FUSE BOX LOCATIONS
Engine compartment fuse box
Fuses
Central fuse box
All vehicles
2. Remove the cover.
3. Turn the knob through 90 degrees and release the fuse box from the retaining bracket.
4. Lower the fuse box cover and pull it towards you.
5. Install in the reverse order.
Rear fuse box
1. Pinch the retaining clips to release the cover.
Release the catches and remove the cover.
221
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuses
FUSE SPECIFICATION CHART
Engine compartment fuse box
Fuse
F1
F1
F2
Ampere rating
10
15
5
Circuits protected
Transmission control module (AWF21)
Transmission control module (MPS6)
Glow plug monitoring (diesel engines)
222
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuse
F2
F3
F3
F4
F5
F6
F7
F8
F5
F6
F6
F8
F8
F9
F9
F9
F9
Fuses
Ampere rating
5
Circuits protected
Vaporizer glow plug monitoring (2.0L Duratorq-TDCi
Stage V and 2.2L Duratorq-TDCi Stage V)
70
80
60
60
70
7.5
10
20
1
1
Engine cooling fan - twin fan (2.3L Duratec-HE and
2.2L Duratorq-TDCi automatic)
Electric hydraulic power steering (EHPAS) (1.6L
EcoBoost SCTi, 2.0L EcoBoost SCTi, 1.6L Duratorq-
TDCi Stage V and 2.0L Duratorq-TDCi Stage V)
Glow plugs
Engine cooling fan (1.6L Duratorq-TDCi, 2.0L Duratorq-
TDCi, 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi manual, 2.0L Duratec-HE, 2.3L Duratec-HE and 2.0L
EcoBoost SCTi)
Engine cooling fan - twin fan (1.6L EcoBoost SCTi)
HEGO sensor (1.6L Duratorq-TDCi)
HEGO sensor, CMS Sensor, Oxygen Sensor (engine management)
Vaporizer glow plug (2.0L Duratorq-TDCi Stage V and
2.2L Duratorq-TDCi Stage V)
5
10
20
15
10
5
7.5
7.5
Relay coils
Powertrain control module, fuel metering unit, MAF sensor, fuel rail pressure control valve (engine management)
Powertrain control module (2.0L EcoBoost SCTi and
2.0L Duratorq-TDCi Stage V)
Powertrain control module (1.6L EcoBoost SCTi, 1.6L
Duratorq-TDCi and 2.2L Duratorq-TDCi Stage V)
MAF Sensor, Fuel Injectors (engine management)
Fuel pump Vaporizer (2.0L Duratorq-TDCi Stage V)
MAF Sensor, EGR bypass Valve , Fuel pump Vaporizer
(2.2L Duratorq-TDCi Stage V) (engine management)
Degas valve, TMAF sensor, active grille shutter, bypass valve, relay coil, auxiliary run on water pump (1.6L
EcoBoost SCTi)
223
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
F11
F11
F11
F11
F12
F12
F12
F12
F13
F14
F14
F15
F16
F17
F18
Fuse
F10
F10
F11
Fuses
Ampere rating
10
7.5
10
Circuits protected
Engine control module (2.0L Duratorq-TDCi)
Auxiliary run on, water pump (1.6L EcoBoost SCTi)
PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic
Purge Valve, Swirl Control Valve, Variable Intake Valve,
EGR Valve, IVVT Oil Control Valve (engine management). T.MAF sensor, variable exhaust timing valve, active grille shutter, cannister purge valve. turbo control valve, wastegate valve (engine management).
10
5
7.5
10
10
10
5
15
Turbo control valve, MAF sensor, active grille shutter,
EGR valve, VCV valve (1.6L Duratorq-TDCi)
MAF sensor, water in fuel sensor, active grille shutter, inlet metering valve (2.0L Duratorq-TDCi Stage V)
Fuel rail pressure, fuel metering unit, active grille shutter (2.2L Duratorq-TDCi Stage V)
Turbo control valve, variable intake timing valve, variable exhaust timing valve, cannister purge valve, electrical bypass valve (1.6L EcoBoost SCTi)
Coil on Plug; Canister Purge Valve, Power Steering
Pressure Switch (engine management)
EGR throttle, variable turbo control (2.0L Duratorq-
TDCi)
Relay coils (2.0L Duratorq-TDCi Stage V, 2.2L
Duratorq-TDCi Stage V and 1.6L Duratorq-TDCi)
Ignition coils (1.6L EcoBoost SCTi and 2.0L EcoBoost
SCTi)
15
15
10
40
80
60
60
Air conditioning
Diesel filter heater (2.0L Duratorq-TDCi, 2.0L Duratorq-
TDCi Stage V and 1.6L Duratorq-TDCi)
HEGO sensors (2.2L Duratorq-TDCi Stage V)
Starter relay
Diesel auxiliary heater (PTC)
Central fuse box supply A
Central fuse box supply B
224
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
F26
F27
F28
F29
F30
F31
F32
Fuse
F19
F20
F21
F22
F23
F24
F25
F33
F39
F40
F41
F42
F43
F34
F35
F36
F37
F38
Fuses
15
5
20
5
15
40
40
15
7.5
10
Ampere rating
60
60
30
Circuits protected
Rear fuse box supply C
Rear fuse box supply D
VQM/non VQM: Cluster/Audio/AC/FLR
30
25
30
30
Windscreen wiper module
Heated rear window
Headlamp washer
ABS valves
40
25
40
–
5
15
5
5
ABS pump
Fuel fired heater
Heater blower
Not used
ABS 30 feed
Horn
Fuel fired heater - remote control
Light switch module, engine compartment fuse box coils
Heated windscreen (left-hand side)
Heated windscreen (right-hand side)
Rear wiper 15 feed
Heated front washer jets/FLR + FSM KL15
PCM/TCM/EHPAS 15 feed
Adaptive front lighting system (AFS)
Headlamp leveling/AFS module
Instrument panel
Cluster IP
Audio/BVC module/DAB module
225
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuses
Fuse
F44
F45
Ampere rating
5
5
Circuits protected
Automatic AC/Manual AC
FLR (Start Stop)
