Drive Medical Scout 3-wheel, 4-wheel electric scooter Owner’s Handbook
Below you will find brief information for Scout 3-wheel, Scout 4-wheel. The Scout is a user-friendly electric scooter designed for easy maneuverability. This scooter is ideal for indoor or outdoor use on smooth surfaces, like shopping centers, smooth paths, etc. It can be easily folded and disassembled.
Advertisement
Advertisement
Scout Electric Scooter Page 1 of 16 Owner’s Handbook (Code: MS008_IFU 08/13)
QUICK REFERENCE GUIDE
Problem: Scooter will not switch on
Symptoms:
Batteries not connected
Circuit breaker has tripped
Rear and front sections not
connected
Remedy:
Check batteries connected
Push circuit breaker to reset
Check connection on front-
to-rear loom
Problem: Scooter will switch on but will not run
Symptoms:
Flat batteries
Charger plugged in
Motor in freewheel mode
Remedy:
Recharge battery
Unplug charger from scooter
Push down freewheel lever
Problem: Scooter appears slow
Symptoms:
Flat batteries
Speed setting slow
Remedy:
Recharge battery
Turn up speed dial
Problem: Seat moves whilst in use
Symptoms:
Seat not locked in position
Remedy:
Slowly rotate the seat until it
drops in place and is secure.
Problem: Tiller appears loose or will not swivel freely
Symptoms:
Tiller adjustment knob loose
Tiller Lock Applied
Remedy:
Tighten tiller adjustment knob
Release Tiller Lock
Problem: Horn sounds involuntarily / automatically
Symptoms:
The scooter has diagnosed a
fault
Remedy:
Ensure the wigwag paddle is
released and switch the
scooter off and on.
Recharge batteries if error
persists.
CONTENTS
1. PREFACE
2. SAFETY NOTICE
2.1 Before Driving
2.2 Whilst Driving
2.3 Labelling
2.4 Electromagnetic Interference
3. PARTS INTRODUCTION
4. OPERATION
4.1 Control Panel
4.2 How to Operate Your Scooter
5. DRIVING ON THE ROAD
6. BATTERY CHARGING AND CARE
7. INSPECTION AND MAINTENANCE
7.1 Daily Checking
7.2 Service Record
7.3 Battery Pack and Tyres
7.4 Cleaning
7.5 Storage
7.6 Moving About
7.7 Disassembling the Scooter for
Transportation
7.8 Assembling the Scooter
8. TROUBLESHOOTING
9. SPECIFICATION
10. WARRANTY
11. APPENDIX: SERVICE RECORD
QUICK REFERENCE GUIDE
Problem: Scooter will not switch on
Symptoms:
Batteries not connected
Circuit breaker has tripped
Rear and front sections not
connected
Remedy:
Check batteries connected
Push circuit breaker to reset
Check connection on front-
to-rear loom
Problem: Scooter will switch on but will not run
Symptoms:
Flat batteries
Charger plugged in
Motor in freewheel mode
Remedy:
Recharge battery
Unplug charger from scooter
Push down freewheel lever
Problem: Scooter appears slow
Symptoms:
Flat batteries
Speed setting slow
Remedy:
Recharge battery
Turn up speed dial
Problem: Seat moves whilst in use
Symptoms:
Seat not locked in position
Remedy:
Slowly rotate the seat until it
drops in place and is secure.
Problem: Tiller appears loose or will not swivel freely
Symptoms:
Tiller adjustment knob loose
Tiller Lock Applied
Remedy:
Tighten tiller adjustment knob
Release Tiller Lock
Problem: Horn sounds involuntarily / automatically
Symptoms:
The scooter has diagnosed a
fault
Remedy:
Ensure the wigwag paddle is
released and switch the
scooter off and on.
Recharge batteries if error
persists.
