJ 3000 only)
Relay, PCA (HP CLJ 3600/3800/CP3505 only)
Right-rear base assembly
Rod, link, left
Rod, link, right
Scanner assembly (HP CLJ 3000)
Scanner assembly (HP CLJ 3600/3800/CP3505)
Sensor, media assembly
Sensor, temperature
Separation-pad assembly
Separation-pad-holder assembly (500-sheet feeder)
Shield, PCA
Simplex page-delivery flay
Spring, compression (HP CLJ 3000)
Spring, grounding
Spring, grounding
Spring, tension
Spring, tension
RC1-6646-000CN
RM1-2952-000CN
RM1-2640-000CN
RM1-2757-000CN
WP2-5214-000CN
RM1-2709-000CN
RM1-2735-000CN
RC1-7599-000CN
RC1-6286-000CN
RC1-6520-000CN
RC1-7583-000CN
RC1-6641-000CN
RC1-6383-000CN
RC1-6634-000CN
Part number
RL1-1069-000CN
RM1-2719-000CN
RC1-6444-000CN
RM1-2775-000CN
RM1-2582-000CN
RM1-2632-000CN
RM1-2678-000CN
RC1-6639-000CN
Table and page
Internal components (3 of 5) on page 277
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
500-sheet feeder paperpickup assembly on page 313
Internal components (4 of 5) on page 279
Internal components (5 of 5) on page 281
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
External panels and covers (1 of 2) on page 265
Internal components (1 of 5) on page 273
324 Chapter 7 Parts and diagrams ENWW
Table 7-29 Alphabetical parts list (continued)
Description
Spring, tension
Spring, tension
Spring, tension
Spring, tension (HP CLJ 3000)
Top-cover assembly (duplex models)
Top-cover assembly (simplex models)
Torsion spring
Upper cover assembly (fuser door) (duplex models)
Upper cover assembly (fuser door) (simplex models)
Part number
RC1-6677-000CN
RC1-7552-000CN
RC1-7598-000CN
RC1-6516-000CN
RM1-2713-020CN
RM1-2672-030CN
RC1-7628-000CN
RM1-2714-000CN
RM1-2671-000CN
Table and page
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
ENWW Alphabetical parts list 325
Numerical parts list
Table 7-30 Numerical parts list
Part number Description
CB441-67901
CB441-69001
Q5982-67907
Q5982-67907
Q5982-67908
Q5982-67908
Q5982-69001
Q5982-69001
Q5982-69002
Q5982-69002
Q5985–67901
Q5987-67901
Q7725-67902
Q7725-67903
Q7800-67951
RC1-6286-000CN
RC1-6381-000CN
RC1-6382-000CN
RC1-6383-000CN
RC1-6394-000CN
RC1-6405-000CN
RC1-6444-000CN
Table and page
Formatter, new, HP Color LaserJet CP3505
Formatter, exchange, HP Color LaserJet CP3505
Formatter, new, HP Color LaserJet 3000 and 3000n Series only (128 MB)
Formatter, new, HP Color LaserJet 3800 and 3800n printers only (128 MB)
Formatter, new, HP Color LaserJet 3000dn and 3000dtn Series only (256 MB)
Formatter, new, HP Color LaserJet 3800dn and 3800dtn printers only (256 MB)
Formatter, exchange, HP Color LaserJet 3000 and 3000n
Series only (128 MB)
Formatter, exchange, HP Color LaserJet 3800 and 3800n printers only (128 MB)
Formatter, exchange, HP Color LaserJet 3000dn and 3000dtn
Series only (256 MB)
Formatter, exchange, HP Color LaserJet 3800dn and 3800dtn printers only (256 MB)
500–sheet feeder and cassette
I controller (formatter), HP Color LaserJet 3600 Series only
Firmware, Compact Flash, HP Color LaserJet 3600/3800/
CP3505 Series only
Firmware, Compact Flash, HP Color LaserJet 3000 Series only
DIMM, 64 MB DDR SDRAM, HP Color LaserJet 3600 Series only
Simplex page-delivery flay
Link, multipurpose tray (tray 1) hinge left
External panels and covers (1 of 2) on page 265
Link, multipurpose tray (tray 1) hinge right
Spring, tension
Media sensor case
Cover, gear
