Fuel and Refueling
SAFETY PRECAUTIONS
WARNINGS
Stop refueling after the fuel nozzle stops the second time. Additional fuel will fill the expansion space in the fuel tank which could lead to fuel overflowing. Fuel spillage could be hazardous to other road users.
Do not use any kind of flames or heat near the fuel system. The fuel system is under pressure. There is a risk of injury if the fuel system is leaking.
FUEL QUALITY - GASOLINE
CAUTION
Do not use leaded gasoline or gasoline with additives containing other metallic compounds (e.g.
manganese-based). They could damage the emission system.
Note: We recommend that you use only high quality fuel without additives or other engine treatments.
Use minimum 95 octane unleaded gasoline that meets the specification defined by EN 228, or the equivalent national specification.
Your vehicle is suitable for use with ethanol blends up to 10% (E5 and E10).
FUEL QUALITY - E85
WARNINGS
Do not modify the fuel system configuration or the components in the system.
Do not replace the fuel system or the components with parts not specially designed to be used with E85.
CAUTIONS
Do not use leaded gasoline or gasoline with additives containing other metallic compounds (e.g.
manganese-based). They could damage the emission system.
Do not use methanol instead of E85.
Note: We recommend that you use only high quality fuel without additives or other engine treatments.
Note: When using E85, you may experience a higher fuel consumption.
Note: Your vehicle will operate well on commercial quality 95 octane unleaded gasoline, but only high quality E85 offers the same protection and performance.
Use minimum 95 octane unleaded gasoline that meets the specification defined by EN 228 , or equivalent. You can also use a mixture of unleaded gasoline and E85.
Long-term storage
Due to small amounts of corrosive impurities that may be found in the E85, it is recommended that you fill the tank with only 95 octane unleaded gasoline prior to long-term storage of your vehicle.
FUEL QUALITY - DIESEL
WARNING
Do not mix diesel with oil, gasoline or other liquids. This could cause a chemical reaction.
CAUTIONS
Do not add kerosene, paraffin or gasoline to diesel. This could cause damage to the fuel system.
155
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
CAUTIONS
Use diesel that meets the specification defined by EN 590 , or the relevant national specification.
Note: We recommend that you use only high quality fuel.
Note: The use of additives or other engine treatments not approved by Ford is not recommended.
Note: We do not recommend the prolonged use of additives intended to prevent fuel waxing.
Long-term storage
Most diesel fuels contain bio-diesel, it is recommended to fill the tank with purely mineral diesel (where available) or add an anti-oxidant prior to long-term storage of your vehicle exceeding two months. Your dealer can help you with a suitable anti-oxidant.
CATALYTIC CONVERTER
WARNING
Do not park or idle your vehicle over dry leaves, dry grass or other combustible materials. The exhaust will radiate a considerable amount of heat during use, and after you have switched the engine off. This is a potential fire hazard.
Driving with a catalytic converter
CAUTIONS
Avoid running out of fuel.
Do not crank the engine for long periods.
Do not run the engine when a spark plug lead is disconnected.
CAUTIONS
251).
Do not push-start or tow-start your
vehicle. Use booster cables. See
Jump Starting the Vehicle (page
Do not switch the ignition off when driving.
REFUELING
CAUTION
Do not attempt to start the engine if you have filled the fuel tank with the incorrect fuel. This could damage the engine. Have the system checked by a properly trained technician immediately.
REFUELING - E85
CAUTION
Do not attempt to start the engine if you have filled the fuel tank with the incorrect fuel. This could damage the engine. Have the system checked by a properly trained technician immediately.
After refueling, allow 5 minutes of normal engine operation above 48 km/h (30 mph) to reduce the risk of an increased engine restart time.
FUEL CONSUMPTION
The CO2 and fuel consumption figures are derived from laboratory tests according to
EEC Directive 80/1268/EEC and subsequent amendments and are carried out by all vehicle manufacturers.
156
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
They are intended as a comparison between makes and models of vehicles.