CONTENTS
1. PREFACE
2. SAFETY NOTICE
2.1 Before Driving
2.2 Whilst Driving
2.3 Labelling
2.4 Electromagnetic Interference
3. PARTS INTRODUCTION
4. OPERATION
4.1 Control Panel
4.2 How to Operate Your Scooter
5. DRIVING ON THE ROAD
6. BATTERY CHARGING AND CARE
7. INSPECTION AND MAINTENANCE
7.1 Daily Checking
7.2 Service Record
7.3 Battery Pack and Tyres
7.4 Cleaning
7.5 Storage
7.6 Moving About
7.7 Disassembling the Scooter for
Transportation
7.8 Assembling the Scooter
8. TROUBLESHOOTING
9. SPECIFICATION
10. WARRANTY
11. APPENDIX: SERVICE RECORD
Scout Electric Scooter Page 2 of 16 Owner’s Handbook (Code: MS008_IFU 08/13)
1. PREFACE AND INTRODUCTION
Please carefully read this owner’s handbook before
using the scooter to ensure that you operate the
scooter safely. Improper use of the scooter could
result in damage, injury or traffic accidents.
This handbook also advises how to get most out of
your scooter by giving comprehensive operating,
assembly and maintenance instructions for the
scooter.
A repair and maintenance record chart and
warranty information is included with this
handbook. Please keep it in a safe place or with the
scooter.
If someone else uses the scooter make sure that you
provide him or her with this handbook for their
consideration.
As designs change some of the illustrations and
pictures in the manual may not correspond to the
scooters that you purchased. We reserve the right
to make design modifications.
The Scout range of scooters have been designed
and manufactured to provide a comfortable and
secure yet affordable solution for some mobility
requirements. They are designed for a single user
to compensate for a loss of mobility as a result of a
disability. They are manoeuvrable and are suitable
for indoor and some outdoor application where the
terrain is forgiving (for example smooth paths,
shopping centres, etc). They are class 2 scooters as
defined by the Road Traffic Act 1988. They feature
a rotating seat and can be easily folded and
disassembled.
There are two styles of Scout scooter available:
3-wheel model for compact environments
4-wheel model for greater stability
2. SAFETY
2.1 Before Driving
The user needs to be familiar with the use and
operation of this scooter before driving.
Ride on the pavement and pedestrian areas only.
Never ride on motorways or dual carriageways.
Only use roads to cross to other side of the
pavement.
Be aware of traffic when crossing or using roads.
Use extreme caution when driving your scooter in
busy areas such as shopping malls.
Do not drive the scooter under the influence of
drink or drugs, or when you are tired.
Be careful when using the scooter in low light. It has
not been designed for use at night.
Before using the scooter in busy or hazardous
environments, familiarise yourself with the
operation of the scooter. Practice in an open and
safe area which is free from hazards and other
people. Turn the speed dial down for your initial
practice.
2.2 Whilst Driving
Do not use your scooter on surfaces that are
muddy, gravelly, bumpy, narrow, snowed over, icy;
or on towpaths near to canals which are not
guarded.
Do not use your scooter outside when it is raining,
snowing, misty or windy.
Do not make erratic turnings on your scooter.
Bear in mind driving motions such as accelerating,
stopping, turning, reversing, and the effect of
gradients.
1. PREFACE AND INTRODUCTION
Please carefully read this owner’s handbook before
using the scooter to ensure that you operate the
scooter safely. Improper use of the scooter could
result in damage, injury or traffic accidents.
This handbook also advises how to get most out of
your scooter by giving comprehensive operating,
assembly and maintenance instructions for the
scooter.
A repair and maintenance record chart and
warranty information is included with this
handbook. Please keep it in a safe place or with the
scooter.
If someone else uses the scooter make sure that you
provide him or her with this handbook for their
consideration.
As designs change some of the illustrations and
pictures in the manual may not correspond to the
scooters that you purchased. We reserve the right
to make design modifications.
The Scout range of scooters have been designed
and manufactured to provide a comfortable and
secure yet affordable solution for some mobility
requirements. They are designed for a single user
to compensate for a loss of mobility as a result of a
disability. They are manoeuvrable and are suitable
for indoor and some outdoor application where the
terrain is forgiving (for example smooth paths,
shopping centres, etc). They are class 2 scooters as
defined by the Road Traffic Act 1988. They feature
a rotating seat and can be easily folded and
disassembled.