Pre-registration rachet (HP CLJ 3000)
External panels and covers (1 of 2) on page 265
External panels and covers (1 of 2) on page 265
Internal components (3 of 5) on page 277
326 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-30 Numerical parts list (continued)
Part number
RC1-6491-000CN
RC1-6499-000CN
RC1-6502-000CN
RC1-6516-000CN
RC1-6517-000CN
RC1-6518-000CN
RC1-6520-000CN
RC1-6521-000CN
RC1-6573-000CN
RC1-6575-000CN
RC1-6584-000CN
RC1-6589-000CN
RC1-6593-000CN
RC1-6594-000CN
RC1-6596-000CN
RC1-6605-000CN
RC1-6607-000CN
RC1-6609-000CN
RC1-6611-000CN
RC1-6612-000CN
RC1-6627-000CN
RC1-6629-000CN
Description
Cover, cassette, front
Guide, cassette front, left
Guide, cassette front, right
Spring, tension (HP CLJ 3000)
Bushing (HP CLJ 3000)
Bushing (HP CLJ 3000)
Spring, compression (HP CLJ 3000)
Gear, 18T (HP CLJ 3000)
Bushing
Gear, 29T
Cam, gear. 48T
Gear, 41T
Gear, 19T/30T
Gear, 31T
Gear, 17T/41T
Flag, developing estrangement (developing separation)
Cover, connector
Cover, cassette roller assembly (HP CLJ 3600/3800/CP3505)
Cover, paper sensor
Cover, registration sensor
Cover, rear
Guide, cartridge, left
Table and page
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (5 of 5) on page 281
(HP CLJ 3600/3800/CP3505) on page 295
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
Internal components (1 of 5) on page 273
Numerical parts list 327
Table 7-30 Numerical parts list (continued)
Part number Description
RC1-6631-000CN Holder, fan
RC1-6632-000CN
RC1-6633-000CN
RC1-6634-000CN
RC1-6636-000CN
RC1-6638-000CN
RC1-6639-000CN
RC1-6640-000CN
RC1-6641-000CN
RC1-6643-000CN
RC1-6645-000CN
RC1-6646-000CN
RC1-6650-000CN
RC1-6651-000CN
RC1-6652-000CN
RC1-6653-000CN
RC1-6668-000CN
RC1-6673-000CN
RC1-6674-000CN
RC1-6677-000CN
RC1-6681-000CN
RC1-6682-000CN
Duct, fan
Lever lock, left
Spring, tension
Lever, lock slide, left
Cam, slide, left
Rod, link, left
Lever, lock, right
Spring, grounding
Lever, lock slide, right
Cam, slide, right
Rod, link, right
Foot, rear
Cover, shutter, left
Holder, drawer connector
Holder, drawer
Cover, crossmember, upper
Holder, ETB, left
Holder, ETB, right
Spring, tension
Guide, cable, left
Guide, cable, right 1
328 Chapter 7 Parts and diagrams
Table and page
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (2 of 5) on page 275
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (2 of 5) on page 275
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (1 of 5) on page 273
Internal components (4 of 5) on page 279
Internal components (2 of 5) on page 275
ENWW
ENWW
Table 7-30 Numerical parts list (continued)
Part number Description
RC1-6684-000CN Mount, hinge, left
RC1-6687-000CN
RC1-6690-000CN
RC1-6691-000CN
RC1-6700-000CN
RC1-6744-000CN
RC1-6755-000CN
RC1-6755-000CN
RC1-6771-000CN
RC1-6772-000CN
RC1-6773-000CN
RC1-6792-000CN
RC1-6795-000CN
RC1-6823-000CN
RC1-6824-000CN
RC1-6825-000CN
RC1-6833-000CN
RC1-6833-020CN
RC1-6945-000CN
RC1-7544-000CN
RC1-7545-000CN
RC1-7546-000CN
Cover, left
Cover, multipurpose tray (tray 1)
Cover, cassette rear right (hinge)
Arm, switch-link
Guide, duplexing external (duplex models)
Duplex page, duplex flag
Duplex-output bin full flag
Holder, toner cartridge
Guide, flexible flat cable 1
Guide, flexible flat cable 2
Cover, cassette rear left
Cover, guide crossmember
Bushing
Cover, slide plate, right
Guard, cable
Plate lock release
Lift plate activator