1 Fit a replacement with the same rating as the one you have removed.
Central fuse box
A
B
Left-hand drive
Right-hand drive
226
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuses
F8
F9
F10
F11
F12
F13
F13
F14
F15
F4
F5
F6
F7
Fuse
F1
F2
F3
F16
F17
F18
F19
F20
F21
10
10
20
7.5
10
15
15
5
5
Ampere rating
7.5
5
10
Circuits protected
Steering wheel module
Cluster
Interior lamps
5
7.5
5
20
Engine immobiliser
Adaptive cruise control (ACC)
Rain sensor
Cigar lighter
Fuel filler flap unlock supply
Windscreen washers - rear
Windscreen washers - front
Luggage compartment release supply
Fuel filler flap lock supply
Fuel pump
Fuel pump (2.2L Duratorq-TDCi Stage V)
5
5
10
7.5
7.5
15
Remote frequency receiver, Interior motion sensor
Ignition switch
Battery backup sounder (alarm system), OBD II
(board computer diagnostics)
Steering wheel vibration actuator
SRS (airbag) supply
ABS, yaw rate sensor (ESC), electric parking brake
(EPB), accelerator pedal supply
Electronic feed, electronic fuse, Auto-dimming mirror, lane departure warning
Radio supply
227
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuses
Fuse
F22
F23
F24
Rear fuse box
Ampere rating
5
20
5
Circuits protected
Brake lamp switch
Sunroof
Climate Control Module and Steering Column Unit supply
228
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuses
Fuse
FA1
FA2
FB4
FB5
FB6
FB7
FB8
FB9
FB10
FB11
FB12
FC1
FA9
FA10
FA11
FA12
FB1
FB2
FB3
FA3
FA4
FA5
FA6
FA7
FA8
Ampere rating
25
Circuits protected
Door module (left-hand front) (window up/down, central locking, electric folding mirror, heated mirror)
25
25
25
Door module (right-hand front) (window up/down, central locking, electric folding mirror, heated mirror)
Door module (left-hand rear) (window up/down)
10
15
5
20
5
-
20
Door module (right-hand rear) (window up/down)
Rear locking (without rear door modules)
Auxiliary power socket
Relay coils
Keyless vehicle module
Relay coils VQM (Start Stop)
Not used
Accessories, trailer module
30
15
15
15
15
–
10
Electric driver's seat
Sunblind system
Suspension module
Heated driver's seat
Heated front passenger seat
Not used
Rear climate control
–
–
7.5
–
5
30
10
Not used
Parking aid, BLIS
Electric front passenger seat
Anti-theft alarm horn
Not used
Not used
Electric rear quarter windows
229
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
Fuses
Fuse
FC2
FC3
FC4
FC5
FC6
FC7
FC8
FC9
FC10
FC11
FC12
Ampere rating
30
30
10
Circuits protected
Electric parking brake (EPB)
Electric parking brake (EPB)
Rear air conditioning
20
20
5
7.5
Keyless vehicle
Rear air conditioning blower
Seat memory function module
Rear seat entertainment/CD Changer
20
10
–
–
Audio amplifier
Sony audiophile
Not used
Not used
Note: A fuse puller is located in the engine compartment fuse box.
CHANGING A FUSE
WARNINGS
Do not modify the electrical system of your vehicle in any way. Have repairs to the electrical system and the replacement of relays and high current fuses carried out by a properly trained technician.
Switch the ignition and all electrical equipment off before touching or attempting to change a fuse.
CAUTION
Fit a replacement fuse with the same rating as the one you have removed.
Note: You can identify a blown fuse by a break in the filament.
Note: All fuses, except high current fuses, are a push fit.
230
Galaxy/S-MAX (CA1) Vehicles Built From: 25-11-2013, Vehicles Built Up To: 18-12-2014, CG3533en enGBR, Edition date: 11/2013, Second Printing