There are two styles of Scout scooter available:
3-wheel model for compact environments
4-wheel model for greater stability
2. SAFETY
2.1 Before Driving
The user needs to be familiar with the use and
operation of this scooter before driving.
Ride on the pavement and pedestrian areas only.
Never ride on motorways or dual carriageways.
Only use roads to cross to other side of the
pavement.
Be aware of traffic when crossing or using roads.
Use extreme caution when driving your scooter in
busy areas such as shopping malls.
Do not drive the scooter under the influence of
drink or drugs, or when you are tired.
Be careful when using the scooter in low light. It has
not been designed for use at night.
Before using the scooter in busy or hazardous
environments, familiarise yourself with the
operation of the scooter. Practice in an open and
safe area which is free from hazards and other
people. Turn the speed dial down for your initial
practice.
2.2 Whilst Driving
Do not use your scooter on surfaces that are
muddy, gravelly, bumpy, narrow, snowed over, icy;
or on towpaths near to canals which are not
guarded.
Do not use your scooter outside when it is raining,
snowing, misty or windy.
Do not make erratic turnings on your scooter.
Bear in mind driving motions such as accelerating,
stopping, turning, reversing, and the effect of
gradients.
Scout Electric Scooter Page 3 of 16 Owner’s Handbook (Code: MS008_IFU 08/13)
Slow down when driving on gradients. Always lean
forward when climbing a steep gradient. Do not
travel on gradients exceeding those stated on the
diagram below:
Do not drive on roads with large drops or potholes.
The scooter is not suitable for carrying passengers.
Do not use the scooter to carry heavy goods.
Do not use a mobile phone or other wireless
communication devices whilst driving. Always stop
somewhere suitable and switch off the scooter
before using the phone.
Do not set in freewheel mode when driving,
especially on a gradient. Ensure that the scooter’s
automatic brake is applied before use.
Do not exceed the weight limit of the scooter.
2.3 Labelling
Please carefully read all labels applied to the
scooter before driving. For future reference, do not
remove them from the scooter. The labels are also
shown below:NEVER LIFT SCOOTER UP BY THE
REAR OR FRONT OF SHROUD
Above: Located on rear shroudWARNING!
Never operate the freewheel lever while
seated on the scooter or on an incline!
OPERATION OF THE FREEWHEEL LEVER
Always pull UP FIRMLY for freewheel mode
Always push DOWN FIRMLY for drive mode
Above: Located by freewheel lever on rearWARNING:
EMI
REFER TO
OPERATORS
MANUAL FOR
INFORMATION
Above: Located on rearWARNING:
EMI
REFER TO
OPERATORS
MANUAL FOR
INFORMATION
THIS UNIT HAS
ACHIEVED 20 V/m
EMI TESTING
REF MS008PB
S/No
Drive Medical Ltd (HX5 9JP)
Drive Medical GmbH (D-88316)
Maximum User Mass 130kg
5 06 02 6 6 8 48 7 11
MADE IN
VIETNAM
Above: Located on rearWARNING
Please hold the tiller before loosen
the tiller adjustment knob.
Before lifting or driving the scooter
make certain the tiller adjustment
knob is fully tightened.
Never attempt to adjust the tiller
whilst the scooter is in motion
Above: Located on tiller
2.4 Electromagnetic Interference
Scooters may be susceptible to electromagnetic
interference (EMI) from sources such as mobile
phones, walkie-talkies, TV and radio broadcast
stations and amateur radio sets. In some cases,
there is a risk this interference may cause
involuntary movement of the scooter. The scooter
has been tested and passed to withstand
interference to a level of 20V per metre.
Be aware that the above sources may cause
involuntary movement due to EMI. Exercise caution
whilst using the aforementioned devices and avoid
close proximity to TV and Radio broadcast stations.
The addition of components or accessories may
effect the EMI susceptibility of the scooter. Do not
fit accessories other than Drive Medical authorised
accessories.