Cover, 500-sheet cassette
Guide, cable, right 3
Guide, cable, right 4
Duct 1
Table and page
Internal components (3 of 5) on page 277
External panels and covers (1 of 2) on page 265
External panels and covers (1 of 2) on page 265
External panels and covers (1 of 2) on page 265
Internal components (4 of 5) on page 279
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
External panels and covers (1 of 2) on page 265
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (1 of 5) on page 273
Internal components (4 of 5) on page 279
Internal components (3 of 5) on page 277
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (5 of 5) on page 281
Numerical parts list 329
Table 7-30 Numerical parts list (continued)
Part number Description
RC1-7547-000CN Duct, 2
RC1-7548-000CN
RC1-7550-000CN
RC1-7551-000CN
RC1-7552-000CN
RC1-7554-000CN
RC1-7555-000CN
RC1-7576-000CN
RC1-7577-000CN
RC1-7583-000CN
RC1-7597-000CN
RC1-7598-000CN
RC1-7599-000CN
RC1-7618-000CN
RC1-7628-000CN
RC1-7959-000CN
RC1–6571-000CN
RK2-0937-000CN
RK2-0939-000CN
RK2-0954-000CN
RK2-0954-000CN
RK2-0966-000CN
Duct, 3
Cover, rear lower
Bracket, left, rear
Spring, tension
Latch, left
Latch, right
Crossmember, drive side plate
Cover
Spring, grounding
Lever, sensing
Spring, tension
Shield, PCA
Lever, lock, left upper
Torsion spring
Block, Multipurpose path (HP CLJ 3000)
Gear, 58T
Motor, DC (ETB) (simplex models)
Motor, AC 24V, 9W
Fan (duplex models)
Fan
Cable, scanner flat (long (HP CLJ 3600/3800/CP3505)
Table and page
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
External panels and covers (1 of 2) on page 265
Internal components (4 of 5) on page 279
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (5 of 5) on page 281
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Internal components (2 of 5) on page 275
Internal components (5 of 5) on page 281
Internal components (1 of 5) on page 273
Internal components (1 of 5) on page 273
Internal components (3 of 5) on page 277
Front-cover assembly (duplex model) on page 271
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
330 Chapter 7 Parts and diagrams ENWW
ENWW
Table 7-30 Numerical parts list (continued)
Part number
RK2-0967-000CN
RK2-0969-000CN
RK2-0970-000CN
RK2-0971-000CN
RK2-0989-000CN
RK2-0996-000CN
RL1-1067-000CN
RL1-1069-000CN
RM1-2576-000CN
RM1-2578-000CN
RM1-2580-000CN
RM1-2581-000CN
RM1-2582-000CN
RM1-2583-000CN
RM1-2584-000CN
RM1-2585-000CN
RM1-2587-000CN
RM1-2589-000CN
RM1-2592-000CN
RM1-2594-000CN
RM1-2595-000CN
RM1-2596-000CN
RM1-2597-000CN
RM1-2600-000CN
RM1-2603-000CN
Description
Cable, scanner flat short
Cable, drive flat 1
Cable, drive flat 2
Cable, scanner flat (long (HP CLJ 3000)
Control-panel assembly (HP CLJ 3600/3800/CP3505)
Control panel-assembly (HP CLJ 3000)
Foot, rubber assembly, front
Plate, gear 3
Cassette sensor PCA
High-voltage PCA assembly
DC controller PCA assembly (HP CLJ 3600/3800/CP3505)
Driver PCA
Relay, PCA (HP CLJ 3000 only)
PCA assembly (500-sheet feeder)
Duplexing PCA assembly (duplex models)
Cartridge-sensor PCA
Cable, panel connecting
Cable, media sensor cassette assembly (HP CLJ 3600/3800/
CP3505)
Cable, power control
Cable, scanner
Cable, environment sensor
Cable, panel
Fuser cable assembly
DC controller PCA assembly (HP CLJ 3000)
Cable, sensor
Table and page
Internal components (2 of 5) on page 275
Internal components (5 of 5) on page 281