They are not intended to represent the real world fuel consumption you may get from your vehicle. Real world fuel consumption is governed by many factors including; driving style, high speed driving, stop/start driving, air conditioning usage, the accessories fitted and towing etc.
Your Ford dealer can give you advice on improving your fuel consumption.
FUEL FILLER DOOR
WARNINGS
Take care when refueling to avoid spilling any residual fuel from the fuel nozzle.
Do not use any kind of flames or heat near the fuel system. The fuel system is under pressure. There is a risk of injury if the fuel system is leaking.
CAUTION
If you use a high pressure spray to wash your vehicle, only spray the fuel filler door briefly from a distance not less than 200 millimeters (8 inches).
Note: Central locking also locks and
unlocks the fuel filler door. See Locking and Unlocking (page 37).
1.
Press the door to open it. Open the door fully until it engages.
Note: When you insert the fuel nozzle, a spring loaded inhibitor will open if the correct size nozzle is detected. This helps to avoid filling up with the wrong fuel.
2. Insert the fuel nozzle up to and including the first notch on the nozzle
A . Keep it resting on the cover of the fuel pipe opening.
157
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
WARNING
Stop refueling after the fuel nozzle stops the second time. Additional fuel will fill the expansion space in the fuel tank which could lead to fuel overflowing. Fuel spillage could be hazardous to other road users.
4. Operate the nozzle within the area shown.
WARNINGS
We recommend that you remove the fuel nozzle slowly to allow any residual fuel to drain into the fuel tank. Alternatively you can wait 10 seconds before removing the fuel nozzle.
Do not remove the nozzle from its fully inserted position during the entire refueling process.
A
B
Incorrect position
Correct position
3. Do not lift the nozzle during refilling. This can affect the flow of fuel and shut off of the fuel nozzle before the fuel tank is full.
5. Slightly raise the fuel nozzle to remove it.
Refueling with a fuel can
Use the funnel which is located in the under floor storage compartment behind
the front seats. See Storage compartments (page 140).
TECHNICAL SPECIFICATIONS
158
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
S-MAX
Fuel Consumption Figures
Variant
Urban l/100 km
(mpg)
Extra-Urban l/100 km
(mpg)
Combined l/100 km
(mpg)
9.4 (30.1) 5.7 (49.6) 7 (40.4)
1.6L EcoBoost
(118kW/160PS), 6-speed manual transmission
2.0L Duratec-HE Stage IV
(107kW/145PS), 5-speed manual transmission
2.0L Duratec-HE Stage V
(107kW/145PS), 5-speed manual transmission
2.0L EcoBoost
(149kW/203PS), 6-speed manual transmission
2.0L EcoBoost
(177kW/240PS), 6-speed manual transmission
2.0L EcoBoost
(149kW/203PS), 6-speed automatic transmission
2.0L EcoBoost
(177kW/240PS), 6-speed automatic transmission
2.3L Duratec-HE
(118kW/160PS), 6-speed automatic transmission
1.6L Duratorq-TDCi
(85kW/115PS), 6-speed manual transmission without start-stop