Slow down when driving on gradients. Always lean
forward when climbing a steep gradient. Do not
travel on gradients exceeding those stated on the
diagram below:
Do not drive on roads with large drops or potholes.
The scooter is not suitable for carrying passengers.
Do not use the scooter to carry heavy goods.
Do not use a mobile phone or other wireless
communication devices whilst driving. Always stop
somewhere suitable and switch off the scooter
before using the phone.
Do not set in freewheel mode when driving,
especially on a gradient. Ensure that the scooter’s
automatic brake is applied before use.
Do not exceed the weight limit of the scooter.
2.3 Labelling
Please carefully read all labels applied to the
scooter before driving. For future reference, do not
remove them from the scooter. The labels are also
shown below:NEVER LIFT SCOOTER UP BY THE
REAR OR FRONT OF SHROUD
Above: Located on rear shroudWARNING!
Never operate the freewheel lever while
seated on the scooter or on an incline!
OPERATION OF THE FREEWHEEL LEVER
Always pull UP FIRMLY for freewheel mode
Always push DOWN FIRMLY for drive mode
Above: Located by freewheel lever on rearWARNING:
EMI
REFER TO
OPERATORS
MANUAL FOR
INFORMATION
Above: Located on rearWARNING:
EMI
REFER TO
OPERATORS
MANUAL FOR
INFORMATION
THIS UNIT HAS
ACHIEVED 20 V/m
EMI TESTING
REF MS008PB
S/No
Drive Medical Ltd (HX5 9JP)
Drive Medical GmbH (D-88316)
Maximum User Mass 130kg
5 06 02 6 6 8 48 7 11
MADE IN
VIETNAM
Above: Located on rearWARNING
Please hold the tiller before loosen
the tiller adjustment knob.
Before lifting or driving the scooter
make certain the tiller adjustment
knob is fully tightened.
Never attempt to adjust the tiller
whilst the scooter is in motion
Above: Located on tiller
2.4 Electromagnetic Interference
Scooters may be susceptible to electromagnetic
interference (EMI) from sources such as mobile
phones, walkie-talkies, TV and radio broadcast
stations and amateur radio sets. In some cases,
there is a risk this interference may cause
involuntary movement of the scooter. The scooter
has been tested and passed to withstand
interference to a level of 20V per metre.
Be aware that the above sources may cause
involuntary movement due to EMI. Exercise caution
whilst using the aforementioned devices and avoid
close proximity to TV and Radio broadcast stations.
The addition of components or accessories may
effect the EMI susceptibility of the scooter. Do not
fit accessories other than Drive Medical authorised
accessories.
Scout Electric Scooter Page 4 of 16 Owner’s Handbook (Code: MS008_IFU 08/13)
3. PARTS INTRODUCTIONScout 4-wheel pictured belowCONTROL
PANEL
CHARGER
SOCKET
TILLER ADJ.
KNOB
SEAT
SEAT
POST
BATTERY
PACK
TILLER
LOCK
Rear section shown below (applicable to both models)FREE-
WHEEL
LEVER
ANTI TIP
WHEEL
4. OPERATION
4.1 Control PanelSPEED
DIAL
WIGWAG
PADDLE
BATTERY
GAUGE
HORN
BUTTON
4.2 How To Operate Your Scooter
Key Ignition. The key ignition acts as the power
switch for the scooter. To switch the power on, turn
the key clockwise and battery gauge should
illuminate. To switch the power off, turn the key
anticlockwise, after which the battery gauge should
switch off and the key can be removed.
Do not turn the ignition off whilst driving
as this will lead to an emergency stop and
possible risk of damage or injury.
Speed Dial. Turn the speed dial to determine the
maximum speed of the scooter. Turn the dial
clockwise to increase the speed setting and turn the
dial anticlockwise to decrease the speed setting.
Do not adjust the speed dial whilst driving
as this could result in loss of control. Do
not set the highest speed whilst driving
indoors.
Tiller Lock. When the tiller is centred, pull the tiller
lock down to secure the tiller for transportation.
Push the tiller lock up to release.
