Replacing Toner Cartridges
Fuji Xerox toner cartridges are available only through Fuji Xerox.
It is recommended that you use Fuji Xerox toner cartridges for your printer. Fuji Xerox does not provide warranty coverage for problems caused by using accessories, parts, or components not supplied by Fuji Xerox.
•
•
WARNING:
Never use a vacuum cleaner for spilled toner and residual toner in this product, toner cartridge or toner bottle.
It may catch fire by electric sparks inside a vacuum cleaner and cause explosion.
Use a broom or a wet cloth to wipe off the spills. If you spill a large volume of toner, contact your local Fuji Xerox representative.
Never throw a toner cartridge into an open flame. Remaining toner in the cartridge may catch fire and cause burn injuries or explosion.
If you have a used toner cartridge no longer needed, contact your local Fuji Xerox representative for its disposal.
•
•
•
CAUTION:
Keep drum cartridges (or drum if not a cartridge type) and toner cartridges out of the reach of children. If a child accidentally swallows toner, spit it out, rinse mouth with water, drink water and consult a physician immediately.
When replacing drum cartridges (or drum if not a cartridge type) and toner cartridges, be careful not to spill the toner. In case of any toner spills, avoid contact with clothes, skin, eyes and mouth as well as inhalation.
If toner spills onto your skin or clothing, wash it off with soap and water.
If you get toner particles in the eyes, wash it out with plenty of water for at least 15 minutes until irritation is gone.
Consult a physician if necessary.
If you inhale toner particles, move to a fresh air location and rinse your mouth with water.
If you swallow toner, spit it out, rinse your mouth with water, drink plenty of water and consult a physician immediately.
IMPORTANT:
• Do not shake the used toner cartridge to avoid spilling of the toner.
• Be sure to use the starter toner cartridge shipped with the printer until it gets empty, and then replace it with a purchased one.
Overview
The printer has toner cartridges of four colors: black (K), yellow (Y), magenta (M), and cyan (C).
When a toner cartridge reaches its usable life-span, the following messages appear on the LCD panel (
XXXX
:
Yellow
,
Magenta
,
Cyan
, or
Black
).
Message
XXXX Cartridge is Close to
Life
*
Action
The specified toner cartridge has become low. Prepare a new one.
Replace
XXXX Cartridge
The specified toner cartridge has become empty. Replace the old toner cartridge with a new one.
*
This warning appears only when Fuji Xerox toner cartridges are used, and
Non-Genuine Mode
is set to
Off
.
•
•
•
IMPORTANT:
• When placing a used toner cartridge on the floor or on a table, place a few sheets of paper under the toner cartridge to catch any toner that may spill.
Do not reuse old toner cartridges once you remove them from the printer. Doing so can impair print quality.
Do not shake or pound the used toner cartridges. The remaining toner may spill.
We recommend you to use up the toner cartridges within one year after removing them from the packaging.
Maintenance
169
Removing the Toner Cartridges
1
2
Turn off the printer.
Open the toner access cover.
3
4
Spread a few sheets of paper on the floor or table where the removed toner cartridge is to be placed.
Pinch the toner cartridge firmly.
5
Pull the toner cartridge out.
IMPORTANT:
• Always pull the toner cartridge out slowly so you do not spill any toner.
6
Place the toner cartridge slowly on the sheets of paper spread in step
3
.
170
Maintenance
Installing a Toner Cartridge
1
Unpack a new toner cartridge of the desired color and shake it five to six times to distribute the toner evenly.
2
•
•
NOTE:
Confirm that the color of the new toner cartridge matches that on the handle before replacing it.
Handle the toner cartridge carefully to avoid spilling of the toner.
Remove the tape from the toner cartridge.
3
Adjust the toner cartridge to the associated cartridge holder, and then insert it firmly by pressing near the center of the label until the toner cartridge clicks.
Maintenance
171
4
Close the toner access cover.
5
6
7
Turn on the printer.
Pack the removed toner cartridge in the box in which the installed toner cartridge was packed up.
Take care not to contact with the spilled toner and remove the sheets of paper spread under the removed toner cartridge.
172
Maintenance