1.6L Duratorq-TDCi
(85kW/115PS), 6-speed manual transmission with start-stop
11 (25.7)
11.3 (25)
11.2 (25.2)
11.2 (25.2)
11 (25.7)
11.5 (24.6)
13.7 (20.6)
6.2 (45.6)
5.9 (47.9)
6.4 (44.1)
6.4 (44.1)
6.4 (44.1)
6.4 (44.1)
6.4 (44.1)
6.5 (43.5)
7.4 (38.2)
5 (56.5)
4.9 (57.6)
8.1 (34.9)
8.2 (34.4)
8.1 (34.9)
8.1 (34.9)
8.1 (34.9)
8.3 (34)
9.7 (29.1)
5.4 (52.3)
5.2 (54.3)
CO2 Emissions g/km
164
194
189
188
188
189
194
232
144
139
159
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
Variant
Urban l/100 km
(mpg)
2.0L Duratorq-TDCi -DW
Stage IV (103kW/140PS),
Durashift 6-speed manual transmission
2.0L Duratorq-TDCi -DW
Stage V, Durashift 6-speed manual transmission
2.0L Duratorq-TDCi -DW
Stage IV (103kW/140PS),
6-speed automatic transmission
2.0L Duratorq-TDCi -DW
Stage V (120kW/163PS), 6speed automatic transmission
2.2L Duratorq-TDCi -DW
Stage IV (129kW/175PS),
Durashift 6-speed manual transmission
2.2L Duratorq-TDCi -DW
(147kW/200PS)
7.7 (36.7)
6.7 (42.2)
9.7 (29.1)
6.8 (41.5)
8.9 (31.7)
8.2 (34.4)
Extra-Urban l/100 km
(mpg)
Combined l/100 km
(mpg)
5 (56.5)
4.7 (60.1)
5.7 (49.6)
5 (56.5)
5.2 (54.3)
5.7 (49.6)
6 (47.1)
5.4 (52.3)
7.2 (39.2)
5.7 (49.6)
6.6 (42.8)
6.6 (42.8)
CO2 Emissions g/km
159
143
189
149
174
174
160
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
Galaxy
Fuel Consumption Figures
Urban
Variant l/100 km
(mpg)
1.6L EcoBoost
(118kW/160PS), 6-speed manual transmission
2.0L Duratec-HE Stage IV
(107kW/145PS), 5-speed manual transmission
2.0L Duratec-HE Stage V
(107kW/145PS), 5-speed manual transmission
2.0L EcoBoost
(149kW/203PS), 6-speed automatic transmission
2.3L Duratec-HE -MI4
(118kW/160PS), 6-speed automatic transmission
1.6L Duratorq-TDCi Stage V
(85kW/115PS), 6-speed manual transmission without start-stop
1.6L Duratorq-TDCi Stage V
(85kW/115PS), 6-speed manual transmission with start-stop
2.0L Duratorq-TDCi Stage
IV (103kW/140PS), Durashift 6-speed manual transmission
2.0L Duratorq-TDCi Stage
V, Durashift 6-speed manual transmission
9.7 (29)
11.2 (25.2)
11.3 (25)
11 (25.7)
13.8 (20.5)
6.2 (45.6)
5.9 (47.9)
7.7 (36.7)
6.7 (42.2)
Extra-Urban l/100 km
(mpg)
5.8 (48.7)
6.5 (43.5)
6.4 (44.1)
6.4 (44.1)
7.5 (37.7)
5 (56.5)
4.9 (57.6)
5 (56.5)
4.7 (60.1)
Combined l/100 km
(mpg)
7.2 (39.2)
8.2 (34.4)
8.2 (34.4)
8.1 (34.9)
9.8 (28.8)
5.4 (52.3)
5.2 (54.3)
6 (47.1)
5.4 (52.3)
CO2 Emissions g/km
169
197
189
189
235
144
139
159
143
161
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuel and Refueling
Urban
Variant l/100 km
(mpg)
2.0L Duratorq-TDCi Stage
IV (100kW/140PS), 6-speed automatic transmission
2.0L Duratorq-TDCi Stage
V (120kW/163PS), 6-speed automatic transmission
2.2L Duratorq-TDCi -DW
Stage IV (129kW/175PS),
Durashift 6-speed manual transmission
2.2L Duratorq-TDCi -DW
(147kW/200PS)
9.7 (29.1)
6.8 (41.5)
9.1 (31)
8.4 (33.6)
Extra-Urban l/100 km
(mpg)
Combined l/100 km
(mpg)
5.7 (49.6)
5 (56.5)
5.3 (53.3)
5.8 (48.7)
7.2 (39.2)
5.7 (49.6)
6.7 (42.2)
6.8 (41.5)
CO2 Emissions g/km
189
149
179
179
162
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