Always ensure the tiller lock is disengaged
when driving the scooter. Always check
the tiller moves and turns freely before
driving.
Moving and Braking. To move forward, pull the right
hand side of the wigwag paddle with your hand
towards you whilst resting the palm of your hand on
the lower handle bar. Pull the left hand side of the
wigwag paddle towards you and the scooter will
move backwards, emitting an audible reversing
alarm. To brake, release the wigwag paddle which
will return to neutral and activate the
electromagnetic brake automatically and bring the
scooter to a prompt stop. The wigwag paddle
allows you to control the speed of the scooter up to
a maximum speed determined by the Speed Dial.
The further the wigwag paddle is deflected, the
faster the scooter will go (up to 4mph).
Warning
Do not push both left and right hand
sides of the wigwag simultaneously. You
3. PARTS INTRODUCTIONScout 4-wheel pictured belowCONTROL
PANEL
CHARGER
SOCKET
TILLER ADJ.
KNOB
SEAT
SEAT
POST
BATTERY
PACK
TILLER
LOCK
Rear section shown below (applicable to both models)FREE-
WHEEL
LEVER
ANTI TIP
WHEEL
4. OPERATION
4.1 Control PanelSPEED
DIAL
WIGWAG
PADDLE
BATTERY
GAUGE
HORN
BUTTON
4.2 How To Operate Your Scooter
Key Ignition. The key ignition acts as the power
switch for the scooter. To switch the power on, turn
the key clockwise and battery gauge should
illuminate. To switch the power off, turn the key
anticlockwise, after which the battery gauge should
switch off and the key can be removed.
Do not turn the ignition off whilst driving
as this will lead to an emergency stop and
possible risk of damage or injury.
Speed Dial. Turn the speed dial to determine the
maximum speed of the scooter. Turn the dial
clockwise to increase the speed setting and turn the
dial anticlockwise to decrease the speed setting.
Do not adjust the speed dial whilst driving
as this could result in loss of control. Do
not set the highest speed whilst driving
indoors.
Tiller Lock. When the tiller is centred, pull the tiller
lock down to secure the tiller for transportation.
Push the tiller lock up to release.
Always ensure the tiller lock is disengaged
when driving the scooter. Always check
the tiller moves and turns freely before
driving.
Moving and Braking. To move forward, pull the right
hand side of the wigwag paddle with your hand
towards you whilst resting the palm of your hand on
the lower handle bar. Pull the left hand side of the
wigwag paddle towards you and the scooter will
move backwards, emitting an audible reversing
alarm. To brake, release the wigwag paddle which
will return to neutral and activate the
electromagnetic brake automatically and bring the
scooter to a prompt stop. The wigwag paddle
allows you to control the speed of the scooter up to
a maximum speed determined by the Speed Dial.
The further the wigwag paddle is deflected, the
faster the scooter will go (up to 4mph).
Warning
Do not push both left and right hand
sides of the wigwag simultaneously. You
5
6
7
8
9
10
11
12
13
14
15
16
Advertisement
Key features
Easy to fold and disassemble
Rotating seat
Suitable for indoor and outdoor use
Class 2 scooter
Maximum user weight: 130 kg
Comes with solid tyres
Maintenance-free batteries
Electromagnetic braking system
Adjustable tiller
Warning system for reverse
Frequently asked questions
The maximum weight capacity of the Scout electric scooter is 130 kg (20 stone).
The Scout electric scooter uses maintenance-free, sealed lead acid batteries.
To charge the batteries, switch the key ignition off, plug the charger’s power cord in to the mains, connect the charger’s round plug in to the charging socket, and switch on the plug socket at the mains. The charger light will illuminate orange to indicate the batteries are charging. When charging is complete, the orange light will turn green.
To adjust the tiller, loosen the knob, reposition the tiller as required, and then retighten the knob to secure.
Related
Thomas Montgomery K203 Range Chair Manual | AI Chat
Drive Medical Scout Owner's Handbook Manual
Heartway Medical Products S21 User Manual
Compact Scooter Instructions | AI Chat & PDF