Internal components (5 of 5) on page 281
Internal components (2 of 5) on page 275
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (3 of 5) on page 277
Internal components (5 of 5) on page 281
500-sheet feeder PCA on page 315
Internal components (5 of 5) on page 281
Internal components (1 of 5) on page 273
Internal components (5 of 5) on page 281
Internal components (2 of 5) on page 275
Internal components (4 of 5) on page 279
Internal components (1 of 5) on page 273
Internal components (4 of 5) on page 279
Internal components (3 of 5) on page 277
Numerical parts list 331
RM1-2617-000CN
RM1-2618-000CN
RM1-2619-000CN
RM1-2620-000CN
RM1-2624-000CN
RM1-2625-000CN
RM1-2627-000CN
RM1-2628-000CN
RM1-2629-000CN
RM1-2630-000CN
RM1-2632-000CN
RM1-2640-000CN
RM1-2665-000CN
Table 7-30 Numerical parts list (continued)
Part number Description
RM1-2605-000CN Cable, drive power
RM1-2608-000CN
RM1-2609-000CN
RM1-2610-000Cn
RM1-2611-000CN
RM1-2613-000CN
RM1-2614-000CN
RM1-2616-000CN
Cable, ETB
Cable, duplex docking
Cable, drum motor
Cable, solenoid
Cable, cassette
Cable, drum motor (HP CLJ 3600/3800/CP3505)
Cable, duplexing (duplex models)
Cable, duplexing (duplex models)
Cable, duplexing sensor (duplex models)
Cable, fuser drive
Cable, paper-full (duplex models)
Cable, option media sensor (500-sheet feeder)
Cable, option sensor
Cable, memory tag
Cable, paper-full
Cable, drum motor (HP CLJ 3000)
Cable, paper-full (simplex models)
Relay, PCA (HP CLJ 3600/3800/CP3505 only)
Scanner assembly (HP CLJ 3600/3800/CP3505)
Fuser assembly 110V-127V
332 Chapter 7 Parts and diagrams
Table and page
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (3 of 5) on page 277
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Duplexing reverse-drive assembly (duplex models) on page 287
Duplexing reverse-drive assembly (duplex models) on page 287
Fuser drive assembly on page 291
500-sheet feeder paperpickup assembly on page 313
500-sheet feeder paperpickup assembly on page 313
Internal components (2 of 5) on page 275
Internal components (4 of 5) on page 279
Internal components (4 of 5) on page 279
Internal components (5 of 5) on page 281
Internal components (4 of 5) on page 279
ENWW
ENWW
Table 7-30 Numerical parts list (continued)
Part number Description
RM1-2668-000CN Fuser drive assembly
RM1-2670-000CN
RM1-2671-000CN
RM1-2672-030CN
RM1-2673-000CN
RM1-2678-000CN
RM1-2679-000CN
RM1-2683-000CN
RM1-2687-000CN
RM1-2689-000CN
RM1-2699-000CN
RM1-2702-000CN
Interlock-switch assembly
Upper cover assembly (fuser door) (simplex models)
Top-cover assembly (simplex models)
Front-cover assembly (simplex models)
Right-rear base assembly
Paper-pickup drive assembly
Contact-holder assembly
Developing separation (estrangement) drive assembly
Drive-motor assembly, print-cartridge (HP CLJ 3600/3800/
CP3505: K, Y, C, M cartridges; HP CLJ 3000: Y, C, M cartridges only)
Multipurpose tray separation-pad assembly (HP CLJ
3600/3800/CP3505)
Cassette
RM1-2704-000CN
RM1-2705-000CN
RM1-2709-000CN
RM1-2710-000CN
RM1-2711-000CN
RM1-2713-020CN
RM1-2714-000CN
RM1-2715-000CN
RM1-2718-000CN
Multipurpose tray paper-pickup gear assembly
Cassette, 250-sheet
Separation-pad assembly
Multipurpose tray (tray 1) extension tray assembly
Multipurpose tray assembly (tray 1)
Top-cover assembly (duplex models)
Upper cover assembly (fuser door) (duplex models)
Front-cover assembly (duplex models)
Duplex-paper feed assembly (duplex models)
Table and page
Fuser drive assembly on page 291
Internal components (3 of 5) on page 277
Paper-pickup drive assembly on page 283
Internal components (1 of 5) on page 273
Developing separation-drive assembly on page 289
Internal components (2 of 5) on page 275
(HP CLJ 3600/3800/CP3505) on page 295
(HP CLJ 3600/3800/CP3505) on page 295
Internal components (5 of 5) on page 281
External panels and covers (1 of 2) on page 265
Front-cover assembly (duplex model) on page 271
Numerical parts list 333
Table 7-30 Numerical parts list (continued)
Part number
RM1-2719-000CN
RM1-2720-000CN
RM1-2721-000CN
RM1-2722-000CN
RM1-2725-000CN
RM1-2732-000CN
RM1-2735-000CN
RM1-2741-000CN
RM1-2743-000CN
RM1-2750-020CN
RM1-2751-000CN
RM1-2752-000CN
RM1-2755-000CN
RM1-2756-000CN
RM1-2757-000CN
RM1-2759-000CN
RM1-2771-000CN
RM1-2773-000CN
RM1-2774-000CN
RM1-2775-000CN
RM1-2777-020CN
Description Table and page
Position-guide assembly (duplex models)
Duplexing-feed drive assembly (duplex models)
Duplexing reverse-drive assembly (duplex models)
Lower guide assembly (duplex models)
500-sheet feeder paper-pickup assembly
500–sheet cassette (only), tray 3
Separation-pad-holder assembly (500-sheet feeder)
Multipurpose tray roller (HP CLJ 3600/3800/CP3505)
Fuser assembly 220V-240V
Face-down tray assembly (HP CLJ 3600/3800/CP3505)
Duplexing-feed drive assembly (duplex models) on page 285
Duplexing reverse-drive assembly (duplex models) on page 287
500-sheet feeder paperpickup assembly on page 313
(HP CLJ 3600/3800/CP3505) on page 295
Main drive assembly
Electronic transfer belt (duplex models)
Paper-pickup assembly (HP CLJ 3600/3800/CP3505)
Internal components (2 of 5) on page 275
(HP CLJ 3600/3800/CP3505) on page 295
Media-sensor cassette assembly (HP CLJ 3600/3800/CP3505)
Internal components (1 of 5) on page 273
Sensor, media assembly
Electronic transfer belt (simplex models)
500-sheet feeder paperpickup assembly on page 313
Cartridge, guide, right assembly
Drive-motor assembly, print-cartridge (HP CLJ 3000: K cartridge only)
Paper-pickup assembly (HP CLJ 3000)
Internal components (1 of 5) on page 273
Internal components (2 of 5) on page 275
Preregistration-guide assembly (HP CLJ 3000)
Face-down tray assembly (HP CLJ 3000)
334 Chapter 7 Parts and diagrams ENWW
Table 7-30 Numerical parts list (continued)
Part number Description
RM1-2952-000CN Scanner assembly (HP CLJ 3000)
RM1-4377-000CN
RM1-4378-000CN
RM1–2669–000CN
RM1–2727–000CN
VS1-7207-003CN
WG8-5696-000CN
WP2-5214-000CN
WT2-5944-000CN
Low-voltage power PCA assembly (110V-127V)
Low-voltage power PCA assembly (220V-240V)
Cover, right
Paper-pickup-roller assembly (500-sheet feeder)
Connector, snap-tight (simplex models)
Photointerruptor
Sensor, temperature
Cable, clamp
Table and page
Internal components (4 of 5) on page 279
External panels and covers (1 of 2) on page 265
500-sheet feeder paperpickup assembly on page 313
500-sheet feeder paperpickup assembly on page 313
Internal components (4 of 5) on page 279
Internal components (5 of 5) on page 281
ENWW Numerical parts list 335
336 Chapter 7 Parts and diagrams ENWW
Laadi alla
Avalik link on uuendatud
Teie vestluse avalik link on uuendatud. You may view and manage your chat links after registration here.
Dokumendi avalik link
Reklaam